Hydromist Compact Manual
Contents
1. 24 23478 pas pp 26 35589 LZ 35986 28 3597 ps 3598 s0 f 3599 i E 32 s59 33 3592 L A 35998 35 359906 36 35908 ar 35998 as 3600 3 36001 40 36002 KZ E mm 42 3600 e seon s 36012 45 36013 46 36049 ar 360158 4 360565 ss 36018 poso 36028 51 36020 LS 3601 53 2349858 54 36059 55 Two23055 56 43202 57 43203 sa Kaes Es ss 43207 ps pp EE 62 4322 6 4323 L S 53409 p 65 362 66 36107 LPL 432021 MA pr 69 Twoos014 po 36183 LZ 36053 72 twoor2i0 73 Ttwoiw20 74 Ttwo20017 75 23708 zes 360838 _ 77 Two33069 pa 11 Current Part Number 02 3771 0000 03 6044 0000 05 3417 0000 05 3418 0000 05 3419 0000 05 3420 0000 05 3421 0000 05 3422 0000 05 3423 0000 05 3427 0000 03 6066 0000 05 3717 0000 02 3381 0000 02 3480 0000 04 0221 0000 04 3332 0000 05 3502 0000 05 3519 0000 05 3557 0000 05 3728 0000 05 3496 0000 05 3497 0000 03 6642 0000 03 6643 0000 03 6653 0000 03 6654 0000 03 6664 0000 04 3396 0000 03 6692 0000 05 3793 0000 02 3433 0000 Drawing Ref 78 Original Part Number TW065063 3 6044 5 3417 5 3418 5 3419 5 3420 5 3421 5 3422 5 3423 5 3427 3 6030 5 3717 2 3381 2 3480 4 221 TW023046 5 3502 5 3519 5 3557 Description Clip Stee2. storage purposes the handle can be lowered by hinging it forward after releasing the locking screws IMPORTANT Ensure locking screws are withdrawn into the handle tube before moving the handle 4 Operation 4 1 Starting the machine e Connect the cable to mains power e Switch on the vacuum motor and brush drive 4 2 Using the machine e Operate spray lever on handle to dispense the cleaning solution whilst pulling the machine slowly backwards to clean the carpet Stop spraying cleaning solution about 30cm 12 before end of cleaning pass to ensure all solution is vacuumed up Wheel the machine forward and repeat slightly overlapping the previous pass Do not clean any area more than twice or overwetting could result in carpets shrinking After a few passes check recovery tank for presence of foam If foam is present either add defoamer or if using an all in one product empty the recovery tank rinse out and continue checking regularly for foam build up WARNING Should water emit from the machine switch off immediately and empty the recovery tank e When solution spray ceases the solution tank is empty Switch off the machine empty the recovery tank and refill the solution tank IMPORTANT Ensure recovery tank is emptied whenever solution tank is filled e IMPORTANT Do not run the pump motor when the solution tank is empty as this will damage the motor 5 Using accessory tools Accessory tools may be u
3. disconnect solution hose from the connector on the front of the machine Remove drain hose from the back of the machine and fit to connector Direct free end of hose into a bucket or drain and switch on the accessory spray switch This will drain the remaining liquid from the tank Finally add approx Ye litre 1 pint of clean water to solution tank to flush out the tank and pump Switch OFF and unplug the machine With both water tanks empty the machine may be titled backwards to rest on the handle to facilitate cleaning Clean underside of machine with a damp cloth to ensure that any carpet debris is removed especially in the area surrounding the brush and bearing assemblies Build up of damp dirt and carpet fibres in this area can lead to early bearing failure 6 2 Storage e Always unplug empty wipe down and dry the machine after use e Wrap supply cord around the handle ensuring that the plug is not trailing on the floor Store the machine in a dry indoor area only 6 3 Maintenance WARNING Before undertaking maintenance operations or adjustments switch off machine and unplug from the electricity supply The machine requires minimum maintenance apart from the following checks by the operator e Supply cord Regularly inspect sheath plug and cord anchorage for damage or loose connection e Solution tank Check filter is clean and undamaged A damaged or missing filter must be replaced or damage to pump head
