Home

Owner`s Manual

1. X Front Passenger Window D Rear RH Window Switch Switch Driver Door Window E Power Window Lock Switch Switch Child Safety E Rear LH Window Switch The quadruple switch controls the window winding functions of all the doors of the vehicle and is located on the floor console It also houses a rear power windows lock switch for child safety that enables disables the power window operation of both the rear doors when operated independently from the respective door To lower raise the window glass push pull the respective power window switch Copyright Mahindra amp Mahindra Ltd 082015 Rear passengers can also raise or lower their respective window glasses individually by the separate switches provided on both the door trim pads NOTICE This switch will not work if the switch lock at the driver control bank is pressed 8 1 FEATURES AND CONTROL A CAUTION Power windows can be operated only when the ignition is IGN position Do not operate the power windows frequently when the engine is OFF This will drain the vehicle battery If you operate the switch often during a short period of time the system might become inoperable for a certain duration to prevent damage due to overheating The system will return to normal functioning shortly It is recommended operating one window switch at a time AX WARNING While operating the power w
2. A Flat Tyre B Chock Blocks To raise the vehicle insert the jack handle end along with the extension into the jack and turn it clockwise with the jack handle As the jack touches the vehicle and begins to lift check that it is properly positioned Raise it high enough so that the spare tire can be installed Remember you will need more ground clearance when putting on the spare tire than when removing the flat tire 2 16 GD A CAUTION Make sure to set the jack properly in the jacking point Raising the vehicle with an improperly positioned jack will damage the underbody of the vehicle or may allow the vehicle to fall off the jack and cause personal injury e Use the jack only for lifting your vehicle during wheel changing e Do not raise the jack with someone in the vehicle e When raising the vehicle do not place any objects on top of or underneath the jack e Raise the vehicle only high enough to remove and change the wheel e Usable extended height of jack is up to the yellow line mark Do not raise the jack above the yellow line e Follow jacking instructions e Do not start or run the engine while your vehicle is supported by the jack AX WARNING Never get under the vehicle when the vehicle is supported by the jack alone Remove the wheel nuts Lift the flat tyre straight off and place it aside Roll the spare wheel into position and align the holes in the Copyright Mahindra amp Mahindra Ltd
3. 80 120 cso 140 gt 40 160Z 180w 8 29 8 17 Warning Lamps in the Instrument Cluster 8 17 1 Malfunction OBD Lamp The Malfunction OBD Lamp illuminates when the ignition is switched ON and remains ON till the engine has started indicating normal status If the lamp remains ON it indicates a potential engine malfunction There may be a malfunction in e The fuel management system e The emission control system e Systems which affect emissions Such malfunctions may result in excessive emissions Contact an Authorized Mahindra Dealer immediately 8 17 2 Check Engine Lamp The check engine lamp illuminates when the ignition ne is switched ON and goes out in 3 seconds indicating normal status The lamp blinks or illuminates continuously if there is a fault in the engine management system Contact the nearest Mahindra Dealer for the necessary repairs 8 30 CD 8 17 3 Glow Plug Indicator Glow plug indicator illuminates when the ignition is GD turned ON It automatically goes OFF when the glow plug reaches the required temperature Contact an Authorized Mahindra Dealer if the glow plug lamp does not illuminate with ignition ON or illuminates while driving 8 17 4 Security Lamp Once the ignition is turned OFF the security lamp will A blink at a fast rate frequency indicating the vehicle is secured against unauthorized start of engine When the vehicle is locked using RKE security lamp will blink at a sl
4. 9 4 2 Parking Brake A CAUTION Be sure the parking brake is fully disengaged before driving off Failure to do so can lead to brake problems due to excessive heating of the rear brakes e The parking brake should be adjusted as per recommended maintenance schedule e Always apply the parking brake when leaving the vehicle and be certain to leave the transmission in gear Failure to do so may allow the vehicle to roll and cause damage hit a bystander resulting in personal injury e Leaving unattended children in a vehicle is dangerous for a number of reasons Children should be warned not to touch the parking brake or the gear shift lever Do not leave the key in the ignition A child could move the vehicle leading to accidents To apply the parking brake pull the park brake lever up as firmly as possible When the parking brake is applied with the ignition ON the brake warning lamp in the instrument cluster illuminates To release the parking brake pull the parking brake lever up slightly press the release button on the lever tip and lower the parking brake lever completely e The parking brake should always be applied when the driver is not in the vehicle A NOTICE ar Engaging the parking brake while the vehicle is in motion can cause The brake warning lamp indicates only the parking brake status the rear wheels to lock up You could lose control of the vehicle and lt does not indicate the degree of brake applicat
5. Hazard lamps flash twice if there was no theft attempt during the lock armed period Hazard lamps flash four times along with an alarm if there was a theft attempt during the lock armed period A NOTICE Upon the remote lock if any of the doors are not closed properly or are left open the hazard lamps will flash five times to indicate the same 76 7 3 3 Auto Locking All doors will get locked automatically when All doors are closed properly e Vehicle speed is greater than 20 kmph Auto Locking ON DOOR OPEN Once the autolock has been activated if any door is opened then the autolock will reactivate only if all doors are closed the vehicle speed goes above 20 kmph and the master actuator is in the unlock position Auto Locking ON MASTER ACTUATOR UNLOCK Once the auto lock has been activated if the master actuator was unlocked at any vehicle speed then the auto lock will reactivate only when the vehicle speed goes below 5 kmph and further crosses 20 kmph 7 3 4 Auto Unlocking Auto Unlock of all doors will happen when From IGN ON to OFF OR e Inthe event of a crash only on Airbag Variants 7 3 5 Auto Re locking Auto Re lock of all doors will happen when Copyright Mahindra amp Mahindra Ltd 082015 AD e No door status change for 45 sec after unlocking the vehicle using RKE 7 3 6 Search Panic Function N i socio Press the SEARCH PANIC button on the RK
6. e Cooling fan fuse 60A Yellow colour 2 6 Flat Tire Reduce your speed gradually keeping a straight line Move cautiously off the road to a safe place well away from traffic Park on a level spot with firm ground Stop the engine and turn ON your hazard warning flashers Firmly apply the parking brake Have everyone come out of the vehicle on the side away from traffic 2 12 hb WARNING Never stop your vehicle in a traffic lane to change a tire Keep driving until you reach a safe location The jack provided along with the vehicle is to be used only for changing a spare tire lt is never to be used to perform any other maintenance or repair on the vehicle D WARNING Never place any part of your body under any portion of the vehicle when it is supported only by the jack You could be crushed by the vehicle if it falls off a jack Keep by stander s away from the vehicle Find level solid ground that is clear of oncoming traffic If you cannot find a safe place to stop it is better to drive on a flat tire and damage the rim than it is to risk being hit by oncoming traffic After changing a flat tire never store the tire or other equipment in the passenger compartment of the vehicle This loose equipment could strike an occupant in the event of a sudden stop or collision Store all of these items in the proper place The following sections outline the procedure for changing a flat tire 2 6 1 Jack Wheel Spanne
7. 14 1 Opening Closing the Hood eee 14 4 Identifying Components in the Engine COMPAPEMEN Ger ee elles aalddeaeangs 14 6 General Maintenance ieee 14 7 In the Engine Compartment eerie 148 Maintenance Inside the Vehicle 14 14 Maintenance Outside the Vehicle isise 14 14 Battery acids Mani onacunsiate A aem ren 14 15 Appearance Care and Protection 14 16 Air Conditioning System Maintenance 14 20 Vehicle Stora ge ies weccecciissisiiereibenciiananiereieniien Winter Gare ivan ai aa aA N RRN Bulb Replacement visscccccacni ad etesda inni Scheduled Maintenance eee Maintenance Schedule Chart CD INTRODUCTION AND SAFETY PRECAUTIONS 1 INTRODUCTION AND SAFETY PRECAUTIONS We extend our best wishes for safe and pleasurable motoring 1 1 Introduction Sincerely MAHINDRA amp MAHINDRA LTD Dear Customer Congratulations on purchasing Mahindra TUV3O0 Your vehicle has been designed to provide years of safe and dependable service as long as it is used and maintained in accordance with the instructions provided in this manual All persons who will use and or maintain this vehicle must read understand and follow all warnings and instructions provided in this manual This Qwner s Manual should be considered an integral part of the vehicle and should remain with the vehicle However nothing in this manual and none of the safety devices installed in the vehicle are a substitute for careful operation and common sense Al
8. All electrical circuits are enabled Some of the warning or information lamps illuminate in this position While some of the lamps will go out after a few seconds some will continue to remain ON till the engine is started When the vehicle is being driven the ignition switch remains in the IGN position A CAUTION Select the ignition ON position when the vehicle is being towed Do not leave the ignition ON for long when the engine is OFF This could lead to battery drain and ignition switch damage START This position is to start the engine by cranking the starter motor This is a momentary position When the key is turned to the start position the starter cranks the engine Once the engine is running release the key and the key reverts back to the ON position and the starter motor disengages from the engine A CAUTION Do not continue cranking after the engine has started This will lead to damage of the starter and other engine components Copyright Mahindra amp Mahindra Ltd 082015 D A NOTICE If turning the key is difficult jiggle the steering wheel from side to side and try again The key can be removed only in the LOCK position When the key is removed the steering column lock is activated and the steering wheel cannot be turned AX WARNING Never return the key to the LOCK position or try to remove the key when the vehicle is in motion Removing the key allows the steering wheel to lock You will los
9. Dealer or an equivalent quality product to help protect from environmental effects Do not use hydrofluoric acid based or high caustic based wheel cleaners steel wool fuels or strong household detergents 14 9 6 Plastic Non painted Exterior Parts 14 9 4 Paint Chips Use only approved products to clean plastic parts These products are available with your authorized dealer You can use these cleaners e Mahindra dealers have the exact touch up paint to match your vehicle s color 14 17 Copyright Mahindra amp Mahindra Ltd 082015 e For routine cleaning of plastic parts e For tar or grease spots e For plastic head lamp lenses 14 9 7 Windows and Wiper Blades The front rear windshield side windows and the wiper blades should be cleaned regularly If the wipers do not wipe properly substances on the vehicle s glass or the wiper blades may be the cause These may include hot wax treatments used by commercial car washes water repellent coatings tree sap or other organic contamination these contaminants may cause squeaking or chatter noise from the blades and streaking and smearing of the windshield To clean these items follow these tips e The windshield rear windows and side windows may be cleaned with a non abrasive cleaner such as Clear Spray Glass Cleaner available at your Authorized Mahindra Dealer e The wiper blades can be cleaned with alcohol or Premium Windshield Washer Concentrate available at you
10. Check the physical condition of the battery Inspect batteries for cracks leaks or any other damage If you find any of these things do g gt not jump start the vehicle Call Mahindra Road Side Assistance or replace the battery If the weather is very cold remove the refill caps and check the condition of the electrolyte If it seems slushy or like ice do not attempt jump starting until it thaws 1 Park the working vehicle near the disabled vehicle Park the vehicle in such a way that the distance between both vehicle GLOVES eee GOeELES batteries is as small as practical Turn off the engine radio lights A C fans and all other electrical components Make S wenn sure that all of these things are OFF in the disabled vehicle too 13 4 Copyright Mahindra amp Mahindra Ltd 082015 3 4 AD Ax WARNING lt may be necessary to remove the disabled vehicle s battery cables from the battery terminals and clean both cables and terminals Use a stiff wire brush to remove all corrosion Reconnect the cables to the battery terminals and jump the vehicle Untangle and unwind your jumper cables Like your batteries your jumper cables will probably have red and black cables and will have heavy duty clamps to connect to the battery terminals You must make sure that the red and black ends of your jumper cables never touch each other once they are connected to the batteries permitting them to do so can result in
11. e Rinse any spilled electrolyte from the battery immediately with a solution of water and baking soda A CAUTION Do not disconnect battery terminals while the engine is running This will adversely affect all electronic controllers AX WARNING While removing the battery always disconnect the negative terminal first And while installing the battery ensure the negative terminal is connected last It is recommended that the negative battery cable terminal be disconnected from the battery if you plan to store your vehicle for an extended period of time This will minimize the discharge of your battery during storage AX WARNING Battery fluid is a corrosive acid solution do not allow battery acid to contact eyes skin or clothing Don t lean over battery when attaching clamps or allow the clamps to touch each other If acid splashes in the eyes or on the skin flush contaminated area immediately with large quantities of water 14 15 MAINTENANCE A battery generates hydrogen gas which is flammable and explosive Keep any flame or spark away from the vent holes Keep batteries out of reach of children Battery posts terminals and related accessories contain lead and lead components Wash hands after handling batteries If the battery has been disconnected or a new battery has been installed the clock if equipped and the preset radio if equipped stations must be reset once the battery is reconnected The replacem
12. emergency stop WARNING A pregnant woman should never wear the seat belt across the stomach area This could lead to serious injuries to the foetus and or the pregnant mother WARNING Never wear twisted seat belts Excessive forces will be transferred from the belt to the wearer in a collision resulting in serious personal injury Each seat belt is meant for use by one person only Using one seat belt for more than one person at a time is dangerous The seat belt will not be able to spread the impact forces properly leading to serious injuries WARNING Never put a belt around a child being carried on the occupant s lap This could lead to serious injuries Copyright Mahindra amp Mahindra Ltd 082015 CD SEATS AND SEAT BELTS Seat Belt Usage is Necessary to 5 6 Fastening the Seat Belt e Reduce the possibility of being thrown from your vehicle 5 6 1 3 Point type if equipped e Reduce the possibility of injuries to lower body and legs during an accident e Hold the driver in a position which allows better control of the vehicle Children who are too large for child restraint systems should always occupy the rear seat and use the vehicle seat belts The lap portion should be fastened snug on the hips and as low as possible and the shoulder strap should be across the child s shoulder not the neck or face If you are unable to position the strap across the child s shoulder the child should remain in a
13. 7 Whether the A C will function if the engine is switched off No the A C will not work However the blower will be in operation when the ignition is ON 8 What will happen if keep the clutch continuously pressed at traffic signals jams The system will not stop the engine if the clutch is continuously pressed since it indicates the driver s intention of moving the vehicle immediately Copyright Mahindra amp Mahindra Ltd 082015 8 45 FEATURES AND CONTROL GD 10 44 12 13 14 15 16 When the battery charge is low whether the engine will be switched off If the battery charge drops below a certain level the system will not stop the engine so as to preserve the battery from further draining Whether will be able to operate the engine with the normal ignition key Yes normal operation with the ignition key is always possible Whether the vehicle will start or stop in gear The vehicle will not start or stop automatically in gear to ensure safety It will do so only in the neutral position of the gear shift lever Whether the system will stop my engine in moving traffic No the engine will be stopped only when the vehicle speed is zero continuously for more than 2 sec Whether the audio system will be switched OFF when the engine shuts down No the audio system will not be switched OFF and you can continue to enjoy the music Whether the engine will re crank whenever the clutch pedal is presse
14. AD 14 9 2 Engine Compartment e Take your vehicle to an Authorized Mahindra Dealer for paint touch up or paint repairs d CAUTION e Remove particles such as bird droppings tree sap insect deposits tar spots road salt and industrial fallout before Do not wash the engine or engine compartment with repairing paint chips pressurized water e Always read the instructions before using the products 14 9 3 Exterior Chrome 14 9 5 Aluminium Wheels And Wheel Covers if equipped e Wash the vehicle first using cool or lukewarm water and a neutral pH shampoo Aluminum wheels and wheel covers are coated with a clear coat of paint finish In order to maintain their shine e Use the custom bright metal cleaners available at your Authorized Mahindra Dealer Apply the product as you would wax to clean chrome parts allow the cleaner to dry for a few minutes and then wipe off the haze with a clean dry rag Clean weekly with wheel and tire cleaner which is available at your Authorized Mahindra Dealer Heavy dirt and brake dust accumulation may require agitation with a sponge Rinse thoroughly with a strong stream of water e Never use abrasive materials such as steel wool or plastic pads as they can leave scratches on the chrome surface e Never apply any cleaning chemicals to hot or warm wheel rims e After polishing the chrome parts you can also apply a coating of iia Premium Liquid Wax available at your Authorized Mahindra
15. All other settings should be kept same as advised for windshield defogging de misting defrosting For heating the vehicle interior while windshield defogging de misting defrosting select the Foot Defrost mode All other settings should be kept same as advised for windshield defogging de misting defrosting For quickly defogging de misting defrosting the outside of the windshield it is advisable to operate the windshield wiper washer for a few times intermittently If snow has deposited on the windshield use an ice scraper to remove the ice deposited before using the wiper In freezing weather warm the windshield with the defroster before using the windshield washer Also use a washer fluid with Copyright Mahindra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC anti freezing properties This will help prevent the washer fluid from freezing on your windshield A dirty contaminated windshield would make misting fogging worse Always keep the inside and outside of the windshield clean Reduced air flow because of a clogged HVAC filter or any other obstructions in the air flow path may lead to inadequate defogging de misting defrosting performance If the air flow seems to have considerably reduced get the filter cleaned replaced immediately The air flow path should be kept free of obstructions Reduced cooling performance from the air conditioner may lead to inadequate defogging de
16. Copyright Mahindra amp Mahindra Ltd 082015 SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped concentrated to one area and the full force of the impact is not delivered to the sensors Under ride Situations Running under a truck s tail gate may not provide the decelerations necessary for airbag deployment Just before impact drivers often brake heavily Such heavy braking lowers the front portion of the vehicle causing it to ride under a vehicle with a higher ground clearance Air bags may not inflate in this under ride situation where deceleration forces that are detected by sensors may be significantly reduced by such under ride collisions a uaeros_ Rear end Collisions Frontal air bags are not designed to inflate in rear collisions where occupants are moved backward away from the airbags by the force of the impact In this case inflated air bags would not be able to provide any additional benefit SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped e Frontal Impact Rollover Frontal impact beyond 30 range from head on to the vehicle L N a N amp uaorie_ Air bags may not inflate in rollover accidents where air bag loyment would not provide protection to the occupants Pot Holes or Stepped Surfaces deploy P P P fees a PES Side Swipe t Driving into a big pot hole stepped surface or hitting th
17. Fuse puller is available in this fuse box location Ja a Hoon F17 15A Front fog lamp TEA ata IM oie 3 F18 _ aa J F19 15A Low beam T e I a F20 5A BMS F21 15A High beam ais cote arae IES Fe2 15A EKP g F23 10A AC Relay ia 85 fretu E F24 5A ESS WIF TPS fied tune alee on SS F F25 15A EGR PBA FMU a ar F26 10A AC Compressor F27 10A EMS Battery 2 FuseNo FuseRating Circuit F28 10A HFM F1 40A ABS Motor F29 10A EMS Battery 1 30A EMS Loads F30 15A Brake switch F4 Relay No Circuit F5 40A AMT Pump R1 Cooling Fan Low F6 40A Starter solenoid R2 Cooling Fan High F7 40A EC Mini Fuse B R3 AMT Pump F8 25A ABS Solenoid R4 EMS ECU F9 AoA Cowiplug R5 GNS Non ESS F10 R6 Fal R7 Copyright Mahindra amp Mahindra Ltd 082015 2 9 GENERAL Relay No Cr R8 Starter Relay Sari R9 Glow plug aa A aaiae aa ededed EEE EPAPER E R10 GNS ESS agis aa a ee a f oeta R11 AC Compressor AoE oe NOT USED NOT USED eae ores R12 Fuel pump 5 38 85 38 ma G EEN g8 28 2 85 aon FEA oncncsre martii gan pote F67 5A ABS T15 2 5 2 Instrument Panel Fuse Box e Pull the Fuse box cover below the switch bank outward to access the instrument panel fuse box Fuse No Fuse Rating Circuit F31 15A Front Wiper CAUTION Rear Wiper Washinfotainment bee 1i IC FATC
18. To extend LMV e Successive UNLOCK commands received from RKE is used for toggling the current status of the head lamp low beam e Each time LMV is extended the low beam will be kept turned on for next 20 seconds Copyright Mahindra amp Mahindra Ltd 082015 AD To disable LMV e LMV ON 20 seconds expires e Ignition off to any other states e LOCK command is received from RKE e Park lamp is switched ON 8 9 Interior Lamps Interior lamps comprise of roof lamps and ignition key ring illumination These lamps can be used for an illuminated entry In auto mode the roof lamps and ignition key ring illuminate when any of the doors are opened Once all doors are closed the interior lamps switch OFF 8 9 1 Front Courtesy Map Reading if equipped Me i 3 wi ous Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL A Map Reading Lamp LH B1 Permanent ON B Roof Lamp B2 Permanent OFF C Map Reading Lamp RH B3 Door Auto Mode The front courtesy lamp is located in the roof console above the front seats The courtesy lamp can be switched on using the middle switch B on the lamp The right left map reading lamps for the driver front passenger are located adjacent to the courtesy lamp and can be individually switched ON OFF by the map reading lamp switches A amp C A CAUTION Do not leave the courtesy map reading lamp in permanent ON mode This will
19. position to return the wipers to the park position provided the wiper stalk is in the OFF position 8 17 FEATURES AND CONTROL 8 11 8 Wipe Wash Washer fluid is taken from the reservoir in the engine compartment Pull Lift the wiper control stalk towards the steering wheel from any position to activate the front wipe wash function Washer fluid is sprayed on the front windshield and the wipers wipe the windshield 3 times after the washer spray is stopped and wipe once after 4 sec Hold the stalk in position for continuous spray of washer fluid The rear windshield wash amp wipe operates 3 to 4 times or as long as the stalk end is turned rotated to wash d tente Wiping will continue for few seconds after releasing the stalk end switch In the front a single nozzle with twin adjustable washer jets is provided on the applique below the wiper Using a pin the eye ball jets can be adjusted precisely for direction Always direct the washer jet to hit the middle of the windshield This will enable the wiper blade to wipe the complete width of the windshield 8 18 Copyright Mahindra amp Mahindra Ltd 082015 In the rear a single nozzle with twin adjustable washer jets is provided on the bottom of the rear windshield Adjust to direct the washer jet to hit the middle of rear windshield using a pin ea AX WARNING Using the windshield washer in freezing temperatures could be dangerous The
20. the vehicle can be driven in the reverse The same is displayed in the cluster also Tap the gear shift lever towards bottom to activate reverse R mode A CAUTION To avoid damage to the transmission system ensure the vehicle comes to a complete stop before changing from A M to R mode and vice versa Copyright Mahindra amp Mahindra Ltd 082015 11 7 7 Parking your Vehicle Your vehicle can be parked in any gear Ensure the park brake is engaged before leaving the vehicle It is recommended to park the vehicle with gear in A1 for uphill and in R for downhill NOTICE Ensure the correct gear is selected by looking at the cluster before switching off the engine The gear cannot be changed after switching off the engine 11 7 8 Starting off on an uphill downhill Uphill e Apply the parking brake firmly so that the vehicle does not roll backwards e Shift the gearshift lever to the A M position while depressing the brake pedal Make sure that the gear position indicator in the instrumental cluster displays 1st gear e Release the brake pedal and depress the accelerator pedal gradually and when the vehicle starts to move release the parking brake and depress the accelerator pedal to start off NOTICE On an uphill slope never hold the vehicle at a stop using only the accelerator pedal or the creeping function Copyright Mahindra amp Mahindra Ltd 082015 STAR
21. 082015 wheel with the bolts Lift up the wheel and get at least the top bolt started through its hole Wiggle the wheel and press it back over the other bolts Re install the wheel nuts with the tapered end inward and tighten by hand Press the wheel inward and tighten the wheel nuts further 42B1 h WARNING Never use oil or grease on the bolts or nuts Doing so may lead to over tightening of the nuts wheel nut spanner slip damage the bolts and also may cause personal injuries Also nuts may loosen and the wheels may fall off which could cause a serious accident If there is oil or grease on any bolt or nut clean before installing wheel nuts Lower the vehicle completely and tighten the diagonally opposite wheel nuts using the wheel nut spanner Turn the jack handle extension counter clockwise using the jack handle to lower the Copyright Mahindra amp Mahindra Ltd 082015 GENERAL vehicle making sure the handle remains firmly fitted onto the jack handle extension Make sure the wheel spanner is securely engaged over the nut Tighten each nut a little at a time in the diagonally opposite order as shown Repeat the process until all the nuts are tight Do not use other tools or any additional leverage other than your hands such as a hammer pipe or your foot U42B11 NOTICE Firmly tighten the wheel nuts two to three times as shown in the illustration h WARNING Imprope
22. 13 9 AD 14 MAINTENANCE 14 1 General Owners Information Your vehicle has been designed for fewer maintenance requirements with longer service intervals to save both your time and money However each regular maintenance as well as day to day care is more important to ensure a smooth trouble free safe and economical operation It is the owner s responsibility to make sure the specified maintenance including general maintenance service is performed Note that both the new vehicle limited warranty and emission control system limited warranties specify that proper maintenance and care must be performed See Service Coupon Booklet for complete warranty information Where to go for service Mahindra technicians are well trained specialists and are kept up to date with the latest service information through technical bulletins service tips and in dealership training programs They learn to work on Mahindra vehicles before they work on your vehicle rather than while they are working on it You can be confident that your Mahindra dealer s service department does the best job to meet the maintenance requirements on your vehicle reliably and economically Get the most from your vehicle with routine maintenance Routine maintenance is the best way to help ensure you get the performance dependability long life and better resale value you expect from your vehicle This is exactly why we ve put together this Maintenance Section It outli
23. 14 9 10 Leather Seats where applicable Your leather seating surfaces have a clear protective coating over the leather e To clean use a soft cloth with a leather and vinyl cleaner Dry the area with a soft cloth e To help maintain its resiliency and color use the leather care kit available from an Authorized Mahindra Dealer e Do not use household cleaning products alcohol solutions solvents or cleaners intended for rubber vinyl and plastics or oil petroleum based leather conditioners These products may cause premature wearing of the clear protective coating A NOTICE In some instances a color or dye transfer can occur when wet clothing comes in contact with leather upholstery If this occurs clean the leather immediately to avoid permanent staining 14 9 11 Underbody Flush the complete underside of your vehicle frequently Keep body and door drain holes free from packed dirt You can also use an 14 19 anti corrosion spray for the underbody to avoid rusting and corrosion especially for vehicles in coastal places 14 10 Air Conditioning System Maintenance Your vehicle s air conditioning is a sealed system Any major maintenance such as recharging should be done by a qualified technician However you can do a few things by yourself to make sure the air conditioning works efficiently Run the air conditioning system at least once a week even during the cold weather months Run it for at least ten minutes with
24. A U4eJ02 A NOTICE Refer to the Audio lnfotainment Manual for complete information on audio controls and features The map upgradation details are also available in the Infotainment manual Copyright Mahindra amp Mahindra Ltd 082015 STEERING AND BRAKES SOURCE w1 a04 _ A Source C Mute Seek Call Receive Disconnect Volume amp Volume Source The source button switches between different modes in the audio system When the source button is pressed once the next source is chosen in the following sequence provided the required media is connected Tuner gt MP3 gt USB Auxiliary In case of the absence of USB mode the system will toggle between Tuner and Auxiliary modes Seek Call Receive Call Disconnect 9 3 STEERING AND BRAKES Press the SEEK switch once to increase radio reception frequency by 0 05 MHz Press the SEEK switch continuously for more than 3 Sec for AUTO scan of radio stations In USB modes the next track can be selected by pressing the switch once This button can also be used to receive or disconnect calls while connected through Bluetooth Mute Press the Mute button to mute the audio Press again to Un mute Volume and Volume To increase the volume by one point press the button once To decrease the volume by one point press the button once A NOTICE If the steering wheel audio control switches do not work
25. Coolant Level hecking Topping Power Steering Fluid hecking Topping the Engine Oil hemicals and Additives hild Restraint and Airbag hild Restraint System CRS hild Safety Rear Door Lock OOOO OOO OO O00 6 D Dealing With Ice Defogging De misting and Defrosting Dimensions Door Ajar Warning Lamp Driver and Front Passenger Air Bag Driver Seat Height Adjust Driving Through Water Driving Your Vehicle E Electric ORVM Adjustment Engine Compartment Engine Compartment Fuse Box Engine Immobilizer System Engine Oil Engine Oil Consumption Exterior Chrome Exterior Lamps sacs irr asrasa AAAA A IAA 8 5 F Fastening the Seat Belt Fastening the Seat Belt 2 Point Lap type Fastening the Seat Belt 3 Point type Feature Matrix Flat Tire Flick Wipe Mist Flowing Water Fluid Leaks Fog Lamps Foldable Arm Rests Follow Me Home FMH Non RKE Follow Me Home FMH RKE Frequently Asked Questions FAQ Front Courtesy Map Reading Front Fog Lamp Front Overview Front Seat Recline Front Seat Slide Front Windshield Defog Fuel Level Gauge Fuel Lid Opening and Closing Fuses and Relays G Gear Selection Display 0 cc cccce eee ee eee reer eee eer een eens 8 26 Gear Shift Lever ies General Driving Precautions General Maintenance General Owners Information General Safety Inf
