67.EPC Operation - Custom Service Hardware
Contents
1. Cherries Jubilee Peppercorn Beef Flambe Clean ventilating fans frequently Grease should not be allowed to accumulate on fan or filter Use proper pan size Always use cookware appropriate for the size of the surface element TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A RANGE TOP GREASE FIRE OBSERVE THE FOLLOWING SMOTHER FLAMES with a close fitting lid cookie sheet or metal tray then turn off the burner BE CAREFUL TO PREVENT BURNS If the flames do not go out immediately EVACUATE AND CALL THE FIRE DEPARTMENT NEVER PICK UP A FLAMING PAN you may be burned DO NOT USE WATER including wet dishcloths or towels a violent steam explosion will result Use an extinguisher ONLY if You have a class ABC extinguisher and know how to operate it The fire is small and contained in the area where it started The fire department is being called You can fight the fire with your back to an exit Do not place any electrical parts in water or spray water on them Such a situation could result in fire or electrical shock In the situation of a potential gas leakage do not switch the unit on and off as it could result in a gas explosion Do not attempt to modify or repair this product Refer all servicing to qualified personnel otherwise it may result in fire electric shock or injury ZA CAUTION For general ventilating use only Do not use to exhaust hazardous or explosive material and vapors To reduce the risk o2. FUSION I Operation Manual RANGE HOOD I MODEL ECP 360 TABLE OF CONTENTS Salely NSIC OMS cesses secs ip ceaepste ect a a O eea ia 2 PUTS OT TS ensisi enan ian aaa n aa iiia aa 4 Operating the Range Hood isa aise warscncseanesenncansansee sundeatecwessnueenacasenecnceosaceeessoituineeeemnes 4 FOW TO UGE cr E E E E E S 5 Care and Wan GANGS re henaneedoraseniaduneusieimiansndecnceniaedutiadesuaasuedsennsadodaveyataneasaueesiadsnicas 6 ISAS SOO MING criaient 7 Aea e E E E 7 Re ASSemMmDINO sssrini EE EEE EE E EE AEE SEEE 8 Replacing the MNO BUlD cessor ct rr saa E RET ai 8 Requesting Service acct ss seth tics sine tascede nenrciantosian cote se siceisdeanionia woteiesins aincieastaanceeneeosnees 9 Prior to Requesting Service nics cvecesacicensmedsietnancanseedwaisedeiesmsiexestonenatessebdedssinedsaenass 9 HSI CHOU LAD Cl asseconda 9 SS Cl NGA OM NS scissa ionidan na NNR E dent iancsitetant ai decsadone EEEE E ORENA 10 TICE NA AN poses ot ectcana E E E 10 FU E DEE SE PAE E E E E E TEE EE ETE 11 Limited Product Wan ANY assisen aaen E EnA aei 12 READ AND SAVE THESE INSTRUCTIONS Keep this manual in a convenient place for future reference FUJI INDUSTRIAL CO LTD 1U02 1581 SAFETY INSTRUCTIONS Before installation and operation read these instructions carefully and use this product only in the manner described by the manufacturer in the operation manual The signal words shown below are used to alert you to potential p
3. Zs ee 2 the range hood be sure to set the lamp and off switches to the OFF position then switch off the breaker of service panel e For safety always wear working gloves safety glasses or goggles while cleaning the filter etc e Keep people away when cleaning to avoid injury from unexpected falling of parts or splashing of detergent CAUTION e Do not splash water on the electric parts such as the switch or connectors Do not use a spray type detergent to clean electric parts It may cause trouble e Do not use solvents such as thinner benzine or the like and polishing powder for cleaning the painted surfaces face plates etc as these parts may become lusterless or scratched e Do not wash parts with a hard brush or the like for cleaning as it can cause damage i mblin Rectifier Baffle Panel After loosening 2 screws fixing the rectifier baffle panel slide the panel to dislocate the keyholes from the screws Then open the panel a little and pull it to remove from the catches NOTE As the rectifier baffle panel may have grease built up be careful about oil drips when removing it Filter First turn the knob counter clockwise then detach the filter with sliding it in the direction of the arrow to disengage from the groove leanin Filter After immersing the filter in water with a mild detergent for 30 to 40 minutes wash it with a toothbrush or the like to remove dirt Clean the fil