4. HMCO1010 out of your carpets and helps 5 litre 4 HMC01050 prevent re soiling Leaves carpets and upholstery soft and fresh Hydromist Pre 500ml 10 HM003005 Formulated to help remove spotter trigger stubborn stains from carpet and spray upholstery IMPORTANT Genuine accessories and chemicals are only available from authorised Service Agents or the Truvox Customer Service Department 12 Fault Diagnosis WARNING Before undertaking maintenance operations or adjustments switch AN off machine and unplug from the electricity supply Problem Reason Remedy Machine not working switches not illuminating Lack of voltage electrical supply Check fuse supply cord plug and socket outlet Poor water recovery e Vacuum head blocked e Remove obstruction e Vacuum hose obstructed e Remove obstruction e Blocked suction filter e Clean filter e Damaged gasket on recovery tank e Replace gasket lid e Replace gasket e Damaged gasket on vacuum motor lid Brush not revolving e Brush jammed by debris e Remove debris e Broken drive belt e Refer to Service Agent e Motor overload cut out operated e Reset cut out No solution spray e Empty solution tank e Refill solution tank from jet e Blocked solution tank filter e Clean filter e Blocked spray jet e Remove spray jet and clean Pump failure e Refer to Service agent If the fuse blows several times the machine should be checked by a
5. SS 00 0400 0511 00 0400 0723 4 Rectifier Spring Washer ilter Support Tube Stainless Steel Nyloc Nut CHAMP COMPACT UPHOLSTERY TOOL 5 3406 5 3429 05 3406 0000 05 3429 0000 pholstery Tool Complete pholstery Hose Assembly 2 3471 02 3471 0000 02 3545 0000 02 3771 0000 03 6029 0000 03 6423 0000 04 3046 0000 97 0213 0000 acuum Hose etal Fluid Coupling rimp Clip lose Bag olution Hose lastic Ties Ipholestry Tool TW065063 3 6029 TW065064 4 3046 RX000752 w SNE lo 12 TRUVOX INTERNATIONAL DRAWING PART No 4 SHEET 1 OF 09 1010 0000 A4 yes Truvox International Ltd Customer Services 023 80706600 General Enquiries 023 80702200 Third Avenue Millbrook Service amp Spares 023 80706601 Southampton Hampshire S015 OLE HH O Es o O O C E LI 5 GG Q 8 gt E Ir om Q o o zT Es Q H 5 H o Fa DED WING cu Se di EM 108 A 1 ODIFIED NEW DRA ITEM 106 ADDED ITEMS 104 128 142 141 01 03 09 02 06 05 13 14 Declaration of Conformity Declaration of Conformity We Truvox International Ltd of Third Avenue Millbrook Southampton Hampshire England S015 OLE declare that the machinery Make Carpet Soil Extraction Machines Type Hydromist Model HC250 Serial Number from 000001 Year of Construction 2010 has been manufactured using the following transposed harmonised European Standards and technical spec
6. e Ensure the machine is switched off before adding or changing accessories 1 3 Transporting the machine CAUTION Incorrect lifting techniques may result in personal injury where applicable do not lift large and heavy machines without assistance We advise that the manual handling regulations are followed Please refer to the technical table for details on weight of machine When transporting the machine ensure that all components tanks and removable parts are securely fastened and that the supply cord and plug are not trailing Detach hose and wand from machine where applicable Do not lift or transport the machine whilst containing liquid as this will add considerably to the weight Take extreme care when moving the machine up or down steps or stairs 1 4 Electrical connection Before connecting the machine to the power supply check that your supply voltage corresponds with that marked on the rating label The power supply cord plus any extension leads should not exceed 30m in total otherwise you may experience problems starting up the machine The cross section of any extension cable wiring must be at least 2 5 mm Should an extension cord be used ensure cord rating is adequate for the equipment Do not use extension cord in coiled condition as this could result in overheating of the cord UK only The supply cord for 230v models is fitted with a plug containing a 13 amp fuse Should the fuse require re