26. Features of the Immobilizer System Prevents the vehicle being started by anyone not in possession of the correct vehicle key The vehicle is automatically protected after the key is removed fram the ignition At every ignition ON if the vehicle does not recognize the correct key code the engine check lamp will illuminate blink and the engine cannot be started The vehicle will not be protected until the key has been taken out of the ignition A CAUTION If the engine check lamp flashes or remains continuously illuminated after the ignition being switched ON there is a system malfunction Contact an Authorized Mahindra Dealer immediately Inserting the correct coded key in the ignition and switching the ignition ON automatically deactivates the system This enables the engine to start NOTICE In the event of the vehicle not starting with the correct key switch off the ignition for a minimum of 1 minute and attempt to start the vehicle again Copyright Mahindra amp Mahindra Ltd 082015 LOCKS AND KEYS A CAUTION Do not modify remove or disassemble the engine immobilizer system Any unauthorized changes or modifications can affect proper operation of the system and will void your warranty Do not attempt to install after market push button start systems These systems may compromise your vehicle s security system 7 11 FEATURES AND CONTROL 8 FEATURES AND CONTROL 8 1 Power Windows
27. P21W 12V 21W A CAUTION a pee Revel Replacement fuse must be with the same rating as the one you Registration Plate lamp WSW 12V SW have removed Roof lamp CoW 12V 10W NOTICE You can identify a blown fuse by a break in the filament All fuses except high current fuses are press fit Never touch fuses with bare hands Always use a fuse puller to remove and refit the fuses Be careful while removing the relay do not shake or apply excessive force to avoid damage to relay terminal Copyright Mahindra amp Mahindra Ltd 082015 2 7 GENERAL 2 5 1 Engine Compartment Fuse Box Three fuse boxes in the vehicle e Battery Mounted Fuse Box Engine Compartment Fuse Box Instrument Panel Fuse Box C ua2B04 The engine compartment fuse box is located adjacent to vehicle battery Follow the below steps to remove the fuse cover e Slightly press nudge the fuse cover towards the Head lamp side and remove the front snap lock 2 8 Copyright Mahindra amp Mahindra Ltd 082015 CGD GENERAL e Further push top cover towards battery side and remove pull FuseNo FuseRating the cover completely F12 60A Battery Cable 2 F13 60A Battery Cable 1 CAUTION F14 60A Battery Cable 3
28. RHS of the engine bay behind the head lamp The reservoir supplies washer fluid to both front and 5 The fluid level should be maintained between the MIN and if equipped MAX marks on the dipstick integrated with the cap rear Ur aupen 14 12 Copyright Mahindra amp Mahindra Ltd 082015 AD MAINTENANCE In very cold weather conditions fill the reservoir with washer fluid 14 5 10 Changing the Wiper Blade premixed with anti freeze A CAUTION If you operate your vehicle in temperatures below 4 5 C use washer fluid with anti freeze protection Failure to use washer fluid with anti freeze protection in cold weather could result in impaired windshield vision and increase the risk of injury or accident 1 14 5 9 Checking the Wiper Blades Lift the wiper arm from its position Expose the blade lip for inspection Clean the wiper blade lips with water applied with a soft sponge If the wiper blade is not wiping the glass satisfactorily or is worn out cut cracked or bulging get it replaced at an Authorized Mahindra Dealer Copyright Mahindra amp Mahindra Ltd 082015 Lift the arm and position the wiper blade at right angles to the wiper arm Press the retaining clip in the opposite direction disengage the wiper blade and pull it off the arm To prevent damage to the windshield don t let the wiper arm slap down on to it Hold the end of the rubber and pull until t
29. Sf Set the temperature control knob to the extreme left coolest position Once the passenger compartment reaches a comfortable temperature shift to fresh air mode Also blower speed and temperature control knob can be re adjusted as desired NOTICE If your vehicle was parked in the hot sun with all the windows closed drive the vehicle with windows open for the first few minutes This will help in venting the hot interior air out and allow the air conditioner to cool the cabin quickly 10 11 Rapid Cabin Heating For rapid heating of the cabin the following AC settings are recommended 1 Make sure that all the windows are fully closed Copyright Mahindra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC Set the blower to maximum speed Set the air distribution control to foot mode Set air intake control to recirculation mode a eA wo Set the temperature control knob to extreme right hot position 6 For dehumidified heating switch the air conditioner ON Once the passenger compartment reaches a comfortable temperature the blower speed and temperature control knob can be readjusted as desired NOTICE In extreme cold weather conditions the engine coolant takes time to get heated up Hence it might take a while for hot air to discharge 10 12 Defogging De misting and Defrosting For keeping the front windshield and side windows clear proper control of the HVAC s
30. Shift Lever The gear shift lever shifts the transmission into various gears The gearshift pattern is shown on the gear lever knob The clutch pedal should be depressed fully while shifting and then released slowly 11 5 With the gear shift lever in neutral and brakes released the vehicle can move freely by pushing or towing The engine can be started in this mode It is always recommended to keep the brake pedal depressed in this position It is advisable to shift into neutral when the vehicle is at a standstill for longer durations with the engine idling CD e Do not leave children unattended in the vehicle or with access to an unlocked vehicle Children could move the gear shift lever which could result in an accident or serious injury e On slippery wet road surfaces never downshift in order to obtain braking action This could result in a wheel slip and WARNING Coasting the vehicle with the gear lever in neutral and engine ON OFF is not recommended The steering and braking will be very hard without power assist while coasting with the engine OFF In an event of panic braking you will not have the power of engine braking to slow down the vehicle This may lead to personal injury or accident A CAUTION Do not leave the vehicle with the gear shift lever in the neutral position Always engage the manual parking brake before leaving the vehicle to prevent any vehicle movement leading to possible injury to a
31. The AMT warning lamp illuminates when the ignition switch is turned ON and goes out as soon as the engine is started If the lamp remains ON even after starting the engine or illuminates while driving there is a possibility of malfunction in AMT system Contact an Authorized Mahindra Dealer immediately 8 18 Voice Messaging System VMS If equipped A state of the art system the Voice Messaging System VMS is provided to monitor and announce various warnings in your vehicle This is in addition to the warnings on the instrument cluster VMS is 8 34 CD a unique gadget which provides security to you and your vehicle It monitors specific fault signals from your vehicle 8 19 Mike If equipped Mike is located in the roof panel near the Roof lamp It receives the voice and transmits during the mobile is connected through Bluetooth a wee od 8 20 Reverse Parking Assist System RPAS If equipped Reverse parking assistance system is provided to aid the driver while parking the vehicle in reverse at a speed of less than 5 kmph While reversing RPAS will detect the obstacles at the rear side of the vehicle within the sensing zone which cannot be viewed through the internal rear view mirror and the outside rear view mirrors The RPAS will then alert the driver by a beep sound about the location of CD the detected obstacle and the distance from the vehicle The alert sound level will vary pro
32. Windows v v v v v v v Central Locking v v v v v v v Mobile Charging Point Front Row only Front amp Second Row Rear Wipe amp Wash v v v v v Rear Defogger v v v v v Lead me to Vehicle Head lamps LMV RKE v y Follow me Home Head lamps v v Lighting of the glove box v v v v y 2 2 Copyright Mahindra amp Mahindra Ltd 082015 D GENERAL Se E Steering Mounted Audio amp Phone Controls Eco Mode v v v v v Storage Tray Below Driver s Seat Copyright Mahindra amp Mahindra Ltd 082015 2 3 2 2 Lubricants and Capacities ENGINE mHawk 80 TRANSMISSION AMT HYDRAULIC OIL REAR AXLE POWER STEERING BRAKE AND CLUTCH 2 4 MAHINDRA MAXIMILE Feo NEW GENERATION GENUINE ENGINE FLUID MAHINDRA MAXIMILE SYNTEC F2 NEW GENERATION GENUINE TRANSMISSION FLUID AMT HYDROMATIC 0701HADO0OS3O0N MAHINDRA MAXIMILE ELITE NEW GENERATION GENUINE DIFFERENTIAL FLUID SHELL SPIRAX S3 ATF MD3 Part No 1102EAA00470N MAHINDRA MAXIMILE DOT 4 Genuine Brake fluid 6 O liters 2 00 liters 0 7 2 0 liters 0 8 liters 0 9 liters Special Engine Fluid Special Manual Transmis sion Fluid Special Hydraulic Fluid Special Differential Fluid Always use MAXIMILE FEO new generation Mahindra genuine engine oil This is specially developed for your engine s optimum performance and fuel efficiency In extreme cases of emergency and non availability of abo
33. advise you to keep one of these keys in a safe place for emergency use but not in the Copyright Mahindra amp Mahindra Ltd 082015 7 1 LOCKS AND KEYS To Open a Door from Inside A NOTICE Locking the driver door from inside activates the central locking system if equipped thereby locking ALL the doors of the vehicle Refer to the Central Locking section for further details Locking Unlocking Doors from Outside N x A NOTICE The key is bi directional you can insert it into the key hole in both directions Locking the driver door from outside activates the central locking system if equipped thereby locking ALL the doors of the vehicle Refer to the Central Locking section for further details A Lock B Unlock 7 2 Copyright Mahindra amp Mahindra Ltd 082015 LOCKS AND KEYS D Locking Unlocking the Back Door 7 2 Central Locking System All doors of the vehicle can be simultaneously locked or unlocked from the driver door Central Locking Unlocking All Doors from Outside N NOTICE In case any door including the back door is open when the central locking is activated that door will not be locked even if it is closed later Copyright Mahindra amp Mahindra Ltd 082015 LOCKS AND KEYS Central Locking Unlocking All Doors from Inside A UnLock B Lock Your vehicle is equipped with
34. be continuous if any of the obstacles is less than 50 cm 8 37 A WARNING NOTICE If the display bars in any one all of the sides are displayed with The distance indicator will display the distance in multiples of 2 cross marks contact the nearest Authorized Mahindra Dealer cm whichever is shortest A NOTICE e System cannot sense wire mesh handrail small objects and some obstacles which come below the bumper level e System cannot sense obstacles like cotton or spongy surfaces which absorb ultrasonic waves e System performance is dependent on the reflection angle of the obstacle U42H69 e System may not detect obstacles up to 40 cm from the bumper by virtue of system design CD System may give wrong signal when any extra material is wrapped around the spare wheel or if there are any protrusions from the spare wheel System may give a wrong signal or detect the wheel as an obstacle if the spare wheel cover mounting is incorrect hanging or misaligned Ensure the spare wheel and wheel cover are intact and rigidly fitted System may give a wrong signal on reversing the vehicle on grasslands and bumpy roads System may give a wrong signal while the vehicle is moving from plain ground to sloping ground or vice versa System may give a wrong signal by sensing the ground when the bumper is tilted more from the normal position or when the vehicle is heavily overloaded System may give a false alarm during heavy rai
35. bending lamps are integrated in both the head lamps Static bending lamps turn ON when a sharp turn is taken They help in illuminating the road in the direction of turn 8 9 FEATURES AND CONTROL The following conditions are to be met for the lamps to switch ON e Ignition ON e Head lamp is ON e Sharp turn taken 8 5 11 Fog Lamps if equipped Fog lamps are to be used along with the head lamp low beam to improve the vision during foggy and misty conditions Fog Lamps OFF Align the inner rotary switch on the lighting control stalk to the fog lamp off O on the inner fixed stalk as shown to switch OFF the fog lamps Front Fog Lamps ON 8 10 To switch ON the front fog lamps switch ON the ignition and the parking lamps Turn the inner rotary switch on the lighting control stalk to align to the fog lamp symbol on the inner fixed stalk as shown The front fog lamp indicator in the instrument cluster indicates the operation status NOTICE Fog lamps will turn ON only if the parking lamp is ON 8 5 12 Hazard Warning Lamp The hazard warning lamp switch is located above the AC controls on the instrument panel Use the hazard warning lamp when your vehicle is stationary or to warn other road users to be cautious while passing your vehicle Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL To turn the hazard warning lamp ON press the switch
36. booster seat Frequently check the seat belt to be sure it remains snug and in position A squirming child could cause the seat belt to come out of position w1 n Adjust the seat as needed and sit up straight and well back in the seat To fasten your seat belt pull the webbing out of the retractor and insert the metal tab into the buckle There will be an audible Copyright Mahindra amp Mahindra Ltd 082015 5 9 SEATS AND SEAT BELTS click when the tab locks into the buckle Pull up on the shoulder strap to tighten the lap belt across your hips The seat belt retractor will pull in any slack in the shoulder strap A slow and easy motion will allow the belt to extend and let you move your body around freely Periodically check the seat belt as you ride to be sure it remains snug and in position If there is a sudden stop or impact the belt will lock into position It will also lock restrict if you try to lean forward too quickly NOTICE If the driver s seat belt is not fastened when the ignition is switched ON the seat belt warning lamp illuminates Refer to Warning Lamps in the Features and Control chapter for further details 5 10 5 6 2 2 Point Lap type if equipped This seat belt is applicable to the second row middle passenger seat Insert the metal tab into the buckle until it snaps Position the lap belt on the hips as low as possible Copyright Ma
37. by stander or damage to the vehicle For brief stops e g at traffic lights keep the gear shift in neutral and hold the vehicle with the brake pedal For prolonged stops it is recommended to switch OFF the engine and apply the parking brake Ax WARNING 11 6 reduced vehicle control Forward Use the gears 1 to 5 as per vehicle load road traffic conditions or as per requirement Reverse This gear is to enable the vehicle to move in the reverse direction Move the gear shift lever into this position only after the vehicle has come to a complete stop AA CAUTION To avoid transmission damage shift into or out of reverse gear only after the vehicle has come to a complete stop and the engine is at idle speed It is recommended you wait approximately for three seconds in neutral gear before shifting into or out of the reverse gear Uphill and Downhill Driving To prevent the engine from laboring at a low RPM when driving uphill gradients or with your vehicle heavily loaded downshift when necessary to maintain engine RPM within the best torque range Similarly while driving downhill downshift to utilize the engine braking in an optimum manner GD STARTING AND DRIVING THE VEHICLE AS WARNING oa 4045 4 5 50 55 When stopping the vehicle on an uphill gradient do not hold it with the clutch accelerator use the brake to avoid Down shifting unnecessary clutch wear heat buildup When parking on an incline gear alone
38. drain your vehicle battery 8 9 2 Roof Lamps if equipped x i Tem fl 8 13 FEATURES AND CONTROL Permanent ON Roof Lamp Permanent OFF Door Auto Mode The Roof lamp is located in the roof above the front amp Rear seats The lamp can be switched on using the switch on the lamp A CAUTION Do not leave the Roof lamp in permanent ON made This will drain your vehicle battery The Roof lamp switch has three operation modes to choose from 1 The lamp remains permanently ON in this position irrespective of the door open status 2 The lamp remains permanently OFF in this position 3 The lamp remains in AUTO mode in this position The operation of the Roof lamp in Auto mode is as follows e Roof lamp switches ON dims and goes OFF after a preset delay once RKE unlock is performed e Roof lamp switches ON when any of the doors is are open e Roof lamp switches ON when Ignition on to ignition off all doors closed condition e Roof lamps dim and go OFF after a preset delay upon closing of all doors during IGN OFF condition 8 14 e Roof lamps dim and go OFF immediately on RKE lock or manual key lock after all doors are closed e f any of the doors are not closed properly then the Roof lamps switch OFF automatically after a preset duration during Key removal from key Barrel or once the vehicle speed gt 20 kmph e Roof lamps go OFF with ignition ON and all doors closed properly 8 1
39. e Do not leave the vehicle unattended or with children and the engine running e Always put the vehicle in gear switch off the engine and apply the park brake before leaving the vehicle 11 14 A NOTICE e After shifting the automated manual transmission gearshift lever to the N position always check the gear position indicator in the instrument cluster shows the N position to make sure that the transmission is disengaged e If the transmission cannot be put in neutral turn the key from the OFF to the ON position and move the automated manual transmission gearshift lever from N to A M or R then back to N again Then turn the key from the ON to the OFF position e These procedures may help put the transmission in neutral If the transmission still cannot be put in neutral you cannot tow the vehicle without using a towing dolly 11 8 Driving Your Vehicle 11 8 1 General Driving Precautions A WARNING Always observe the following precautions to minimize the risk of accidents leading to serious personal injury or damage to your vehicle Before you drive your vehicle please read this manual carefully Copyright Mahindra amp Mahindra Ltd 082015 CD Before you start driving check proper operation of the brakes and steering system If while driving you hear any strange noise or feel unusual vibration or if you have any concerns whatsoever or if any wa
40. ened 8 13 Power Qutlet assisar 8 14 Windshield WiperS s sessssssssssisssisssiesriresriesrierrirsrresrrenrns 8 16 Utility Folder Sasan N 8 20 PAOD ATEA E EEA O 8 22 nstr ment Clute csnssnannno daona 8 23 Warning Lamps OVeErVieW cccccessseseseeeeeteeteeneenees 8 29 Warning Lamps in the Instrument Cluster 8 30 Voice Messaging System VMS If equipped 8 34 Mikefif equipped ss sesissssssssesssrssrrsssreersrssnresrissnresnerenrees 8 34 Reverse Parking Assist System RPAS If LEWIN 8 a EAE eaters E rey AREA eT NCR eT 8 34 Brake Energy Regeneration Technology If SQUIPPEO AEE E EERE TEET 8 40 Micro Hybrid Technology Engine Stop Start System ES5 IRequip ped mirror 8 42 Radio Frequency ID RFID Tag eee 8 47 STEERING AND BRAKES ccc eee eesieeneeteteeneeneeneeneeenees 9 1 weenNG ena a reece ercae cares recone nee en TT cree 9 1 Tilt Steer gesien 9 2 Steering Controls Audio Control System if equIP ER erraina a ti 9 2 Brake Shs EE 9 4 Anti Lock Brake System ABS if equipped 9 6 10 HEATING VENTILATION AND AIR CONDITIONING SYSTEM FIVAG ia ce ciihed een ugh ane nel ate eo hi et 10 1 AVAG OVENMIEW vicina iis nin ite cciiadiiadiianreroimcenta 10 2 Center Side Vents icc uscd areed ean ieee 10 3 HVAC Controls Air Distribution Control eens 10 4 Blower Speed Control eeeseesessecesesesteesesteessesteneentes 10 5 Temperature Control eeeesesecestesseesee
41. gas DO NOT operate the vehicle with the engine oil level dipstick and or the engine oil filler cap removed NOTICE Draining Changing of engine oil should always be done by an Authorized Mahindra Dealer 14 9 MAINTENANCE GD 14 5 5 Checking Topping Engine Coolant Level Ax WARNING e Park the vehicle on a flat horizontal surface Keep the parking Never open the pressure cap when the engine is hot Hot brake fully engaged Shut off the engine coolant may splash resulting in serious personal injury or severe burns by the erupting liquid A NOTICE Top up only with recommended Ready To Use RTU coolants for ensuring performance anti freezing and corrosion protection Do not add water directly Mixing with other brands of coolant is not recommended and should be avoided NOTICE Draining or changing of engine coolant should always be done by an Authorized Mahindra Dealer e Wait till the engine cools down and hence coolant temperature comes down to normal room temperature e The coolant level should be between MIN and MAX marking provided on the coolant recovery tank e In case the coolant level is below the MIN marking the coolant should be topped up e The coolant should be filled till the level rises above the MIN but remain below the MAX marking on the coolant recovery tank e However if the Coolant Recovery Tank is found to be near empty it is recommended that the system be check
42. may not be sufficient to prevent the vehicle Shift Range Vehicle Road Speed Engine RPM Range from moving Always set the parking brake in addition to shifting kmph the gear shift lever into gear It is also recommended to turn ped 50 45 the front wheels towards the curb 4 3 40 35 JA e 1300 1800 11 6 2 Recommended Gear Shifting Speeds 2 1 20 15 hs CAUTION 11 7 Automated Manual Transmission AMT If Equipped Shift gears at suitable engine or road speeds to safeguard the transmission components Avoid driving in high RPM s gt 3000 RPM Always depress the clutch fully before moving the gear shift lever from the current position to any desired position Perform up shifts or down shifts one gear at a time do not jump gears Upshifting 1 2 20 25 ire 1600 2500 Your TUV300 is equipped with 5 speed Automated Manual 2 5 0 35 Transmission AMT and a Monostable shifter AMT has the basic Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE features of conventional manual transmission but clutch operation and gear shifting are controlled hydraulically The cluster displays the current gear position both in Auto Manual modes In auto mode the gears are displayed as A1 A2 A3 A4 amp AS In Manual Mountain mode the gears are displayed as 1 2 3 4 amp 5 Neutral and reverse are displayed as N and R respectively N Neutral Position A Automated Mode M Manual Mountain Mo
43. misting defrosting If the cooling effect seems to have dropped considerably get the air conditioning system checked by an Authorized Mahindra Dealer 10 11 11 STARTING AND DRIVING THE VEHICLE 11 1 Safety Tips Before Starting your Vehicle 11 1 1 General Before starting the vehicle inspect the inside and outside of the vehicle and look for any damages leaks loose parts foreign objects debris Contact an Authorized Mahindra Dealer if required Before starting your journey check the working of all safety devices components especially brakes steering lamps signals and tires In case you suspect any system devices not working properly contact Authorized Mahindra Dealer Adjust the seat headrest steering wheel and fasten the seat belt as described in this manual Never perform any seat steering adjustments when the vehicle is in motion Start the vehicle only when seated and belted in the driver s seat NOTICE The Engine Management System controls the engine s idle speed When the engine starts idle RPM runs higher than normal in order to warm the engine The engine idle speed RPM reduces once the engine warms up Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE AX WARNING Never start your vehicle in a closed garage or in an enclosed area Exhaust fumes can be toxic Always keep the garage door open or start the engine in an open area 11 1 2 Mirror Adjustment Ens
44. other advantages of this system e Since the engine is switched off during traffic signals jams considerable amount of carbon dioxide release to the atmosphere is avoided This reduces global warming and thus provides us with a sustainable planet to live in e Ability to restart the engine by pressing the clutch pedal e Reduces noise pollution at traffic signals 3 Is it possible to start the engine through the clutch pedal for the first time No the engine can be cranked only with the ignition key for the first time If the engine is stopped automatically by the system only then it is possible to start the engine through the clutch 4 Whether the system will get activated as soon as the engine is started the first time with the ignition key The system will get activated only after the completion of engine temperature dependent warm up period which may extend up to 15 minutes This is to ensure better performance of the engine in terms of fuel economy and durability 5 Are there any safety precautions to be followed Yes when the engine is turned OFF at traffic signals jams with heavy electrical loads like head lamp or AC switched ON If the duration of such stops are long it is recommended to keep the engine ON and the ESS system in OFF position 6 What is to be done if don t want the system to stop my engine at traffic signals jams The system can be turned OFF by switching OFF the Stop Start selection switch
45. radial tires are repairable only in the tread area because of sidewall flexing Consult your authorized dealer for radial tire repairs 12 4 4 Tread Wear Indicators TWI Tread wear indicators are molded into the bottom of the tread grooves They will appear as bands when the tread depth becomes 1 16 inch 2 mm When the indicators appear in two or more adjacent grooves the tire should be replaced Copyright Mahindra amp Mahindra Ltd 082015 WHEELS AND TYRES A CAUTION Avoid abrupt maneuvering and braking This can cause tire deterioration and lead to loss of steering or braking control 12 4 5 Life of Tire The service life of a tire is dependent upon various factors including but not limited to e Driving style e Tire pressure e Distance driven AX WARNING Tires and the spare tire should be replaced after six years regardless of the remaining tread Failure to follow this warning can result in sudden and unexpected tire failure leading to an accident and or personal injury NOTICE Keep dismounted tires in a cool dry place with as little exposure to light as possible Protect tires from contact with oil grease and fuels 12 5 WHEELS AND TYRES GD WARNING 12 5 Tire Rotation Recommendations Do not use a tire wheel size or speed rating other than that Type 1 Applicable for all 5 Steel 5 Alloy wheels specified for your vehicle on the tire placard Combinations of unapproved tires and w
46. speed to maximum For quick defrosting set the temperature to extreme hot Once the windshield is cleared keeping the air conditioner ON leads to dehumidified cabin heating cooling which helps in keeping windshields and windows clear Keep the fresh air mode selected If required re adjust the blower speed and temperature control knob to maintain comfort The temperature of air coming out of the vents should neither be too hot nor too cold Driving the vehicle for long with the air conditioner switched off may lead to windshield or windows getting misted fogged up Driving the vehicle for long continuously in the recirculation mode may lead to windshield or windows getting misted fogged up Do not blow cold air on the windshield and windows for long during humid weather It could make windshield windows mist fog up When on a long drive during warm humid rainy weather once cabin temperature becomes comfortable shift to A C ECO mode if using A C mode earlier Adjust the temperature knob such that air coming out of the vents is not too cold Keep the fresh air intake mode selected Shift to any distribution mode other than defrost mode This will help in keeping windshields and windows clear Copyright Mahindra amp Mahindra Ltd 082015 For defogging de misting defrosting the side windows at the front select either Face or Face Foot mode while directing air flow towards windows by adjusting the louvers of side vents
47. stopping at traffic signals or for momentary stops along with brake pedal depressed or park brake engaged 414148 STARTING AND DRIVING THE VEHICLE This prevents the vehicle from moving ahead due to the creep 11 7 4 A Mode function When the A mode is selected the vehicle can be driven with automatic gear shifts as per the vehicle speed The first gear is displayed in the cluster as A1 As the vehicle speed increases the appropriate gear is selected automatically and the same is displayed in the cluster Tap the gear shift lever to the right to go to N position u42L09 NOTICE Though you can park your vehicle in N mode it is pe d SE TO ANAR ORRI ARO LO 1E TOP aoa Tap the gear shift lever to the left to toggle between A M modes A WARNING Never shift the gearshift lever to the N position while driving This will lead to loss of engine braking and in turn increase the braking distance effort to stop the vehicle 11 10 Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE gear is displayed in the cluster as 1 As the vehicle speed increases manually shift up by tapping the gear lever towards To downshift tap the gear lever towards The cluster displays the current gear position h WARNING Do not shift the gearshift lever to the N position while driving This will lead to loss of engine brakin
48. to operate the wash The stalk automatically comes back to position B when released 8 11 4 Intermittent INT Mode Intermittent INT wiping is selected when the wipe control stalk is pushed down to position C In the INT mode the wiper operates on preset intervals The delay between each wipe can be programmed from 1 to 60 sec according to the rain by the user Programming of the INT delay time is as follows e Turn the wiper stalk to position C wiper will start wiping e Turn the wiper stalk to OFF position before wiper starts second wipe e Turn the wiper stalk to position C again after the required delay and the same delay will be programmed e On keeping wiper ON position C the wiper will wipe again with the programmed delay 8 11 5 Low Speed Wiping Push the wipe control stalk up to the position D to operate the wiper at a fixed low speed Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL 8 11 6 High Speed Wiping Push the wiper control stalk up to position E to operate the wiper at a fixed high speed 8 11 7 Rear Wiper if equipped Rotate the outer rotary switch F on the wiper control stalk to align the arrow on the switch to rear wiper symbol on the wiper stalk to operate the rear wiper NOTICE If you switch OFF the ignition before switching OFF the wiper the blades stop at random on the windshield Switch ON the ignition and move wiper stalk to the MIST
49. to self repair or reinstall the cover 6 2 10 Airbag Maintenance For cleaning the airbag covers areas use only a soft dry cloth or one which has been moistened with plain water Solvents or cleaners could adversely affect the airbag covers and proper deployment of the system 6 9 GD LOCKS AND KEYS 7 LOCKS AND KEYS vehicle Should you lose your keys or if you need replacement keys they can be ordered through an Authorized Mahindra Dealer 7 1 Locks and Keys i NOTICE ii nan ie There is a limitation max 2 keys at a time to the number of TUV300 comes with two types of keys based on the model variant keys that can be programmed The minimum time frame required to supply the duplicate keys is 20 days after all the e Conventional key formalities are completed Please contact the dealer to e Remote Keyless Entry RKE understand the formalities involved r AX WARNING Never leave the key in the ignition switch with children in the vehicle A child could switch on the ignition start the engine operate power windows and other controls or move the vehicle resulting in personal injuries to bystanders and or children seated inside a U42601 of Key Number Tag Your key number is shown on the plastic tag attached to the key It is recommended that you record the key number and store in a safe place The keys operate all locks in your vehicle including those of the doors and ignition with steering lock We
