ENGINEERING TEST REPORT NUMBER: 10215290EUS1 ON
Contents
1. PowerSupply TLEVMTMDSDOCOB 8 J Y f f 1l 6 of 22 CFR 47 PART 15 SUBPART B CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Nemko Client Name T l Work Order 10215290 Model Number Date 10 196 11 Test Configuration Powered on Transmitting Page 7 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 4 Conducted Emissions Mains ports Purpose The test is intended to demonstrate the compliance of the Equipment Under Test E U T to the limits for conducted disturbance as defined by CFR 47 Part 15 Subpart B Class B Paragraph Number 15 107 Specification Limits Limits for conducted disturbance at the mains ports Frequency Range MHz Quasi peak Limits Average Limits dBuV 0 15 to 0 50 66 56 0 50 to 5 00 5 00 to 30 00 Method of Measurement Procedure ANSI C63 4 2003 Measurements were made using a spectrum analyzer with 10 kHz RBW Peak detector Any emissions that are close to the limit are measured using a test receiver with 9 or 10 kHz bandwidth CISPR Quasi Peak detector See Sections 7 and 8 Page 8 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Test CEPV 01 Tested By Brian Boyea Date of Tests 10 19 11 Test Conditions Test Voltage 120 Vac Temperature2. CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 8 Labeling Requirements Your product has successfully complied with 47 CFR FCC Part 15 B Class B requirements FCC Class B Label This device has been tested and Verified to comply with Part 15 Class of the FCC Rules Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation In addition to placing the above label on your product the three items that are required to be included in your product s manual are 1 For a Class B Verified device the instructions furnished to the user shall include the following or similar statement placed in a prominent location at the front of the manual NOTE This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does
3. Page 10 of 22 QP Margin 17 05 18 22 19 48 18 34 17 89 25 25 21 53 23 27 22 95 15 81 Line 2 CFR 47 PART 15 SUBPART B CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Omia b DOT br 2 2 FOCS 169 30 Conducted Emissions Line 2 Peaks Operator Brian Frequency MHz 0 151 0 159 0 167 0 175 0 184 0 192 0 203 0 211 0 228 0 517 Conducted Emissions Peaks 41 55 39 94 42 85 41 13 41 57 40 99 38 92 39 14 37 26 37 38 Fully Operational FCC AVG Limit 55 98 55 75 55 50 55 27 55 02 54 79 54 49 54 26 53 78 46 00 FCC QP Limit 65 98 65 75 65 50 65 27 65 02 64 79 64 49 64 26 63 78 56 00 Avg Margin 14 43 15 81 12 65 14 15 13 46 13 80 15 57 15 12 16 52 8 62 11 of 22 Margin 24 43 25 81 22 65 24 15 23 46 23 80 25 57 25 12 26 52 18 62 CFR 47 PART 15 SUBPART B N Nemke CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units raphs Test CEPV 01 Test Photo Page 12 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 5 Radiated Emissions Purpose The tests are intended to demonstrate the compliance of the Equipment Under Test E U T to the limits for radiated emissions as define
4. 25 C Humidity 45 Test Results The E U T complies TEST EQUIPMENT Asset Tag Description Manufacturer Model Serial Last Cal Next Cal 674 Limiter Hewlett Packard 11947A 3107A02200 26 Oct 2010 26 Oct 2011 704 Filter High Solar 7930 5 0 933126 29 Sep 2010 29 Sep 2011 Pass 5KHz Electronics 749 0 5m Cable Nemko USA RG213 25 Feb 2011 25 Feb 2012 Assy 1258 LISN 15mhz EMCO 3825 2 1305 25 Oct 2010 25 Oct 2011 30mhz 1663 Spectrum Rohde amp FSP3 100073 2 Sept 2011 2 Sept 2013 Analyzer Schwartz 1988 Cable Coaxial Nemko USA 03 Nov 2010 03 Nov 2011 Inc Page 9 of 22 Test Data Conducted Emissions Power Lines Test CEPV 01 Oma Gera ret Z Tt Line 1 Condected Geisstons OCB 15 19 Mhr es L a Nom CFR 47 PART 15 SUBPART B CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Nemko FCC B Conducted Emissions Line 1 Peaks Operator Brian Frequency MHz 0 152 0 161 0 169 0 177 0 185 0 194 0 203 0 228 0 278 0 525 Peaks 48 90 47 48 45 99 46 88 47 09 39 50 42 96 40 49 39 39 40 19 AVG Limit 55 95 55 70 55 47 55 22 54 99 54 76 54 49 53 76 52 34 46 00 Limit 65 95 65 70 65 47 65 22 64 99 64 76 64 49 63 76 62 34 56 00 Avg Margin 7 05 8 22 9 48 8 34 7 89 15 25 11 53 13 27 12 95 5 81
