Owner`s Manual
Contents
1. REFRIGERATION VEREST EVEREST REFRIGERATION Commercial Refrigerators amp Freezers Owner s Manual for models Chef Bases ECB52D2 ECB52 60D2 ECB72D4 ECB82D4 ECB82 84D4 ECB82 86D4 ECB96D4 A Step Above the Standard q i i a ms iniiai UT Lae RTL LIL 7c E Danian ETTET Mimiti dd Thank you for selecting an EVEREST product www EVERESTref com D D ENERGY STAR Y STAR STANDARD 7 ISO 9001 ue REFRIGERATION VEREST MANUFACTURING A Step Above the Standard 967 Sandhill Ave Carson CA 90746 Tel 310 323 6586 800 444 6285 Fax 310 323 7524 Visit our website at www EVERESTref com REFRIGERATION VEREST REFRIGERATION VEREST Safety Notices Safety Notices WARNING Read and follow all safety notices in this installation guide These notices provide helpful safety and efficient operation WARNING When using your appliance always follow basic precautions including the following When installing the unit be careful that the electrical cord is not under the unit or pressed against the wall This could cause damage to the cord To prevent electrical shock please do not plug or unplug the cord with wet hands Install the unit on a hard and level surface Please do not store temperature sensitive items in the unit such as medical or science research related materials Before starting the unit for the first time make sure2. etc After unplugging the unit please wait at least 6 minutes before re plugging it in Failure to do E so could cause extensive damage to the compressor If the unit will not be used for an extended period of time please unplug it from the outlet The refrigerator compartment s temperature should be set from 33 40 F Setting the temperature out of the recommended ranges will void the unit s warranty REFRIGERATION VEREST Do not use the electrical cord or plug if they are damaged in any way Avoid installing the unit where it could be exposed to water or moisture Avoid touching frozen foods or containers especially metal containers with wet hands It could cause frostbite Please do not attempt to remove or repair any components unless you are an authorized service technician Keep the drawers closed properly at all times Check periodically if the drawer gaskets seal perfectly Losing cold air from the cabinet due to old gaskets will lead to a severe damage to the product and increased electrical consumption Installation Guide Install the unit on a hard and level surface or the unit could produce undesired noises Indoor Use Only Outdoor use may cause a decrease in performance and significant damage to the Do not build an enclosure or cabinet around the unit Restricting the airflow around the unit s condenser area will cause the compr
3. not warrant economic loss profit loss or special indirect or consequential damages including without limitation losses or damages arising from food or product spoilage claims caused by refrigeration failure B IMPROPER USAGE EVEREST is not responsible for parts or labor coverage for component failure and or other damages resulting from improper usage installation or failure to clean and or maintain product as set forth in the user s manual provided with this unit All EVEREST products are designed for commercial usage not for residential use Therefore the warranty will not be honored if product is installed in a residential house C WARRANTY IS NOT TRANSFERABLE Warranty is limited to only the original purchaser user to whom delivered It is not transferable D ALTERATION NEGLECT MISUSE ABUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD EVEREST is not responsible for malfunctions due to alteration neglect misuse abuse accident damage during transit or installation fire flood storm and or other acts of God And EVEREST is not responsible for any improper electrical connections resulting from electrical power failure the use of extension cords and low voltage or voltage drops to the unit E UNAUTHORIZED MODIFICATION EVEREST is not responsible for the repair or replacement of failed or damaged components resulting from unauthorized modifications to units or the use of non standard parts without
4. prior written approval from EVEREST F RESIDENTIAL NON COMMERCIAL USE This warranty does not apply to a unit installed in a residential setting This unit is for commercial use only G OUTSIDE THE U S This warranty does not apply to any parts and or labor warranty claims made on units sold or used outside of the United States ADDITIONAL FOUR 4 YEAR COMPRESSOR WARRANTY In addition to the warranty set forth above EVEREST warrants the hermetically sealed compressor for an additional four 4 years not to exceed sixty 60 months from the date of shipment from EVEREST provided upon receipt of the compressor manufacturer examination shows the sealed compressor to be defective This compressor warranty does not apply to any of the other parts of the unit including compressor start components which are covered under the one 1 year parts and labor warranty These warranties are exclusive and in lieu of all other warranties expressed or implied and all other obligations or liabilities on our part and we neither assume nor authorize any other person to assume for us any other obligation or liability in connection with the sale of said refrigeration units or any part thereof ADDITIONAL SIX 6 MONTHS PARTS AND LABOR WARRANTY WHEN WARRANTY REGISTRATION CARD IS RETURNED TO EVEREST WITHIN THIRTY 30 DAYS OF PURCHASE REFRIGERATION es on Ge Sy V MANUFACTURING U E R S l