50. to the vehicle occupants in addition to the primary protection provided by the seat belts and seat belt pre tensioners The primary components of the system are the sensors which measure the crash severity In the event of a significant frontal impact the airbags inflate to work in conjunction with the seat belts and help reduce injuries mainly to the driver s or front passenger s head chest A NOTICE Seat belts are the primary restraint system in the vehicle An airbag provides supplemental protection in addition to the seat belts All occupants including the driver should always wear their seat belts irrespective of presence of airbags to minimize the risk of severe injury in the event of a crash Airbags are more effective in reducing injuries when the seat belts are worn 6 2 1 Driver and Front Passenger Air Bag If equipped Your vehicle is equipped with a Airbag and lap shoulder belts at both the driver and front passenger seating positions The indications of the system s presence are the letters AIR BAG 6 1 SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped embossed on the airbag pad cover in the steering wheel and the passenger s side front panel pad above the glove box The SRS is designed to deploy the front airbags only when an impact is sufficiently severe and when the impact angle is less than 30 from the forward longitudinal axis of the vehicle Front airbags are not
51. washer fluid could freeze on the windshield and Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL block your vision resulting in an accident If you operate your vehicle in temperatures below 4 C use washer fluid with antifreeze protection A CAUTION e Do not operate the wipers when the windshield is dry lt may lead to scratches on the glass e Itis recommended not to use the wiper when the windshield glass is covered with debris snow or leaves Clean the glass before using the wiper to avoid damage to the wiper blades and glass e Do not operate the windshield washer when the reservoir is empty 8 19 FEATURES AND CONTROL 8 12 Utility Holders 8 12 1 Can Cup Bottle Holders if equipped 8 20 There are cup can bottle holders in the front floor console next to the park brake lever in the front rear and back door trims There is also a storage space on the instrument panel above the centre vents for mobiles and other small items H CAUTION Only sealed or cups with lids are to be used in the cup holders Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL Use caution when using the cup holders A spilled beverage that is very hot can injure the driver or passengers Spilled liquids can also damage interior trim and electrical components Any spilled beverage can also startle the driver and cause loss of control of the vehicle re
52. you can still control the system through the infotainment system or with the remote if equipped 9 4 Brakes Your vehicle is equipped with disc brakes in the front and drum brakes in the rear Disc brakes offer good braking capability and reduced stopping distance Wet brake discs result in reduced braking efficiency After a car wash or driving the vehicle through water dab the brake 9 4 pedal while driving to remove the film of water from the brake pads Brake pads feature wear indicator When the brake pad is worn metallic squeal noise is heard indicating the pad wear Have them replaced immediately AX WARNING Driving with wet brakes is dangerous Stopping distance increases considerably when braking Dry the brakes by driving at very slow speed and applying the brakes lightly until the brake performance becomes normal A CAUTION Even if the power assist vacuum assistance is completely lost the brakes will still work The brake pedal would be much harder than normal and the vehicle stopping braking distance will be longer than usual 9 4 1 Parking on a Hill Incline If you have to park facing uphill select first gear and turn the front wheels away from the kerb If you have to park facing downhill select reverse gear and turn the front wheels towards the kerb Always ensure the parking brake is engaged before leaving the vehicle Copyright Mahindra amp Mahindra Ltd 082015 CGD STEERING AND BRAKES
53. you may experience a temporary drive disturbance This is a characteristic of the tires and should be no reason for concern The condition should correct itself within 5 15 kms of driving If the disturbance persists have the tires checked by an Authorized Mahindra Dealer Driving and Alcohol Your driving ability can be seriously impaired by alcohol even if the blood alcohol level is far below the legal minimum Drunken driving is one of the most frequent causes of accidents Ax WARNING Never drink and drive Drinking and driving will lead to an accident resulting in serious personal injury Driving and Drugs Medication Your driving ability can be seriously impaired through the use of prescription or non prescription drugs or medication even cough syrup If you are taking any sort of drug or medication be sure that it will not affect your driving ability Mobile Phones Warning Use of electrical devices such as mobile phones computers portable radios or other by the driver while driving is dangerous If use of a mobile phone is necessary despite this warning use a AD hands free system to at least leave the hands free to drive the vehicle Please comply with the legal regulations concerning the use of communication equipment in vehicles in your country Driving Long Distances When you are driving over long distances follow these tips so that you have a safe journey e Lack of sleep or fatigue may impact your abi
54. 0 Power Outlet There are two on select variants 12V power supply sockets provided for power take OFF depending on the vehicle variant Electrical equipment appliances like mobile phone charger cigarette lighter etc can be used in the outlets The power outlet is rated 12V 120W when the engine is ON The power outlets are located in the following places in the vehicle e Front In the floor console ahead of the gear lever Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL personal injuries Contact an Authorized Mahindra Dealer for any necessary repairs A WARNING To prevent injuries and accidents secure all electrical appliances before use Do not use any appliance that may e Distract the driver while driving or hamper safe driving e Result in a fire or burn injuries due to the appliance rolling falling or overheating e Second Row In the floor console behind the park brake lever if equipped e Emit steam while the windows of the passenger compartment are closed e Never use the power outlet for electric heaters while sleeping e Never insert foreign objects into the power outlet e Never use malfunctioning electrical appliances e Never insert inappropriate or badly fitting plugs into the power outlet a ware b CAUTION CAUTION Accessories that draw higher power i e coolers vacuum cleaners etc will drain the battery quickly and may damage Do not modify disassembl
55. 5 Vinyl and Rubber Use a good conditioner on all vinyl and rubber parts to prevent from drying out 14 12 6 Interior Clean the glass shampoo the carpets dig in between the seats to see what s there clean the upholstery in all nooks and corners 14 12 7 Engine Check all hoses and wires to make sure everything is in good condition and replace any that need to be The last thing to do is to make sure the internal components of the engine remain lubricated and don t corrode A NOTICE If the engine is being started after a very long period of non use warm up the engine at an idle speed for 2 3 minutes before driving the vehicle 14 21 MAINTENANCE 14 13 Bulb Replacement 14 13 1 Head Lamp Bulb Replacement NOTICE The head lamp bulb can be replaced without removing the head lamp assembly from the vehicle The head lamp assembly has been removed here for illustration purpose only To replace the head lamp bulb Ensure ignition is switched OFF Remove rear dust cover from the head lamp Remove the bulb assembly with connector from the head lamp by unlocking the wire clamp Detach the bulb assembly from the wiring connector near to the head lamp Insert the connector into the new bulb of the same wattage and follow the reverse procedure to assemble the bulb assembly in the headlight assembly Clamp the bulb assembly by wire clamp properly 14 22 C D A CAUTION Do not touch the new bulb with your fing
56. 6 5Jx 15 215 75R15 Rack amp Pinion type Power assisted Hydraulic 521m Double Wish Bone with Coil Spring Stabilizer Bar Rigid axle Multi Link 5 Links with Coil Spring Stabilizer Bar Front and Rear Double Acting Telescopic Hydraulic Shock Absorber Hydraulic amp Vacuum assisted with optional ABS Ventilated Disc Drum type Copyright Mahindra amp Mahindra Ltd 082015 CGD GENERAL Parking Brake Integral Drum FUEL Fuel Capacity 60 liters ELECTRICAL SYSTEM System Voltage 12V Battery 65 Ah 72 Ah 90 Ah 2 9 Vehicle Identification Number VIN U42B12 Vehicle Identification Number VIN is the legal identity of your vehicle The vehicle identification number is stamped on the VIN plate riveted on the driver side It is visible after opening Driver door on the B pillar of the vehicle The engine number is also stamped on the same plate Copyright Mahindra amp Mahindra Ltd 082015 2 21 CD VEHICLE OVERVIEW 3 VEHICLE OVERVIEW 3 1 Front Overview Hood Front Windshield Wiper Antenna Ski Rail Outside Rear View Mirror Footstep Side Repeater Static Bending Lamp Front Park Lamp Front Turn Signal Lamp Fog Lamp ZA Gl S Se ep all fl i fe ee e Front Tow Hook Mounting provision lt Head lamp If equipped Copyright Mahindra amp Mahindra Ltd 082015 3 1 VEHICLE OVERVIEW GD 3 2 Rear Overview Rear Butterfly
57. AL 2 GENERAL We recommend you contact the nearest Authorised Mahindra Dealer for the latest features applicable to your vehicle 2 1 Feature Matrix NOTICE In view of our policy of continuously improving our products we reserve the right to alter specifications designs or features without prior notice and without liability ooo ee 2 ce O e O TENT Micro Hybrid Technology Engine Start Stop Automated Manual Transmission AMT autoSHIFT v v Intellipark v v Digital Immobiliser v v v v v v v Voice Messaging System VMS v M v v v Remote Lock amp Keyless Entry RKE v v v v v PN ay With Display Screen 2 DIN Music System 7 a 7 7 7 Driver Information System DIS v v Static Bending Head Lamps v v Airbag Driver side Airbag Co driver side v v v v v Anti Lock Braking System ABS with EBD v v v v v v Copyright Mahindra amp Mahindra Ltd 082015 2 1 GENERAL C SS Ea eae ae T6 AMT Ss TE AMT Collapsible Steering Column Tubeless Tyres v v v v v v v SS SS ee ee See Sees Wheels Steel Rims Steel Rims Wheel Caps Wheel Caps Wheel Caps Alloys Alloys Roof top Ski Racks v v v v s Front Fog Lamps v v Side and Rear Foot Step v v v v v ooo Comfort amp Convinience Tiltable Steering v v v v v v v Individual Armrest for Driver amp Co driver Seats v v Driver Seat Height Adjust v v Lumbar Support Driver amp Co Driver Seat v v Second Row Seat Fold v v Electric ORVM v v Power Steering v v v v v v v Power
58. ATURES AND CONTROL 8 5 1 Turn Signals A Turn Signal Left B Turn Signal Right Lane Changing You can signal a lane change by moving the lighting control stalk clockwise or anti clockwise to the limit point of free movement of the lever and releasing it once you change the lane NOTICE After you have completed your turn the stalk will automatically return to the neutral position lf the turn signal lamps on the instrument panel flash faster than normal there may be a possibility that one or more of the turn signal lamp bulbs have blown Replace the blown bulb immediately 8 6 8 5 2 Lamps Off Rotate the outer rotary switch on the lighting control stalk aligning the arrow on the switch to O on the stalk to switch OFF all lamps Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL Rotate the outer rotary switch on the lighting control stalk aligning the arrow on the switch to the 1st d tente position on the stalk to switch ON the parking lamps H CAUTION The tail lamp license plate lamp front park lamp and instrument panel illumination lamps are activated when the parking lamp is switched ON 8 5 4 Head Lamp On Rotate the outer rotary switch on the lighting control stalk aligning the dot on the switch to the 2nd d tente position on the stalk to switch ON the head lamps Copyright Mahindr
59. D CONTROL 8 3 1 Tip Tap ORVM Adjustment if equipped Tip Tap ORVM s can be adjusted by hand in the direction as indicated by the arrows Adjust the mirror as required to bring the rear traffic vision as desired 34 8 3 2 Manual Joystick ORVM Adjustment if equipped a gt og a Manual ORVM s can be adjusted by the joystick provided on the ORVM trim Adjust the joy stick as required to bring the rear traffic vision as desired 8 3 3 Electric ORVM Adjustment if equipped The electric exterior mirror adjustment switch is located on the RHS of instrument panel adjacent to the head lamp levelling switch The joystick on the switch can be used to select the left right mirror and also to adjust the respective mirror Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL 8 4 Interior Mirror S wieHi1 _ The interior mirror has day and night anti glare positions The night position reduces glare from head lamps of vehicles behind you Flip the tab on the bottom edge of the mirror to select the day or night position Copyright Mahindra amp Mahindra Ltd 082015 8 5 Exterior Lamps The lighting control stalk is located on the right hand side of the steering wheel It controls operations of parking lamps head lamps head lamp beam selection high beam flashing fog lamps if equipped and turn signals when the ignition switch is ON 8 5 FE
60. E to locate the vehicle in a parking lot Panic alarm can also bring attention to the vehicle and surrounding area warning about an intruder or seek for help When the SEARCH PANIC function is ON the hazard lamps flash along with an alarm for 30 sec In this mode e Pressing the SEARCH button again switches OFF the alarm e Pressing the UNLOCK button switches OFF the alarm and disarms unlocks all doors Copyright Mahindra amp Mahindra Ltd 082015 LOCKS AND KEYS NOTICE The search function works both during the Locked Unlocked conditions of the vehicle 7 3 7 Mute Un mute Function The chirps can be muted un muted Press the LOCK amp SEARCH buttons together for 3 sec to toggle between MUTE UN MUTE mode Hazard lamps will flash once to indicate the change in status NOTICE In the un muted condition alarm chirps would be heard during Auto Re lock 1 Chirp RKE Lock when door open 5 Chirps and RKE Unlock if there was a theft attempt during the lock armed period 4 Chirps In the mute condition only hazard would flash and alarm chirps would not be audible 7 7 LOCKS AND KEYS C D a N NOTICE The security system alarm will be activated only when the vehicle is locked using the RKE Locking the doors with the mechanical key will not trigger the alarm When the vehicle is armed by RKE opening the door from the inside by operating the door inner handle or opening the door from th
61. Genuine Parts Mahindra uses high quality parts for building vehicles In the event that any parts need replacement we recommend that you use only Mahindra genuine parts Non Mahindra parts may harm vehicle performance and will not be covered by your Mahindra warranty 1 5 INTRODUCTION AND SAFETY PRECAUTIONS To avoid counterfeit parts and to protect our brand image Mahindra genuine parts are packed in a branded carton Look for the Mahindra Genuine Parts logo A WARNING Any unauthorized modifications or alterations to this vehicle or failure to use appropriate specification and quality spare parts could seriously affect vehicle road worthiness and safety leading to an accident resulting in serious injury Mahindra Genuine Accessories A wide selection of quality accessories is available through your authorized Mahindra dealership These accessories have been specifically engineered to allow you to personalize your vehicle to suit your requirements and compliment its style and aerodynamic appearance Each accessory is made from high quality materials and meets Mahindra s rigid engineering and safety specifications Every Mahindra accessory installed according to the Mahindra installation provisions comes with the respective accessory warranty Consult your Mahindra authorized dealer for detailed information about accessories available for your specific model variant 1 6 A NOTICE For maximum vehicle performa
62. Mode button displays AC meter reading Once again pressing the Mode button displays DTE reading 8 26 CD Gear selection display displays the shifter position in Numerics 1 2 3 4 5 A NOTICE AC meter is displayed only when the ignition is ON To cycle between trip A amp B and AC meter press and release MODE B button for few seconds 8 15 6 Temperature Gauge The engine coolant temperature bar graph functions only when the ignition is switched ON It indicates the instantaneous engine coolant temperature The coolant temperature varies with changes in weather load on engine and driving pattern LCD bar rises from Cold C towards Hot H At normal operating temperature 4 bars are displayed in the LCD bar graph The high engine coolant temperature lamp along with all 8 bars blink when the temperature reaches 110 o C And when the temperature is 119 o C the temperature warning lamp and all 8 bars are permanently ON In such situations switch OFF the AC and observe any improvements in the temperature gauge If not stop the vehicle and allow the engine to cool down Check the coolant level in the coolant reservoir and top up if required If the engine is still overheating contact your nearest Authorized Mahindra Dealer A CAUTION Never remove the degassing tank cap when the engine is hot The engine coolant is under pressure and could splash on to skin eyes causing severe burns Wait for the engine to co
63. Owner s Manual TUV300 T4 T4 T6 T6 T6 AMT T8 T8 AMT Original Issue Date August 2015 Revision Date September 2015 NOTE Carefully read understand and follow the instructions provided in this manual and keep it in a safe place for future reference If you have any doubt whatsoever regarding the use or care of your vehicle please visit your Mahindra Dealer for assistance or advice This Owner s Manual should be considered as an integral part of the vehicle and should remain with the vehicle Mahindra MAHINDRA amp MAHINDRA LTD GATEWAY BUILDING APOLLO BUNDER MUMBAI 400 039 www mahindra com INTRODUCTION AND SAFETY PRECAUTIONS 1 1 INtPOCUGHON Sa Winicis alee aii ane eet 1 1 Safety Sym BO Sirenia a E AER AEE EA ET 1 2 General Safety Information and Instructions 1 3 To Owner s of a Mahindra Vehicle 1 4 Audio Infotainment Manual 1 7 GENERAL o Earra EE E EE 2 1 Feat re Matrix asinsnsmannunmanmn asnan 2 1 Lubricants and Capacities eeceeneen 2 4 DIM NSIONS a aa enan N AAIR ERE APEA 2 6 B lb Specificatioi sz nscnenynnaan a aR 2 7 Fuses and Relays 0 cesesceesessessceseeseessensaseesseeteesseatenseentenses 2 7 eal cal Le perio eeepc nr ervercr yar epee ee TPMT 2 12 JACK POINTS svani eaae 2 15 Technical Specifications e iseeesssiseseresrssrirrsersrrrsriessin 2 19 Vehicle Identification Number VIN 2 21 VEHIGLE OVERVIEW iinisarinnuan n a 3 1 Front OVETVEW sagn nanna
64. Spare fuses are available in this fuse box location E33 5A MBFM FATC ACC F34 5A Audio ACC Res 15A Cigar LTR2 Copyright Mahindra amp Mahindra Ltd 082015 CD GENERAL FuseNo FuseRating Circuit MM FuseNo FuseRating 0 Circuit F36 15A Cigar LTR1 F64 5A Crank Ear 10A ORVM F65 10A Reverse RPAS IGN F38 EEB 5A MBFM FATC T15 F39 40A Power window F67 5A ABS T15 F40 40A Blower motor F68 10A Airbag F41 S a F69 F42 10A AMT B F70 F43 10A Rear fog lamp E71 F34 5A Instrument cluster B F72 F45 F46 F47 Rie F48 R18 De mister Relay F49 10A Interior lamp R19 F50 15A Infotainment HVAC FATC B R20 Rear Foglamp F51 5A Immobilizer B R21 Blower F52 20A MBFM 1 R22 AC cut off F53 20A MBFM 3 F54 15A Rear Defogger F55 5A Key IN 2 5 3 Battery Mounted Fuse Box F56 5A Diagnostics F57 10A Park lamp The battery mounted fuse box is connected to the positive terminal F58 20A MBFM 2 of the battery Functionality of battery mounted fuse box is to F59 provide short circuit protection to alternator power supply to main F60 15A AMT IGN engine compartment fuse box amp electric cooling fan F61 5A Infotainment FATC IGN F62 F63 5A EMS Immo IGN Copyright Mahindra amp Mahindra Ltd 082015 2 11 GENERAL Battery mounted fuse box consist of following fuses e Main charging fuse 125A Pink colour Bus bar fuse 80A White colour
65. TING AND DRIVING THE VEHICLE Use Manual Mountain mode while driving in Uphill Downhill e Depress the brake pedal and shift the gearshift lever to the A M position Make sure that the gear is in 1st by checking the gear position indicator e Release the brake pedal and depress the accelerator pedal slowly Even if the accelerator pedal is not depressed the clutch will be engaged when the vehicle speed increases NOTICE Use Manual Mountain mode while driving in Downhill 11 7 9 Starting in Snow e Shift to M mode e Upshift to 2nd gear e Slowly release the parking brake accelerate slowly or drive in idle 11 13 STARTING AND DRIVING THE VEHICLE 11 7 10 General AMT Precautions AX WARNING Ensure the brake pedal is depressed or park brake engaged while vehicle is stopped with the engine running This will prevent the vehicle from moving ahead due to the creep function Ensure park brake engaged while vehicle is stopped with the engine off AS WARNING Any malfunction of the AMT is indicated by the Transmission Malfunction lamp in the T instrument cluster Contact your nearest Mahindra Authorised Dealer for further assistance e Never use the accelerator pedal to hold the vehicle on an uphill slope with the gear in forward A or M position e Do not rev the engine with the gear in A or M position with park foot brake engaged This will reduce the clutch life
66. Vehicle Loading Condition Position 8 Driver only or Driver with front passenger Driver Front passenger Rear seat occupied 1 2 All seats occupied 3 All seats occupied with luggage OR Driver with luggage at extreme rear side Select the suitable switch position depending on the pay load as advised in the table NOTICE The headlights can only be adjusted when the low beam is switched ON Copyright Mahindra amp Mahindra Ltd 082015 8 5 8 Power ECO Switch Power economy switch helps you to improve the fuel efficiency of the vehicle It is located on the driver panel next to the Head lamp levelling switch Press the switch gently once to switch between modes The ECO mode is indicated by LED illumination in the switch NOTICE Power or Economy mode can be changed at any time in vehicle running condition Select the suitable mode depending on the requirement If the vehicle is in ECO mode when engine is switched off and restarted still vehicle will be in ECO mode ECO ON or OFF is indicated by the light in the ECO mode button Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL 8 5 9 Hazard on Panic Braking Hazard Lamps are turned ON during panic braking for 5 sec when the following conditions are met e Ignition is ON e Vehicle speed is greater than 100 kmph e Brake is applied e Sudden High deceleration Rate 8 5 10 Static Bending Lamps if equipped Static
67. a amp Mahindra Ltd 082015 8 5 5 Head Lamp High Beam Low Beam d High Beam A Low Beam B With the head lamp low beam ON push the lighting control stalk down away from steering wheel to switch ON the head lamp high beam The head lamp high beam telltale lamp in the instrument cluster illuminates indicating high beam option selected For low beam pull the stalk back up A NOTICE Your vehicle head lamps are vented and moisture may be collected on the inside of the head lamp lens under certain climatic and geographical conditions This moisture will evaporate once the head lamps have been switched ON for a few minutes 8 7 FEATURES AND CONTROL 8 5 6 Head Lamp Flash Pull the lighting control stalk from the head lamp low beam position towards the steering wheel to instantaneously flash the head lamp high beam The head lamp flash works even when the head lamp is OFF 8 5 7 Head Lamp Leveling System When the vehicle is either fully or partially loaded it may have an upward inclination disturbing the head lamp aiming A correct head lamp setting provides good visibility to the driver with minimum inconvenience to other road users To properly aim the head lamp beam use the head lamp leveling switch This switch is located on the right side of the steering column shroud in the instrument panel This switch has three positions marked as 0 1 Ge 8 8
68. a A 3 1 Rear OVervieW iussione N 3 2 6 Instrument Panel Overview sessie 3 3 INSTRUMENT CLUSTER OVERVIEW 4 1 Instrument Gluster ities cineicadnarniaianadeaind 4 1 Warning Lamps OVErVieW ccccerereeteteseeenenseeeeees 4 2 Warning Lamps isis diaiiencitewacacsiavinqdindaa nk 4 3 SEATS AND SEAT BELTS eeeiesieeiestee tenses 5 1 Driver Seating unin caiwaentininetancaiiys 5 1 Head Restraint isincitiintvcvndneninainiinnidiin 5 4 Second Row Bench Seat ccccseceseeeeseetseeseeeeeeeeeeneenes 5 5 Third ROW S ats isan eraann RAA iE 5 5 General Warnings and Instructions Seat Belts 5 6 Fastening the Seat Belt sesssesissrisersersrreerissrrssrirrsriesree 5 9 Child Restraint System CRS ecer 5 11 SUPPLEMENTAL RESTRAINT SYSTEM SRS if GQUIPPER sonnia na nie AT 6 1 Airbags iiien a a A a e 6 1 INEROCWICHON gosg aan eins 6 1 LOGKS AND KEYS ccosanin anime A 7 1 Locks and Kaysi ioina tina a s 7 1 Central Locking System 7 3 Remote Keyless Entry RKE System ou eee 7 5 Engine Immobilizer System 7 10 FEATURES AND CONTROL iiiar 8 1 Power Windows Butterfly Window Rear Quarter Window 8 2 Outside Rear View Mirror ORVM ece 8 3 Interior MIPPOP visie issn adenine narnia 8 5 Exterior Lamps 2 twohn2aie alienate 8 5 Follow Me Home FMH RKE 8 11 Follow Me Home FMH Non RKE ceeeeseeeeeneeeeeeees 8 12 Lead Me to Vehicle LMV RKE cee 8 12 Interior tamps stenen oretne
69. a potential malfunction in the engine system contact an Authorized Mahindra Dealer immediately High Coolant Temperature No Continuously ON or Engine temperature very high Contact an Authorized Authorized Mahindra Dealer immediately D Warning Lamp Blinking Mahindra Dealer immediately Indicates right turn lamp is blinking Right Turn Indicators No Slow or Fast Blinking Slow Blinking Normal operation Fast Blinking One more turn signal lamp bulb has fused Have the bulb replaced O Head Lamp High Beam Indicator No Continuously ON Indicates head lamp high beam is ON p Indicates malfunction of the ABS system Contact an ABS Warning Lamp For about 3 sec Gontingousiy ON Authorized Mahindra Dealer immediately 27 Airbag Warning Lamp For bo t 45sec Continuously ON Indicates malfunction of the airbag system Contact an 4 4 Copyright Mahindra amp Mahindra Ltd 082015 GD Symbol Warning Lamp Tell Tale Lamp Pre check Lamp Status INSTRUMENT CLUSTER OVERVIEW Action Remarks Door Ajar Warning Lamp No Continuously ON _ Indicates one or more doors are open Front Fog Lamp Indicator No Continuously ON __ Indicates front fog lamp is ON Indicates driver seat belt not fastened If tell tale is not turning Seat Belt Warning Lamp No Continuously ON OFF even after fastening the driver seat belt contact an Authorized Mahindra Dealer for assistance Low Fuel Warnin
70. ahindra amp Mahindra Ltd 082015 CD A NOTICE Your vehicle is equipped with a creep function When the gear mode is in either A or M positions and you release your foot off the brake pedal the vehicle starts moving without pressing the accelerator pedal You can hold the vehicle using the park brake for momentary stops or shift to N mode 11 7 2 Driving the Vehicle TUV300 autoSHIFT DRIVING INFORMATION FROM STATIONARY U4e2L13 A NOTICE Before driving observe if any warning lamps are ON in the cluster If yes follow the appropriate checks given in the Warning Lamps Overview section of the Owner s Manual 1 Ensure there are no warning lamps ON in the cluster A o o Nog Idling for a few seconds Press the brake pedal Shift the gear shift lever to A M once for auto mode and repeat it once again to Manual Mountain mode Select or shift shifting to Manual Mountain mode Release the parking brake Release the service brake pedal The vehicle starts to move with the help of the creep function Slowly accelerate to drive away NOTICE While starting on an incline Start the engine as per the Starting the Engine procedure Shift to A or M Release the service brake pedal Slowly accelerate and simultaneously release the park brake 11 7 3 N Mode When the N mode is selected the vehicle is in Neutral This mode can be used for
71. ahindra Dealer or a qualified mechanic If the inspection reveals any damage or excessive wear immediately replace or have the component serviced 1 3 12 13 14 15 16 We recommend that you use only genuine parts supplied by Mahindra The use of non Mahindra parts will not be covered by warranty Never crawl under or be in close proximity to the vehicle when it is lifted off the ground by a jack unless the vehicle is properly supported with jack stands wheel chocks and other appropriate safety devices Never attempt any repairs or adjustments to any component while the vehicle is in motion Always switch off the engine and wait for the engine to come to a complete stop before performing any repairs or adjustments The vehicle identification plates are the only legal identification reference hence it is necessary to keep them in good condition Never modify data on the plates or remove them The customer is responsible for any possible tampering with the plates which will immediately void the warranty Do not attempt sharp turns abrupt maneuvers or other unsafe driving actions that can cause loss of vehicle control When the vehicle is fully loaded drive at a slow speed especially when turning Note that the center of gravity of the vehicle increases as the vehicle is fully loaded on the roof carrier 14 C D 1 4 To Owner s of a Mahindra Vehicle When first driving the vehicle after long periods of non use
72. all open flames and other burning material like cigarettes away from the battery and all fuel related parts AX WARNING Do not start run the engine when any engine peripheral parts are removed 14 2 Opening Closing the Hood The hood release lever is located in the driver side foot well area below the instrument panel To open the hood follow the steps below 1 Pull the lever to release the hood 2 Lift the hood a little to access the safety latch holding the hood striker This safety latch is located below the hood at the center 3 Move the safety latch to the left and lift the hood up 14 4 Copyright Mahindra amp Mahindra Ltd 082015 CD MAINTENANCE WARNING e Do not open the hood immediately after a drive the engine compartment will be very hot e Always double check to be sure that the hood is firmly latched before driving away If it is not latched properly the hood could open while the vehicle is being driven causing a total loss of visibility resulting in an accident e Do not move the vehicle with the hood in the raised position as vision is obstructed Follow the below steps to close the hood 1 Pull the hood down to a few inches above its fully closed position 2 Now release the hood and allow it to fall by its own weight The secondary latch is engaged now 3 Firmly press the hood down with both your hands to engage the primary latch This ensures that safety latch firmly
73. and pry the cap away from the wheel M CAUTION Do not try to pry off the wheel cap by hand alone Take due care in handling the wheel cap to avoid unexpected personal injury Copyright Mahindra amp Mahindra Ltd 082015 U42B07 Always loosen the wheel nuts before raising the vehicle Turn the wheel nuts counter clockwise to loosen as per the crisscross sequence shown To get maximum leverage fit the spanner to the nut so that the handle is on the left side Grab the spanner near the end of the handle and push down on the handle Be careful that the spanner does not slip off the nut Do not remove the nuts but loosen them by one or two turns 1 CAUTION Do not apply force with your legs for stand on the wheel spanner while loosening tightening the wheel nuts Copyright Mahindra amp Mahindra Ltd 082015 GENERAL 2 7 Jack Points Front jack up point Qn the chassis long member behind the front wheels Rear jack up point On either side of the rear axle U42B08 4 4 U42B09 2 15 GENERAL 2 7 1 Jacking Position the jack at the correct jacking point Make sure the jack is positioned on a level and solid ground Ensure no one is in the vehicle Block the wheel diagonally opposite the flat tyre to keep the vehicle from rolling when it is jacked up When blocking the wheel place a wheel block in front of one of the front wheels or behind one of the rear wheels 4
74. anket in case you get stuck in a storm 14 12 2 Keep Enough Fuel in the Tank Never let the fuel level in the tank drop below the half full mark A sudden storm with unexpected heavy rains could leave you stranded for hours Having adequate fuel supply will allow you to idle the engine from time to time to keep warm AD Do not e Tap the ice on the window to crack it or chip it for a good place to start scraping You could end up cracking more than the ice and end up with a cracked or shattered windshield window e Pour warm or hot water on the windshield to melt ice This will crack your windshield 14 12 3 During Winter Storage Start the engine occasionally here are a few pointers to keep in mind e Run it in a well ventilated area Carbon monoxide can build up quickly e Run for a minimum of 20 minutes to allow the engine to come up to the normal operating temperature This will allow the oil to circulate and will also open up the thermostat so that your radiator antifreeze circulates as well e Start up the air conditioner and or heater and run both for 10 minutes or so Again circulating fluids is essential for good life of the system e If your vehicle has power steering you may want to turn the wheels a few times to keep the fluids flowing Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE 14 12 4 Exterior Wash and wax your car to provide an extra layer of protection to your paint 14 12
