Home

Turck DeviceNet - Steven Engineering

1. a 24v Isolation DeviceNet V j Isolation Group B Isolation AY 39090017 Group A Isolation Group C TO USE EXTERNAL POWER SUPPLY Input Signal Current each input OFF lt 2 mA ON 3 0 3 4 mA nominal 24 VDC Input Delay 2 5 ms Output Current 0 5 A max per output TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com WARNING NOTE V and V PROVIDE POWER FROM DeviceNet F72 E DeviceNet TURCK Industrial I O DeviceNet Products DeviceNet Addressing DeviceNet stations must have a network address for communication The address for FDN20 stations may be set via the visible rotary switches on the front of the station ADDRESS SWITCHES Address 6x10 3x1 63 The pair of switches represents the address as a decimal number the left switch being the 10 s multiplier and the right switch the 1 s multiplier To program the stations rotate the switches with a small slotted screwdriver until the arrows are pointing at the appropriate numbers for the chosen address Diagnostics FDN20 stations provide a single Network Status LED for diagnosing communication problems Green Connection established Flashing green Waiting for connection Flashing
2. 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs Auxiliary power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F FDN PCB 22 1003 BKT Protection Open Frame CE Diagnostics Logical e One bit in I O table indicates input fault for entire station one bit per output for fault indication 1 820 46 2 F113 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Input Output Connectors DN O3 fel DeviceNet DeviceNet I O Note L refers to CAN L and H refers to CAN H I O Data Map 1 Le ws post a pri re EN 1 1 1 Enea TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F114 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Operator Station ODNA 4S 4XSG E 3 500 88 9 4 Ideal for Operator Interfaces e Bus Powered I O IP 67 Protection Automatic Baud Rate Sens
3. Connectors Nickel plated brass ON LETE ek Housing Nylon SDNB 40A 0005 SDNB 40A 0007 Diagnostics Physical e One LED indicates an I O fault for the entire station C LEDs to indicate status of DeviceNet communication 9 138 93 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout eurofast Male 5 4 Diagnostic LEDs 1 Shield 2 V4 IT 1 3 4 CAN H 5 CAN L 6 889 175 0 REF 1 0 connectors Aux Power Power LEDs UB Bus InputPower 1 Uc UL OutputPower 2 U Power 3 Gnd connectors 4 Gnd Ou 1 181 30 0 L F97 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr fel DeviceNet Loop Powered Isolated DeviceNet Powered Transducer Mating cordset Isolated Loop RK 4 5T M RS 4 5T 5653 Loop Powered RK 4 5T M RS 4 5T LPS S653 Note The LPS in the part number indicates that the cord jumpers pin 3 to pin 4 on the male side to the signal to the station common Pin 3 is not connected at the female end Applications TURCK Sensors LU RK 4 4T RS 4 4T 51118 Ll RK 4 4T RS 4 4T 51120 I O Data Map 1 Channel 0 MSB sn EJ Channel 2 MS
4. Industrial Automation indust A DeviceNet M12x1 eurofast Male Receptacles e Provides Quick Connection to Field Devices e Available for 1 2 14NPT 1 2 14NPSM 3 4 14NPT and M20 Threads 1 2 14NPT full length FS 57 M 14 5 iaia 3 4 14NPT full h FS 57 M 14 75 b lia E DeviceNet Media Nickel Plated CuZn or Stainless Steel FS 57 M M20 250V 4A M20x1 5 threads 40 to 105 C 36 FS 57 M PG 9 threads 37 A 1 2 14NPT modified IUSSIT length threads See page G71 for dimensional drawings Length in meters Standard cable length is 0 3 meters Consult factory for other lengths Receptacles require a 13 16 21 0 mm clearance hole for panel mounting Standard housing material is nickel plated brass RKF RKFV indicates 316 stainless steel housing TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G64 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet M12x1 eurofast Female Receptacles Mounted for Quick Connection to Enclosures Available for 1 2 14NPT 1 2 14NPSM 3 4 14NPT and M20 Threads 1 2 14NPT full FK 57 M 14 5 length threads 3 4 14NPT full FK 57 M 14 75 length threads Female Nickel Plated CuZn gr or Stainless Steel
5. i E 1 000 25 4 Page G64 FS M20 0 984 25 0 945 24 0 FS NPT Page G64 G71 35 8 fy i I D 1 250 31 7 FS 14 75 Page G64 9 709 18 0 SL 669 17 0 FS Page G64 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A eurofast Female Receptacles 38 40 EET 1 299 SE 3 4 14 NPT Lo B M12x1 e 25 0 i Sl 409 35 8 LIRE m D 1 250 31 7 FK 14 5 Page G65 FK 14 75 Page G65 39 41 E DeviceNet Media M20x1 7 985 25 ie Bond y 788 20 0 M12x1 01 134 28 8 9 709 18 0 669 17 0 0 M 1 000 25 4 FK M20 Page G65 FK Page G65 42 0 984 25 0 945 24 0 FK NPT Page G65 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G72 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products minifast PCB Mount Male and Female Receptacles 43 1 043 26 5 374 TM 0 945 24 0 0 039 pen
6. 0a os 2 fo 9 I O Data Map 3 pepe peje peje I O Data Map 5 o 17 16 15 1 4 1 3 1 2 1 1 1 0 E sE ecd sgg ejos o 17 r6 15 te 1 3 1 2 1 1 1 0 1 ses os rur 1 9 1 8 out o for3fo2 01 oo ou o 07 os os og os oz ox 0 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F34 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Deluxe Input Output Rugged Fully Potted Stations Auxiliary Powered Outputs Station IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 100 mA plus sum of input currents from DeviceNet Sensor Current 80 mA per input from DeviceNet Output Current 0 5 A per output from Auxiliary power Power Distribution Inputs DeviceNet power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Logical e Open short circ
7. DeviceNet Spanner The FDN DN1 Spanner module provides a means to route data between two PLC s using DeviceNet The spanner eliminates the need for a high level control network pyramid by connecting the DeviceNet networks directly This simple approach is extremely powerful and economical It is simple because the spanner appears to each PLC as a standard rack of I O any DeviceNet scanner can send I O data to the spanner without additional software or complex configuration procedures It is powerful because it can transfer up to 128 bytes of data in one message It is economical because it replaces the high level control network eliminating two control cards wiring conduit and programming Theory of operation The spanner transfers data between PLC A and PLC B by appearing as I O to each PLC The spanner immediately copies the output data from PLC A to the input data for PLC B Similarly PLC B s output data is copied to PLC A s input data The size of data transferred is set by the transfer size switch If the transfer size switch is set at 4 16 32 or 128 bytes then the size of the data transferred is the same in both directions If the transfer size switch is set to software then the transfer size is set via software and it can be any size 0 1 2 3 128 bytes When in software mode the data size mapped to the PLC must be equal in opposite directions on either side of the spanner For example if side A produces 2 input bytes and
8. E DeviceNet TURCK USER Engineering TURCK s I O Assistant software package is used to configure the BL67 system TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F118 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet BL20 Gateway Modular I O IP 20 Protection 2 Fieldbus Independent Configuration Various I O Styles Electrical Operating Current 250 mA from BR power supply e Supply Current 10 A to I O from U 1 5 A to backplane from Uyys Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IP 20 Vibration 1g 5 100 Hz Material Housing PC VO Lexan BL20 GWBR DNET Diagnostics Logical Diagnostic information available through the DeviceNet I O map CE G Diagnostics Physical e LEDs to indicate status of DeviceNet and Module Bus communication Diagnostic Service Port LEDs DeviceNet Connector Switches TST CS ESS Oo 0000 V lai V connector CAN_H CAN_L 4 496 114 2 Status LEDs Power Connector DeviceNet connector GNDsys GNDL 1 988 50 5 n F119 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support
9. Industrial I O DeviceNet Products DeviceNet DeviceNet Spanner Rugged Fully Potted Stations Communicate Between PLCs IP 67 Protection Connect Two DeviceNet Networks Electrical Operating Current 125 mA from segment A 30 mA from segment B Power Distribution Station DeviceNet power supply for each segment must be powered by separate supplies Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 and IEC IP 67 e Vibration 50 g 9 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request FDN DN1 Diagnostics Physical C G One LED for each segment to indicate communication status Network connectors Segment B 8 661 220 0 REF 8 267 210 0 Address ond Doto Rote Switches DeviceNet minifast Pinouts Network connectors Segment A 1 Shield C 2 V 9 213 95 4 3 V 1 654 42 0 MOUNTING HOLE 4 2 362 60 0 i 4 CAN H REF 5 CAN_L Note Each segment has one male and one female connector F69 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A
10. M12x1 eurofast Trunk and Drop Harness WSC 2VBWK WKC 5724 DCL 250 V 4A Available in custom configurations including length number of drops 40 to 75 C and end connector styles Consult factory for other designs nn r VBWI nn r Wi nn r 1 233 31 3 F REF 2x 2 167 55 0 REF 2x 1 555 39 5 REF STANDARD KEYWAY KEYWAY ROTATED 90 FROM STANDARD ON ALL FEMALE CONNECTORS 224 5 7 TYP 1 5 METERS 0 2 METERS 0 2 METERS Pinouts G79 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet eurofast Daisy Chain Configurations Multi drop Harnesses Designed for OEM Applications Provides Cost Effective Solution vs Single i Tees and Drops PUR Polyurethane M12x1 eurofast Trunk and Drop Harness RSC 8VBRK RKC 5724 DCL 250 V 4A Available in custom configurations including length number of 40 to 75 C drops and end connector styles E DeviceNet Media Consult factory for other designs O VBRK_connectors 1 770 45 0 REF i 8x Y i 7 874 200 0 224 5 7 CABLE LENGTH BETWEEN VBRK CONNECTORS 8 858 225 0 7 874 200 0 2 173
11. af II Fosse f er nl awsome x or sen Output Connectors E DeviceNet 2GN Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T I O Data Map 1 I O Data Map 2 mm Be ar Hat mL sita BL ML mp ea fan fas es Tos Jar es oo Out 0 05 7 05 6 05 5 05 4 05 3 05 2 05 1 05 0 o 0 7 0 6 0 5 0 4 0 3 0 2 0 1 0 0 Out o 07 0 6 0 5 0 4 0 3 o2 o 1 0 0 1 0 15 es 3 0 12 0 11 0 10 0 9 6 6 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F30 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Station Rugged Fully Potted Stations Auxiliary Powered Inputs IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 20 mA from DeviceNet Sensor Current 700 mA total of all inputs from V power Power Distribution e Inputs Auxiliary Vin power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless steel ava
12. jejes Series E connect with Monitoring and Annunciation Push Button Push Button The second system adds DeviceNet in order to Optional Optional i Pilot Light Pilot Light monitor where the e stop occurred and provide an MP um Du output for local annunciation The safety circuit is E Stop E Stop still a true hard wired system it is passing through Qe T Qe TO M 5 Monitored 2 Monitored i and uses an E connect station as a connectorized 010 ojo junction No 040 to Safety Citcuit Safety Gilcuit FOO E LU WSC E80 M einpoiN Ajejes RSC RKC EE oc D M RSM RKM 579 M FNDQ ES22 T Door Switch Dedicated E connect This method offers easy connectorization for safety devices ZS Each set of safety contacts in the e stop device connects sd to a single set of inputs on the safety relay Two door safety switches id are connected by 4 wire cordsets to the VB2 Y junction and an 8 TM O wire cordset connects to two safety modules or a tandem module All pico circuits remain isolated l VB2 FSM E8 RKC RKC E40 M M RSC RKC E80 M aynpo Ajejes anpo Ajeyes F52 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6
13. o og D D D D D D I O Data Map 1 I O Data Map 2 Byte Bit 7 Bit 6 Bi o 17 16 1 1 115 1 14 I 2 1 23 1 22 1 3_ 1 31 1 30 1 4 168 065 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F82 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Enclosure Mounted In Cabinet I O Ideal for Retrofits Input Output Stations e IP 20 Protection Automatic Baud Rate Sensing Electrical e Bus Power 11 26 VDC Internal Current Consumption lt 75 mA plus sum of sensor and output currents from bus power Input Circuits 4 Negetive switched dry contacts Input Voltage V 0 26 VDC e Input Signal Current Input OFF gt 3 V 0 5 mA ON 0 1 V 2 3 mA Input Delay 1 ms Output Circuits 12 Solid state relays Output Voltage 0 26 VDC Output Load Current 120 mA max Output Circuits Analog 4 0 10 V FDN20 4DR e Output Voltage 0 10 V e Representation 16 bit signed integer C lt gt DIV 2 e Analog Supply Voltage 10 24 V Network Status LED Status Green Established connection Flashing Green Ready for connection Red Connection not possible Flashing Amber
14. to 75 C 689 17 5 7 8 16UN 7 8 16UN eurofast Drop Cordset PO RSM RKC 57x M minifast to eurofast cordset RKM 57 Bus power and data drop a Le 9 591 15 0 M12x1 Pinouts minifast eurofast Female TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G58 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet eurofast Bus Tees Creates a Drop or Branch from the Main Bus Line Cable Drop Can Be Up to a Maximum of 6 Meters eurofast Drop Connector eurofast Tee RSC 2RKC 57 0 589 LL 2 165 55 0 gt 15 0 PUR eurofast trunk and drop Polyurethane 250V 4A 40 to 75 C eurofast trunk and drop RSC 2RKC 57 KS zd iz 9 590 15 0 Keyway aligns tee in line M12x1 on M8x1 piconet boxes M12x1 eurofast Tee Pinouts eurofast G59 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation DeviceNet Gender Changers and Elbow Con
15. 19 0 Pages G7 G10 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G12 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Flat Cable Specifications Cable that Meets the Requirements of ODVA Thick or Type II Cable Uses Insulation Displacement Connectors as Device Taps Jacket Red White Blue Black Approvals AWG DCR 1000 feet AWG DER 1000 feet Material Color Type et Color Code Insulation Color Code Insulation Nominal O D Drain Wire eig NEC CL2 2 6 AWG 4 1 2 16 AWG 4 1 PVC Light Grey m RB50787 M CEC AWM 1 11 A B FT4 BK RD PE BU WH PE Flat Profile 116 lbs Indicates length in meters Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths Flat cable profile is 19 3 mm 0 760 in x 5 3 mm 0 210 in Flat Cable Profile 100 2 5 210 5 3 760 19 3 FLAT CABLE G13 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial
16. 40 to 105 C 40 to 221 F RSC Pages F54 F55 RKC 6 po 1 555 39 5 0 591 15 0 M12x1 WSC Pages F54 F55 WKC 11 118 3 0 xd 21 5 Ld m FSFD Pages F54 F55 FKFD 118 3 0 EET PE 18 0 1 909 48 5 9 532 13 5 mr M12x1 BE Pages F54 F55 8 Zz 1 811 46 0 ET Pages F54 F55 12 M12x1 0 787 20 0 748 19 0 Pages F54 F55 F57 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A E connect Tee Provides Dual Interuptions to Auxiliary Power 7 8 16 UN minifast Connectors on Bus amp Drop Lines E amp M Dual Stop Drop Tee N DeviceNet TPU Polyurethane Provides dual See Figure 1 RSM RKM RKM 40 DESD 250V 4A interruption to auxiliary 30 to 75 C power Terminate with minifast internal jumper Standard housing material is nickel plated brass RSM RKM RSV RKV indicates stainless steel housing 1 Wiring Diagram DI 2 2 2 874 73 0 REF 1 102 28 0 3 3 sl m 4 4 91 024 26 0 01 024 26 0
17. 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Specifications PUR Polyurethane or POM Nylon picofast POM Nylon eurofast Automation Housing POM Nylon Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 30V Rated Current 1 5 A Ambient Temperature JBBS 57 FS P824Z 4 961 126 0 4 685 119 0 138 3 5 TYP 669 17 0 787 po 138 3 5 TYP 1 181 906 30 0 23 0 906 23 0 394 fr M12x1 984 25 0 PN 40 to 75 C 22 to 167 F 9 138 63 5 THRU MOUNTING HOLE M3 SOCKET HEAD 12 mm MIN LENGTH 2x 10 0 177 4 5 F 177 3 JBBS 57 FS P824M 4 961 126 0 4 685 119 0 138 3 5 TYP 669 17 0 138 3 5 TYP 1 181 906 30 0 23 0 906 23 0 pe M12x1 984 25 0 I Bare Shield Drain Wire Red Voltage Black Voltage White CAN H Bl ue CAN L N C picofast only TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Industr A E DeviceNet Media 9 138 93 5 THRU MOUNTING HOLE M3 SOCKET HEAD 12 mm MIN
18. 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Industr A Specifications Anodized Aluminum Nickel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K 250 V 4A 40 to 75 C 22 to 167 F Dimensions 10 Port 2 520 64 0 1 417 36 0 j 1 713 43 5 7 303 185 5 6 831 173 5 MOUNTING SCREW 8 M4 2 L x NOT INCLUDED Pinouts eurofast TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com G42 E DeviceNet Media TURCK Network Media Products DeviceNet eurofast Passive Multi Switchable DeviceNet Diagnostic Box Used fo DeviceNet Troubleshooting 2 V 3 v BUS m1 SHIELD OUT 4 CAN H J1 Diagnostic Box 5 CAN L JBBS 57 DGM Fiberglass Taps into CAN_H CAN L V V and SHIELD Used to diagnose DeviceNet should not be installed permanently on network van ve LH CAN_L o 8 S SHIELD
19. 8 105 0001 SDNB 10S 0001 9 138 93 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout eurofast Male 5 4 Diagnostic LEDs 1 Shield 2 V i 3 3 V 6 889 175 0 AN 4 CAN H 5 CANL co 1 0 connectors Aux Power C1 Power LEDs UB Bus InputPower z UL 0utputPower Te 2 U Power 3 Gnd connectors 4 Gnd O 5 1 181 30 0 L F105 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Input Output Connectors 4 3 2 Co 1 V 2 Gate 3 Gnd 4 Latch 5 Shield I O Data Map 1 Er a 2 Count Value Low LSB 3 o tate a Period Value High MB Le Lo serial Interface Control re Set value Low 9 GJ rese ua rese TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com ENC 7 Status 8 B 9 NC 10 Gnd 11 Gnd 12 V Industri A F106 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet TURCK BE ae Industrial I O piconet Products IM
20. Bus in bus out connections 7 8 16UN minifast Eight M12x1 eurofast connectors for field connectors G27 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature 6 770 172 0 Specifications POM Nylon Nickel Plated CuZn or Stainless Steel Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 68 250 V 4A 40 to 75 C 22 to 167 F Dimensions 8 port 2 441 62 0 1 654 42 0 6 376 162 0 8x 4x Pinouts REMOVABLE LABEL INCLUDED VZ 1 CLEARANCE HOLE FOR NO 8 SCREW Industr A 1 470 37 3 1 043 26 5 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet Media G28 TURCK Network Media Products DeviceNet picofast Junctions 4 port e Multi Port Passive Junction Box in Small Compact Housing Accepts M8x1 Snap Loc
21. Ground a 3 connection 1 Shield 2 2 V 0 213 95 4 NV 1 654 42 0 MOUNTING HOLE LEN 2 362 60 0 A 4 CAN H 5 REF 5 CANL F45 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr E DeviceNet Output B Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter Splitter VBRS 4 4 2RK 4T VBRS 4 4 2RK 4T TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F46 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Analog Input Station Rugged Fully Potted Stations Compact Housing IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 100 mA plus sum of input currents from DeviceNet Sensor Current 0 20 mA or 4 20 mA analog signal 16 bit signed integer The 0 20 mA or 4 20 mA range can be adjusted via rotary switch on front of station Power Distribution Inputs DeviceNet power supply Mechanical Operating
22. Industrial Automation Industr A Inputs TAR PP mm 3 5 61 f bie E fi moser of e E LEES ef ess s spare o CE Input Output Connectors E DeviceNet FS V 1 09 1 01 1 021 03 la ls lg ly V Note I O to I O can be used as inputs or outputs o 3 p p I O Data Map 1 pe pepe pepe e lie o f 1 7 6 rs ra 13 1 2 1 1 1 0 FETERE EN ENES EN out o fosfor on 0 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F76 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Enclosure Mounted In Cabinet I O Ideal for Retrofits Input Output Station e IP 20 Protection Automatic Baud Rate Sensing Electrical Operating Current 75 mA plus I O currents from bus power Input Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection IEC IP 20 FDN20 4S 4XSG 0189 FDN20 S0404G 0220 Not CE Material C Housing Nylon Diagnostics Logical e Open short cir
23. Inputs U Power supply Outputs U Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 SDNL 0404D 0003 Material Connectors Nickel plated brass C Housing Nylon Diagnostics Physical One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 9 138 93 5 MOUNTING HOLE M 2x Network Connector Address DeviceNet Pinout Switches 5 eurofast Male Lene N 1 Shield 4 IP Fiber 2 V Link 3 V 4 CAN_H 5 CANL 6 889 175 0 ci REF 2 cs 1 0 connectors SY cs Aux Power Power LEDs UB Bus InputPower UL OutputPower Power connectors 1 181 30 0 L F125 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Input Output Connectors E DeviceNet Mating cordset Mating cordset PSG 3M PSG 3M I O Data Map 1 Data from next input o me tama ene fra re rre DEE Tos os os oe TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F126 Courtesy of Steven Engineering Inc 230 Ryan Way South San Fra
