GM Predator Web
Contents
1. Par ameTer KL Pede Fatio aing Fars Jer Erwichumznit Spark Pierra Shift Adaptation Allows user to adjust the time delay between shift commitments i e quickness of the shift Modifying Parameters When adjusting to a negative percentage the shift adaptation will be shorter hence a quicker shift Positive adjustment will yield a longer and slower shift Axle Ratio Cooling Fans Power Enrichment Spark Normal Shift Adaptation Adjust only if different gears are installed and where necessary Corrects speedometer and transmission for gear changes N A for Corvette y car please read addendum to manual for instructions Allows user to change temperatures where cooling fans go on and off Applies only to vehicles with electric fans On temperature MUST be higher than OFF temperature for proper operation of fans Adjust only if vehicle is running rich or lean as verified by an air fuel meter Increase numbers if the air fuel ratio is lean and decrease numbers if the air fuel numbers are rich When adjusting the Power Enrichment we will allow up to a 5 increase or decrease of fuel trims at WOT This translates to approximately 0 1 5 point air fuel adjustment range plus or minus Adjust only if the vehicle has a spark knock detonation Higher number will advance timing lower number will retard timing When adjusting the spark we will allow up to a 10 increase or decrease of timing in the2. Product This limited warranty does not cover damage caused by modifica tion alteration repair or service of the Product by anyone other than DiabloSport physical abuse misuse use in a manner contrary to the instructions which accompany the Product or any damage caused by acts of God Contacting your Distributor or Dealer may make claims for repair service or replacement of the Product pursuant to this limited warranty The Chip will either be repaired replaced at the option of DiabloSport at no cost to Purchaser if the defective Product is covered by this limited warranty DiabloSport s liability pursuant to this limited warranty and for any damages loss and or claims associated with the Product shall be limited to the price of the Product paid by Purchaser or at DiabloSport s option repair or replacement of the Product 6 State Law Some states do not allow limitations of implied warranties or the exclu sion or limitation of incidental special or consequential damages so the above limitations may not apply to you In such states liability shall be limited to the greatest extent permitted by applicable law 7 Governing Law amp Venue This Agreement shall be governed by and construed in accordance with the laws of the State of Florida and venue for any legal proceeding or action at law arising out of or construing this Agreement shall lie in the state or federal courts of Orange County Florida and the parties specifically waive
3. be left untouched by inexperienced users c S ze ec E Sg 3 D OBD II Diagnostic port locations 99 03 Vette 99 02 Firebird Camaro Driver side underneath dash in the center facing floor Driver side underneath dash right hand side facing driver Il Diagnostic 2 2 S 2 Q Q 0BD OBD II Diagnostic port locations 99 02 Chevrolet GMC 1500 2500 3500 trucks Chevrolet Tahoe Avalanche GMC Yukon Denali Cadillac Escalade Escalade EXT Driver side underneath dash TK left hand side above parking brake 500020 iod aysoubbig 1090 Vehicles equipped with the GM OnStar system Vehicles equipped with the GM OnStar system Due to fact that the GM OnStar system sends transmissions periodically to the vehicle we suggest that the system should temporarily be disabled during the installation and modification process If the OnStar system is not disabled during install and modification and the system should receive a transmission in the middle of tune install or backup the tool will be interrupted and the process will have to be started over again To avoid this problem it is recommended that the system is disabled during tune install backup and modification To disable the OnStar system please refer to your ownersi manual and locate the fuse s associated with OnStar The OnStar system is disabled when the OnStar light is turned off On some v
4. or operation of law is hereby excluded and disclaimed The implied warranties of merchantability and of fitness for any particular purpose herein are expressly disclaimed 4 No Liability For Damages Injuries Or Incidental Special Or Consequential Damages Under no circumstances shall ToolRama Inc DiabloSport LLC or ToolRama LLC or any other party related to ToolRama beliable to Purchaser or any other person for any damage to Purchaser s vehicle loss of use of Purchaser s vehicle or for personal injuries suffered by any person or for any incidental special or conse quential damages whether arising out of negligence breach of warranty breach of contract otherwise ToolRamo s liability for any damages loss and or claims associated with the Product shall be limited to the price of the Product paid by purchaser Purchaser hereby releases ToolRama from all liability claims and damages associated with the Products with the sole exception of ToolRama s liability for the refund of the purchase price of the Product to Purchaser in the event that a court of competent jurisdiction determines the Purchaser suffered damages directly resulting from the malfunction of the Product 5 Wearreanty Not withstanding the provisions of the End User License Agreement DiabloSport warrants the Product to be free from all defects in material and workmanship for the life of the Product This limited warranty applies only to the original Purchaser of the