75. ay damage the vehicle s suspension and body Avoid a tow with sling type equipment 13 5 2 Towing your Vehicle During Emergency U4eNo2 J If your vehicle needs to be towed call a professional towing service If a towing service is unavailable in an emergency your vehicle may be temporarily towed by a cable or chain secured to the emergency towing hook screwed into the front towing eyelet The tow eye is in the tools pouch under the third row seat 13 7 EMERGENCIES GD ke Also the wheels axles drive train steering and brakes must all be in good working condition Avoid sudden starts or erratic driving maneuvers which would place excessive stress on the towing hook and towing cable or chain resulting in breakage of the hook or the chain If the engine is not running the power assist for the steering and brakes will not be functional making it harder to steer or S Your vehicle also comes with a rear tow hook option The same tow eye can be screwed into the eyelet for towing LS brake than usual uaenos When lifting the rear wheels take care to ensure adequate ground clearance for towing at the front end of the raised vehicle The bumper and or underbody of the vehicle may be damaged during towing Remove Prise out the tow hook cover in the front LHS bumper using a screwdriver Screw in the tow hook and tighten clockwise Fasten a cable or chain specifically intended for use in to
76. brake system The ABS warning lamp lights up when you switch ON the ignition and should go out after a few seconds If the ABS warning lamp does not go out or if it comes ON while driving it means there is a fault in the ABS system In both cases the normal braking system remains efficient exactly as on a vehicle without ABS The vehicle should be examined as soon as possible by an authorized Mahindra dealer The Anti lock brake system is not designed to shorten the stopping distance Always drive at a moderate speed and maintain a safe distance from the vehicle in front of you The stopping distance may be longer in the following cases e Driving on rough gravel or snow covered roads e Driving with tyre chains installed e Driving over steps such as the joints on the road e Driving on roads where the road surface is pitted or differences in surface height the ignition and should go out after a few seconds If the ABS warning lamp does not go out or if it comes ON while driving it means there is a fault in the ABS system In both cases the normal braking system remains efficient exactly as on a vehicle without ABS The vehicle should be examined as soon as possible by an authorized Mahindra dealer The ABS warning lamp lights up when you switch ON CD STEERING AND BRAKES Ax WARNING Do not overestimate the Anti lock Brake System Although the Anti lock Brake System assists in providing vehicle control it is still imp
77. ce chest arms and hands These are usually in the nature of minor burns or abrasions and swelling but the force of a deploying airbag can also cause more serious injuries especially if an occupant s hands arms chest or head is in close proximity to the airbag module at the time of deployment Sit straight and well back into the seat Move your seat as far back as practical to allow room for airbag inflation while still allowing you to properly operate drive the vehicle AX WARNING The front passenger should never sit on the edge of the seat stand near the glove compartment rest feet or other parts of the body on the dashboard when the vehicle is moving 6 4 wi Ea ol AX WARNING The driver or front passenger who is too close to the steering wheel or dashboard can be seriously injured during airbag deployment The driver must sit as far back as possible from the steering wheel while still maintaining control of the vehicle The front passenger must sit as far back as possible from the dashboard Sitting improperly or out of position can cause occupants to be shifted too close to a deploying airbag strike the interior structure or be thrown from the vehicle resulting in serious injury Copyright Mahindra amp Mahindra Ltd 082015 w1 re AX WARNING e Always sit upright with the seat back in an upright position on the seat cushion centre with your seat belt on
78. cially worthwhile with aggressive tread designs such as those on On Off road type tires a Voricie Rotation will increase tread life help to maintain mud snow and wet traction levels and contribute to a smooth quiet ride Follow the recommended tire rotation frequency for your type of driving More frequent rotation is permissible if desired The reasons for any rapid or unusual wear should be corrected prior to rotation being performed 12 5 1 Changing a Flat Tire Refer to If you have a Flat Tire section in the general chapter for details Copyright Mahindra amp Mahindra Ltd 082015 WHEELS AND TYRES 12 5 2 Wheel Tightness When you change a wheel remove all rust and dirt at all locations where the wheel contacts the wheel hub Use a scraper or wire brush to be sure that you remove all rust and dirt A loose wheel could have damaged or elongated the holes in the rim or damaged the rim hub assembly If any of the wheel studs or nuts are damaged contact the nearest Authorized Mahindra Dealer Ax WARNING Always tighten the nuts in a crisscross sequence Never use oil or grease on your wheel studs or nuts Never over tighten the nuts on the wheel stud You could damage the stud or the nut Torque tighten the wheel nuts to the specified value at the nearest Authorized Mahindra Workshop NOTICE The tyres fitted in this vehicle meet the requirements of BIS and they comply with the requireme
79. cked if a leak is suspected abnormal noises are apparent and or the system is not functioning as anticipated Coordinate inspection efforts through an Authorized Mahindra Dealer H CAUTION Driving a vehicle with power steering fluid below the minimum mark will damage steering system Use only recommended power steering fluid Do not use other types of power steering fluids which may damage the power steering system 14 11 MAINTENANCE 6 If the fluid is low add fluid in small amounts continuously checking the level until it reaches the correct operating range Be sure to put the cap back on the reservoir 7 With a clean cloth wipe any spilled fluid from all surfaces A NOTICE Changing of power steering fluid should always be done by an Authorized Mahindra Dealer y42P08 b WARNING 14 5 8 Windshield Washer Fluid Top up The fluid level in the reservoir should be checked on a level surface with the engine OFF to prevent injury from moving parts and to ensure accurate fluid level reading Follow the below steps for checking and topping up the power steering fluid 1 Start the engine and let it run until it reaches normal operating temperature 2 While the engine idles turn the steering wheel left and right a couple of times 3 Turn the engine OFF Top up the windshield washer reservoir as and when required The 4 Check the power steering fluid level in the reservoir fluid reservoir is located on the
80. d No when the engine is running the starter motor will not attempt to re crank If any component involved in the system fails what will happen The system has a built in diagnostic module which understands the failure and immediately goes to bypass mode In the bypass mode the engine can be turned ON and OFF with ignition key as usual Are there any indications to show that engine does not stop due to poor battery charge state Yes if all other conditions except battery charge are met the ESS lamp blinks faster for 7 5 seconds and the engine does not switch OFF 8 46 Copyright Mahindra amp Mahindra Ltd 082015 CD FEATURES AND CONTROL 8 23 Radio Frequency ID RFID Tag A NOTICE Your vehicle is fitted with a RFID tag as per CMVR regulations on Do not peel or remove the RFID front windshield RFID tag may be used for Electronic Toll Collection ETC Copyright Mahindra amp Mahindra Ltd 082015 8 47 AD 9 STEERING AND BRAKES 9 1 Steering Your vehicle is equipped with power steering Power steering uses energy from the engine to decrease the driver s effort in steering the vehicle The power steering system will give you good vehicle response and increased ease of maneuverability in tight spaces If for some reason the power assist is interrupted it will provide mechanical steering capability to steer the vehicle Under these conditions you will observe a substantial increase in steering effort especiall
81. d 082015 5 SEATS AND SEAT BELTS 5 1 Driver seat 5 1 1 Sitting in the Correct Position W12E01 Follow the tips below for a comfortable and safe journey Sit in an upright position with the base of your spine pressed against the seat back Adjust the head restraint as close as possible to the above specified position with the top of the head restraint even with the top of your head Maintain sufficient distance between yourself and the steering wheel Maintain at least a ten inch 10 distance from the centre of the steering wheel to your chest Copyright Mahindra amp Mahindra Ltd 082015 SEATS AND SEAT BELTS e The top curve of the steering wheel should align with your chin for ideal road visibility e Adjust your seat and seat back angle such that your wrists rest on top of the steering wheel freely e Ensure your legs are in a bent position while fully depressing the clutch pedal The seat should be adjusted while still maintaining control of the foot pedals steering wheel and your view of the instrument panel controls AX WARNING Never adjust the driver s seat while the vehicle is in motion The seat may unexpectedly move and cause the driver to unintentionally operate the accelerator or brake or turn the steering wheel causing loss of control of the vehicle an accident or serious personal injury Adjust the driver s seat only when the vehicle is not in motion Never put objec
82. de R Reverse Mode Upshift in Manual Mountain mode Downshift in Manual Mountain mode 11 7 1 Starting the Engine Apply park brake firmly Press the brake pedal Ensure transmission is in N check the cluster gear display Do not press the accelerator a fF oO Turn the key momentarily to the START position to crank the engine 6 Once the engine starts release the key it will return to the IGN position ds A CAUTION Do not continue cranking after the engine has started This will lead to damage of the starter and other engine components 7 If the engine fails to start attempt to restart by toggling the key 8 If the engine fails to start even after repeated attempts as per the procedure given above contact the nearest Authorized Mahindra Dealer A CAUTION e The engine can be started only when the brake pedal is pressed and the gear shift lever is in N position e If turning the key is difficult jiggle the steering wheel from side to side and try again The key can be removed only in the LOCK position When the key is removed the steering column lock is activated and the steering wheel cannot be turned e Never return the key to the LOCK position or try to remove the key when the vehicle is in motion Removing the key allows the steering wheel to lock You will loose the control of the vehicle and may cause serious accident Remove the key only when the vehicle is parked Copyright M
83. dra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC AX WARNING Refrigerant used in the system is a hazardous liquefied gas and is under high pressure The refrigerant is colorless and has ethereal or faint sweetish odor Exposure of refrigerant to the skin or eyes may cause irritation and frostbite It can also cause suffocation dizziness and loss of concentration When mixed with compressed air or certain other refrigerants it may form a flammable mixture Never try to service the HVAC system yourself which would involve refrigerant handling NOTICE To ensure sufficient air flow and hence adequate HVAC system performance the air flow path should be kept free of obstructions Keep the system s air intake located near the plenum appliqu free of snow leaves and other debris Also keep the area in front of the air vents free of any obstruction inside the cabin 10 1 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC 10 1 HVAC Overview N U42K01 ww A Side De misting Vents D Center Vents B Windshield Defrost Vents E Foot Vents C Side Vents E HVAC Controls 10 2 Copyright Mahindra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC 10 2 Center Side Vents pe J Rotate the thumb wheel right to open or left to close the air vent Direct air to the desired direction by the adjusting louvers A A Adjus
84. e Engine oil consumption depends upon the viscosity and quality of the oil and upon the conditions in which the vehicle is driven Oil consumption will be more due to high speed driving and frequent acceleration and deceleration A new engine may consume more oil since its pistons piston rings and cylinder walls are not conditioned 14 5 4 Checking Topping the Engine Oil e Make sure the vehicle is on level ground e Turn the engine OFF and wait a few minutes for the oil to settle down into the oil sump e Apply the parking brake e Open the hood Protect yourself from engine heat e Locate and carefully remove the engine oil level dipstick Copyright Mahindra amp Mahindra Ltd 082015 Wipe the dipstick with a clean cloth Insert the dipstick fully then remove it again If the oil level is between Min and Max marks the oil level is acceptable DO NOT ADD OIL If the oil level is below the Min mark add enough oil through the oil filler neck to raise the level within the Min and Max marks Wait for a few minutes after every top up for the oil to settle down before checking the level Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE e Oil levels above the Max mark may cause engine damage poor performance e Put the dipstick and the oil filler cap back and ensure it is fully properly seated H CAUTION To avoid possible oil loss and injury due to hot blow by
85. e amp clutch fluid every 40k km or 2 yr whichever earlier D Check amp Clean as per km or when Indicator Glows Note AMT oil top up should not be done on vehicle it should be done after removing from vehicle Copyright Mahindra amp Mahindra Ltd 082015 A After Driving Off road or through Water 0 0 cece eee 11 17 Air Conditioning System Maintenance Air Distribution Control Air Intake Mode Control Air conditioner ON Airbag Deployment Airbag Disposal Airbag Inflation Deployment Airbag Maintenance Airbag Repair Airbag Replacement Airbag System Malfunction Lamp Airbag Warning Lamp AirbagS 00 Aluminium Wheels And Wheel Covers AMT warning Lamp Anti Lock Brake System ABS Anti lock Brake System ABS Malfunction Lamp Appearance Care and Protection Audio Infotainment Manual Auto Locking Auto Re locking Auto Unlocking B Battery Battery Charging System Warning Lamp Battery Mounted Fuse Box Blower Speed Control Brake Energy Regeneration Technology If equipped Brakes Bulb Replacements Bulb Specification C Can Cup Bottle Holders eee cette e reer A 8 20 Center Side Vents Central Locking System hanging a Flat Tire P hanging the Wiper Blad 14 13 heck Engine Lamp 8 30 hecking the Electrolyte Level hecking the Wiper Blades hecking Topping Brake Fluid hecking Topping Engine
86. e circulation mode for long will make the cabin air too dry and the oxygen level drops inside cabin turning the air stale On the contrary keeping air intake control in the recirculation mode for long with the air conditioner switched OFF will make the cabin air too humid and the windshield windows are more likely to fog A NOTICE The re circulation mode is activated by default every ignition cycle 10 8 Air Conditioner ON The air conditioning system can be switched ON OFF by the AC button in the climate control system A LED is also incorporated on the button to indicates the status The air conditioner is operational only when both the engine and blower are running When the air conditioner is ON air gets cooled and de humidified before being circulated inside the cabin In hot weather conditions it Copyright Mahindra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC will take slightly longer to cool the interior as compared to cooler Occasionally the air conditioner might not actually be weather Fuel consumption will be relatively higher if the vehicle is functioning even when the LED on the AC switch remains being driven with the air conditioner illuminated This is to be considered as normal AC system operation e During extreme cold weather conditions the air conditioner may not function until the temperature of the air near the evaporator rises above a pre defined th
87. e clutch pedal and the engine starts immediately e The indicator in the cluster goes OFF indicating that the engine has started again and you are ready to drive on For auto stop to happen the following major conditions are to be met e ESS system is activated using the selection switch e Bonnet is fully closed Copyright Mahindra amp Mahindra Ltd 082015 8 43 FEATURES AND CONTROL e Inthe current ignition cycle the vehicle has crossed 2 kmph at least once e Current status of the engine is idling e Vehicle speed is zero e Accelerator pedal and clutch pedal are fully released e Vehicle battery should be in healthy condition e Engine is warm This is an extra precaution to ensure safe working of the engine e Gear is in neutral For auto start to happen the following major conditions are to be e Vehicle should have been stopped by the ESS system e Gear lever is in the neutral position e Vehicle speed is zero e ESS switch is in active mode Bonnet should be closed e Clutch pedal is fully pressed to restart 8 22 3 Frequently Asked Questions FAQ 1 What is the advantage of this system The ESS system aids in attaining better fuel efficiency of your vehicle and thus reducing your running costs However the mileage improvement will depend upon various parameters such as prevailing traffic driving patterns etc 8 44 Copyright Mahindra amp Mahindra Ltd 082015 CGD FEATURES AND CONTROL 2 What are the
88. e control of the vehicle and may cause a serious accident Remove the key only when the vehicle is parked 11 3 Pedals Manual Transmission See Y U4eL02 Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE A Accelerator Pedal B Brake Pedal C Clutch Pedal Automated Manual Transmission AMT A Accelerator Pedal B Brake Pedal 11 4 Starting the Engine Make sure all vehicle occupants are properly seated in their seats and have buckled their safety belts For more information on seat headrest positioning safety belts and their proper usage refer to the Seat Belts section in this manual A NOTICE Conditions to be met before cranking the engine 11 3 STARTING AND DRIVING THE VEHICLE e Make sure the gear shift lever is in neutral and clutch is fully pressed e The glow plug lamp has to switch off before the engine crank e The engine will start even if half turned and the above conditions are met e Make sure the parking brake is engaged Turn the key to IGN position but do not turn the key to start e Few warning lamps briefly illuminate See Warning Lamps in the Instrument Cluster section for more information Sequence of activities Shift the gear shift lever to neutral position Apply parking brake Turn the ignition ON Do not press the accelerator Turn the key momentarily to the START position to crank the a a Fw PY O
89. e details of Trip meter A B AC Meter amp Distance to empty DTE details Trip meter A amp B displays the distance travelled since the last trip reset AC Meter displays the total distance travelled updated as per the odometer with the AC ON When the vehicle is stationary with the AC ON every minute is taken as 1 km and added to the AC meter reading The Distance To Empty is the information in km for the driver to be aware of number of km the vehicle can travel with the available fuel and the fuel economy that the vehicle is giving at that instance The DTE update will be faster if the refueling quantity is greater than 5 liters A NOTICE DTE feature should never be used to calculate the fuel remaining refilled in the vehicle During air lock there are chances that the DTE will be showing some value but the engine switches OFF and will not able to crank 8 25 8 15 5 Gear Selection Display AMT Display If Equipped A Set Button B Mode Button The trip meters A B amp AC meter can be reset to zero by pressing SET A button for more than 3 seconds Gear selection display displays the shifter position A1 Ae A3 A4 NOTICE A5 Odometer and trip meter are displayed only when the ignition is Manual Display ON To cycle between trip A B AC meter amp DTE press and release MODE B button Pressing the Mode button while in trip A displays the trip B reading Again pressing the
90. e far side Frontal Side Swipe Impac of a hole incline will not inflate the airbag 6 8 Copyright Mahindra amp Mahindra Ltd 082015 Frontal offset impact to the vehicle may not provide the deceleration force necessary for airbag deployment In an angled collision the force of impact may direct the occupants in a direction where the air bags would not be able to provide any additional benefit and thus the sensors may not deploy any air bags 6 2 6 Airbag Replacement Self servicing or tampering with the airbag system is dangerous An airbag could accidentally deploy causing serious injuries or will not deploy when there is a need Always take your vehicle to an authorized Mahindra dealer for inspection and repairs 6 2 7 Self Removing SRS Related Parts Self removing the instrument panel steering wheel seats or airbag related parts or sensors is not recommended Airbags could accidentally activate and cause serious injuries or they may not deploy when there is a need Visit an authorized Mahindra dealer if these parts must be removed 6 2 8 Airbag Disposal Improper disposal of an airbag or a vehicle with live airbags can be extremely dangerous Approach an authorized Mahindra dealer to do these jobs 6 2 9 Airbag Repair If the front airbag cover or IP airbag cover shows signs of damage or having been removed the vehicle should be towed to the nearest authorized Mahindra dealer for repair Do not attempt
91. e has RADIAL STEEL BELTED RADIAL on the sidewall A tyre not marked 12 1 Tyre Information with RADIAL is a bias ply tyre D TUBELESS or TUBE TYPE A tubeless tyre does not have A NOTICE a tube inside the tyre and air is directly filled in the tyre A tube type tyre has a tube inside the tyre and the tube The tyres fitted in this vehicle meet the requirements of BIS and maintains the air pressure they comply with the requirements under the Central Motor Vehicles Rules CMVR 1989 12 2 Tyre Rating Your vehicle is originally equipped with tyres supplied by a reputable manufacturer If you ever have any questions regarding your tyres please refer to literature supplied by the tyre manufacturer or to the separate tyre warranty provided by the tyre manufacturer You may also contact Mahindra directly or the tyre manufacturer The tyre rating of your vehicle is e P215 75 R15 100S Tyre rating is explained as below U4emM01 A Max Load Limit B Tyre Size Copyright Mahindra amp Mahindra Ltd 082015 12 1 WHEELS AND TYRES a N 1579 R 45 100 5 dedede U42M02 cA Tyre size example P215 75 R15 1005 A 215 Three digit number This number gives the width in millimeters of the tyre from sidewall edge to sidewall edge This is called Section Width B 75 Two digit number This number known as the aspect ratio gives the tyres ratio of height to
92. e or repair the power outlet in any the power outlet way Doing so may result in unexpected malfunction or fire which could cause serious damage to equipment and or Copyright Mahindra amp Mahindra Ltd 082015 8 15 FEATURES AND CONTROL e Use the power outlets only when the engine is running Remove the plug from the power outlet after using the electric device Using the power outlets when the engine is OFF or leaving the electric device plugged in for many hours may cause the battery to drain e Do not use the power outlet to connect electric accessories or equipment that are not designed to operate on 12V e Some electronic devices can cause electronic interference when plugged into the power outlet These devices may cause excessive audio noise and may interfere with other electronic systems or devices in your vehicle 8 11 Windshield Wipers 8 11 1 Wiper Control Stalk The wipe wash function can be activated only when the ignition is in IGN position 8 16 Flick Wipe MIST Off Intermittent INT Low Speed LO High Speed HI irl E tcp tae oe 8 11 2 Wiper Off The wipe function is OFF when the wipe control stalk is in neutral position B 8 11 3 Flick Wipe Mist Push the wipe control stalk to position A for a flick wipe hold to operate the wipe continuously simultaneously lift the wiper stalk Copyright Mahindra amp Mahindra Ltd 082015 towards the steering wheel
93. e outside using the key will be treated as unauthorized S J activating the vehicle security alarm If this occurs the alarm as can be disarmed by either pressing the UNLOCK button on the RKE or turning ON the ignition followed by a successful 7 3 8 Theft Alarm authentication Vehicle enters into alarm mode when there is a change in door 7 3 9 RKE Operating Range status ignition status provided the vehicle was locked through RKE e Alarm time Pre alarm alarm with less intensity for 5 sec and continuous alarm for 25 sec for the first time e f there is any change in door ignition status for the second time the system enters the alarm state for 30 sec without any pre alarm After the alarm period there will not be any alarm again till any further change in the door ignition status U42613 J Using RKE you can lock arm or unlock disarm the vehicle from distances approx 30ft 9m 78 Copyright Mahindra amp Mahindra Ltd 082015 AD A NOTICE lf there is reduction in RKE range please follow the steps below e Check the distance The RKE may be too far from the vehicle Stand closer to the vehicle during rain or bad weather e Check the location Other vehicles or objects may be blocking the signals Take a few steps to the left or right hold the RKE higher and try again Moreover closeness to a radio transmitter such as radio station tower airport transmitter mobile or CB radio
94. e pulling the restraint out To put it back align the head restraint shafts over the holes on the seat top and push the restraint straight down till you hear the lock click Keep the seat back as upright as possible so the headrest is behind not beneath and almost touching your head D WARNING Never drive with the head restraints not properly adjusted head restraints removed or inserted in a flipped condition With no support behind your head your neck could be seriously injured in a collision Copyright Mahindra amp Mahindra Ltd 082015 SEATS AND SEAT BELTS 5 3 Second Row Bench Seat h WARNING Loading cargo on the seats is dangerous The cargo becomes a projectile that could hit and injure passengers in a sudden stop or collision Cargo should always be kept on the floor Seat Back Fold if equipped The second row seat back can folded forward for maximum cargo space To fold the second row seat back down pull the strap at the rear bottom of the seat firmly and push seat back forward Ensure the head restraints on the second row seat are lowered all the way down before attempting to fold U42E12 Copyright Mahindra amp Mahindra Ltd 082015 5 4 Third Row Seats 5 5 SEATS AND SEAT BELTS z j B U42E09 The third row side facing jump seats can be folded to maximise cargo space Swing the seat cushion fully up Fold the seat leg completely dow
95. ed at an Authorized Mahindra Dealer 14 10 Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE 14 5 6 Checking Topping Brake Clutch Fluid The brake system is supplied with brake fluid from the brake fluid reservoir located adjacent to the air filter The brake fluid level will drop slowly as the brakes wear and will rise when the brake components are replaced Fluid levels between the MIN and MAX lines are within the normal operating range there is no need to add fluid If the fluid levels are below the MIN mark the performance of the systems could be compromised the brake clutch operation could be spongy and gear change harder Top up the recommended brake clutch fluid till the MAX mark or contact an Authorized Mahindra Dealer immediately Carefully clean the cap on the reservoir before you remove it and be sure no debris fall in the reservoir Do not keep the reservoir open for longer than necessary to add brake fluid Copyright Mahindra amp Mahindra Ltd 082015 Use only brake clutch fluid that meets Mahindra specifications Refer to the Lubricant and Capacities section NOTICE Draining or changing of brake clutch fluid should always be done by an Authorized Mahindra dealer 14 5 7 Checking Topping Power Steering Fluid Check the power steering fluid level at the defined service intervals Refer to Maintenance Chart for details The fluid level should be che
96. ehicle in the reverse direction 4 Display bars in the respective direction will glow according to obstacles in its path e If the obstacle is between 100 to 120 cm bar 4 will be turned ON U42H67 Operation of RPAS 1 Start the vehicle IGN is turned ON 2 Change the gear to reverse engage the reverse gear The RPAS will be displayed on the infotainment screen U42H74 e If the obstacle is between 75 to 100 cm bar 3 amp 4 will be turned ON 8 36 U4eH65 e If the obstacle is between 50 to 75 cm bar 2 3 amp 4 will be turned ON U4eH62 e If the obstacle is less than 50 cm all bars in that direction will be turned ON and a STOP symbol will be displayed 5 U42H63 The alert sound can be heard from the driver and co driver side speaker Frequency of the beep will increase if obstacles comes closer crossing each display bar and the sound will be continuous if any of the obstacle is less than 50 cm The RPAS distance displayed will be the minimum of distances sensed by left center and right sensors For eg Assume 3 obstacles are placed as below e Obstacle at left at 60 cm e Obstacle at center at 90 cm e Obstacle at right at 110 cm On engaging the gear in reverse infotainment will display as below Along with this a beep sound can be heard from the driver amp co driver speakers Frequency of the beep will increase if the obstacle comes closer crossing each zones and the sound will
97. ent battery must meet the specification of the originally fitted battery 14 8 2 Checking the Electrolyte Level Check the electrolyte level and specific gravity at intervals of three months Check all the six cells for proper electrolyte levels If the level is below the lower marker add distilled water until the level reaches the upper marker Adding distilled water e Remove the vent plugs e Add distilled water to all the cells that require the fluid and secure the plugs properly 14 16 14 9 Appearance Care and Protection 14 9 1 Washing the Exterior Wash your vehicle regularly with cool or lukewarm water and a neutral pH soap Never use strong household detergents or soap such as dish washing or laundry liquid These products can discolor and spot painted surfaces Never wash a vehicle that is hot to the touch or during exposure to strong direct sunlight Always use a clean sponge or car wash mitt with plenty of water for best results Dry the vehicle with a chamois or soft terry cloth towel in order to eliminate water spotting It is especially important to wash the vehicle regularly during the winter months as dirt and road salt are difficult to remove and cause damage to the vehicle Immediately remove items such as gasoline diesel fuel bird droppings and insect deposits they can cause damage to the vehicle s paint work and trim over time Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE
98. ers Oil contamination will severely shorten bulb life If the bulb comes in contact with any oily surface clean the bulb with rubbing alcohol A CAUTION To avoid burning yourself do not replace the light bulbs when they are hot Halogen bulbs have pressurized gas inside and are to be handled with special care Mishandling it may cause the bulb to burst or shatter Hold the bulb with its metal plastic holder base and do not touch the glass part with bare hands Using bulbs with units of higher output capacity wattage is illegal and may damage your vehicle s electrical system Replacement bulbs must meet the specification of originally fitted bulbs 14 14 Scheduled Maintenance The scheduled maintenance jobs listed in the Scheduled Maintenance Chart are those required to be carried out at regular predetermined intervals To make sure that your vehicle runs efficiently all the time follow the maintenance schedule The service interval for the scheduled maintenance is determined by the odometer reading Take your vehicle to an Authorized Mahindra Service Station only Trained Copyright Mahindra amp Mahindra Ltd 082015 D technicians and genuine Mahindra parts at Mahindra Authorized service stations are best for your vehicle They will perform all the scheduled maintenance jobs reliably and economically Inadequate incomplete and insufficient servicing may result in problems The owner should retain records document
99. es A NOTICE For optimum performance of the cooling system you must maintain the required coolant level and use only recommended engine coolant 13 4 Jump Starting If your vehicle s battery has run down you may be able to start the engine by using a standalone booster battery or a vehicle with a good condition battery But before going ahead with this procedure ensure that the battery is the cause of vehicle not starting To confirm this few simple tests can be conducted as follows 13 3 EMERGENCIES GD Check the headlights Are they dim or bright If they are dim it s a N likely your battery is dead If your headlights are bright you do not have a dead battery and a jump start may not help e Try to start your vehicle Does it turn over very slowly or does it crank quickly If it cranks quickly you do not have a dead battery and a jump start may not help If it cranks slowly or not at all you probably have a dead battery Open the bonnet and locate the battery near the left side fender Identify the positive and negative terminals w1 emoe_ e The positive terminal will be marked with a plus sign and will AS WARNING usually have a RED cable attached on it f Don t let the vehicles touch each other e The negative terminal will be marked with a minus sign and will usually have a BLACK cable attached to it 2 Wear safety gear goggles or face guard and gloves if you have it