24. Power Distribution Outputs Auxiliary power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material FDNP S0008G TT Connectors Nickel plated brass stainless steel available on request FDNP S0008G TT V Housing Nylon 6 other materials available on request FDNP S0008H TT Diagnostics Logical FDNP S0016N TT 0200 e short circuit status mapped to DeviceNet I O table one bit per each I O point Not FM except FDNP 0200 has no diagnostic data Diagnostics Physical C GR lt gt Individual LED to indicate open short circuit for each channel except FDNP 0200 has one LED indicating a short for all I O points Aux Power Pinout em RE 2 Pass thru 3 Pass thru ca 4 Vaux C5 1 0 8 659 220 0 connectors REF c2 8 266 210 0 Address Switches 1 Shield connectors 2 V Ground 3 V ti connection 4 CAN_H 0 213 05 4 5 CAN L 1 654 42 0 MOUNTING HOLE x 2 362 60 0 ax REF F29 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr went
25. autobaud 125k 250k 500k e L L e a LI a L L LJ L a 0400200009009 Adjustments Slave Side Network address 0 63 via rotary switches Master Side Node count 0 8 via rotary switches e Master Baud Rage 5 6 7 5 125 K 6 250 K 7 500 K I O Status LED OFF off Green On ADDRESS SWITCHES BUS TERMINAL Housing Material Nylon Operating Temperature 40 to 70 C 40 to 158 F 5 994 152 2 1 0 TERMINAL DeviceNet Connector Oo 0 00 V SHD V CAN H CAN L 2 250 57 2 F83 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Sinking Input Output Connectors fel DeviceNet Terminal 1 Terminal 2 OUT 9 I y OUTg OUT UTE E OUT Drive Interface OUT 3 ours OUTPUT INPUT outs y OUTg L Common OUT OUT19 a N E INx H OUTs SI OUT I I I Drive Interface Rey Relay INPUT OUTPUT Common 1 S O Common 2 i i INo IN2 AV NOTE Euge Q S PD Relay Common a
26. 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation DeviceNet BL20 Stations Industr A TURCK s BL20 is a modular user configurable network I O system designed to allow installation of nodes containing different types and sizes of I O depending on the users needs for a particular area Featuring IP 20 protection and terminal point connections the BL20 is intended to be mounted in the control cabinet or in a field enclosure The BL20 system supports several different network protocols including DeviceNet A BL20 station consists of a gateway module that interfaces to the DeviceNet system and several I O modules that interface with the physical I O in the field The terminal bases are available with tension clamp or screw terminal connector types For more details on the BL20 system please see section H of this catalog 1 0 ASSISTANT File Edit Station Online View Extras Options Olla tex sas me ele v eve z j i A n il anui EE Image Process Image Parameter Diagnostics Comment 42 catalog B Adr 1 B W E Pos 1 BL20 E 8DI 24VDC P FA M T SE TR H E Pos 2 BL20 E 16DI 24VDC P H E Pos 3 BL20 4DI 24VDC P amp B Pos 4 BL20 2D0 R CO H E Pos 5 BL20 E 8D0 24VDC 0 54 P i B Pos 6 BL20 E 16D0 24VDC 0 54 P
27. 2 a G43 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Specifications Fiberglass Nickel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn IEC IP20 250 V 4A 40 to 75 C 22 to 167 F Dimensions DGM 4 103 104 2 REF 2 953 75 0 413 10 5 REF Pinouts eurofast Male minifast Male minifast Female Industr A TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet Media G44 TURCK Network Media Products DeviceNet eurofast Passive Multi Port Junctions System Module Junction Box System module with two circuit groups PO ci Bhi V Left 2 V Right vi n P V DeviceNet circuit CAN H 4 CANH CANL CANL Supplies DC power Shield Shield Shield V Right Two drops Shield v Die cast alumin
28. 55 2 REF 1 909 48 5 REF EL R nnector RK nn r Pinouts TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G80 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com
29. Automation indust A DeviceNet Flat Cable Connectors Provides a minifast or eurofast Drop Connector from Flat Cable 50 4 1 589 40 4 END CAP Female 7 8 16UN minifast Flat Cable Connector RKF 57 IDC Flat cable connector to female 7 8 16UN minifast drop RKF 40 IDC ee dio minifast Auxiliary ower Connector M12x1 eurofast Flat Cable Connector FK 57 IDC Flat cable connector to female M12x1 eurofast drop 1 220 31 0 1 531 38 9 d SA z FK 57 IDC ET SPLITTER CAP 1 220 31 0 1 531 2 RKF 57 IDC ET Includes connector end termination and splice kit Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature RKF 40 IDC ET Specifications POM Nylon Nickel Plated CuZn or Stainless Steel Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 68 250 V 4 A eurofast 9 A minifast 40 to 75 C 22 to 167 F TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Hi DeviceNet Media G14 TURCK Network Media Products G15 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Supp
30. DeviceNet eurofast Pinouts Different I O connector pinouts are used for different station types Stations are available with one or two inputs per connector one or two outputs per connector or one input and one output per connector The pin assignments for these styles are provided below Screw Terminal I O Connection Mating cordset RK 4 4T RS 4 4T PE Output Mating cordset RK 4 4T RS 4 4T Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T WH Output B Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T Mating cordset RK 4 4T RS 4 4T Splitter VB2 RS 4 4T 1 2RK 4 41 5651 WH 1 0 B BN Vi A amp B Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T F7 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A AIM stations with part numbers ending in ST support screw terminal I O and bus connections The screw term these stations are located on the back of the station The back of the station is also fitted with a foam gasket to allow the station to be mounted to the outside of a cabinet or field I O box i e motor cont
31. Die cast aluminum enclosure JBBS 57 E403 4 port Junction Bus in bus out straight 7 8 16UN minifast JBBS 57 E411 through ports Four device ports with M12x1 eurofast connectors JBBS 57 E421 Fiberglass JBBS 57 E601 Die cast aluminum enclosure 6 port Junction Bus in bus out straight 7 8 16UN minifast through ports Six device ports with M12x1 eurofast connectors JBBS 57 E621 Fiberglass G37 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Specifications Anodized Aluminum Fiberglass Nickel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K 250 V 4A 40 to 75 C 22 to 167 F Dimensions 4 Port 6 Port 5 433 138 0 5 906 150 0 3 669 93 2 REF 2 520 64 0 1 417 36 0 3 689 93 2 REF 2 520 64 0 1 417 36 0 ia 1 713 43 5 6 831 173 5 7 303 185 5 MOUNTING SCREW 8
32. Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A ses e ere 971 1 1 Hebel et 1 17 Note Total output current for the station is limited to 4 A Input Output Connectors E DeviceNet Mating cordset Mating cordset PSG 3M PSG 3M I O Data Map 1 ele rosi ea eo ia Tre Peres o 15 3 15 2 1s 1 18 0 1 3 1 2 1 1 1 0 Pa T T fosa os osi aseo ou o o2 o2 o3 fen TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F96 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products Im DeviceNet Analog Input Stations e Rugged Fully Potted Stations e Small Footprint IP 67 Protection Automatic Baud Rate Sensing G Electrical e Operating Current lt 75 mA plus sensor currents from Up Power Distribution Inputs Ug Power supply Lj i Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material
33. ES 1 483 SM 7 il 7 8 16UN 01 483 37 7 l dom 1 312 33 3 al 1 312 33 3 SEALING GASKET LOCKING NUT END VIEW SEALING GASKET LOCKING NUT END VIEW TRIM WASHER THRUST WASHER LOCENUT NOT SHOWN TRIM WASHER THRUST WASHER LOCKNUT NOT SHOWN RSFP Pages G7 G10 RKFP Pages G7 G10 G11 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet eurofast Cordset and Receptacle Connector Dimensions Specifications Overmold PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane or POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 68 Rated Voltage 250V Rated Current 4A Ambient Temperature 40 to 75 C 22 to 167 F 2 173 dla 13 5 d RSC Pages G7 G10 RKC 1 555 39 5 9 591 15 0 M12x1 WSC Pages G7 G10 WKC 11 12 118 3 0 MAX 9 787 20 0 748 19 0 FSFD Pages G7 G10 FKFD 846 21 5 709 18 0 118 3 0 u Hj y E DeviceNet Media po am Br ua 13 5 Pages G7 G10 E 1 811 46 0 1 300 33 0 TE to Pages G7 G10 M12x1 9 787 20 0 748
34. F Not CE Protection Open Frame Diagnostics Logical C One bit in I O table indicates input fault for entire station one bit er output for fault indication 1 437 36 5 1 169 29 7 490 12 4 Bus and l I O connector F111 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Screw e 51 Input Output Connectors E DeviceNet OBDDAO BODAOAO7G20G QQQQQQOYOOQ 0 fe Toy i Tope Te TH T Note L refers to CAN_L and H refers to CAN_H I O Data Map 1 o es Le EN 101 131 1 1 1 Ei TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F112 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet OEM Station e PC Board Slaves e Ideal for Retrofits Small Footprint Included Mounting Bracket Electrical e Operating Current 50 mA plus sum of I O currents from DeviceNet Input Current 700 mA sum of all inputs from DeviceNet Output Current
35. LENGTH 2x 394 10 0 Es 4477 4 5 G32 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet minifast Passive Multi Port Junctions Rugged Fully Encapsulated Enclosure For Connecting I O in Concentrated Areas Bus In Bus Out Eliminates Need for Splitter Tee Suitable for Outdoor Applications 4 port Junction JBBS 57 M401 Bus in bus out straight 7 8 16UN minifast through ports JBBS 57 M413 Four device ports with 7 8 16UN minifast connectors 6 port Junction JBBS 57 M601 Bus in bus out straight 7 8 16UN minifast through ports JBBS 57 M613 Die cast aluminum Six device ports with 7 8 16UN minifast connectors enclosure 8 port Junction JBBS 57 M801 Bus in bus out straight 7 8 16UN minifast through ports JBBS 57 M813 Eight device ports with 7 8 16UN minifast connectors G33 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indusi A Specifications Housing Anodized Alumi
36. Local Area 800 258 9200 www stevenengineering com Industrial Automation Indust DeviceNet Cable Cordsets Selection Matrix Snap Lock gt O 7 cmmm condo o UB PKGZ PSG RST WST PKGZ 57x M PSG 57x M RST 57x WST 57x RKT 57x WKT 57x Bare 15 cma n PKGZ PKGZ 57x M PKGZ PSG 57x M PKGZ RST 57x M PKGZ WST 57x M PKGZ RKT 57x M PKGZ WKT 57x M PKGZ 16 cA TEES PSG PSG 57x M PSG RST 57x M PSG WST 57x M PSG RKT 57x M PSG WKT 57x M PSG See pages G19 G20 for dimensional drawings Socket Female EE DeviceNet Media Pin Male Indicates length in meters x Indicates cable type See page B125 for available cable types Type 5715 cable can be used with RST WST RKT and WKT smaller body styles Consult factory for part numbers Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths Female Bare Shield Drain Wire Female Red Voltage EI Black Voltage White CAN_H Blue CAN_L N C picofast only TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G18 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering
37. M eo E DeviceNet Media WSM WSC 57x M WSM RKC 57x M WSM WKC 57x M 57x M RKM WSC 57x M RKM RKC 57x M RKM WKC 57x M 57x M WKM WSC 57x M WKM RKC 57x M WKM WKC 57x M 57x M RSC WSC 57x M RKC 57x RSC WKC 57x M 57x M RSC M WSC WSC 57x M WSC WKC TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G8 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Open Connector Cordset Selection Matrix Pin Socket Female APA RSC CBC5 57x M RSM CBC5 57x M WSM CBC5 57x M RKM CBC5 57x M WKM CBC5 57x M RSC CBC5 57x M CBC5 14 UE BK52C 57x M BK52C See pages G10 G12 for dimensional drawings Indicates length in meters x Indicates cable type Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths For stainless steel coupling nut Change part number RSM to RSV RSC to RSCV RSM BK52C 57x M WSM BK52C 57x M RKM BK52C 57x M WKM BK52C 57x M RSC BK52C 57x M Thin Cable Only Thin Mid
38. Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F116 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet BL67 Gateway Modular I O e IP 67 Protection Fieldbus Independent Configuration e Various I O Styles Electrical e Operating Current 600 mA from V e Supply Current lt 8 A to I O from DeviceNet e Backplane Current 1 5 A from DeviceNet Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IP 67 e Vibration 5 g 10 500 Hz Material Housing PC VO Lexan C G Diagnostics Logical Diagnostic information available through the DeviceNet I O map BL67 GW DN Diagnostics Physical e LEDs to indicate status of DeviceNet and Module Bus communication I 3 051 77 5 r 2 913 74 0 Service Port and Address Switches Diagnostic 3 583 91 0 LEDs 5 709 145 0 DeviceNet connector DeviceNet connector N 1 260 32 0 L DeviceNet minifast Pinouts 1 Shield 2 V 3 V 4 CAN H 5 CAN L Note Power feeding modules may be used for I O current supply to prevent overloading the DeviceNet power supply F117 TURCK Inc 3000 Campus Drive Minneapolis MN 55441
39. Network Media Products Gasket and Mounting Screws Provided For Use with a Single Gang Electrical Box 2 962 75 2 Attaches to standard 119 2 single gang electrical 3 281 83 3 BPA 57 M113 box for transition to 5 wire 7 8 16UN minifast connector Stainless Steel 250 V 4 0 A 40 to 70 C 40 to 158 F 2 962 75 2 Attaches to standard 119 2 single gang electrical 3 281 BPA 57 E113 box for transition to 5 wire M12x1 eurofast connector 1 Shield 2 6 gt CAN H 55 CAN L Elo J CAN_L Y Shield o CAN H V G55 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet Bus Drop and Diagnost e Creates a Drop or Branch from the Main Bus Line e 7 8 16UN minifast Connectors on Bus and Drop Lines Available in Three Keyway Options minifast Drop Off ES 2 874 73 0 REF e4 Bus Line uo 28 0 r 01 024 2601 7 8 18UN PO 7 H 8 16UN Ld 689 17 5 Full power and data drop Max
40. O counts greater than eight total points connect two signals to each connector If the signals being connected are on the same physical device for example a sensor with two outputs a simple four or five wire cordset can be used for connection Figure 1 on the next page Input O Output ISS Input Short Circuit Status lOS Input Open Circuit Status OS Output Status APS Auxiliary Power Status TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F10 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet If the signals are on two separate devices a splitter can be used to separate the AIM I O connector into two individual eurofast connectors The recommended splitter is wired such that the second signal pin on the AIM station pin 2 is wired to the default signal pin pin 4 on the second splitter arm requiring no special wiring by the user The splitter is simply plugged into the AIM I O connector and each arm is plugged into the appropriate I O devices as shown Figure 2 Figure 1 For one input per connector use standard cordsets for example RK 4 4T 1 RS 4 4T AIM stations provide a wide range of connection options depending on the I O count and type being used The user
41. Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K Vibration 50 g O 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request FDNL SN0808N C Diagnostics Physical C G One LED indicates a fault for the entire station e LEDs to indicate status of DeviceNet communication C4 c5 1 0 connectors c6 7 756 197 0 REF 7 362 187 0 c7 Address Dota Rote bs DeviceNet eurofast Pinout Network connectors 1 Shield Ground 2 V connection 3 V 4 CAN H 9 213 05 4 1 654 42 0 MOUNTING HOLE 5 CANL 2 362 60 0 ae REF F21 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Input Output Connectors E DeviceNet Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T I O Data Map 1 Pepe pepe ppp pe o 1 r6 15 12 18 2 2 re ME sis F a ER BON A Fue o 0 7 0 6 os Jos 0 3 0 2 9 9 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F22 Courtesy of Steven Engineering Inc 230 Ry
42. Rated Current 9A Ambient Temperature 40 to 105 C 40 to 221 F E DeviceNet RSM Pages F54 F55 gt 1 720 43 7 2 2 047 52 0 r 01 024 26 0 WSM Pages F54 F55 9 256 31 9 peta DK 1 1 039 26411 1 483 37 7 RKM Pages F54 F55 4 ES 2 047 52 0 gt 1 583 40 2 01 024 26 0 7 8 16UN WKM Pages F54 F55 10 1 106 28 1 890 d M30x1 5 7 8 16UN H 7 8 16UN i 01 483 37 7 Hi 1 312 33 3 ZL E 1 312 53 3 SEALING GASKET LOCKING NUT SEALING GASKET LORKING NUT END VIEW TRIM WASHER L THRUST WASHER GENE NOE SHOWN TRIM WASHER THRUST WASHER LOCKNUT NOT SHOWN RSPP Pages F54 F55 RKFP Pages F54 F55 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F56 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products Bos E connect eurofast Cordset and Receptacle Connector Dimensions Specifications Overmold PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane or POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 68 Rated Voltage 250 V Rated Current 4A Ambient Temperature
43. Switches 5 Pin minifast DeviceNet connectors Advantages Tremendous savings in startup and trouble shooting time DeviceNet PLC monitors the state of the safety switch Easy to integrate into any DeviceNet station Provides quick connection to standard e stop devices and safety relays The information contained in this publication is general in nature and is for educational purposes Each application is unique It is the responsibility of the user to ensure all applicable jurisdictional codes and regulations are satisfied and that installation and maintenance instructions are followed F51 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industri A Series E connect The series E connect system provides quick basic e stop with a total of only seven different components and cabling The red cables tees and mini connectors assemble quickly and can be maintained easily Its only difference from a standard pipe and wire solution is that it is connectorized It is still a true hard wired system the pipe and wire have simply been replaced with red connectorized cable Push Button Push Button RSM RKM E40 M Y RSM RKM RKM 40 DESD alnpojy
44. U 3 Gnd Power E SY connectors 4 Gnd O 1 181 30 0 L F109 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A E DeviceNet 1 Clock SSI 2 Clock 3 Data 4 Data 5 NC 6 NC 7 NC 8 NC 9 NC 10 NC 11 V 12 Ground Mating cordset CKM 12 12 5817 I O Data Map 1 o Data 0 ao meses TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F110 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet OEM Stations e PC Board Slaves e Ideal for Retrofits Small Footprint Bus Powered I O Electrical Operating Current 50 mA plus sum of I O currents from DeviceNet Input Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply FDN PCB 22 Mechanical FDN PCB 22 OEM Operating Temperature 40 to 70 C 40 to 158
45. and discrete actuators TURCK stations also serve as a buffer between I O devices and the DeviceNet bus by detecting short circuits without disrupting DeviceNet communication For deluxe style stations each I O point on the station provides state and status data State data represents the real world value of the I O device for example when the sensor is on or the actuator is off Status data indicates short circuits in the I O device or in the wiring between the device and the station Some models also use status data to indicate open circuits State and status data are transferred to the DeviceNet scanner where it is available for fault handling in the control program Additionally each input and output has a multicolored LED to indicate its state and status and pinpoint I O problems quickly for example the module status LED indicates the internal health of the station and the network status LED indicates the station s communication on the DeviceNet network Addressing The valid range of DeviceNet node addresses is O to 63 The station s default node address is 63 Each node s address must be initially set usually via rotary dials or switches on the node The address can also be set with a DeviceNet configuration tool Changes to the address settings take effect when the station power is cycled Care must be taken to prevent the same address from being assigned to more than one node in a system If the same address is set on multiple nodes o
46. c2 ce 4 Var 8 266 210 0 c3 c7 Address Switches 1 Shield ror 2 V Ground 3 V connection 4 CAN_H 1 0 213 05 4 5 CANL 1 654 42 0 MOUNTING HOLE sa 2 362 60 0 e REF F33 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr FDNP XSG16 TT FDNP S1204H TT 0149 DeviceNet Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T Splitter VB2 RS 4 4T 1 2RK 4 4T S651 G Mating cordset Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T Splitter VBRS 4 4 2RK 4T Splitter VBRS 4 4 2RK 4T I O Data Map 1 jan PERIZ oie Sf plen ALe Menn elt Bee I O Data Map 4 o res oss 1 3 12 1 1 teo eae out o 03 o 2 0 1 0 0 ro fav refpistialisa iz it 10 I O Data Map 2 e ses os pe pepe ppp pe o os 0 6 os oa 5 o Gi oo Lo iz re rs re i ref rif ro Ott os 024 025 022 9 1 036 09 0 8 1 16s os ou o o os fos
47. com TURCK Network Media Products DeviceNet eurofast Cable Cordsets Connector Dimensions Specifications Housing PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 68 Rated Voltage 250 V Rated Current 4A Ambient Temperature 40 to 75 C 22 to 167 F 1 546 SE 0 571 14 5 Di im RST Pages G17 G18 RKT 0 571 14 5 Pages G17 G18 22 1 220 31 0 984 25 0 3 1 220 31 0 Ld 13 5 591 15 0 MINA T M12x1 WST Pages G17 G18 WKT Pages G17 G18 G19 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet picofast Cable Cordsets Connector Dimensions Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature PSGM Pages G17 G18 PKGM 15 1 220 31 0 1 022 26 0 9 531 13 5 M8x1 E l l PSWM Pages G17 G18 PKWM 17 na 1 228 31 2 po HAJ oss 8 4 PSG Pages G17 G18 PKGZ TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Applicati
