User Manual
Contents
1. Jurbec TOR MAANA E TURER Turbo Air Speeds up the Pace of Innovator Underbar Equipment Beer Dispensers Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment TBD 1SD TBD 1SB TBD 2SD TBD 2SB TBD 3SD TBD 3SB eae TBD 4SD TBD 4SB SD series Stainless Steel Exterior SB series Black Laminated Vinyl Exterior or Black Powder Coating Exterior www turboairinc com CONTENTS ad Fy a ea 2 SERALE NONMBPER a a 2 INSTALLATION OF DRE CASTERS cesses tre et 3 Draft Arms Towers Installation Schematic Diagram 3 Beer Line amp CO Line Installation Schematic Diagram w 4 Cawtion IMPORTANT se 5 6 INSTALLATION eiiieaenii iasiipaisiascisins 7 CEEA PIN G iE a a E 8 BASIC OPERA NON resina i a 9 TROUBLE OO TIN eee eee ee eee ee WARRANTY a a aaa 11 13 SPECIFICATIONS MODEL COMPHP V Hz REFRIGERANT AMPS WEIGHT _ rTep 2spis8 18 118Vi60H2 Rt34a 70A 800 819 Ibs aspisB 1s 115V 60H2 R ts4a 70A 996 048 Ibs 1 3 TBD 3SD SB 1 3 TBD 4SD SB 115V 60Hz R 134a 440 Ibs SERIAL NUMBER The serial number is located on the rating label which is on interior left side wall Please retain the unit s serial number for service purpose INSTALLATION OF THE CASTERS According to model refer to the assembly position of casters TCB 2SD TBD 2SD TBB 2SB TBB 2SG TCB 3SD TBD 3SD TBB 3SB TBB 3SG TCB 4SD TBD 4SD TBB 4S2. motor starting equipment fan assembly any other electrical component etcetera 134A 404A COMPRESSOR WARRANTY The five year compressor warranty detailed above will be voided if the following procedure is not carefully adhered to 1 This system contains R134A refrigerant and polyol ester lubricant The Polyol ester lubricant has rapid moisture absorbing qualities If long exposure to the ambient conditions occur the lubricant must be removed and replaced with new Listed below are the approved lubricants for the Tecumseh compressors 1 ICl Emkarate RL 184 2 Emery 2927 A 3 Mobile Artic 22A Failure to comply with recommended lubricant specification will void the compressor warranty 2 Dryer replacement is very important and must be changed when a system is opened for servicing dryer must be used with XH 9 desiccant 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must obtained What is NOT covered by this warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than expressly covered by this warranty 1 WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANT
3. warm e Check the condition of stored e The unit lid is opened too product frequently or left open too long Check the position of the temp The temp dial is not on the control dial correct position e The condenser is clogged There is a loud noise The floor is too weak or the e Check the installation leveling feet are set incorrectly The backside of the unit is too close to the wall There are dew drops High moisture air can produce Wipe with a dry cloth on the unit exterior dewdrops during rainy seasons There are dew drops The lid is opened too frequently Keep the lid closed to remove on the unit interior or left open too long dewdrops The following points are not malfunctions A water flowing sound can be heard when the compressor stops This is the sound of REFRIGERANT flowing The compressor does not run during the defrost cycle 10 farbo Bir MANUFACTURING COMPANY THREE YEAR WARRANTY Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit the cabinet and all parts thereof to be free from defects in material or workmanship under normal use and service for a period of three 8 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any parts covered by this warranty that are examined and determined by Turbo Air to have been defective within three 3 year of original installa
4. 0 days or as needed To clean condenser unplug the unit Condenser can be cleaned with vacuum brush or CO2 high pressure air 3 CLEAN THE GASKET The door gasket should be cleaned frequently to maintain proper sealing 4 CLEAN THE DRAIN PAN Empty the Drain Pan which is located under the unit periodically When reinstalling Drain Pan make sure Drain Hose is placed back in pan 5 CHECK AFTER CLEANING Plug unit back in Check that the unit is operating properly BASIC OPERATION REFRIGERATORS 1 The controller thermostat is located at the back right inside of the unit 2 The factory setting maintains about 38 F 3 C inside 3 Set toward counter clock wise warmer temperature and clock wise for colder temperature NORMAL COLD COOL OFF Temperature Controller Thermostat 4 The thermostat controls compressor s cycling by sensing inside temperature 5 When unit will not be used for a long time unplug the unit TROUBLESHOOTING SYMPTOMS CAUSES SOLUTIONS Cooler is freezing e Thermostat set too cold Turn the temperature dial to a products warmer setting The unit does not e There is a power connection e Check the power cord to make refrigerate at all failure problem sure the unit is pluged in it correctly The unit does not e The unit is in sunlight or near a Move out of sunlight or away refrigerate well heating device from heater e Product was put in
