Home

Swine Industry Manual - American Association of Swine Veterinarians

1. gt a oO me _ om 4 2 1 Farrowing and Nursery Weaned piglets can be moved by herding or picking them up and carrying them Piglets have sharp teeth and can bite exercise caution when picking them up scooping holding under the rib cage or lifting a rear leg above the hock as shown in the photo on the right The sow may become aggressive when piglets are removed use care when reaching into the pen Noise shakers are used to herd piglets down hallways and load them into truck or trailers At a nursery pigs are usually unloaded by herding them out of the trailer in groups and sorting them by number and size into pens Towards the end of the nursery phase pigs may become too large to lift and should be moved using a sorting board relying on their flight zone as illustrated in Figure 5 When loading or unloading provide extra time for the animals to move to avoid injury FAD PReP Swine Industry Manual Page 17 of 58 4 2 2 Grow Finish Transport to market is the most common reason grow finish pigs are moved The most effective technique for loading and unloading is to work in pairs and use the flight zone Figure 5 Use a sorting board to turn or stop market pigs It is also important to watch for signs of fatigue such as open mouthed breathing inability to move or splotchy skin Careful and proper handling to reduce stress will minimize the risk of animals becoming fatigued 4 2 3 Boar Stud Once boars are at a boar stu
2. 3 Soak Soak the area with hot water and a detergent or cleaning agent Be sure to wash and soap down all equipment in the area waterers feed troughs pails etc 4 Wash Wipe spray or scrub the area starting with the dirtiest or highest area ceiling after it has soaked for a period of time This step can be enhanced by the use of pressure washers when cleaning wood cement or other porous surfaces Use caution when using high pressure washers 200 1000 psi as they can aerosolize disease organisms and spread them to other areas 5 Rinse Remove all detergent residue by applying a low pressure water rinse on all surfaces starting with the highest area and working your way to the floor This is especially important as certain disin fectants are inactivated by detergents and soaps 6 Dry Allow the area to dry completely before applying a disinfectant so that it can work effectively Proper Disinfecting Procedures 1 Read the product label This is important to make sure the solution is handled correctly Personal protective equipment gloves mask should be used when mixing up solutions Other considerations to review before applying solutions to fomites include specific dilutions water temperature environmental temperature the need for ventilation and the disease organisms killed by the disinfectant 2 Disinfect Apply the product at the correct dilution and let it sit and work for the suggested amount of time
3. Traceability relies on record keeping regarding inventory and animal movement which can vary by operation and range from hand written paper documents to computerized software programs Swine disease traceability plays a key role in disease surveillance control eradication and continuity of business As defined by the World Organization for Animal Health Office International des Epizooties animal traceability means the ability to follow an animal or group of animals during all stages of life During an animal health event it is necessary to locate the source of the animal s in question the other premises on which the animal s resided other animals that were exposed and animals at risk of exposure If this information 1s not readily available response time is prolonged Producers are encouraged to document animal movements using on farm records to expedite disease investigations Sources e Draft Swine Program Standards Pork Industry Working Group June 22 2006 e OIE Terrestrial Animal Health Code 2009 Glossary accessed February 5 2010 at http www oie int eng normes mcode en glossaire htm terme systeme d identification des animaux 2 LIFE STAGES AND ANIMAL HUSBANDRY NEEDS 2 1 Concept of Pig Flow Swine production is generally categorized into four production phases as illustrated in Figure 4 Breeding gestation 1 Farrowing 2 Nursery 3 and Finishing 4 Pig flow ultimately begins with breeding and gestation which
4. Outbreak Response Tools e Case definitions appraisal and compensation guidelines and formulas and specific surveillance guidance are examples of important outbreak response tools State Tribal Planning e State and Tribal planning is essential for an effective FAD response These plans are tailored to the particular requirements and environments of the State or Tribal area taking into account animal populations industry and population needs Industry Academic and Extension Planning e Industry academia and extension stakeholder planning is critical and essential emergency management is not just a Federal or State activity APHIS Emergency Management e APHIS directives and Veterinary Services Memorandums provide critical emergency management policy APHIS Emergency Management documents provide guidance on topics ranging from emergency mobilization to the steps in investigating a potential FAD to protecting personnel from highly pathogenic avian influenza These documents are available on the FAD PReP collaboration website https fadprep mi org For those who have access to the APHIS intranet these documents are available on the internal APHIS FAD PReP website http inside aphis usda gov vs em fadprep shtml FAD PReP Swine Industry Manual Page iv Swine Industry Manual The information provided here is meant to be used as a preparedness resource rather than a comprehensive document Several key APHIS documents complement th
5. a non slip floor with proper drainage and protection from the outside environment Loading pigs onto the trailer requires a ramp with no more than a 20 degree incline with non slip flooring and cleats spaced 3 inches apart for piglets and 8 inches apart for adult pigs Transport space recommendations differ depending on the production phase of the pig Table 4 The trailer should be equipped with dividers to limit the number of pigs within a given area Weather conditions and animal size should be Loading Ramp considered when deciding space requirements per pig Table 4 Transport Space Recommendations for Pigs in Normal Weather Conditions Average Weight Ibs Square Feet Per Head Average Weight Ibs Square Feet Per Head 12 0 65 250 4 26 50 1 53 300 4 79 100 232 350 5 48 150 2 95 400 6 39 200 3 48 Source Transport Quality Assurance National Pork Board 2008 FAD PReP Swine Industry Manual Page 16 of 58 Weather conditions affect how the transport vehicle is prepared for the well being of the pigs Table 5 In cold weather vents should be closed slats placed inside the trailer to block the wind the trailer should be loaded at the upper end of space recommendations to maximize body heat and extra bedding provided For hot weather keep pigs cool by opening vents scheduling transportation in the early morning or late evening providing wet shavings and loading fewer pigs Continuous truck movement is essential for f
6. hats and coveralls must be worn while on the farm These should be provided by your farm e Protective clothing should remain on your farm and be washed and or disinfected before being worn again e Disinfect footwear before entering AND after leaving any animal housing area e Boot baths should be provided at the entrance exit of all animal areas The disinfectant solution should be changed at least daily or when visibly soiled e Hands must be washed with soap and warm water before entering AND after leaving animal areas even when gloves are used e Minimize contact with animals to only tasks necessary for the continued operation of the farm and health and well being of the animals Educate your employees on their role in preventing disease introduction and spread They should e Understand how FMD can be spread e Understand the farm s biosecurity procedures and how to prevent the spread of the disease e Know the signs of illness in pigs with FMD and e Know who to contact if signs of disease are seen Animal Movement If FMD is confirmed in the U S movement restrictions may be implemented locally regionally and possibly nationally Restrictions will depend on the scope of the outbreak Know the health status and the source of any animal s brought onto your farm If animal movement is allowed in your area thor oughly clean and disinfect the vehicle and trailer before loading and after unloading e Pay special
7. includes gilts brought in for their initial breeding and sows Semen is brought in from boar studs to inseminate the gilts sows In some facilities live boars are still kept as part of the breeding herd and used as semen donors or for natural mating The majority of the industry acquires semen from an off site boar stud Figure 4 Concept of Pig Flow aaa Sows to Market amp ooh ae 6 g xO Finished Pigs to Market Breeding Weaned Ww Boar amp Gilts i eaned Piglets Stock Animals PUST for Breedin Arrives Moved Piglets to Finishing Stock o gt 45 RG c vL CAC g nS AS a amp 0 A SF S Bleeding B oar Stock Culled Breeding Gestation Farrowing Nursery Finishing 16 to 20 weeks 3 to 4 weeks 6to9 wack 16 to 18 weeks FAD PReP Swine Industry Manual Page 7 of 58 Just prior to farrowing pregnant animals are moved to individual pens in the farrowing barn which 1s still part of the breeding and gestation facility Farrowing and lactation occur in the same facilities until the piglets are weaned Weaned piglets are moved to either a nursery facility or a wean to finish building In either case both types of facilities are often on separate sites from the farrowing facility and may require interstate transport of the pigs Following weaning sows either return to the breeding facility or are removed from the herd and sent to market Nursery pigs are eventually sent to a finishing building where t
8. Antibiotics used including type dose dates fed which group s e Company that delivered feed and e Date feed was delivered 4 ANIMAL MOVEMENT AND HANDLING Swine production requires frequent movement of animals within a given facility Quiet handling by well trained people is essential Transportation of pigs between facilities or to market 1s another aspect of swine production Animal handlers should be trained to use behavioral principles of handling such as flight zone and point of balance as illustrated in Figure 5 Flags plastic paddles or panels should be used as the primary movement aids Frequent use of electric prods is detrimental to pig welfare because shocking increases body temperature heart rate and the incidence of stressed or non ambulatory pigs Proper animal handling plays a key role in the health and welfare of the pig as well as the quality of the final product The National Pork Board advises that sows and pigs that are unable to walk or those that are ill and will not recover be humanely euthanized on the farm by properly trained personnel and not transported to market channels Figure 5 A Pig s Flight Zone Point of Balance and Blind Spot BLIND SPOT Shaded Gray EDGE OF FLIGHT ZONE HANDLER S POSITION TO STOP MOVEMENT HANDLER S POSITION TO START MOVEMENT POINT OF BALANCE Source Transport Quality Assurance Handbook National Pork Board 2008 FAD PReP Swine Industry Man
9. PReP Swine Industry Manual Page 54 of 58 Prevention Practices for Classical Swine Fever CSF Or Classical Swine Fever CSF is a highly contagious disease of swine The various routes of transmission for the virus are listed below CSF is not zoonotic it does not affect humans ee PP IFTP Oral Pigs may ingest the CSF virus in contaminated feed such as uncooked garbage or meat products or by licking or chewing on contaminated environmental objects Direct Contact Pigs can be exposed by contact with infected pigs The virus can enter through open wounds or mucous membranes e g eyes nose mouth following nose to nose contact rubbing or biting Reproductive The CSF virus can be transmitted through semen during mating or to the fetus during pregnancy Aerosol The virus can be carried short distances in droplets passed through the air from one animal to another Environmental Contamination The virus is shed in nasal secretions blood saliva urine feces or can be found in the tissues of infected pigs Fomites Objects contaminated by infected pigs can transfer the virus from one susceptible animal to another Traffic Vehicles trailers or humans by clothing boots or hands can transfer the virus to another location Vector borne Insects such as flies may carry the virus from one animal to another FAD PReP Swine Industry Manual Page 55 of 58 Prevention Practices for Classical Swine Fever
10. acclimation period begins shortly after arrival and overlaps with isolation Many times this phase is referred to as the isolation acclimation period Swing The purpose of acclimation is to provide an oppor Building tunity for the new animals to booster or develop an immune response to organisms that may be unique specific to that particular farm This can be achieved through routine vaccination with either commercial products or farm specific vaccines autogenous or natural exposure The natural exposure process may involve mixing cull animals with new replacements introducing placentas or feces from the farrowing house or other means 3 1 2 Breeding and Gestation m _ After the pigs are weaned sows are brought into the breeding Se ed TSS Mee wad room and are usually bred within 7 days This area can have either feeding stalls with sows grouped together or individual confinement stalls Boar pens are placed adjacent to the sows to help detect heat estrus After breeding sows are moved to the partially slotted floor gestation pens Gestation pens can be individual stalls or group housing in pens Feeding may be done on the floor or in a trough by hand or with a mechanical feeder A common feed and water trough may also be used l l Breeding amp Gestation 3 1 3 Farrowing Nursing Farrowing houses contain individual farrowing pens or stalls designed to provide a comfortable place for the sow to farrow and to protect t
11. as FAD eradication For more information on regionalization please see the FAD PReP SOP Overview of Regionalization for International Trade 2011 as well as 9 CFR 92 2 which lists 11 factors that should be evaluated in establishing a region Compartmentalization which distinguishes between animal subpopulations by management and husbandry prac tices related to biosecurity has not yet been implemented within the United States with any trading partners OIE Chapter 4 4 Disease free compartments must be recognized by trading partners prior to an outbreak for product movement For further information on compartmentalization please see the OIE Terrestrial Animal Health Code 2010 Chapter 4 4 as well as sections on compartmentalization in disease specific chapters for example see Chapter 8 5 Article 8 5 6 on foot and mouth disease FAD PReP Swine Industry Manual Page 30 of 58 Acknowledgements In addition to the sources throughout the manual portions of this document were obtained from e Swine Production Facilities Manual Emergency Preparedness and Response Plan for Pork Facilities draft August 2005 FMD Working Group e Highly Contagious Foreign Animal Diseases of Swine Strategy Document draft June 2008 by P Webb on behalf of National Pork Board e APHIS Framework for Foreign Animal Disease Preparedness and Response Plan FAD PReP Chapter 3 USDA APHIS Draft July 2010 This FAD PReP Industry Manual was produced in
