Operation Manual 02/2000 (Rev. 05)
Contents
1. 8 Automatic temperature control disabled r 8 Automatic temperature control enabled a r 8 OBTAINING PRODUCTS MILK LEVEL DEPENDENT 9 Milk level indication and product delivery enabled milk level too low 9 Milk level indication enabled and product delivery disabled milk level too low 9 Milk level indication disabled and product delivery enabled milk level too low 9 AENA tit sialic a EN s ERE RESEN IE spna us s 9 Setting portions for milk and frothed Milk oooccccccoconcccocncoconnnnconoconnonanoncnnonnononononnnnaninnnnnananonnns 9 OPERATION ea toco ii iaa 10 PA NNN GN 10 F FOGUCT SE IC CUO I Hu 10 POGUE CS TI CI ee ie ae chen lan 10 AUTOMATIC CLEANING 2 a Sua a ua qupa uta Qopa queulisa ukta a Oa 11 Cleaning sequence asis ANSA 11 ACCessones tor daly USE s rer SARS 14 ERROR 4 15 Possible AUS ua NN 15 BAMF 02 00 VOS Page 3 User manual Safety instructions Attention Read the information given in the user manual carefully see Chapter 2 Page 2 1 Hygiene Note Prior to commissioning do the daily cleaning see Chapter Cleani2. As an option all three versions of the Milk Foamer can be fitted with an external warning lamp which flashes for 3 minutes if a product button is pressed when the milk level is too low Ready state The Milk Foamer is ready to use as soon as the milk temperature and level are correct Setting portions for milk and frothed milk You can pre program product portions and assign products to individual buttons from the coffee machine control board Attention Failure to comply with points 3 1 to 3 7 above when setting up the Milk Foamer can impair its subsequent performance Never put your hands beneath the delivery spout during product delivery or the cleaning cycle otherwise you risk scalding BAMF 02 00 VOS Page 9 User manual 4 Operation 4 1 Spout height Place a cup or other container beneath the spout For shallow cups you can place a cup stand on the drip grille to raise its height The clearance height is 145 mm in the case of single spouts and 125 mm in the case of twin spouts 4 2 Product selection Press the relevant product button O Cappuccino Milk Coffee or Hot Milk 4 2 Product delivery The appliance delivers the selected product in the quantity you have set Accounting mode You need to enable delivery using the Accounting pin key before the appliance will output the product Extra portion in Accounting mode If you press the button together with the relevant product button e the appliance wil
3. Mikktoamer User Manual User manual Milkfoamer User manual Published by M Schaerer Ltd CH 3302 Moosseedorf Edition 5 Edition November 2005 Replaces 4 Edition March 2005 Designed edited by M Schaerer Ltd CH 3302 Moosseedorf Copyright by M Schaerer Ltd CH 3302 Moosseedorf All rights reserved including translations into foreign languages It is prohibited to copy reproduce distribute or communicate by electronic means all or any parts of this document in any form without the express permission of the publisher All information technical data and illustrations contained in this guide reflect the latest factual position at the time of going to print M Schaerer Ltd reserves the right to introduce modifications at any time without specific notification BAMF 02 00 VOS Page 1 User manual Page 2 BAMF 02 00 VOS User manual Table of contents Chapter Page SAFETY INSTRUCTIONS NE 4 VIE 4 PRODUCT DESCRIPTION nasa aora 5 MENA A MENO ee 5 Sale y OLE 035 ID 7 asado dia oasis opcion asas 5 Instalan ee rennen 6 DISPLAY AND CONTROL ELEMENTS ararauna a 7 Verein NS 7 Coole 7 COMMISSIONING see 8 PNI SUNN 8 Before you switch on the appliance and heater a a r 8 PFU MI IN u u 5 tia 8 SWIteMING ON Une M CARE uu k u u a kau Qu asa NE EE oca 8 OBTAINING PRODUCTS MILK TEMPERATURE DEPENDENT
4. MBL 2 VHS IG 3NdE JVAOOP VOL MALE peog Paj28UU0 suor38InbaJ 1890 0 NOA JeJauJ M SU0111IpU03 Jayjo JO D 8 9 J Z SS UDJ8U J3 M ESP 9VSW 40304 UTAN dung pi ww QL 0018 1911NO pue sja u Joy Buruadg ww 954 aqn3 ufeup 911S81d Z UOudIS 8A88 S p DBu8 j 01 uor ww 002 uu OG J STH 6 U01138UU02 JAJBA 2 19 8 A 8A d01S 2 19 L sJeq 186 Jaonpa aJNSSaJd 9 4911134 G A9AS 01 P8188 aA GA UJNLSJ UON p peauyj SPTSUT J0198UU039 2 19 sa 0d g a eway 194908 Z Wy Joy WWE Aq SUJOW 84 WOJJ pejeJedas sajod 118 YIIJAS UTEN MN HE DAA EAS DA Juesajd aq ysnw s uj1114 Dufro oy au Page 6 User manual 3 Display and control elements 3 1 View of machine Legend Trip grid Milk and coffee outlet Control panel Explanation of messages Air valve cover Milk container Lid for milk container a TS Oy AD pee pe Pos eT e fe 3 2 Control panel 2 Legend Cleaning button Stop button Product button Main switch ON OFF F O N BAMF 02 00 V05 Page 7 User manual 3 3 3 3 1 3 3 2 3 3 3 3 3 4 3 4 3 4 1 3 4 2 Page 8 Commissioning Power supply Connect the appliance to the mains supply Operating voltage 230 V 10 A 50 60 Hz Before you switch on the appliance and heater Important Remove the milk container Pour 0 5 dl water fill