4. asured airflow under HVI 916 and noise levels under Japanese Industrial Standard JIS C9603 items 8 8 and 8 9 Lamp Switch Fan Switch Connector Black Connector orani Grey _ Yellow i SSII Lamp Lu N Motor S Yellow Yellow a White White M slack Connector To BeAT Connector 120V 60Hz White Purple B Capacitor 10 Back Panel Fan Unit Case Earth Wire Unit o Z 2 A O g o 2 3 D O C LLI ab Cc A _ Cc O L LL a 6 SiroccoFan _ Bellmouth Wire Box Unit 9 Switch Box Unit Motor Gm bop U Exhaust Pipe Unit Mounting Bracket Inner Duct Outer Frame Inner Frame Rectifier Baffle Panel 19 Attachment Attachment Name of parts 8 Pieces Eight M5 1 x 45 11 limited proc Warran The Fujioh product warranty is to the original purchaser consumer of its products only and is not transferable Fujioh warrants that its products will be free from defects in materials or workmanship for a period of three years from the date of original purchase THERE ARE NO OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE During this three year warranty
5. ating Low In case of light cooking Medium Usual position III High In case of heavy cooking To stop the fan just push the button Push the button if you want to turn the light on To turn it off push the button again how to use Before operation make sure that the rectifier baffle panel and filters are attached securely A CAUTION During cooking do not touch the rectifier baffle panel or its screws If the rectifier baffle panel is attached incorrectly it may become detached and fall down Do not touch the lamps or their peripheral areas when they are ON or your hand may r r be burned as they get overheated DON T TOUCH Do not use a gas range with nothing on the burners Otherwise the range hood could become overheated and it might be a cause of failure Stop running the range hood immediately if a fire occurs while cooking Continued operation of the range hood will add intensity to the fire r na MaihntenaNn Clean the range hood as many times as possible especially clean the filter once a month as it becomes dirty and deteriorates in function if it s left unclean For a family size of 4 to 5 people and cooking twice a day clean the filter once every two weeks to avoid grease contamination and grease build up which is difficult to clean J CAUTION Control Switches e Before replacing the light bulb or cleaning
6. ersonal injury and property damage hazards There are three hazard classifications based on potentially dangerous situations Obey all safety instructions that show these symbols to avoid possible injury death and property damage AN WARNING WARNING indicates a potentially hazardous situation which if not avoided could result in death or serious injury A CAUTION CAUTION indicates a potentially hazardous situation which if not avoided may result in minor or moderate injury CAUTION CAUTION used without the safety alert symbol indicates a potentially hazardous situation which if not avoided may result in property damage A WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK OR INJURY TO PERSONS OBSERVE THE FOLLOWING Use this unit only in the manner intended by the manufacturer If you have questions contact the manufacturer Before servicing or cleaning the unit switch power off at service panel and lock the service disconnecting means to prevent power from being switched on accidentally When the service disconnecting means cannot be locked securely fasten a prominent warning device such as a tag to the service panel TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE Never leave surface units unattended at high settings Boilovers cause smoking and greasy spillovers that may ignite Heat oils slowly on low or medium settings Always turn hood ON when cooking at high heat or when flambeing foods i e Crepes Suzette
7. f fire and to properly exhaust air be sure to duct air outside Do not vent exhaust air into spaces within walls ceilings or into attics crawl spaces or garages Read specification label on this product for further information and requirements Switch power off at the service panel when you won t be using the range hood for a long period If you do not do so damage to the electrical insulation may result Fasten the filter and other parts securely Incorrect attachment may result in personal injury or damage to property Do not use a commercially sold filter or filter cover on the filter part as it may affect its performance and cause trouble To protect hands from injury from the edges of the sheet metal wear working gloves while servicing NOTE The safety instructions are explained with the following pictographic symbols means prohibition It indicates actions if any that mustn t be done means forcible execution It indicates actions if any that must be done Duct Cover Enclosure Control Switches Lamp Not supplied Rectifier Baffle Panel Control Switches H II Pilot Lamp Lamp Switch OFF Switch High Switch Low Switch Medium Switch operating the Range Hood The range hood has five control switch buttons on its front cover Push one of the switches II according to your cooking need The fan will start rot