12. attention to the tires and wheel wells e Avoid mixing pigs from different sources when transporting FAD PReP Swine Industry Manual Page 41 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Maintain thorough and accurate records of animal movement e Document all animal movements including the dates of introduction into the herd where they came from and movements between separate units e Each farm location must be treated as a separate unit or premises This information will be essential to help trace where the disease came from Animals Do not feed meat products or unpasteurized milk to swine Where licensed garbage feeding has been per mitted in the past contact the state regulatory agency before feeding cooked garbage to swine to determine if regulations have changed Do not allow your animals to have contact with wildlife e Feral swine are also susceptible to FMD and if infected could potentially spread the virus to domestic swine Monitor animals closely and frequently for any developing illness or signs of disease Educate yourself and train your employees about FMD and the signs of illness Appendix D e Blistering or ulcers on feet causing lameness e Refusal to walk or move e Blanching of skin at coronary band e Blistering or ulcers on the mouth tongue or teats e Fever mild inconsistent e Dullness or weakness e Decreased appetite Isolate any
13. born Many of these movements do not require interstate or intrastate health certificates as pig ownership is maintained and pigs stay within a state Half of the annual pig crop is born on farms in only four states NC IA MN and IL These same four states also account for 62 percent of the Nation s market hog inventory and about 56 percent of the slaughter capacity In Iowa 1 7 million pigs move into the state every month approximately 67 000 pigs every day Therefore the efficient and timely movement of pigs is important for animal welfare and continuation of business for individual operations and the swine industry Sources e USDA NASS Meat Animals Production Disposition and Income 2009 Summary April 2010 accessed March 6 2011 at http usda mannilib cornell edu usda current MeatAnimPr MeatAnimPr 04 29 2010 pdf e Shields DA Mathews KH Interstate Livestock Movements Electronic Outlook Report LDP M 108 01 June 2003 Economic Research Service United States Department of Agriculture With these animal movements swine operations can introduce pigs in a continuous or all in all out flow In continuous flow operations a steady flow of pigs enters the stage with a concurrent flow of pigs leaving the stage The rooms or buildings will have pigs of different ages and the facility is never completely empty All in all out AI AO production involves completely filling a room building or site with animals and then completely emp
14. can occur via semen boar to sow or during pregnancy sow to piglet The virus can also survive in the environment contami nating equipment pens buckets even footwear and cloth ing of people in contact with infected pigs These items termed fomites can serve as an additional source of virus for susceptible pigs If infected pigs are transported in vehicles or trailers these items can also become contami nated and serve as a source of the virus on the farm or to other farms if not properly cleaned and disinfected Other less common routes of transmission include aerosol spread in closed areas or mechanical transfer of the virus by insect vectors e g flies These areas should also be considered when implementing biosecurity measures to prevent the introduction of CSF onto your farm K kor General Precautionary Measures Prevention measures to minimize the introduction and spread of CSF on your farm fall into three general categories 1 Use strict biosecurity measures for animals animal products vehicles people and equipment 2 Restrict or stop all animal movement to prevent entry or spread of the disease 3 Detect and report any disease or unusual signs to your herd veterinarian as quickly as possible Specific steps to take if CSF is confirmed in the U S are listed below Many should already be in place on your farm but should be enhanced and more strictly enforced 1f CSF is found in the U S These m
15. only operations utilizing rendering companies may be able to adjust operations to handle a high number of carcasses if the rendering company can ac commodate them If the disease is highly contagious rendering will not be used Burying large numbers of animals on a particular site requires special permission and is usually under the jurisdiction of the state s environmental regu latory agency Incinerators can only burn so many carcasses at a time and compost piles would require additional space and compost materials 9 5 Manure Many disease organisms are shed in bodily secretions including manure Pathogen survival in manure varies and is affected by environmental tempera tures Cold weather usually increases pathogen survival Solid manure can be composted to increase core temperature and kill most pathogens However most U S swine operations store manure in a liquid form which cannot be composted Many operations contract with manure pumping services which increases the possibility of exposure to many different operations in the area Manure application movement logs should be kept including dates origin application sites volume applied per site and application method During and after a disease outbreak decisions will have to be made on how to decontaminate and dispose of manure The future application of this manure on crop ground must be considered as disinfectants and chemicals that change manure pH may affect subsequent plant
16. susceptible to the highly contagious FAD can complicate disease eradication or control efforts A coordinated effort between local State Tribal and federal agencies including the U S Fish and Wildlife Service the Department of the Interior and State wildlife agencies is necessary to accomplish control without jeopardizing environmental ecosystems Producers knowledge of area wildlife and potential exposure will be vital in this as sessment and management process For additional information see FAD PReP NAHEMS Guidelines and SOP Wildlife Management and Vector Control 2011 16 INTERNATIONAL TRADE In 2009 international exports of pork totaled nearly 4 1 billion pounds valued at over 4 billion USD The top four countries receiving U S pork exports included Mexico Japan Hong Kong China and Canada These markets are vital to the swine industry In the event of a highly contagious FAD outbreak affecting swine international trade of animals and animal products would be halted for the affected zones or regions Source e U S Meat Export Federation 2000 2009 Pork Exports Data accessed March 3 2011 at http www usmef org downloads Pork 2000 to 2009 pdf Regionalization also known as zoning separates animal subpopulations to maintain disease free status in one or more zones Regionalization defines animal subpopulations primarily on a geographical basis As an FAD response tool regionalization can facilitate international trade as well
17. times per maximum incubation period for the disease under investigation During the highly contagious FAD event surveillance could include on farm obser vation testing market animals and at slaughter Please refer to the FAD PReP NAHEMS Guidelines and SOP Surveillance Epidemiology and Tracing 2011 for additional details 10 1 People Visitors and employees can introduce or spread disease to susceptible animals if steps are not taken to mitigate these risks prior to entry Sanitation and hygiene practices are important to prevent disease agent spread and include wearing clean clothing coveralls footwear and washing hands before and after animal contact or glove removal If the highly contagious FAD is zoonotic additional personal protective equipment must be worn by all those handling animals The movement of people on and off the farm during a disease event must be documented to aid exposure assessments Using a written log to record name contact information last contact with a susceptible animal species and reason for being on farm including facilities entered animals contacted is crucial Prior to a disease event records of this information may not be as readily available on all operations Visitor logs are available in the Appendices During an outbreak personnel on farm should be limited to those essential for the day to day operation making it easier to trace and minimize the risk of disease introduction For all employees records
18. when using high pressure washers 200 1000 psi as they can aerosolize disease organisms and spread them to other areas Rinse Remove all detergent residue by applying a low pressure water rinse on all surfaces starting with the highest area and working your way to the floor This is especially important as certain disin fectants are inactivated by detergents and soap FAD PReP Swine Industry Manual Page 53 of 58 Prevention Practices for Classical Swine Fever CSF Tr 6 Dry Allow the area to dry completely before e This includes barns and buildings vehicles applying a disinfectant so that it can work effectively trailers equipment and supplies e Tires and wheel wells of vehicles and trailers are especially important Proper Disinfecting Procedures Surfaces should be scraped cleaned with high 1 Read the product label This is important to pressure hot water and detergent and rinsed make sure the solution 1s handled correctly e The disinfectant should then be applied and Personal protective equipment gloves mask allowed to sit for the optimal contact time should be used when mixing up solutions Other considerations to review before applying solutions to fomites include specific dilutions water tem perature environmental temperature the need for ventilation and the disease organisms killed by the disinfectant 2 Disinfect Apply the product at the correct dilution and let it sit and work for the s
19. 0 4 Sample Collection Premises with the highest risk of infection will have animals sampled for disease testing Handling tissues and fluids from these operations requires strict adherence to biosecurity and infection control procedures Pigs at harvest facilities may also have samples collected Unless otherwise specified samples will be collected by trained animal health personnel veterinarians animal health technicians private or government Depending on the disease specific tissues and or fluids will be obtained on farm after performing a full post mortem exam whenever possible Guidelines will be provided regarding the specific type of tissues needed fresh or fixed fluids serum whole blood vesicular fluids and details related to how to label and package them ap propriately See VS Memo 580 4 Procedures for Investigating a Foreign Animal Disease Emerging Disease Incident FAD EDI October 2008 for more information Personal protective equipment PPE such as coveralls and gloves must be worn by personnel handling the animals tissues and fluids If the disease is zoonotic enhanced PPE should include goggles and an appropriate respirator N 95 or N 99 or a full face shield if aerosolization is not a route of human exposure All equipment used on farm to collect and transport samples and protect the personnel should be properly cleaned and disinfected in the designated area prior to leaving the farm Care should be taken not to c
20. CSF ua a Appendix B Sample Signs Sample signs to post at the farm entrance in the event of a CSF outbreak in the U S Available from the CFSPH web site at www cfsph iastate edu PROTECTIVE HONK BOOTS amp TO ANNOUNCE ARRIVAL CLOTHING ai CHECK IN REQUIRED UPON ENTRY UPON ARRIVAL i Birr ex ee Ee www cfsph iastate E Public Heath ph iastate ed www cfsph iastate er TOWA STATE UNIVERSITY d e Only enter this farm with permission Park at the entrance or in designated parking areas Vi S i O R e Check in with farm personnel upon arrival and sign the visitor lo pP L i E S Follow instructions provide ar AUTHORIZED C ua PERSONNEL br iveries i isi must b m m tans with all osted signs rules on this farm d for your safet and the a BEYOND THIS POINT WITHOUT PERMISSION Q amp S ONS www cfsph iastate edu Policies for a Visitors Contacting Animals or Entering Animal Areas Boots must be clean before enti Allo burdens ctan ene ave ample contact time wit ih iha shee urface cthing an noo otwe sia ride by ane Tari SoHE n the d ted a own protection wash your ha oap and warm water before leaving the far Signage is also available from private companies such as Gempler s DISEASE STOP Takala ALL visitors AREA n SALONS MUST REGISTER MUST CHECK IN PLEASE KEEP OUT ENTERING PREMISES AT OFFICE FAD PReP Swine Industry Manual Page 56 of 58 Prevention Pract
21. Contact time of the disinfectant 1s impor tant for the product to inactivate or kill the micro organism present 3 Final rinse Remove all disinfectant by applying a low pressure water rinse on all surfaces starting with the highest area and working your way to the floor 4 Dry Allow the area to completely dry before allowing animals to contact the area or item that was just cleaned and disinfected Proper Boot Bath Procedures 1 Mix solution to the proper concentration according to the label instructions 2 Clean all dirt manure and debris off of boots BEFORE stepping into the disinfectant solution The presence of organic material dirt manure etc will prevent most disinfectants from working 3 Allow the disinfectant solution to have ample con tact time with the boot surface This will vary with the disinfectant selected Consult the product label 4 Change solutions at least daily or when visibly dirty Proper Storage If the equipment or area will not be used immediately it is important to avoid contamination between uses Small items can be placed into plastic bags and sealed larger items can be placed into closed cabinets Equip ment and housing areas are more difficult to protect for long periods of time and may need to be rinsed again before allowing animal contact Barns and Buildings Clean and disinfect anything that has had contact with animals manure or animal secretions e This includes barns and build
22. SES SWINE INDUSTRY MANUAL SAN as USDA FAD PReP Foreign Animal Disease PHI Preparedness amp Response Plan National Animal Health the Center for od Secu Emergency Management System E n IOWA STATE UNIVERSITY United States Department of Agriculture Animal and Plant Health Inspection Service Veterinary Services pm A Swine Industry Manual The Foreign Animal Disease Preparedness and Response Plan FAD PReP Swine Industry Manual provides an overview of U S swine production methods to enhance understanding of normal business operations and the inherent high risk disease transmission behaviors in order to effectively aid in containing or eradicating a highly contagious foreign animal disease outbreak in the United States This FAD PReP Industry Manual was produced by the Center for Food Security and Public Health Iowa State University of Science and Technology College of Veterinary Medicine in collaboration with the U S Department of Agriculture Animal and Plant Health Inspection Service through a cooperative agreement The FAD PReP Swine Industry Manual was last updated in March 2011 Please send questions or comments to Center for Food Security and Public Health National Center for Animal Health 2160 Veterinary Medicine Emergency Management Iowa State University of Science and Technology USDA Animal and Plant Health Inspection Service Ames IA 50011 Veterinary Services Telepho