5. page during procedures Installing a tune into a vehicle Select Tune It read and follow the instructions and disclaimers Continue by pressing any key Earned EE ajere Apply parking brake Fredator must be used nith Turn the ignition OM factory tune otherwise damage Ta Turn off daytime may result to your vehicle 1 uou are not sure about your tune Rumning Nante contact DisbleSpornt i lt 17 S aun D hicle Installing a tune into a ve Installing a tune into a vehicle Continue by pressing any key eee clair eee Predator tunes must be used MIT premium super unleaded fuels only Failure to do so meu result in damage fo your vehicle Frese key Continue by pressing any key deee yc Tete eee Pead merical carefully before pooceedina in predator modify parameters Section Pres Installing a tune into a vehicle Press Enter to continue Select the type of Transmission for your vehicle Press Esc fo return to main menu Press Enter key e ransmniasion Type Automatic Mariel eel yoann edet Do Uou want To Enter Tor YES ESC for Ho D ojUI aun D Q Installing a tune into a vehicle The tool will automatically back up the factory stock tune Please wait until completed This may take several minutes During the backup process the gaug
6. tests where not performed during the DTC check NOTE DTC Not Ran SCC DIC Not Ran Since Code Cleared Because the PCM performs tests of modules during driving cycles some modules are not tested at the time the DTC All command is performed This feature displays what modules where excluded during the DTC All test This information always bases itself from last Erase DIC s command performed Select DTC All to view all codes once viewed press ESC twice then select Erase your SES light should now turn off as long as the problem is fixed Monitoring Real Time Data Real time data is just what it implies The Predator will display an If you select Testing the following screen will be displayed array of sensor input values as the engine is running Select Diagnostics from main screen Select Real Time Data Monitor desired parameters TRAET EHO E AE KA Calibration kiz Pina Ful NOTE Only values supported by vehicle model will be displayed Abbreviation If you select Abbreviations you will be able to look through a list of all the abbreviations that may be used during the live data session Testing Calibration Ids displays numerical ID s of each section Unless instructed DO NOT USE THIS MENU of the tune The Testing menu is designed to aid DiabloSport if we need to Ping All monitors communication status between troubleshoot your Predator PCM and mo
7. La gt hicle Installing a tune into a ve Installing a tune into a vehicle Turn ignition Off Then press snp key Follow instructions on the screen E seconds Installing a tune into a vehicle DO NOT start the engine Turn ignition on Lait seconds File ig Successfully installed Press anuj SA Ld So Lap oS La gt Restoring factory stock tune We recommend restoring the stock tune whenever the Plug tool into port select Tune It and go through the same steps as vehicle goes in for service installing a DiabloSport tune Refer to install intructions After the transmission selection you should see the following screen The stock tune can be re installed at any time using the restore feature This feature will take the DiabloSport tune out and reset the computer to stock The DiabloSport tune will be saved in the Predator eee eror E Ta ae Install Performance Modif Fercforcmence Restore Saeued Hata Trcuablezmnootina Select Restore Saved Data The fool will go through the same installation process as when installing 0 performance tune D pu 2 ue Restoring factory stock tune Follow all the steps and once you see this screen your vehicle has been restored back to stock tune gt S e zi ED Caution DiabloSport will not be held responsible for vehicles with
8. Table of Contents End User License Agreement Predator Satisfaction Guarantee Return Policy Predator Re flash Policy Display and Keypad description Before Installing DiabloSport Performance Tune Preparing Vehicle for DiabloSport Performance Tune Installation Important note regarding DiabloSport Performance Tune Parameter modification OBD II Diagnostic port locations Vehicles equipped with the GM OnStar system Installing a tune into a vehicle Restoring factory stock tune Caution Modifying Parameters Modifying Parameters Parameters Explanation Important information regarding DiabloSport Performance Tune Parameter modification Diagnostic Section How to check and erase the SES light Monitoring Real Time Data Options Section ST e l D 3 a greement imer Warranty and Discla End User License A End User License Agreement Warranty and Disclaimer THIS END USER LICENSE AGREEMENT the Agreement is an agreement between you as the purchaser the Purchaser of either the Diablo Module the Module or the ToolRama hand held computer unit the Unit and ProgRama Tools Inc DiabloSport LLC or ToolRama LLC collectively ToolRama as the manufacturer of the Product The Product and the Unit shall be referred to collectively herein as the Product 1 Acknowledgment And Acceptance Of Agreement If you do not agree to the terms and conditions of this Agreement do not use the Product Inste