5. CFR 47 Part 15 Subpart B Equipment with oscillator frequencies above 108 MHz were tested to the fifth harmonic or in accordance with the requirements of CFR 47 Part 15 33 Frequencies were initially identified in a semi anechoic chamber Amplitude measurements were made in a semi anechoic chamber Details of the chamber are on file with the FCC and Industry Canada Abstract Name of Test Basic Standard Conducted Emissions CFR 47 Part 15 Subpart B Para No 15 107 s ERAT Pan 1S SERENE Complies Radiated Emissions CFR 47 Part 15 Subpart B Para No 15 109 THE FOLLOWING DEVIATIONS FROM ADDITIONS TO OR EXCLUSIONS FROM THE TEST SPECIFICATIONS HAVE BEEN MADE NONE Page 3 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 2 Equipment Under Test E U T Manufacturer Texas Instruments Inc Name Development Evaluation Modules Model Number MB PRO MVK MCU 430F5438A MVK AFE BREAKOUT MVK RF BREAKOUT MVK amp RF TCA8418 MVK Serial Number None Part Number MB PRO MVK MCU 430F5438A MVK AFE BREAKOUT MVK RF BREAKOUT MVK amp RF TCA8418 MVK Production Status Production E U T Arrival Date 10 19 11 Description of E U T Development Evaluation Modules Clock Oscillator Highest Frequencies Utilized 25 0 MHz Justification The E U T was configured for testing as per typical installation Position and bundling of cables
6. N Nemko ENGINEERING TEST REPORT NUMBER 10215290EUS1 ON Model No s MB PRO MVK MCU 430F5438A MVK AFE BREAKOUT MVK RF BREAKOUT MVK amp RF TCA8418 MVK IN ACCORDANCE WITH CFR 47 PART 15 SUBPART B CLASS B VERIFICATION TESTED FOR Texas Instruments Inc 12500 TI Boulevard M S 8669 Dallas TX 75243 TESTED BY Nemko USA Inc 802 N Kealy Lewisville Texas 75057 3136 Total Number of Pages 22 APPROVED BY k DATE 3 Nov 2011 Art Ruvalcaba EMC Engineer TESTED BY Tu 4 DATE 19 Oct 2011 Brian Boyea EMC Engineer IVA NVLAP Lab Code 1004260 Nemko USA Inc authorizes the above named company to reproduce this report provided it is reproduced in its entirety for use by the company s employees only This report must not be used to claim product certification approval or endorsement by NVLAP NIST or any agency of the Federal Government Nemko USA Inc is a NVLAP accredited laboratory Any use which a third party makes of this report or any reliance on or decisions to be made based on it are the responsibility of such third parties Nemko USA Inc accepts no responsibility for damages if any suffered by any third party as a result of decisions made or actions based on this report This report applies only to the items tested CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 SECTION 6
7. SECTION 7 SECTION 8 EQUIPMENT EVM Units Table of Contents SUMMARY OF TEST RESULLITS 3 EQUIPMENT UNDER TEST E U T 4 EQUIPMENT CONFIGURATION 6 CONDUCTED EMISSIONS MAINS PORTS 8 RADIATED EMISSIONS 13 MICROWAVE RADIATED EMISSIONS 18 TEST METHODS AND BLOCK DIAGRAMS 19 LABELING REQUIREMENTS 22 Page 2 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 1 Summary of Test Results General All measurements are traceable to national standards These tests were conducted on a sample of the equipment for the purpose of demonstrating compliance with CFR 47 Part 15 Subpart B for Class B Digital Devices These tests were conducted using measurement procedures of ANSI 63 4 2003 The equipment was tested for conducted emissions from 0 150 MHz to 30 MHz using a 50 microhenry line impedance stabilization network L I S N as described in ANSI C63 4 2003 Peripheral equipment was also operated through 50 microhenry L I S N The equipment was tested for radiated emissions from 30 MHz to 1000 MHz in accordance with the requirements of
8. cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver Connect the equipment into an outlet on a circuit different from that to which the receiver is connected Consult the dealer or an experienced radio TV technician for help 2 The user s manual must caution the user that changes or modifications not expressly approved by the party responsible for compliance you your company could void the user s authority to operate the equipment 3 In addition the instruction manual must include appropriate instructions on the first page of the manual concerning installation of the device or special accessories special cabling shields adapters that must be used with the device An appropriate caution statement should warn the user to utilize the special accessories supplied with the equipment for continued FCC compliance Page 22 of 22
9. 0 00 40 00 24 84 15 16 96 01 43 50 32 06 11 44 108 86 43 50 30 76 12 75 147 78 43 50 30 99 12 51 218 76 47 00 17 22 29 79 232 67 47 00 28 68 18 32 400 96 47 00 13 34 33 66 500 03 47 00 20 13 26 87 800 01 47 00 31 70 15 30 27 77 19 23 837 86 47 00 15 48 31 52 871 63 47 00 27 52 19 48 899 95 47 00 29 96 17 04 900 01 47 00 34 24 12 76 996 38 54 00 26 33 27 67 MB PRO MVK Rev F MCU 430F5438A MVK AFE Breakout MVK RF Breakout MVK RF TCA8418 MVK 30 MHz to 1GHz was the spectrum searched RBW 120kHz VBW 120kHz Page 16 of 22 47 PART 15 SUBPART N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Test Photographs Test REHE 01 Page 17 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 6 Microwave Radiated Emissions N A The has no clocks above 108MHz Purpose The tests are intended to demonstrate the compliance of the Equipment Under Test E U T to the limits for radiated emissions as defined by CFR 47 Part 15 Subpart B Class B Paragraph Number 15 109 Specification Limits Limits for radiated disturbance of Class B Frequency Range MHz 3m Limits dBuV 10m Limits dBuV Above 960 Method of Measurement Procedure ANSI C63 4 2003 The equipment was prescanned in a semi anechoic chamber using a spectrum analyzer and horn antenna A list of frequencies wa
10. 6 11 2011 11 2012 1767 Receiver Rohde amp Schwartz ESIB26 837491 0002 01 Dec 2010 01 Dec 2011 Test 20Hz 26 5 GHz 150 30 dBm LCD 1783 Cable Assy 3m Nemko Chamber 26 Sept 2011 26 Sept 2012 Chamber Page 14 of 22 47 PART 15 SUBPART N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Test Data Radiated Emissions Electric Field Test REHE 01 Nem s emo IBFFD M K Rw MOHSRGSAMW FCC Class B 30 MHz 1GHz FE Ras Hrizatd m FP Beckot M K FR TOBHGMK 80 0 70 0 60 0 50 0 340 0 230 0 20 0 10 0 0 30 0M 230 0M 430 0M 630 0M 830 0M Fregery B Oprda Bin 05 41 25 AM Odder Z 21 i Nemiko B PRO M VK Rev F MCU 430F5438A M VK REBlimit Srs FCC Class B 30M Hz 1GHz AFE Breakout M VK Ras Vertical Scan RF Breakout M VK RF TCA8418 M VK go 80 EET E ao ao 100 t t t t am nor enar Frequency Operator Brian 06 41 34 AM Thursday October 27 2011 Page 15 of 22 CFR 47 PART 15 SUBPART B N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Lewisville TX FCC 3 Meter Chamber Final Quasi Peak Measurements Operator Brian Frequency Limit Horizontal QP Vertical Vertical MHz QP Margin QP Margin 6
11. d by CFR 47 Part 15 Subpart B Class B Paragraph Number 15 109 Specification Limits Limits for radiated disturbance of Class B Frequency Range MHz 3m Limits dBuV 10m Limits dBuV 30 230 40 0 30 0 230 1000 Method of Measurement Procedure ANSI C63 4 2003 The equipment was prescanned in a semi anechoic chamber using a spectrum analyzer and broadband antenna A list of frequencies was compiled for investigation in the semi anechoic chamber The bandwidth was set to 100 kHz and the detector function was CISPR Quasi Peak Any emissions above 1 GHz were measured with a horn antenna and low noise pre amplifier at a distance of 3 meters See Sections 7 and 8 Page 13 of 22 Test Tested By Date of Tests Test Conditions Test Voltage Temperature Humidity Test Results The E U T complies REHE 01 Brian Boyea 10 19 11 120 Vac 25 45 CFR 47 PART 15 SUBPART CLASS VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units TEST EQUIPMENT Asset Description Manufacturer Model Serial Last Cal Next Cal Tag 1 3m Semi Nemko USA Inc Chamber 1 26 Sept 2011 26 Sept 2012 Anechoic Chamber 1016 Preamplifier Hewlett Packard 8449A 2749A00159 20 July 2011 20 July 2012 1025 Preamplifier Nemko USA Inc LNA25 399 23 Feb 2011 23 Feb 2012 25dB 1304 Antenna Horn Electro Metrics RGA 60 6151 24 Nov 2010 24 Nov 2012 1763 Antenna Bilog Schaffner 61110 2292