100. f Removing SRS Related Parts Sitting in the Correct Position Snow Chains Spare Wheel Removal Speed Rating Speedometer Start Stop Lamp Micro Hybrid Starting the Engine Static Bending Lamps Steering Steering Controls Audio Control System Stopping the Engine ee Suggestions for Obtaining Service for your Vehicle Sun Visor T Tachometer ie Technical Specifications Temperature Control Temperature Gauge Theft Alarm 8 24 2 19 10 5 8 27 78 Third Row Seats Tilt Steering Tip Tap ORVM Adjustment Tips for Better Fuel Economy Tire Pressure Tire Rotation Recommendations To Lock and Arm the Vehicle with RKE To Owner s of a Mahindra Vehicle Trip Meter A B AC Meter amp DTE Turn Lamps Turn Signals Tyre Rating U Erua T aea a ARAE RETANA AEEA OSER EPEE AE EEE ETEEN 14 19 Unfastening the Seat Belt both 3 Point amp 2 Point 25 11 Unlock and Disarm the Vehicle with RKE Utility Holders V Vehicle Does not Start Checks isssrisrerrenirinadrienranirerirn ies Vehicle Identification Number VIN zi Vehicle Overheating Vehicle Self Maintenance General Precautions Ps Voice Messaging System VMS If equipped 0 ee W Warning Lamps Warning Lamps in the Instrument Cluster Warning Lamps Overview Warranty Information Washing the Exterior Water in Fuel Warning Lamp Whee
101. g Lamp No Continuously ON The fuel level in the fuel tank is low Re fuel immediately to a avoid empty tank Continuously ON or Continuously ON Engine is in auto stop mode Blinking Stop Start is about to stop the engine Engine Starts L fae tany ae Ror appa eee Blinking Fast Blinking Stop Start is inhibited due to unhealthy battery conditions Continuously ON till There is a potential malfunction related to emission control Malfunction Lamp OBD Engine Starts a OIN system contact an Authorized Mahindra Dealer immediately F Continuously ON till TEOR Battery Charging Warning Lamp Continuously ON Indicates malfunction in the charging system Contact an Authorized Mahindra Dealer for assistance Copyright Mahindra amp Mahindra Ltd 082015 4 5 INSTRUMENT CLUSTER OVERVIEW Symbol Warning Lamp Tell Tale Lamp Pre check Lamp Status Action Remarks EOW P oo ak ae ae ul Continuously ON _ Indicates engine oil pressure is low Check oil level and top up ies mam gine S or contact an Authorized Mahindra Dealer for assistance Glow Plug Indicator For about 2 seconds Continuously ON Indicates a malfunction in the starting system Contact an Authorized Mahindra Dealer immediately AMT warning lamp For about 3 sec Continuously ON Indicates malfunction of the AMT system Contact an Authorized Mahindra Dealer immediately 46 Copyright Mahindra amp Mahindra Lt
102. g and in turn increase the braking distance effort to stop the vehicle If you return the gearshift lever from N to A mode the appropriate gear will Tap the gear shift lever to the left to toggle between A M modes be selected according to the vehicle speed NOTICE While driving downhill it is recommended to shift to M mode and change to lower gear This will enable engine braking and better vehicle control 11 7 5 M Mode When the M mode is selected the vehicle can be driven with manual gear shifts similar to conventional manual gears The first Copyright Mahindra amp Mahindra Ltd 082015 11 11 STARTING AND DRIVING THE VEHICLE AX WARNING Do not shift the gearshift lever to the N position while driving This will lead to loss of engine braking and in turn increase the braking distance effort to stop the vehicle If you return the gearshift lever from N to M mode the appropriate gear will be selected according to the vehicle speed A CAUTION In M mode though the gear change is done manually if the vehicle speed does not necessitate an upshift then you will not be able change to higher gear till the required vehicle speed is met The same holds good for downshifts too you can shift to a lower gear only when the vehicle speed meets the recommended speed for that particular gear 11 12 11 7 6 R Mode When the R mode is selected
103. h the service coupon booklet It s important to document the maintenance of your vehicle For your convenience to maintain records of service the scheduled maintenance coupons are provided in the service coupon booklet Every time you bring your vehicle in for scheduled maintenance be sure to present this booklet and certify the work Also record the date of service and mileage at the time of service This will make CD record keeping easy and should your vehicle ever require warranty coverage you will have all the documentation to show you ve properly maintained it 14 1 1 Maintenance Interval Mahindra establishes recommended maintenance intervals based upon engineering testing to determine the most appropriate mileage to perform the various maintenance services This protects your vehicle at the lowest overall cost to you Mahindra recommends that you do not deviate from the maintenance schedules presented in this Maintenance Schedule 14 1 1 2 Oils Fluids and Flushing In many cases fluid discoloration is a normal operating characteristic by itself and does not necessarily indicate a concern or that the fluid needs to be changed However discolored fluids that also show signs of overheating and or foreign material contamination should be inspected immediately by a qualified expert such as the factory trained technicians at your Authorized Mahindra Dealer Your vehicle s oils and fluids should be changed at the specified interva
104. he Engine Compartment e Parking brake e Front windshield washer fluid level S Eear levershitt mechanism Engine coolant level Outside the Vehicle e Battery condition Lamps Copyright Mahindra amp Mahindra Ltd 082015 14 7 MAINTENANCE e Fluid leaks e Doors and engine hood latches e Tire inflation pressure e Tire surface thread and wheel nuts 14 5 In the Engine Compartment 14 5 1 Fluid Leaks Check the engine compartment and the underbody of the vehicle for any leaks If you smell fuel vapor or notice any leak have the cause found and corrected immediately 14 5 2 Engine Oil Engine oil has the primary function of lubricating and cooling the inside of the engine It plays a major role in maintaining the engine in proper working order Therefore it is essential to check the engine oil regularly 14 5 3 Engine Oil Consumption It is normal for engines to consume some engine oil during operation Causes of consumption in a normal engine are as follows 14 8 AD e Oil is used to lubricate pistons piston rings and cylinders Thin films of oil left over when pistons move in cylinders are sucked into the combustion chamber due to high negative pressure generated when the vehicle is decelerating This oil gets burnt in the combustion chamber e Qil is also used to lubricate the stems of intake valves Some of this oil is sucked into the combustion chamber together with the intake air and is burnt ther
105. he air intake Following are the five different distribution modes to choose from knob in fresh air mode e Defrost Mode air is discharged from the side defrost vents and windshield defrost vents This mode is most suitable for directing air flow towards the front windshield to ensure defrosting or de misting defogging Keep the air intake knob in fresh air mode e Face Mode air is discharged from the center vents and side vents This mode is most suitable for directing air flow towards the face of the passengers 10 4 Copyright Mahindra amp Mahindra Ltd 082015 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC 10 5 Blower Speed Control The blower force circulates air through the HVAC unit and distributes it throughout the passenger compartment Blower is off when the blower speed control knob is set to small o position extreme left To switch on the blower rotate the control knob clockwise which progressively increases the blower speed Copyright Mahindra amp Mahindra Ltd 082015 10 6 Temperature Control By operating the temperature control knob temperature of air being discharged from various vents can be adjusted to the desired level Engine coolant is utilized to heat whereas the air conditioner is used to cool the air inside the AC unit Based upon selected position of the temperature control dial the desired discharged air temperature can be obtained By rotating the dial co
106. he fuel system drained completely During freezing weather if the fuel is not winterized or is insufficiently winterized waxing gelling may take place in the fuel leading to interruption in fuel supply to the engine For smooth functioning and reliable operation of the engine during cold weather conditions use winterized ULSD which is available at the filling stations during winter months Check with your fuel retailer for further details 1 CAUTION Avoid inhaling fuel vapors and any skin or clothing contact Direct skin contact with diesel or the inhalation of fuel vapor may affect your health It is recommended maintaining a minimum of 10 liters of fuel in the fuel tank Driving the vehicle till the fuel tank is empty is not recommended Always have sufficient fuel in the tank Check the fuel level prior to starting your journey B WARNING Never carry fuel in separate containers in the vehicle it is dangerous and may lead to an inadvertent fuel leak or spillage Copyright Mahindra amp Mahindra Ltd 082015 11 9 1 Fuel Lid Opening and Closing The fuelid can be opened by the lever located at the foot of the driver seat Lift the lever up firmly to open Turn the fuel cap counter clockwise to open Refuel and put the cap back in its place and tighten in the clockwise direction till three distinct clicks are heard Close the fuel lid shut WES STARTING AND DRIVING THE VEHICLE GD A CAUTION e While id
107. he tabs are free of the metal support Carefully insert the new blade rubber Then install the blade assembly in the reverse order of removal 14 13 MAINTENANCE 14 6 Maintenance Inside the Vehicle 14 6 1 Lights Make sure the headlights stop lights tail lights turn signal lights and other lights are all working Check headlight aim 14 6 2 Warning Messages and Lamps Check all warning lamps appearing in the instrument cluster and DDAS Refer to the relevant sections in this manual for further details 14 6 3 Seats Check that all seat controls such as seat adjusters seat back recliner etc operate smoothly and that all latches lock securely in any position Check that the head restraints move up and down smoothly and that the locks hold securely in any latched position 14 6 4 Seat Belts Check that the seat belt system such as buckles retractors and anchors operate properly and smoothly Make sure the belt webbing is not cut frayed worn or damaged 14 14 GD 14 6 5 Accelerator Pedal Check the pedal for smooth operation uneven pedal effort or stickiness Check the foot well and remove obstructions if any 14 6 6 Brake Pedal Check the pedal for smooth operation and proper clearance Check the foot well and remove obstructions if any 14 7 Maintenance Outside the Vehicle The following checks should be carried out from time to time unless otherwise specified 14 7 1 Lamps Check and ensure proper f
108. heels may change suspension a Vehicle Front geometric and performance characteristics resulting in changes to steering handling and braking of your vehicle This can cause unpredictable handling stress to steering and suspension components You could lose control of the vehicle or the tire can unexpectedly fail resulting in an accident and or on personal injury NOTICE W12L09 Replacing original tires with tires of a different size may result in false speedometer and odometer readings Tires on the front and rear axles of vehicles operate at different loads and perform different steering handling and braking functions For these reasons they wear at unequal rates and 12 4 6 Snow Chains develop irregular wear patterns Snow chains cannot be used on these tires Rotation will increase tread life help to maintain mud snow and AS WARNING wet traction levels and contribute to a smooth quiet ride Follow the recommended tire rotation frequency for your type of driving In CaSe of harsh winter driving conditions it is recommended Type 2 Applicable for 4 Alloy wheels and Spare wheel with Steel rim using winter tires with the same specifications for better stability safety and performance lt is recommended rotating the tires as per the Maintenance Schedule 12 6 Copyright Mahindra amp Mahindra Ltd 082015 The suggested rotation method is the forward cross shown in the diagram The benefits of rotation are espe
109. her assistance 8 31 8 17 9 Low Engine Oil Pressure Warning Lamp The low engine oil pressure warning lamp illuminates when the ignition switch is turned ON and goes out g as soon as the engine is started If the lamp remains ON even after starting the engine or illuminates while driving stop immediately and check the oil level after 2 3 minutes If low add engine oil to the MAX level and check status If problem persists contact an Authorized Mahindra Dealer immediately AS WARNING Operating the vehicle with the low oil pressure warning lamp ON could cause sudden unexpected engine failure and loss of vehicle control resulting in an accident or personal injury Do not run the engine with low oil pressure warning indicator ON This may result in engine damage which will not be covered by the limited warranty 8 17 10 High Engine Coolant Temperature Warning Lamp The high engine coolant temperature warning lamp aa and all bars in the temp gauge blink when the coolant temperature is 110 C and they remain permanently ON when the temperature reaches 119 C Contact an Authorised Mahindra Dealer immediately 8 32 CD Ax WARNING Do not continue driving the vehicle with an overheated engine This may result in engine damage which will not be covered by the warranty 8 17 11 Water in Fuel Warning Lamp The water in fuel warning lamp illuminates when the accumulation of water in the fuel filter reaches the D maximu
110. hindra amp Mahindra Ltd 082015 SEATS AND SEAT BELTS 5 6 3 Unfastening the Seat Belt both 3 Point amp 2 Point To release the belt press the buckle release button and allow the belt to retract If the belt does not retract smoothly pull it out and check for kinks or twists Then make sure it remains untwisted as it retracts B WARNING Never insert coins clips etc in the buckle as this may prevent you from properly latching the tab and may cause damage to the buckle mechanism thereby making the seat belt ineffective in an accident resulting in serious personal injury Copyright Mahindra amp Mahindra Ltd 082015 u Suitable position for using universal child restraint system using seat belt Not Suitable position for using child restraint system using seat belt Always secure a child in a proper Child Restraints System in accordance with age and size of the child as recommended by the child restraint system manufacturer Be sure to follow the Child 5 11 SEATS AND SEAT BELTS Restraint System Child seat manufacturer s instructions for seat belt routing AX WARNING Do not allow children to stand up or kneel on either the rear or the front seats An unrestrained child could suffer serious injuries during emergency braking or collision Legend U Suitable position for using universal child restraint system using seat belt and buc
111. ility or can be held liable for any 8 39 direct or indirect incidental or consequential damage caused by this system 8 21 Brake Energy Regeneration Technology If equipped In Brake Energy Regeneration technology additional electrical energy is generated through Alternator during braking decelerating and preserved in the battery This optimisation process of electrical energy generation leads to reduced fuel consumption and emission Also during accelerations generation process is disabled which reduces load on the engine leading to improvement in vehicle performance The system architecture is equipped with battery management sensor patented by Mahindra and an intelligent alternator which ensures optimal electrical energy management as an additional benefit 8 21 1 How Does the system Work While braking decelerating energy is transferred from wheels to battery e For auto stop to happen the following major conditions are to be met While accelerating the alternator is disabled and the energy is available to wheels e When the vehicle is accelerating for example while overtaking alternator will be electrically disabled and load on the engine reduces which helps to accelerate little faster 8 40 8 21 2 Frequently Asked Questions FAQ 1 What is the advantage of this system The Brake Energy Regeneration system helps in attaining better fuel efficiency on your vehicle as you drive and thus reduces your
112. im could prevent proper deployment of the airbag If you need to make any modifications to accommodate any disability you may have please contact your Authorized Mahindra Dealer Never try to open or strike the airbag cover If the airbag cover is cracked or damaged in any way the airbag may not function as intended Take the vehicle to an Authorized Mahindra Dealer Even if the airbags do not deploy during an accident take your vehicle to an authorized Mahindra Dealer for a thorough inspection of the airbag and seat belt systems no matter how minor the accident The airbag system could have been damaged and may not work as intended in the future resulting in serious injury 6 2 3 Airbag Inflation Deployment The airbag sensors constantly monitor the forward deceleration of the vehicle If an impact results in a forward deceleration beyond the designed threshold level the system triggers the airbag inflators This initiates a chemical reaction which quickly fills the airbags with non toxic gas Upon deployment tear seams molded directly into the pad covers separate under pressure from the expansion of the airbags Further opening of the covers allows full inflation of the airbags A fully inflated airbag in combination with a properly worn seat belt slows the driver s or the passenger s forward motion reducing the risk of head and chest injury After complete inflation the airbag immediately starts deflating enabling the dri
113. in All the Pressing the hazard switch twice deactivates this feature turn signal lamps flash To turn OFF press the switch again 8 6 Follow Me Home FMH RKE This feature helps the driver and passengers to easily get out of the vehicle during poor light conditions The head lamp low beam is turned ON for about 20 seconds assisting the passengers to find their way unless cancelled by the UNLOCK signal from the RKE To enable FMH e Ignition transition from ON to OFF e Park lamp ON to OFF A NOTICE e Ignition key is out The turn lamps do not work when the hazard warning lamps e Double press RKE LOCK are operational e Head lamp low beam will turn ON for 20 seconds unless Hazard lamps are also switched ON during the following cancelled by the UNLOCK signal conditions To extend FMH Crash H f i REA E wide The first RKE LOCK command will be used for locking all doors e Panic Braking When the vehicle is running above 100 kmph and panic sudden brakes are applied hazard will turn on for 5 sec e Successive RKE LOCK commands will be used for toggling the current status of the head lamp low beam e Each time FMH is extended the head lamp low beam will be kept turned on for the next 20 seconds e Vehicle break down warning bonnet open The vehicle break down warning would be enabled only when bonnet switch changes from close to open condition at vehicle If no extension is provided for 3 mins FMH will get ex
114. indows check for obstructions like a head hand etc which may lead to personal injuries 8 2 8 1 1 Power Window Lock Switch A power window lock switch is provided in the quadruple switch bank which toggles the operation of the rear passenger power window switches 8 2 Butterfly Window Rear Quarter Window To open the rear quarter window butterfly window pull the latch handle towards you and push the window out completely For closing the window pull and lock the latch handle which will bring the rear quarter window back to its original closed position Copyright Mahindra amp Mahindra Ltd 082015 CGD FEATURES AND CONTROL 8 3 Outside Rear View Mirror ORVM Integrated exterior rear view mirrors on both the sides facilitate maximum rear view information to the driver Both the ORVM s are hinged and can be manually folded or unfolded This avoids hindrances in narrow areas and parking slots Make sure that you fully engage the mirror in its support while folding or unfolding Ad WARNING A CAUTION l Do not overestimate the distance of the objects that you see in Do not allow children to operate the quarter window Pinching the mirrors Objects seen in convex mirrors are much closer fingers is inevitable if not operated properly Make sure it is than they appear operated only by adults Copyright Mahindra amp Mahindra Ltd 082015 8 3 FEATURES AN
115. ine before turning it off may reduce fuel economy Carrying unnecessary weight may readuce fueliecononiy i Ls e Addin in ri r vehicle may r fuel e The air conditioner may reduce fuel economy dding certain accessones to yeurvenicle may reduce fue economy e Warming up a vehicle on cold mornings is not required and may reduce fuel economy e Four wheel drive operation if equipped is less fuel efficient than two wheel drive operation 11 20 Copyright Mahindra amp Mahindra Ltd 082015 Driving on flat terrains offer improved fuel economy as compared to driving on hilly terrains Close windows during high speed driving for better fuel economy It is recommended to refuel in the mornings cold weather condition 11 10 1 How to Calculate Fuel Efficiency Mileage Das go Ensure recommended tire pressure is maintained Refuel your vehicle till the fuel gun at the fuel station is auto cut off Reset trip meter to zero Drive at a moderate speed for a minimum distance of 100 km Refuel at the same fuel station till the auto cut off mode Assuming a liters of fuel was filled and b was the trip meter reading Fuel Efficiency b a kmpl We recommend that point no 2 and point no 5 should be done in cold conditions In mornings Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE 1124 CGD WHEELS AND TYRES 12 WHEELS AND TYRES C Radial tyres or bias ply tyre A radial tyr
116. intended to deploy in side impact rear impact or rollover crashes In addition front airbags will not deploy in frontal crashes which are below the prescribed deployment threshold where risk of serious injuries is low A NOTICE Do not place any objects over the airbag or between the airbag and yourself 6 2 2 Airbag System Malfunction Lamp Airbags do not require any regular maintenance of 27 service The airbag system malfunction lamp illuminates when the ignition is ON as self check confirming normal operations of airbag system and malfunction lamp This lamp monitors airbag sensor assembly airbag sensors indicator lamp seat belt pre tensioner assemblies inflators interconnecting wiring and power sources If either of the following conditions occur there is a malfunction of the airbags or seat belt pre tensioner Immediately contact your Mahindra Dealer e The lamp does not glow when the ignition is switched ON or glows beyond six 6 seconds after switching the ignition ON e The lamp comes ON at any other time even briefly Copyright Mahindra amp Mahindra Ltd 082015 CD e The lamp comes ON intermittently A NOTICE Never make any modifications to your vehicle which could affect the performance of your airbag system In particular changes to the vehicle frame bumpers bull bar front fenders ride height suspension seat belts interior trim seats or steering wheel especially covers pads or other tr
117. ion Radial tires may look properly inflated even when they are underinflated At the same time each tire should be inspected for signs of tire wear or visible damage Inflation pressures specified on the placard are always cold tire inflation pressures Cold tire inflation pressure is defined as the tire pressure after the vehicle has not been driven for at least three hours or driven less than 1 km after a three hour period Check tire pressures more often if subject to a wide range of outdoor temperatures as tire pressures vary with temperature changes Tire pressures change by approximately 1 psi 7 kPa per 7 C of air temperature change Keep this in mind when checking tire pressure inside a garage especially in the winter When it was new the spare tire in your vehicle was fully inflated However a spare tire can lose pressure over time In order to avoid being stranded check the spare tire air pressure frequently 12 4 2 Inflating Your Tires Safe operation of your vehicle requires that your tires are properly inflated Remember that a tire can lose up to half of its air pressure without appearing flat 12 4 CD At least once a month or before long trips inspect each tire and check the tire pressure with a tire gauge including spare tire Inflate all tires to the recommended inflation pressure A WARNING Under inflation is the most common cause of tire failures and may result in severe tire cracking tread separatio
118. ion Be sure the cause an accident parking brake is firmly set when parked and the gear shift lever is in gear When parking on a hill you should apply the parking brake before placing the shift lever gear since the load on the transmission locking mechanism may make it difficult to move the shift lever out of gear Copyright Mahindra amp Mahindra Ltd 082015 9 5 9 5 Anti Lock Brake System ABS if equipped The Anti lock Brake System also called as ABS is designed to help prevent lock up of the wheels and stable stopping of vehicle during a sudden panic emergency braking or braking on slippery road surfaces The ABS system takes input from wheel speed sensors and brake pedal switch to control the brake fluid pressures at the wheels to avoid wheel lock up It allows vehicle to be steered during braking The minimum speed for ABS to function is 12 kmph ABS is activated only during wheel lock conditions where ABS takes over and prevents wheel lock During the ABS operation a slight pulsation may be felt in the brake pedal to indicate ABS is active You may also hear motor noise from the engine compartment It is recommended to hold the brake pedal firmly while the ABS is active rather than pumping the brake pedal 9 6 CD Depressing the brake pedal on slippery road surfaces as on a manhole cover a steel plate at a construction site a joint in a bridge etc on a rainy day tends to activate the anti lock
119. ity safety emissions and reliability When driving through water drive very slowly and at constant speed less than 5 kmph Water waves generated will be high and may enter air intake causing severe engine damage or cause a vehicle to get stalled You must slow down while driving through shallow water Speeding may cause water to splash onto the windshield impairing your vision The ground under the water might not be firm which could result the water being deeper than expected when driving the vehicle through it CD Do not stop or shut OFF the engine while immersed in water It helps in preventing water getting inside the exhaust pipes When backing down a ramp do not allow the exhaust tail pipe to immerse in water Water can wash the grease from wheel bearings causing rusting and premature failure It may also enter the differentials transmission and transfer case reducing the oil s lubricating qualities If these are submerged in water the lubricants should be replaced as required Water entering the transmission will cause deterioration in shift quality locking up of your transmission accompanied by vibration and ultimately damaging the transmission Sand mud sludge that has accumulated in brake drums and around brake discs may affect braking efficiency This may also damage brake system components Wet brakes cannot stop the vehicle as effectively as dry brakes Drying can be improved by driving the vehicle slowl
120. kles marked with CRS Not Suitable position for using child restraint system using seat belt Group 0 0 10 Rear facing child restraint system on the Group O upto 13 outboard 2nd row seats using seat belt Group 1 9 18 Forward facing child 2 restraint system on the Grap 18 25 outboard 2nd row seat Group 3 22 36 using seat belt 5 12 Copyright Mahindra amp Mahindra Ltd 082015 CD 6 SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped 6 1 Airbags Your vehicle has the following airbags e A frontal airbag for the driver e A frontal airbag for the front passenger if equipped Airbags are located in e The steering wheel hub e The passenger side instrument panel They are indicated by AIRBAG embossed on the covers A NOTICE An airbag is not designed to deploy in every type of crash Depending on the type of accident or impact the front airbags independently deploy thereby protecting the occupants It is not necessary that ALL the airbags deploy during an accident To minimize the risk of severe injury in the event of a crash every passenger must always wear their seat belt see the chapter on Seat Belts in this manual The airbags inflate very quickly with great force Do not position any part of your body too close to a airbag you or especially children could be seriously injured killed by a deploying airbag 6 2 Introduction The airbags are designed to provide further protection
121. l Nut Loosening Wheel Tightness Windows and Wiper Blades Windshield Washer Fluid Top up 14 12 Windshield Wipers 8 16 Winter Care 14 20 Wipe Wash 8 18 Wiper Control Stal Wiper Off
122. left and right side child safety rear door locks When the lock mechanism is engaged the rear door s cannot be opened from the inside The door s can only be opened from the outside Move the tab up down in the slot provided in the side face of rear door to disable enable the child safety rear door lock NOTICE lf the rear doors are not operable from inside ensure that the A Lock B Unlock child safety locks have been disabled NOTICE 7 2 1 Child Safety Rear Door Lock Mahindra strongly recommends that the child safety rear door locks be used whenever there are children traveling in the rear seat U42G07 ft 74 Copyright Mahindra amp Mahindra Ltd 082015 D 7 3 Remote Keyless Entry RKE System U42608 J A Lock B Search Panic Alarm C Unlock D LED Key Tag Copyright Mahindra amp Mahindra Ltd 082015 LOCKS AND KEYS 7 3 1 To Lock and Arm the Vehicle with RKE a U42G09 J Press the LOCK button on the RKE for locking and arming the vehicle Hazard lamps flash once if all the doors in the vehicle are locked and armed successfully using RKE Hazard lamps flash five times along with an alarm if any of the doors including bonnet in the vehicle are open 7 5 LOCKS AND KEYS 7 3 2 Unlock and Disarm the Vehicle with RKE a U42611 Zo Press the UNLOCK button on the RKE to unlock and disarm the vehicle
123. legs comfortably extended and your feet on the floor e All vehicle occupants must be properly restrained using the seat belts Copyright Mahindra amp Mahindra Ltd 082015 SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped All infants and children must be placed in the rear seat of the vehicle in a child restraint seat and be properly restrained by seat belts Front airbags can injure occupants improperly positioned in the front seats Even with airbags improperly belted and _ un belted occupants can be severely injured when the airbag inflates Always follow the precautions about seat belts airbags and occupant safety contained in this manual Do not modify the front seats Modification of the front seats could interfere with the operation of the supplemental restraint system or side impact airbags Do not place items under the front seats Placing items under the front seats could interfere with the operation of the supplemental restraint system sensing components and wiring harnesses SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped 6 2 4 Child Restraint and Airbag a pReag N L W12F06 4 Never place a rear facing child restraint in the front passenger s seat If the airbag deploys injuries to the child may be fatal In addition do not place front facing child restraints in the front passenger s seat either If the front passenger airbag inflates it could cause serious or fatal injurie
124. ling put the gear shift lever in the neutral position Ensure the fuel cap and lid are securely closed before starting Resting your foot on the clutch pedal while driving will reduce fuel the vehicle economy e Combine errands and minimize stop and go driving 11 10 Tips for Better Fuel Economy e Keep tires properly inflated It is recommended to check your tire pressure in the morning when the tyre is cold Give due consideration to the points listed below for better performance of vehicle and enhancement of fuel economy e Use recommended engine oil Refer to the Maintenance Section for specifications and capacities e Smooth moderate operation can yield savings in fuel i a e Replace the fuel filter and air filter at the recommended intervals e Steady speeds without stopping will usually give the best fuel economy e Shift gears at the recommended speeds and rpm bands only Refer to the gear shifting speed table for further details e Idling for long periods of time may waste fuel e Control the maximum speed between 90 to 100 kmph in 5th e Anticipate stopping slowing down may eliminate the need to gear to achieve the best fuel efficiency sto j Follow the recommended maintenance schedule and perform e Sudden or hard accelerations reduce fuel economy the owner maintenance checks recommended Slow down gradually e Heavily loading a vehicle or towing a trailer will reduce fuel e Drive at moderate speeds economy e Rewing the eng