23. acilities for use in AI Semen is collected from boars 2 or 3 times a week to maximize the volume and sperm concentration obtained from each boar 2 2 7 Quality Control The sperm concentration of an individual boar s ejaculate will be determined using specialized equipment calibrated spectrophotometer If the semen passes internal quality standards it is then mixed with a semen extender that provides nutrients and antibiotics to extend the life of the semen Extended semen can then be stored at 63 F 17 C for a maximum of 5 7 days The goal is to use the semen as fresh as possible to maximize conception rates and litter size 2 2 8 Genetics Most commercial boar studs will mix semen from several boars in a single batch Knowing the exact sire of a litter 1s not a priority since genetic advance ments are made by sire lines rather than a particular individual sire A typical boar may produce thousands of doses of semen per year Therefore semen quality from a single sire influences a large number of offspring 2 2 9 Disease Testing At a boar stud a subset of boars is usually monitored on a weekly basis to confirm virus negative status for porcine reproductive and respiratory syndrome PRRS Some boar studs will also test each batch of semen for PRRS A single boar stud can supply all the semen needs for thousands of sows in several dozen different facilities Detailed records are kept at the boar stud for each batch of semen pr
24. age vi Swine Industry Manual Table of Contents 3 3 Feeding 14 3 3 1 Delivery to Farm 14 3 3 2 On Site Storage 14 3 3 3 Delivery to Animals 14 3 3 4 Records 15 4 Animal Movement and Handling 15 4 1 Movement Within the Same Premises 16 4 2 Movement Off Farm Off Premises 16 4 2 1 Farrowing and Nursery 17 4 2 2 Grow Finish 18 4 2 3 Boar Stud 18 4 2 4 Sow Farm 18 4 2 5 Auction Markets Buying Station 18 4 2 6 Mortalities 19 4 2 7 Records 20 5 Product Movement 20 5 1 Semen 20 5 2 Manure Handling 20 5 3 Records 21 5 3 1 Semen 21 5 3 2 Boar Studs 21 5 3 3 Manure 21 PART Il RESPONSE TO A HIGHLY CONTAGIOUS FOREIGN ANIMAL DISEASE 22 6 Designation of Zones Areas and Premises 22 7 Disease Specific Biosecurity Measures 24 8 Providing Animal Care 24 8 1 Feeding 24 8 2 Breeding 24 8 3 Farrowing 24 8 4 Nursery and Finishing 25 8 5 Vaccination 25 8 5 1 Routine Personnel Records 25 8 5 2 Specific to Disease Event 25 9 Product Handling 26 9 1 Market Weight Animals 26 9 2 Nursery Pigs 27 9 3 Culls 27 9 4 Maortalities 27 9 5 Manure 27 FAD PReP Swine Industry Manual Page vii Swine Industry Manual Table of Contents 10 Surveillance 27 10 1 People 28 10 2 Vehicle Traffic 28 10 3 Disease Monitoring 28 10 4 Sample Collection 29 10 5 Sample Submission 29 11 Appraisal and Compensation FAD PReP NAHEMS Guidelines and SOP 29 12 Mass Depopulation and Euthanasia FAD PReP NAHEMS Guideline
25. aging a highly contagious FAD outbreak should read this manual to understand the normal busi U S D A ness operationsof the swine industry in order to effectively aid in disease containment or eradication Veterinarians and animal health technicians who are members of the USDA ay APHIS National Animal Health Emergency Response Corps NAHERC or their state or county veterinary response teams carrying out disease control efforts on swine operations should familiarize themselves with this manual Livestock producers and any support per sonnel interacting with swine operations need to be aware of the procedures as described here that may be implemented in a highly contagious FAD event and the biosecurity procedures they would be expected to follow to reduce the chance of becoming infected Scope This manual is divided into two parts plus acronyms glossary and appendices e Part I provides an overview of U S swine production including life stages and animal husbandry facility types and animal movement e Part II describes the response to prevent or mitigate the spread of a highly contagious foreign animal disease such as foot and mouth disease FMD or classical swine fever CSF including designated zones and areas disease specific biosecurity measures and providing animal care e Acronyms and glossary explain the terms used in the swine industry and in emergency response e Disease specific biosecurity measures are found in the appe
26. ailable land Alternatively Type I landfills may be suitable for burial of massive mortality How ever prior arrangements with the landfill operator to accept non contagious carcasses should be made during planning for this disposal method 2 Rendering of carcasses is a common method for farms located in an area where the service 1s available This can be an expensive option but is offset by the benefit of having a third party take the responsibility for managing the carcasses in an environmentally sound manner Rendering is nearly always carried out by a business independent from the farm and often includes pickup service at a designated location on the farm preferably at the edge of the farm away from main traffic area Rendering collection trucks going from farm to farm can present a biosecurity risk Rendering services are not available in all areas In situations involving massive depopulation rendering services Compost Pile can be quickly overwhelmed If a highly contagious FAD was involved this will likely not be an option 3 Controlled incineration of the carcass on farm works well for a small number of animals The process of incineration takes several hours to complete and the burning odor and smoke pollution can be a public concern Thus open pyre burning should be the method of last resort Incineration is often not suitable or cost effective for larger animals but it will destroy most of the pathogen and leave minimal bypro
27. ained in a series of different types of integrated documents as illustrated and described below FAD PReP Suite of Documents and Materials Strategic Plans Concept of Operations Disease E E APHIS NAHEMS E z Continuity State Tribal Response Emergenc of Business HEA y d Guidelines Plans Management Critical Activit industry Academic mi y Outbreak 4 Additional SOFs and and Extension Response Tools in Resources Checklists AE aN Industry Manuals Note APHIS Animal and Plant Health Inspection Service NAHEMS National Animal Health Emergency Management System SOP standard operating procedures Strategic Plans Concept of Operations e APHIS Framework for Foreign Animal Disease Preparedness and Response This document provides an overall concept of operations for FAD preparedness and response for APHIS explaining the framework of existing approaches systems and relationships e National Center for Animal Health Emergency Management NCAHEM Stakeholder Coordination and Collaboration Plan This plan describes NCAHEM strategy for enhancing stakeholder collaboration and identifies key stakeholders e NCAHEM Incident Coordination Group Plan This document explains how APHIS headquarters will organize in the event of an animal health emergency NAHEMS Guidelines e These documents describe many of the critical preparedness and response activities and can be considered as a competent veterinary a
28. ak that disrupts movement off the farm will greatly affect farrowing operations If pig movement is stopped facilities need plans for housing newly weaned pigs to make space in the farrowing facility for the next litters of pigs Sows can be moved back into the breeding facility but the piglets due to their small size and specific housing requirements need to be housed separately from older animals Over time this designated space on the farm may fill up and piglets may need to remain in the farrowing stall This limits the available space for subsequent groups of sows due to farrow A stop in movement for more than 4 7 days could cause significant welfare problems for piglets and or sows FAD PReP Swine Industry Manual Page 24 of 58 8 4 Nursery and Finishing The most important considerations for nurseries and finishers during a disease response are the age and weight of the pigs in the facility as well as the amount of time that off farm movement is halted For pigs that just entered the facility space allocation flooring weight limits nurseries only height of the pens ventilation systems and feedstuffs can accommodate their needs while growing However off farm movement restrictions could have a sizeable impact on pigs that are a few days from moving from the nursery to the finisher or are a few days from reaching market weight due to the design and flow of the facility The animals well being and health could be negatively affected due
29. al Health Emergency Management OIE Office International des Epizooties currently referred to as the World Organization for Animal Health PPE Personal Protective Equipment SOP Standard Operating Procedures SP Suspect Premises SC Subcutaneous SZ Surveillance Zone USDA United States Department of Agriculture VP Vaccinated Premises VS Veterinary Services a division of APHIS FAD PReP Swine Industry Manual Page 36 of 58 Glossary All in all out Al AO Completely filling a room building or site with animals and then completely emptying it to allow for cleaning and disinfection before the next group of pigs arrives This process breaks the disease cycle by preventing the mixing of pigs of different ages which can carry infectious disease agents to expose younger susceptible pigs Barrow A castrated male pig Boar An intact male pig Boar Stud A specific area or building used for holding boars and collecting semen for artificial insemination Boar studs may be housed on the same farm where their semen is used to inseminate gilts sows In these facilities boars are often housed in individual stalls A production system may have a stand alone Boar Stud that produces semen for use at multiple farms within that production system There are also commercial boar studs which produce semen for retail sale to multiple customers Semen from Boar Studs is shipped both intrastate and interstate either by overnight shipment with a commercia
30. als closely and frequently for any developing illness or signs of disease Educate yourself and train your employees about CSF and the signs of illness Appendix D e Disease signs may vary from mild to severe e High fever 41 C 105 F e Dullness or weakness e Purple discoloration of the skin e Conjunctivitis e Abortions and or congenital deformities piglets e Death Mortality rates may be low Isolate any sick animals from the herd and contact your herd veterinarian immediately to examine sick animals Use separate facilities equipment and staff to handle isolated livestock e If this is not possible at a minimum handle or visit the isolated animals LAST e Clean and disinfect all equipment clothing boots etc that come into contact with isolated animals Quarantine any newly purchased or newly arriving animals for at least 30 days e New or returning animals e g shows competitions can be infected with a disease without showing any signs of illness right away Quarantining the animal s before introducing them with the rest of the herd allows time for any signs of disease to develop in the animal without exposing your entire herd to the disease agent Swine exposed to the CSF virus may take as long as 14 days before signs of illness are seen Quarantined animals should not share water feed facilities or bedding with your other animals Ideally animals should be quarantined at a separate location p
31. amirez Veterinary Diagnostic and Production Animal Medicine Iowa State University Bottom Photo of the proper packaging and labeling of samples placed in a cooler with ice packs that will be submitted to a laboratory for testing Photo source Danelle Bickett Weddle Iowa State University FAD PReP Swine Industry Manual Page 34 of 58 Al Al AO APHIS ARP AVIC AVMA BGF C amp D CA CFR CP CSF CVI CVO EDI EZ FAD FADD FAD PReP FMD FP ID IM IP IZ Acronyms Artificial Insemination All In All Out Animal and Plant Health Inspection Service At Risk Premises Area Veterinarian in Charge American Veterinary Medical Association Breeding Gestation Farrowing Buffer Zone Cleaning and Disinfection Control Area Code of Federal Regulations Contact Premises Classical Swine Fever Certificate of Veterinary Inspection Chief Veterinary Officer Emerging Disease Incident Exclusion Zone Foreign Animal Disease Foreign Animal Disease Diagnostician Foreign Animal Disease Preparedness and Response Plan Foot and Mouth Disease Free Premises Identification Intramuscular Infected Premises Infected Zone FAD PReP Swine Industry Manual Page 35 of 58 Acronyms MP Monitored Premises NAHEMS National Animal Health Emergency Management System NAHERC National Animal Health Emergency Response Corps NASS National Agricultural Statistics Service NCAHEM National Center for Anim
32. anagement has become a major factor in determining the location and population limits of operations Poor manure management can result in increased disease in the pigs odor issues and declining water quality Pork producers select a manure handling system based on state regulations as well as factors such as location size type and use of their cropland the number of animals they have on site and the type of animal housing When the animals are housed outside the manure is commonly stored as a concentrated manure pack Manure is scraped from the animal housing area and routinely applied FAD PReP Swine Industry Manual Page 20 of 58 to cropland When the animals are housed in controlled environment facilities the manure is often stored in a liquid form in one of the following ways e Anaerobic deep pit e Above ground storage e Earthen storage pit e Lagoon The capacity of the above types of storage facilities are determined by state regulations which are based on their size and the estimated amount of manure being produced by the pigs They generally allow for removal and draining twice a year when convenient for crop and pig production Crop types and harvest times greatly affect the timing of manure application The manure water mixture 1s applied to the soil by direct injection or through spray from an irrigation sprayer a spreader or injector The amount of manure that can be applied to any specific area of ground is regulated
33. arm access routes parking areas yards and storage areas clean and tidy to avoid attraction of birds or rodents e Implement rodent and vermin control measures to minimize the potential spread of disease by these animals Appendix E Cleaning and Disinfection The virus that causes FMD has shown to be stable in the environment Virus stability increases at lower temperatures and with protection from sunlight FMD virus is inactivated at pH below 6 5 or above 11 Ef fective disinfectants include sodium hydroxide 2 sodium carbonate 4 acetic acid 5 sodium hy pochlorite 6 0 and proprietary products In addition to selecting an effective disinfectant proper cleaning and disinfecting procedures are essential in order to ad equately and effectively control the spread of the virus Proper Cleaning Procedures 1 Wear personal protective equipment Gloves coveralls rubber boots or disposable boots and possibly a mask if you are cleaning an area that will generate dust FAD PReP Swine Industry Manual Page 42 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations 2 Dry clean Remove all visible material by brush ing scraping and or sweeping This is the most important step as organic matter prevents many disinfectants from working effectively Disposal of waste material should be handled in such a way as to prevent contamination of other areas such as feed water or other animals
34. ater Mix thoroughly Follow label directions Comments Household vinegar is a 5 solution of acetic acid Always add acid to water NEVER add water to acid Can be deactivated by hard water Mildly caustic irritate skin and dull paint varnished surfaces Highly caustic skin burns damages metals Use water resistant protective clothing gloves safety glasses Warning Always add the lye to water NEVER pour water over lye Must be mixed fresh prior to each application unstable in warm sunny conditions above 59 F As of August 2010 there are 7 products registered by EPA with a claim to inactivate FMD virus USDA APHIS has an exemption for use of this chemical to inactivate FMD and only USDA personnel may use it as described Sources USDA National Emergency Response to a Highly Contagious Animal Disease Executive Summary Appendix III Disinfectants for Foot and Mouth Disease Field Use March 30 2001 At http www aphis usda gov emergency_response tools cleaning htdocs images Annex09_Cleaning pdf Personal communication Jeff Kempter Senior Advisor Antimicrobials Division Office of Pesticide Programs Environmental Protection Agency Proprietary products are listed at http www aphis usda gov emergency_response downloads nahems Selected 20FAD 20table 200ct 2008 pdf FAD PReP Swine Industry Manual Page 50 of 58 Prevention Practices for Classical Swine Fever CSF Leta ASSO scAN Cr s A