7. subject to the following conditions CONDITIONS 1 Claims made under the terms of the guarantee must be supported by the original invoice bill of sale issued at the time of sale or the machine Serial Number 2 For claims under this guarantee contact the supplier from whom you purchased the product who will arrange the appropriate action Do not initially return the product as this could result in transit damage 3 Neither Truvox nor its distributors shall be liable for any incidental or consequential loss 4 This guarantee is governed by the laws of England This guarantee does not cover any of the following Periodic maintenance and repair or replacement of parts due to normal wear and tear 5 This guarantee is governed by the laws of England This guarantee does not cover any of the following Periodic maintenance and repair or replacement of parts due to normal wear and tear e Damage caused by accident misuse or neglect or the fitting of other than genuine Truvox parts e Defects in other than genuine Truvox parts or repairs modifications or adjustments performed by other than a Truvox service engineer or authorised service agent e Costs and risks of transport relating directly or indirectly to the guarantee of this product e Consumable items and wear parts such as drive belts This guarantee does not affect your statutory rights nor your rights against the supplier arising from their sales or purchas
8. 0 0412 0011 00 0500 0521 00 0600 0513 00 0400 0503 02 3464 0000 02 3465 0000 02 3466 0000 02 3467 0000 00 0412 0013 02 3484 0000 00 0410 0091 00 0403 0091 00 0400 0701 02 3493 0000 00 0516 0011 00 0520 0011 00 0525 0011 00 0500 0701 00 0510 0031 00 0500 0701 00 0500 0503 4 Rectifier Screw 5 Shakeproof Washers for Bonding Screw 6 Spring Washers Stainless Motor Mount ilter Support Tube Stainless Steel Washer crew for P Clip oto Small Tapper oto Intermediate Tapper oto Large Tapper 14x12 Pozi Pn Hd ss Screw 6 Handle Insert rush Pulley Grub Screw otor Pulley Grub Screw ut for Nylon Screw eflector Plate Peel Rivet able Restraint Bolt ectifier Bolt arth Bonding Screw ectifier Nut rush Motor Retainer able Restraint Nut 14x12 SS Washer M5 R ZN M6 P SS M4 OLG SS 2 3464 2 3465 2 3466 2 3467 eh N ps 2 3484 M4 10 XB M4 3 XB M4 1 ZN 2 3493 M5 16 CP ZN M5 20 CP ZN M5 25 CP ZN M5 I ZN M5 10 BP ZN M5 1 ZN i 00 0400 0513 05 0010 0011 00 0500 0511 00 0830 0113 00 0840 0126 00 0612 0013 00 0410 0113 00 0800 0553 00 0800 0513 lousing Spring Washer rush Motor Retainer ectifier Spring Washer ick Up Bolt jandle Pivot Bolt 6 Motor Mounting Screws ilter Support Tube Stainless Steel Hex Screw 8 Pick Up Mounting Washers 8 Spring Washers Stainless Pick up Mount M5 10 CP ZN M5 P ZN M8 30 E SS M8 40 E B M6 12 CP SS M4 10 E SS M8 OHG SS M8 P SS Es M4 P ZN M4 LN
9. ORIGINAL INSTRUCTIONS CAUTION READ THESE INSTRUCTIONS BEFORE USING THE MACHINE User instructions Hydromist Compact Carpet Soil Extraction Machines 03 6066 0000 Iss 2 04 10 Contents 4 10 11 12 13 14 Prod ct Information A A iD 4 1 1 Important Safety Advice uuussnsnsnsnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn nn 4 1 2 Guidelines for the operaior ann 5 1 3 Transporting the Machine nenn 5 1 4 Electrical COMMECHION osiin i e ie aia 5 1 5 Symbols amp Markings 4444440ssnnnnnnnnnnannnnannnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn ann 5 A EE 6 Preparing bt e 6 EA e lee DINN TEE 6 Ope AT O TTT 6 4 1 Starting au Ee VTT 6 4 2 USING the machine session 6 USING ee ein Ate E 6 palk Cleaning N T Il o1 URFRPRIPTRIPERFEPESETETFTFTRTRPEPRPPEETFTLTETERFERPRERTLTRTEISERTPIRERTLTETTERERTREGERERTETFTRTRTREPFRTRTFTFTET 6 5 2 Cleaning Mitos 7 5 3 Cleaning Upbolstenm eect ee cccee tees eee et cca a ease nn cnn nan n rra nr n nn rra nana rn nr cnn nn rra nnnnnn nan 7 When Cleaning is Finished 44440snnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn 7 6 1 Draining and Cleaning ooocooccccnnncccnnncoonnccnnnnconnnnnnnnncnnnncnnnnnn nn nn cnn nn nr nana rn nn cnn rr nena nr r rancia 7 o A nee nee bee ne aa Ha nea anal eee 7 ECO 7 After Sales Service uuuuussssnssnnnnnnnnnnnnnnnnnnnnnnunnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn
10. ance with the manufacturer s instructions If in doubt contact the supplier of your machine These instructions are valid for the following models Hydromist Compact 1 1 Important Safety Advice When using electrical equipment basic safety precautions should be followed including the following e Read all instructions carefully before use e This appliance is suitable for commercial use for example in hotels schools hospitals factories shops offices rental businesses and other than normal housekeeping purposes This machine is not intended for use by persons including children with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning use of the machine by a person responsible for their safety Keep children and unauthorised persons away from the machine when in use Before using the appliance check that the mains power voltage corresponds with the voltage shown on the rating plate e All parts are to be positioned as indicated in the instructions before using the machine e Do not operate the machine if it malfunctions or is damaged in any way Contact an authorised service agent for repair or adjustment Do not operate switches or touch the mains plug with wet hands as this may cause electric shock When unplugging pull the plug not the supply cord Do not pull or carry by cord use cord as a handle clo
11. and spray jet could occur e Vacuum head Check and remove any debris or lint build up from the head e Spray jet Check jet for blockage and full spray pattern Blow through jet to clean Do not use a pin as this could damage the jet IMPORTANT All other servicing and repairs should only be performed by a Truvox engineer or Authorised Service Agent 7 After Sales Service Truvox machines are high quality machines that have been tested for safety by authorised technicians It is always apparent that after longer working periods electrical and mechanical components will show signs of wear and tear or ageing Under extreme or specialised conditions and or insufficient maintenance shorter maintenance intervals are necessary Use only original Truvox spare parts Use of other spare parts will invalidate all warranty and liability claims Should you require after sales service please contact the supplier from whom you purchased the machine who will arrange service Repairs and servicing of Truvox products should only be performed by trained staff Improper repairs can cause considerable dangers to the user 8 Guarantee Your product is guaranteed for two year from the date of original purchase or hire purchase against defects in materials or workmanship during manufacture Within the guarantee period we undertake at our discretion to repair or replace free of charge to the purchaser any part found to be defective
12. d overbalancing 1 2 Guidelines for the operator WARNING Operators must be fully trained in the use of the machine in accordance with these instructions able to perform user maintenance and the correct selection of accessories e Operators should be physically capable to manoeuvre transport and operate the machine Operators should be able to recognise unusual operation of the machine and report any problems Only use the machine on firm level surfaces Wear suitable footwear to avoid slipping Wear suitable clothing to keep dry and warm Where possible implement job rotation and adequate rest periods to avoid continuous use of the same muscles Do not leave machine running unattended Do not smoke when using the machine Do not put any objects into openings Do not use with any opening blocked keep free of dust debris hair or anything that may reduce air flow CAUTION This machine is for indoor use only and should not be used or stored outdoors or in wet conditions CAUTION If it is suspected that there is hazardous dust or flammable materials stop cleaning the area immediately and consult your superior WARNING Only use accessories and spare parts provided with the machine or those approved by the manufacturer The use of other accessories may impair the safety of the machine WARNING Should water emit from the machine exhaust switch off immediately and refer to instructions for Using the Machine gt PEP