125. lity to drive safely e Exercise your eyes by shifting the focus of your eyes to different parts of the road e Use stimulating beverages such as coffee or tea e Relax and stay calm Protecting Our Environment Every one of us should play our part in protecting our environment Judicious vehicle usage and disposing hazardous waste including cleaning and lubrication fluids are important steps towards this initiative Mahindra vehicles confirm to existing emission norms standards Adhering to the periodical maintenance schedule and using Mahindra genuine parts will help retain emission performance of the vehicle and is a pre requisite to emissions warranty coverage Copyright Mahindra amp Mahindra Ltd 082015 INTRODUCTION AND SAFETY PRECAUTIONS Servicing If you have any questions concerning the proper use or maintenance of your vehicle please call your Authorized Mahindra Dealer A list of dealers can be found in the Dealer Directory Supplement or on the Internet Alternatively you can contact Mahindra on 1800 209 6006 customercare mahindra com Running in Driving smoothly during first 1000 kms will help to prevent premature failures and abnormal system wear improving the life of drivetrain and vehicle components A new engine may consume more oil during the first 1000 kms of running This should be considered as a normal part of break in and not interpreted as any problem with the engine Mahindra
126. locks the hood in its fully closed position Copyright Mahindra amp Mahindra Ltd 082015 14 5 MAINTENANCE 14 3 Identifying Components in the Engine Compartment Windshield Washer Fluid Reservoir Power Steering Fluid Reservoir Brake Clutch Fluid Reservoir Dipstick Engine Oil Level Checking Engine Oil Engine Oil Filling Battery So fy tes aS a6 oa tw Degassing Tank Coolant Filling Engine Compartment Fuse Box 14 6 Copyright Mahindra amp Mahindra Ltd 082015 CD MAINTENANCE Maintenance is classified as below e Brake Clutch fluid level e General Maintenance e Engine oil level e Scheduled Maintenance e Power steering fluid level e Fluid leaks 14 4 General Maintenance sate Ss e Hoses joints and pipes for any abnormalities AX WARNING Inside the Vehicle Exercise extreme caution when the hood is open and engine is e Lights ON e Warning lamps Listed below are the general maintenance items that should be e Windshield wipe and wash performed frequently In addition to checking the items listed below if you notice any unusual noise fluid leakages smell or vibration you should investigate the cause or take your vehicle to your Authorized e Seats Mahindra Dealer or a qualified service shop immediately e Steering wheel e Seat belts A CAUTION Accelerator pedal Make these checks only with adequate ventilation if you intend e Brake pedal to run the engine amp Brakes In t
127. ls or in conjunction with a repair 14 1 1 3 Chemicals and Additives Non Mahindra approved chemicals or additives are not required for factory recommended maintenance In fact Mahindra recommends against the use of such additive products unless specifically recommended by Mahindra for a particular application Your vehicle is very sophisticated and built with multiple complex performance systems Every manufacturer develops these systems using different specifications and performance features That s why i s important to rely on your Authorized Mahindra Dealer to properly diagnose and repair your vehicle When planning your maintenance services consider your Authorized Mahindra Dealer for all your vehicle s needs 14 1 1 4 Get the most from your service and maintenance visits Getting your vehicle serviced at an Authorized Mahindra Dealer adds great value to your vehicle in number of ways Hence it is recommended to service your vehicle at an Authorized Mahindra Dealer only 14 1 5 Vehicle Self Maintenance General Precautions e Refer to relevant sections of the manual before starting e Set the parking brake 14 3 MAINTENANCE e Block the wheels to prevent the vehicle from moving unexpectedly e Turn OFF the engine and remove the key e Stay clear of hot vehicle parts e Avoid repeated contact with fluids e Do not let fuel coolant and other fluids spill over electrical and hot vehicle parts e Keep
128. lt will reduce the protection in an accident Seat belts should be adjusted as tightly as possible consistent with comfort to properly secure the wearer in the seat Copyright Mahindra amp Mahindra Ltd 082015 The seat belts provided for your vehicle are designed for people of adult size must be properly used and maintained For usage of adult seatbelt to secure children refer to section on manual for child seat positions and use a child restraint systems 7 Passengers should not move out of or change seats while the vehicle is moving A passenger who is not wearing a seat belt can be thrown against the inside of the vehicle against other Copyright Mahindra amp Mahindra Ltd 082015 SEATS AND SEAT BELTS occupants or out of the vehicle during a crash or emergency stop Do not use any accessories on seat belts or modify in any way the seat belt system Devices claiming to improve occupant comfort or reposition the seat belt can reduce the protection provided by the seat belt and increase the chance of serious injury in a crash An accident or emergency stop can damage your seat belt system even if the accident is minor Please have your Authorized Mahindra Dealer inspect the seat belt system after an accident Please be aware that any unsecured item in your vehicle such as your pet unsecured child restraint system or a laptop can become a projectile in the event of an accident or
129. ly when ignition is turned ON is called pre check This is self check done by the cluster at every ignition ON Symbol Warning Lamp Tell Tale Lamp Pre check Lamp Status Action Remarks Either one of below conditions 1 Park brake might be engaged Parking Brake ONABra ke Fluid 2 Brake fluid level might be low Low Warning Lamp EBD No Continuously ON Malfunction 3 EBD Malfunction detected Contact Authorized Mahindra Dealer immediately for assistance if the lamp is not turning OFF even after checking the above conditions Indicates left turn lamp is blinking Left Turn Indicators No Slow or Fast Blinking Slow Blinking Normal operation Fast Blinking One more left turn lamp bulb has fused Have the bulb replaced Water in Fuel Filter Warning Yes Continuously ON _ Indicates water in fuel filter Drain the water from filter or Lamp contact an Authorized Mahindra Dealer for assistance Security Lamp No Slow or Fast Blinking Slow Blinking Vehicle armed and Immobilizer system active Copyright Mahindra amp Mahindra Ltd 082015 4 3 INSTRUMENT CLUSTER OVERVIEW Symbol Warning Lamp Tell Tale Lamp Pre check Lamp Status Action Remarks Fast Blinking Once the ignition is turned OFF security lamp will blink at fast rate frequency indicating vehicle is secured against unauthorized start of engine Check Engine Lamp For about 3 sec Continuously ON or Blinking There is
130. m permissible limit The fuel filter needs to be drained Contact an Authorised Mahindra Dealer A WARNING Do not continue driving the vehicle with the water in fuel warning lamp ON This may result in fuel pump other fuel system component damage which will not be covered by the limited warranty 8 17 12 Low Fuel Warning Lamp When the fuel level in the fuel tank falls below the ah reserve limit the low fuel warning lamp is ON Refuel sufficiently and the lamp goes out If the lamp continues to be ON even after refueling contact an Authorized Mahindra Dealer CD 8 17 13 Seat Belt Warning Lamp The seat belt warning lamp illuminates reminding the driver to fasten the seat belt when the ignition is ON A The lamp will continue to illuminate till the driver fastens the seat belt properly 8 17 14 Airbag Warning Lamp The airbag warning lamp in the instrument cluster 27 illuminates when the ignition is switched ON and goes OFF in about 4 5 seconds If the lamp remains ON continuously or flashes intermittently contact an Authorized Mahindra Dealer immediately Following conditions indicate airbag malfunction e Lamp fails to go OFF e Lamp does not illuminate at all e lluminates while driving Contact an Authorized Mahindra Dealer immediately when the airbag warning lamp indicates a system malfunction The airbag may not deploy when needed which could result in serious or fatal injury or it might deploy unexpectedly and un
131. n Secure the seat by fastening the hook amp strap provided on the bottom of the cushion to the loop provided behind the Seat Back 5 5 General Warnings and Instructions Seat Belts At least once each month inspect the seat belt webbing for any cuts tears or other signs of wear such as fraying along the edges Also inspect the anchors retractors and buckles to be sure they are tight and operational All occupants including the driver should always wear their seat belt no matter how short the trip in order to minimize the risk of severe injury in the event of a crash In an accident an un belted passenger becomes a projectile and can cause serious injury to himself or another passenger In a rollover crash an un belted person is significantly more likely prone to Injury than a person wearing a seat belt In order to be properly buckled you must always sit up straight and keep your feet on the floor in front of you The lap part must be worn low and tight across your hips just touching the top of your thighs While fastening the seat belt the shoulder strap of the seat belt must pass over your chest and top of your shoulder It must never touch your neck face the side of your shoulder arm or pass under your arm The belt must always be flat against your body and not twisted in any way Nothing such as an arm rest a pocketbook or any external objects should be between you and the seat belt Improper wearing of a seat be
132. n windy or snowy conditions Clean the sensors and ensure they are free of ice dust water etc for proper working of the system System will not work properly if the sensor orientation is changed The distance of the obstacle displayed is from the rear bumper System will not sense pot holes or trenches or drains which are below ground level Any sort of paint or any adhesive on the sensor faces will not guarantee the proper functioning of the system Applying pressure on the sensor face may deteriorate system performance so care should be taken while replacing sensors In the event the sensors are found damaged don t attempt to replace them by yourself bring them to the notice of your dealer Bumper covered with guards and other accessories may not allow sensors to function properly Not all obstacles are detected from 120 cm for instance a person is detected from 75 cm because of weak reflection or absorption of the waves of clothes The distance indication may move up and down due to different sizes of obstacles at different positions Though the obstacle is in the sensing zone the obstacle may not be detected in certain cases if the ultrasonic waves are not reflected back to the sensor While braking decelerating energy is transferred from wheels to batteryFor auto stop to happen the following major conditions are to be met A NOTICE RPAS is an aiding system Under no circumstances will Mahindra accept any responsib
133. n or blowout with unexpected loss of vehicle control and increased risk of injury Under inflation increases sidewall flexing and rolling resistance resulting in heat buildup and internal damage to the tire It also may result in unnecessary tire stress irregular wear loss of vehicle control and accidents Always inflate your tires to the recommended pressure even if it is less than the maximum inflation pressure information found on the tire The recommended tire inflation pressure is found on the Tire Label which is located on the front passenger side inner B pillar Failure to follow the tire pressure recommendations can cause uneven tread wear patterns and adversely affect the way your vehicle handles NOTICE If you overfill the tire release air by pushing the metal stem in the center of the valve Then recheck the pressure AD WARNING After inspecting or adjusting the tire pressure always reinstall the valve stem cap if equipped This will prevent moisture and dirt from entering the valve stem which could damage the stem resulting in an unexpected loss of tire pressure an accident and or personal injury 12 4 3 Radial Ply Tires WARNING Combining radial ply tires with other types of tires on your vehicle will cause your vehicle to handle poorly resulting in an accident and or personal injury Always use radial tires in sets of four Never combine them with other types of tires Cuts and punctures in
134. n them if required and torque to the values A specified in the Repair Manual AS WARNING Abrasive material in any part of the brakes may cause excessive wear or unpredictable braking You might not have full braking power when needed leading to accidents If you have been operating the vehicle in off road conditions get the brakes checked and cleaned as necessary lt Ooo O A e f any unusual vibration is experienced check the wheels for Use commercially available vehicular Ultra low Sulfur Highway imbalance Get it inspected corrected as soon as possible Diesel that meets the BIS standard IS 1460 2010 BS IV BS Il specification or equivalent Information on diesel quality can e After driving through deep water inspect your vehicle fluids and normally be found in the fuel pump Please contact any filling station lubricants engine oil transmission transfer case axle oils to personnel in case labels in the pump cannot be found ensure the fluids have not been contaminated A CAUTION Do not fill the fuel tank or mix the fuel with gasoline alcohol based fuels kerosene etc This will damage the engine fuel and exhaust system components NOTICE If you have accidentally filled the fuel tank with an incorrect or non approved fuel do not start the vehicle Contact an 11 18 Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE Authorized Mahindra Dealer to have t
135. nce and safety considerations always keep the following information in mind When adding accessories equipment passengers and luggage to your vehicle do not exceed the total weight capacity of the vehicle or of the front and rear axle Consult Mahindra authorized dealer for specific weight information Bull bars and nudge guards are not recommended for variants with an airbag Accessories causing any change in vehicle specifications like wheel rims bull bars etc may affect the performance of safety systems Mobile communication systems such as two way radios telephones and theft alarms that are equipped with radio transmitters and installed in your vehicle should comply with the local regulations and should be installed only by a your Authorized Mahindra Dealer Vehicle Safety When leaving your vehicle unoccupied Always remove the ignition key when you park the vehicle Close all the windows completely and lock all the doors Copyright Mahindra amp Mahindra Ltd 082015 CD INTRODUCTION AND SAFETY PRECAUTIONS e Do not leave any valuables in your vehicle If you must leave something in your vehicle hide them and securely lock all the doors 1 5 Audio Infotainment Manual Please refer the Audio Infotainment user manual available in the vehicle for details regarding e Audio Infotainment functions e Bluetooth functions e Hands free call Copyright Mahindra amp Mahindra Ltd 082015 led GENER
136. nce the engine starts release the key it will return to the IGN position A CAUTION Do not continue cranking after the engine has started This will lead to damage of the starter and other engine components 11 4 7 If the engine fails to start attempt to restart after about 10 seconds by toggling the ignition 8 If the engine fails to start even after repeated attempts as per the procedure given above contact the nearest Authorized Mahindra Dealer AX WARNING lf the vehicle battery has discharged use booster cables a booster battery or a battery from another vehicle to start Jump starting a vehicle can be dangerous if done improperly Refer to the Jump starting procedure section in this manual If the engine still fails to start contact an Authorized Mahindra Dealer for assistance The idle speed is controlled automatically and it will decrease as the engine warms up Observe the following when the engine is running e All warning lamps are OFF e Low oil pressure lamp is OFF After idling for a few seconds release the parking brake depress the clutch shift the gear shift lever to 1st gear release the service brake pedal drive by releasing the clutch and pressing the accelerator pedal simultaneously Copyright Mahindra amp Mahindra Ltd 082015 11 4 1 Engine Idling In Cold Weather Avoid full throttle operation when the engine is cold and prolonged idling at low ambient temperatures Long period
137. ndard IS 1460 2010 BS IV SECC INSEE TEL BS Ill specification or 60 liters a equivalent 2 5 Copyright Mahindra amp Mahindra Ltd 082015 GENERAL 2 3 Dimensions 2 3 1 Front View 2 3 2 Rear View O u42B02 2 6 2 3 3 Side View Wheel Base 2680 mm Overall Length 3995 mm Overall Width 2079 mm including outside mirrors Overall Height 1839 with ski rack Track Width Front 1520 mm Track Width Rear 1500 mm The specifications are for reference only Subject to change without prior notice Copyright Mahindra amp Mahindra Ltd 082015 GID GENERAL 2 4 Bulb Specification 2 5 Fuses and Relays Lamp Bulb Wattage A fuse is the most common electric protection device The fuse is Head Lamp H4 12V 55 60W placed in an electrical circuit so that when current flow exceeds Park lamp W5W 12V 5W the rating of the circuit fuse it blows off The element in the fuse melts opening the circuit and preventing other components of the urn emp PRIVY ee circuit from being damaged by the over current The size of the Static Bending lamp H1 12V SSW metal fuse element determines the rating Once a fuse blows off it Front Fog lamp H8 12V 35W must be replaced with a new one Side Turn Signal lamp W5W 12V 5W EN Tal ap nie P21 5W 12V 21 5W A aeay ai equipment OFF before touching Rear Turn lamp PY21W 12V 21W Reverse lamp
138. necessarily which may result in personal injury 8 17 15 Anti lock Brake System ABS Malfunction Lamp The ABS malfunction lamp illuminates when the ignition is switched ON and goes OFF after about seconds If the ABS malfunction lamp continues to remain ON or illuminates while driving the ABS will not operate But the brake system will still operate conventionally In this condition the wheels can lock during severe braking Have the vehicle checked by an Authorized Mahindra Dealer as soon as possible A WARNING When a EBD failure is detected both the ABS and the parking brake warning lamps illuminate 8 17 16 Front Fog Lamp 8 17 17 Door Ajar Warning Lamp The front fog lamp telltale indicates the status of the front fog lamp The front fog lamp can be switched ON only when the parking lamp is ON The door ajar warning lamp illuminates when any door is open when the ignition is ON The lamp goes OFF when all the doors are closed properly 8 33 8 17 18 Start Stop Lamp Micro Hybrid The Start Stop lamp blinks when the engine is about to be stopped by Start Stop System And the lamp QO turns ON continuously when the engine has been switched OFF by the System On restarting engine by pressing the clutch key the lamp turns off The Start Stop lamp blinks at faster rate for a longer time than usual when the battery state does not allow the system to stop the engine automatically 8 17 19 AMT warning Lamp
139. nes the services required to properly maintain your vehicle and when they should be performed The focus is on maintaining your vehicle while it s running great which goes a long way toward preventing major repairs and expenses later Here are a few suggestions to help you get started on routine maintenance e Familiarize yourself with your vehicle by going through your Owner s Manual e Take a few minutes to review this Maintenance Section e Make it a habit to use this manual to record scheduled maintenance in the Service Coupon Booklet e Consult with your Authorized Mahindra Dealer for all your vehicle s needs 14 1 1 Suggestions for Obtaining Service for your Vehicle Prepare for the Appointment If you have warranty work to be done be sure to have the right papers with you All work to be performed may not be covered by 14 1 the warranty Discuss additional charges with the service manager Keep a maintenance log of your vehicle s service history Prepare a List Make a written list of your vehicle s problems or the specific work you want done If you ve had an accident or work done that is not on your maintenance log let the service advisor know about it Be Reasonable with Requests If you list a number of items and you must have your vehicle by the end of the day discuss the situation with the service advisor and list the items in order of priority 14 1 2 Need Assistance lt is recommended talking to an Autho
140. njury Copyright Mahindra amp Mahindra Ltd 082015 12 4 Tire Pressure Proper tire inflation pressure is essential to the safe and satisfactory operation of your vehicle Three primary areas are affected by improper tire pressure e Safety e Economy e Ride Comfort and Vehicle Stability Proper tire inflation contributes to a comfortable and safe ride Overinflating produces a jarring and uncomfortable ride Both underinflation and overinflation affect the stability of the vehicle and can produce a feeling of sluggish response or over responsiveness in the steering Unequal tire pressures can cause erratic and unpredictable steering response or may cause the vehicle to drift left or right Improper inflation pressures can cause uneven wear patterns to develop across the tire tread These abnormal wear patterns will reduce tread life resulting in a need for earlier tire replacement Under inflation also increases tire rolling resistance and results in higher fuel consumption NOTICE The proper cold tire inflation pressure is listed in the Tire Label Vehicle Placard located on the front passenger side inner B pillar 12 3 12 4 1 Inspection and Adjustment Procedure The tire pressure should be checked and adjusted as well as inspected for signs of tire wear or visible damage at least once a month Use a good quality pressure gauge to check tire pressure Do not make a visual judgement when determining proper inflat
141. nsive damage to your vehicle s suspension and chassis Maintain steering wheel control at all times especially on rough terrains Sudden changes in terrain can result in abrupt steering wheel motion Make sure you grip the steering wheel from the outside Do not grip the spokes If the vehicle goes from one type of surface to another e g from concrete to gravel sand mud snow there will be a change in the way the vehicle responds especially the way it responds to steering braking and accelerating inputs Be extremely careful when driving on pavements made slippery by loose sand water gravel snow or ice If your vehicle goes off the edge of the pavement slow down but avoid severe brake or steering application Ease the vehicle back onto the pavement only after reducing your speed Do not turn the steering wheel too sharply while returning to the road surface It may be safer to stay on the apron or shoulder of the road and slow down gradually before returning to the pavement You may 1115 lose control if you do not slow down or if you turn the steering wheel too sharply or abruptly In an unavoidable emergency situation where a sudden sharp turn must be made turn the steering wheel only as rapidly and as far as required to avoid the emergency Excessive steering will result in less vehicle control Additionally smooth variations of the accelerator and or brake pedal pressure should be utilized if changes in vehicle speed a
142. nterval Maintenance Schedule Chart Maintenance Inside the Vehicle Maintenance Outside the Vehicle Malfunction OBD Lamp Manual Joystick ORVM Adjustment Manual Transmission Micro Hybrid Technology If equipped Mike If equipped Mute Un mute Function N O 5e elagi r enka Muse POE EAIA ER EITANT AON Off Road Driving Precautions Oils Fluids and Flushing Opening the Hood a Outside Rear View Mirror QRVM 0 00 cece eect eee eens 8 3 P Paint Chips Parking Brake Parking Brake Low Brake Fluid EBD Warning Lamp Parking Lamps On Parking on a Hill Inclin Plastic Non painted Exterior Parts Power ECO Switch Power Outlet Power Window Lock Switc Power Windows Precautions while Handling RKE Protect your Warranty R Radial Ply Tires Radio Frequency ID RFID Tag Rapid Cabin Cooling Rapid Cabin Heating Rear Overview Rear Windshield Defog Rear Wiper Recommended Gear Shifting Speeds Remote Keyless Entry RKE System Restore the Tools Jack and Flat Tyre Securely Reverse Parking Assist System RPAS If equipped RKE Battery Replacement RKE Operating Range ROOF AMPS dcsantsntacdss ETA T ST E seid slanar ravens S Safety Symbols Safety Tips Before Starting your Vehicle Scheduled Maintenance Search Panic Function Seat Belt Warning Lamp Second Row Bench Seat Security Lamp Sel
143. nts under the Central Motor Vehicles Rules CMVR 1989 12 7 13 EMERGENCIES 13 1 Hazard Warning Lamp The hazard warning lamp switch is located above the AC controls on the instrument panel Use the hazard warning lamp when your vehicle is stationary or to warn other road users to be cautious while passing your vehicle To turn the hazard warning lamp ON press the switch in All the turn signal lamps flash To turn OFF press the switch again NOTICE The turn lamps do not work when the hazard warning lamps are operational Hazard lamps are also switched ON during the following conditions Copyright Mahindra amp Mahindra Ltd 082015 Crash Hazard would be turned on for 30 mins e Panic Braking When the vehicle is running above 100 kmph and panic sudden brakes are applied hazard will turn on for 5 sec e Vehicle break down warning bonnet open The vehicle break down warning would be enabled only when bonnet switch changes from close to open condition at vehicle unlocked condition Pressing the hazard switch twice deactivates this feature 13 2 Vehicle Does not Start Checks Before making these checks make sure you have followed the correct starting procedure and that you have sufficient fuel If the engine is not cranking or is cranking too slowly intermittently 1 Check that the battery terminals are tight and clean 2 If the battery terminals are firmly fastened turn the interior lam
144. of the upper portion of the instrument panel The dull finish in this area helps protect the driver from undesirable windshield reflection CD e Do not use household or glass cleaners as these may damage the finish of the instrument panel interior trim and cluster lens If a staining liquid like coffee juice has been spilled on the instrument panel or on the interior trim surfaces clean as follows e Wipe up spilled liquid using a clean white cotton cloth e Apply Vinyl Cleaner to the wiped area and spread around evenly e Apply cleaner to a clean white cotton cloth and press the cloth onto the soiled area and allow this to set in at room temperature for 30 minutes e Remove the soaked cloth and if it is not soiled badly use this cloth to clean the area with a rubbing motion for 60 seconds e Following this wipe area dry with a clean white cotton cloth 14 9 9 Interior Maintenance For fabric carpets cloth seats safety belts and seats e Remove dust and loose dirt with a vacuum cleaner e Remove light stains and soil with carpet and upholstery cleaner e f grease or tar is present on the material spot clean the area first with a stain remover Do not use household cleaning products or glass cleaners which can stain and discolor the fabric and affect the flame retardant abilities of the seat materials e Do not use cleaning solvents bleach or dye on the vehicle s safety belts as these actions may weaken the belt webbing
145. ol down before adding coolant to the reservoir Do not continue driving the vehicle with a overheated engine This will lead to damage of engine components and engine seizure 8 15 7 Fuel Level Gauge The fuel level bar graph functions only when the ignition is switched ON It gives the status of the fuel level in the fuel tank F indicates the tank is full 60 liters E indicates the tank in empty The amount of fuel required to fill the tank up may be less than the specified tank Capacity as a small amount of reserve fuel always remains in the tank 8 27 When the tank is nearly full 8 bars illuminate on the LCD bar graph display When the tank is near empty i e RESERVE the bottom bar alone is illuminated and the low fuel warning lamp in the cluster is ON 8 28 CD On inclines or curves due to the movement of fuel in the tank the fuel level may fluctuate or the low fuel level warning lamp may illuminate earlier than usual and also alert message will come for Low fuel level if equipped with audio system Always check the fuel level when the vehicle is on level road If the low fuel warning lamp continues to be ON even after filling sufficient fuel contact your Authorized Mahindra Dealer as soon as possible AX WARNING Refuel your vehicle as soon as the last bar illuminates in the fuel bar graph Refuel your vehicle only after switching OFF the ignition CD 8 16 Warning Lamps Overview ATUT PUR ay AN 100 15
146. ormation and Instructions General Warnings and Instructions Get the most from your service and maintenance visits Glove Box Glow Plug Indicator H lazard on Panic EERO n Airain retien hark n 8 9 lazard Warning Lamp ead Lamp Bulb Replacement 14 22 ead Lamp Flash ead Lamp High Beam Lamp ead Lamp High Beam Low Beam ead Lamp Leveling System ead Lamp On ead Restraint igh Engine Coolant Temperature Warning Lamp igh Speed Wiping ow to Calculate Fuel Efficiency Mileage VAC Air Filter Cabin Air Filter VAC Controls VAC Overview ode Ae ak le ec ee eke thee ded cs Ae adele ake Identifying Components in the Engine Compartment f RKE is Lost Ignition Switch In the Engine Compartment Inflating Your Tires Instrument Cluster Gauge Instrument Panel Fuse Box Instrument Panel Overview Instrument Panel Interior Trim and Cluster Lens Interior Lamps Interior Maintenance Interior Mirror Intermittent INT Mode Introduction J PACK POINES AENIL TETEP POEPIE TEYE EIT E TEES FAAEE 2 15 Jacking we 2 16 Jump Starting we 13 3 Keep Enough Fuel in the Tank 14 20 Lead Me to Vehicle LMV RKE Leather Seat Life of Tire Limp Home Mode Locks and Keys Low Engine Oil Pressure Warning Lamp Low Fuel Warning Lamp Low Speed Wiping Lubricants and Capacities Maintenance I
147. ortant to drive with all due care and maintain a moderate speed and safe distance from the vehicle in front of you There are limits to the vehicle stability and effectiveness of steering wheel operation even with ABS active If tyre grip performance exceeds its capability or if hydroplaning occurs during high speed driving in the rain the Anti lock Brake System will not assist with vehicle control Copyright Mahindra amp Mahindra Ltd 082015 97 10 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC The climate control system enables you to set the cabin at the desired comfortable condition by controlling airflow air intake and temperature control The HVAC system also helps in defrosting and defogging de misting the windshield and windows Engine coolant is utilized to heat the cabin air For cooling cabin air an air conditioning circuit based on the vapor compression refrigeration cycle is used The air conditioning system uses a refrigerant along with a suitable lubricating oil Although being non ozone depleting the refrigerant is a greenhouse gas hence once allowed to escape in the atmosphere it adversely affects the environment by contributing to global warming climate change Multiple vents are provided for distributing the air being force circulated by the HVAC blower throughout the passenger compartment Various ducts supply air from the HVAC unit to these vents having adjustable louvers Copyright Mahin
148. ow rate frequency which will indicate that antitheft system is armed and unauthorized door entry to the vehicle will trigger alarm At ignition ON the security lamp blinking continuously indicates a malfunction in the engine immobilizer system Contact an Authorized Mahindra Dealer immediately 8 17 5 Parking Brake Low Brake Fluid EBD Warning Lamp if equipped engaged or when the brake fluid level in the reservoir is low or when EBD if equipped failure is detected If the lamp illuminates while driving do the following The lamp illuminates when the parking brake is CD e Check if the parking brake is engaged If yes disengage it e Check if the brake fluid level is low If yes top up brake fluid DOT 4 to the required level If the brake lamp still continues to illuminate immediately get the vehicle checked at an Authorized Mahindra Dealer Ax WARNING Clean the top of the brake fluid reservoir before removing the cap Make sure no dirt impurities or other items fall into the reservoir Do not leave the cap off for more than a few minutes Any contaminants impurities or moisture in the brake fluid can affect brake operation resulting in an accident If the brake warning lamp comes ON while driving the brake system or the EBD system if equipped might not be working properly The pedal might be harder to operate or might go closer to the floor and it can take longer to stop Pull off the road carefully and stop
