Pizza Prep Table Refrigerators Installation and Operation
Contents
1. Jurbec TOR IUA TURER Turbo Air Speeds up the Pace of Innovation Pizza Prep Table Refrigerators Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment Full Stainless Steel Visible Exterior REFRIGERATORS TPR 44SD D2 TPR 67SD D2 TPR 67SD D4 TPR 93SD D2 TPR 93SD D4 TPR 93SD D6 www turboairinc com CONTENTS SPECIFICATIONS O ennn cece cecctccececeetcrccnenenentneneneeraanneeei 2 SERIAL NUMBER rerorecerecereceterereccecececectctcrctcnenencenetneennratannnntannetneaae 2 INSTALLATION OF CASTERS AND CASTER BRAKES ee 3 HOW TO CLEAN THE PAN AIR DUCT PANEL e 3 REMOVAL DRAWER 0r rerereeereeerererecececectctcrctrnrectenetetetnrntntntntneeeteteeiai 4 TO ACCESS THE FAN MOTOR i 1 11111111141114111 111111111 ttan tintet ettn ettn stanset setne etane 4 HOW TO OPEN AND CLOSE THE HOOD LID Htt 4 INSTALLATION mee 5 BASIC OPERATION 11 111111111111111111111115tt1 151151 rtt ettn ttn stt ett ettare tet renata ttn 5 CLEANING nneeererececccecececrcrcticececrcrccenceererceneneerannenenenennneneneanntnenenesiia 6 CAUTION ee S 6 TROUBLESHOOTING SNe 7 WARRANTY AA 8 10 SPECIFICATIONS Pizza Prep Tables ee a pee ed en ee eb ee TPR 44SD D2 lt 115V 60Hz R 134A 321 Ibs TPR 67SD D2 115V 60Hz 561lbs TPR 67SD D4 115V 60Hz 572lbs TPR 93SD D2 115V 60Hz 711lbs TPR 93SD D4 115V 60Hz R 404A 11A 722lbs TPR 93SD D6 115V 60Hz R 404A 11A 733lbs2. LID 1 When opening HOOD LID push forward away from you till locked in place at lid bracket 2 When closing HOOD LID lift handie and pull up and close slowly INSTALLATION 1 GOOD AIR CIRCULATION Do not place any object that will restrict air flow in front or back grills Turbo air highly recommends that there is ample space in rear of unit 5 inches or more is best 2 PLACE ON STRONG GROUND Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents 3 DO NOT PLACE NEAR HEAT Be sure to avoid hot corners and locations near stoves High ambient temperature will make cooling efficiency lower 4 INDOOR USAGE ONLY Be sure to install this unit indoor so it will not get wet from the rain 5 STABILIZING Make sure the unit is installed in a stable condition with the front wheels locked while in use 6 LEVELING Be sure that the unit is level from front to back and side to side 7 UNIT SHOULD BE ON DEDICATED OUTLET BASIC OPERATION 1 The controller thermostat is located at the right inside of the unit 2 The factory setting for the control is Normal and maintains about 38 F 3 C inside 3 Set toward Cool for higher temperature and Cold for lower temperature 4 The thermostat controls compressor s cycling by sensing inside temperature 5 When unit will not be used for a long time turn the power switch off located under the thermo
3. SERIAL NUMBER The serial number is located on the rating label which is on the left interior wall Please retain the unit s serial number for service purpose 2 INSTALLATION OF CASTERS AND CASTER BRAKES 1 Screw the caster in rear side and the caster brakes in front side by using caster wrench 2 Use the caster shims to level the cabinet if necessary by inserting them to stems of the casters CASTER WITH BRAKE 2EA CASTER 2EA 63 HOW TO CLEAN THE PAN AIR DUCT PANEL The Pan Air Duct Panel is y HOOD LID located under pans N 7h wat PAN k i ita 1 Remove all pans 2 Clean the PANEL with cloth and warm water When cleaning where pans are located or putting and removing food be careful that hood lid is in lid brackets correctly so it will not fall 3 Drawer Pan Capacity Each drawer accommodates 12 1 6 size L 67 8 x W 61 4 x H 4 and 8 food pan sold seperately REMOVAL DRAWER Fully extend the drawer out toward you as pictured After full extension lift the drawer up and pull towards you This will disngage the rollers from the roller guide TO ACCESS THE FAN MOTOR 1 Remove the drawer guide by removing screw in the front and back 2 After removing the drawer guide the evaporator duct shroud will be accessi ble Remove the screws from the shroud and then remove shroud The fan motor will be direct behind it HOT TO OPEN AND CLOSE THE HOOD
4. or and other electrical components etcetera 404A 134a Compressor Warranty The five year compressor warranty detailed above will be void if the following procedure is not carefully adhered to 1 This system contains R404A or R134a refrigerant and polyol ester lubricant The polyol ester lubricant has rapid moisture absorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A620 copper drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained When compressor is grounded suction drier and 620 drier or better must be replaced 5 Compressor must be obtained through Turbo Air unless otherwise specified in writing through Turbo Air s warranty department aN 404A 134a Compressor Warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE REGARDLESS OF WHETHER OR NOT THEY RESULT FROM REFRIGERATION FAILURE WARRANTY IS NOT TRA
5. NSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANNTIES HEREIN AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR LABOR COVERAGE FOR COMPONENT FAILURE OR OTHER THE WARRANTY PACKET PROVIDED WITH THE UNIT ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FOOD ACTS OF GOD Turbo Air is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of GOD IMPROPER ELECTRICAL CONNECTIONS TURBO AIR IS NOT RESPONSIBLE FOR THE REPAIR OR REPLACEMENT OF FAILED OR DAMAGED COMPONENTS RESULTING FROM ELECTRICAL POWER FAILURE THE USE OF EXTENSION CORDS LOW VOLTAGE OR VOLTAGE DROPS TO THE UNIT NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESSED IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR PARTS amp LABOR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF Outs
6. OR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE CLAIMS WHETHER OR NOT ON ACCOUNT OF REFRIGERATION FAILURE 3 ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD TURBO AIR is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or an Act of God 4 NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESS IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF 5 TRANSPORTATION COSTS Turbo Air will accept parts covered under this warranty freight collect provided that shipment has received prior approval Turbo Air is not responsible for any other transporation costs but will ship freight collect pars either repaired or replaced under these warranties 6 WARRANTY CLAIMS All claims should include model number of the cooler the serial number of
7. after shipment date from Turbo Air whichever occurs first Any part covered under this warranty that are by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Two Year Compressor Warranty In addition to the three 3 year warranty stated adove Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s discretion be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly
8. e is not carefully adhered to 1 This system contains R134A refrigerant and polyol ester lubricant The Polyol ester lubricant has rapid moisture absorbing qualities If long exposure to the ambient conditions occur the lubricant must be removed and replaced with new Listed below are the approved lubricants for the Tecumseh compressors 1 ICl Emkarate RL 184 2 Emery 2927 A 3 Mobile Artic 22A Failure to comply with recommended lubricant specification will void the compressor warranty 2 Dryer replacement is very important and must be changed when a system is opened for servicing dryer must be used with XH 9 desiccant 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must obtained What is NOT covered by this warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than expressly covered by this warranty 1 WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANTIES HEREIN MADE AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE 2 NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE F
9. er cord whenever performing maintenance functions or cleaning the refrigerated cabinet Compressor warranties are void if compressor burns out due to low voltage 2 RE STARTING If disconnected wait 5 minutes before re starting 3 POSITIONING FOOD Do not obstruct the air inlet which is located at the right inside of the unit Check the gap between the air inlet and food etc whether above 3 inch or not TROUBLESHOOTING SYMPTOMS CAUSES Refrigerator Freezer The setting temperature is too is freezing melting low high to maintain food food freshness The unit does not There is a power connection e Check the power cord to make sure refrigerate at all failure problem the unit is pluged in it correctly e Move out of sunlight or away e The unit is in sunlight or near a heating device SOLUTIONS Turn the temperature dial to a warmer colder setting e The unit contains hot food or too Check the condition of stored The unit does not much food refrigerate well e The unit door is opened too frequently or left open too long The temp dial is not on the correct position e The condenser is clogged The floor is too weak or the leveling feet are set incorrectly The backside of the unit is too Close to the wall e The tray is not in the correct position There is a loud noise There are dew drops High moisture air can produce Wipe with a dry cloth on the unit e
10. ide U S and Canada This warranty does not apply to and Turbo Air is not responsible for any warranty claims made on products sold or used outside the continent of the United States and Canada New Extended Warranty policy applies to all units sold by Turbo Air starting Dec 1 2012