5. precautions The Milk Foamer has to stand along the side of your coffee machine on a even level surface Never open the appliance casing There are no controls inside the appliance or any parts which require attention from the user In the event of a malfunction please contact Schaerer Customer Services The ambient temperature must not be lower than 10 C or higher than 40 C To ensure your Milk Foamer always functions perfectly never place objects on top of the appliance Do not clean the appliance using a hose or high pressure spray The use of steam cleaning equipment should also be avoided Your Milk Foamer may only be operated by personnel instructed in its use If the appliance is going to be unused for a long period remove the mains plug from the socket Attention M Schaerer Ltd accepts no liability under the warranty for damage resulting from improper use of the appliance e g using liquids other than milk connecting it to the wrong current or operator error Put never the lid cover from the milk tray into the dishwasher The synthetic material of the lid will be damaged from heat in the dishwasher The material gets brittel gt Manual risk BAMF 02 00 VOS Page 5 User manual Installation layout 2 3 q 3 BEPG B E RCT pS spis JojeJedo AA JaweOJHT TN ULIN TIWS aa a U011811I81SUI ywawo sng juB sep 8U01 0NJ1SU0J ayy abueyo 01 D8AJ888J ST 1UuBTJ 8ul BAMF 02 00 VOS 3Nd IVADEL vol
6. the tank of the bain Marie heater with 1 5 dl of water for a 10 liter Milk Foamer The correct water level is essential for effective heat transfer If you overfill the bain Marie the water will run over when you insert the milk tray Re insert the milk container Plastic bag milk insert To make the appliance even easier to use and especially to make daily cleaning even more efficient we recommend using special design bag inserts made from HDPE plastic These bags do not impair the quality of the milk produced to the slightest degree They are taste and odour free safe for use with food heat resistant and biodegradable They are designed for single use Pour in the volume of milk you require up to a maximum of 5 liters Replace the milk level sensor and suction tube Switching on the machine Power up the machine by pressing the main switch which is located under the buttons protector flap below the control panel marked 4 in the diagram on page 3 9 The signal lamp lights up Obtaining products milk temperature dependent Automatic temperature control disabled If automatic temperature control is disabled you can order a product immediately after refilling with fresh milk Automatic temperature control enabled If automatic temperature control is enabled you cannot order a product after refilling with fresh milk until the milk reaches the programmed temperature If you press any product button during heating the Clean
7. ing agent Turn the foamer head the spout assembly to the left to release its bayonet connection and remove Open and clean the foamer head and inspect the seals Remove the spring loaded whisk unit and clean thoroughly Clean the milk outlet with a fine brush BAMF 02 00 VOS Page 11 User manual 4 Lift the double lidded milk tray out of the bain Marie Remove the milk bag and any residues for disposal Clean the milk tray Remove any remaining water from the bain Marie and clean Attention Avoid cutting or scratching the surface of the milk tray and bain Marie with pointed or hard objects Do not use a metal pan scrubber or abrasive scouring agent for cleaning Clean the containers with either a nylon brush or a special sponge for Teflon Hot water with standard dish washing agents is quite adequate The removable milk tray is dishwasher proof 5 Fill the bain Marie with 0 5 dl water 1 5 dl for the 10 liter Milk Foamer and replace the milk tray Add 2 liters of warm water containing 0 5 dl special cleaning agent Thermoclean Order number 065 642 to the milk tray Page 12 BAMF 02 00 VOS User manual 7 After cleaning reassemble the foamer head and whisk unit and replace 8 Once cleaning program has started you cannot select any products from the Milk Foamer for about 13 18 minutes 22 rinse cycles You cannot interrupt the cleaning program once it has started The automatic cleaning process sta
8. ing button on the Milk Foamer flashes and the following message appears on the coffee machine display Unable to select Product milk temperature not reached The milk will take approximately 16 to 20 minutes to reach the pre set temperature Note Automatic temperature control can only be programmed as enabled or disabled by an M Schaerer AG authorised service technician BAMF 02 00 VOS 3 5 3 5 1 3 5 2 3 5 3 3 6 3 7 User manual Obtaining products milk level dependent Milk level indication and product delivery enabled milk level too low If the milk container is empty or nearly empty the Cleaning button on the Milk Foamer flashes when you press a product button and the coffee machine displays the following message Unable to select Product Milk level not reached You can obtain a product Milk level indication enabled and product delivery disabled milk level too low If the milk container is empty or nearly empty the Cleaning button on the Milk Foamer flashes when you press a product button and the coffee machine displays the following message Unable to select Product Milk level not reached You cannot obtain a product Milk level indication disabled and product delivery enabled milk level too low If the milk container is empty or nearly empty the Milk Foamer does not display a level indication The coffee machine displays the following message Select product You can obtain a product