12. r or Test Receiver Page 19 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Radiated Emissions Test Method Radiated Emissions Applicable Test Standard CFR47 FCC Pt 15 Subpart B The test set up in the shielded room is as per the test configuration diagram The E U T is configured as typically used The E U T and any accessories are operated with typical load conditions Radiated emissions measurements are made from 30 MHz to 1000 MHz The equipment was prescanned in the semi anechoic chamber using a spectrum analyzer and broadband antenna to produce a list of frequencies e Variations in antenna height antenna polarization and E U T azimuth are explored to produce the emission that has the highest amplitude relative to the limit e The frequencies noted in the preliminary test are investigated on the semi anechoic chamber where amplitude measurements are made Any emissions above 1 GHz are measured using a horn antenna and low noise pre amplifier at a distance of 3 meters The bandwidth was set to 1 MHz and the detector function was average Page 20 of 22 CFR 47 PART 15 SUBPART B N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Test Configuration Radiated Emissions Radiated Pre scan AND PLOTTER OR TEST RECEIVER Semi Anechoic Chamber SPECTRUM ANALYZER COMPUTER Page 21 of 22
13. s compiled for investigation in the semi anechoic chamber with an average detector Any emissions above 1 GHz were measured with a horn antenna and low noise pre amplifier at a distance of 3 meters The bandwidth was set to 1 MHz and the detector function was average See Sections 7 and 8 Page 18 of 22 CFR 47 PART 15 SUBPART B N CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 7 Test Methods and Block Diagrams Conducted Emissions Mains Ports Applicable Test Standard CFR 47 FCC Pt 15 Subpart B The test set up is as per the test configuration diagram The E U T is configured as typically used The E U T and any accessories are operated with typical load conditions Conducted power line measurements are made from 150 kHz to 30 MHz For each current carrying conductor of each power cord associated with the E U T the emission closest to the limit is recorded e Initial measurements are made using a spectrum analyzer with 10 kHz RBW peak detector If emissions are below the Average limit the unit is deemed to be compliant e Any emissions within 6dB of the quasi peak limit are measured using a test receiver with 9 kHz bandwidth CISPR quasi peak detector e Bandwidths used on the test receiver are those specified in CISPR 16 1 Test Configuration Power line Conducted Emissions Line Impedance Stabilization Network AC Power Source L L S N Spectrum Analyze
14. were investigated to establish maximum amplitude of emissions Exercise Program The E U T exercise program used during radiated and conducted testing was designed to exercise the various system components in a manner similar to typical use The EUT was in the following exercise mode Powered on running Page 4 of 22 47 PART 15 SUBPART N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Page 5 of 22 CFR 47 PART 15 SUBPART B N Nemko CLASS B VERIFICATION REPORT NO 10215290EUS1 EQUIPMENT EVM Units Section 3 Equipment Configuration Date 10 19 2011 USE ONLY DR 10215290 Company T I EQUIPMENT CONFIGURATION LIST HARDWARE PERIPHERALS Place next to EUT and any item that is part of the EUT Hem Generic Description Manufacturer ____ Serial __ Rev FCC ID Status A EvaluationModule TMDSDOCKR S7 j B loop Latitude D61O 20618812117 PowerSupply HA6NSCQ0 __ o 1 FCC ID STATUS 1 FCC DOC 3 None If performing FCC testing contact lab manager 2 FCC A B Verification 4 Certification include FCC ID in parenthesis INTER CONNECTION CABLES Place next to EUT and any item that is part of the EUT Cable Type Manufacturer Inm Term Shield Qty UB emetic t
Download Pdf Manuals
Related Search