48. com F60 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com VB2 Junction with Trunk Line VB2 FSM E8 RKC RKC E40 M M Reduced power and data branch Maximum six meter branch qr 512 13 0 905 23 0 0 315 98 0 2x 0 177 04 5 2x 984 25 0 ES DeviceNet TURCK Industrial I O DeviceNet Products Rugged Fully Potted Stations Monitor E Stop Switches with DeviceNet E Connect Stations Electrical Power Distribution Mechanical Material Diagnostics Logical FDNP ES44 TC FDNP ES88 TC FDNP ES88 TT Ce Diagnostics Physical Auxiliary Power 1 0 and E stop circuit connectors 8 661 220 0 REF 8 267 Address Switches Network connectors Ground connection 0 213 05 4 MOUNTING HOLE 4x 2 362 60 0 REF F61 DeviceNet IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Operating Current 40 mA from DeviceNet Output Current 500 mA per output from Aux Power Inputs Auxiliary power supply Outputs Auxiliary power supply Operating Temperature 25 to 70 C 13 to 158 F e Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Connectors Nickel plated brass stainless steel available on request Ho
49. consumes 12 output bytes then side B must be set to produce 12 input bytes and consume 2 output bytes E DeviceNet Electrically The spanner optically isolates network A from network B the networks do not interact electrically in any way The spanner is powered internally by network A a power reset on the A side will reset the entire station Addressing Because the spanner is essentially two DeviceNet devices one on network A and one on network B it has two sets of address switches The address switches for network A are completely independent of network B Baudrate The spanner automatically detects the Baudrate at startup Network A and B may be at different baudrates Spanner Topology The spanner is typically used to correct and coordinate multiple work cells Conveyor PLC To other stations on conveyor To other stations on work cell A To other stations on work cell B T I Cell B PLC El H B S Work Cell A Network Work Cell A Network TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F70 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet DeviceNet FDN20 Stations TURCK s FDN20 DeviceNet stations are low cost screw terminal connection stations designed for moun
50. ff ox N y HOOH FK 57 M M20 250V 4A M20x1 5 threads NJ 40 to 105 C lt ab FK 57 M PG 9 threads 1 2 14NPT FK 57 M NPT modified length threads See page G72 for dimensional drawings 8 40 39 1 42 Length in meters Standard cable length is 0 3 meters Consult factory for other lengths Receptacles require a 13 16 21 0 mm clearance hole for panel mounting Standard housing material is nickel plated brass RKF RKFV indicates 316 stainless steel housing G65 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet minifast PCB and Solder Cup Receptacles Provides 7 8 16UN minifast Connection to Field Devices RSF 57 PCB Male minifast PCB pins RSF 57 Male minifast solder cups Nickel Plated CuZn or Stainless Steel i 44 300 V 9A 40 to 105 C RKF 57 PCB Female minifast PCB pins Female 46 RKF 57 Female minifast solder cups See page G73 for dimensional drawings Standard housing material is nickel plated brass RSFV RKFV indicates 316 stainless steel Panel Cutout Board Layout reference only FK FS FK FS 60 60 0 827 21 0 Fe P ev V VM 0 350 98
51. i Di 45 1 043 26 5 394 aL pee 25 1 209 EST 7 N PG11 7 8 16UN 1 091 27 7 1 2 14NPSM 7 8 16UN j N A 138 3 5 pE 551 0 ES E 24 0 O RING E J O RING RSF PCB Page G66 RSF Page G66 44 46 913 23 2 Hos 913 23 2 236 6 0 9 937 23 8 394 10 0 9 039 os E 209 5 3 zi C AI PG 11 7 8 16UN 1 091 27 7 1 2 14NPSM 7 8 16UN y po d 138 3 5 A lt E A 543 13 8 945 24 0 O RING O RING RKF PCB Page G66 RKF Page G66 eurofast PCB Mount Male and Female Receptacles 47 1 410 35 8 640 16 3 463 11 8 320 8 1 ses 041 FN MN a Pcs TOP j W Ud MAX RECOMMENDED ti 281 7 1 ANEL MOUNTIN 199 5 1 104 2 6 200 5 1 200 5 1 WFS PCB Page G68 G73 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial eurofast PCB Mount Male and Female Receptacles Automation 48 I act 846 21 5 118 3 0 MAX F mizzi MED O RING FSFDL Page G68 49 846 21 5 118 3 0 mar m p 0 031 De m IK j le 787 20 0 7 494 12 5 K gt 748 19 0 374 9 5 O RING 19 0 FSFD PCB Page G68 50 9 809 20 5 Right Angle Connecto
52. should be aware of the I O pinout being used Figure 2 1 3 BRANCH 2 m4 lt 1 1 2 TRUNK 3 BRANCH 1 4 LA For two inputs per connector use a splitter for example VBRS 4 4 2RK 4T 1 1 F11 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A F AIM Designator Top entry plastic Connector Material Blank Nickel Plated Brass V Stainless Steel DeviceNet Aux Power Connector T Through minifast 8 I O Ports Aux power 220 mm long Both maleandifemale P L 8 I O Ports 197 mm long Q 41 0 Ports 148 mm long E DeviceNet DeviceNet Connector Configuration T Through minifast both male and female E eurofast Drop single male L NPN PNP Individual Open and Short circuit Detection mini P PNP Individual Open and Short circuit Detection MIE drop nae Ry S PNP Group Input Short circuit Detection Earth Ground Pin 5 C Combined ie CPG Combined PNP and 500 mA Outputs X Universal PNP Input or 500 mA Output G 510 mA Outputs N NPN Group Input Short circuit Detection Earth Ground Pin 5 H 1 4 or 2 0 Amp Outputs Number of Outputs Number of Inputs TURCK Inc 3000 Campus Driv
53. turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A E connect Cable Cordset Selection Matrix Pin Male Socket Female WSM WKM RSM Exx M WSM Exx RKM Exx M WKM Exx M RSM RSM Exx RSM WSM Exx M RSM RKM Exx M RSM WKM Exx M WSM WSM Exx M WSM RKM Exx M WSM WKM Exx M RKM RKM Exx M RKM WKM Exx M ES T Pin Male nf 100 22 co x RSC Exx M RSM RSC Exx M E DeviceNet Pin Male WSM RSC Exx M RKM RSC Exx M Socket Female WKM RSC Exx M RSC RSC Exx M Pin Male Socket Female See pages F56 F57 for dimensional drawings Indicates length in meters x Indicates cable type Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 0 3 0 5 1 0 2 0 2 5 3 0 3 5 4 0 5 0 6 0 8 0 10 15 50 Meters Consult factory for other lengths For stainless steel coupling nuts change part number RSM to RSV WSM to WSV minitas Female 1 Bare Shield Drain Wire 2 Red Voltage 3 Black Voltage 4 White CAN_H TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F54 Courtesy of
54. use the autobaud setting Parameters Many DeviceNet configuration tools support the use of EDS driver files to configure nodes and set various parameters Some of the user settable parameters available for AIM stations are Baud Rate Defines the baud rate for the station to use if 125kB 250kB 500kB 125kB Autobaud is disabled Autobaud If enabled the station automatically senses the Enable Disable Enable baud rate Set to UCMM to use unconnected messaging ai cn Predefined M S Connection i Set to enable fast startup connection to is i DeviceNet QuickConnect SM Consult the documentation for the DeviceNet configuration tool you are using for details on how to access device parameters via EDS files F9 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Diagnostics AIM stations provide two LEDs for diagnosing communication problems Module Status Green Working properly Flashing green Detecting baud rate Flashing red Input short circuit Network Status e Green Connection established Flashing green Waiting for connection E DeviceNet Flashing red Connection timed out Red Cannot connect There is an additional LED for ea
55. 0 1 000 25 4 RSF Page G62 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust Ai minifast Female Receptacles 28 30 1 180 30 0 1 268 32 2 709 18 0 ie A 0 988 25 1 dea af 0 988 25 1 p R 7 8 16UN 61 142 29 0 7 8 16UN 01 409 35 8 a j d T E 1 000 25 4 1 250 31 7 to RKF 14 5 Page G63 RKF 14 75 Page G63 2 29 31 m 964 24 5 913 23 2 374 9 5 0 988 25 1 394 lg a 91 000 25 4 7 8 16UN 1 142 29 0 4 E 1 000 25 4 vai MERE 1 2 14NPT 4 V O RING RKF M20 Page G63 RKF Page G63 32 1 011 25 7 499 12 7 0 988 25 1 1 2 14NPT F N 7 8 16UN 1 142 29 0 F Y 1 000 25 4 RKF NPT Page G63 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G70 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products eurofast Male Receptacles 33 a E 5 0 FS 14 5 Page G64 2001 55 M 969 24 6
56. 00 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Cordsets TURCK offers a complete line of molded DeviceNet cordsets to facilitate network installation resulting in a faster start up and fewer wiring errors The bus and drop cables are specially designed foil shielded high flex cables with very low inductance and capacitance to minimize propagation delay time DeviceNet cables consist of a shielded and twisted data pair as well as a shielded and twisted power pair for the 24 VDC bus power with an additional outer shield The 24 VDC power pair provides bus power to the station s communication electronics and typically to input circuits The data lines for CAN High and CAN Low differential signals conform to the CAN standard and support network data exchange at the maximum transmission speed of 500 kbps In most cases bus cable connections are made using 5 pin minifast 7 8 16 UN or eurofast M12 connectors A variety of stations are also available that support terminal block type connections Stations with output circuits for DC actuators normally require 24 VDC auxiliary power fed through a separate connection from the communication bus TURCK cordsets for the DeviceNet system are available in standard lengths Contact your local sales representative to order custom lengths Diagnostics TURCK stations provide increased diagnostics when used with standard proximity or photoelectric sensors
57. 08 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Input Output Connectors m DeviceNet RTD Shield Mating connector field wireable Mating cordset WAS5 THERMO RK 4 5T RS 4 5T includes cold junction compensation I O Data Map 1 EY Channel 0 MSB 4 cheer ese 6 mes m Pet TT e Tasa Jasa Jas TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F100 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O piconet Products Analog Output Stations m m m RS e SDNB 04A 0009 SDNB 04A 0007 CE MET n gt Rugged Fully Potted Stations e Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA from Up Power Distribution Outputs U Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire
58. 1 o 4 5 6 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F48 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Analog Input Station Rugged Fully Potted Stations Compact Housing IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 100 mA plus sum of input currents from DeviceNet Sensor Current 0 20 mA or 4 20 mA analog signal 16 bit signed integer Sensor Voltage 0 to 10 V or 10 to 10 V Analog signal 16 bit signed integer The voltage current ranges can be adjusted via rotary switch on front of station Power Distribution Inputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K FDNQ 4AI V I T e Vibration 50 g 10 500 Hz CE amp Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Physical e LEDs to indicate status of DeviceNet communication 1 0 connectors 5 829 148 1 REF 5 376 136 6 Address Input mode Switches Network o connectors DeviceNet minifast Pinout Ground c
59. 2 362 60 0 hs REF F25 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Mating cordset RK 4 4T RS 4 4T Mating cordset RK 4 4T RS 4 4T I O Data Map 1 REE CI NOH LINDE REGN C E ET NEAN EE REIN RUNS rasert e os E gt memes E fa E E 2 fosafx E gt ae o os c 2 fome x x peje e A a AE a os E 2 me LLL E EE E IC Input Output Connectors 2L Mating cordset Sensor with dual outputs RK 4 4T RS 4 4T Two sensors RK 4 5T RS 4 5T Splitter VBRS 4 5 2RK 4T S818 2G WH Output B Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T I O Data Map 2 Industr E DeviceNet Mating cordset Sensor with dual outputs RK 4 4T RS 4 4T Two sensors RK 4 5T RS 4 5T Splitter VBRS 4 5 2RK 4T S818 2H Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T e sr 1s e 10581054 1053 os 10 1 1050 3 05 7 05 6 05 5 05 4 05 3 05 2 05 1 05 0 DEC Ea pos de ari o e e o e eos TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F26 Courtesy of Steve
60. 200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature MOUNTING SCREW M4 2x NOT INCLUDED TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Specifications Anodized Aluminum Nickel Plated CuZn or Stainless Steel PUR Polyurethane Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 68 300 V 9A 30 to 75 C 22 to 167 F SPTC1 4 920 125 0 4 448 113 0 SPTT1 2 264 57 5 MOUNTING SCREW 8 ma 2x NOT INCLUDED 1 Bare Shield 2 Red Voltage 3 Black Voltage 4 White CAN H 5 Blue CAN L 1 417 36 0 4 920 125 0 4 448 113 0 Industr A SPTC2 3 857 98 0 3 384 86 0 1 417 36 0 64 0 MOUNTING SCREW 8 M4 2x NOT INCLUDED 1 Voltage 2 Voltage 3 Voltage 4 Voltage E DeviceNet Media G78 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet eurofast Daisy Chain Configurations Multi drop Harnesses Designed for OEM Applications Provides Cost Effective Solution vs Single Tees and Drops PUR Polyurethane
61. 370 Main Office 650 588 9200 Outsid 0 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet E connect Cable Specifications Provides E line Connection from Safety Module to Field Device Provides Drop to E Stop Device Red PCV Jackets Approvals NEC PLTC ITC C CEC AWM 1 11 A NEC PLTC ITC C CEC AWM I II A NEC CL2 L2 B FT4 2 B FT4 CEC AWM 1 11 A Indicates length in meters x Indicates cable type Standard cable lengths are 30 75 150 225 and 300 meters Consult factory for other lengths B FT4 Jacket E line from safety module to field device Figure B Jacket Drop cable to E stop device Power Pai WG A Color Code 4 18 AWG BN BU RD OR 4 16 AWG BN BU RD OR 8 24 BN BU RD OR BK WH WH RD WH OR See page A6 for flexlife and weldlife performance For stainless steel coupling nuts change part number RSM to RSV WSM to WSV F53 DCR 1000 feet Insulation 6 5 Ohms PVC 4 3 Ohms PVC 27 7 Ohms PVC Material Color Nominal O D PVC Red 7 2 mm 285 in PVC Red 8 4 mm 330 in PVC Red 5 7 mm 224 in Brown Blue Red Orange Brown Blue Red Orange Black White WH RD WH OR Bulk Cable Part Number Weight 300 M RB50896 M RB50925 M RB50897 M 36 lbs TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www
62. 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G62 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet 7 8 16UN minifast Female Receptacles Provides Quick Connection to Field Devices or Enclosures Available for 1 2 14NPT 1 2 14NPSM 3 4 14NPT and M20 Threads 1 2 14NPT full h RKF 57 M 14 5 du mer 3 4 14NPT full length RKF 57 M 14 75 threads RKF 57 M 1 2 14NPSM threads 1 2 14NPT modified length threads RKF 57 M NPT 29 Female Nickel Plated CuZn or Stainless Steel f RKF 57 M M20 300 V 9 A M20x1 5 threads 40 to 105 C See page G70 for dimensional drawings Length in meters Standard cable length is 0 3 meters Consult factory for other lengths Receptacles require a 13 16 21 0 mm clearance hole for panel mounting Standard housing material is nickel plated brass RKF RKFV indicates 316 stainless steel housing For locknuts to be included add W LN to the end of the part number G63 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com
63. 63 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust Al Notes E DeviceNet Media TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G24 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Panel Mount Junction Box DIN Rail Junction Box Open Style Removable Terminals APPROVED P1 BUS IN3 4 JO BUS OUT JRBS 57 4 12345 12345 12345 12345 J1 J2 J3 J4 JO BUS OUT Open style DIN mounted junction box JRBS 57 6 12345 12345 12345 12345 12345 J2 J3 J4 J5 J6 JO BUS OUT JRBS 57 8 12345 12345 12345 12345 12345 12345 12345 12345 J1 J2 J3 J4 J5 J6 J7 J8 G25 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Contact Carrier Contacts Protection Connection Mode Ambient Temperature Specifications Alumi
64. 68 0 2x i 9 177 64 5 2x mp M12x1 LI M12x1 984 25 0 984 25 0 I 905 23 0 Le Eus 38 0 905 23 0 1 496 38 0 VB2 FKM RKC RSC 57x M M 0 315 08 0 2x ma 13 0 0 177 4 5 2x M i M12x1 2x T M12x1 984 25 0 905 23 0 m L aas 38 0 Pinouts TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G52 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet minifast Conduit Adapters Gasket and Mounting Screws Provided Same Housing Style for Single or Double Port 1 870 47 5 Attaches to standard conduit body for transition BCA 57 M123 to 5 wire 7 8 16UN minifast connector Crouse Hinds 3 4 Form 8 Mark 9 or equivalent Female Nylon Housing Stainless Steel Receptacle Housing 300 V 9 A 40 to 75 C Attaches to standard conduit body for transition 4 350 110 5 BCA 57 M223 to 5 wire 7 8 16UN minifast connector Crouse Hinds 3 4 Form 8 Mark 9 or equivalent Standard receptacle housing material is stainless steel for nickel plated brass change part number from M223 to M224 1 port Wiring Diagram 2 port Wiring Diagram Svrezi er ir 1zeys LZCHS Svezi ir Gv g zei LZEHS SvEZI G53 T
65. 688 17 5 Tee provides iw 833 RSM RKM 57 WSM 40 PST segment power T e RR 1 504 38 2 Includes reverse current protection 4 L 91 024 26 0 LO 7 8 16UN PUR Polyurethane 300V 9A 40 to 75 C Bus Diagnostic Tee 2 874 73 0 REF SF 1 102 28 0 rr 01 024 26 0 so 26 0 Provides easy 4 connection for diagnostic tools 689 17 5 7 8 160N ssion M RSM 2RKM 57 DGT L i S Tap protected TY E 1 370 34 8 with cover when not in use j 7 not shown lella 61 024 26 0 Pinouts minifast G57 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet Bus Tees Creates a Drop or Branch from the Main Bus Line Cable Drop Can Be Up to a Maximum of 6 Meters eurofast Drop Connector or Extension Cordset p 2 874 73 0 e uo 28 0 j 01 024 26 0 01 024 26 0 H lg T eurofast Drop y 689 17 5 nai oY RSM FKM RKM 57 1 239 31 5 E DeviceNet Media minifast to eurofast Bus power and data drop PUR Polyurethane 2 874 73 0 quo 28 0 250 V 4A 01 024 26 0 poro 26 0 40
66. 689 17 5 7 8 16UN 7 8 16UN 3124 1 370 34 8 l eon 26 0 7 8 16UN TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F58 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet E connect Terminating Resistor Male minifast Connector TPE PUR Overmold Body minifast with Male 1 909 e qoem 26 0 Nickel Plated Brass n em EJ mos or Stainless Steel P 1 3 Internally Internal Jumper Internal Jumper RSM 40 DJ 12 34 300V 9A jumpered to 1and 2 3 and 4 40 to 75 C complete dual I Pe E amp M stop circuits F59 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation E connect eurofast Drop Junctions Creates a Drop or Branch from the Main Bus Line Cable Drop Lengths Available Up to a Maximum of 6 Meters See Figure 1 Indicates length in meters TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck
67. 8 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Enclosure Mounted In Cabinet I O Ideal for Retrofits Input Output Stations IP 20 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus applicable I O currents from bus power Input Current 700 mA sum of all inputs Output Current 500 mA per output Power Distribution Inputs Optionally DeviceNet or Auxiliary power supply as shown in wiring diagram Outputs Optionally DeviceNet or Auxiliary power supply as shown in wiring diagram Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection IEC IP 20 Material FDN20 16XSG Housing Nylon FDN20 16S Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates a fault for all inputs on bit indicates a fault for all outputs Diagnostics Physical C lt gt DIV 2 ED to indicate status of DeviceNet communication ADDRESS SWITCHES BUS TERMINAL 5 994 152 2 1 0 TERMINAL DeviceNet Connector CAN H CAN L L 2 250 img F79 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francis
68. 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet DeviceNet Repeater Extend Network Length Isolate Power Segments Extend Drop Lengths Isolate Communication Segments Electrical Operating Current 125 mA from segment A 30 mA from segment B Power Distribution REP DN DeviceNet power supply for each segment must be powered by separate supplies REP DN Drop Does not require a separate power supply and does not isolate power between segments Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 and IEC IP 67 e Vibration 50 g amp 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request REP DN REP DN DROP Diagnostics Physical C G One LED for each segment to indicate communication status Housing Nylon 6 other materials available on request Network connectors Segment B 8 661 220 0 REF 8 267 210 0 Doto Rote Switches DeviceNet minifast Pinout Y Network t Segment A 1 Shield 2 V 3 V 9 213 05 4 1 654 42 0 St L 4 CAN H 2 562 60 0 va 5 CANL REF Note each segment has one male and one female connector F67 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Offi
69. 85 C a 250 V 9A Mates with all 5 pin cordsets and Glass filled nylon receptacles PG 9 cable gland accepts 6 8 mm cable diameter BS 4151 0 13 5 DNET B 4151 0 9 DNET inal 01 065 27 0 3 346 85 0 dl Screw terminals Female 85 C 250V 9A 7 8 16UN i Glass filled nylon To PG 13 5 cable gland accepts 10 12 mm cable diameter Screw terminals 85 C 250V 9A B 4151 0 13 5 DNET G75 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet eurofast Field Wireable Connectors e Allows for Quick Connection when Pre Molded Cables not Available e Available for Male and Female Connectors in Straight or Right Angle Configurations e Color Coded Wire Connections for DeviceNet ur 0 772 19 6 PBT Black PG 9 cable gland accepts 4 8 mm cable diameter B 8251 0 PG9 DNET 1 574 40 0 Screw terminals APPROX 85 C 125 V 4A E DeviceNet Media 1 651 41 9 0 772 19 6 PBT Black PG 9 cable gland accepts 4 8 mm cable diameter 1 574 40 0 BS 8251 0 PG9 DNET Screw terminals APPROX 85 C 125V 4A PBT Black 2120 1840 0 772 19 6 PG 9 cable gland accepts 4 8 mm cable diameter B 8151 0 PG9 DNET Screw terminals i 85 C Fema
