Quantum Manual Nov 2007(12)
Contents
1. and original Electrical Plate if removed to Towbar Centre Profiles using replacement Bolts and Nyloc Nuts Tighten Bolts to 96 Nm Assemble Weather Cap VW to the Towball Receptor Unit so as to cover the openings for the Towball Neck B and Handle C N A EG StowBar Detachable Towball System Towa ETETE Quantum Detachable Towball System Operation Manual COWRA M TETEE General directions for the operation of all Detachable Towball Systenns dle 7 This user manual contains information that is essential to ensure the safe operation of the system and must be kept with the vehicle documents at all times We emphasise that a Towbar is a safety critical item which should be used and installed as stated in the installation instructions The operations should only be performed by hand Never use tools of any kind to operate the locking system This can result in damage of the locking system after which safe usage can no longer be assured and the warranty would be invalid It is permissible to use a Witter ZQR handle Check the green indicator is correct every time before towing as shown in diagram 3 When used in combination with a coupling head with an integrated stabiliser e g ALKO or Winterhoff do not use grease on the towball If the trailer is equipped with a safety cable or brake cable this must be connected to the special safety hole that is located in the fixed part of the Towbar making sure that it cannot2. lite kutt i st tfanger for gi tilstrekkelig plass til betjeningshendelen P se at kunden brukeren f r overlevert brukerveiledningen samt blir gitt oppl ring i bruk av systemet Vertikal Montasje Horisontal Montasje Quantum Detachable Towball System Operation Manual rowsan LIT Removal of the detachable towball system Always remove unhitch the trailer prior to removing the towball diagram 6 and remove any accessories if they obstruct the locking system as well as detaching the safety cable Unlock the towball by turning the key clockwise Refer to diagram 7 Hold the detachable towball with the left hand Push the operation handle into its housing and turn fully clockwise The handle should remain in this position refer to diagram 8 Let the detachable towball slide out of the housing whilst holding to prevent falling onto the floor When not in use keep the towball in the bag provided If kept in the vehicle this must be located such that it is not free to enter the passenger compartment in the event of a collision Maintenance The detachable towball requires no special maintenance A few useful tips are given below The detachable towball and the towbar mounted receiver can be washed with warm water and mild detergent in the installed position or wipe with a dry cloth Do not use liquid solvent for cleaning purposes It is recommended that a small amount of light lubricating oil is used in the key locking
3. TOWBAR SYSTEMS TOWBHAR STSTEMA Witter Detachable Witter Towbars Chester CH5 2NY Towball Systems Detachable Towball Technical Helpline 44 0 845 2009534 www witter towbars co uk Operation Manual Malcolms Caravans and 10 12 Wynnefield Road Rathmines Dublin I Tel 353 0 I 497 5713 Product Warranty E mail info malcolms ie Garanti This document contains essential safety information Vedr rende garantisporsm l Henvend Dem til SLH AS tlf 47 32253060 and must be read and understood before using your E mail post slh as new Witter Detachable Towball System It should eller S Kjos Import A S tlf 47 32784556 be stored in the vehicle for future reference E mail k import online no 2007 C P Witter Ltd ZQ M Issue 6 Registered Office 5 Temple Square Temple Street Liverpool L2 SRH Terms and Conditions of Warranty This product warranty is only valid if the Detachable System is registered with Witter Towbars on line at www witter towbars co uk warranty ZQ I This product warranty is valid for 2 years from the date you purchased the Detachable System from Witter Towbars or their agents The Warranty will be extended for a further year 3 years in total if you register the Detachable System within 30 days of the date of purchase This product warranty covers faulty materials and workmanship During the period this warranty is valid the Detachable System you have purchased will be repaired replaced or ha