35. ations for Pigs in Normal Weather Conditions Content provided by Transport Quality Assurance National Pork Board Graphic illustration by Dani Ausen lowa State University Page 17 Top Table 5 Truck Setup Procedures During Extreme Temperatures for Market Hogs Content provided by Transport Quality Assurance National Pork Board Graphic illustration by Dani Ausen lowa State University Center Using a pressure washer to clean and disinfect a livestock trailer in a truck wash facility Photo source Danelle Bickett Weddle Iowa State University Bottom The proper way to pick up a piglet out of a farrowing pen is to lift them by their rear leg above the hock Photo Source Alex Ramirez Veterinary Diagnostic and Production Animal Medicine Iowa State University Page 18 Top Photo depicting sows being off loaded Photo Source Danelle Bickett Weddle Iowa State University Bottom A carcass of a market weight hog sold to slaughter top A USDA backtag applied to a sow at a slaughter facility bottom Photo Source USDA Food Safety and Inspection Service top Dr Stephen Lewis Supervisory Public Health Veterinarian Food Safety and Inspection Service bottom FAD PReP Swine Industry Manual Page 33 of 58 Photo and Illustration Credits Page 19 Four methods of disposal are permitted burial rendering incineration and composting A rendering truck picking up hogs from multiple farms top A photo of an incarcinator which
36. be used but they usually generate lower productivity in terms of output per unit of land labor or feed These systems also use more land and more labor per unit of output Interest in outdoor or pasture facilities has increased in recent years as niche markets for meat from pasture raised pigs have developed 3 2 1 Farrowing Huts Farrowing on pasture usually involves individual houses also known as farrowing huts These house types range from A frames without floors to larger houses with floors and areas to feed the animals Huts are bedded with straw for nesting purposes and insulated to help with temperature regulation To encourage the sow to nest in the hut rather than out in the open only 10 15 farrowing huts should be placed on one acre of land Self feeders are used for the sows and creep feeders are generally used for the piglets Outdoor Rearing Systems E f Shade Structures Pigs are susceptible to heat stress making shade structures necessary for the pigs welfare in outdoor systems During warm weather months shade structures protect pigs from the direct heat from the sun which could result in heat stress slower growth and lower conception rates Farrowing Huts 255 3 2 3 Hoop Buildings Hoop facilities can be used successfully for gestation and finishing pigs Hoop buildings have wooden or concrete sidewalls 3 4 feet high upon which are mounted hoops that support covers made of specially treated fabric or
37. book On CD and available from Purdue University Extension e Pork Quality Assurance Guidelines National Pork Board e Transport Quality Assurance manual National Pork Board http www pork org Producers docs TQA_08 pdf FAD PReP Swine Industry Manual Page v Swine Industry Manual LELKE Purpose Intent Scope Learning Objectives _ _ p PART I UNITED STATES SWINE PRODUCTION 1 1 Scope of the Swine Industry 1 1 1 Swine Numbers 2 1 2 Animal Production Systems 3 1 2 1 Location and Movement 3 1 2 2 Routine Deliveries 4 1 2 3 Diverse Workforce 5 1 2 4 Business Continuity 6 1 3 Swine Disease Traceability 6 2 Life Stages and Animal Husbandry Needs 7 2 1 Concept of Pig Flow 7 2 2 Breeding Adults Sows Boars 8 2 2 1 Sows 8 2 2 2 Genetics 8 2 2 3 Timing 8 2 2 4 Natural Mating 8 2 2 5 Semen Handling and Artificial Insemination 9 2 2 6 Boars 9 2 2 7 Quality Control 9 2 2 8 Genetics 9 2 2 9 Disease Testing 9 2 3 Gestation 9 2 4 Farrowing 10 2 5 Nursery 10 2 6 Grow Finish 10 2 7 Production Records 10 3 Swine Facilities 11 3 1 Controlled Environment Confinement 11 3 1 1 Isolation and Acclimation 11 3 1 2 Breeding and Gestation 12 3 1 3 Farrowing Nursing 12 3 1 4 Nursery 12 3 1 5 Grow Finish 13 3 1 6 Wean to Finish 13 3 1 7 Boar Stud 13 3 2 Outdoor Rearing Systems 13 32l Farrowing Huts 13 3 2 2 Shade Structures 13 3 2 3 Hoop Buildings 13 FAD PReP Swine Industry Manual P
38. by the state s environmental regulatory agency 5 3 Records 5 3 1 Semen Records are kept both by the receiving farm and by the boar stud Farm records usually include e Date delivered e Time delivered e Number of doses and e Source premises identification number 5 3 2 Boar Studs Records usually include e Date delivered e Doses e Customer premises identification number and e Boars that produced semen 5 3 3 Manure Manure records usually include the amount of manure spread and the location of the field it was applied to Each state s environmental regulatory agency has specific requirements about the type of records that need to be kept as part of an official manure management plan FAD PReP Swine Industry Manual Page 21 of 58 PART Il RESPONSE TO A HIGHLY CONTAGIOUS FOREIGN ANIMAL DISEASE 6 DESIGNATION OF ZONES AREAS AND PREMISES A critical component for FAD response is the designation of zones areas and premises Epidemiological inves tigation and tracing will be used to classify premises It 1s the responsibility of the Incident Management Team to designate zones and premises in an FAD outbreak These zones areas and premises designations will be used in quarantine and movement control efforts Table 6 summarizes the premises designations that would be employed in an FAD outbreak response Table 7 summarizes the zone and area designations that would be used in an FAD outbreak response Table 6 Su
39. collaboration with USDA APHIS VS National Center for Animal Health and Emergency Management by the Center for Food Security and Public Health Iowa State University of Science and Technology College of Veterinary Medicine through a cooperative agreement Authors include e Alex Ramirez DVM MPH DACVPM Veterinary Diagnostic and Production Animal Medicine e Dan Whitney First year veterinary student e Danelle Bickett Weddle DVM MPH PhD DACVPM Associate Director Center for Food Security and Public Health Illustrations were designed by e Dani Ausen BFA Graphic designer CFSPH This manual was reviewed within USDA APHIS VS by e Dave Pyburn DVM Veterinary Medical Officer Swine Health Programs e Troy T Bigelow DVM Swine Disease Staff Officer e Oliver Williams DVM MPH Swine Health Officer e Todd Johnson DVM Area Emergency Coordinator New York This manual was also reviewed by e Harry Snelson DVM Director Communications American Association of Swine Veterinarians e Patrick Webb DVM Director Swine Health Programs National Pork Board e Tim Goldsmith DVM MPH Center for Animal Health and Food Safety University of Minnesota FAD PReP Swine Industry Manual Page 31 of 58 Photo and Illustration Credits Page ii Photo strip Left to right Landrace pigs Red Angus Simmental cross beef cow with calf Holstein heifers chicks and feedlot cattle Photo sources Iowa State University Beth Carlson North Dakota Mark K
40. d Premises meet a set of defined criteria in seeking to move susceptible animals or products out of the Control Area by permit Free Premises FP Premises outside of a Control Area and nota Surveillance Zone Contact or Suspect Premises Free Area Vaccinated Premises VP Premises where emergency vaccination Containment has been performed This is a secondary Vaccination Zone premises designation Protection Vaccination Zone FAD PReP Swine Industry Manual Page 22 of 58 Table 7 Summary of Zone and Area Designations Zone Definition Infected Zone IZ Zone that immediately surrounds an Infected Premises Zone that immediately surrounds an Infected Zone or a Butar ZoneAB2 Contact Premises Control Area CA Consists of an Infected Zone and a Buffer Zone Surveillance Zone SZ Zone outside and along the border of a Control Area Free Area FA Area not included in any Control Area Vaccination Zone VZ Emergency Vaccination Zone classified as either Containment Vaccination Zone typically inside the Control Area or Protection Vaccination Zone typically outside Control Area This is a secondary zone designation Figure 6 illustrates all the zones and premises Note Figures are not to scale The Vaccination Zone can be either a Protection Vaccination Zone or Containment Vaccination Zone Figure 6 Control Zones Zones and Areas Premises Infected Zone E Buffer Zone wE Vaccination Zone w Surveillance Zone For d
41. d they typically will not be moved off the farm until they are sent to market Take precautions to minimize aggression when transporting boars Allow extra time for them to become comfortable with their new environment Due to the boars size they should be loaded individually Boars should be penned sepa rately to prevent injuries from fighting with finisher pigs or other boars 4 2 4 Sow Farm Sows are moved to market when they become unproductive in a breeding operation They are often older and large in size requiring extra time for movement and to become comfortable with their environment Sows should be marketed when they are still fit for travel 4 2 5 Auction Markets Buying Station When pigs reach approximately 240 280 pounds producers sell them on either a live weight basis at terminal markets or auctions or on a live weight or carcass weight most common basis direct to slaughter houses and meatpackers Some producers also use livestock exchanges or producer owned marketing networks for price negotiation and transportation Terminal markets developed in the late 1800s near slaughter plants in major metropolitan areas and played a major role in the development of the U S livestock industry Currently less than one percent of all pigs are sold through terminal markets due to improved communication systems about when pigs are ready for market Auction markets were organized in many rural communities to provide a point of sal
42. delivered and e Individual animal treatment 3 SWINE FACILITIES Whether pigs are raised in pastures or in totally enclosed barns systems approaches are becoming the norm in pork production Repeatable management methods and specialization characterize the modern pork producer regardless of the type of facilities used The facility type is often based on capital investment labor requirement and management expertise Animal and worker welfare are primary concerns to producers The key to good swine care depends more on the producer s ability to properly manage housing than it does on the specific type of housing provided 3 1 Controlled Environment Confinement Controlled environment buildings require much higher initial investment but lower labor per unit of output These facil ities make handling hogs easier provide for more direct observation of animals allow greater control of the production process protect animals and workers from the heat cold rain and snow and usually result in more efficient growth A controlled environment uses specialized computer controllers which allow for the regulation of temperature and humidity These computer controllers can be very simple or quite sophisticated Electric fans provide ventilation and heaters provide warmth in the winter season Many controlled environment buildings have flexible curtains on the side walls that can be automatically opened and closed to allow circulation of fresh air Some ma
43. ducts 4 Composting on farm is an inexpensive option in some climates localities and it may require a large space access to water and co composting materials carbon rich sources such as sawdust wood shavings hay bales etc when incorporated into a sizable swine farm Well described techniques are available at http www extension iastate edu Publications PM1917 pdf and http www cast science org websiteUploads publication PDFs CAST 20I ssue 20Paper 2039 20FINAL155 pdf equipment needed and protocols will vary States will regulate whether this is an allowable disposal method proximity to groundwater and prevention of run on to and runoff from the composting area must be considered Producers using this method must have a plan in place for utilizing the finished compost spread on crop ground bedding When done properly composting can destroy most infectious disease agents FAD PReP Swine Industry Manual Page 19 of 58 Please refer to the FAD PReP NAHEMS Guidelines and SOP Disposal 2011 for specific details on each of the above described options in the event of a highly contagious FAD outbreak Other resources on animal mortality management includes Managing Contaminated Animal and Plant Materials A Field Guide on Best Practices available at http tammi tamu edu MortalitvTSWGeguide 2008 pdf and On Farm Euthanasia of Swine Options for the Producer National Pork Board American Association of Swine Veterinarians joint publicatio
44. e Check openings around augers pipes and wires Use mortar masonry or metal collars in these areas Doors windows and screens should fit tightly The distance between the bottom of the door and threshold should not exceed inch Drainage pipes or sewage systems may be used by rodents as routes to enter buildings Equip floor drains with metal grates openings less than 1 2 Remove potential hiding resting and nesting sites Equipment e g refrigerators powerwashers etc should be raised and easily movable to allow for easy cleaning behind and underneath them Sacked feed should be stacked on pallets with adequate space around and under them to allow easy inspection for signs of rodent activity and trap or bait placement Rats can burrow and nest under feed bunks placed directly on the ground Use of a concrete base around feed bunks can eliminate habitat Maintain the water level in livestock waterers so it is deep enough that birds cannot stand in it Hanging strips of heavy plastic vertically in door ways of buildings will allow machinery and people to pass through but keeps birds out This will not prevent rodent entry Cover the undersides of rafters with netting to exclude birds from nesting sites Eliminate potential food sources e Store feed in well sealed containers preferably metal with tight fitting lids e Use covered feeders that exclude birds e Clean up any spilled feed immediately Establish a
45. e Pierce RA Bait Stations for Controlling Rats and Mice University of Missouri Extension http muextension missouri edu explore agguidees wildlife g09444 htm e Brittingham MC Falker ST Controlling birds around farm buildings Pennsylvania State Univer sity Extension Attp pubs cas psu edu FreePubs pdfs uh126 pdf e See T Controlling rodents North Carolina State University Extension http www thepigsite com Featured Article Default asp Display 1015 e Baker RO Bodman GR Timm RM Rodent proof construction and exclusion methods University of Nebraska http www ces ncsu edu nreos wild pdf wildilfe RODENT PROOF CONSTRUCT PDF FAD PReP Swine Industry Manual Page 49 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Note Before disinfecting all surfaces must be cleaned This includes removing any visible material such as manure bedding and feed Product Dilution Acetic acid 5 vinegar Sodium carbonate 4 soda ash Sodium hydroxide 2 lye NaOH Sodium hypchlorite 1 10 6 0 NaOCl household bleach Proprietary products Mixing Instructions Add 8 ounces of glacial aceticl acid to 1 gallon of water Mix thoroughly Add 5 33 ounces sodium carbonate to 1 gallon of hot water or 1 pound to 3 gallons Mix thoroughly Add 1 3 cup of NaOH pellets 2 7 ounces of lye to 1 gallon of cold water Add 1 5 cups of chlorine bleach to 1 gallon of w