70. 9 9 059 01 5 5x TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G66 E DeviceNet Media Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet eurofast PCB and Solder Cup Receptacles Provides M12x1 eurofast Connection to Field Devices Male eurofast with FS 57 PCB KIT mounting kit Male FS 57 PCB Male eurofast Nickel Plated CuZn o Stainless Steel 54 250V 4A 40 to 105 C Female eurofast with FK 57 PCB KIT mounting kit 55 FK 57 PCB Female eurofast See page G74 for dimensional drawings Standard housing material is nickel plated brass FSV FKV indicates 316 stainless steel Board Layout reference only FK FS 098 2 5 TYP AY 9 043 01 1 5x 197 5 0 G67 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet eurofast PCB Pins and Solder Cup Receptacles Provides M12x1 eurofast Connection to Field Devices Male eurofast PCB pins FSFD 57 P
71. 96 63 4 714 18 1 Nickel Plated CuZn or Stainless Steel Female eurofast to male RSM 57 FK 4 5 250V 4A minifast adapter 40 to 75 C Pinouts minifast eurofast G61 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet 7 8 16UN minifast Male Receptacles Provides Quick Connection to Field Devices or Enclosures Available for 1 2 14NPT 1 2 14NPSM 3 4 14NPT and M20 Threads 23 1 2 14NPT full length RSF 57 M 14 5 threads i 25 3 4 14NPT full length RSF 57 M 14 75 threads T E DeviceNet Media 24 Nickel Plated CuZn o Stainless Steel RSF 57 M M20 300 V 9A M20x1 5 threads 40 to 105 C RSF 57 M 1 2 14NPSM threads x 1 2 14NPT modified RSF 57 M NPT length threads Standard cable length is 0 3 meters Consult factory for other lengths Receptacles require a 13 16 21 0 mm clearance hole for panel mounting Standard housing material is nickel plated brass RKF RKFV indicates 316 stainless steel housing For locknuts to be included add W LN to the end of the part number See page G69 for dimensional drawings Length in meters TURCK Inc 3000 Campus Drive Minneapolis MN
72. Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet BL67 Stations TURCK s BL67 is a modular user configurable network I O system designed to allow installation of nodes containing different types and sizes of I O depending on the users needs for a particular area Featuring IP 67 protection and metal threaded connectors the BL67 can often be mounted in the physical process environment or directly on a machine without the need to plan or purchase a separate enclosure for the I O This saves planning and installation time as well as the cost of the enclosure itself The BL67 system supports several different network protocols including DeviceNet A BL67 station consists of a gateway module that interfaces to the DeviceNet system and several I O modules that interface with the physical I O in the field Different connector options are available to allow a greater level of customization to the user For more details on the BL67 system please see the section G of this catalog O ASSISTANT File Edit Station Online View Extras Options Image Process Image Parameter Diagnostics Comment 42 catalog bl57 devicenet Pos 6 BL67 PF 24VDC Bi Pos 7 BL67 16D0 0 14 P iB Pos 8 BL67 4D0 24 P
73. B Channel 2 LSB EN Channel 3 MSB Channel 3 LSB EG eM 0T A TTT Risi TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F98 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products LH DeviceNet Temperature Input Stations Rugged Fully Potted Stations e Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus sensor currents from Up Power Distribution Inputs Ug Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon SDNB 40A 0004 SDNB 40A 0009 Diagnostics Physical e One LED indicates an I O fault for the entire station C e LEDs to indicate status of DeviceNet communication 9 138 63 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout 5 4 Diagnostic LEDs 1 Shield 2 V i 3 V 4 CAN H 5 CAN_L 1 0 connectors Aux Power Power LEDs UB Bus InputPower UL OutputPower Power connectors 1 181 30 0 F99 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 07
74. B FT4 BK RD PVC BU WH PE 13 7 mm 540 in None NEC AWM 2 15 AWG 3 44 Ohms 2 18 AWG 7 06 Ohms Foil Braid CEC AWM 1 11 A B FT1 BK RD PVC BU WH PE i 18 AWG Indicates length in meters Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths t See page A7 for flexlife and weldlife performance t Zero Halogen to DIN VDE 0472 part 815 IEC 60754 1 Industr A Bulk Cable Part Number Weight 300 M RB50633 M 94 Ibs RB50652 M 122 lbs RB50793 M 168 lbs RB51038 M 150 lbs Halogen Free RB51106 M 157 lbs flexlife 10 9 RB51231 M 110 lbs flexlife weldlife TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet Media G6 TURCK Network Media Products DeviceNet Cable Cordset Selection Matrix Pin Male Socket Female amp UE ng RSM WSM RKM WKM 4 RSM 57x M WSM 57x M RKM 57x M WKM 57x M Bare 1 cm RSM RSM 57x M RSM WSM 57x M RSM RKM 57x M RSM WKM 57x M RSM 2 WSM WSM 57x M WSM RKM 57x M WSM WKM 57x M WSM 3 RKM RSC WSC 4 2 c O RSC 57x M RSM RSC 57x M Pin Male WSM RSC 57x M
75. BK RD P P P NEC AWM CEC AWM 1 11 A B FT1 2 16 AWG BK RD Indicates length in meters 6 7Ohms 2 20AWG 10 40hms PVC Light Grey 14 9 mm 585 in BU WH E h Aluminum Armor 4 1 Ohms PV BU WH VC 5 2 Ohms 2 20 AWG VC BU WH VC cC Jacket Drain Wire Blue Figure A White Pata Black 4 r Red ower Foil Shield Braid Shield Jacket Aluminum Armor Inner Jacket Drain Wire Blue Dit Figure B White ata Black Red Power Foil Shield Overall Foil Shield Bulk Cable Part Number Weight 300 M Material Color Nominal O D Type Drain Wire 2 20 AWG PVC Light Grey Foil 8 4 mm 330 in 20 AWG RB50721 M 65 lbs 11 2 Ohms PE 10 4 Ohms PE 10 4 Ohms PE P RB50876 M 71 lbs flexlife 10 9 PVC Light Grey 2 20 AWG BU 8 9 mm 350 in WH RB50877 M 60 Ibs flexlife 10 PUR Light Grey 8 4 mm 330 in RB50859 M 101 Ibs armorfast RB51235 M 95 Ibs flexlife weldlife Foil Armor 20 AWG 2 20 AWG Foil Spiral None 10 4 Ohms TPE Charcoal Grey PE 10 mm 394 in Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths See page A7 for flexlife and weldlife performance G5 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way S
76. CB E DeviceNet Media Male eurofast solder FSFDL 57 cups Nickel Plated CuZn Male eurofast right or Stainless Steel angle PCB pins 250V 4A 40 to 105 C WFS 57 PCB Female eurofast PCB pins FKFD 57 PCB Female eurofast solde FKFDL 57 cups See pages G73 G74 for dimensional drawings Standard housing material is nickel plated brass FKFD FKFDV indicates 316 stainless steel Panel Cutout Board Layout reference only Panel Cutout Board Layout reference only FKFD FSFD FKFD FSFD WFS WFS 9 073 91 de 098 2 5 TYP 9 051 61 3 m 9 602 15 3 E LET 8 9 0 500 12 7 5 600 15 2 535 13 6 eter 950 LI 098 2 5 TYP 200 5 Jede 051 1 3 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G68 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products minifast Male Receptacles 23 B i 01 142 29 0 Il 1 000 25 4 RSF 14 5 Page G62 RSF M20 Page G62 27 1 043 26 5 prem 25 1 394 10 0 A 1 2 14NPT a 91 142 29 0 1 000 25 4 RSF NPT Page G62 G69 pe ANO il lal I 1 jj 61 409 35 8 RSF 14 75 Page G62 26 1 043 26 5 394 10 1 2 1 d na 0 988 25 1 91 142 29
77. DeviceNet Serial Interface Stations Rugged Fully Potted Stations Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical Operating Current 75 mA from U Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire station LEDs to indicate status of DeviceNet communication SDNB 10S 0002 SDNB 10S 0004 CE 0 138 93 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout Diagnostic LEDs eurofast Male 4 1 Shield 5 2 V 3 V i gt 6 889 175 0 4 CAN H REF 5 CANL C3 1 0 connector Power LEDs UB Bus InputPower 1 Ust UL OutputPower 2 U Power 3 Gnd connectors 4 Gnd 1 181 30 0 F107 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A memme o fr fr fen soso fo o9 fr fee ss Input Output Connectors E DeviceNet Ground Mating cordset Mating cordset RK 4 5T RS 4 5T RK 4 5T RS 4 5T I O Data Map 1 Eu Serial Interface St
78. E Pos 7 BL20 E 1SWIRE Pos 8 BL20 PF 24VDC D H E Pos 3 BL20 16D0 24VDC 0 54 P Pos 10 BL20 PF 120 230VAC D amp Pos 11 BL20 2DI 120 230VAC 8 Pos 12 BL20 2D0 120 230VAC 0 54 Pos 13 BL20 PF 24VDC D BA Pos 14 BL20 441 1141 Pos 15 BL20 241 THERMO PI amp Pos 16 BL20 1A0 I 0 4 20MA mm Pos 17 BL20 1CNT 24VDC B 8 8 8 Bl 8 x 3 on 1a 1 4 15 1 m 8 Offline C Online A C Online RAW Ready nclute Engineering DeviceNet TURCK s I O Assistant software package is used to configure the BL20 system TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet F120 TURCK Industrial I O DeviceNet Products DeviceNet DeviceNet to AS interface Gateways AS I systems can be easily connected to a higher level network such as DeviceNet through a gateway master The gateway acts as a master to the AS I system s and a slave to the DeviceNet system mapping all of the AS I data for DeviceNet in a single block For AS I specifications and ratings details see section E of this catalog DeviceNet System Gateway is the Slave AS I System Gateway is the Master F121 TURCK Inc 3000 Campus Drive Min
79. M4 2x NOT INCLUDED MOUNTING SCREW 8 M4 2x NOT INCLUDED Pinouts eurofast Industr A p 43 5 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com gt E DeviceNet Media G38 TURCK Network Media Products DeviceNet eurofast Passive Multi Port Junctions Rugged Fully Encapsulated Enclosure For Connecting I O in Concentrated Areas Bus In Bus Out Eliminates Need for Splitter Tee Suitable for Outdoor Applications JBBS 57 E801 Die cast aluminum enclosure JBBS 57 E803 8 port Junction Bus in bus out straight 7 8 16UN minifast through ports Eight device ports with M12x1 eurofast connectors JBBS 57 E821 Fiberglass G39 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Industr A Specifications Anodized Aluminum Fiberglass Ni
80. N minifast connectors G35 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Industr A Specifications Fiberglass Nickel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K 250 V 9A 40 to 75 C 22 to 167 F S PI Dimensions p Qo 6 Port m 2 520 64 0 1 417 36 0 MOUNTING SCREW 8 M4 2x NOT INCLUDED Pinouts minifast TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G36 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet eurofast Passive Multi Rugged Fully Encapsulated Enclosure For Connecting I O in Concentrated Areas Bus In Bus Out Eliminates Need for Splitter Tee Suitable for Outdoor Applications JBBS 57 E401
81. Net Products DeviceNet Standard Input Output Stations FDNP S0404G TT FDNP S0808G TT FDNP CSG88 TT FDNP XSG16 TT FDNP S1204H TT 0149 Not FM Approved CE Rugged Fully Potted Stations Auxiliary Powered IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical e Operating Current lt 75 mA plus applicable input currents from DeviceNet Sensor Current lt 700 mA total from DeviceNet except FDNP CSG and FDNP XSG per input Output Current See table on facing page Power Distribution Inputs DeviceNet power supply except FDNP CSG and FDNP XSG from Auxiliary supply Outputs Auxiliary power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates fault for entire station FDNP CSG88 TT maps one bit for all inputs and one bit for each output point Diagnostics Physical One LED indicates fault for entire station T Fo 5 LEDs to indicate status of DeviceNet communication Auxiliary Power Aux Power Pinout co ca ci c5 1 Viuxt 2 Pass thru 8 659 220 0 eee 3 Pass thru
82. Network Connector Address x Switches DeviceNet Pinout eurofast Male 4 5 Diagnostic Ds 6 889 175 0 REF 1 0 connectors Aux Power Power LEDs UB Bus InputPower UL OutputPower Power J connectors 1 181 30 0 F91 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A sucios a forfo ee l iebet fos L1 Input Output Connectors Mating cordset PSG 4M I O Data Map 1 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F92 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet TURCK Industrial I O piconet Products Output Stations SDNB 0008D 0006 SDNB 0008D 0002 CE 6 889 175 0 REF F93 MET Boss Small Footprint Automatic Baud Rate Sensing Rugged Fully Potted Stations C IP 67 Protection Electrical e Operating Current 75 mA from Uy e Output Current See table on facing page from U Power Distrib
83. Output Connectors Y 2 2 r Q 6 1 In 5 2 Out d 3 AUX E 1 4 SCI 3 8 5 x SC1e 2 6 SC2 7 SC2 Mating cordset 3 AUX RSC RKC E80 M I O Data Map 1 I O Data Map 2 NESST Lo jus A ES m pen Pe pus qus ala oo 1 1 L 41 d lon 1 TI lee TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F64 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet DeviceNet Master e Used to Manage a Sub Network Manages 8 nodes on Sub Network Electrical BusPower 11 30 VDC e Current Consumption 125 mA Slave 30 mA Master LED Indication Slave Network Status Flashing Green Ready for connection Green Established connection Flashing Red Connection time out e Master Network Status Flashing Green Ready for connection Green Connected to all stations Flashing Red Time out with one or more stations Red Connection not possible Adjustments Slave Side Network address 0 63 via rotary switches Master Side Node count 0 8 via rotary switches FDN MSTR 1220 e Master Baud Rage 5 6 7 5 125 K 672250 K 7 500 K CE G Connections e BusLine 5 pin minifast connectors Housing Material Glass filled nylon with nickel plat
84. Q C F39 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Fosse es a fel DeviceNet Input Connectors Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T I O Data Map 1 I O Data Map 3 ISS o fis Jra re 11 ro ous 5 f ft to I O Data Map 2 pe Pr fase e pe pa e ps aa o 1 7 1 6 1 5 ra 1 3 12 1 2 1 0 Eneas ME Es TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F40 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products Boss Compact Housing Standard Output Station Rugged Fully Potted Stations Automatic Baud Rate Sensing P 67 IP 68 IP 69K Protection Electrical Operating Current 75 mA plus total of all output currents from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Outputs DeviceNet power supply Mechanical e Opera
85. REF Rear removable terminal present on FDNL S1204H 0142 only F23 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A N an E DeviceNet M HA amp B Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T Splitter VBRS 4 4 2RK 4T SIGNAL PIN 6 PE 24V USI LEAD SIGNAL 24V US2 1 24V US2 0 v USI HE I 2 Ov US1 US2 Q ovs 2 5 LG fo sr us Us CAN high 12 4 Us CAN high al Us CAN tow 17 5 s aa tes E KSR2 9 6 KSR2 KSR1 7 KSR1 A 8 8 o Us COM 9 e A of Devnet high E 11 N Devnet low 12 B RBST 13 m I O Data Map 1 o rz 1 6 15 1 4 123 1 2 1 1 1 0 pt press ratio 19 18 EN o os o o1 oo TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F24 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Produc
86. REF i 7 362 187 0 C3 FDNL T DeviceNet eurofast Pinouts Address Doto Rote Switch A DS 1 Shield 2 V Network Ga nnect of a e 4 CAN H Ground Connection 5 CAN L 0 213 05 4 1 654 42 0 MOUNTING HOLE 2 362 60 0 e REF F13 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr ET ES D DeviceNet Input Connectors Mating cordset Mating cordset RK 4 4T RS 4 4T Sensor with dual outputs RK 4 4T RS 4 4T Two sensors RK 4 5T RS 4 5T Splitter VBRS 4 5 2RK 4T S818 I O Data Map 1 I O Data Map 2 o 17 1 6 15 1 4 123 1 2 1 1 1 0 o 17 16 15 1 4 1 3 1 2 1 1 1 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F14 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Stations Rugged Fully Potted Stations Rotary Address Switches IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operatin
87. RKM RSC 57x M RKM RKM 57x M RKM WKM 57x M Socket Female WKM WKM 57x M WKM RSC 57x M 4 WKM uw 7 cUm RKC 8 RSC RSC 57x M Pin Male Socket Female See pages G11 G12 for dimensional drawings Indicates length in meters x Indicates cable type Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths For stainless steel coupling nuts change part number RSM to RSV WSM to WSV minitas mol eurofast Female 1 Bare Shield Drain Wire ea 2 Red Voltage ry 3 Black Voltage 4 White CAN_H 5 Blue CAN L G7 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust DeviceNet Cable Cordset Selection Matrix Pin Male Socket Female Socket Female Socket Female WSC RKC WKC S RKFP FSFD FKFD WSC 57x M RKC 57x M WKC 57x M RSFP 57x M RKFP 57x M FSFD 57x M FKFD 57x M RSM WSC 57x M RSM RKC 57x M RSM WKC 57x M RSM RSFP 57x M RSM RKFP 57x M RSM FSFD 57x M 57x
88. Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet E connect Cable Cordset Selection Matr Pin Male Socket Female i Pin Male ib 151 Ed ili RKFP FSFD FKFD WSC Exx M WKC Exx M RSFP Exx M RKFP Exx M FKFD Exx M RSM WSC Exx M RSM FSFD Exx M WSM WSC Exx M RKM WSC Exx WKM WSC Exx M WSC WSC Exx Exx M 7 E miniati Pimouts miis euros Pimouts eurofast 1 BK IN 2 WH OUT Female 3 BN AUX 4 RD SC1 5 WH RD SC10 6 OR SC2 7 WH OR SC2c 8 BU AUX tM kand ha hanen fa fia fa Erud an Foti fa t m Female 1 BN AUX 2 RD E1L 3 OR E2L 4 BU AUX gt ot F55 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A E connect minifast Cordset and Receptacle Connector Dimensions Specifications Overmold PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 300 V
89. T on E 10 1 380 35 1 E 2 585 65 7 REF 1 959 49 8 e CBC5 Page G9 BK52C Black Voltage Blue CAN L B White CAN H Red Voltage 1 2 3 4 5 are Shield Drain FSFD CBC5 57x M FKFD CBC5 57x M Thin Cable Only P 4 Page G9 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com 1 053 26 7 REF E DeviceNet Media G10 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet minifast Cordset and Receptacle Connector Dimensions Specifications Overmold PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 300 V Rated Current 9A Ambient Temperature 40 to 75 C 22 to 167 F 1 3 ENG 68 5 mo 27 0 2 559 65 0 Sid 27 0 7 8 16UN 7 8 16UN RSM Pages G7 G10 RKM Pages G7 G10 2 4 2 047 52 0 Eum 520 1 720 43 7 1 583 40 2 E e 01 024 26 0 91 024 26 0 7 8 16UN 7 8 16UN WSM Pages G7 G10 WKM Pages G7 G10 9 10 1 256 31 9 106 28 1 1 039 a 5 ino 890 22 i M30x1 5 Ul ul 7 8 16UN ES
90. TING HOLE 2 362 60 0 ax REF F19 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A E DeviceNet Mating cordset RK 4 4T RS 4 4T Splitter VB2 RS 4 4T 1 2RK 4 4T S651 I O Data Map 1 pepe pep epp p o 17 r6 15 tee 1 3 r2 1 1 1 0 Colas Les gt lt s Out o 0 7 0 6 0 5 0 4 0 3 0 2 0 1 0 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F20 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Input Output Station Rugged Fully Potted Stations DeviceNet Powered I O IP 67 IP 68 IP 69K Protection Sinking Outputs Electrical Operating Current 75 mA from DeviceNet Sensor Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F
91. TURCK Industrial I O DeviceNet Products DeviceNet F1 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet System Description DeviceNet is a low cost communications protocol that eliminates hard wiring and connects industrial devices such as limit switches photoelectric sensors valve manifolds motor starters process sensors bar code readers variable frequency drives panel displays and operator interfaces to a network DeviceNet s direct connection provides improved communication between devices as well as important device level diagnostics not easily accessible or available through hard wired I O interfaces DeviceNet is based on the Controller Area Network CAN broadcast oriented communication architecture CAN uses a bus arbitration method CSMA BA that assures the highest priority message always gets use of the bus in the event of a data collision The DeviceNet protocol further defines message priorities such that I O messages are given top priority and configuration messages have lower priority A DeviceNet network supports up to 64 nodes and virtually an unlimited amount of I O The bus uses a trunkline dropline topology where bus pow
92. Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz FDNQ 4A1 1 T Material C Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Physical e LEDs to indicate status of DeviceNet communication 1 0 connectors 5 829 148 1 REF 5 376 136 6 Address Input mode Switches Network o connectors DeviceNet minifast Pinout Ground connection 1 Shield 2 V 9 213 95 4 3 2 V 1 654 42 0 MOUNTING HOLE u 2 362 60 0 idi FSF REF 5 CAN L F47 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr FDNQ 4AI I T fel DeviceNet Loop Powered Isolated DeviceNet Powered Transducer Mating cordset Isolated Loop RK 4 5T M RS 4 5T 5653 Loop Powered RK 4 5T M RS 4 5T LPS S653 Note The LPS in the part number indicates that the cord jumpers pin 3 to pin 4 on the male side to the signal to the station common Pin 3 is not connected at the female end Applications TURCK Sensors LU RK 4 4T RS 4 4T S1118 LI RK 4 4T RS 4 4T S1120 I O Data Map
93. URCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet eurofast Conduit Adapters Gasket and Mounting Screws Provided Same Housing Style for Single or Double Port 1 870 47 5 E DeviceNet Media Attaches to standard conduit i body for transition to 5 wire BCA 57 E123 M12x1 eurofast connector Crouse Hinds 3 4 Form 8 Mark 9 or equivalent Female Nylon Housing Stainless Steel Receptacle Housing 1 870 47 5 250 V 4A 40 to 75 C Attaches to standard conduit body for transition to 5 wire us BCA 57 E223 M12x1 eurofast connector 131 3 Crouse Hinds 3 4 Form 8 Mark 9 or equivalent Standard receptacle housing material is stainless steel for nickel plated brass change part number from M223 to M224 1 port Wiring Diagram 2 port Wiring Diagram Ah N s A S gt E a e TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G54 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK
94. a 800 258 9200 www stevenengineering com E DeviceNet TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Output Rugged Fully Potted Stations Input and Output on Same Station IP 67 IP 68 IP 69K Protection Connector Automatic Baud Rate Sensing Electrical Operating Current 100 mA plus sum of I O currents from DeviceNet Sensor Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material FDNL CSG88 T Connectors Nickel plated brass stainless steel available on request FDNL CSG88 T V Housing Nylon 6 other materials available on request Diagnostics Logical C G lt gt e Open short circuit status mapped to DeviceNet I O table one bit indicates a fault for all inputs one bit for all outputs Diagnostics Physical One LED indicates I O fault for entire station LEDsto indicate status of DeviceNet communication I f C4 1 0 connectors 7 756 197 0 REF 7 362 187 0 c3 er Address DeviceNet minifast Pinout Switches 1 Shield Network connectors B V gt Ground 3 V 7 connection 4 CAN H 0 213 05 4 5 CAN_L 1 654 42 0 MOUN
95. amp Output F17 F27 F33 F37 F43 F45 Input amp Output F51 F64 F65 Input amp Output Input amp Output Input amp Output F5 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr DeviceNet AIM Stations i TURCK s Advanced I O Module AIM DeviceNet stations are extremely rugged stations designed for machine mounting These stations allow easy connection of standard I O devices such as sensors limit switches valves and pilot lights to a DeviceNet network typically without a protective enclosure This is made possible by epoxy filled station housings all metal connectors and visible rotary address switches among other things Specifications Mechanical TURCK DeviceNet AIM stations are designed for machine mounting with no separate enclosure or housing necessary Quick disconnect capability combined with an epoxy filled housing creates an extremely durable station that can be mounted in most industrial environments Detailed environmental specifications are as follows Housing material Glass filled nylon Connector material Nickel plated brass Protection level NEMA 1 3 4 12 13 IEC IP 67 Operating temperature SE station
96. an Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Input Output Station Rugged Fully Potted Stations e DeviceNet Powered I O IP 67 IP 68 IP 69K Protection Sinking Outputs Electrical Operating Current 75 mA from DeviceNet Sensor Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g amp 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request FDNL S1204H 0142 Housing Nylon 6 other materials available on request FDNL S1204H 0153 Diagnostics Physical C G e One LED indicates a fault for the entire station e LEDs to indicate status of DeviceNet communication DeviceNet multifast Pinout 1 0 connectors 7 756 197 0 REF 7 362 187 0 Terminal dod 1 OV us1 10 KSR1 2 0V US2 11 3 24 US2 12 Us CAN high Switches 4 24 USI 13 Devnet high PE 14 Devnet low Network 6 15 RBST connectors 7 Us COM 16 UL la ub SUSAN ION 9 KSR2 0 213 95 4 1 654 42 0 MOUNTING HOLE x 2 362 60 0
97. an Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products LH DeviceNet Input Station Rugged Fully Potted Stations Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus sensor currents from Up Sensor Current 500 mA total of all sensors from U Power Distribution O Inputs Ug Power supply mv g La Mechanical Of e Operating Temperature 0 to 55 C 32 to 131 F Protection IP 67 mO Vibration IEC 68 part 2 6 E Q Material Connectors Nickel plated brass SDNB 0800D 0008 Housing Nylon CE Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 0 138 93 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout Diagnostic eurofast Male LEDs 1 Shield 5 x 2 V 3 V i 3 6 889 175 0 4 CAN H REF 5 CAN L 1 0 connectors Aux Power Power LEDs UB Bus InputPower UL OutputPower E Power ZF connectors 1 BT 2 U 1 181 30 0 3 Gnd 4 Gnd F89 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 O
98. and Thick Cable minitas Pis eurofas Female 1 Bare Shield Drain Wire curs li if 2 Red Voltage 3 Black Voltage 4 White CAN_H 5 Blue CAN_L G9 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation DeviceNet Open Connector Cordset Selection Matrix Industr A Socket Female Socket Female Socket Female A ba gt RIO valg WSC RKC WKC WSC CBC5 57x M RKC CBC5 57x M WKC CBC5 57x M RSFP CBC5 57x M WSC BK52C 57x M RKC BK52C 57x M WKC BK52C 57x M RSFP BK52C 57x M RKFP BK52C 57x M FSFD BK52C 57x M FKFD BK52C 57x M Thin and Mid Cable Only Thin Mid and Thick Cable See pages G11 G12 for dimensional drawings Indicates length in meters x Indicates cable type RKFP CBC5 57x M Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths Specifications Housing PA Nylon Protection NEMA 1 and IEC IP 20 Rated Voltage 250V Rated Current 12 8 Ambient Temperature 40 to 75 C 22 to 167 F 13 14 450 11 4 F 2 488 63 2 REF
99. atus 5 Ets Oe rt stats Lo Serial Interface consi 6 mus Note Five data byte configuration shown Can be configured for 3 4 or 5 data bytes Consult user manual for details TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F108 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK BE ae Industrial I O piconet Products I DeviceNet SSI Station Rugged Fully Potted Stations Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus sensor currents from Up Mechanical Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire station LEDs to indicate status of DeviceNet communication SDNB 10S 0005 CE 9 138 93 5 MOUNTING HOLE 2x Network Connector Address DeviceNet Pinout Switches eurofast Male 1 Shield 5 4 Diagnostic LEDs 2 V 3 V 1 3 4 CAN_H 5 CAN_L VO connector e unused 175 0 6 889 REF Aux Power C1 1 0 connector Power LEDs _ gt UB Bus InputPower 1 U Y UL OutputPower 2
100. ber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber CL I Div 2 Groups A D see TURCK drawing N1 2 400 T6 Ta 70 C G47 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Specifications Housing PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane or POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 300 V Rated Current 9A Ambient Temperature 40 to 75 C 22 to 167 F E DeviceNet Media i Dimensions 4 port 6 port GROUND TERMINAL GROUND TERMINAL WITH CASE OR ISOLATED WITH CASE OR ISOLATED GROUNDING OPTIONS n GROUNDING OPTIONS 8 742 222 0 8 742 222 0 MOUNTING SCREWS 1 4 M6 SOCKET HEAD CAP 2x NOT INCLUDED 1 776 45 1 Pinouts MOUNTING SCREWS 1 4 M6 SOCKET HEAD CAP 2x NOT INCLUDED 1 776 45 1 1 280 32 5 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G48 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengi
101. ce 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A DeviceNet Repeater The REP DN is a potted fully connectorized rugged repeater that can be mounted directly on the machine It is designed for use on any Controller Area Network CAN including DeviceNet Network segments connected by a repeater are considered separate physical networks trunk and drop lengths for each segment are determined as if the other segments are not there but one logical network addresses cannot be duplicated the scanner and configuration tools work as a single network A repeater does not consume an address and is invisible to all the other devices on the network A repeater does not have an EDS file The REP DN repeater can be used to extend either the trunk or drop lines and to isolate power supplies on networks with multiple supplies There is no limit to the number of repeaters that can be used on one network A repeater s baudrate is set via a rotary switch The baudrate on each side of the repeater must be the same as different rates would cause the slow side to be overloaded with messages from the fast side When a message is repeated a 2 ms delay is introduced This is typically insignificant compared to the overall scan time of the network If more than four repeaters are used in series the interscan delay may need to be increased DeviceNet 500 M 125 k Rep
102. ch I O point on the station This LED indicates Off Point is off Green Point is on Amber Point is in open circuit state advanced diagnostic stations only e Red Point is in short circuit state advanced diagnostic stations only For SE style group diagnostic stations there is also a single bit communicated to the controller for diagnostic purposes This bit is on if any input on the station is in the short circuit condition and off if all inputs are operating normally LX style extended diagnostic stations indicate the diagnostic status of each I O point on the station with an extra bit to indicate if the point is short or open circuited These diagnostic bits can be disabled via the EDS parameter settings I O Data Map 1 Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 0 I 7 I 6 I 5 I 4 I 3 I 2 I 1 I 0 1 ISS 7 ISS 6 ISS 5 ISS 4 ISS 3 ISS 2 ISS 1 ISS 0 In 2 105 7 10s 6 105 5 105 4 105 3 105 2 I05 1 105 0 extended diagnostic 3 0S 7 0S 6 0S 5 OS 4 OS 3 05 2 OS 1 0S 0 4 APS Out 0 0 7 0 6 0 5 0 4 0 3 0 2 0 1 0 0 Connecting Devices to an AIM Station AIM stations typically provide a eurofast M12 connection for each I O point Standard TURCK I O cordsets can be used to connect physical devices in the field to the AIM station Some AIM stations specifically those with I
103. ckel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K 250 V 4A 40 to 75 C 22 to 167 F Dimensions 8 Port je 3 669 93 2 REF 2 520 64 0 al T 7 303 185 5 6 831 173 5 MOUNTING SCREW 8 M4 2x NOT INCLUDED Pinouts eurofast TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com G40 E DeviceNet Media TURCK Network Media Products DeviceNet eurofast Passive Multi Rugged Fully Encapsulated Enclosure 55 y P For Connecting I O in Concentrated Areas Bus In Bus Out Eliminates Need for Splitter Tee Suitable for Outdoor Applications 10 port Junction NUBU NUDSDU NU MU MO BU NUO NO bU Die cast aluminum Busin bus out straight 7 8 16UN minifast through ports JBBS 57 E1001 enclosure Ten device ports with M12x1 eurofast connectors NU BU NUA NU AU 2 NU bU NMUO BU NUKU G41 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office
104. co CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A meae ve ax me x f LS f gt ess se fa 88 fx ft te E DeviceNet Input Output Connectors Aux Aux 2 11 08 _ 1 09 1 010 On 1 02 os PAUX 3 Aux 1 01 Wastes ernie Indicates I O groups which can be powered from separate Aux Power supplies if desired I O Data Map 1 I O Data Map 2 o 1 7 1 6 1 5 1 4 1 3 1 2 1 1 ro o 17 1 6 1 5 1 4 1 3 1 2 11 ro e es fost gt gt gt LzbseibwslI I 1 1 1 1 4 o pos 0 6 os 64 63 62 vi oo Out o is ous 0 13 0 12 9 11 0 10 o 0 8 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F80 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Enclosure Mounted In Cabinet I O Ideal for Retrofits Input Output Stations IP 20 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus applicable I O currents from bus power Input Current 700 mA sum
105. cuit status mapped to DeviceNet I O table one bit indicates a fault for all inputs and one bit indicates a fault for all outputs Diagnostics Physical e LED to indicate status of DeviceNet communication 2 854 72 5 MOUNTING HOLES 0 157 04 0 2x ADDRESS SWITCHES I O TERMINAL BUS 2 736 69 5 TERMINAL DeviceNet Connector a v SHD v la 3 209 81 5 l 728 18 5 CAN H CAN L F77 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A ip Gp Tata Aul lll meae s ef x of fo CI me x CO EG EC Input Output Connectors E DeviceNet FS FS 2 CSSSSSSSSS V 1 00 1 011 021 03 la lo lg ly V V 09 O 02 03 b Hh b l Vt Note I O to I O can be used as inputs or outputs I O Data Map 1 e Pr Ts ra pa Pres Pres EE I O Data Map 2 o na 16 126 124 1 3 1 2 1 1 to o tes os 1 3 1 2 1 1 1 0 es es ee a To ou o oso 001 oo gua o os oz o1 oo TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F7
106. der from 1 to 8 The baud rate for this network is determined by the rotary switch setting on the FDN MSTR The slaves on the subnet are independent of the main DeviceNet network Hence a node 4 on the main network will conflict with a node 4 on the sub network I O Data Map 1 The Input data size is 64 bytes where the first two bytes are reserved for status information from the FDN MSTR Bit 9 Bit 8 Bit 6 9 x pe os ew eee alos ate 2 NN ESN 2 RSN 7 Node Address 1 Input Data Node Address 2 Input Data EN Node Address X Input Data The Output data is 64 bytes E Node Address 1 Output Data Node Address 2 Output Data Oul Node Address 3 Output Data N Node Address X Output Data IC Invalid configuration of node missing 0 means OK 1 means error ESNX Error on sub node X 0 means OK 1 means error communicating with node RSNX Registered sub node X 0 means no node is present 1 means that node is present The data table for the Input and Output show the last Byte as N This N is variable depending on the total amount of data generated by all the nodes on the deviceNet sub network However the maximum for both the Input and the Ouptut are 64 bytes TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F66 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area
107. e Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F12 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Deluxe Input Stations Rugged Fully Potted Stations Rotary Address Switches IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current lt 100 mA 8 in or 140 mA 16 in plus sum of input currents from DeviceNet Sensor Current 80 mA per input from DeviceNet Power Distribution Inputs DeviceNet power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 e Vibration 50 g 10 500 Hz Material FDNL L0800 T Connectors Nickel plated brass stainless steel available on request FDNL L0800 T V Housing Nylon 6 other materials available on request FDNL L1600 T Diagnostics Logical FDNL L0800 C e Open short circuit status mapped to DeviceNet I O table one bit each per I O FDNL L1600 C point lt gt G Diagnostics Physical Individual LED to indicate open short circuit for each channel e LEDs to indicate status of DeviceNet communication C4 DeviceNet minifast Pinouts m 1 Shield 22 V 1 0 32 V connectors 4 CAN H 7 756 197 0 ez TS 5 CAN L
108. eNet Pinout Address Switches eurofast Male 4 5 1 3 4 CAN H Ground 5 CAN L 1 Shield 2 V etwor connectors 3 V connection 0 213 05 4 1 654 42 0 MOUNTING HOLE 2 362 60 0 A REF F43 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr FDNQ XSG08 T DIE FDNQ CSG44 E DeviceNet Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter Splitter VB2 RS 4 4T 1 2RK 4 4T 5651 VBRS 4 4 2RK 4T G Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter Splitter VBRS 4 4 2RK 4T VBRS 4 4 2RK 4T I O Data Map 1 I O Data Map 3 Lo tes oso 1 1 1 0 o 127 1 6 1 5 1 4 1 3 12 1 1 1 0 ou 1 1 1 1 1 1 19 LEDs T9 1 11 1 1 Oni o vs es os es e o o 95 a SES LTTE esee em icit ec pe pepe pes es pe I O Data Map 2 o res os 1 3 re 1 1 vo A ol tT ojo oa oo TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F44 Courtesy of St
109. each station can be used Common power ratings for AIM stations include Bus DeviceNet Voltage 11 26 VDC Aux Power Voltage 24 VDC nominal supported stations TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F8 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Input Voltage 13 26 VDC From DeviceNet supply Input Signal Current each input OFF 2 mA ON 3 0 3 4 mA nominal 24 VDC Input Delay 2 5 ms Addressing DeviceNet stations must have a network address for communication The address for AIM stations may be set via the visible rotary switches under the clear plastic cover on the front of the station The pair of switches represents the address as a decimal number the left switch being the 10 s multiplier and the right switch the 1 s multiplier To program the station rotate the switches with a small slotted screwdriver until the arrows on the switch point to the appropriate numbers for the chosen address Some stations LX style with extended diagnostics have a third switch This switch is used to set the communication baud rate for the station When set to the AUTO position the station automatically senses the baud rate of the network SE style stations only
110. eater Configurations Network Segment B Extended Trunk Line Repeaters are connected in series to extend the trunk line The total delay is 2 77 RSM 57 TR2 To terminate left side of network B ms multiplied by the number of repeaters REP DN DROP does not require a separate power supply on segment B If a separate power supply is desired it must be attached using a Power T RSM RKM 57 WSM 40 PST recommended RSM 57 TR2 Network Segment A To terminate left side of network A 500 M 125 k Extended Drop Line 500M Repeaters are connected in parallel to extend the drop length The overall network delay is 2 ms RSM 57 TR2 because there is only one To terminate drop C repeater between the scanner on RSM 57 TR2 the trunk and any other device To terminate drop B Network A passes through repeater Do Not Create a Ring 500 M 125 k While a repeater can be used to create very large and complex networks some configurations are not permitted If a ring is created both sides of a repeater are connected to the same network the repeater will continuously repeat to itself causing the network to overload TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F68 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK
111. ed brass connectors Enclosure NEMA 1 3 4 12 12 and IEC IP 67 68 and 69K Operating Temperature 25 to 70 C 13 to 158 F Network connectors Segment B 8 661 220 0 REF 8 267 210 0 Address and Dota s PT Rote Switches DeviceNet minifast Pinout connectors 1 Shield Segment A 2 V 3 V 0 213 05 4 4 CAN H Ti 1 654 42 0 MOUN me HOLE 5 CAN L 2 362 60 0 REF Note each segment has one male and one female connector F65 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A The FDN MSTR is a DeviceNet master used to manage a subnet off of the main DeviceNet network Main DeviceNet Network i The subnet to the FDN MSTR is a DeviceNet network terminated on both ends and is limited to 8 nodes with addresses that must be in sequential order from 1 to 8 The baud rate for this network is determined by the rotary switch setting on the FDN MSTR Master Side B DeviceNet SubNetwork m DeviceNet Node 1 Node 2 Node 3 Node 4 Node 5 Node 6 Node 7 Node 8 The subnet to the FDN MSTR is a DeviceNet network terminated on both ends and is limited to 8 nodes with addresses that must be in sequential or
112. el Contact Carrier Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 30V 1 5A 40 to 75 C 22 to 167 F Rated Current Ambient Temperature JBBS 57 FS P424Z p 3 386 86 0 138 3 5 TYP l 3 110 79 0 138 3 5 TYP 898 22 8 787 20 0 1 181 30 0 9 138 03 5 MOUNTING HOLE M3 SOCKET HEAD 12mm MINIMUM LENGTH 2x 394 10 0 669 17 0 Mast Cisano 984 25 op 630 16 0 477 4 5 m 177 a 669 17 0 eurofast Bare Shield Drain Wire Red Voltage Black Voltage White CAN_H Blue CAN_L N C picofast only TURCK Inc 138 3 5 TYP Industr A PUR Polyurethane or POM Nylon picofast POM Nylon eurofast JBBS 57 FS P424M 3 386 86 0 3 110 79 0 138 3 5 TYP 898 22 8 787 20 0 1 181 30 0 9 138 03 5 906 23 0 MOUNTING HOLE M3 SOCKET HEAD 12mm MINIMUM LENGTH 2x 394 10 0 E DeviceNet Media Ba Copie m JBBS 57 FS E424 984 25 0 630 16 0 829 21 1 837 21 2 1 181 30 0 906 23 0 4 685 119 0 4 961 126 0 630 16 0 Shield Drain Wire Voltage Voltage CAN H CAN L 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G30 Courtesy
113. engineering com E DeviceNet Media G46 TURCK Network Media Products DeviceNet minifast Junction Tee Indoor Use Only for outdoor applications use JBBS family Multi Port Junction Provides a Rugged Connection to Network Devices Bus in Bus out Feature Eliminates Need for Splitter Tee 4 port Junction Tee 7 8 16UN minifast bus in bus out connections JTBS 57 M433 Four 7 8 16UN minifast device ports For nickel plated brass connectors change part number to JTBS 57 M434 4 port Junction Tee 7 8 16UN minifast bus in bus out connections Four 7 8 16UN minifast device ports For nickel plated brass connectors change part number to JTBS 57VM M434 JTBS 57VM M433 Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED indication Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber CL I Div 2 Groups A D see TURCK drawing N1 2 400 T6 Ta 70 C APPROVED 6 port Junction Tee 7 8 16UN minifast bus in bus out connections JTBS 57 M633 is Six 7 8 16UN minifast device ports For nickel plated brass connectors change part number to JTBS 57 M634 6 port Junction Tee 7 8 16UN minifast bus in bus out connections Six 7 8 16UN minifast device ports For nickel plated brass connectors change part number to JTBS 57VM M634 JTBS 57VM M633 Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED indication Lo lt 12 9 V Am
114. er CL I Div 2 Groups A D see TURCK drawing N1 2 400 T6 Ta 70 C G49 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Indust Ai Specifications Housing PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 Rated Voltage 250V Rated Current 4A Ambient Temperature 40 to 75 C 22 to 167 F Dimensions 4 port 6 port E DeviceNet Media GROUND TERMINAL GROUND TERMINAL WITH CASE OR ISOLATED WITH CASE OR ISOLATED GROUNDING OPTIONS GROUNDING OPTIONS 7 677 195 0 OE 8 742 222 0 8 742 222 0 MOUNTING SCREWS MOUNTING SCREWS 1 4 M6 SOCKET 1 4 M6 SOCKET HEAD CAP 2x HEAD CAP 2x NOT INCLUDED NOT INCLUDED 1 776 45 1 1 280 32 5 1 776 45 1 1 280 32 5 Pinouts TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G50 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Pr