5. B TBB 4SG This picture is a plan view of bottom cabinets CB is an abbreviation of the caster with a brake Other casters don t have a brake DRAFT ARMS TOWERS Installation Schematic Diagram Screw M4xL12 x 4EA 7 i f TR Screw M4xL12 x 4EA TCB 2SD TCB 3SD TCB 4SD TBD 2SD TBD 3SD TBD 4SD TBD 2SB TBD 3SB TBD 4SB Assemble DRAFT TOWER as above drawing 3 BEER LINE amp CO LINE Installation Schematic Diagram Distributor Fixture ee ESS r w aS Y WN 1 E3 la tU 2 Ly aah CO Line S TCB 2SD TCB 3SD TCB 4SD TBD 2SD TBD 3SD TBD 4SD TBD 2SB TBD 3SB TBD 4SB Assemble BEER LINE amp CQ2 LINE as above drawing CAUTION IMPORTANT Don t pull out or Turn drain line DIRECT DRAW On direct draw dispensers the drain is located at the front of the cabinet To plumb in the drain connect 5 8 P V C pipe to the 5 8 barbed fitting supplies with the unit CAUTION IMPORTANT A Excessively opening the door will cause the breakdown B Handle with care as shutting the door 1 POWER CORD Be sure the power cord is connected to the proper voltage and amps should be run before connecting power cord to outlet A protected circuit of the correct voltage and amperage must be run for connection of the line cord Unplug the unit whenever performing maintenance functions or cleaning the refrigerated cabin
6. IES HEREIN MADE AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE 2 NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDIRECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE CLAIMS WHETHER OR NOT ON ACCOUNT OF REFRIGERATION FAILURE 3 ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FLOOD ACTS OF GOD TURBO AIR is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or an Act of God 4 NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESS IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF 5 TRANSPORTATION COSTS Turbo Air will accept parts covered under this warranty freight collect provided that shipment has received prior approval Turbo Air is not responsible for any othe
7. ND IN LIEU OF ALL OTHER WARRANTIES INCLUDING IMPLIED WARRANTY AND MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF Outside U S and Canada This warranty does not apply to and Turbo Air is not responsible for any warranty claims made on products sold or used outside the continent of the United States and Canada New Extended Warranty policy applies to all units sold by Turbo Air starting Dec 1 2012
8. RECT OR CONSEQUENTIAL DAMAGES INCLUDING WITHOUT LIMITATION LOSSES OR DAMAGES ARISING FROM FOOD OR PRODUCT SPOILAGE REGARDLESS OF WHETHER OR NOT THEY RESULT FROM REFRIGERATION FAILURE WARRANTY IS NOT TRANSFERABLE This warranty is not assignable and applies only in favor of the original purchaser user to whom delivered ANY SUCH ASSIGNMENT OR TRANSFER SHALL VOID THE WARRANNTIES HEREIN AND SHALL VOID ALL WARRANTIES EXPRESS OR IMPLIED INCLUDING ANY WARRANTY OF MERCHANTABILITY OR LABOR COVERAGE FOR COMPONENT FAILURE OR OTHER THE WARRANTY PACKET PROVIDED WITH THE UNIT ALTERATION NEGLECT ABUSE MISUSE ACCIDENT DAMAGE DURING TRANSIT OR INSTALLATION FIRE FOOD ACTS OF GOD Turbo Air is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration neglect abuse misuse accident damage during transit or installation fire flood or act of GOD IMPROPER ELECTRICAL CONNECTIONS TURBO AIR IS NOT RESPONSIBLE FOR THE REPAIR OR REPLACEMENT OF FAILED OR DAMAGED COMPONENTS RESULTING FROM ELECTRICAL POWER FAILURE THE USE OF EXTENSION CORDS LOW VOLTAGE OR VOLTAGE DROPS TO THE UNIT NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE THERE ARE NO OTHER WARRANTIES EXPRESSED IMPLIED OR STATUTORY EXCEPT THE THREE 3 YEAR PARTS amp LABOR WARRANTY AND THE ADDITIONAL TWO 2 YEAR COMPRESSOR WARRANTY AS DESCRIBED ABOVE THESE WARRANTIES ARE EXCLUSIVE A
9. dance with the instruction packet supplied with each Turbo Air unit Turbo Air s obligation under this warranty is limited to a period of three 3 year from the date of original installation or 39 months after shipment date from Turbo Air whichever occurs first Any part covered under this warranty that are by Turbo Air to have been defective within three 3 year of original installation or thirty nine 39 months after shipment date from manufacturer whichever occurs first is limited to the repair or replacement including labor charges of defective parts or assemblies The labor warranty shall include standard straight time labor charges only and reasonable travel time as determined by Turbo Air Additional Two Year Compressor Warranty In addition to the three 3 year warranty stated adove Turbo Air warrants its hermetically sealed compressor to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from the manufacturer Compressor determined by Turbo Air to have been defective within this extended period will at Turbo Air s discretion be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically sealed parts of the compress