46. e disease Source e Code of Federal Regulations Title 9 Chapter I Part 71 1 Definitions Farms located on a single site selling only to terminal slaughter markets or using only their own pig transportation may keep few written records Slaughter facilities keep track of the farm of origin number of pigs unloaded and the trucking company 3 PRODUCT MOVEMENT Besides pigs moving to market other products move onto and off of swine operations 5 1 Semen Semen from boar studs is shipped both intrastate and interstate either by overnight shipment or delivery by a vehicle associated with the boar stud In most cases the biosecurity programs used at boar studs are very strict The extensive use of artificial insemination creates the potential for the rapid and extensive spread of any disease transmitted via the semen Semen doses should be identified with the premises identification number of the source herd for traceability 5 2 Manure Handling Manure is an inevitable by product of pork production It has been estimated that 500 finishing pigs produce nearly 3 000 cubic feet of manure in a month s time or 265 000 gallons of manure in a year Swine manure contains nutrients that can support crop production and enhance the soil s chemical and physical properties The plant nutrients in manure can reduce a producer s fertilizer costs Thus manure can be an asset to a pork production operation if its nutrient value is maximized Manure m
47. e for small groups of livestock from relatively small geographic areas Like terminal markets these markets are less numerous and handle fewer pigs today However they still provide needed market price discovery CS ee and livestock assembly services in some areas especially Wie FIE 2G A those distant from packing plants or terminal markets e Directly selling to slaughter houses meatpackers is the primary marketing option for the majority of the pigs produced Pigs are delivered directly to the plant or to buying stations Over 70 of the pigs produced in the U S are now sold on carcass merit pricing systems in which a portion of the price is determined by certain characteristics of the animal Based on consumer demand packers pay premiums for pigs with low amounts of fat and high amounts of muscle Specialty packers purchase under performing pigs that are often sold at lighter than normal slaughter weights when the producer determines that the pig is no longer growing at a profitable rate These pigs are often collected at buying stations from multiple owners for delivery to the specialty packers These are often referred to as roaster pigs Adult sows and boars at the end of their useful reproductive life also go to specialty packers These animals are sold on a daily basis to consolidators As the sows boars are off loaded an official USDA backtag is applied This generates a record linking the backtag to the previous owner prod
48. e neither gestating nor lactating Price Discovery A method of determining the price paid for a certain weight of pig based on current market conditions Roaster Pigs Underweight pigs within a group of market ready pigs that are too small to be accepted by a traditional slaughter plant These pigs are sent for sale for whole carcass roasting or barbequing Sale Barns A location for buying selling or trading pigs Segregated Weaning Facility A facility used to house piglets that are weaned early and moved to a separate site Single File Races A walkway or path setup to only allow one pig through at a time Sow An adult female pig which has had piglets Type Landfill Landfill that can accept household trash and industrial waste with authorization to do so Vaccination Crew A specialized group of individuals either company employees or for commercial hire that are trained to properly administer vaccines Vaccination teams can cover a large geographical area and come in contact with many different pigs on many different farms Vasectomized Excision of the vas ductus deferens that carries semen from the testicles of a boar to render it sterile Zoonotic disease Those diseases spread between animals and humans through direct contact with infectious fluids at farrowing during urination defecation eating undercooked pork or through vectors such as ticks or mosquitoes FAD PReP Swine Industry Manual Page 38 of 58 S
49. e nursery phase 45 75 lbs and pigs are much smaller coming in 12 15 lbs This smaller size can allow an operation to double stock them initially i e placing twice as many pigs into the pens until they grow to a larger size Double stocking will not adversely affect pigs as long as it is only done for 2 3 weeks and adequate feed and water are provided At the end of the nursery phase there is less of a window of opportunity to move pigs to the next phase Pigs will become too big size and weight for the facility Buildings reach their maximum ventilation capacity by this time In most nurseries holding pigs longer than one week past the scheduled exit date will create significant health and welfare problems for the pigs 9 3 Culls Pig cull markets and slaughter facilities are totally different than those used for normal market weight pigs Most swine producers hire a cull market company consolidators to take cull animals and sell them in larger groups to a slaughter facility Some slaughter facilities process thin cull sows while others can process a very large sow There are only a small number of facilities that can process cull animals in the U S making it impossible for them to handle large volumes of animals at any one time 9 4 Mortalities It is important to remember that most facilities have designed sized their method of carcass disposal based on usual mortality rates If a FAD causes higher than average mortality rates
50. eaks FAD PREP MISSION AND GOALS The significant threat and potential consequences of FADs and the challenges and lessons learned of effective and rapid FAD response have led to the development of the Foreign Animal Disease Preparedness and Response Plan also known as FAD PReP The mission of FAD PReP is to raise awareness expectations and develop capabilities FAD PReP Swine Industry Manual Page ii Swine Industry Manual surrounding FAD preparedness and response The goal of FAD PReP is to integrate synchronize and de conflict preparedness and response capabilities as much as possible before an outbreak by providing goals guidelines strategies and procedures that are clear comprehensive easily readable easily updated and that comply with the National Incident Management System In the event of an FAD outbreak the three key response goals are to 1 detect control and contain the FAD in ani mals as quickly as possible 2 eradicate the FAD using strategies that seek to stabilize animal agriculture the food supply the economy and protect public health and 3 provide science and risk based approaches and systems to facilitate continuity of business for non infected animals and non contaminated animal products FAD PReP DOCUMENTS AND MATERIALS FAD PReP is not just one standalone FAD plan Instead it is a comprehensive U S preparedness and response strat egy for FAD threats This strategy is provided and expl
51. ears shortly after birth For most grow finish pigs sows and boars unique individual animal identification is not required for movements within a state Most nursery and grow finish pigs can be identified as a group or lot thus negating the need for individual identification When a group is assembled the group gets a unique number but individual pigs are not identified The group is kept together and not commingled with other pigs throughout the growing finishing period and through the slaughter process When pigs leave the group for whatever reason they are individually identified Figure 3 Animal Identification Tattoos Ear notches are a form of on farm animal identi fication used for animal health management and husbandry purposes When piglets are born their ears may be notched using a special instrument to remove a small V shape from the edge of the ear to indicate which sow they were born to litter mark in the right ear and their number in the litter individual mark in the left ear To review all of ficial forms of identification see the Code of Federal Regulations Title 9 Chapter I Part 71 19 Identification of swine in interstate commerce For more information about the USDA s cooperative approach with States and Tribal Nations animal disease traceability visit the USDA Animal Disease Traceability website http www aphis usda gov traceability FAD PReP Swine Industry Manual Page 6 of 58
52. easures can help minimize the chance of CSF being introduced on your farm Farm Entrance Limit access to your farm e The entrance to your farm is a major control point e Gates at farm entries should be locked when not in use e By having only one gated entrance to the farm you can better control and monitor all visitors and vehicles arriving at your farm Post signs at the farm entrance Appendix B Signs inform unauthorized visitors to not enter your farm When entry is necessary signs give specific rules and biosecurity measures to follow while on your farm Restrict or limit visitors on your farm e Atall times limit the number of visitors to the farm e Visitors who have traveled internationally within the past five days should not be allowed to enter the farm e Post warning signs indicating entry onto the farm is not allowed without permission Strict biosecurity measures must be followed by any visitors to the farm Some visitors are essential for the continued operation of the farm Establish strict biosecurity procedures for these individuals then inform them of the measures to follow while on your farm FAD PReP Swine Industry Manual Page 51 of 58 Prevention Practices for Classical Swine Fever CSF oe e Honk before getting out of their vehicle to announce their arrival e Check in with farm personnel upon arrival direct visitors to where they should check in e Be accompanied by someone fr
53. es for Swine Intramuscular Injection Gauge Length inches Baby Pigs 18 or 20 5 8 or V2 Nursery 16 or 18 4 Oh 3 Finisher 16 1 Breeding Stock 14 15 or 16 1 or 1 Subcutaneous Injection Gauge Length inches Nursery 16 or 18 y2 Finisher 16 Ja Breeding Stock 14 or 16 r Source PQA Plus Producer Certification Book National Pork Board 9 PRODUCT HANDLING 9 1 Market Weight Animals Pigs raised in the U S have been genetically designed to maximize performance at a specific end weight Most pigs are marketed at 240 280 pounds and are sold under a carcass merit program Each slaughter house packing plant sells its product into specific meat markets and thus targets specific market weights In the event of a disease response moving pigs to market at heavier than normal weights can impact the animals because housing requirements change as they get larger Producers and packing plants also have contractual obligations to meet Most pigs are taken to market in groups of 170 200 one semi trailer load As a general rule packing plants either process smaller pigs 220 260 pounds or larger pigs 250 290 pounds Slaughter plants have been designed to accommodate a particular carcass weight The average chain speed of a U S packing plant is 1 000 pigs per hour and there is not time to make slight adjustments for different sized animals Operations that provide pigs that do not meet a particular packing plant target weight too smal
54. es with pens commonly containing 30 to 50 animals Pigs are usually in this phase for 17 20 weeks entering as feeder pigs 45 55 pounds and leaving as market weight pigs 240 280 pounds 3 1 6 Wean to Finish Wean to finish is a type of production system that combines the nursery and grow finish stages into one production phase Pigs are moved to a special finishing barn at weaning 16 23 days of age and remain in this facility until they reach market weight There are multiple pens per room and multiple rooms per barn To accommodate the younger pigs additional heating equipment may be used in the pens 3 1 7 Boar Stud A boar stud is a specific area or building used for holding boars and collecting semen for artificial insemination AT Boars are often housed in individual stalls Boar studs may be housed within a Breeding Gestation Farrowing BGF barn with the semen produced subsequently used within that BGF or a production system may have a stand alone boar stud that produces semen for use at multiple BGF farms There are also commercial boar studs that produce semen for retail sale to multiple customers In most cases the biosecurity programs used at boar studs are very strict because the use of AI creates the potential for rapid and extensive spread of any disease transmitted via semen 3 2 Outdoor Rearing Systems Pasture or outdoor production systems generally require a lower capital investment especially when marginal land can
55. etails on the zones areas and premises please see the APHIS Framework for Foreign Animal Disease Prepared ness and Response For additional information integrating the zones areas and premises designations with specific FAD response strategies please see the disease specific response plans such as the FMD Response Plan The Red Book These documents are available on the following sites e FAD PReP collaboration website at https fadprep mi org e APHIS FAD PReP website for APHIS employees at http inside aphis usda gov vs em fadprep shtml FAD PReP Swine Industry Manual Page 23 of 58 7 DISEASE SPECIFIC BIOSECURITY MEASURES In the event of a highly contagious FAD outbreak biosecurity measures must be enhanced and more strictly enforced to minimize the risk of introduction Exposure to disease can occur through five main routes of transmission aero sol direct contact fomite oral and vector borne Humans are exposed to zoonotic diseases via the same five routes of transmission Disease specific biosecurity measures aimed at preventing exposure to FMD and CSF are provided as appendices These biosecurity measures can also be applied to other diseases with similar exposure routes Swine Routes of Transmission Appendix A e FMD spread by aerosol direct contact fomite oral Appendix B e CSF spread by aerosol direct contact fomite oral vector Appendix C In order for an epidemiological investigation to d
56. etermine potential exposures during a highly contagious FAD event operations should keep an inventory of animals in the herd including identification numbers breed age origin and location Animal movement to and from the farm should also be recorded including date animal ID origin destination reason for movement driver vehicle used previous owners name and phone number Likewise movement logs for equipment feed and semen should include dates origins destinations delivery person salesman and the insemina tor s name Finally pets and other animals located on the premises should be documented While ideal this may not be achievable on U S swine operations the depth of record keeping really varies by operation 8 PROVIDING ANIMAL CARE During a disease response producers may experience disruptions in supply deliveries and animal transportation Producers and support industry personnel should develop plans prior to an outbreak to ensure animals continue to receive proper care during a disease response Table 8 General Estimates on 8 1 Feeding Average Feed Consumption During a disease response the on farm inventory of feed Pounds of Feed must be promptly ascertained along with the rate at which it will be depleted in order to determine when more feed will be needed Table 8 provides general estimates of the Boars 5 6 amount of feed consumed per day by each animal in various life stages on an as fed basis Transportation routes