9. WOT range This translates to about a 2 degree range of adjustability Applies to automatic transmissions without TOW HAUL mode Modifying Parameters Parameters Explanation Performance Applies to automatic transmissions with TOW HAUL Shift mode Adjusting Parameters in the Performance Adaptation section will apply only when the TOW HAUL mode is activated eu Parameterseee Shift Points Mous user to adjust at what MPH the shift should MPH take place Shift Pressure Few Limit eet ez Shift Points Mous user to adjust at what RPM the shift should Actual Wheel size RPM take place Shift Pressure Allows user to adjust the firmness of the shift action Rev Limit Allows user to adjust Rev Limit u 3 ED a Factory Wheel size Enter the factory tire size tire width aspect ratio and wheel size Actual Wheel size Enter the actual tire size tire width aspect ratio and wheel size X X XX Go to next page for NOTES Modifying Parameters Modifying Parameters Important information regarding DiabloSport Performance Tune Parameter modification k NOTE The shift point functions work in conjunction with each other based on load Use the RPM shift point function for WOT wide open throttle shifts and MPH shift point function for part throttle shifts The vehicle WILL shift at which ever point it reaches first This is dictated by load on the veh
10. ad promptly contact the distribu tor from which you purchased the Product in writing requesting a refund of the purchase price Any use of the Product by you will constitute your agreement to the terms and conditions contained herein 2 Grant Of License The parties hereto acknowledge that ToolRama is granting a non transfer able restricted license to Purchaser to use the Product for the sole purpose of installation in Purchaser s vehicle ToolRama shall retain all title ownership rights and intellectual property rights in and to the Prod uct Purchaser agrees that Purchaser shall not directly or indirectly modify translate reverse engineer decompile disassemble or create derivative works based on the Product Purchaser further agrees not 10 permit any third parties to modify translate reverse engineer decompile disassemble or create deriva tive works based on the Product 3 Disclaimer The Product is being sold with no warranties of any kind express or implied The Product is not endorsed by the manufacturer of your vehicle and there is no affiliation between ToolRama and the manufacturer of your vehicle Installation of the Product in your vehicle or use of the Product with your vehicle may limit or void your rights under any warranty provided by the manufacturer of your vehicle and ToolRama assumes no responsibility in such event Any warranty not provided herein and any remedy which but for this provision might arise by implication
11. any other venue DISCLAIMER Not legal for sale or use on any pollution con trolled motor vehicles Legal in California only for racing vehicles which may never be used upon a highway SPORT DIABLO DiabloSport LLC Predator Satisfaction Guarantee Return Policy All DiabloSport products have a guarantee of satisfaction If in the first 15 days from date of purchase you are not satisfied with the results the Predator generates in your vehicle simply restore the factory tune to your vehicle and return the Predator to the selling dealer and pending examination of the tool by DiabloSport you will receive a refund from your selling dealer Under no circumstances will DiabloSport accept the return of a Predator unit that has a factory tune remaining in The Predator will marry to the vehicle upon upload of the factory tune and cannot be re lashed for any reason back to blank tool This marrying of the DiabloSport LLC to the tool is what makes it possible for us to allow the vehicle to Predator Re Flash be re flashed by GM and still be re pro f grammed again by the Predator Re flashing Policy of the Predator is not possible with out the complete disassembly replacement and reprogramming of critical components of the Predator tool D Display and Keypad description Display and Keypad description This ig zm zimubetion of the Predator ux screen Haug the deb in Trot of MOL reading this
12. dules 3 S z E e 2 oO ED Options Section Options Section The options menu is mainly for the DiabloSport Predator Dealer It contains functions for up downloading of tunes into tool tick purchases as well as specific tool identification When you select Options the following screen will be displayed This option is used to upload download info to the PC This option shows the tools serial number This option is used to set a security password This option is used to clear the security password This option is used when user gets files from dealer This option displays the amount of ticks available This option is used to buy more ticks This option is specify price of ticks password needed This option will display Predator tool data