13. e 3 6018 hamp Compact Switch Label 3 6038 rush Motor Mounting Bracket 3 6020 ac Lid Seal 3 6021 ater path deflector plate 2 3495 ulley End Brush Spacer 3 6059 rotected Bearing Housing TW023055 mall Black P clip 4 3202 landle Switch 4 3203 rush motor eplacement Motor Brushes Brush Motor 04 3203 0000 ac Motor 116110 01 4 3207 witch with cover C250 Solenoid Pump C250 0 7Amp Cut Out 4 3212 able gland 4 3213 able gland back nut 5 3409 iring kit 230volt Not Shown 3 6132 C250 Vac Motor Cover Outer Seal 3 6107 C250 Vac Cavity amp Motor Seal 4 3221 C250 Suppressor olution Drain Hose TW005014 ilter Element 3 6133 C250 Vac Motor Cover Inner Seal 3 6053 acuum Lip Seal TW007210 ectifier Brush Motor TW011120 ed nylon tube TW020017 ord set 2 3708 hite P clip Internal Cable Restraint 3 6043 ump Outlet Hose TW033069 ubilee clip o nln s o o Sojo gt oJo gt gt 0 0 gt gt 2 gt gt gt gt 0 gt gt gt gt 9 gt gt gt 0 2 2 2 9 st eis els t l n uju 3 v o pe mn Di N NI Kai Ki Es E 3 gt D D LL 2265 LZ 230991 RECH 224 ps 36080 5 23161 e 23152 7 23417 ps psa 23443 to 23485 MA 23447 LZ 2349 LS 23487 pts 23452 15 23454 16 23453 ptr 23455 P18 36041 ts 23457 20 23459 21 23460 22 23068 23 23169
14. e contract 9 Waste Electrical amp Electronic Equipment WEEE Do not dispose of this device with unsorted waste Improper disposal may be harmful to the environment and human health Please refer to your local ee waste authority for information on return and collection systems in your area 10 Technical specification All models 230 240 V 50 Hz Class construction Enclosure to IPX4 Fitted with 12m supply cord and 13A fused plug Hydromist Model compact Code HC250 Voltage AC Frequency V Hz 230 50 60 Pump pressure Bar max 1 5 Vac motor W 1200 Brush width cleaning width cm 24 5 Solution tank capacity litres 14 Recovery tank litres 11 5 Sound pressure level dB A 73 Cable length m 12 Size L x W x H cm 54 x 36 x 87 Weight empty kg 22 5 Warranty 1 year Truvox International is a BSI Registered Company and our policy is one of continuous development We reserve the right to change specifications without prior notification 11 Accessories and Cleaning Chemicals Accessory Part no Usage Accessory kit for Hydromist 05 3406 0000 Comprising bag hose and Compact upholstery tool Wand 05 3679 0000 Heavy duty wand Chemical Bottle size Bottles Part No Usage per case Hydromist 500ml 10 HMCO1005 The quality way to beautify Carpet Cleaning carpets and upholstery Solution Formulation lifts dirt and stains 1 litre 10
15. e is stable and cannot overbalance possibly causing injury to either operator or third party Use the optional stair upholstery tool for cleaning in place of the wand assembly 5 3 Cleaning Upholstery This is done in the same way as carpet cleaning except using the optional upholstery tool in place of the wand assembly Cleaning is achieved using a gentle dragging motion of the upholstery tool over the material e An inconspicuous area of the item to be cleaned should always be tested for colour fastness prior to cleaning Should doubt exist as to the suitability of the fabric for wet cleaning the chemical manufacturer should be consulted for advice Loose cushions should be cleaned separately e Care should be taken to avoid over wetting the fabric removed and 6 When Cleaning is Finished 6 1 Draining and Cleaning e When cleaning is finished run vacuum motor for approx 2 minutes to allow residual water in the system to be fully sucked into the recovery tank Failure ti do this may result in a small quantity of water being discharged from the machine It can also shorten the life of the vacuum motor as residual water can damage the bearings Disconnect vacuum hose and lift off recovery tank Remove transparent cover and pull off filter Empty the dirty water rinse out tank with clean water to remove dirt and sediment Clean and refit filter and cover and replace tank e To empty liquid from the solution tank
16. ifications Ref No Title 2006 42 EC Machinery Directive and subsequent amendments 2006 95 EC The Low Voltage Directive and subsequent amendments BS EN 60335 1 BS EN 60335 2 68 2004 108 EC The EMC Directive and subsequent amendments EN61000 3 2 EN61000 3 3 EN55014 1 EN55014 2 Signed in SOUTHAMPTON England on the 29 day of December 2009 Signature pu Name David Overell Technical file Hydromist Compact Iss 1 Position Managing Director Mark Campbell Product Support Manager 14 15 Authorised dealer Truvox International Limited Third Avenue Millbrook Southampton Hampshire SO15 OLE England Tel 44 0 23 8070 2200 Fax 44 0 23 8070 5001 e mail truvox truvox com Web www truvox com 16