57. growth Returning decontaminated manure to a stable pH prior to application is an option with associated costs but may be the best option in certain situations The application of untreated manure has the potential to spread disease to other pigs livestock e g cattle grazing and possibly wildlife Manure handling equipment must be considered a biosecurity risk and should be properly cleaned and disinfected between operations 10 SURVEILLANCE Within 48 hours of the identification of the index case a surveillance plan will be implemented to define the extent of the highly contagious FAD outbreak and to detect unknown but Infected Premises and new cases quickly through a combination of observation and laboratory testing This surveillance plan may include the susceptible wildlife population in the area Information will also be gathered for a surveillance plan to identify disease free zones so that this portion of the plan can be implemented within seven days of the identification of the index case FAD PReP Swine Industry Manual Page 27 of 58 Infected Contact Suspect and At Risk Premises will all be involved in some level of surveillance in an effort to control and contain disease spread or determine freedom from disease Initial surveillance of susceptible animals will be visual inspection As soon as practical surveillance will include laboratory testing of susceptible animals Contact and Suspect Premises should be inspected at least three
58. hased feed supplements protein sources vitamins and minerals to create customized diets for their pigs Other farms choose to purchase complete feeds that do not require further preparation on farm and can be fed directly to the pigs upon delivery from a vendor Some large production systems construct large centrally located feed mills to deliver complete feeds to their farms On large operations feed deliveries can be a daily occurrence due to the large amount of feed that may be consumed Each system of feed manufacture has tradeoffs including biosecurity considerations diet flexibility degree of management and expertise required and quality control For many farms any halt in feed deliveries will result in a welfare situation within days 3 3 2 On Site Storage Some producers have on farm feed mills and mix feed from individual ingredients which is then transported to feed bins next to the animal barns Others use homegrown grain and either a commercial protein supplement containing the needed protein vitamins and minerals or add a protein meal soybean canola peas etc and a premix that contains only vitamins and minerals Many farms purchase complete feeds from commercial manufacturers These diets require no further processing or mixing but require storage on site 3 3 3 Delivery to Animals The feed delivery system used on a particular site depends upon the management style the facility layout and the soc
59. he method and procedures used for depopulation will depend on available resources and the population dynamics of susceptible animals on the premises This requires location specific planning and preparation which is addressed in the FAD PReP NAHEMS Guidelines and SOP Mass Depopulation and Euthanasia 2011 13 DISPOSAL FAD PREP NAHEMS GUIDELINES AND SOP Animal carcasses and associated contaminated materials e g feed bedding must be disposed of in a way to limit disease spread using State or municipality approved methods Once euthanasia 1s complete specific personnel will be assigned to an operation to carry out these activities For additional information see FAD PReP NAHEMS Guidelines and SOP Disposal 2011 14 CLEANING AND DISINFECTION FAD PREP NAHEMS GUIDELINES AND SOP Facilities that housed infected animals and equipment used in their daily care must be cleaned and disinfected to prevent the spread of disease to live animals returned to the operation Coordination of equipment supplies scheduling and certifying work completed by the producer contractors or animal health response teams will be carried out by USDA APHIS VS Items that cannot be adequately cleaned and disinfected will be properly disposed of once their value is determined For additional information see FAD PReP NAHEMS Guidelines and SOP Cleaning and Disinfection 2011 15 WILDLIFE MANAGEMENT AND VECTOR CONTROL FAD PREP NAHEMS GUIDELINES AND SOP Wildlife
60. he newborn pigs These facilities reduce the risk newborn pigs will be crushed by sows by accidentally laying on them and prevents injury to pigs or workers if the sow s protective mothering instincts cause aggressive behavior Heat lamps and mats are commonly used to keep the newborn piglets warm without altering the ambient temperature for the sow Farrowing rooms are thoroughly cleaned and disinfected before a new group of sows enter 3 1 4 Nursery Swine nurseries provide pen housing with multiple pens in one room and often multiple rooms in one barn The number of animals in one pen varies but is often 20 to 30 head Biosecurity between rooms can be extensive to limit disease spread between animal groups Most housing for newly weaned pigs has slotted floors to allow the pigs waste to fall through into a holding pit or gutter This keeps floors drier and cleaner to keep pigs comfortable and growing The slot ted floors are made of easily cleaned easily maintained and comfortable materials FAD PReP Swine Industry Manual Page 12 of 58 3 1 5 Grow Finish Grow finish housing is pen housing with multiple pens in one room and usually more than one room in a barn Biosecurity between rooms is often minimal but biosecurity between barns may be more extensive Slotted floors are commonly used in grow finish facilities to aid in manure removal and to keep the pigs in a cleaner environment Group sizes vary in grow finish faciliti
61. he signs of illness in pigs with CSF and e Know who to contact if signs of disease are seen Animal Movement If CSF is confirmed in the U S movement restrictions may be implemented locally regionally and possibly nationally Restrictions will depend on the scope of the outbreak Know the health status and the source of any animal s brought onto your farm If animal movement is allowed in your area thoroughly clean and disinfect the vehicle and trailer before loading and after unloading e Pay special attention to the tires and wheel wells e Avoid mixing pigs from different sources when transporting FAD PReP Swine Industry Manual Page 52 of 58 Prevention Practices for Classical Swine Fever CSF Tr Maintain thorough and accurate records of animal movement e Document all animal movements including the dates of introduction into the herd where they came from and movements between separate units e Each farm location must be treated as a separate unit or premise This information will be essential to help trace where the disease came from Animals Where licensed garbage feeding has been per mitted in the past contact the state regulatory agency before feeding cooked garbage to swine to determine if regulations have changed Do not allow your animals to have contact with wildlife e Feral swine are also susceptible to CSF and if infected could potentially spread the virus to domestic swine Monitor anim
62. hey are raised until they reach market weight Most finishing facilities are on a separate site from the nursery which may again require the interstate transport of the pigs At the time pigs reach market weight gilts are selected to become replacements and will be housed in a breeding gestation facility The remainder of the market weight pigs will then be sent to slaughter Transport to slaughter often requires interstate movement of the pigs Each production phase has facilities to house a certain number and size of animals A producer plans the number of gilts sows to breed and knows how many sows will farrow and the approximate number of piglets born in a given time frame The breeding and farrowing process is done with relative accuracy so that the next production phase receives the right number of animals A change in pig flow in one area can affect multiple facilities producers and how many animals reach market Breeding Facility 2 2 Breeding Adults Sows Boars 2 2 1 Sows Breeding is an essential phase of swine production There is no defined breeding season in the domestic pig Gilts reach puberty around 6 to 8 months of age and post pubertal females generally exhibit estrus every 21 days After weaning sows usually return to estrus within 5 to 7 days Intensive management systems generally set annual goals of approximately 2 5 litters per sow Many elements comprise the breeding process such as genetics timing and na
63. his illustration depicts the various injection sites used in swine based on size and whether the injection is to be given subcutaneously or intramuscular Subcutaneous injections should be given in the loose flaps of flank skin or behind the elbow in small pigs and in the neck behind the ear at the same location as intramuscular injections in larger pigs Slide the needle under the skin and away from the site of skin puncture before depositing the vaccine Content provided by National Pork Board Graphic illustration by Andrew Kingsbury Iowa State University Page 26 Top Table 9 Recommended Needle Sizes for Swine Content provided by National Pork Board Graphic illustration by Dani Ausen Iowa State University Bottom Off loading grow finish pigs from a livestock trailer Photo source Alex Ramirez Veterinary Diagnostic and Production Animal Medicine Iowa State University Page 27 An example of a liquid manure injection system used on a swine production facility Photo source Alex Ramirez Veterinary Diagnostic and Production Animal Medicine Iowa State University Page 28 Photo of signs located at the entrance of a swine facility warning of a disease control area and notifying visitors of the need to check in with management before entering the farm Photo source Veterinary Diagnostic and Production Animal Medicine Iowa State University Page 29 Top Photo depicting a veterinarian collecting blood to submit for testing Photo source Alex R
64. hoto source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Bottom Sow Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Page 9 Top Insemination of the sow or gilt begins by stimulating the animal with adjacent boars Once the sow gilt is stimulated an insemination rod is inserted into the cervix and semen is deposited by a trained professional Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Center Boar Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Bottom Semen doses are extended with an extender that provides nutrients and antibiotics to extend the life of the semen Extended semen can be stored at 63 degrees Farenheit for a maximum of five to seven days in a shipping container such as the one shown in the photograph Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Page 10 Top Piglets nursing from their mother in a farrowing crate which keeps the mother from lying on her piglets Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine FAD PReP Swine Industry Manual Page 32 of 58 Photo and Illustration Credits Center Table 3 Common Procedures Performed on Piglets by Day of Age Photo of piglets in a pen Content provided by Alex Ramirez Veterinary Diagnostic and Production Animal Medicine Iowa S
65. ial interactions between pigs Common methods of feed Automated Feed Delivery delivery include automated systems and hand delivery FAD PReP Swine Industry Manual Page 14 of 58 3 3 3 1 Automated Systems Feed is pulled from the feed bin using an auger and delivered to pigs via feed lines The feed is automatically dispensed into a feed holding tub or feeder Feed delivery can be triggered by feed consumption from a designated feeder typically at the end of the barn or manually turned on by a worker If a barn of pigs needs to be emptied ensure that the pen with the designated feeder is emptied last to ensure all other pens continue to receive feed This automated system requires a power source i1 e electricity to get the feed from the storage facility to the pigs 3 3 3 2 Hand Delivery Hand feeding is more labor intensive than other feed delivery systems Workers are responsible for visually monitoring feed intake and delivering feed to the pens This method is designed to meet individual nutritional needs of pigs and allows for increased accuracy in feed records Hand feeding is usually used in outdoor rearing systems and in farrowing rooms where individual sow feed intake needs to be regulated 3 3 4 Records Feed records are important to monitor animal production feed use feed quality and for tracing purposes Important data recorded includes e Amount of feed delivered e Feed ingredients grain protein minerals vitamins e
66. ices for Classical Swine Fever CSF ua aa Appendix C Daily Visitor Log Name and Date of Last Reason for Visit Contact with Time in Time Out Phone Number Livestock FAD PReP Swine Industry Manual Page 57 of 58 Prevention Practices for Classical Swine Fever CSF Or EN Purple skin discoloration body Purple skin discoloration ears Source Dr R Thanawongnuwech Veterinary Pathology Source Dr R Thanawongnuwech Veterinary Pathology Chulalongkorn University Chulalongkorn University Hemorrhages on the kidney Hemorrhages on the lung Source Plum Island Animal Disease Center Source Plum Island Animal Disease Center Sick pigs huddling Source Dr R Thanawongnuwech Veterinary Pathology Chulalongkorn University FAD PReP Swine Industry Manual Page 58 of 58
67. ill vary greatly by region of the country infected and depend on impacts to both the domestic economy and foreign trade This decision will be made by the Chief Veterinary Officer CVO at the federal level Proactive discussions as to the optimal vaccination strategies in a given region based upon livestock demographics and foreign trade impacts will better prepare decision makers and industry for real time decisions of this nature It is prudent to keep in mind that for vaccination to live strategies tracking and permitting of vaccinated animals will likely need to occur for the life of the animal and may impact movement of other unvaccinated livestock in that vaccinated region If vaccination is implemented the product will be made Figure 7 Injection Sites in Swine available by regulatory officials Guidance as to dose delivery method and how to administer the product will be provided In some cases the regulatory officials may Subcutaneous small pigs require administration by state federal personnel rather than commercial or in house vaccination crews In other situa tions these crews may be utilized Individual situations will be taken into consideration and may vary among operations depending on their proximity to the Infected Premises and Control Area ae Intramuscular all Whenever vaccines need to be administered follow the Subcutaneous large pigs dosage and injection site recommendations provided with the vaccine En
68. ings vehicles trailers equipment and supplies e Tires and wheel wells of vehicles and trailers are especially important e Surfaces should be scraped cleaned with high pressure hot water and detergent and rinsed e The disinfectant should then be applied and allowed to sit for the optimal contact time FAD PReP Swine Industry Manual Page 43 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Foot and Mouth Disease FMD is a highly contagious disease of swine The virus is shed in expired air saliva blood urine feces and semen The various routes of transmission for the virus are listed below FMD is not zoonotic it does not affect humans Oral Pigs may ingest the FMD virus in contaminated feed such as unpasteurized milk or uncooked meat products or by licking or chewing on contaminated environmental objects Direct Contact Pigs can be exposed by contact with infected pigs The virus can enter through open wounds or mucous membranes e g eyes nose mouth following nose to nose contact rubbing or biting Reproductive The FMD virus can be shed in semen during mating Fomites Objects contaminated by infected pigs e g equipment buckets feeders can transfer the virus from one susceptible animal to another This includes vehicles trailers and clothing boots worn by people because they can transfer the virus to another location Aerosol The virus can be carried