4. bevares i bilen m den plasseres p et sikkert sted slik at den ved en kraftig oppbremsing eller en eventuell kollisjon ikke kan for rsake skade B wer W Qa C P Monteringsanvisning quantum AVTAGBART TITTET TREKKDEL Innhold Receptorhus Avtarbar trekkdel Nokler for avtagbar trekkdel M12 x 25mm x 1 75mm bolter sprengskiver og stoppskiver 25mm diam Plastdeksel Avtagbart plastdeksel Klistremerke pil Oppbevaringspose Brukerveiledning Plasser plastdeksel FC over front av receptorhuset A horisontal montasje over topp av receptorhuset A ved vertikal montasje Plasser receptorhuset A mellom platene p tilhengerfestet monter l slig med bolter X Dersom vinkelbrakett EQI og kontaktplate ZEP medf lger tilhengerfestet monteres disse p venstre side benytt bolt M10 x 25mm med mutter og skiver Kontaktplate ZEP2 monteres med en av boltene X Eventuell sikkerhetskjettingplate SC monteres p h yre side i nedre hull Plasser Trekkdelen T i receptorhuset i henhold til brukerveiledning p se at trekkdelen st r rett vertikal posisjon trekk til bolter X Tiltrekkingsmoment MI2 95 Nm Plasser pil L nederst i senter p st tfangeren for indikere receptorhusets plassering vertikal montering Dekselet RC skal alltid v re plassert i recptorhuset A n r trekkdelen Tikke er montert Den avtagbare trekkdel skal kun v re montert ved kj ring med tilhenger Det kan v re n dvendig p enkelte modeller med et
5. come into contact with the operation han If the towball obscures even partly the vehicle registration plate the towball must be removed at all times when the towbar is not in use and the vehicle is used on public roads 8 If there are any doubts or concerns regarding the use or operation of the detachable system contact either your local Witter fitting specialist or visit our website where a full instructional video can be downloaded Mounting of Detachable Towball Systems Refer to the diagrams on pages 5 amp 6 Before installing the detachable towball you must be sure that it is in the set position In this position the 18mm diameter 18 cylinder is set into the towball mechanism or it can be pushed inwards with the fingers The operation handle is NOT in the set position if red is visible in the recess on the underside If this is the case push the knob in firmly and then rotate the handle fully clockwise to its end position The handle should now re main in this position see diagram Remove the plastic weather cap and ensure that the receiver is clear of any mud gravel road debris etc Insert the detachable towball into the Towbar mounted housing until the large pin through the towball is located in the recess in the Towbar mounted housing refer to diagram 2 Keep your hands away from the locking system For vertical systems pull the towball towards you whilst holding the mechanism in place after
6. e are no loose components attached i e ZEQI electrical socket angle bracket Insert detachable towball unit T using procedure detailed in Operation Manual provided and ensure correct vertical alignment of the towball before fully tightening bolts X Attach centreline label L to lower edge of bumper Remove keys K from neck of towball and record the key number in the Operation Manual together with the fitter s name telephone number date fitted vehicle model and registration number and Towbar part number Bumper Cut It may be necessary to trim the bumper to allow adequate clearance around the operation handle on the right hand side Note It is essential that the customer end user is familiar with the operation of the towball system as detailed in the Operation Manual which must be handed to the customer end user Recommended torque settings M12 95 Nm
7. ellt Bruk ikke verkt y av noen art til betjening av l semekanismen dette kan delegge l sen og vil hindre sikker bruk samt at garantien vil bortfalle Kontroller den gr nne indikatoren f r hver kj retur ref tegning 3 N r kulen brukes sammen med kulekoblinger med innebygget stabilisator som ALKO eller Winterhof skal det ikke benyttes fett eller olje p kulen Tilhengerens sikkerhetskjettinger eller katastrofevire m alltid festes til hull eller egen brakett for dette form l p den faste delen av tilhengerfestet p se at de ikke kommer i kontakt med betjeningshendelen Den avtagbare trekkdelen kulen skal den alltid v re avmontert n r tilhengerfestet ikke er i bruk Dersom det er noe tvil om bruk av det avtagbare system ta kontakt med din forhandler Betjening av det avtagbare system se bildeinstruksjon side 5 Fjern st vdeksel RC fra receptorhuset F r installering av den avtagbare kule p se at receptorhuset p tilhengerfestet er rent og fri for eventuellt sn og is P se at betjeningshendelen st r p set posisjon i denne posisjon er sylinderen 18mm diam sunket inn i kulen eller kan lett presses inn med fingren Hendlen er ikke i set posisjon dersom det r de feltet er synlig i pningen p undersiden dette tilfelle m hendelen vris medurs til sluttposisjon og stopper i henhold til bilde I Plasser den avtagbare del helt opp i huset vertikal montasje inn i huset horisontal montasje Hold fingre