13. ehicles it is necessary to remove more than one fuse this will be indicated by the OnStar light still on after removal of fuse in the engine compartment fuse panel Vehicles equipped with the GM OnStar system Step Turn ignition OFF Locate the fuse panel in the engine compartment behind battery on the driver s side Carefully remove cover and locate the SEO 1 fuse Special Equipment Option Power Location may vary from illustration consult your user manual Carefully remove the fuse with the ignition OFF V SPARE SPARE EXTRACTOR sense senec aisa 3 CCC DJ melee aor S io r1 tcp P3 Coss era ez i Cc Dew be Cele Co ce ri Deje rues SS ial mar c2 ZO Ss 3 E EI OPA C Caer repe mae FOG LP L1 Les Tis rj mc ars eee vea me NOTE Replace cover after servicing Vehicles equipped with the GM OnStar system Step 2 3 Turn ignition ON look and confirm that the OnStar Dash light is turned OFF If the light is still ON continue with step 3 if it is OFF continue and install DiabloSport tune Step 3 Turn ignition OFF Locate the fuse panel located on the driver s side dashboard carefully remove cover and locate the following fuses SEO IGN Special Equipment Option Power RAP 2 Retai
14. es might sweep and various messages will be displayed in the message center This is normal so do not be alarmed Backup Ics Press Arig Een to completed COTE Mehide Data Backup hicle Installing a tune into a ve Installing a tune into a vehicle The Predator will count down 10sec until it is ok to proceed 00 NOT start the engine The predator will count down 1 until it is ok to proceed Turn kognition Off Turn lanition nl Then press up key Then press p ken i ms Ld Ss oS La gt hicle Installing a tune into a ve Installing a tune into a vehicle Vehicle Data Backup is now complete Press any key to continue Installing 0 performance tune noun mmn cte dede dede Install Performance Modify Fercformence Restore Data Trouble Select Install Performance lne Tell Fcfocamences the Tle Do you Hant to continuar Fress Enter tor YES Or Ezc for HO Installing a tune into a vehicle During the installation process the gauges might sweep and various messages will be displayed in the message center This is normal so do not be alarmed After installation is complete the Predator will prompt you to Press Enter Please wait until installation is complete This may take several minutes IOU Fress To continu SMA completed Performance sS lt S Sc oS
15. icle RPM vs MPH X NOTE Adjust only if speedometer is off due to the increase or decrease in tire size The factory GM PCM can only calculate up to a certain tire size before it will disable the traction control system however it WILL correct the speedo but the traction control system will be turned off permanently Traction Control will function once the tire size is restored to factory Select Tune It go through and read carefully the disclaimers oot be held responsie Tor wehiches with modified parameters miu are mot present to monitor the Modifying Parameters Until you get to this screen adjusted parameters therefore pam recommend that this shite be lett untouched buy inexperienced Users de rn oan mmn cte L lrn Tell Performance Modify Fercfocimenca Restore Saved Dats Troubleshooting parntocmencedor Fress Enter if you understand and agree else Esc to cuit 2 Z D a Modifying Parameters Once desired parameter has been selected its current value will be shown Make desired adjustments and select Enter to save The new value will Press Enter to make adjustments be displayed Press Esc to return to Set Parameters menu Adjust other parameters if desired using the same steps as above Modifying Parameters DECREASE INCREASE Modifying Parameters Press Enter to u
16. maral ESC Key Scroll page back to previous page Arrow up Scroll up the menu Arrow left Scroll menu to the left Arrow right Scroll menu right Use this key to view entire descriptions Arrow down Scroll down the menu Enter Key Select parameter highlighted in menu Before Installing DiabloSport Performance Tune Please read through the manual before installing tune in your vehicle failure to follow proper instructions can result in a damaged or disabled PCM Powertrain Control Module User MUST ensure that the factory stock tune is in the vehicle s PCM before installing the DiabloSport tune GM dealer re flashes are the same as stock factory tune Serious engine damage can occur if the Predator tune is installed over a non factory aftermarket performance tune Very Important Do not perform any operations on Predator expect live data diagnostics while vehicle is running The vehicle must be parked and engine OFF 3 S 3 7 S Q Q E i 3 Preparing Vehicle for DiabloSport Performance Tune Installation The vehicle MUST be running on 91 93 octane Super Un Leaded Premium grade fuel before installing DiabloSport Performance tune Amoco or Mobil Super Un Leaded Premium grade fuels are highly recommended Apply parking brake to de activate daytime running lights Always have all the doors closed while installing the DiabloSport Performance tune and remain closed untill