115. er and communication are supplied on a single cable Bus power is 24 VDC and supplies current to operate the nodes and typically power input devices Some TURCK stations require an additional 24 VDC auxiliary power to supply current for outputs E DeviceNet DeviceNet allows peer to peer data exchange where a DeviceNet node can initiate communication with other nodes or peers and a master slave configuration in which the master node initiates all communication and all other nodes or slaves respond to the master node s requests Typical System Configuration Power Supply Q RSMCBC5 5711 1M BL20 I O System RKM 46 1M RSC CBC5 572 1M mu FDNQ S0400 T RSM RSM 5711 2M RSM2RKM 57 D C D RKM RKC 5711 1M FDNP 50404C TT BL67 I O System A typical DeviceNet system consists of the following parts A Controller e C DeviceNet Cable e E Terminating Resistors e B Power Supply D DeviceNet I O Modules or Slaves DeviceNet stations require a network master also called a scanner to interface the stations to the host controller TURCK DeviceNet stations are designed to be fully compatible with DeviceNet equipment from other manufacturers TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F2 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 8
116. er stations piconet stations are the smallest rugged I O modules available with a standard housing footprint of 30 x 175 mm They are also available with picofast M8 connectors for I O making them ideally suited for small space applications Mechanical Specifications TURCK DeviceNet piconet stations are designed to be mounted directly on machines and work cells with no separate enclosure or housing necessary Epoxy filled housing creates a durable station that allows it to be mounted in most industrial environments Detailed environmental specifications include Housing material Glass filled nylon e Connector material Nickel plated brass Protection level NEMA 1 3 4 12 13 IEC IP 67 Operating temperature 0 to 55 C The station s components are identified in the figure below DeviceNet Connector Address Switches Diagnostic LEDs I O Connectors Power Connectors F85 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Connectors DeviceNet piconet stations provide connectors for bus and I O power Unlike other TURCK DeviceNet stations piconet stations power all I O from auxiliary power Bus connector DeviceNet eurofast Pino
117. even Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Output Rugged Fully Potted Stations Auxiliary Powered Outputs Station IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 75 mA plus total of input currents from DeviceNet Sensor Current 700 mA total of all inputs from DeviceNet Output Current 500 mA per output from Auxiliary power Power Distribution Inputs DeviceNet power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 9 10 500 Hz FDNQ S0404G MM Material C GP lt gt Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates fault for entire station Diagnostics Physical e One LED indicates a fault for the entire station LEDs to indicate status of DeviceNet communication 1 Aux Power Pinout c2 minifast Male 1 0 connectors C3 5 829 148 1 REF 5 376 136 6 Address Switches Network DeviceNet Pinout Auxiliary Power connectors minifast Male
118. g Current 50 mA plus input currents from DeviceNet Sensor Current 700 mA sum of all inputs from DeviceNet Power Distribution Inputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request FDNL S0800 T Diagnostics Logical FDNL S1600 T e Open short circuit status mapped to DeviceNet I O table one bit indicates a FDNL S1600 T V fault for all inputs FDNL N0800 T Diagnostics Physical FDNL N1600 T One LED indicates a fault for the whole station FDNL S1600 E e LEDs to indicate status of DeviceNet communication cc G m 1 X a DeviceNet minifast Pinout co 1 Shield 2 V 3 V e A CAN H 5 CANL 7 756 197 0 c2 i REF 7 362 187 0 n FDNL T DeviceNet eurofast Pinouts Address Switches 1 Shield u 2 2 V Network 32 V connectors 4 CAN H me 5 CAN L 0 213 05 4 MOUNTING HOLE 4x REF F15 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Aut
119. iconet Products Counter Station SDNB 0202D 0003 CE MET Boss Rugged Fully Potted Stations Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical Operating Current 75 mA plus device currents from Up e Input Current 500 mA total of all sensors from Up e Output Current 500 mA per output from U Frequency 100 KHz Power Distribution Inputs Ug Power supply Outputs U Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 9 138 63 5 MOUNTING HOLE 2x Network Connector DeviceNet Pinout Address eurofast Male Switches 4 1 Shield 3 Diagnostic 2 V LEDs 3 V 4 CAN H 5 CANL 6 889 175 0 REF 1 0 connectors Aux Power C3 12U Power LEDs 2 U UB Bus InputPower TEL UL OutputPower 3S Gnd Power 4 Gnd connectors 1 181 30 0 F103 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automa
120. ilable on request Housing Nylon 6 other materials available on request Diagnostics Logical FDNP N1600 TT 0197 No diagnostic data CE G Diagnostics Physical L One LED indicates a fault for the entire station LEDs to indicate status of DeviceNet communication M Aux Power Pinout Auxiliary Power 1 0 connectors 8 659 220 0 REF c2 210 0 C6 8 266 c7 Address DeviceNet minifast Pinout Switches connectors 1 Shield 2 V Ground connection 3 V 0 213 05 4 CAN H 1 654 42 0 MOUNTING HOLE 5 CAN L 2 362 60 0 Ax REF F31 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Input Connectors fel DeviceNet Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T VO Data Map 1 ara o 15 r6 15 12 13 fre 12 ro TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F32 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O Device
121. imum six meter branch DeviceNet Media Standard keyway pol Bran 1 024 26 0 024 26 0 t 024 26 0 2N oY RSM 2RKM 57 1 370 34 8 2 874 73 0 REF e4 1 102 50 minifast Drop Off 01 024 CA p 26 0 Bus Line VEN Ba PUR Polyurethane ee and y ata drop L RSM 2RKM 57 KF 300V 9A 40 to 75 C Maximum six meter branch 91 024 26 0 rela Keyway facing gt keyway facing Female female 2 874 73 0 REF 1 102 28 0 minifast Drop Off 91 024 26 0 91 024 26 0 Bus Line i i T Full power and I data drop RSM 2RKM 57 KM 1 370 34 8 Maximum six meter branch zi al 91 024 26 0 Keyway facing Pinouts minifast TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G56 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Power and Diagnostic Tees Provide a Drop to Insert Power or Diagnostic Equipment 7 8 16UN minifast Connectors on Bus and Drop Lines Reverse Current Protection on Power Tap 2 874 73 0 REF e amp ze iste 28 0 01 024 26 0 Bus Power
122. ing Electrical Operating Current 50 mA plus sum of all I O currents from DeviceNet Input Current 700 mA sum of all inputs from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F e Protection NEMA 4 IEC IP 67 Material Connectors Nickel plated brass stainless steel available on request Housing Fiberglass Diagnostics Logical e One bit in I O table indicates an I O fault for inputs one bit for outputs Diagnostics Physical e LED to indicate status of DeviceNet communication 3 809 96 7 2 937 74 6 6 621 168 2 Bus Connector Address switches 123 8 1 0 connector DeviceNet eurofast Pinouts Bus Connector 1 Shield 2 V 3 V 4 CAN H 5 CAN L F115 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A pa TT Oups Dn me e fe A IC bL Input Output Connectors fel DeviceNet FS 000000999 y 1 00 1 0 1 09 1 03 l4 ls Ig ly V I O Data Map 1 oa Blank TURCK Inc 3000 Campus Drive
123. k or Threaded Connectors Available in Standard and Voltage Monitoring 4 port Junction Tee JBBS 57 FS P424Z M12x1 eurofast drop connector Four M8x1 picofast snap lock connectors 4 port Junction Tee JBBS 57 FS P424M M12x1 eurofast drop connector Four M8x1 picofast threaded connectors 4 port Junction Tee M12x1 eurofast drop connector Four M8x1 picofast snap lock connectors Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED Indication Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber JBBS 57 FS VM P424Z 4 port Junction Tee M12x1 eurofast drop connector Four M8x1 picofast threaded connectors Voltage monitoring provides low voltage 12 9 V and high JBBS 57 FS VM P424M voltage 25 6 indication LED indication Lo lt 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber J1 12345 4 port Junction Tee JBBS 57 FS E424 M12x1 eurofast drop connector Four M12x1 eurofast threaded connectors G29 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Specifications Automation Housing POM Nylon Coupling Nut Nickel Plated CuZn or Stainless Ste
124. l 125V 2A 40 to 105 C 120 Ohms 1 2 W IP 67 internal resistance 1 366 34 7 Hr TERMINATING RESISTOR 120 2 LI KT TEE MBx1 PKGM 57 TR Ti Male picofast connector Female TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G22 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Receptacles Receptacles Provide Transition from Male to Female Connectors Available for Bulkhead and Feed Through Applications 1 941 49 3 us 32 7 te 9 937 23 Nickel Plated CuZn minifast Bulkhead B QU 5 or Stainless Steel Receptacle r ren M NI lig 7 8 16un RSF RKF 57 22 300 V 9A sui i MO r i reuse Ma WockwesuER L THRUST WASHER 1 877 47 7 rir 29 4 p _ Nickel Plated CuZn eurofast Bulkhead Tug TI or Stainless Steel Receptacle Li 118177 NND FKM FS 57 M12 250v 4A Straight 40710 eec mek LOCKNUT LN M12 LOCKWASHER LW M12 IP 67 Standard housing material is nickel plated brass RSF RKF RSFV RKFV indicates stainless steel housing Panel Cutout Panel Cutout RSF RKF 57 22 FKM FS 57 M12 EH pene 3 2 0 500 12 7 062 1 6 9 875 022 2 G23 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 7
125. le 250V 4A Mates with 5 pin cordsets and receptacles PBT Black APPROX 0772 119 8 PG 9 cable gland accepts 4 8 mm cable diameter BS 8151 0 PG9 DNET s terminals 85 C 250V 4A TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G76 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Power Taps Allows Connection to Bus Line for Bringing in 12 VDC Power Available with minifast Bus Line and Drop Connectors or Terminal Connectors CAN_L 5 CAN_H 4 VE 3 Power Tap with minifast Connectors V 2 SHIELD 1 7 8 16UN minifast male to female bus connector 7 8 16UN minifast female power connector Power Tap with minifast Connectors 7 8 16UN minifast female to female bus connector 7 8 16UN minifast female power connector 1234 V V V V SUPPLY Power Tap with Terminal Connectors Terminal strip bus connectors Terminal strip power connector i 2 3 4 V V V V SUPPLY G77 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9
126. n PVC Light Grey 7 8 mm 310 in Foil Braid 22 AWG PVC Light Grey 6 0 mm 235 in Foil Data Only 22 AWG Foil Braid 22 AWG TPE Charcoal Grey 9 3 mm 365 in Foil Braid 22 AWG Part Number Weight 300 M RB50603 M 44 lbs RB50629 M 65 Ibs flexlife 10 9 RB50651 M 51 Ibs RB50764 M 26 lbs RB50994 M 50 lbs Halogen Free RB51296 M 68 Ibs flexlife weldlife TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com E DeviceNet Media Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Mid Cable Specifications Cable That Meets the Requirements of ODVA Mid or Type III Cable Provides More Flexibility When Used as a Trunk Cable Up to a Maximum Length of 300 Meters 984 Feet Maximum Trunk Length 125 Kbaud 300 meters 984 feet 250 Kbaud 250 meters 820 feet 500 Kbaud 100 meters 328 feet DCR 1000 feet AWG DCR 1000 feet Insulation Color Code Insulation 4 1 Ohms BU WH 5 2 Ohms SR PVC Approvals AWG Color Code NEC PLTC CEC AWM 1 11 A B FT4 2 16 AWG BK RD NEC PLTC CEC AWM 1 11 A B FT4 2 17 AWG BK RD NEC AWM CEC AWM 1 11 A B FT1 2 17 AWG BK RD NEC PLTC CM CEC CMG HL ABCD 2 18 AWG
127. n Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Deluxe Input Output Rugged Fully Potted Stations Auxiliary Powered I O Station IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 30 mA from DeviceNet Sensor Current 120 mA per input from Auxiliary power Output Current 0 5 A per output from Auxiliary power Power Distribution Inputs Auxiliary power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request FDNP CPG88 TT Diagnostics Logical C GR lt gt e Open short circuit status mapped to DeviceNet I O table one bit each per I O point Diagnostics Physical Individual LED to indicate open short circuit for each channel e LEDs to indicate status of DeviceNet communication Auxiliary Power C4 Aux Power Pinout 1 Vaxt 1 0 2 Pass thru connectors T 2 h o m 8 266 210 0 c3 B c7 8 659 220 0 REF Address Dota Rote Switche
128. n Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Output Rugged Fully Potted Stations DeviceNet Powered I O Stations IP 67 IP 68 IP 69K Protection Compact Housing Electrical Operating Current 75 mA plus total of all I O current from DeviceNet Sensor Current 700 mA total of all inputs from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz FDNQ S0201G T Material FDNQ CSG44 T Connectors Nickel plated brass stainless steel available on request FDNQ S0404G T Housing Nylon 6 other materials available on request FDNQ XSG08 T Diagnostics Logical FDNQ CSG44 E e Open short circuit status mapped to DeviceNet I O table one bit indicates fault for entire station 60201G T has one dedicated bit to indicate a fault for Not CSA Approved the output point as well CE G Diagnostics Physical One LED indicates fault for entire station e LEDs to indicate status of DeviceNet communication DeviceNet minifast Pinout C2 1 Shield 2 V 1 0 connectors 3 V 4 CAN H c3 5 CAN_L 5 829 148 1 REF Devic
129. n Networks Up to a Maximum Length of 100 Meters 328 Feet Jacket Drain Wire Foil Shield Overall Foil Shield Braid Shield Drop Length Data Rate Maximum Trunk Length Blue White Black Red Data Power 500 Kbaud 100 meters 328 feet 100 meters 328 feet 6 meters 20 feet 100 meters 328 feet Bulk Cable Approvals NEC PLTC CEC AWM 1 11 A B FT4 NEC PLTC CEC AWM 1 11 A B FT4 NEC PLTC CL2 CEC CMG NEC AWM CEC AWM 1 11 A B FT1 NEC AWM NEC AWM CEC AWM 1 11 A B FT4 Indicates length in meters AWG Color Code 2 22 AWG BK RD 18 1 Ohms 16 9 Ohms VI 2 22 AWG BK RD VI VI VI 2 22 AWG BK RD PVC PVC 18 1 Ohms PVC 2 22 AWG 16 5 Ohms BK RD PVC P C 2 22 AWG BK RD 16 5 Ohms E 2 22 AWG BK RD 16 5 Ohms PV Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths See page A7 for flexlife performance Zero Halogen to DIN VDE 0472 part 815 IEC 60754 1 2 22 AWG BU WH 2 22 AWG BU WH 2 22 AWG BU WH 2 22 AWG BU WH 2 24 AWG BU WH 2 22 AWG BU WH DCR 1000 feet AWG DCR 1000 feet Insulation Color Code Insulation 18 1 Ohms PE 16 9 Ohms PE 18 1 Ohms PE 16 5 Ohms PE 27 7 Ohms PE 16 5 Ohms PE Material Color Nominal O D Type Drain Wire Foil 22 AWG Foil Braid 22 AWG PVC Light Grey 7 2 mm 285 in PVC Light Grey 8 4 mm 330 i
130. nc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK BE ae Industrial I O piconet Products I DeviceNet Input Output Stations Rugged Fully Potted Stations Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus sensor currents from Up e Sensor Current 500 mA total of all sensors from U Output Current See table on facing page from U Power Distribution Inputs U Power supply Outputs U Power supply f 4 Ln KSA A Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 on o 8 EA r HT SDNB 0404D 0005 Material SDNB 0404D 0001 Connectors Nickel plated brass Housing Nylon C Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 9 138 93 5 MOUNTING HOLE 2x Network Connector L Switches Address DeviceNet Pinout eurofast Male 5 4 1 Shield Diagnostic LEDs 2 V 3 V 1 3 4 CAN_H 5 CANL co 6 889 175 0 c1 REF c2 c3 c4 1 0 connectors Aux Power Lo c7 Power LEDs UB Bus InputPower 1 Ut UL 0utputPower 2 U Power 3 Gnd S EN connectors 4 Gnd OL 1 181 30 0 L F95 TURCK Inc 3000 Campus
131. ncisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Media G1 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet Selection Guide E DeviceNet Media G56 G59 G62 G74 G75 G77 G79 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G2 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products G3 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation DeviceNet Thin Cable Specifications Industr A Cable that Meets the Requirements of ODVA Thin or Type 1 Cable Commonly Used as Drop Cable to a Maximum Length of 6 Meters 20 Feet or Trunk Cable i
132. nd Relay No O N INS AV 10 24 Drive Interface Common 2 are isolated from each other and Ao amp S A2 ANALOG s Drive Interface INPUT ba connedled de OUTPUT Ax A As 10 24 V or AV AV 10 24V S G Common Analog fom dte or Sy 9 AV AV Drivelnterface extemal supply Diagram A Diagram B I O Data Map 1 pot tu to 2 1 3 I o 05 0 4 0 3 0 2 0 1 0 0 i o 11 0 10 0 9 0 8 0 7 0 6 AO High Byte out tl tow te n Al High Byte 6 tow Byte sd A2 High Byte pelo mHliowByte 9 A3 High Byte TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F84 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products Im DeviceNet DeviceNet piconet Stations TURCK s piconet DeviceNet stations are compact rugged stations designed for machine mounting These stations allow easy connection of standard I O devices such as sensors limit switches valves and pilot lights to a DeviceNet network typically without a protective enclosure This is made possible by epoxy filled station housings all metal connectors and visible rotary address switches among other things piconet s small size sets them apart from oth
133. ndustrial I O DeviceNet Products DeviceNet AS I Gateways in Stainless Steel e AS I v3 0 Supported e Integrated Ground Fault Detection e Graphical Display Integrated AS I Diagnostics Electrical Operating Current 200 mA from V s Power Supply A 200 MA from Vas 4 ZOMA from Vas Power Supply A2 250 mA from V yx Power Supply E enam P Power Distribution ali From AS I supply for each network Power Supply A A2 t eoe ES ms Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IP 20 From external supply Power Supply E p ASI DNG SS BW1818 Vibration According to EN 61131 2 ASI DNG SS BW1819 Material ASI DNG SS BW1820 Housing Stainless Steel ASI DNG SS C1D2 BW1824 Diagnostics Logical ASI DNG SS C1D2 BW1825 e AS I diagnostic data is available via Network interface Nor ante LEDs to indicate status of network and AS I communication and power supply CEG 0 LEDs Devicenet connector Display 4 724 120 0 User Interface buttons DeviceNet Connector AS i and Power connectors Ope 0 0 0 V SHD V CAN H CAN L F123 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Indu
134. ne node will take control of the address and the others will go into Critical Link Failure state indicated by the network status LED solid red F3 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Communication Rate Cycle Time DeviceNet specifications define three transmission speeds 125 250 and 500 kbps All nodes on a network must communicate at the same rate Several factors must be considered when calculating the complete cycle time of a DeviceNet system including Number of nodes being scanned Amount of data produced and consumed by the nodes Type of I O messaging change of state strobe poll Network communication rate Device time out and explicit messaging traffic Cycle time of the control program m DeviceNet Electronic Data Sheets EDS Files Electronic Data Sheets or EDS files are files that contain detailed information about a DeviceNet device including I O data size and the device s configurable parameters The information provided by EDS files guide a user through the steps necessary to configure a device EDS files are available on the TURCK web site www turck com Maximum Ratings The DeviceNet bus uses tr
135. neapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Addressing DeviceNet stations must have a network address for communication The address for AS i DeviceNet gateway stations may be set via the display screen and push buttons Please consult the manual for a particular gateway for instruction on the procedure Diagnostics AS i DeviceNet gateways contain LEDs for diagnosing I O and communication problems for both the DeviceNet and AS I interfaces For a detailed description of the LED states please see the Bihl Wiedemann AS i DeviceNet Gateway User Manual available to download from www bihl wiedemann com Power Mu E z S E S Y Q Most AS i DeviceNet gateways draw power from the AS I power supply The option to use a separate non AS I power supply is also available Refer to the AS I masters section of this catalog for more details on the power supply configurations TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F122 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK I
136. nectors Industr A Allows Quick and Easy Changes from Male to Female Connectors Available in Straight and Right Angle Styles with minifast Connectors ja 3 008 76 4 REF 1 102 28 0 F 61 024 26 0 91 024 26 0 1 689 17 5 7 8 16UN 7 8 16UN L s RSM RSM 57 RKM RKM 57 WSM RKM 57 Pinouts minifast 2 740 69 6 REF 1 102 28 0 Fr 91 024 26 0 E A WE 689 17 5 7 8 16UN 1 91 024 26 0 Y PUR Polyurethane 300V 9A 40 to 75 C 7 8 16UN L p ad 1 102 28 0 E 91 024 26 0 E 689 17 5 1 504 38 2 91 024 26 0 le 7 8 16UN Male minifast Gender Changer Changes female cordset to male cordset Female minifast Gender Changer Changes male cordset to female cordset Changes straight male or female cordset to right angle cordset minifast Elbow Right angle male to female connector TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Pi DeviceNet Media G60 TURCK Network Media Products DeviceNet Gender Changers and Elbow Connectors Allows Quick and Easy Changes from Male to Female and minifast to eurofast Connectors 91 024 26 0 2 4