5. the interior of the unit and the evaporator coil Rust resulting from the lack of or improper maintenance will not be covered under warranty Interior Cleaning Clean the interior surface of the unit with mild soap and warm water Do not let water accumulate inside the unit To prevent water damage wipe the interior of the unit with a dry cloth as needed Do not use abrasive cleaners concentrated detergents bleaches cleaning waxes solvents or polishes to clean the interior of the unit Condenser Coil Cleaning Poor condensing unit performance is caused by heavy dust build up on the condenser coil The condenser coil should be cleaned monthly Shine a flashlight through the condenser coil to check for dirt between the fins Clean the outside of the condenser with a soft brush or a vacuum with a brush attachment The condenser coil should be cleaned in the direction of the fins top to bottom not side to side Be careful not to bend the fins Trouble Shooting BEFORE YOU CALL REFRIGERATION VEREST Please check the following before requesting service P Symptom Possible Solutions Condensing unit fails to start Cabinet does not maintain proper temperature Refrigerated compartment is too cold Noisy operation Condensation on the exterior surface Sound of water dripping Exterior walls are warm Condensation on the interior a Check to see that that the electrical cord has
6. the unit is free from all packaging Packaging left on the unit during G operation may cause a fire hazard Before cleaning or maintaining the unit please unplug it Do not use any flammable cleaning products on or around the unit Please do not hang or climb on the unit as this may cause the unit to fall If you suspect a refrigerant leak unplug the unit and immediately contact an authorized service technician To minimize shock and fire hazards be sure not to overload the outlet into which the unit is plugged into A dedicated circuit of sufficient amperage is preferred Clean the pronges of the electrical plug with a soft cloth or brush before plugging it into an electrical receptacle to prevent a fire hazard wi P m P Sl J F vos cy La M information Failure to do so may lead to serious injury and or damage to the unit To prevent electrical shock and malfunction do not spray the unit with water When it is time to salvage the unit make sure to remove the rubber gaskets from the drawers to prevent the risk of children or animals getting trapped inside the unit Caution To prevent electrical shock and damage to the electrical cord please hold gt e i the plug head tek when plugging and unplugging the unit Do not put your hands under the unit when moving it You could be injured by sharp edges protruding parts crushing
7. When the number is flashing release the button Caution If PS symbol appears on the LED it means that you pressed and held D button too long Release it and then press D button twice to restart the temperature setting Step2 While flashing the number set your desired temperature by pressing C high or E low button The number increases or decreases by a decimal point Note Your new setting temperature should be in the range of between 32 F and 42 F Step 3 Press D button to get out of the setting mode The LED will show the current cabinet temperature ECB82D4 ECB82 84D4 ECB82 86D4 ECB96D4 32 21 3 4 Critical Information CONDENSER COIL MAINTENANCE Failure to maintain a clean condenser coil will eventually result in compressor failure and product loss Mechanical failures due to a lack of or improper maintenance are not covered under warranty Keeping the condenser coil clean will maximize energy savings Cleaning of the condenser coil is part of regular maintenance and is not covered under warranty CONDENSER COIL CLEANING PROCEDURE Please use the following steps to clean the condenser coil If you have any questions regarding this procedure please call the Everest customer service department at 800 444 6285 1 Open the front left panel door 2 Remove condenser coil dust filter by sliding it up 3 Clean the condenser coil dust filter by wiping both sides dow
8. dividers required Full 2 Vertical Pan Dividers 2 Vertical Pan Dividers 5 Vertical Pan Dividers 5 Vertical Pan Dividers ECB52D2 2 B Drawers ECB52 60D2 2 B Drawers ECB72D4 4 A Drawers ECB82D4 2 A Drawers and 2 B Drawers ECB82 84D4 2 A Drawers and 2 B Drawers ECB82 86D4 2 A Drawers and 2 B Drawers ECB96D4 4 B Drawers REFRIGERATION Specifications ECB52 60D2 ECB72D4 ofFullSizePanCapacity 6 6 8 amp 8 Refrigerant Crated Weight LBS 284 REFRIGERATION VEREST ECB82D4 10 4 1 3 115 60 1 32 42 R 134a 412 Amps A SO CS l o Power VHEPh Crated Weight LES Amps i NOTE Exterior height does not include 5 overall height casters Specifications subject to change without notice A N Warning Do not attempt to adjust pan dividers when loaded r Ll 7 REFRIGERATION Temperature Setting A CUEREST REFRIGERATION VEREST Ee pens oar ee ony eee nee LED Display A Operation of compressor B Current cabinet temperature Control Buttons i Side View hy Oi C Power button ECB52D2 ECB72D4 D Temperature setting button eaea J E Defrost button How to set desired temperature Step 1 Press and hold D button until the LED displays SEt symbol and a number consecutively The number is the previous setting temperature recommended setting is 35 F