8. if it is to be used with a clamp on the ball type coupling stabiliser Check that all fasteners are tight every 10 000Km Vedlikehold Etter bruk vask trekkdelen B og hendelen C med mildt s pevann benytt ikke l sningsmidler ren for skitt og salt p se at overflatene p trekkdelen B hendelen C og innvendig i reseptor huset A alltid er rene og p f rt et tynt lag med fett dette vil lette bruken og beskytte overflater og nylonforinger Plasser trekkdelen B og hendelen C i oppbevaringsposen st vdekslet W plasseres over hullene i reseptorhuset SAFETY Never leave the detachable towball loose in the car Always store the towball in a secure location where it is not free to enter the passenger compartment in the event of a collision or heavy braking If not secured the towball could cause serious injuries Make sure that when installed the hook on the Handle is correctly engaged over the Pin on the Towball Neck See operating instructions on following page In UK law the driver is responsible for the safe operation and use of a vehicle Therefore if there is any doubt as to the integrity of the installation of the detachable towball do not use for towing Either contact your local Witter fitting specialist or visit our website at www witter towbars co uk Viktig NB Trekkdelen B skal kun vere montert ved kjgring med tilhenger Nar den avtagbare kulen ikke er i bruk skal den oppbevares i posen som nedf lger dersom den opp
9. mechanism only Place the detachable towball inside the bag provided and store preferably in a dry place Never leave the detachable towball loose in the car Always store the towball in a secure location where it is not free to enter the passenger compartment in the event of a collision or heavy braking If not secured the towball could cause serious injuries Make sure that when installed the detachable towball locking system shows the green indica tion strip and that the operation handle has popped out This must be confirmed by locking the towball In UK law the driver is responsible for the safe operation and use of a vehicle Therefore if there is any doubt as to the integrity of the installation of the detachable towball do not use for towing Either contact your local Witter fitting specialist or visit our website www witter towbars co uk Brukerveiledning za OUANTUM AVTAGBART KULESYSTEM Frakobling av det avtagbare system f lg bildeinstruksjon Fjern alltid tilhenger og utstyr som kan vere i veien for betjeningshendelen for kulen frakobles bilde 6 Las opp kulen ved a dreie nokkelen medurs bilde 7 Hold kulen med venstre hand press betjeningshendelen inn og vri denne medurs helt frem til den stopper hendelen skal forbli i denne posisjon bilde 8 Kulen er l s og vil n gli ut av huset pase at den taes forsiktig ut slik at den ikke faller i bakken med fare for skade betjeningshendelen gjelder ve
10. ne borte fra l sehendelen med kulen presset opp inn gj res et lite rykk bakover den vil da l se automatisk bilde 2 Betjeningshendelen vil n dreie til gr nn posisjon og sprette ut ca 7mm bilde 3 Kontroller dette Dersom dette ikke er situasjonen ta kulen ut og start igjen fra punkt A L s kulen ved dreie hendelen moturs bilde 4 med betjeningshendelen l st kan denne ikke lenger presses inn eller vris i noen retning n r systemet lar seg l se er dette en bekreftelse p at monteringen er gjort riktig N r indikatoren viser gr nt og hendelen er l st med n kkelen er kulen klar til bruk bilde 5 StowBar Detachable Quantum Horizontal Towball System v Detachable Towball Quantum Vertical StowBar Detachable Detachable Towball Towball System General Maintenance Towa ETETE MAINTENANCE For prolonged life minor maintenance is reguired as detailed below Keep the Towball Receptor Unit Towball Neck and Handle in a clean condition The Towball Receptor Unit can be washed with warm water and mild detergent to remove dirt ingress Do not use liquid solvent After use place the Towball Neck B and Handle C inside the bag provided store preferably in a dry place and refit Weather Cap VV Maintain a thin layer of general purpose grease not oil on the parts of the Handle and Towball Neck that are inserted into the Towball Receptor Unit Do not the spherical surface of the towball