69. irkpatrick Idaho USDA and Danelle Bickett Weddle Iowa State University Page iii FAD PReP Suite of Documents and Materials Graphic illustration by USDA Page 1 The official logos of USDA APHIS and OIE Graphic illustration of the USDA APHIS and OIE logos by Dani Ausen Iowa State University Page 2 Top Figure 1 Products and Byproducts of Swine Many different products that can be produced from pigs such as meat heart valves suede insulin etc Graphic illustration by Dani Ausen Iowa State University Bottom Illustration depicts the billions of pounds of imports and exports of pork production Graphic illustration by Dani Ausen Iowa State University Page 3 Top Figure 2 Potential Movement of Swine Arrows depict the movement of swine under the control of a single owner or group of contractually connected owners from one site of production to another such as sow herds nursery herds growing or finishing herds but does not include slaughter plants or livestock markets Content provided by Spencer Wayne Graphic illustration by Dani Ausen Iowa State University Bottom Definition of inshipments Graphic illustration by Dani Ausen Iowa State University Page 4 Table 1 Total Number of Inshipments by State in 2007 Content provided by USDA NASS Graphic illustration by Dani Ausen Iowa State University Page 5 Table 2 Type and Frequency of Vehicle Personnel Movement onto Swine Operations Content provided by Alex Ramirez Ve
70. is FAD PReP Swine Industry Manual and provide further details when necessary This document references the following APHIS documents e APHIS Framework for Foreign Animal Disease Preparedness and Response Plan e FAD PReP NAHEMS Guidelines Appraisal and Compensation 2011 Biosecurity 2011 Cleaning and Disinfection 2011 Disposal 2011 Surveillance Epidemiology and Traceability 2011 Personal Protective Equipment 2011 Mass Depopulation and Euthanasia 2011 Vaccination for Contagious Diseases 2011 with Appendix A FMD Considerations and Strategies 2011 Wildlife Management and Vector Control 2011 e FAD PReP Standard Operating Procedures SOP Appraisal and Compensation 2011 Biosecurity 2011 Cleaning and Disinfection 2011 Disposal 2011 Surveillance Epidemiology and Traceability 2011 Personal Protective Equipment 2011 Mass Depopulation and Euthanasia 2011 Vaccination for Contagious Diseases 2011 with Appendix A FMD Considerations and Strategies 2011 Wildlife Management and Vector Control 2011 e FMD Response Plan The Red Book USDA APHIS VS Memo 580 4 Procedures for Investigating a Foreign Animal Disease Emerging Disease Incident FAD EDI October 2008 These documents are available on the FAD PReP collaboration website at https fadprep mi org Username and password can be requested Additional information can also be obtained from e Pork Industry Hand
71. is not intended to reflect their importance nor is it intended to constitute approval or endorsement of any views expressed or products or services offered on these outside web sites or the organizations sponsoring the web sites Trade names are used solely for the purpose of providing spe cific information Mention of a trade name does not constitute a guarantee or warranty of the product by USDA or an endorsement over other products not mentioned USDA prohibits discrimination in all its programs and activities on the basis of race color national origin sex religion age disability political beliefs sexual orientation or marital or family status Not all prohibited bases apply to all programs Persons with disabilities who require alternative means for communication of program information Braille large print audiotape etc should contact USDA s TARGET Center at 202 720 2600 voice and telecommunications device for the deaf TDD To file a complaint of discrimination write USDA Director Office of Civil Rights Room 326 W Whitten Building 1400 Independence Avenue SW Washington DC 20250 9410 or call 202 720 5964 voice and TDD USDA is an equal opportunity provider and employer Iowa State University does not discriminate on the basis of race color age religion national origin sexual orientation sex marital status gender identity disability or status as a U S Veteran Any persons having inquiries concerning thi
72. isease Understanding how FMD is spread to and between pigs can help highlight the importance of biosecurity measures needed on your farm and help you recognize areas that may need additional work to prevent disease introduction and spread FMD virus can be found in all body fluids of infected pigs including nasal secretions blood urine feces saliva and even semen see Appendix A Pigs produce large quantities of aerosolized FMD virus but pigs are less susceptible to this route of exposure than cattle or sheep FMD can be spread orally by ingestion of contaminated feed including garbage swill or meat products Transmission can also occur through direct contact with infected animals The virus can also be spread reproductively This can occur via semen boar to sow or during pregnancy sow to piglet FMD virus can also survive in the environment contaminating equipment pens buckets even footwear and clothing of people in contact with infected pigs These items termed fomites can serve as an ad ditional source of virus for susceptible pigs If infected pigs are transported in vehicles or trailers these items can also become contaminated and serve as a source of the virus on the farm or to other farms if not properly cleaned and disinfected These exposure routes should be considered when implementing biosecurity measures to prevent the introduction of FMD onto your farm General Precautionary Measures Preventio
73. ity and extent of records kept on swine farms varies As a general rule financial and production records are maintained separately although software packages that integrate these functions are becoming more widely available This section briefly describes the management information recorded on most swine farms Several computerized production record systems are available Common data recorded in the Breeding Gestation and Farrowing production stages includes e Mating information dates boar ID e Pregnancy testing date result e Farrowing date FAD PReP Swine Industry Manual Page 10 of 58 e Feed intake during lactation e Litter information number born alive dead neonatal mortality and e Weaning information date number weight The Nursery and Grow Finish production stages often have less intensive record keeping systems The continuous flow nature of these production stages creates challenges for maintaining concise growth and performance data An increasing number of farms have chosen to create batches or groups of pigs identified by pen room or building that provides an opportunity for thorough collection of data In these situations a group is established by an all in all out procedure accounting for all inputs allocated to the group Data collected in most Nursery and Grow Finish stages includes e Number of pigs in a group e Starting weight e Mortality e Sale weight e Amount of feed
74. l courier or delivered by a vehicle associated with the boar stud Carbon Dioxide Chambers An anesthesia chamber used to administer carbon dioxide gas for the humane slaughter of swine Conveyor Restrainers A restraint mechanism used in slaughter houses to move pigs Corn Belt States Traditional area in the Midwest Indiana Illinois Iowa Missouri Nebraska Kansas in which corn and soybeans are the dominant crops Creep Areas Areas where piglets can eat their feed away from the sows Epididymized Excision of the epididymis that stores allows semen to mature and transports it from the testicles of a boar to render it sterile Farrowing Giving birth to piglets Farrowing is also the term used to describe the production phase between birth and weaning of the piglets Feed Bin A metal upright storage tank that holds feed grain protein minerals which is often located near the barn for easy dispensing Flight Zone The area around an animal that will cause alarm and escape behavior when encroached upon Gilt A female pig that has not yet had piglets Grow Finish Production phase in which pigs are grown to market weights FAD PReP Swine Industry Manual Page 37 of 58 Glossary Inshipments The total number of hogs shipped into a state for feeding or breeding purposes excludes animals brought in for immediate slaughter Needle Teeth The sharp pointed canine teeth of a piglet Nonproductive Sow Sows that ar
75. l or too big are financially penalized The delivery of pigs to each packing plant is also tightly scheduled to keep the proper flow of pigs chain speed in the system Many times truckers delivering pigs only have a 2 hour window to meet their contract Most of today s pigs are marketed to a packing plant based on a specific contract that dictates the number of pigs to be delivered to a particular company in a specified timeframe These are legal contracts requiring agreement by both parties before any changes can be made In the event of a highly contagious FAD outbreak transportation may be disrupted and the contract packing plants may be outside the permitted travel area Given the type of equipment required to process pigs of different sizes redirecting market pigs from packing plant A to plant B is not an easy task Producers will need reassurance that plant A will allow them to void their contractual obligations without severe financial penalties Likewise plant B must be willing and able to process the pigs and FAD PReP Swine Industry Manual Page 26 of 58 compensate producers for their pigs Re routing market weight pigs requires consideration by the packing plants producers and regulatory officials so as not to cause undue financial hardship to any one sector 9 2 Nursery Pigs There is more flexibility in the movement of pigs in and out of a nursery Nursery facilities are designed based on the pigs weight at the end of th
76. may be disrupted so plans for alternate feed sources and delivery Animal Category Consumed Per Day Gestating Sows 5 nae aaa routes should be made before the situation arises Depending on the feeding system in place manual feeding may be Farrowing Sows 12 required Recording the origin of the feed delivery the date and the amount is necessary to maintain operation records 25 to 75 b Pigs 1 3 to 3 5 8 2 Breeding 100 to 200 Ib Pigs 4 5 to 6 2 Breeding is an extremely time sensitive situation and plan ning for how it will be handled needs to occur early in an 225 Ib to Market 6 5 to 7 0 outbreak situation Most sows will return to estrus around 5 days after weaning and therefore the timing of weaning is scheduled to minimize matings over the weekend when labor is limited Sows in estrus after weaning will only stay in heat for 2 3 days Therefore it is imperative to get semen onto the farm as soon as possible to breed the animals Most farms do not have breeding boars available on site and semen is scheduled for delivery twice a week Plans should be in place to accomplish this in the event transportation routes are disrupted This is critical to maintaining the operation s pig flow and continuity of business 8 3 Farrowing Farrowing space per animal and facilities are designed based on a given number of animals on farm and the man agement s plan for breeding farrowing and movement of pigs to the next stage A disease outbre
77. mmary of Premises Designations Animal Category Definitions Zone Infected Premises IP Premises where a presumptive positive case or Infected Zone confirmed positive case exists based on laboratory results compatible clinical signs case definition and international standards Contact Premises CP Premises with susceptible animals that may have Infected Zone been exposed to the FAD agent either directly or Buffer Zone indirectly including but not limited to exposure to animals animal products fomites or people from Infected Premises Suspect Premises SP Premises under investigation due to the presence Infected Zone of susceptible animals reported to have clinical Buffer Zone signs compatible with the FAD This is intended to Surveillance Zone be a short term premises designation Vaccination Zone At Risk Premises ARP Premises with susceptible animals but none have Infected Zone clinical signs compatible with the FAD Premises Buffer Zone objectively demonstrates that it is not an Infected Premises Contact Premises or Suspect Premises At Risk Premises seek to move susceptible animals or products within the Control Area by permit Only At Risk Premises are eligible to be Monitored Premises Monitored Premises MP Premises objectively demonstrates that it is not an Infected Zone Infected Premises Contact Premises or Suspect Buffer Zone Premises Only At Risk Premises are eligible to become Monitored Premises Monitore
78. monstrate absence of the disease for permitted animal movement and accurate timely result reporting is essential Samples obtained in the field should be properly packaged to prevent leakage individually sealed plastic bags around each fluid tube and thus contamination of samples within or external to the box cooler Completed paperwork should also be placed in a sealed plastic bag Cold packs are recommended instead of ice for transporting samples Be aware of environmental temperatures and provide enough cold packs to keep tissues from degrading in transport 11 APPRAISAL AND COMPENSATION FAD PREP NAHEMS GUIDELINES AND SOP Animal health regulatory officials will create an inventory of animals designated for depopulation and appraise their fair market value in order for compensation to be paid Contaminated materials on farm feed bedding will also be appraised as they may need to be disposed of in an effort to control disease spread Facilities and equipment that cannot be properly disinfected must also be destroyed and fair market value assessed Please refer to the FAD PReP NAHEMS Guidelines and SOP Appraisal and Compensation 2011 for specific details on this process FAD PReP Swine Industry Manual Page 29 of 58 12 MASS DEPOPULATION AND EUTHANASIA FAD PREP NAHEMS GUIDELINES AND SOP To control disease spread infected and exposed animals may be depopulated by qualified personnel according to USDA APHIS and AVMA guidelines T
79. n www pork org 4 2 7 Records The quality of transportation and movement records can vary widely between farms Large farms and breeding stock suppliers that utilize contract haulers or conduct animal movements that utilize interstate Certificates of Veterinary Inspection for individually identified animals or interstate swine movement reports for group lot identified animals often have extensive databases to manage the process The interstate swine movement report includes e The name of the swine production system e The name location and premises identification number of the premises from which the swine are to be moved e The name location and premises identification number of the premises to which the swine are to be moved e The date of movement e The number age and type of swine to be moved e A description of any individual or group identification associated with the swine e The name of the swine production system s USDA Accredited Veterinarian s e The health status of the herd from which the swine are to be moved including any disease of regulatory concern to APHIS or to the States involved and e A statement that swine on the premises from which the swine are to be moved have been inspected by the swine production system s accredited veterinarian s within 30 days prior to the interstate movement and are consistent with the dates specified by the premises swine production health plan and found free from signs of communicabl