9. essor to work harder which can result in compressor failure and the unit not being able to maintain the desired temperature REFRIGERATION VEREST The unit should be positioned at least 7 away from the wall for proper ventiliation For side mount units a 7 space should also be afforded to the left side of the unit or wall Pa Bak nall Dusty and High Humidity Areas Dusty environments will cause the condenser coil to prematurely clog which will require it to be cleaned more often High humidy environments could cause the unit to rust Select a location away from other heat and moisture generating equipment such as stoves ovens dish washers etc High ambient temperatures cause the compressor to work harder which can result in compressor failure and the unit not being able to maintain the desired temperature REFRIGERATION Maintenance Guide UEREST Door Gasket Cleaning To preserve the life soan of the drawer gasket clean the gasket with mild soap and water on a regular basis Plastic Pan Cleaning Periodically remove the pans from the unit and clean them with mild soap and warm water Do not use the following products when cleaning Clean the exterior of the product with a stainless steel cleaner only Never use steel wool strong acids abrasive cleaners or degreasers Acidic products and products containing vinegar must be stored in sealed containers to prevent acid damage to
10. lation and start up in accordance with the instruction packet supplied with each unit Our obligation under this warranty is limited to a period of one 1 year from the date of original installation or fifteen 15 months after shipment date from EVEREST which ever occurs first Any part covered under this warranty that is determined by EVEREST to have been defective within one 1 year of original installation or fifteen 15 months after shipment date from the manufacturer which ever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include standard straight time labor charges only and reasonable travel time as determined by EVEREST WARRANTY CLAIMS All warranty claims for labor or parts must be made directly through EVEREST All claims shall include unit model number cabinet serial number proof of new product purchase installation date and all pertinent information related to the alleged defect For compressor warranty claims the compressor tag shall be returned to EVEREST with the above listed information WARRANTY EXCLUSIONS EVEREST s sole obligation under this warranty is limited to either the repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty A INDIRECT OR CONSEQUENTIAL DAMAGE EVEREST does
11. n with a damp cloth 4 Replace the dust filter by sliding it back into place and close the front left panel door The warranty card below must be submitted to Everest within thirty 30 days of purchase WARRANTY REGISTRATION CARD Business Name ___ CSCS CSSS SSSSSCO P ____ Tele hon Address City Place of Purchase _____ d Datte Purchased _________ Date Installed Cabinet Serial No ModelNo INSTANT ADDITIONAL SIX 6 MONTHS EXTENDED PARTS amp LABOR WARRANTY We offer a FREE additional six 6 Months extended parts amp labor warranty to customers who return this warranty registration card to Everest within one 1 month of the date of purchase EXTENDED WARRANTY OPTIONAL Additional 1 year parts amp labor extended warranty available for only 199 00 Please make check payable to EVEREST Refrigeration and return it with this registration card L_lYes would like to purchase the extended warranty L_INo have declined to purchased the extended warranty Name of Business Owner ees Date Signature of Business Owner REFRIGERATION VEREST REFRIGERATION VEREST Warranty Certificate EVEREST LIMITED WARRANTY EVEREST warrants to the original purchaser of every new EVEREST unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal and proper use and maintenance service as specified by EVEREST and upon proper instal
12. not been disconnected b Check to see that the unit is turned on a Check the drawer gasket for proper seal b Check to see if the temp control setting is too high and adjust as necessary c Avoid installing the unit next to heat generating equipment and direct sunlight d Avoid storing hot contents e Make sure the drawers are fully closed a Adjust the temperature control to a warmer setting a Check for loose parts b Check for tubing rattle c Check for a bent fan blade d Check for damaged fan motor bearings e Check that the unit is stable f Check that the cabinet is level a Condensation on the exterior surface of the unit is perfectly normal during periods of high humidity b Check drawer alignment and gaskets for proper seal a This is the sound of the refrigerant circulating during the compressor rest period and it is normal a Heaters have been placed around the drawer openings to prevent condensation buildup This is normal a Condensation can occur during hot and humid weather with frequent or prolonged drawer opening This is normal b The drawer might not be closed roperly Check door alignment and gaskets for proper seal Pan Configurations Drawer Type A i aa No pan dividers required S 1 Vertical Pan Divider 1 Vertical Pan Divider 3 Vertical Pan Dividers 3 Vertical Pan Dividers VEREST Drawer Type B Standard No pan
Download Pdf Manuals
Related Search