9. l output programmed extra portion of the selected product Note i Only one extra portion is available in accounting mode Extra portion in Self Service mode You have the option to define one of the user buttons as the Extra Portion button The appliance will output hot milk for as long as you press the button up to maximum of 10 seconds Ordering possibilities You can order a coffee from the coffee machine and hot milk from the Milk Foamer at the same time However you cannot order two coffee products simultaneously from both appliances Attention Never put your hands beneath the delivery spout during product delivery or the cleaning cycle otherwise you risk scalding Page 10 BAMF 02 00 VOS 9 1 User manual Automatic cleaning Cleaning sequence Attention The Milk Foamer must be cleaned every day Drain all the remaining milk out of the container by pressing the Cleaning buttons J on both the Milk Foamer and the coffee machine simultaneously When the Stop button starts to flash to indicate that the container is completely empty press it to acknowledge 2 JR 9 0 0 The following message appears on the display 4 Select product 2 Select product Empty Milk Foamer Start Milk Foamer cleaning Remove the lid cover from the top of the Milk Foamer Take out the suction hose milk level sensor and valve from the milk tray Take them apart and immerse all the parts in a bath of clean
10. ng Attention e Please follow the generally valid hygiene HACCP regulations HACCP Hazard Analysis and Critical Control Point e Do not use raw milk Use only pasteurised or UHT milk Homogenized milk must always be used e Milk that has already been heated up or for which the expiry date has lapsed may not be used e When using packaged milk it is recommended for hygienic reasons to use the milk directly from the original packaging e The milk in the refrigerator must have a temperature of approx 3 C to 5 C If this rule is not followed it is not possible to dispense an optimal product e Only refill with milk which has not exceeded 5 C Never put warm milk in the refrigerator It takes too long for a temperature of 3 C to 5 C to be reached The refrigerator will also ice up Frequent defrosting required e For daily and weekly cleaning proceed as described in chapter Cleaning e Never spray the machine with water or other liquids e For cleaning never immerse the machine in water or any other liquid Danger During cleaning and usage of cleaning tools or products there is a risk of injury Page 4 BAMF 02 00 VOS 2 1 2 2 User manual Product description Intended purpose The Milk Foamer has been developed for the production of Cappuccino milk coffee and for heated milk The Milk Foamer has been designed to work exclusively in combination with a Schaerer coffee machine model SM Il Safety
11. rts as soon as the cleaning water reaches the required temperature 9 As soon as the automatic cleaning program is finished the display shows Select product Start Milk Foamer rinsing 10 Use a cloth to remove the rest of the cleaning agent from the milk tray then refill it with around 4 litres on the Milk of cold water which does not contain cleaning agent Press the flashing Cleaning button Foamer This activates one rinse cycle which cannot be interrupted Note To stop the rinsing press on the illuminated Stop button 11 When you have finished cleaning the Milk Foamer switch it off at the main power switch under the control panel While the Milk Foamer cleaning program is running the coffee machine can be cleaned BAMF 02 00 VOS Page 13 User manual Attention Removing the foamer head during the Milk Foamer cleaning cycle cancels the cleaning cycle Once the foamer head is back in place the cleaning cycle starts again from the beginning Important STOP The appliance should be cleaned weekly using an acidic cleaning agent such as vinegar to remove milk scale Attention A Cleaning agents In the event of contact with skin or eyes rinse thoroughly in water without delay Before restarting the Milk Foamer it is essential to check that the bain Marie contains the necessary 0 5 dl water 1 5 dl in the case of the 10 litre Milk Foamer Put never the lid cover from the milk tray into the dish
12. washer The synthetic material of the lid will be damaged from heat in the dishwasher The material gets brittle gt Manual risk 5 2 Accessories for daily use Portioning beaker 050424 Plastic bag milk inserts 065624 Seal 5 x 1 5 065632 Fine cleaning brush 067407 Cleaning set 065642 Seal 36 x 2 065633 Page 14 BAMF 02 00 V05 6 1 User manual Errors Possible faults Unsatisfactory frothing The resistance in the spout is missing The spout is dirty The air infeed valve has stopped working No milk or foam delivered The suction tube is blocked The walls of the suction tube are stuck together Milk slow to heat Less than 0 5 dl water is in the hot water bath There is not the required 0 5 dl water 1 5 dl in the case of the 10 liter Milk Foamer between the milk tray and the bain Marie No coffee or milk delivered The Milk Foamer spout assembly has been removed or incorrectly replaced the display indicates Foamer head not in place The milk is droping at the spout The flap valve below the cover is filthy incorrectly mounted or missing Attention If you cannot remedy the fault yourself with the help of the above guidance you should call in an M Schaerer AG authorised service technician BAMF 02 00 VOS Page 15 User manual Page 16 BAMF 02 00 VOS
Download Pdf Manuals
Related Search