17. l prayjet Hose ick Up Assembly Includes 36 20ff 47 ac Motor Cover Assembly Includes 29 65 70 71 126 7 off jandle Assembly Includes 19 20ff 20 35 55 30ff 83 124 3off 129 30ff landle Switch Assembly Includes 43 56 ecovery Tank Assembly Includes 30 37 46 48 51 52 95 123 133 148 153 rush Motor Assembly Includes 15 57 131 eplacement Brush amp Drive Assembly Includes 16 23 27 34 53 54 103 108 130 rain Hose Assembly Includes 12 68 78 ultilingual User Instructions Not Shown C250 Recovery Tank Lid Assembi teel O Clip etal Elbow mall Plastic Ties Not Shown erminal Block 30volt Spare Vac Motor Assembly Motor complete with flying leads id Chain Assembly C250 Outlet Boss Repair Kit C250 Bottom Cover Kit Includes 100 31 104 102 13 14 C250 Vac Cavity Upgrade Kit Not Shown C250 Vac Cavity Upgrade Kit amp 230v Motor Not Shown rush Cavity Guard rush End Bearing Caps ottom Cover Edge Seal rush Axle Spinner xhaust Port Spinning C250 Solenoid Pump Thermal Overload ower Vacuum Motor Seal C250 Complete Vac Lid Assembly djuster Arm Wheel Side Spacer 5 3496 5 3497 es 78 80 81 82 8 84 85 86 89 90 a 92 93 94 95 98 _ 98 99 400 401 102 103 104 105 106 108 109 110 120 121 122 123 124 125 126 127 128 129 130 0
18. n authorised Service Agent 10 13 Parts Lists amp Diagrams HydroMist Compact 250 Service Parts List Model Ref HC250 Service Parts List Issue 7 Dated 01st June 2010 Ref Drawing 09 1010 0000 Issue E Dated 17 11 2004 Drawing Original Part Description Ref Number Number 2 265 ilicon hose 2 3121 heel with Cap tarlock washer 3 6080 ecial Wheel Cap Water Blue 2 3151 lip cable restraint 2 3152 able restraint 2 3417 jon Washer Po 2 3443 8 male barb 2 3445 letal Bulkhd Coupling 2 3447 letal Male Coupling 2 3449 letal Drain Hose Connector 2 3487 ed Spray Nozzle Assembly 2 3452 pray Nozzle Retaining nut 2 3454 lotor Pulley 2 3453 rush Pulley 2 3455 tush Drive Belt 3 6041 eed to Pump Hose 2 3457 ube End Cap 2 3459 andle Grip 2 3460 andle lock knob 2 3468 ac pick up hose 2 3469 lon Brush Spacer 2 3478 ump Out Hose Clips sl 3 5589 heel spacer 3 5986 earing Housing 3 5987 ack Electrical Cover 3 5988 ac motor cover 3 5989 ac Lid C250 Bottom cover 3 5991 xle retain brackets 3 5992 luid Coupling Bracket 3 5995 rush Bod 3 5996 andle 3 5998 ick up Strip 3 5999 ilter element waste tank 3 6000 le 3 6001 ectifier heat sink 3 6002 hamp Compact Label 3 6009 asket Strip Bck bot cvrs Pump Strips 3 6010 asket bot 10mm pads 3 6011 hamp Compact Sprayjet Label 3 6012 hamp Compact Pictorial Label 3 6013 olution Tank Jet Black 3 6014 ecovery Tank Water Blue 3 6015 ick up Water Blue 3 6056 ilter Support Tub
19. nnnnnnnnnnnnn anne 8 QUA A A A A 8 Waste Electrical amp Electronic Equipment WEEE oooonnncccccccnnnccccnnccccnccnnnncnnnnn non cncnnn co nannnnn nn 8 Technical epechicatton nc ttnn nn nan nnnnnn anna nn r anna cn nn rannnnn rn 9 Accessories and Cleaning Chemicals oocoonnncocccccnnnccconnnanoncnnnnncnnnnnn conc cnn nn nnn nan n nr cnn nn rra nnnnnnnne 9 UA E sr een ea a 10 E A A a 11 Declaration of Contomtv nn 14 IMPORTANT BEFORE USE READ THESE INSTRUCTIONS AND RETAIN FOR FUTURE REFERENCE 1 Product Information The Hydromist range of carpet soil extraction machines are designed for the efficient cleaning of carpets and upholstery We recommend that any user not familiar with carpet cleaning should read these user instructions fully before using the machine If you have any queries please contact the supplier who you purchased the machine from or Truvox International on the contact details provided at the back These machines must only be used for the manufacturer s approved application Do not use the machine where it is suspected that the carpet floor or upholstery contains health endangering dust or debris such as asbestos or chemical waste If this is suspected do not proceed contact your supervisor supplier or Truvox International for advice The following instructions contain important information about the machine and safety advice for the operator Equipment must be operated serviced and maintained in accord