149. p will go OFF once the engine is cranked as in the normal case If there is any problem in the system a DTC will be set which can be accessed by our Service Engineer During vehicle acceleration alternator generation is disabled What about the vehicle electrical loads During that momentary duration all electrical loads will be supported by the battery 8 41 8 22 Micro Hybrid Technology Engine Stop Start System ESS If equipped 8 22 1 Overview of the System Stop at Traffic Signal Jam Engine stops after few seconds Cluster Indication ON Switch to Release the Neutral Clutch Pedal Ala Clearance of Press the Engine Cluster Signal Jam Clutch Pedal Restarts Indication OFF 7 8 42 CD FEATURES AND CONTROL 8 22 2 How Does the ESS Work Let s take a simple example of driving in traffic conditions within your city Assume that your vehicle has stopped at a traffic junction due to a red signal The following steps illustrate how the system functions The vehicle has come to a halt at a traffic signal is in the neutral gear and the clutch pedal is released The ESS lamp in the cluster will blink indicating that the engine is going to stop shortly The engine will shut down automatically after a specific time period The ESS lamp will illuminate in the instrument cluster indicating the engine was stopped by the ESS system e Once the signal turns green press th
150. pired unlocked condition Copyright Mahindra amp Mahindra Ltd 082015 8 11 FEATURES AND CONTROL To disable FMH e Park lamp transition from OFF to ON e Ignition off to any other states e FMH ON 20 seconds expires e Maxtime of 3 mins has elapsed and no extension of FMH With FMH mode ON if the UNLOCK signal is received twice from RKE the feature gets deactivated and cannot be extended further Also the doors are unlocked and vehicle disarmed 8 7 Follow Me Home FMH Non RKE This feature helps the driver and passengers to easily get out of the vehicle during poor light conditions The head lamp low beam is turned ON for about 20 seconds assisting the passengers to find their way To enable FMH e Ignition transition from ON to OFF e Park lamp ON to OFF e Ignition key is out e Open Driver door Head lamp low beam will turn ON for 20 seconds To disable FMH 8 12 e FMH ON 20 seconds expires e Park lamp transition from OFF to ON 8 8 Lead Me to Vehicle LMV RKE LMV is the feature that switches the head lamp ON in low beam for 20 sec helping the passengers to reach the parked vehicle safely and comfortably at night To enable LMV e Ignition key is out e Park lamps OFF e Press UNLOCK button twice on the RKE e System will unlock all doors and disarm the vehicle followed by head lamp turning ON for 20 sec A NOTICE If FMH has already expired LMV would turn ON in the 2nd Press RKE Unlock
151. portional to the distance Smaller the distance shorter the interval between the beeps Four RPAS sensors are located at the rear bumper to provide complete rear view to the driver for hassle free parking A NOTICE Magnetic devices present in the detection range could vastly affect the sensor performance and the distance displayed may not be accurate 8 20 1 Working Principle e Qn engaging the gear in reverse the RPAS system gets activated automatically and the vehicle image appears in the infotainment screen Display bars below the car image indicate the obstacles behind the vehicle e When the obstacle comes in the sensing zone the system starts giving the indication based on the distance and direction of the obstacle as defined in the detecting zones The closer the obstacle more display bars are illuminated RPAS Information on Infotainment Screen U42H74 RPAS display on the infotainment screen gives the following information e Left zone indicates obstacle on the left hand side e Center zone indicates obstacle in the center e Right zone indicates obstacle on the right hand side Display bars 1 2 3 and 4 indicate how close the obstacle distance is from the vehicle rear bumper with bar 1 being very close and bar 4 being distant The infotainment screen display s a STOP symbol if the obstacle is less than 50 cm from the vehicle rear bumper 8 35 C uaeH55 3 Start moving the v
152. ps ON 3 If the lamps do not illuminate glow dim or go OFF when the starter is cranked the battery is weak or discharged Try jump starting Follow Jump starting instructions given later in this chapter 4 Check the fuses in the Engine Compartment Fuse Box and Central Fuse Box 13 1 If the engine cranks normally but does not start 1 If the lamp illumination is normal engine is cranking normally but the engine does not start even after repeated cranking it needs adjustment or repair Contact an Authorized Mahindra Dealer 2 During winter use of non winter diesel or due to extreme cold conditions the vehicle may not start Contact an Authorized Mahindra Dealer for further assistance If the engine stalls while driving Reduce your speed gradually keeping a straight line Move cautiously off the road to a safe place Turn ON your hazard warning flashers and check for any malfunction lamps in the instrument cluster Turn the ignition OFF wait for approximately 90 sec and try starting the engine again If the vehicle still does not start contact an Authorized Mahindra Dealer A WARNING If the engine stalls while running the power assist for the brakes and steering will not work Steering and braking will be much harder than usual If the engine speed does not increase If the engine speed does not increase when the accelerator pedal is depressed there may be a problem in the Engine Management System electrical o
153. r The jack and tool bag is placed under the third row seat Copyright Mahindra amp Mahindra Ltd 082015 GENERAL U42B05 Remove the Tool bag velcro placed around the bag Wheel spanner jack handle Tow hook and Tools are placed in the tool bag and fastened using Velcro Jack is held in place by a wing type bolt Remove the wing bolt and move the jack towards tail gate slightly to remove it from its position Copyright Mahindra amp Mahindra Ltd 082015 2 13 GENERAL 2 6 2 Spare Wheel Removal The spare wheel is mounted on the back door at the rear end of the vehicle It is held in place by a securing nuts underneath the Mahindra badge e Wrap the tip of a screw driver with cloth insert it at the bottom edge of the Mahindra badge on the spare wheel cover if equipped and pry the badge away from the Cover e Loosen and remove the securing nut counter clockwise with a wheel spanner e Hold the spare wheel cover with both hands and pull outwards to remove e Loosen the remaining securing nuts counter clockwise with a wheel spanner e Slowly support and lower the spare wheel 2 14 t CAUTION A anti theft lock system is provided for the spare wheel as shown Any small lock can be used to disable the securing nut from being removed 2 6 3 Wheel Nut Loosening Wrap the tip of a screw driver with cloth insert it near the lugs of the wheel cap if equipped
154. r Authorized Mahindra Dealer This washer fluid contains a special solution in addition to alcohol which helps remove the hot wax deposited on the wiper blade and windshield Be sure to replace wiper blades when they appear worn or do not function properly Do not use abrasives as they may cause scratches 14 18 CD e Do not use fuel kerosene or paint thinner to clean any glass parts If you cannot remove those streaks after cleaning with the glass cleaner or if the wipers chatter and move in a jerky motion clean the outer surface of the windshield and the wiper blades using a sponge or soft cloth with a neutral detergent or mild abrasive cleaning solution After cleaning rinse the windshield and wiper blades with clean water The windshield is clean if beads do not form when you rinse the windshield with water Do not use sharp objects such as a razor blade to remove decals as it may cause damage to the glass or rear windshield heater grid lines if equipped 14 9 8 Instrument Panel Interior Trim and Cluster Lens NOTICE Do not use chemical solvents or strong detergents when cleaning the steering wheel or instrument panel Clean the instrument panel interior trim areas and cluster lens with a clean and damp white cotton cloth then with a clean and dry white cotton cloth you may also use Dash and Vinyl Cleaner on the instrument panel and interior trim areas e Avoid cleaners or polishes that increase the gloss
155. r clamps to 13 5 help ensure a good electrical connection Restart the working vehicle again Allow another 5 minutes for charging before attempting to start the disabled vehicle If this does not work after a few tries you may need to have the vehicle towed or the battery replaced Remove the jumper cables once the vehicle starts Do this in the reverse of the order in which they were attached and don t let any of the cables or clamps touch each other or dangle into the engine compartment e Disconnect the black clamp from the grounded metal on the dead vehicle e Disconnect the black clamp from the negative terminal of the good battery e Disconnect the red clamp from the positive terminal of the good battery e Disconnect the red clamp from the positive terminal of the dead battery Replace any positive red post protective covers if applicable You have had to remove or open these in the beginning These covers help prevent accidental short circuiting of the battery Keep the recently disabled vehicle s engine running Run the vehicle above idle slightly rewed up with your foot on the accelerator This should give the battery enough charge to start the vehicle again If it does not you probably have a dead battery or a dying alternator 13 6 AD AX WARNING Improper jump starting procedures can result in battery explosion and acid burn hazard Loosely connected battery cables could damage the elec
156. r electronic controls In case of certain faults the engine may go to limp home mode which is indicated by the 13 2 CD check engine lamp Have your vehicle checked by an Authorized Mahindra Dealer as soon as possible 13 3 Vehicle Overheating If the needle in the temperature gauge in the instrument cluster is all the way up to the H and or the high engine coolant temperature warning lamp is ON your engine has overheated Upon engine getting overheated the Engine Management System reduces engine power substantially and may even shut the engine OFF it is dangerous to continue driving when the engine has overheated You need to first cool the engine down before starting to drive again Follow the below instructions to cool the engine down e Progressively reduce the vehicle speed and bring the vehicle to a stop at the side of the road e Turn ON the hazard warning flashers e Keep the engine running at idle e Engage the parking brake e Switch off the air conditioner e You can keep the AC blower speed at maximum and set the temperature control knob to the extreme end of the hot zone clockwise end CD e Wait till the engine coolant temperature drops sufficiently such that the needle in the temperature gauge is around halfway between C and H Now switch the engine OFF and carefully open the bonnet hood to visibly inspect the engine cooling system parts Be cautious while doing an inspection as vehicle parts will still be
157. re called for Avoid abrupt steering acceleration or braking which could result in an increased risk of loss of vehicle control vehicle rollover and or personal injury Use all available road surfaces to return the vehicle to a safe direction of travel 11 8 2 Off Road Driving Precautions When driving off road or on rugged terrains never overspeed or make sharp turns This may cause loss of control or vehicle rollover causing serious injury Maintain steering wheel control at all times Sudden changes in terrain can result in abrupt steering wheel motion Do not drive horizontally or diagonally across steep slopes your vehicle can tip over sideways Driving straight up or straight down is preferred Drive cautiously to avoid vehicle damage from concealed objects such as rocks and stumps You should either know the terrain or map out your route before driving in the area 11 16 CD Always perform a maintenance inspection after each day of off road driving that has taken you through rough terrain sand mud or water 11 8 3 Driving Through Water Although your vehicle is capable of driving through shallow water there are a number of precautions that must be considered before entering the water JA CAUTION Never drive through still water that is higher than the bottom of the axle hubs Not following this instruction will allow water to enter vehicle components causing internal damage to the components affecting driveabil
158. reclined the lap belt may slide past your hips and apply restraint forces directly to the abdomen or the shoulder strap may contact your neck lt is recommended to adjust the seat height only when the vehicle is stationary A CAUTION 5 1 5 Foldable Arm Rests if equipped When returning a extremely reclined seat back to its upright position make sure you support the seat back while operating the lever 5 1 4 Driver Seat Height Adjust if equipped Front seats are provided with individual foldable arm rests Lift Push the seat height adjustment lever located on the outboard side of the driver seat to raise lower the seat Adjust the seat Copyright Mahindra amp Mahindra Ltd 082015 SEATS AND SEAT BELTS 5 1 6 Lumbar Support if equipped Both the front seats are provided with lumbar support Turn the lever on the outboard side of the seat back as per requirement to enable disable lumbar support 5 2 Head Restraint Your vehicle seats are equipped with head restraints which are vertically adjustable The purpose of these head restraints is to help limit head motion in the event of a collision 5 4 Always align top of the head restraint with the top of your head or as close to it as possible To raise lower the head restraint press the lock tab and pull push the restraint up down The head restraint can be pulled out completely by depressing the locking button whil
159. reshold e When the air conditioner is ON moisture is extracted from the air The resulting condensate is drained off from the vehicle It is therefore normal if you see a small pool of water under your vehicle e The air conditioner should be operated at least for ten minutes once every fortnight even during winter months The following steps outline the procedure to switch ON the AC This allows the AC system components to get lubricated periodically and ensures optimum system performance Adjust the blower speed as required 2 Select the air distribution mode as desired A NOTICE Bo Deer eie alte Ee Uauon ini mee abr aur Your vehicle is equipped with an HVAC filter If the AC 4 Press the AC button to turn on the AC performance is considerably low it is recommended have the 5 Adjust the temperature control dial as per the temperature HVAC filter checked at the nearest Mahindra Dealer requirement A NOTICE 10 9 HVAC Air Filter Cabin Air Filter Your vehicle s HVAC system is equipped with an air filter at the blower inlet just behind the glove box Before getting sucked in by the blower air passes through this filter element Dirt and other e In certain operating conditions when the engine gets overheated the engine management system may switch off the air conditioner intermittently Copyright Mahindra amp Mahindra Ltd 082015 10 7 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC foreign pa
160. rized Mahindra Dealer service manager first Most matters can be resolved with this process If for some reason you are still not satisfied talk to the general manager or owner of the dealership If an Authorized Mahindra Dealership is unable to resolve the concern you may contact any Mahindra Customer Care executive They would need the following information Owner s name and address owner s telephone number home and office Authorized Dealership name Vehicle Identification Number VIN vehicle delivery date and mileage 14 2 AD 14 1 3 Warranty Information Read the Warranty Information given in the Warranty Information amp Maintenance Guide for the terms and provisions of Mahindra warranties applicable to this vehicle Mahindra genuine parts fluids lubricants and accessories are available at any Authorized Mahindra Dealer They will help keep the vehicle operating at its best 14 1 4 Protect your Warranty Routine maintenance is not only the best way to help keep your vehicle performing as intended it s also the best way to protect your warranty Failure to perform scheduled maintenance specified in the Service Coupon Booklet will invalidate warranty coverage on parts affected by the lack of maintenance We can t stress enough how important it is to keep records of all maintenance Damage or failures due to neglect or lack of proper maintenance are not covered under warranty Keeping maintenance records is easy wit
161. rly or loosely tightened wheel nuts are dangerous The wheel could wobble or come off This could result in loss of vehicle control and cause a serious accident Always make sure all the wheel nuts are properly securely tightened to the specified torque 2 17 GENERAL When lowering the vehicle make sure all portions of your body are Clear off the vehicle as it is lowered to the ground Have the wheel nuts tightened with the torque spanner to 120 Nm as soon as possible after changing wheels AX WARNING If you have rotated repaired changed your tyres or changed the wheel rims check the wheel nuts are still tight after driving about 1 000 kms Torque 120 Nm Put the wheel cap if equipped into position aligning the nozzle on the wheel to the nozzle clearance on the wheel cover Tap it firmly on the sides with your hand to snap it into place Check the air pressure of the replaced tyre If the pressure is lower than recommended drive slowly to the nearest service station and inflate to the correct pressure If it is too high adjust it until it is correct Always reinstall the valve cap after checking or adjusting tyre pressure If the cap is not replaced dirt and moisture could get into the valve core and cause air leakage If you lose a valve cap buy another and install it as soon as possible A CAUTION Wheel balancing to be done after tyre puncture rework 2 18 CD 2 7 2 Restore the Tools Jack and Flat Tyre Securel
162. rning lamps illuminate or buzzers sound park stop the vehicle in a safe location as soon as possible Identify the cause and take any necessary remedial action Contact your Authorized Mahindra Dealer if necessary Never overload or improperly load your vehicle Always be attentive while driving and follow safe driving practices Always maintain the recommended inflation pressure in tires Always drive at a safe speed appropriate for given driving conditions You must follow the speed limits While backing up keep a constant lookout for people particularly children or other obstructions or hazardous material that might be present behind the vehicle Avoid loading any items on the roof that will raise the vehicles center of gravity and make your vehicle more unstable Loaded vehicles with a higher center of gravity may handle differently than unloaded vehicles Extra precautions such as slower speeds and increased stopping distance should be taken when driving a heavily loaded vehicle Always slow down in gusty crosswinds Because of its profile and higher center of gravity your vehicle is more sensitive to side winds than an ordinary passenger car Slowing down will allow you to have much better control When driving off road or on rugged terrain do not drive at excessive speeds jump make sharp turns strike objects etc This may cause loss of control or vehicle rollover causing serious injury You are also risking expe
163. rticles get trapped inside the filter Clean air is then circulated through the HVAC unit and into the cabin The HVAC filter gets clogged after long use The clogged filter will reduce the air flow rate thereby the air conditioning and heating efficiencies will be drastically reduced Even the windshield windows may begin to mist fog up easily To maintain optimum HVAC system performance clean the filter element as per recommended maintenance schedule However while operating in highly dusty or polluting conditions the filter may require early replacement If the air flow seems to have considerably reduced get the filter cleaned immediately To access the filter open the glove box remove the rubber pins on both sides of the glove box lid Un clip the filter retaining clip and remove the filter straight out Clean the air filter or replace if damaged and follow the reverse procedure for putting the filter back A CAUTION Never operate the HVAC system with the filter removed This may result in premature failure of system components 10 10 Rapid Cabin Cooling For rapid cooling of the cabin the following AC settings are recommended 10 8 1 Make sure that all the windows are fully closed Set the blower to maximum speed w Fully open the vents and adjust louvers to direct air toward face Set the air distribution control to face mode Set air intake control to recirculation mode Turn the air conditioner ON N O oO
164. running costs The fuel efficiency improvement depends on various parameters of your driving pattern and vehicle conditions 2 What are the other advantages of this system e Since the engine is switched off during traffic signals jams considerable amount of carbon dioxide release to the atmosphere is avoided This reduces global warming and thus provides us with a sustainable planet to live in e It improves the vehicle performance during acceleration e It improves the battery life by proper battery conditioning e No need to perform any additional actions towards the benefits the system works as you drive your vehicle 3 What are the additional parts of the system The system consists of e Battery Management Sensor BMS e Intelligent Alternator e Headlamp PWM Modules 4 What is the function of Intelligent Alternator 5 6 Z The Intelligent Alternator is the one which responds to the commands of BMS and generates energy accordingly What is the function of Headlamp PWM module The Headlamp PWM module suppresses any voltage spikes and provide the operational voltage to the Headlamps What if any of the part fails If the Battery Management Sensor fail communication gets disturbed there are redundant functionalities integrated into the system towards charging the battery How do know whether the system is working Copyright Mahindra amp Mahindra Ltd 082015 FEATURES AND CONTROL The BCC lam
165. s may lead to reduction in range of RKE e Check the RKE battery See battery replacement procedure given later in this section e Ifthe RKE is still not working correctly contact an Authorized Mahindra Dealer 7 3 10 RKE Battery Replacement If the RKE operation is inconsistent when any of the buttons are pressed it indicates that the RKE battery is weak The rear side of the RKE is screw fitted Using a small screw driver unscrew and separate the two halves of the casing The battery type is button type CR1632 3V cell Copyright Mahindra amp Mahindra Ltd 082015 A CAUTION LOCKS AND KEYS U4e614 a i mene While prying the RKE case take care not to damage the battery 79 LOCKS AND KEYS C D A CAUTION Only RKE transmitters programmed to your vehicle electronics can be used for remote locking and unlocking of your vehicle Do not touch the battery terminals that are on the back housing or the printed circuit board z ER P f 7 3 12 Precautions while Handling RKE Pull out the battery and discard the same Insert new battery of same type While fitting the new battery ensure the positive side of the batteries face up Align both the halves of the RKE and screw to tight fit Check operation of the RKE Do not cover the key grip with any material that cuts off RF waves e Do not leave the key exposed to high temperatures for a long period such as on
166. s of idling may be harmful to your engine Combustion chamber temperatures can drop so low that the fuel may not burn completely Incomplete combustion allows carbon and varnish to form on piston rings and injector nozzles Also the unburned fuel can enter the crankcase diluting the oil and causing rapid wear to the engine 11 5 Stopping the Engine Your vehicle is powered by a turbo diesel engine Before turning the engine OFF always allow the engine to return to normal idle speed and run for few seconds This assures proper cooling and lubrication of the turbocharger This is particularly necessary after any hard driving A CAUTION To reduce the risk of personal injury before turning OFF the engine and leaving the vehicle always e Keep your right foot on the service brake pedal e Turn front wheels towards the road curb e Switch OFF the ignition turn the key to the steering lock position and remove the key e Firmly engage the parking brake Copyright Mahindra amp Mahindra Ltd 082015 STARTING AND DRIVING THE VEHICLE e Move the gear shift lever to 1st gear position reverse gear if parking on an incline e Slowly release the service brake pedal e Lock your vehicle when leaving 11 6 Manual Transmission If Equipped The first few shifts on a new vehicle may be somewhat rough This is a normal phenomenon and precision shifts will develop within the initial few hundred kilometers of running 11 6 1 Gear
167. s that proper maintenance has been performed as prescribed Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE 14 23 MAINTENANCE 14 15 Maintenance Schedule Chart Description Inspect Replace Interval Engine Engine Oil 1 Engine Oil Filter Auto Tensioner and Drive Belts Coolant 3 Air Fuel and Exhaust Air filter element 5 Fuel Filter Element Water in Fuel Filter D Transmission Transmission Oil 2 Axles Wheels and Tires Differential Oil 2 Tire Rotation Brakes LSPV Setting Non ABS Brake amp Clutch Fluid Level amp LeakB Brake Pads Calipers Brake Drum and Lining 14 24 Replace at 3000 10000 then every 10000 kms R Replace at 3000 10000 then every 10000 kms R Replace every 100000 kms Replace at 60000 140000 then every 80000 kms Replace every 40000 kms Replace every 30000 kms Replace at 10000 100000 then every 100000 kms Replace at 10000 70000 then every 60000 kms Inspect every 10000 kms Adjust at 3000 40000 then every 40000 kms A Replace every 40000 kms or 2 yrs Inspect at every 10000 kms Inspect every 20000 kms R R R R R R R R R l l l l R R C Cc C R R l l l l A l R l l Copyright Mahindra amp Mahindra Ltd 082015 CGD MAINTENANCE Description Inspect Replace Interval Parking Brake Operations Adjust at 3000 10000 then every 20000 kms A A A A A A Suspension Suspension Bushes Inspect at 10000 then ever
168. s to the child AX DANGER Extreme Hazard Do not use a rear facing child restraint on a seat protected by an airbag in front of it Never put a child restraint in the front passenger s seat If the front passenger airbag inflates it can cause serious or fatal injuries Never hold an infant or child on your lap The infant or child could be seriously injured in the event of a crash All infants and 6 6 children should be properly restrained in appropriate child safety seats or seat belts in the rear seat Install the child restraint system on the rear outboard seats and securely lock the child restraint system in position Always Buckle Children ABC in the back seat It is the safest place for children of any age to ride 6 2 5 Airbag Deployment NOTICE The images shown in this section are for illustrative purpose only They may not look like your model variant or vehicle Front Air bag s Front air bags are designed to inflate in a frontal collision depending on the intensity speed or angles of impact of the front collision Copyright Mahindra amp Mahindra Ltd 082015 Airbag Non deployment Impacts below a pre determined threshold level may not cause the airbags to deploy in the following cases e Collision with Utility Poles or Trees uaeros_ Air bags may not inflate if the vehicle collides with objects such as utility poles or trees where the point of impact is
169. section width C R This is the tyre Construction Code The R stands for Radial D 15 Two digit number This number is the wheel or rim diameter in inches E 100 Two or three digit number This number is the tyres load index It is a measurement of how much weight each tyre can support F S Tire speed rating or speed symbol Never drive the vehicle faster than the tyre speed rating The speed rating denotes the 12 2 speed at which a tyre is designed to be driven for extended periods of time under a standard condition of load and inflation pressure 12 2 1 Speed Rating L 120 T 190 M 130 U 200 N 140 H 210 B 150 V 240 Q 160 W 270 R 170 Y 300 S 180 Z 240 12 3 Tyre Label Vehicle Placard The tyre Label Vehicle Placard is located on the driver door B pillar inner edge face This placard gives you important information about the tyre size designed for your vehicle and the tyre inflation pressures for the front and rear tyres Copyright Mahindra amp Mahindra Ltd 082015 WHEELS AND TYRES U42M03 Tyre Pressure Bar psi Front Rear 215 75 R15 2 2 82 2 2 82 h WARNING Never overload your vehicle Overloading can cause tyre failure affect vehicle handling and increase your stopping distance resulting in an accident and or personal injury Improperly inflated tyres can adversely affect vehicle handling or can fail unexpectedly resulting in an accident and or personal i
170. serious arcing and or damage to one or both vehicles Connect the jumper cables in the order described below e Connect one red clamp to the positive terminal of the dead battery disabled vehicle e Connect the other red clamp to the positive terminal of the good battery e Connect one black clamp to the negative terminal of the good battery e Connect the other black clamp to a piece of grounded metal on the dead vehicle preferably shiny metal not painted or oily that is attached to the engine Usually a nut bolt or other protruding shiny metal will work You may see Copyright Mahindra amp Mahindra Ltd 082015 5 6 a small spark when you connect to a good ground As a last resort you may connect to the negative post of the dead battery but this risks igniting hydrogen gas coming off the battery a UNS Car X a AX WARNING Make sure none of the cables are dangling into the engine compartment where they could be exposed to moving parts Start the working vehicle Let it idle for a few minutes Rev the engine a little above idle for 30 to 60 seconds You do this to charge the battery in the dead vehicle A good clean connection between the battery cables and the battery terminals is essential Try to start the disabled vehicle If it does not start shut the engine off and disconnect the last connection temporarily while you slightly twist or wiggle each of the fou
171. specialized knowledge tools and experience General mechanical aptitude may not be sufficient to properly service or repair your vehicle If you have any doubt whatsoever regarding your ability to properly service or repair your vehicle 10 TI please contact your Authorized Mahindra Dealer or a qualified technician Inspect the seat belt system periodically checking for cuts frays or wear in the seat belt webbing or loose buckles retractors anchors or other loose parts Damaged parts must be replaced immediately Always start and operate the engine in a well ventilated area If in an enclosed area vent the exhaust to the outside Do not modify or tamper with the exhaust system Examine tires for excessive tread wear and uneven wear patterns Check for stones nails glass or other objects lodged in the tread and check sidewalls for any cuts cracks or other signs of wear Replace as necessary Always maintain the safety labels affixed to your vehicle in a good legible condition All signal lamps buzzers shields guards and other protective safety devices must always remain in place and in good proper working condition The life span of Mahindra products depend on many factors Improper use abuse or harsh use in general may compromise the integrity of the vehicle and significantly reduce its life span The vehicle is also subject to wear over a period of time Please have your vehicle regularly inspected by an Authorized M
172. ssenseentenseeseetees 10 5 Air Intake Mode Control ccc 10 6 AiP Conditioner ON s icsssticsieiiaseniinrcnennactin 10 6 HVAC Air Filter Cabin Air Filter oo ee 10 7 Rapid Cabin Cooling 10 8 Rapid Cabin Heating 10 8 Defogging De misting and Defrosting ceeeeee 10 9 11 STARTING AND DRIVING THE VEHICLE eee 11 1 Safety Tips Before Starting your Vehicle 11 1 IGNIGION SWITCH ieisiiyer secede tare aaiinnrncipoemns 11 2 Pedals erone se stachasatusentyn E ATO 11 3 Stopping the Engine qu eeesseceeeeseceeeeseeteeseateeeseetes 11 5 Manual Transmission If Equipped 11 5 Automated Manual Transmission AMT If Equipped jet advantiiiieeh edd center Driving Your Vehicle LLU IE E E rar Ree eRe EPS TEE ET Tips for Better Fuel ECONOMY cesses 11 20 12 WHEELS AND TYRES iiitr 12 1 Tyre Information rainen nena sisi 12 1 Tyre Rating ae aana NA Aat 12 1 Tyre Label Vehicle Placard 12 2 Tike PRESSURE h ee ea ae 12 3 Tire Rotation Recommendations eececereen 12 6 13 EMERGENCE Sairaan a aA 13 1 Hazard Warning Lamp s esssseesieesisesiessiieiiresrisrirrsresress 13 1 Vehicle Does not Start CheckS sessceceeren 13 1 Vehicle Overheating s sssssesisesissrissriresrissriersersrrersreesree 13 2 JUMP StArtinG amana a a a 13 3 Table of Contents Limp Home Mode mornan taan ia 13 9 14 MAINTENANCE o sssssesssssssisssninsssnsirssnnsinnnniinnnrrinnnnrinnnrinnnnnnne 14 1 General Owners Information
173. steering wheel to sound the horn The horn functions even when the ignition has been switched OFF 8 22 Copyright Mahindra amp Mahindra Ltd 082015 CD 8 14 Instrument Cluster mni Ga a p Tachometer RPM Gauge Warning Tell tale Lamps Speedometer Mode Button Fuel Gauge c EQT U42D01 Odometer Gear Display Temperature Gauge Trip Meter Set Button 8 23 8 15 Instrument Cluster Gauges 8 15 2 Speedometer The instrument cluster comprises of the tachometer speedometer trip meter A amp B AC meter DTE SET button MODE button odometer fuel gauge coolant temperature gauge warning lamps and telltale indicators 8 15 1 Tachometer The tachometer indicates the real time engine speed in thousands of RPM revolutions per minute Maintain steady engine speed below and do not accelerate or decelerate abruptly The speedometer indicates the real time road surface speed of the vehicle in kilometers per hour A NOTICE The vehicle speed is affected by the size of the tires used If the size of the tires are changed from those fitted at the factory the speedometer might not display the correct road surface speed and distance travelled 8 24 GAD 8 15 3 Odometer The bottom row of the LCD display gives the odometer reading It records and displays the total distance traveled in kms 8 15 4 Trip Meter A B AC Meter amp DTE The top row of the LCD display gives th