8. ot operate Is power switch on at the service panel Range Hood is noisier than usual Is the filter contaminated by grease or vibrating Lamp does not turn on Is the bulb broken Is the bulb put in the socket correctly NOTE e Service parts are kept at the manufacturer for a maximum of six years after ceasing the production of this model e Requesting service indirectly can be done through contacting the dealer who sold this range hood to you e When the range hood is not working normally even after checking common errors please provide the following information to Fuji Industrial USA Inc FIU Fuji Industrial USA Inc 16300 Christensen Rd Ste 212 Seattle WA 98188 3403 Telephone 1 888 547 9880 After Service Division Telephone 1 866 FUJI IND 1 866 385 4463 Product Range Hood Model Number ECP 360 Serial Number Date of purchase What is the problem Owner s address Owner s telephone number Suggested date for service person s visit TQ SANOM in ion The model number and serial number are indicated on the inspection label which is attached to the inside of the Range Hood Remove the rectifier baffle panel to see it Inspection label specifications Refer to the following table Pi Frequency Speed Power Air Flow CMF Noise Hz at 25 Pa Level dB 51 0 ECP 360 39 5 spe AA 295 5 NOTE FUJI INDUSTRIAL CO LTD has me
9. period Fujioh will at its option repair or replace free of charge any product or part that is found to be defective under normal use and service This warranty does not cover 1 Normal maintenance and service or 2 Any products or parts that have been subject to misuse negligence accident improper maintenance or repair faulty installation or installation not in accordance to recommended installation instructions 3 Light Bulbs The duration of any implied warranty is also limited to the three year period as specified above for the express warranty In that case above limitation may not apply to you FUJIOH S OBLIGATION TO REPAIR OR REPLACE PRODUCT OR PARTS AT FUJIOH S OPTION SHALL BE THE PURCHASER S SOLE AND EXCLUSIVE REMEDY UNDER THIS WARRANTY FUJIOH WILL NOT BE LIABLE FOR INDIRECT INCIDENTAL CONSEQUENTIAL OR SPECIAL DAMAGES ARISING OUT OF OR IN CONNECTION WITH PRODUCT USE OR PERFORMANCE Some states do not allow the exclusion of incidental or consequential damages In that case the above limitation may not apply to you This warranty gives the original purchaser consumer specific legal rights and there may also be other rights that vary from state This warranty supersedes all prior warranties To qualify for warranty service first 1 Notify Fujioh at the address shown below or telephone 1 888 547 9880 2 Give the model number and part identification and 3 Describe the nature of any defect in the product or pa
10. rt At the time warranty service is requested proof of purchase and evidence showing the original purchase date must be presented Keep this book and your sales slip together for future reference You must provide proof of purchase or installation date for in warranty service Write down the following information about your Dealer Name Range Hood to better help you obtain assistance or Address service if you ever need it You will need to know Phone Number your complete model number and serial number You Model Number can find this information on the Inspection Label Serial Number located on your appliance as shown in the Operation Purchase Number Manual REQUESTING SERVICE After Service Division Telephone 1 866 FUJI IND 1 866 385 4463 FUJIOH Fuji Industrial USA Inc 16300 Christensen Rd Ste 212 Seattle WA 98188 3403 Telephone 1 888 547 9880 1U02 1581
11. ter frequently to avoid grease contamination and grease build up which is difficult to clean Enclosure Rectifier Baffle Panel After wiping the enclosure and rectifier baffle panel off with a cloth immersed in a mild detergent wipe off moisture thoroughly with a dry cloth mild detergent LN Filter Place the filter in the groove hold it upward and turn the knob clockwise to fix it securely Rectifier Baffle Panel With holding the rectifier baffle panel by both hands place it on the catches Push the panel upward and slide it to engage the keyholes with 2 screws then tighten the screws to fix the panel firmly NOTE Make sure that the rectifier baffle panel and filters are fixed in the appropriate positions correctly Two 50W halogen light bulbs can be installed in this range hood Prior to replacing the light bulb purchase a halogen light bulb PAR20 bulb in the base diameter 26mm medium base rated 120V 50W or below To remove the light bulb turn it counter clockwise Then replace the light bulb with a new one NOTE When replacing the bulb wait until it has cooled off before removing or you may burn your hand To remove the light bulb To install the light bulb r in rvi prior to requesting service Prior to requesting service do the following check by yourself for common errors Situation Check Range Hood does n
Download Pdf Manuals
Related Search