11. on under the foregoing warranties by electing either one of the following procedures at the sole discretion of Turbo Air 1 Furnishing a replacement part freight collect in even exchange for the returned part freight collect 2 Receiving the defective part freight collect repairing it and returning it freight collect ADDITIONAL TWO YEAR COMPRESSOR WARRANTY In addition to the three 3 year warranty stated above Turbo Air warrants its hermetically and semi hermetically sealed compressor to be free from defects in both material and workmanship under normal use and service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from manufacturer Compressors determined by Turbo Air have been defective within this extended time period will at Turbo Airs option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically and semi hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly any other electrical component etcetera 134A 404A COMPRESSOR WARRANTY The five year compressor warranty detailed above will be voided if the following procedur
12. stst knob NORMAL f thermostat knob is pointing at OFF compressor and condenser fan motor would not run Keep unit unplugged if not in use for a long period of time Temperature Controller Thermostat CLEANING Before cleaning turn unit off at power switch 1 CLEANING THE INTERIOR AND EXTERIOR The interior and exterior of the unit can be cleaned using warm water with soap Do not use an abrasive cleaner because it will scratch the surface 2 CLEANING THE CONDENSER FINS To maintain proper refrigeration performance the Condenser coil must be free of dust dirt and grease This will require periodic cleaning Condenser fins should be cleaned at least every three months 90 days or as needed To clean condenser unplug at power cord Condenser can be cleaned with vaccum brush or CO high pressure air 3 CLEAN THE GASKET The door gasket should be cleaned frequently to maintain proper sealing 4 CLEAN THE DRAIN PAN Empty the Drain Pan which is located under the unit periodically When reinstalling Drain Pan make sure Drain Hose is placed back in pan 5 CHECK AFTER CLEANING Plug unit back in and turn on power switch Check that the unit is operating properly CAUTION 1 POWER CORD Be sure the power cord is connected to the proper voltage A protected circuit of the correct voltage and ampere must be run for connection of the line cord Turn off the power switch before disconnecting the pow
13. the cabinet proof of purchase date of installation and all pertinent information supporting the existence of the alleged defect Any action or breach of these warranty provisions must be commenced within three 3 year after that cause of action has accrued hurbe TOR PUN TURER 4184 E Conant St Long Beach CA 90808 TEL 310 900 1000 FAX 310 900 1077 TOLL FREE 1 800 627 0032 U S A amp Canada Website www turboairinc com Warranty Claims All claims for parts or labor must be made directly thorough Turbo Air All claims should include model number of the unit the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the alleged defect In case of compressor replacement under warranty either compressor or compressor tag must be returned to Turbo Air along with above listed information Failure to comply with warranty policies will result in voiding claims Three Year Parts amp Labor Warranty Turbo Air warrants all new refrigerated components the cabinet and all parts to be free from defects in materials or workmanship under normal and proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in accordance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty is limited to a period of three 3 year from the date of original installation or 39 months
14. xterior dewdrops during rainy seasons e Keep the door closed to remove dewdrops The door is opened too frequently or left open too long e Damp food is stored There are dew drops on the unit interior The door is bent The unit is not level The door gasket has come out The door does not close tightly The following points are not malfunctions A water flowing sound can be heard when the compressor stops This is the sound of REFRIGERANT flowing The compressor does not run during the defrost cycle e Check the installation and adjust the tray position e Level the unit again e Reposition the gasket e Check the position of the temp farbo Bir MANUFACTURING COMPANY THREE YEAR WARRANTY Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal use and service for a period of three 8 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any parts covered by this warranty that are examined and determined by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first shall be repaired or replaced as stated below Turbo Air shall be deemed to have fully complied with its obligati
Download Pdf Manuals
Related Search