174. still steer the vehicle manually but it takes more effort If the steering wanders or pulls check for e Under inflated tire s on any wheel s e Uneven vehicle loading 9 1 STEERING AND BRAKES e High crown in the center of the road e High crosswinds e Wheels out of alignment e Wheels out of balance e Loose or worn suspension components 9 2 Tilt Steering S b W1e2101 J The steering wheel can be adjusted for rake as required using the lever in the steering shroud under the steering wheel To tilt adjust the steering wheel 9 2 U42J01 Ensure the vehicle is stationary and parking brake engaged Pull the steering tilt lever down to unlock Raise or lower the steering wheel to the desired position A wow Push the lever back up to its original position to lock the steering 5 Adjust the seat according to the steering wheel position A WARNING An improperly locked steering wheel could cause loss of control and lead to accidents Never adjust the steering wheel while driving 9 3 Steering Controls Audio Control System if equipped Audio control through the steering wheel switches buttons helps the driver to operate the audio system from the steering wheel Copyright Mahindra amp Mahindra Ltd 082015 without losing concentration The system has four switches which are mounted on the steering wheel Hold the Mute button to start the infotainment 7
175. sudden stop causing injuries to occupants in the vehicle AS WARNING Never use a damaged seat belt system A damaged seat belt will not provide protection in an accident resulting in serious injury Seat belt systems can be prone to abuse They are not indestructible They must be handled with care to avoid damage Keep the belts clean and dry Belt retraction may become difficult if the belts and webbing are soiled If they need cleaning use a mild soap solution or lukewarm water Never use bleach SEATS AND SEAT BELTS dye or abrasive cleaners These chemicals will severely weaken the belts Retractors in 3 point type seat belts retract the seat belts when The lap belt should be worn snugly and as low as possible over the hips The shoulder belt should be worn across your shoulder but never across the stomach area When worn properly the seat belt will protect both the mother and the foetus in an accident or not in use The inertia lock and coil spring allow the belts to remain comfortable on users during normal driving During accidents or abrupt stops inertia locks restrict the sudden forward movement of the wearer Seat Belts Patients Persons with serious medical conditions should also wear a seat belt Consult your doctor for specific recommendations before travel Seat Belts Pregnant Women S D Pregnant women must also wear seat belts Consult your doctor for specific recommendations 5 8
176. sulting in an accident Never place objects other than cups or cans in the cup holder These objects can be thrown out in the event of a sudden stop or an accident possibly injuring the passengers in the vehicle 8 12 2 Glove Box The instrument panel houses a glove box on the passenger side The owner s manual can be found inside the glove box It is advisable to always keep it in the glove box for ease of reach lt is also recommended to keep copies of all vehicle documents in the glove box for reference when needed There is also a pen holder inside the glove box for convenience NOTICE Do not overload the glove box Do not store loose or small metal objects inside the glove box This will lead to rattling while the vehicle is driven on bad roads Copyright Mahindra amp Mahindra Ltd 082015 8 21 FEATURES AND CONTROL b WARNING To avoid the possibility of injury in case of an accident or a sudden stop the glove box lid should be kept closed when the vehicle is in motion 8 12 3 Sun Visor In certain variants a vanity mirror is provided on the back of the front passenger sun visor 8 13 Horn The sun visors can be used for either frontal or sideward shade to reduce glare or to shut out direct rays of the sun The sun visor can be swivelled to the side as shown to provide shade from the glare of the sun Press the pad on the
177. table Louvers B Thumb Wheel Open Close 10 3 HVAC Controls Two center vents are located above the audio system on the instrument panel Both the center and side vents provide air flow to the front seat passengers Rotate the thumb wheel B up to open or down to close the air vent Direct air to the desired direction by the adjusting louvers A There are two side vents located one each at the left and right extreme ends of the instrument panel Copyright Mahindra amp Mahindra Ltd 082015 103 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC GD A Air Distribution Control D AC ON OFF e Face Foot Mode air is discharged from the center vents side vents and foot vents This mode is most suitable for directing air flow towards both the face and feet of passengers at the same time B Blower Speed Control E AC ECO Mode Air Re circulation C Temperature Control F Switch g Foot Mode air is discharged from the two foot vents This mode is most suitable for directing air flow towards the feet of Soren eae ees passengers seated on front seats 10 4 Air Distribution Control e Foot Defrost Mode air is discharged from the foot vents side The air flowing out of various vents can be controlled by the air defrost vents and windshield defrost vents This mode is most distribution control knob button suitable for directing air flow towards the feet of passengers while defrosting or de misting defogging Keep t
178. the engine running at normal operating temperature This circulates the lubricating oil contained in the refrigerant AA CAUTION Whenever you get the air conditioning system serviced make sure the service facility uses a refrigerant recycling system This system captures the refrigerant for re use Releasing the refrigerant into the atmosphere may cause damage to the environment 14 11 Vehicle Storage If you are leaving your vehicle for more than 2 weeks you may want to take stopping to protect your battery Disconnect the negative cable from the battery Anytime you store your vehicle or keep it 14 20 CD out of service i e vacation for two weeks or more run the air conditioning system at idle for about five minutes in the fresh air mode and high blower speed setting This will ensure adequate system lubrication to minimize the possibility of compressor damage when the system is started again It is recommended storing the vehicle in a covered clean dry well leveled ventilated and closed place 14 12 Winter Care 14 12 1 Dealing With Ice Make sure you have window ice scrapers and de icers for the locks When you re stuck having a small shovel is useful to dig out of the snow The weight of a bag of sand in the trunk will give added traction in rear wheel drive vehicles and can be used to sprinkle on the snow and ice to gain better traction And don t forget personal protection such as a warm coat hat gloves and a bl
179. the dashboard or hood under direct sunlight 7 3 11 If RKE is Lost Do not put the key in any liquid or wash it in an ultrasonic washer If you have lost the programmed RKE contact an Authorized Mahindra Dealer for procuring a new RKE 7 4 Engine Immobilizer System While programming a new key set you will have to submit all the keys available with you to an Authorized Mahindra Dealer An Engine Immobilizer System is a security system that prevents the vehicle being operated by an unauthorized person The Engine A NOTICE immobilizer prevents the engine from being started unless it recognizes signals from the correct coded key There is a limitation max 2 keys at a time to the number of keys that can be programmed The minimum time frame The system is automatically activated when the key is removed required to supply the duplicate keys is 20 days after all the from the ignition formalities are completed Please contact the dealer to A understand the formalities involved NOTICE If the key is stolen or lost communicate to an Authorized In order to safeguard the theft protection system of the vehicle Mahindra Dealer to de activate the function of the lost or stolen Mahindra will not supply EMS ECU Engine Management key This is essential to avoid unauthorized access using the System Electronic Control Unit vehicle keys and the ICU as a misplaced key set for any vehicle 7 10 Copyright Mahindra amp Mahindra Ltd 082015 7 4 1
180. the vehicle Contact the nearest Authorized Mahindra Dealer for checks or repairs Driving the vehicle with the brake warning lamp ON or when you suspect brake trouble is very dangerous and could result in serious injuries Contact an Authorized Mahindra Dealer for checks or repairs When there is a EBD failure the parking brake lamp illuminates along with the ABS warning lamp 8 17 6 Turn Lamps The turn lamp arrows in the instrument cluster flash showing the direction indicated by the turn signals A sudden increase in the rate of flashing indicates failure of one or more of the lamp bulbs Have them replaced as soon as possible 8 17 7 Head Lamp High Beam Lamp 8 17 8 Battery Charging System Warning Lamp The battery charging system warning lamp illuminates when the battery is not being charged or when there is a malfunction in the alternator The head lamp high beam lamp illuminates whenever the head lamps are switched ON to high beam or when the head lamp flash is used This lamp illuminates when the ignition is switched ON and goes out as soon as the engine is started If the lamp continues to remain ON even after starting the engine it is an indication that the battery is not being charged or there is a malfunction in the alternator Check the alternator drive belt for looseness breakage If the drive belt is okay switch OFF all unnecessary electrical equipment and recheck Contact an Authorized Mahindra Dealer for furt
181. this manual never Legend of the Symbols To emphasize information and procedures regarding safety use maintenance etc the following symbols are used throughout the manual DANGER DANGER indicates an imminently hazardous situation which if not avoided will result in death or serious injury AX WARNING WARNING indicates a potentially hazardous situation which if not avoided could result in death or serious injury 1 2 Copyright Mahindra amp Mahindra Ltd 082015 CD 1 3 General Safety Information and Instructions As WARNING Failure to follow the warnings and instructions provided in this manual could result in failure of the vehicle an accident and or serious personal injury 1 Carefully read understand and follow the warnings and instructions given in this manual This manual is an essential part of the product Keep it in the vehicle glove box for future reference Spare bulb and first aid kit are placed in the glove box of the vehicle Ensure they are not taken out of the vehicle at any point of time Please note that throughout this manual reference is made that an accident could occur An accident could cause you or a bystander to sustain severe personal injury or result in property damage Never use a mobile phone or personal music device while driving This may take your focus off the road and lead to accidents Please be advised that many service and repair tasks require
182. too hot Verify that the engine coolant level in the coolant recovery tank is maintained between the Min and Max mark Check for possible fluid leakages Check for damages to heat exchangers and connecting hoses Also verify that the radiator shrouds engine fan blades and the engine belt all are in good condition If any evidence of failure is observed contact the nearest Authorized Mahindra Dealer for help In case no system leakage failure is suspected driving can be continued Either due to severe operating conditions or due to any system leakages or failures the engine can get overheated However if the engine is getting overheated repeatedly even in normal operating conditions get the vehicle checked by an Authorized Mahindra Dealer as soon as possible A NOTICE Refer to the High Engine Coolant Temperature section under the Features and Control chapter for details Ax WARNING If the high engine coolant temperature warning is ignored the engine shuts OFF abruptly to safeguard engine components from overheating and consequent failure Abrupt engine shut off can lead to uncontrollable driving condition and accidents Stay clear of hot and rotating vehicle parts while visually inspecting the vehicle The coolant inside the cooling system is under high pressure and temperature Never open the pressure cap of the degassing tank when the engine is hot Not taking precautions may lead to serious injury to your skin ey
183. tronic control units To disconnect battery terminals wait for at least 2 minutes to allow discharge of high voltage or it could lead to personal injury While disconnecting always disconnect the VE terminal first and while connecting always connect the VE terminal last AX WARNING Towing a vehicle to start could be dangerous The vehicle being towed could surge forward when the engine starts causing the tow vehicles to collide injuring the occupants Modern vehicles with electronic management systems should not be jump started without protected jump starter leads It is necessary to refer to the owner s handbook for jump starting procedures for such vehicles Copyright Mahindra amp Mahindra Ltd 082015 CD 13 5 Towing 13 5 1 Towing Equipment Flat Bed Towing N Towing equipment are of two types U42N01 wi e Flat bed equipment Your vehicle is loaded on the back of a truck This is the safest and best way of towing Copyright Mahindra amp Mahindra Ltd 082015 e Rear lift equipment The tow truck uses two pivoting arms that go under the tires front or rear and lift them off the ground The other two tires remain on the ground e Sling type equipment The tow truck uses metal cables with hooks on both ends These hooks go around parts of the frame or suspension and lift the end of the vehicle off the ground This is not a good method of towing as it m
184. ts under the seats They may interfere with the seat lock mechanism or unexpectedly activate the seat position adjusting lever causing the seat to suddenly move resulting in loss of contro of the vehicle an accident or serious personal injury While adjusting the seat do not put your hands under the seat or near the moving parts This may lead to injuries 5 1 SEATS AND SEAT BELTS 5 1 2 Front Seat Slide CAUTION While adjusting the seat make sure the latch engages fully and the seat is locked firmly in the desired position An unlocked seat may move in a sudden stop or collision causing injury to the person in that seat Push and pull on the seat to be sure it is locked 5 1 3 Front Seat Recline To adjust the seat back lift the recline lever located on the outboard side of the seat lean back and release the lever at the Move the seat forward or backward by lifting the adjustment lever desired position To return the seat back lift the lever lean forward towel bar located under the seat front and release once the desired and release the lever position is reached Copyright Mahindra amp Mahindra Ltd 082015 GD SEATS AND SEAT BELTS height such that you are able to depress the clutch pedal Ax WARNING completely The seat belts provide maximum protection in a frontal or rear collision when the occupants are sitting up straight and well Ax WARNING back in the seats If you are
185. unctioning of all exterior lamps 14 7 2 Fluid Leaks Check the engine compartment and the underbody of the vehicle for any leaks If you smell fuel vapor or notice any leak have the cause found and corrected immediately Copyright Mahindra amp Mahindra Ltd 082015 D 14 7 3 Doors and Engine Hood Check all doors and latches including the tailgate for proper functioning Make sure the engine hood secondary latch secures the hood from opening when the primary latch is released 14 7 4 Tire Inflation Pressure Check the tire pressure with a pressure gauge every week 14 8 Battery Your vehicle is equipped with a Mahindra genuine battery For longer trouble free operation keep the top of the battery clean and dry Also make certain the battery cables are always tightly fastened to the battery terminals If you see any corrosion on the battery or terminals remove the cables from the terminals and clean with a wire brush To prevent corrosion apply petroleum jelly to the battery terminals Tighten loose terminals and hold down clamp nuts only enough to keep the battery firmly in place Tightening excessively may damage the battery terminals 14 8 1 For Best Battery Service e Keep the battery securely mounted Copyright Mahindra amp Mahindra Ltd 082015 MAINTENANCE e Keep the battery top clean and dry e Keep the terminals and connections clean tight and coated with petroleum jelly or terminal grease
186. unter clockwise and setting it to the extreme left position maximum cooling is obtained When the dial is rotated clockwise the discharged air progressively starts getting warmer and at the extreme right position hot air is discharged A NOTICE represents cooling and represents heating 10 5 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC 10 7 Air Intake Mode Control The air intake control button toggles between fresh air or recirculated air modes Fresh Air Mode Outside Air Mode To set the HVAC system to fresh air mode keep the air intake control switch in the OFF condition The lamp on this switch is OFF indicating that the fresh air mode is active In this mode fresh air from outside the vehicle is sucked by the blower and utilized further to ventilate cool heat the cabin Re circulation Mode Re circulated Air Mode To set the HVAC system to re circulation mode press the air intake control switch once The lamp on the switch is ON indicating that re circulation mode is active 10 6 In this mode the air from inside the passenger compartment will be sucked by the blower and utilized further to ventilate cool heat the cabin For quick cabin cooling heating or while driving through dusty polluted regions the recirculation mode can be selected Driving with this mode active may lead to better fuel economy and longer HVAC filter life However running the air conditioner in the r
187. ure that the rear view mirror and both the ORVM s are adjusted for an unobstructed view of the road behind 11 1 3 Exterior Lamps Have someone observe and confirm normal operation of all exterior lamps while you work on the controls from the driver seat Also check functioning of all lamps in the instrument panel 11 1 4 Door Latches Check for positive closing latching and locking of all doors both from inside and outside 11 1 5 Fluid Leaks Check the area under vehicle after an overnight parking for fuel power steering fluid brake fluid engine coolant oil or other fluid 11 1 STARTING AND DRIVING THE VEHICLE leaks If leaks are observed contact an Authorized Mahindra Dealer 11 2 Ignition Switch An illuminator ring is provided on the face of the ignition switch to help in locating the ignition switch at night The ring will illuminate the moment the driver door is opened and will remain glowing till the driver door is closed The different positions of the ignition switch are LOCK This is the ignition and steering lock position The vehicle circuits and engine are completely switched OFF The steering wheel is also locked and the key can be removed from the ignition only in this position ACC The steering is unlocked and can be rotated In this position all electrical circuits are enabled Use this mode when you want to listen to music etc with the engine temporarily switched OFF ON
188. ve oil we suggest Engine Oil meeting minimum API CH 4 SAE 15W 40 specification can be used and replaced at 6000 km This alternate oil or other Brand will not provide equivalent performance of above Genuine oil Other Transmission Oils meeting API GL 4 SAE 80W 90 Specifications Drain Interval should change to 20000km Other Brand may not provide equivalent performance of recommended oil Special super clean oil recommended for AMT hydraulic unit No other oil recommended or to be used Alternate oil usage may harm the performance and cause unit failure Other Axle Oils meeting API GL 5 SAE 80W 90 Specifications Drain Interval should change to 20000km Other Brand may not provide equivalent perfomance of recommeded oil Alternately CALTEX MAKE TEXAMATIC 1888 BRAND can be used NO OTHER BRAND SHOULD BE USED If Maximile DOT 4 brake fluid is not used and in emergency conditions use Brake Fluid Meeting SAE J1703 FMVSS NO 116 DOT 4 OR IS 8654 TYPE 2 Specification and change it at 30 000 km or 2 years whichever earlier CD GENERAL MAHINDRA MAXIMILE ULTRA Brand Specific Don t use other coolants water for top up In case of ENGINE COOLING COOL A5 lite emergency coolant meeting JIS K 2234 specification should be used 80 GENUINE LONG LIFE COOLANT 2 INEPS concentration diluted with distilled water and coolant change period to be READY TO USE COOLANT NO NEED TO MIX WATER reduced as 30 000 km Diesel confirming to Indian sta
189. ver to maintain forward visibility and the ability to maneuver or operate other controls Deployment of the airbags happen in a fraction of a second producing a loud noise releasing a white smoke and residue along with a non toxic gas This does not indicate a fire This smoke may remain inside the vehicle for some time and may cause some minor irritation to the eyes skin or breathing Be sure to wash off any residue with soap and water as soon as possible to prevent any potential skin irritation If you can safely exit the vehicle you should do so immediately Ax WARNING e Do not modify remove strike or open the seat belt pre tensioner assemblies airbag sensor or surrounding area or wiring Failure to follow these instructions may prevent them from activating correctly cause sudden operation of the system or disable the system which could result in serious injury 6 3 SUPPLEMENTAL RESTRAINT SYSTEM SRS if equipped Parts of the airbag module steering wheel hub airbag cover and inflator may be hot for several minutes after deployment The airbags inflate only once Do not cover the steering wheel instrument panel seats with any object e g dash panel covers seat covers which may prevent the airbags from inflating properly The airbags inflate with considerable force While the system is designed to reduce serious injuries primarily to the head and chest it may also cause other less severe injuries to the fa
190. ways make sure that your vehicle is in optimum working order and take note of the road and weather conditions under which you are using your vehicle If you have any questions concerning the proper use or maintenance of your vehicle please call your Authorized Mahindra Dealer A list of dealers can be found in the Dealer Directory Supplement Alternatively you can contact Mahindra at e 1800 209 6006 Toll free e customercare mahindra com Copyright Mahindra amp Mahindra Ltd 082015 1 1 INTRODUCTION AND SAFETY PRECAUTIONS GD Servicing and Summary Data A CAUTION e For all issues concerning the vehicle and for any need of spare CAUTION indicates a potentially hazardous situation which if parts contact only the Authorized Mahindra network P y not avoided may result in minor or moderate injury and or e We recommend you always use genuine Mahindra spare parts property damage when performing repairs on the vehicle A NOTICE e We suggest that you record the vehicle data in the Warranty Information amp Maintenance Guide for future references NOTICE indicates important information relevant to the vehicle the vehicle s use or to sections of this manual to which articular attention must be paid for optimum use of the 1 2 Safety Symbols pP p p vehicle Carefully read understand and follow the safety symbols If you see this symbol it indicates no do not do not do this or instructions given in
191. window High Mounted Stop Lamp Rear Wiper Spare wheel Rear Footstep Reversing Lamp Reflector Rear Tow hook mounting provision T E eT e S N eel 2 Reversing Sensor Rear Turn signal Lamp Fuel Lid Rear Park Lamp Brake Lamp Side Footstep ale aN E If equipped u42c02 3 2 Copyright Mahindra amp Mahindra Ltd 082015 3 3 Instrument Panel Overview ae fm an oot fw ce be J C U42C03 P Copyright Mahindra amp Mahindra Ltd 082015 Side Vents Passenger Airbag HVAC Controls Hazard Warning switch Infotainment Screen Centre Vents Steering controls Audio Steering wheel Instrument Cluster Horn Pad Driver Airbag if equipped oD olur Olz Ez VEHICLE OVERVIEW Headlamp Levelling ESS ORVM PowerECO switches Transmission Gear Lever AUX USB Ports Parking Brake 12V Power Outlet Rear Can Bottle holder Power Window switches 12V Power Outlet Front Glove Box 3 3 AD 4 INSTRUMENT CLUSTER OVERVIEW 4 1 Instrument Cluster a u42D01 A Tachometer RPM Gauge F Odometer B Warning Tell tale Lamps G Gear Display e Speedometer H Temperature Gauge D Mode Button Trip A B AC Meter amp DTE E Fuel Gauge J Set Button 4 1 4 2 Warning Lamps Overview GD INSTRUMENT CLUSTER OVERVIEW 4 3 Warning Lamps The phenomenon of warning lamps flashing momentari
192. wing vehicles to the towing hook A CAUTION Use only the towing hook provided for towing in an emergency Do not tow by the bumper or any other part which may be damaged Use only the cable or chain specifically intended for use in towing vehicles A driver must be in the vehicle being towed to steer and operate the brakes Towing in this manner must be done only on hard surfaced roads for short distances and at low speeds 13 8 Copyright Mahindra amp Mahindra Ltd 082015 GD 13 6 Limp Home Mode Limp home mode is an emergency situation declared by the EMS Engine Management System due to failure of one more critical sensors actuators In this mode the EMS Engine Management System will revert back to basic minimum requirement fuel quantity injection timings to aid the driver to bring the vehicle back to the nearest workshop Needless to say the drivability amp fuel consumption will be greatly affected If vehicle acceleration worsens or if there is a drop in vehicle performance there might be a malfunction in the engine management system which triggers activates the Limp Home Mode This condition is accompanied by the check engine lamp illuminating in the instrument cluster In this mode the vehicle speed is limited and the accelerator pedal may not function normally It is recommended you contact an Authorized Mahindra Dealer immediately for assistance Copyright Mahindra amp Mahindra Ltd 082015
193. y Restore the tools and jack back to their respective locations Mount the flat tyre to the back door bracket at the rear of the vehicle Firmly tighten the securing nuts and put the wheel cover back Double check to ensure the tyre is snug against the back door of the vehicle NOTICE lt is recommended to fix the flat tyre at the nearest tyre shop and swap the spare wheel back The wheel balance and alignment differ from wheel to wheel which may lead to difference in steering and braking Copyright Mahindra amp Mahindra Ltd 082015 CD GENERAL 2 8 Technical Specifications ENGINE mHawk 80 Displacement Cubic Capacity 1493 cc Type 4 Stroke Turbocharged Compression Ignition Bore x Stroke 83 0 X 92 0 mm No of Cylinders 3 Max Engine Output 84 bhp 3750 rpm Max Engine Output AMT 80 bhp 3750 rpm Max Torque Nm rpm 230 Nm 1500 to 2250 rpm CLUTCH Type Single plate Dry Diaphragm Type TRANSMISSION Type Manual Synchromesh in all Forward Gears No of Gears 5 Forward 1 Reverse SHIFT MECHANISM Type Manual Automated GEAR RATIOS 3 78 1 ll 221 24 Ill 1 42 1 2 19 Copyright Mahindra amp Mahindra Ltd 082015 GENERAL IV Vv Reverse AXLES Front Rear WHEELS amp TIRES Rim Tires STEERING Type Description Turning Circle Radius SUSPENSION Front Rear Anti rollbar Shock Absorber BRAKES Service Brake Front Rear 2 20 1 00 1 0789 11 3 56 1 N A 43 1
194. y 20000 kms l l l Suspension Arms amp Links Inspect at 10000 then every 20000 kms l l l Steering Power Steering Fluid Level amp Leak Inspect every Service l l l l l l l Wheel Alignment At 40000 kms earlier if abnormal wear is noticed Electrical Battery Electrolyte Level Inspect every Service l l l l l l l l l Battery Electrolyte Specific Gravity Inspect every Service l l l l l l tI All Lamps Horns Wipers and Washers Inspect every Service l l l l tI Head Lamp Aiming Inspect at 3000 kms I HVAC Mesh Filter Clean Inspect every Service G C c Cc 4 G Cc Cc Cc G Final Inspection Tyre Pressure Inspect every Service l l l l l l Under Chassis Bolts for Tightness Inspect at 3000 20000 then every 20000 kms l l l l l Exhaust Pipe Mountings and Damage Leaks Inspect at 3000 20000 then every 20000 kms l l l l Road Test if any complaints reported Inspect every Service l l l l l l l l A Adjust as Necessary Inspect amp correct Replace if worn out or faulty R Replace C Clean On chargeable basis 1 Change as per the km or 1 year whichever earlier 2 Change as per the km or 2 years whichever earlier Copyright Mahindra amp Mahindra Ltd 082015 14 25 MAINTENANCE Description Inspect Replace Interval 3 Change as per the km or 3 years whichever earlier 5 Under extreme operating conditions replace air filter every 20 000 kms B Change brak
195. y at very low vehicle speeds and during parking maneuvers A NOTICE Upon initial start up in cold weather the power steering pump may produce noise for a short amount of time This is due to the cold thick fluid in the steering system This noise should be considered normal and it does not in any way damage the steering system Ax WARNING Continued operation with reduced power steering performance could pose a safety risk to yourself and others Have the vehicle serviced at specified intervals or whenever a power steering problem is noticed When driving in rough off roads hold the steering wheel rim do not hold the wheel spokes A sudden bump can jerk turn the wheel and injure your hand This may also lead to loss of vehicle control A NOTICE Keep both hands on the steering wheel with the thumbs resting on the outer wheel rim To help prevent damage to the power steering pump e Never hold the steering wheel to the extreme right or the extreme left for more than a few seconds when the engine is running e Heavy or uneven steering efforts may be caused by low power steering pump fluid level Check the low power steering pump fluid level before seeking service from an Authorized Mahindra Dealer e Do not fill the power steering pump reservoir above the MAX mark on the reservoir this may result in leaks from the reservoir NOTICE If the power steering system breaks down or if the engine is turned OFF you can
196. y while applying light pressure on the brake pedal When driving through water traction or brake capability may be limited Always perform a maintenance inspection after each day of off road driving that has taken you through water 11 8 4 Flowing Water If the water is swift flowing and rising as in storm run off avoid crossing until the water level recedes and or the flow rate is reduced The flowing water can erode the streambed causing your vehicle to sink into deeper water Determine the exit point s that are downstream of your entry point to compensate for drifting 11 8 5 After Driving Off road or through Water Off road operation puts more stress on your vehicle than does most on road driving Always perform a maintenance inspection after each day of off road driving that has taken you through rough terrain sand mud or water e After going off road it is always a good idea to check for damage Completely inspect the underbody of the vehicle for any damages e Check for accumulations of plants or bushes These could be a fire hazard They might also hide damage to fuel lines brake tubes hoses etc e Inspect all the tubes hoses and check for any fluid leakages e Get heat exchangers radiator and condenser cleaned EA STARTING AND DRIVING THE VEHICLE GID e Check threaded fasteners for looseness particularly on the 11 9 Fuel chassis drive train components steering suspension and brakes Retighte
197. ystem is essential Follow the instructions in the subsequent sections to clear the frosted misted fogged up front windshield Copyright Mahindra amp Mahindra Ltd 082015 10 12 1 Front Windshield Defog Set the blower to full speed Switch the air conditioner ON Set the air distribution control to defrost mode Select the fresh outside air intake mode a amp Ww Adjust the temperature control knob to maintain comfort NOTICE To defrost the outside windshield follow the above steps but switch OFF the AC On humid days do not blow cold air on the windshield and side window glass the difference between the outside and inside cabin temperature could make the fogging worse 109 HEATING VENTILATION AND AIR CONDITIONING SYSTEM HVAC 10 12 2 Rear Windshield De mist if equipped 10 12 3 HVAC Points to Remember The rear windshield glass de mist button is located in the switch bank on the instrument panel RHS of steering adjacent to the head lamp leveling switch Press the button once to activate the de mister The LED on the button illuminates upon activation and the de mister heats the rear windshield clearing the fog Switch OFF the de mister by pressing the button again as soon as the fog is e cleared NOTICE The rear windshield de mister switches OFF automatically after a pre defined time 10 10 For quickly clearing the misted fogged frosted up windshield set the blower

Owner`s Manual

Contents

Download Pdf Manuals

Related Search

Related Contents