11. rtikal montasje ved horisontal montasje trekkes kulen bakover ut av reseptorhuset N r kulen ikke er i bruk b r den oppbevares i posen som medf lger dersom den oppbevares i bilen m den plasseres p et sikkert sted slik at den ved kraftig oppbremsing eller en eventuell kollisjon ikke kan for rsake skade Vedlikehold Den avtagbare kule krever ikke noe spesielt vedlikehold noen gode r d nevnes nedenunder Kulen kan vaskes med mildt s pevann n r den er montert eller renses med en t rr klut n r den er frakoblet Benytt ikke flytende fettl slige midler for rengj ring Det anbefales noen o tynn olje i l sen d Quantum Detachable Towball System Upgrade Installation THwEAR ETFETERD Receptor Socket for Towball Detachable Towball Keys for Detachable Towball M12 x 25 x 1 75mm Bolts Spring Washers and Flat Spacer Washers 25mm O D Fixed Weather Cover Removable Weather Cover Centreline Label Bag Operation Manual INSTALLATION PROCEDURE Place black plastic fixed weather cap FC over forward horizontal system upper vertical system holes of receptor socket A insert receptor socket A into gap between mounting plates on the Towbar and loosely attach using bolts X Notes The electric plate angle bracket ZEQ1 which is provided as part of the Towbar should be refitted on the left hand side together with the electrical socket mounting plate ZEP1 Only use the 25mm O D Flat Spacer Washers X where ther
12. ve parts replaced free of charge provided that a the Detachable System is returned to Witter Towbars with evidence of the purchase date b the Detachable System has been installed and operated correctly c the Detachable System or Towbar has been used within the towing limits specified by the vehicle manufacturer See vehicle handbook d the Detachable System or its mechanism has not been damaged unless as a result of faulty materials or workmanship by Witter Towbars e it has not been used for any purpose other than towing a trailer or for use with a cycle carrier and this does not exceed the towing limits of the towbars f the mechanism of the Detachable System has been operated only by hand as described in the Operation Manual or in conjunction with a Witter ZQR handle g repairs to the Detachable System have not been attempted other than by Witter Towbars This Warranty does not confer any rights other than those expressly set out above and does not cover any claims for consequential loss or damage This warranty is offered as an extra benefit and does not affect your statutory rights FM27936 Va StowBar Detachable Towball System Upgrade Installation TAAT A Receptor B Towball Neck C Handle P Safety Chain Plate W Weather Cap FITTING OF TOWBALL RECEPTOR l 2 3 4 Remove original bolts at X and Towbar Centre Part if fitted Attach Towball Receptor Unit A Safety Chain Plate P
13. which the towball will lock automatically For horizontal systems push the towball downwards The operation handle will turn to indica tion green and will also pop out 7mm diagram 3 CHECK THIS If this is not the case remove the towball and start again at diagram 1 Lock the towball by turning the key anti clockwise refer to diagram 4 After this the operation handle can no longer be pushed inwards also it is no longer possible to turn the handle If the towball system can be locked this confirms that the towball is correctly installed It is essential that the indicator is green prior to towing Remem ber to remove the key from the lock before starting your journey The towball is then ready to be used Refer to diagram 5 The key operated lock is an anti theft device only It is not involved with the attachment of the towball It is safe to tow with the key operated lock un locked as long as the towball is correctly attached as described above A StowBar Detachable Brukerveiledning Towball System Fal me QUANTUM AVTAGBART al Ea Operation Manual KULESYSTEM Generell veiledning for bruk av avtagbart kulesystem Denne manual inneholder viktige sikkerhetsanvisninger og skal oppbevares sammen med bilens vrige dokumenter Vi vil p peke at tilhengerfestet er et sikkerhetssystem som b r monteres og behandles med st rste forsiktighet Betjening av det avtagbare system m kun betjenes manu
Download Pdf Manuals
Related Search