137. neering com TURCK Network Media Products DeviceNet eurofast Junction Tee Indoor Use Only for outdoor applications use JBBS family Multi Port Junction Provides a Rugged Connection to Network Devices Bus in Bus out Feature Eliminates Need for Splitter Tee 4 port Junction Tee 7 8 16UN minifast bus in bus out connections JTBS 57 E433 Four M12x1 eurofast device ports For nickel plated brass connectors change part number to JTBS 57 E434 4 port Junction Tee 7 8 16UN minifast bus in bus out connections Four M12x1 eurofast device ports For nickel plated brass connectors change part number to JTBS 57VM E434 JTBS 57VM E433 Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED indication Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber CL I Div 2 Groups A D see TURCK drawing N1 2 400 T6 Ta 70 C APPROVED 6 port Junction Tee 7 8 16UN minifast bus in bus out connections JTBS 57 E633 Six M12x1 eurofast device ports For nickel plated brass connectors change part number to JTBS 57 E634 6 port Junction Tee 7 8 16UN minifast bus in bus out connections Six M12x1 eurofast device ports For nickel plated brass connectors change part number to JTBS 57VM E634 JTBS 57VM E633 Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED indication Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amb
138. ngineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Output Rugged Fully Potted Stations Screw Terminal Connections Stations IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical e Operating Current lt 75 mA from DeviceNet for 50808C add input currents e Sensor Current 700 mA total of all inputs 50808C From DeviceNet XSG16 from aux Power Output Current 500 mA per output from aux power Power Distribution Inputs 50808C from DeviceNet power supply XSC16 From Auxiliary power supply Outputs Auxiliary power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 9 10 500 Hz Material FDNP S0808G ST Connectors Nickel plated brass stainless steel available on request FDNP XSG16 ST Housing Nylon 6 other materials available on request CE G Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates a fault for the entire station Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication Auxiliary Power C47 Aux Power Pinout cs va 1 Viyxt 8659 220 0 connectors 2 pass thru ce 3 pass thru 8 266 210 0 4 Vaux Screw Terminal en Connection Z Switche
139. nneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A TURCK s USA website is your most complete and up to date source for product documentation CAD files and more Search results produce downloadable documentation or request for quote RFQ Additional product information or CAD files are easily requested and promptly filled Visit our site for new product releases approvals white papers application support and more m DeviceNet Access to all TURCK catalogs press releases white papers and tutorials Senso it Connect It Buv It a Complete category listing Search for products of TURCK products by part number ID number or key word Access to CAD wiring and pinout diagrams dio 6827177 ta 210 to o mann 210 20 f 216 vara mms b to to EIL ELI Leer 2 devalaad eks nee m pets e mem ED add He te My ker foro maling and jor RQ Sata 3 nasti Download or e mail files request for quote Contact a Option to TURCK representative e mail pages www turck com TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F88 Courtesy of Steven Engineering Inc 230 Ry
140. num PA Nylon Gold Plated CuZn NEMA 1 and IP 20 Snap on DIN RAIL DIN 50022 25 0 EDO 10 CSI OI E E E E 4 150 105 4 4 150 105 4 OOO 2 O00 Of vx OE rye ore on 22020700 bc 4 213 107 0 Cal 8 Port 4 150 229 12 O 2 A Two am ome v ee a y DOD 272172172102 72 lm 2 z 2 De paeo Jom v H H E e een z 2000009200000 6 969 177 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com 6 Port 4 Devo am Pone Industr A E DeviceNet Media Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet eurofast Junctions Multi port Junction Boxes for Connecting I O in Concentrated Areas Available in Standard and Voltage Monitoring 8 port Junction with Voltage Monitoring Bus in bus out connections 7 8 16UN minifast Eight M12x1 eurofast connectors for field connectors JBBS 57 E811 Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication LED indication Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber 8 port Junction JBBS 57 E812
141. num Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier TPU Polyurethane or POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K Rated Voltage 250 V Rated Current 9A Ambient Temperature 40 to 75 C 22 to 167 F Dimensions 8 Port 6 Port 2 520 64 0 1 417 36 0 2 520 64 0 1 417 36 0 E DeviceNet Media E 7 302 185 5 MOUNTING SCREW M4 2x 8 MOUNTING SCREW NOT INCLUDED 8 M4 2x NOT INCLUDED 4 Port 2 520 64 0 1 417 36 0 1 713 MUR Pinouts minifast 5 905 150 0 5 433 138 0 MOUNTING SCREW 8 M4 2x NOT INCLUDED TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G34 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet minifast Passive Multi Junctions Rugged Fully Encapsulated Enclosure For Connecting I O in Concentrated Areas Bus In Bus Out Eliminates Need for Splitter Tee Suitable for Outdoor Applications 6 port Junction Fiberglass Bus in bus out straight 7 8 16UN minifast JBBS 57 M623 through ports enclosure Six device ports with 7 8 16U
142. oducts DeviceNet eurofast Drop Junctions Creates a Drop or Branch from the Main Bus Line Cable Drop Lengths Available Up to a Maximum of 6 Meters VB2 Junction v ES VB2 FKM FKM FSM 57 Ready for eurofast drop and trunk cordsets Maximum six meter drop i x U GN TWH VB2 Junction with Trunk Line VB2 RKC 57x M FKM FSM Ready for eurofast trunk line Maximum six meter drop VB2 Junction with Trunk Line VB2 FKM RKC RSC 57x M M Ready for eurofast drop cordsets Maximum six meter branch Indicates length in meters x Indicates cable type G51 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Indust A Specifications Housing PUR Polyurethane Coupling Nut Nickel Plated CuZn or Stainless Steel Contact Carrier PUR Polyurethane or POM Nylon Contacts Gold Plated CuZn Protection NEMA 1 3 4 6P and IEC IP 68 Rated Voltage 250V Rated Current 4A Ambient Temperature 40 to 75 C 22 to 167 F Mounting Mounting hole accepts 8 screw E DeviceNet Media VB2 FKM FKM FSM 57 VB2 RKC 57x M FKM FSM 0 177 04 5 2x 512 13 0 9 315 08 0 2x FT 13 0 0 315
143. of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet picofast Junctions 8 port Multi Port Passive Junction Box in Small Compact Housing Accepts M8x1 Snap Lock or Threaded Connectors Available in Standard and Voltage Monitoring 8 port Junction Tee JBBS 57 FS P824Z M12x1 eurofast drop connector J3 J5 Eight M8x1 picofast snap lock connectors 123456 123456 8 port Junction Tee is id AB icu JBBS 57 FS P824M M12x1 eurofast drop connector Eight M8x1 picofast threaded connectors 8 port Junction Tee M12x1 eurofast drop connector Eight M8x1 picofast snap lock connectors Voltage monitoring provides low voltage 12 9 V and high voltage 25 6 indication JBBS 57 FS VM P824Z MR J1 J3 J5 J7 LED indication 123456 123456 123456 123456 Lo 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber 8 port Junction Tee M12x1 eurofast drop connector 12345 123456 123456 123456 J2 J4 J6 J8 Eight M8x1 picofast threaded connectors Voltage monitoring provides low voltage 12 9 V JBBS 57 FS VM P824M and high voltage 25 6 indication LED indication Lo lt 12 9 V Amber Ok 12 9 25 6 V Green Hi gt 25 6 V Amber G31 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763
144. of all inputs Output Current 1 8 A per output Power Distribution Inputs Optionally DeviceNet or Auxiliary power supply as shown in wiring diagram Outputs Optionally DeviceNet or Auxiliary power supply as shown in wiring diagram Mechanical FDN20 16SN 16XSG Operating Temperature 40 to 70 C 40 to 158 F FDN20 32SN Protection IEC IP 20 Material CE lt DIV 2 Housing Nylon Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates a fault for all inputs on bit indicates a fault for all outputs Diagnostics Physical e LED to indicate status of DeviceNet communication 5 994 152 3 DeviceNet Connector NE NN ad CAN H CAN L F81 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Inputs TAG PPT roer or fr pee x D E HE f Fono fer O CG af PP A E E IC 16 dedicated inputs and 16 points which can be used as inputs or outputs E DeviceNet 0000050000 sr nez olele z olele zlee ee di ASSE 8 Z 9 S v Lxny lxny Lxny Lxny xny Cuxny o0
145. omation Industr FDNL S1600 E E DeviceNet Mating cordset RK 4 4T RS 4 4T Mating cordset RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter VBRS 4 4 2RK 4T I O Data Map 1 I O Data Map 2 je Patter pre faa ia Pra pre en pen o irre is 1 1 2 12 9 ef 0 12 s 5 9 153 r2 1 09 Pose os qoin sj je T E 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F16 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Deluxe Input Output Station Rugged Fully Potted Stations Input and Output on Same Connector IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 100 mA plus sum of I O currents from DeviceNet Sensor Current 120 mA per input from DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material Connectors Nickel plated brass stainless s
146. on Support 1 800 544 7769 Fax 763 553 0708 www turck com m 1 622 41 2 Specifications PUR Polyurethane Nickel Plated CuZn or Stainless Steel thread Nylon snap lock PUR Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 30 V TESTA 40 to 75 C 22 to 167 F 13 M8x1 TI 0 374 9 5 I I 14 1 366 34 7 n 9 354 9 0 aft M8x1 4i Fi DeviceNet Media Pages G17 G18 16 Pages G17 G18 18 9 404 10 2 LOCKING ciam HE lt SLEEVE Pages G17 G18 G20 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Terminating Resistors Terminating Resistors Stabilize and Minimize Reflections on the Bus Line A Terminating Resistor is Required at the Beginning and End of the Main Bus Line po Herpes 26 0 4 91 024 26 0 n 1 909 48 5 AE 7 8 16UN TIT TIME ge poda Md 26 0 zm 2 173 55 2 9 531 13 5 1 910 48 5 G21 RKE 57 TR2 Nickel Plated Brass or Stainless Steel 300V 9A 40 to 75 C IP 67 Nickel Plated Brass or Stainless Steel 300V 9A 40 to 75 C IP 67 Nickel Plated Brass or Stainless Steel 250V 4A 40 to 75 C IP 67 Nickel Plated CuZn or Stainless Steel 250V 4A 40
147. on is given in the product information on the following pages F71 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Power The short FDN20 stations provide all the power to the I O devices from the DeviceNet power supply In this case there is no auxiliary power connection Industr A The remaining long FDN20 stations FDN20 16XSG for example provide an auxiliary power connection 1 O devices can be powered from the DeviceNet or auxiliary power supply depending on how the user chooses to wire the station The different wiring options are illustrated in the following diagram WARNING NOTE V and V PROVIDE POWER FROM DeviceNet From DeviceNet 0 7 A DO NOT CONNECT TO SUPPLY OR GROUND CONNECT AS SHOWN TO USE DeviceNet to POWER I O Power ratings for FDN20 stations Bus DeviceNet Voltage 11 26 VDC Aux Power Voltage 24 VDC nominal e Internal Current Consumption lt 75 mA nominal 24 VDC plus sum of I O currents if auxiliary power is not used Input Voltage 13 26 VDC From DeviceNet supply Input Short Circuit Current 700 mA total for entire station DO NOT CONNECT TO SUPPLY OR GROUND DeviceNet V
148. onnection 1 Shield 2 V 9 213 95 4 3 2 V 1 654 42 0 MOUNTING HOLE u 2 362 60 0 idi FSF REF 5 CAN L F49 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr 5 5 e ma o o 5 5 A mha N E DeviceNet AI I Loop Powered Isolated DeviceNet Powered Transducer Mating cordset Isolated Loop RK 4 5T M RS 4 5T 5653 Loop Powered RK 4 5T M RS 4 5T LPS S653 Note The LPS in the part number indicates that the cord jumpers pin 3 to pin 4 on the male side to the signal to the station common Pin 3 is not connected at the female end Applications TURCK Sensors LU RK 4 4T RS 4 4T S1118 Ll RK 4 4T RS 4 4T 51120 I O Data Map 1 o EJ 5 6 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F50 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products The E connect system Safely stopping motion is becoming more critical as machinery and systems become more automated Whe
149. ort 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet Pico Cable Specifications Cable that Meets the Electrical Requirements of ODVA Thin Cable Data Pair Only Pico Cable has 24 AWG Conductors Which May be Used with picofast Connectors Submittal to ODVA Pending Jacket Blue White Black Red Data Power E DeviceNet Media Foil Shield Overall Foil Shield DeviceNet Pico Cable 5724 DeviceNet Thin Cable 5715 Approvals AWG DCR 1000 fee AWG DCR 1000 feet Material Color Type DE i Color Code Insulation Color Code Insulation Nominal O D Drain Wire eg NEC AWM 2 24 AWG 24 9 2 24 AWG 24 9 PVC Light Grey Foil Data Only RB51045 M CEC AWM I II A B FT1 BK RD PVC BU WH PE 5 7 mm 224 in 24 AWG 27 lbs NEC AWM 2 22 ANG 16 5 2 22 ANG 16 5 PVC Light Grey Foil Data Only RB50764 M CEC AWM I II A B FT1 BK RD PVC BU WH PE 6 0 mm 235 in 22 AWG 26 lbs Indicates length in meters Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com G16 Courtesy of Steven Enginee
150. ourtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products Im DeviceNet Addressing DeviceNet stations must have a network address for communication The address for piconet stations may be set via the visible rotary switches under the clear plastic cover on the front of the station X1U La Address Switches Address 6x10 3x1 63 The pair of switches represents the address as a decimal number the left switch being the 10 s multiplier and the right switch the 1 s multiplier To program the station rotate the switches with a small slotted screwdriver until the arrows point to the appropriate numbers for the chosen address Diagnostics piconet DeviceNet stations provide two LEDs for diagnosing communication problems Module Status Green Working properly Flashing green Detecting baud rate Flashing red Input short circuit Network Status Green Connection established Flashing green Waiting for connection Flashing red Connection timed out Red Cannot connect There is an additional LED for each input on the station This LED indicates Off Input is off Green Input is on There is also an LED to indicate the status of the two auxiliary power supplies Off Power is missing On Power is present F87 TURCK Inc 3000 Campus Drive Mi
151. outh San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation DeviceNet Thick Cable Specifications Cable That Meets the Requirements of ODVA Thick or Type II Cable t Provides the Most Power to a Network When Used as a Trunk Cable Up to a Maximum Standard Cable Length of 500 Meters 1640 Feet Jacket Drain Wire Blue White Black Red Data Power Foil Shield Overall Foil Shield Data Rate Maximum Maximum Trunk Length Trunk Length 5720 125 Kbaud 500 meters 1640 feet 420 meters 1378 feet 250 Kbaud 250 meters 820 feet 200 meters 656 feet 500 Kbaud 100 meters 328 feet 100 meters 328 feet Approvals AWG DCR 1000 feet AWG DER 1000 feet Material Color Type Color Code Insulation Color Code Insulation Nominal O D Drain Wire NEC AWM 2 15 AWG 3 3 Ohms 2 18 AWG 6 5 Ohms PUR Light Grey Foil Braid CEC AWM 1 11 A B FT1 BK RD PVC BU WH PE 10 4 mm 409 in 18 AWG NEC PLTC CL2 2 15 AWG 3 2 Ohms 2 18 AWG 6 5 Ohms PVC Light Grey Foil Braid CEC CMG BK RD PVC BU WH PE 11 3 mm 445 in 18 AWG NEC TC 2 16 AWG 4 uet 2 8 AWG 6 9 PVC Light Grey Foil Braid BK RD BU WH 13 mm 515 in 16 AWG NEC AWM 2 15 AWG 3 2 Ohms 2 18 AWG 6 9 Ohms PUR Violet Foil Braid BK RD PE BU WH PE 11 2 mm 449 in 18 AWG NEC PLTC 2 15 AWG 3 44 Ohms 2 18 AWG 7 06 Ohms PVC Light Grey Foil Spiral CEC AWM 1 11 A
152. outh San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Input Stations Rugged Fully Potted Stations Compact Housing IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current 75 mA plus total of input currents from DeviceNet Sensor Current 700 mA sum of all inputs from DeviceNet Power Distribution Inputs DeviceNet power supply Mechanical Operating Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz EON Material Q S0200 T Connectors Nickel plated brass stainless steel available on request FDNQ S0400 T Housing Nylon 6 other materials available on request DN Diagnostics Logical FDNQ S0400 C e Open short circuit status mapped to DeviceNet I O table one bit indicates Not FM Approved fault for entire station CE G lt Em gt Diagnostics Physical One LED indicates fault for entire station e LEDs to indicate status of DeviceNet communication DeviceNet minifast Pinout 1 Shield 2 V c2 3 V 1 0 4 CAN H connectors 5 CAN L C3 5 829 148 1 REF 5 376 136 6 Address Switches Network 1 Shield connectors 2 V Ground 3 V connection 4 CAN H 0 213 05 4 AAN 1 654 42 0 MOUNTING HOLE 2 362 60 0 s REF FDN
153. r Orientation FS PCB KIT Page G67 51 Md 21 0 M ts T 2 039 nad 197 5 0 T se e E FS PCB KIT Page G67 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Industr A 52 709 18 0 118 3 0 EX 0 071 1 st 197 5 0 FKFDL 0 787 20 0 748 19 0 Page G68 Ui E DeviceNet Media 709 18 0 118 3 0 LN PG 9 T 9 031 0 M 9 787 20 0 j 494 VN E 748 19 0 374 9 5 p O RING pe FKFD PCB Page G68 54 894 22 7 1 120 28 4 Right Angle Connector Orientation FK PCB KIT Page G67 55 y Fi 19 5 x 9 709 18 0 0 039 sat ar 079 2 0 N o ga lE ss 70 FK PCB KIT Page G67 G74 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet minifast Field Wireable Connectors Allows for Quick Connection when Pre Molded Cables not Available Available for Male and Female Connectors Color Coded Wire Connections for DeviceNet Glass filled nylon PG 9 cable gland accepts 6 8 mm cable diameter BS 4151 0 9 DNET Screw terminals 91 065 PE 88 0 MN 85 250 V 9A 7 8 16UN Glass filled nylon PG 13 5 cable gland accepts 10 12 mm cable diameter Screw terminals
154. re once a machine was controlled by one person today we have many interconnect machines that are controlled by Industrial PCs and PLCs Motion may start automatically without warning and some of today s equipment is almost silent in comparision to the background noise of the factory TURCK has developed three systems to quickly connectorize standard e stop devices 1 2 3 Series E connect Series E connect with bus monitoring and annunciation Dedicated E connect Series E connect Series connection of redundant e stop device contacts is one of the most common ways in North America to provide machine safety for personnel Two isolated circuits go from the safety relay module to the redundant contacts of each emergency stop devices Dedicated E connect Two dedicated circuits go from the safety relay module to redundant contacts of a single emergency stop or safeguarding device E connect Station Less than 50 mA current consumption on DeviceNet power bus 8 Pin eurofast for quick connection to E Stop devices 4 wires for redundant safety circuit contacts 2 wires for monitoring contacts 2 wires for optional local annunciation 4 Pin eurofast for quick series connection of E connect stations to a safety relay module 2 isolated wires for redundant safety circuits 2 wires for auxiliary power for local pilot light annunciation controlled via DeviceNet Visible Rotary Address
155. red Connection timed out Red Cannot connect e Flashing Amber Finding baud rate autobaud setting The long housing stations i e FDN20 16XSG have an additional LED for each I O point on the station indicating Off Point is off Green Point is on Additionally most FDN20 stations provide diagnostic bits in the I O table for diagnostics One bit indicates a short circuit fault for outputs or inputs See product pages in this catalog for detailed I O information F73 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F74 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com E DeviceNet TURCK Industrial I O DeviceNet Products DeviceNet Enclosure Mounted n Cabinet I O e Ideal for Retrofits Input Output Stations IP 20 Protection Automatic Baud Rate Sensing ES E Electrical e Operating Current lt 75 mA from DeviceNet plus I O currents from bus power Input Current 700 mA sum of all inputs f
156. ring Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Network Media Products DeviceNet Cable Cordsets Selection Matrix Threaded Socket female ml gt 3 cmm d o HUB PKGM PKWM PSGM PSWM WST 3 PKGM 57x M PKUM 57x M PSGM 57x M PSWM 57x M RST 57x MST 57x RKT 57x WKT 57x Bare PKGM PKGM 57x M PKGM PKUM 57x M PKGM PSGM 57x M PKGM PSWM 57x M PKGM RST 57x M PKGM WST 57x M PKGM RKT 57x M PKGM WKT 57x M Socket Female Indicates length in meters x Indicates cable type See page B125 for available cable types Type 5715 cable can be used with RST WST RKT and WKT smaller body styles Consult factory for part numbers Refer to the Cordset Builder at www turck com for assistance with cordset cable combinations Standard cable lengths are 1 2 4 5 6 8 10 15 and in 5 meter increments from there Consult factory for other lengths Pin Male See pages G19 G20 for dimensional drawings Female Bare Shield Drain Wire Female Red Voltage Black Voltage White CAN H Blue CAN L N C picofast only G17 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside
157. rol center Auxiliary Power Connectors E DeviceNet St at ions where I O draws a significant amount of current 2 Amp outputs for example receives this power from a second or auxiliary power supply Some stations receive input power from the network and output power from the auxiliary supply Generally the connection is a male female pair to allow cabling one power supply to multiple stations without the use of a tee daisy chain configuration Auxiliary power is typically supplied by a 4 pin minifast 7 8 16 UN connector though other auxiliary power connections are used on some stations For further details see the individual station entries in this catalog Aux Power Pinout 1 Vat 2 Pass Through 3 Pass Through 4 e Power Some AIM stations typically those with only inputs are completely powered from the DeviceNet power supply When designing a network take care to include the current draw for the station as well as all input devices connected to the station in your power supply sizing calculations For example if the internal current consumption of the station is lt 50 mA and the total short circuit limit for all inputs combined is lt 700 mA then the maximum current draw for the station is 50 mA 700 mA 750 mA Stations with output points normally use a separate auxiliary power supply to provide current for the outputs Several AIM stations can be powered by one auxiliary supply or a single supply for
158. rom DeviceNet Output Current 500 mA per output from DeviceNet Power Distribution Inputs DeviceNet power supply Outputs DeviceNet power supply FDN20 4S 4XSG Mechanical FDN20 4S 4XSG E e Operating Temperature 40 to 70 C 40 to 158 F FDN20 4S 4XSG DIN Protection IEC IP 20 SPORIS Material C lt a gt UL Connectors Nickel plated brass eurofast option only ue Housing Nylon Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit indicates a fault for all inputs and one bit indicates a fault for all outputs Diagnostics Physical e LED to indicate status of DeviceNet communication DeviceNet Pinout eurofast Male 1 Shield 2 V so ADDRESS SWITCHES Nea 4 CAN 1 THICKNESS m z 157 4 0 5 CAN L BUS TERMINAL i CONNECTOR PG 9 FDN20 45 4XSG E only MOUNTING HOLES ad i2 2 460 62 5 Fer 1 0 TERMINAL nio 1 750 44 4 1 05 921 mad La 2 165 55 0 1 689 42 9 FDN20 4S 4XSG E shown V SHD v CAN_H CAN_L Note A DIN rail mounting bracket FDN20 BKT DIN may be purchased separately for use with the FDN20 4S 4XSG F75 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com
159. s Network 1 Shield connectors DEA ten 3 V 4 CAN_H 213 5 1 654 42 0 BOLING HOLE 5 CAN_L 2 362 60 0 ak REF F37 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr N o N DeviceNet WH Output B Mating cordset Mating cordset Mating cordset RK 4 4T RS 4 4T RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter Splitter Splitter VBRS 4 4 2RK 4T VBRS 4 4 2RK 4T VBRS 4 4 2RK 4T ST1 ST2 Visc Vaux7 Visct Vaux a Vaux a Vaux k Se l3 5 LU Sto le Le Sti L Si2 Sis v S14 CAN Sis Shield t CAN Vaux t V Vaux NOTE Msc is from DeviceNet power supply Vo is from Auxiliary power supply I O Data Map 1 I O Data Map 2 o 1 7 1 6 15 1 4 1 3 re tr ro o I7 rs is 1 4 1 3 12 11 ro x pe pep ea la es eee pz es ves Ls gt lo ER o 0 7 0 6 os 0 4 0 3 0 2 0 1 0 0 out i o is 0 24 0 13 0 12 0 11 0 10 0 9 06 om o ox os es os o3 os o3 95 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F38 Courtesy of Steven Engineering Inc 230 Ryan Way S
160. s 40 to 70 C 40 to 158 F LX stations 25 to 70 C 13 to 158 F e Vibration 50 g 10 500 Hz E DeviceNet Other housing and connector materials available upon request The stations components are identified in the following figure The figure shows a station with minifast 7 8 16 UN network connectors but other connector options such as M12 eurofast are available for some stations Stations with all I O powered from the DeviceNet power supply do not have the auxiliary power connectors at the top of the housing Aux Power Connectors I O Connectors Address and Data Rate Switches Network Connectors TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F6 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products Connectors DeviceNet DeviceNet AIM stations generally provide connections for the bus and I O in addition to auxiliary power for stations with outputs Bus Connectors minifast 7 8 16UN is the standard bus connector for DeviceNet AIM stations Some stations are available with eurofast M12 or M23 bus connectors DeviceNet minifast Pinouts eurofast I O Connectors 1 Shield Drain 3 V 0 VDC 4 CAN High 5 CAN Low 2 V 24 VDC
161. s Network TS Shield connectors 2 V Ground connection 3 V E 4 CAN H 9 213 95 4 5 CAN L 1 654 42 0 MOUNTING HOLE a 2 362 60 0 REF F27 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr E DeviceNet C WH Output Mating cordset RK 4 4T RS 4 4T Splitter VB2 RS 4 4T 1 2RK 4 4T 5651 I O Data Map 1 o ne 16 15 ra 13 12 T1 19 05 6 a aes Pp Out o 0 7 0 6 es e 3 jojojo TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F28 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Standard Output Stations Rugged Fully Potted Stations Auxiliary Powered Outputs IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical Operating Current lt 140 mA FDNP G TT 50 mA FDNP H TT 75 mA FDNP 0200 from DeviceNet Output Current see table on facing page from aux power
162. station LEDs to indicate status of DeviceNet communication 9 138 63 5 MOUNTING HOLE 2x Network Connector Address Switches DeviceNet Pinout Diagnostic LEDs 1 Shield 5 2 V 3 V 1 3 4 CAN_H 5 CANL 1 0 connectors Aux Power Power LEDs UB Bus InputPower UL OutputPower Power connectors 1 181 30 0 F101 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Outputs Output Connectors E DeviceNet AOV AOI WH Output WH Output BU Ground Ground BK Output REF Output DeviceNet Powered Transducer Mating cordset Mating cordset RK 4 5T RS 4 5T RK 4 5T RS 4 5T Applications TURCK Sensors LU RK 4 4T RS 4 4T S1118 Ll RK 4 4T RS 4 4T S1120 I O Data Map 1 NES Lo aos 3 aos 2 aos 1 aos o 0 Channel 0 MSB 4 stemt 6 d emers TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F102 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O p
163. strial Automation Industr A ASI DNG SS BW1818 ASI DNG SS BW1819 ASI DNG SS BW1820 DeviceNet t ASI DNG SS C1D2 BW1824 ASI DNG SS C1D2 BW1825 ASI DNG SS CID2 BW1826 Approved for use in Class 1 Division 2 areas 2 E 2 E N DeviceNet Input Output Connectors A A2 E ASI ASI1 ASI2 30 ASI ASI PWR NC NC GND ASI1 PWR ASI2 PWR GND ASI1 ASI1 ASI2 VDC GND Y GIU GJ Y OY Y A Single AS I network is powered by and AS I power supply A2 Dual AS I networks are each powered by their own AS I power supply E Dual AS I networks are both powered by a single 30 VDC supply decoupled through the gateway TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F124 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet piconet Gateway Rugged Fully Potted Stations Small Footprint IP 67 Protection Flexible I O Subnetwork Electrical e Operating Current 75 mA plus sensor currents from Up e Sensor Current 500 mA total of all sensors from U Output Current 500 mA per output from U Power Distribution
164. teel available on request FDNL CPG88 T P pe Housing Nylon 6 other materials available on request i Diagnostics Logical is C G e Open short circuit status mapped to DeviceNet I O table one bit each per I O point Diagnostics Physical Individual LED to indicate open short circuit for each channel 3 LEDsto indicate status of DeviceNet communication C4 C5 1 0 connectors c2 C6 7 756 197 0 REF 7 362 187 0 c3 c7 a oto Rote 1 Inr 1 Roto Ro DeviceNet minifast Pinout Network UE Shield connectors 2 2 V Ground 32 V connection 4 CANH 9 213 05 4 5 CANL MOUNTING HOLE 4x 1 654 42 0 2 362 60 0 RE F F17 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr peer sempre vq mp AA Input Output Connectors C Mating cordset RK 4 4T RS 4 4T Splitter VB2 RS 4 4T 1 2RK 4 4T 5651 I O Data Map 1 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F18 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Are
165. ting Temperature 40 to 70 C 40 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz Material FDNQ S0002G T Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request ce E Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit each per I O point Diagnostics Physical Individual LED to indicate open short circuit for each channel LEDsto indicate status of DeviceNet communication C2 1 0 connectors c3 5 829 148 1 REF 5 376 136 6 Address Switches DeviceNet minifast Pinout Network connectors Ground 1 Shield connection 2 V 213 05 4 aa 9 95 1 654 42 0 MOUNTING HOLE 4 CAN H 2 362 60 0 di 5 CAN L REF F41 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A Output Connectors E DeviceNet Mating cordset RK 4 4T RS 4 4T I O Data Map 1 CEE delle ea a os s dese gs EN 1 0 1 1 ESSO TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com j 3 F42 Courtesy of Steve
166. ting in an enclosure These stations allow you to easily connect standard I O devices such as push buttons pilot lights motor starters and drives to a DeviceNet network The FDN20 station is designed to easily upgrade existing equipment to a DeviceNet network Specifications TURCK FDN20 stations are designed to be mounted in standard equipment enclosures operator stations motor control centers etc Most FDN20 stations use only screw terminal connections for all I O and network wiring FDN20 4S 4XSG E has a DeviceNet eurofast M12 connector on the back of the housing that enables mounting the station to an enclosure wall with the DeviceNet connection on the outside of the box greatly simplifying network wiring Detailed environmental specifications are as follows Housing material Glass filled nylon Protection level IP 20 Operating temperature 40 to 70 C 40 to 158 F The station s components are identified in the figure below Rotary Address Switches DeviceNet eurofast M12x1 Connector Compact Low Profile I O Screw Terminals 4 Dedicated Inputs 4 Inputs or Outputs Connectors Bus connectors FDN20 screw terminal and eurofast bus connectors pinouts DeviceNet Pinout TU 1 Shield O e e e O devi 3 V V SHD V 4 CAN H CAN_H CAN_L 5 CAN L 1 O connectors Each FDN20 version uses a different screw terminal connector Detailed pinout informati
167. tion Industr A Input Output Connectors E DeviceNet PCNT Co C C Ground Ground Shield Mating cordset Mating cordset Mating cordset RK 4 5T RS 4 5T RK 4 5T RS 4 5T RK 4 5T RS 4 5T C3 I O Data Map 1 Mating cordset RK 4 5T RS 4 5T o Channel 0 Status a Channel O Byte 3 6 Channel 1 Byte O 8 Chamell Byte 9 Chamel 1 Byte3 oS io Channel O Control 4 5 5 Chamel O Byte3 6 Channel 1 Byte0 8 channel 1 Byte a melBMe3 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F104 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK BE ae Industrial I O piconet Products I DeviceNet Incremental Encoder Rugged Fully Potted Stations Small Footprint Station P 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus device currents from Uy Power Distribution Inputs Ug Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication
168. tions Electrical Operating Current 50 mA from DeviceNet Output Current 500 mA per output from Auxiliary power supply Power Distribution Inputs Auxiliary power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz FDNQ ES11 T Material FDNQ ES22 T Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request CE GR Diagnostics Logical e One bit in I O table indicates status of Auxiliary Power Supply APS Diagnostics Physical e LEDs to indicate status of DeviceNet communication Aux Power eurofast Pinout T a 1 0 ond E stop C2 circuit 1 Vaux connectors 2 SC 1 3 SC c3 Auxiliary Power 43 Vaux 5 831 148 1 connectors REF 5 377 Address Switches Network connectors 1 Shield Ground i A connection 2 V S 3 V an 0 213 05 4 1 654 42 0 MOUNTING HOLE 4 CAN H 4x 2 362 60 0 5 CAN L REF F63 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Input
169. to 75 C IP 67 Nickel Plated CuZn or Stainless Steel 250V 4A 40 to 75 C IP 67 minifast Terminating Resistor Male minifast connector 120 Ohms 1 4 W internal resistance minifast Terminating Resistor with Voltage Monitoring Male minifast connector Led indication Red reverse polarity Green okay 120 Ohms 1 4W internal resistance Female minifast Terminating Resistor Female minifast connector 120 Ohms 1 4 W internal resistance eurofast Terminating Resistor Male eurofast connector 120 Ohms 1 4W internal resistance Female eurofast Terminating Resistor Female eurofast connector 120 Ohms 1 4 W internal resistance TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation indust A DeviceNet Terminating Resistors Terminating Resistors Stabilize and Minimize Reflections on the Bus Line A Terminating Resistor is Required at the Beginning and End of the Main Bus Line Male 1 622 41 2 0 378 TERMINATING RESISTOR ig m 120 Q 1 2W BETWEEN PINS 4 5 M8x1 PSGM 57 TR EE E DeviceNet Media Nickel Plated Brass or picofast Terminating Resistor Stainless Stee
170. ts DeviceNet Deluxe Input Output Rugged Fully Potted Stations Auxiliary Powered Outputs Stations IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing Electrical e Operating Current 100 mA all except L0404G is 140 mA plus sensor currents from DeviceNet power Sensor Current 80 mA per input from DeviceNet Output Current See table on facing page Power Distribution Inputs DeviceNet power supply Outputs Auxiliary power supply Mechanical Operating Temperature 25 to 70 C 13 to 158 F Protection NEMA 1 3 4 12 13 IEC IP 67 IP 68 IP 69K e Vibration 50 g 10 500 Hz FDNP L0404G TT FDNP L0808G TT FDNP L0808H TT FDNP P0808H TT Not FM Material Connectors Nickel plated brass stainless steel available on request Housing Nylon 6 other materials available on request Diagnostics Logical e Open short circuit status mapped to DeviceNet I O table one bit each per I O point CE G a Diagnostics Physical Individual LED to indicate open short circuit for each channel o LEDs to indicate status of DeviceNet communication Auxiliary Power T Aux Power Pinout 12 Vaxt 2 Pass thru 3 Pass thru 1 0 8 659 220 0 V O nacions A Va C2 8 266 210 0 c7 Address DeviceNet minifast Pinout Dota Rote Switches 1 Shield Network iu 2 V Ground 3 Vs connection 4 CAN H 0 213 05 4 5 CANL 1 654 42 0 MOUNTING HOLE
171. uit status mapped to DeviceNet I O table one bit for each I O point Diagnostics Physical Individual LED to indicate open short circuit for each channel LEDsto indicate status of DeviceNet communication T gt A ETT Aux Power Pinout Power cu T 1 Vuxt 2 pass thru 3 pass thru ci cs 4 Vix 8 659 220 0 Y cla REF c2 cs 8 266 210 0 cs er gr DeviceNet minifast Pinout Switches 1 Shield Network connectors Du V Ground 3 V connection 4 CANH 1 654 p 10 5 CANL 2 362 60 0 REF E F35 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Input Output Connectors E DeviceNet Mating cordset Mating cordset Sensor with dual outputs RK 4 4T RS 4 4T RK 4 4T RS 4 4T Splitter Two sensors RK 4 5T RS 4 5T Splitter VBRS 4 5 2RK 4T 5818 VBRS 4 4 2RK 4T I O Data Map 1 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F36 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevene
172. um Shield 4 gt 4 CANH Auxili Shield 5 gt CANL uxiliai ower enclosure yp JBBS 57 SM01 E stop R 2 lt Shield Supplies DC power Estop R 1 lt V Right Estp L 4 lt v E stop L 3 lt 5 lt i CAN H Catagory 2 E stop 5 CANL E stop L 2 gt E stop R stop lt E stop R General purpose i AIR _ Aux R M machine stop G45 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Housing Coupling Nut Contact Carrier Contacts Protection Rated Voltage Rated Current Ambient Temperature Specifications Anodized Aluminum Nickel Plated CuZn or Stainless Steel TPU Polyurethane or POM Nylon Gold Plated CuZn NEMA 1 3 4 6P and IEC IP 67 IP 68 IP 69K 250 V 4A 40 to 75 C 22 to 167 F Dimensions SMO1 2 520 64 0 1 417 36 0 5 906 CLEARANCE HOLE FOR NO 8 SCREW 2x Industr A TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www steven
173. unk and drop topology The trunk is the main communication cable and requires a 121 ohm resistor at both ends of the trunk The length of the trunk depends on the communication rate and the cable type Drops are branches off the trunk and may be from zero to 6 m 20 ft in length The cumulative drop lengths are dependent on the communication rate The following table shows the maximum ratings for a trunk using thick mid and thin cable Thick and thin DeviceNet communication cable types are defined by the DeviceNet specification mid cable is a hybrid of the two that is offered by TURCK 125 kbps 500 m 1640 ft 300 m 984 ft 100 m 328 ft 6 m 20 ft 156 m 512 ft 250 kbps 250 m 820 ft 250 m 820 ft 100 m 328 ft 6 m 20 ft 78 m 256 ft 500 kbps 100 m 328 ft 100 m 328 ft 100 m 328 ft 6 m 20 ft 39 m 128 ft TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F4 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products Discrete Analog E connect Master Repeater Discrete Discrete Analog Special Function Discrete Discrete Gateways BL67 BL20 AS I piconet DeviceNet Media y DeviceNet DeviceNet Selection Guide F13 F15 F31 F39 Output Input
174. using Nylon 6 other materials available on request One bit in I O table indicates status of Auxiliary Power Supply APS e LEDs to indicate status of DeviceNet communication Aux Power eurofast Pinout 1 Shield 2 V 3 V 4 CAN H 5 CAN L TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr Input Output Connectors E DeviceNet E8 6 1 In 2 Out 8 7 3 AUX 4 SC1 4 1 5 SCI 6 SC2 3 8 2 7 SC2 8 AUX Mating cordset RSC RKC E80 M I O Data Map 1 I O Data Map 2 o iz 16 15 ta 13 1 2 1 1 1 0 MELKEN pep Lll mao Dos Toe oa oJ fou o o os os ea 03 92 93 99 rn epe pe pr pe ps pe TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F62 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK Industrial I O DeviceNet Products DeviceNet Rugged Fully Potted Stations Monitor E Stop Switches with DeviceNet IP 67 IP 68 IP 69K Protection Automatic Baud Rate Sensing E Connect Sta
175. ution Outputs U Power supply Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 Material Connectors Nickel plated brass Housing Nylon Diagnostics Physical e One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 0 138 03 5 MOUNTING HOLE 2x Network Connector DeviceNet Pinout Address eurofast Male Switches 1 Shield 5 A 2 V Diagnostic 3 V 1 3 EDs 4 CAN H 5 CANL 1 0 connectors Aux Power Power LEDs UB Bus InputPower UL 0utputPower Power connectors 1 181 30 0 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr omme of or fo 1 91 d 1 prete JANNE eye i deo Note Total output current for the station is limited to 4 A Output Connectors E DeviceNet Mating cordset PSG 3M I O Data Map 1 DEI 0 05 7 05 6 05 5 05 4 05 3 os 2 0s 1 oa o 0 7 es os os o o2 o3 TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F94 Courtesy of Steven Engineering I
176. uts 1 Shield Drain 2 V 24 VDC E DeviceNet 3 V 0 VDC 4 CAN High 5 CAN Low picofast I O connectors piconet stations with discrete I O are available with picofast M8 connectors See the individual product pages in this catalog for detailed pinouts eurofast I O connectors piconet stations with analog and special function I O are available with eurofast M12 and in some cases M23 connectors See the individual product pages in this catalog for detailed pinouts Auxiliary Power Connectors piconet stations have two 4 pin picofast auxiliary power connectors one male and one female that allow the stations to be daisy chained from one power supply to another without using a T connector Two power supplies are connected through the auxiliary supply one for the station electronics and inputs and one for outputs Aux Power picofast Male picofast Female 2 U 3 Gnd 4 Gnd Stations may be available with different connector options than the standards mentioned here Consult your local sales representative for different connector options Power Common power specifications for piconet stations Bus DeviceNet Voltage 11 26 VDC Aux Power Voltage 24 VDC nominal e Input Voltage From Auxiliary supply U Output Voltage From Auxiliary supply U TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F86 C
177. utside Local Area 800 258 9200 www stevenengineering com Industrial Automation Industr A 50NG 0600D 0008 a ER EN UR GE Input Connectors E DeviceNet PI Mating cordset PSG 3M I O Data Map 1 Pe a pre es pa ee ea pen Fs xy xe ee TURCK Inc 3000 Campus Drive Minneapolis MN 55441 Application Support 1 800 544 7769 Fax 763 553 0708 www turck com F90 Courtesy of Steven Engineering Inc 230 Ryan Way South San Francisco CA 94080 6370 Main Office 650 588 9200 Outside Local Area 800 258 9200 www stevenengineering com TURCK prio Industrial I O piconet Products LH DeviceNet Input Output Stations e Rugged Fully Potted Stations e Small Footprint IP 67 Protection Automatic Baud Rate Sensing Electrical e Operating Current 75 mA plus sensor currents from Up e Sensor Current 500 mA total of all sensors from U e Output Current 500 mA per output from U Power Distribution Inputs U Power supply a 191 19 Outputs U Power supply 3 te fo rO Mechanical e Operating Temperature 0 to 55 C 32 to 131 F Protection IEC IP 67 Vibration IEC 68 part 2 6 15 ill O ORO SDNB 0808D 0001 Material CE Connectors Nickel plated brass Housing Nylon Diagnostics Physical One LED indicates an I O fault for the entire station e LEDs to indicate status of DeviceNet communication 0 138 93 5 MOUNTING HOLE 2x

Turck DeviceNet - Steven Engineering

Contents

Download Pdf Manuals

Related Search

Related Contents