17. modified parameters since we are not present to monitor the adjusted parameters therefore we recommend that this should be left untouched by inexperienced users Whenever DiaboSport Performance Tune parameters are adjusted especially power enrichment and spark parameters it is very important to monitor the vehides timing and air fuel to check for detonation pinging to ensure the vehicle is operating within safe parameters Do not perform any operations on Predator expect live data diagnostics while vehicle is running The vehicle must be parked and engine OFF Modifying Parameters This feature is designed for users with extended knowledge of automotive tuning Modifying fuel and spark parameters increases risk of detonation pinging and can increase risk to the durability of the vehicle These parameters as well as others in the Predator should only be modified by an experienced tuner and should not be modified unless necessary Select Modify Performance Modify Pertormance View parameters allows user to see parameter settings Set parameters allows user to adjust parameter settings Reset parameters allows user to reset parameters back to original DiabloSport Performance tune Using the reset feature will reset ALL modified parameters back to the original DiabloSport Performance tune 2 D a Modifying Parameters Parameters Explanation Select View Parameters to della
18. ned Accessory Power Relay RDO 1 Audio System Location may vary from illustration consult your user manual Chvact_ Ciena _ BRAKE nmp ANG C Ceruse TURN LRR wer ws wer seo GN Cuun _ SE0 accy BAG MIR LOCK Lint ppc UNLOCK Carefully remove each fuse with the ignition OFF Turn ignition ON look and confirm that the OnStar Dash light is turned OFF SS Fa T 19 a DS SS T 2 5 Coc Continue and install DiabloSport tune DRV UNLOCK Vehicles equipped with the GM OnStar system Step 4 Once completed reinstall the fuses with the ignition OFF c DS S 5 5 S t CD Se DSS Installing a tune o Installing a tune into a vehicle Locate OBD II diagnostic port on your vehicle see reference picture in Section viii and ix Connect Predator into vehicle s diagnostic port and turn ignition to on position DO NOT start the engine the following screen will be displayed Controllers Tune It will take the user through the process of programming and modifying the tune for the vehicle tebe orth ede deed Tune if Diagnostics Options Diagnostics take the user through scanning erasing ET and live data monitoring Z L I Options contains tool options and troubleshooting menus i Press ESC to go to the previous
19. pload new adjusted tune The Predator will continue and install tuned file Once desired adjustments are completed Press Esc while in Set Parameters screen mim Llano Intell modified puros nance fier Fr Enter for vex Press Esd fon Mao Diagnostic Section Diagnostic Section How to check and erase the SES light The diagnostic features on this tool can check and erase SES service engine soon lights as well as monitor live data from sensors supported Select Diagnostics from main menu eee Transmission Tipet Mariel Diagnostic Section How to check and erase the SES light Select your transmission type Engine Control Unite Trouble Codes Feal Time Data Abbreviations Testing Trouble Codes Real Time Data Abbreviations Testing Select Trouble Codes Allows user to view and erase trouble codes Displays live data Displays the abbreviations used in live data This menu is used for troubleshooting only ae Too Cogaezdesedsd DTC Infection Erase DTCs Diagnostic Section Diagnostic Section How to check and erase the SES light To view the specific trouble code select DTC information DTC stands for Diagnostic Trouble Code erue mb Dets CTC All Specie OTC QTC Met Ran SCC DIC All Specific DIC Not Ran SCC View all DTC s Enter DIC to view status Displays what DTC
20. the process is complete Do not activate any electrical accessories while installing the DiabloSport Performance tune Ensure that there are no electronic devices wired or plugged into the vehicle that can cause a substantial voltage drop when activated during installation of the DiabloSport Performance tune Please contact DiabloSport dealer if uncertain about devices that are on your vehicle e Certain cellular phones or radio equipment might also cause interference please remove or turn such devices off Do not try to install tune on a vehicle with a low battery voltage charge your battery if necessary Never turn the key OFF while Predator is plugged in diagnostic port unless instructed Do not touch the cable while the Predator is installing the DiabloSport performance tune Performance Tune Installation Important note regarding DiabloSport Performance Tune Parameter modification This feature is designed for users with extended knowledge of automotive tun ing Modifying fuel and spark parameters increases risk of detonation pinging and can increase risk to the durability of the vehicle These parameters as well as others in the Predator should only be modified by an experienced tuner and should not be modified unless necessary DiabloSport will not be held responsible for vehicles with modified parameters since we are not present to monitor the adjusted parameters therefore we recommend that this should
Download Pdf Manuals
Related Search