10. et Compressor warranty is void if burnt out due to low voltage 2 RE STARTING If unpluged wait 5 minutes before re starting INSTALLATION 1 GOOD AIR CIRCULATION Do not place any object that will restrict air flow in front or back grills Turbo air highly recommends that there is ample space in rear of unit 3 inches or more is best 2 PLACE ON STRONG GROUND Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents 3 DO NOT PLACE NEAR HEAT Be sure to avoid hot corners and locations near stoves High ambient temperature will make cooling efficiency lower 4 INDOOR USAGE ONLY Be sure to install this unit indoor so it will not get wet from the rain 5 STABILIZING Make sure the unit Is installed in a stable condition 6 LEVELING Be sure that the unit is level from front to back and side to side 7 DO NOT PLUG IN WITH OTHER UNITS ON SAME BREAKER 8 DO NOT RUN ON EXTENSION CORD CLEANING Before cleaning unplug the unit 1 CLEANING THE INTERIOR AND EXTERIOR The interior and exterior of the unit can be cleaned using warm water with soap Do not use an abrasive cleaner because it will scratch the surface 2 CLEANING THE CONDENSER FINS To maintain proper refrigeration performance the Condenser coil must be free of dust dirt and grease This will require periodic cleaning Condenser fins should be cleaned at least every three months 9
11. or and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers motor starting equipment fan assembly or and other electrical components etcetera 404A 134a Compressor Warranty The five year compressor warranty detailed above will be void if the following procedure is not carefully adhered to 1 This system contains R404A or R134a refrigerant and polyol ester lubricant The polyol ester lubricant has rapid moisture absorbing qualities 2 Drier replacement is very important and must be changed when a system is opened for servicing A620 copper drier or better is highly recommended 3 Micron level vacuums must be achieved to insure low moisture levels in the system 500 microns or lower must be obtained When compressor is grounded suction drier and 620 drier or better must be replaced 5 Compressor must be obtained through Turbo Air unless otherwise specified in writing through Turbo Air s warranty department aN 404A 134a Compressor Warranty Turbo Air s sole obligation under this warranty is limited to either repair or replacement of parts subject to the additional limitations below This warranty neither assumes nor authorizes any person to assume obligations other than those expressly covered by this warranty NO CONSEQUENTIAL DAMAGES TURBO AIR IS NOT RESPONSIBLE FOR ECONOMIC LOSS PROFIT LOSS OR SPECIAL INDI
12. r transporation costs but will ship freight collect pars either repaired or replaced under these warranties 6 WARRANTY CLAIMS All claims should include model number of the cooler the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the existence of the alleged defect Any action or breach of these warranty provisions must be commenced within three 3 year after that cause of action has accrued hurbe TOR PUN TURER 4184 E Conant St Long Beach CA 90808 TEL 310 900 1000 FAX 310 900 1077 TOLL FREE 1 800 627 0032 U S A amp Canada Website www turboairinc com Warranty Claims All claims for parts or labor must be made directly thorough Turbo Air All claims should include model number of the unit the serial number of the cabinet proof of purchase date of installation and all pertinent information supporting the alleged defect In case of compressor replacement under warranty either compressor or compressor tag must be returned to Turbo Air along with above listed information Failure to comply with warranty policies will result in voiding claims Three Year Parts amp Labor Warranty Turbo Air warrants all new refrigerated components the cabinet and all parts to be free from defects in materials or workmanship under normal and proper use and maintenance service as specified by Turbo Air and upon proper installation and start up in accor
13. tion or thirty nine 39 months after shipment date from manufacturer whichever occurs first shall be repaired or replaced as stated below Turbo Air shall be deemed to have fully complied with its obligation under the foregoing warranties by electing either one of the following procedures at the sole discretion of Turbo Air 1 Furnishing a replacement part freight collect in even exchange for the returned part freight collect 2 Receiving the defective part freight collect repairing it and returning it freight collect ADDITIONAL TWO YEAR COMPRESSOR WARRANTY In addition to the three 3 year warranty stated above Turbo Air warrants its hermetically and semi hermetically sealed compressor to be free from defects in both material and workmanship under normal use and service for a period of two 2 additional years from the date of original installation but not to exceed five 5 years and three 3 months after shipment from manufacturer Compressors determined by Turbo Air have been defective within this extended time period will at Turbo Airs option be either repaired or replaced with a compressor or compressor parts of similar design and capacity The two 2 year extended compressor warranty applies only to hermetically and semi hermetically sealed parts of the compressor and does not apply to any other parts or components including but not limited to cabinet paint finish temperature control refrigerant metering device driers
Download Pdf Manuals
Related Search