20. placement it must only be replaced by a 13 amp fuse conforming to BS1362 and the fuse cover must be refitted If the fuse cover is lost the plug must not be used until the correct replacement cover is fitted IMPORTANT If the supply cord is damaged it must only be replaced by a special cord available from the manufacturer or an authorised service agent WARNING THIS APPLIANCE MUST BE EARTHED 1 5 Symbols amp Markings WARNING Earth symbol 2 Controls The machine control switches are located on the top of the machine They are illuminated when in the ON positions Fig 1 Fig 1 1 Vacuum motor switch extracts dirty water from carpet into recovery tank 2 Brush drive switch Operates the rotating brush 3 Accessory spray switch Pumps cleaning solution to accessories Must be switched on when using wand or upholstery tool 4 Spray operating lever Sprays cleaning solution onto carpet 5 Cut out reset button Cut out operates when brush motor is overloaded Press to reset after motor has been allowed Fig 2 Fig 2 3 Preparing for use WARNING Before undertaking DA assembly or changing of accessories tools switch off machine and unplug from the electricity supply 3 1 Securing the handle The working position of the handle is raised It must be fixed in position by means of the locking screw on either side which must be inserted and tightened before use For transportation and
21. se a door on cord or pull around sharp edges or corners Keep hair loose clothing fingers and all parts of body away from openings and moving parts Keep cord away from heated surfaces Do not use where hazardous dust is present Do not use in an explosive atmosphere Do not pick up oil or other flammable material Do not use to pick up moisture or any liquids Do not leave the machine connected to the electricity supply when not in use always remove the plug from the socket outlet Switch off the machine before removing the plug Keep the power supply cord clear of moving parts During operation hazard may occur when running the machine over the power supply cord The power supply cord must be regularly inspected for signs of damage If the power supply cord is damaged it shall only be replaced by the manufacturer its service agent or a similar qualified person in order to avoid a hazard Only replace the supply cord with the type specified in the instruction manual Do not operate the machine with a damaged supply cord or plug or after the machine malfunctions or is damaged in any way Contact an authorised Service Agent for repair or adjustment The plug of the power supply cord must be removed from the socket outlet before commencing cleaning of the machine or undertaking maintenance operations Do not kink or twist the power cord Take care when using a machine near the top of stairs to avoi
22. sed for cleaning stairs upholstery and inaccessible areas e To use accessories remove the vacuum hose from the recovery tank and insert accessory vacuum hose in its place e Disconnect solution hose from connector on front of machine and connect accessory solution hose to machine e Switch OFF brush drive e Switch ON vacuum motor and accessory spray The accessory can now be used 5 1 Cleaning Carpet Colour fastness Before using cleaning solution or pre spotter test carpet for colour fastness on an inconspicuous area Apply solution to a small piece of clean white material or tissue and then rub on carpet vigorously Excessive amounts of dye showing on the material indicate that the colours are not fast and the carpet should not be wet cleaned e Move furniture around to give a clear working area Cover bottoms of furniture legs where necessary aluminium cooking foil is ideal Pin up curtains and drapes Vacuum carpet thoroughly to remove any residual dust or debris Areas of heavy carpet soiling can be removed more easily if first treated with a concentrated cleaning solution or pre spotting solution Rate of cleaning will depend upon the thickness of the carpet and the degree of dirt in the area being cleaned Do not clean any more than twice Carpets may shrink if they are over wet or not properly fixed down 5 2 Cleaning Stairs CAUTION When cleaning on stairs A exercise great care to ensure that machin
Download Pdf Manuals
Related Search