80. n measures to minimize the introduction and spread of FMD on your farm fall into three general categories 1 Use strict biosecurity measures for animals animal products vehicles people and equipment 2 Restrict or stop all animal movement to prevent entry or spread of the disease 3 Detect and report any disease or unusual signs to your herd veterinarian as quickly as possible Specific steps to take if FMD is confirmed in the U S are listed below Many should already be in place on your farm but should be enhanced and more strictly enforced if FMD is found in the U S These measures can help mini mize the chance of FMD being introduced on your farm Farm Entrance Limit access to your farm e The entrance to your farm is a major control point e Gates at farm entries should be locked when not in use e By having only one gated entrance to the farm you can better control and monitor all visitors and vehicles arriving at your farm Post signs at the farm entrance Appendix B Signs inform unauthorized visitors to not enter your farm When entry is necessary signs give specific rules and biosecurity measures to follow while on your farm Restrict or limit visitors on your farm e Atall times limit the number of visitors to the farm e Visitors who have traveled internationally within the past five days should not be allowed to enter the farm e Post warning signs indicating entry onto the farm is not allowed without permis
81. ndices FMD prevention practices CSF prevention practices Learning Objectives Upon reviewing this manual readers will be able to 1 Describe the various types of housing for swine 2 Explain the animal care needs of piglets growing pigs and adult swine 3 Illustrate FAD response zones and areas used in quarantine and movement control efforts and explain classifications of premises in a response 4 Implement biosecurity measures and surveillance activities on a swine farm to prevent highly contagious foreign animal disease entry and monitor its presence absence 5 Communicate with supervisory personnel and or the regulatory officials regarding swine farm status animal needs biosecurity measures in place test results tracebacks traceouts facility flow and 6 Identify biosecurity deficiencies that increase a premises chances of becoming infected transmitting the highly contagious FAD PART I UNITED STATES SWINE PRODUCTION 1 SCOPE OF THE SWINE INDUSTRY Over the last 10 to 20 years the U S pork industry has evolved to include larger sized technology dependent highly integrated farms that produce a safe food source for the United States and the world Pork was regarded as FAD PReP Swine Industry Manual Page 1 of 58 the most widely eaten meat in the world in 2005 Along with meat other important products from swine are insulin valves for human heart surgery suede and gelatin for food uses Pigs also generate important b
82. ne 515 294 1492 4700 River Road Unit 41 Fax 515 294 8259 Riverdale Maryland 20732 1231 Email cfsph iastate edu Telephone 301 734 8073 Fax 301 734 7817 subject line FAD PReP Dairy Industry Manual E mail FAD PReP Comments aphis usda gov While best efforts have been used in developing and preparing the FAD PReP Swine Industry Manual the U S Govern ment U S Department of Agriculture and the Animal Plant and Health Inspection Service and Iowa State University of Science and Technology ISU and other parties such as employees and contractors contributing to this document neither warrant nor assume any legal liability or responsibility for the accuracy completeness or usefulness of any information or procedure disclosed The primary purpose of the FAD PReP Swine Industry Manual is to provide guidance to those government officials responding to a foreign animal disease outbreak It is only posted for public access as a reference The FAD PReP Swine Industry Manual may refer to links to various other Federal and State agencies and private organizations These links are maintained solely for the user s information and convenience If you link to such site please be aware that you are then subject to the policies of that site In addition please note that USDA does not control and cannot guarantee the relevance timeliness or accuracy of these outside materials Further the inclusion of links or pointers to particular items in hypertext
83. oduced including boar identification so that a trace back could be implemented if needed This could be helpful information in the event of a highly contagious FAD spread via semen 2 3 Gestation Gestation ranges from 112 to 116 days depending on the breed litter size and season It is often stated as 3 months 3 weeks and 3 days 114 days It is important that animal movement and stress are kept to a minimum in the first 5 30 days of pregnancy to prevent early embryonic death FAD PReP Swine Industry Manual Page 9 of 58 2 4 Farrowing Farrowing is the term used to describe the production phase between birth and weaning of the piglets After birth several procedures may be performed on piglets to improve their survival chances and or to prevent future problems These procedures include disinfecting navels to prevent infections clipping needle teeth to prevent injuries to other pigs or the sow giving supplemental iron injections to improve the blood s oxygen carrying capacity docking tails to prevent future injury and castrating boars to prevent off flavored meat boar taint Vaccinations may coincide with some of these procedures but will vary by operation Antibiotics may also be given for the more invasive procedures but again will vary Weaning usually occurs at 18 21 days of age Facilities that are less intensively managed 1 e non confinement will often wean later than 21 days of age Table 3 Common Procedures Perf
84. om the farm at all times to ensure biosecurity measures are being followed e Visitors and vehicles should avoid contact with animals or animal areas unless absolutely necessary e If animal contact is necessary wear clean farm specific protective clothing e g coveralls boots while on the farm Guide visitors to where protec tive clothing is located These items should remain on farm when the visitor leaves Monitor and record all traffic on or off your farm Maintain a log sheet Appendix C of all visitors and ve hicles that enter your farm Accurate record keeping of traffic on your farm will help with disease surveillance and tracking if necessary You should not rely on your ability to recall visitors and vehicles that were on your farm Vehicles Minimize traffic onto your farm to only vehicles essential for continued operation e Vehicles should be parked at the farm entrance away from animal areas or in designated parking areas preferably concrete or paved e Off farm vehicles should not be allowed to drive onto your farm unless necessary If necessary vehicles should be cleaned and disinfected or restricted to areas where vehicle traffic is allowed e Have deliveries left at the farm entrance whenever possible Clean and disinfect vehicles prior to entry and upon leaving e All vehicles entering the farm must first clean off then spray their wheels wheel wells and under carriage with disinfectan
85. ome language barriers Not all translators however have the necessary background in animal health emergencies and livestock production Pre qualifying translators before they are needed can help to ensure that they have the requisite knowledge If language barriers still exist demonstrating concepts or tasks can be helpful It is also important to remember that not all workers can read in their native language Having a variety of educational tools the more visual the better can be an effective way of explaining what is needed Being aware and respectful of ethnic and cultural differences is critical for effective communication so that disease prevention practices can be implemented Depending on the highly contagious FAD strategies to control its spread could include mass depopulation of infected animals and subsequent disposal on farm or in the community Farm workers owners and outside labor may be directly involved in this process Workers and owners may not be prepared to deal with the loss of animals that have been a part of their lives and a source of livelihood Returning to an empty farm in subsequent days weeks may also be another psychologically upsetting situation Providing a support network for owners and their workers again in an ethnically and culturally acceptable format needs to be part of preparedness plans at the local level FAD PReP Swine Industry Manual Page 5 of 58 1 2 4 Business Continuity The swine industry relies
86. on animal and resource flow animals to from the facility feed delivery supply delivery animals to slaughter as part of their normal business structure In the event a highly contagious FAD is diagnosed in the U S stop movement orders may be implemented until an investigation can identify the infected suspect and at risk premises This may involve a local community an entire state or a large region of the country During this time swine facilities will need to make arrangements to ensure their animals receive the necessary supplies to ensure they are fed watered healthy and comfortable If traffic flow is disrupted this will be difficult and plans for dealing with this situation should be discussed prior to an event In order for business to continue during a disease outbreak response uninfected swine operations in the disease Control Area see Section 6 Designation of Zones Areas and Premises will need to cooperate with regulatory officials on many levels The first critical control point for the business is biosecurity The facility needs to document they are not at risk of exposure to the highly contagious FAD Records of animal movement people movement and supplies received are some examples of what will be needed to verify exposure status Once that is complete surveillance will be implemented to monitor the health of the animals through visual exams and diagnostic testing For animals to be moved demonstrating negligible
87. ontaminate diagnostic samples with disinfectant as the highly contagious FAD will be inactivated providing false negative results See the FAD PReP NAHEMS Guidelines and SOP Personal Protective Equipment 2011 Biosecurity 2011 and Cleaning and Disinfection 2011 for more information 10 5 Sample Submission Early in the disease outbreak there may be a single laboratory or a select group of laboratories that can perform the diagnostic testing Guidance will be provided regarding sample submissions to laboratories This may change as the outbreak continues and other laboratories are able to perform the specific tests Contact personnel at the receiving laboratory will provide specifics related to sample submission There are some fundamental principles that must be adhered to in the event of a highly contagious FAD investigation to ensure accurate rapid results Once samples are obtained proper labeling is PARAMOUNT to ensure results are correctly reported Submit samples with the appropriate paper work hard copy or electronic This may consist of forms provided by the lab oratory or animal health authority The premises must be properly identified on all paperwork and sample packaging using a premises identification number if available Again proper completion of the paperwork is essential so that the results are accurately reported to the submitting veterinarian or animal health authority In some cases samples could be submitted to de
88. ord keeping of traffic on your farm will help with disease surveillance and tracking if necessary You should not rely on your ability to recall visitors and vehicles that were on your farm Vehicles Minimize traffic onto your farm to only vehicles essential for continued operation e Vehicles should be parked at the farm entrance away from animal areas or in designated parking areas These areas should preferably be concrete or paved areas e Off farm vehicles should not be allowed to drive onto your farm unless necessary If neces sary vehicles should be cleaned and disinfected or restricted to areas where vehicle traffic is allowed e Have deliveries left at the farm entrance whenever possible Clean and disinfect vehicles prior to entry and upon leaving e All vehicles entering the farm must first clean off then spray their wheels wheel wells and under carriage with disinfectant e Facilities for washing and disinfecting vehicles should be provided on farm at the perimeter accounting for drainage Do not share equipment or vehicles between farms or sites People Limit employees to only those necessary for the continued operation of the farm Employees that have contact with swine cattle sheep or goats at other locations including their own home should use very strict biosecurity measures while on your farm Implement strict biosecurity measures for employees coming onto the farm e Clean boots
89. ork production with nearly 800 million pounds in imports and 4 billion pounds in exports For pounds of production and value of produc tion per year pork ranks third among livestock in the United States behind cattle and broilers The swine industry also contributes substantially to the economy USDA estimated in 2009 that 14 4 billion dollars of farm income was generated through the sale of swine Sources e USDA NASS Meat AnimalsProduction Disposition Pork Production Imports Exports 800 million 4 billion pounds pounds and Income 2009 Summary April 2010 accessed March 6 2011 at http usda mannlib cornell edu usda current MeatAnimPr MeatAnimPr 04 29 2010 pdf e Farms Land in Farms and Livestock Operations 2010 Summary February 2011 Accessed March 6 2011 at http usda mannlib cornell edu usda current FarmLandIn FarmLandIn 02 11 2011_revision pdf FAD PReP Swine Industry Manual Page 2 of 58 1 2 Animal Production Systems 1 2 1 Location and Movement Swine production in the United States is generally concentrated in the upper Midwest northern most Corn Belt states near abundant feed supplies and slaughtering facilities Since 1990 significant growth of swine production has occurred in North Carolina Oklahoma Colorado Utah and Texas Modern production involves the routine interstate shipment of pigs as the various stages of production occur in different states as illustrated in Figure 2 There i
90. ormed on Piglets by Day of Age Common Procedures Days of Age Disinfecting navel 1 Birth Clipping needle teeth 2 5 lron injections 205 Docking tails 2 5 Castration 25 2 5 Nursery After weaning pigs can be placed in a nursery facility separate from the farrowing facility This environment accommodates the young pigs needs and allows them to acclimate to dry feed Group sizes in nurseries vary depending upon the facility setup Pigs remain in the nursery until they are 8 to 10 weeks of age 45 75 pounds 2 6 Grow Finish Growing and finishing were once thought of as distinct phases in the pork production process The difference in terminology dates back to the time when growing pigs up to 120 pounds were housed separately from finishing pigs 120 pounds to market weight Today pigs are seldom moved at 120 pounds and the grow finish phase is actually comprised of two to nine phases in which unique diets are fed to closely match the pigs nutritional requirements In addition barrows and gilts are frequently fed separately during the grow finish phase because their nutritional requirements are significantly different In the United States hogs are generally fed ad libitum which facilitates high growth rates Market weight averaging 240 280 pounds is generally achieved by 5 to 6 months of age At this time barrows and gilts not kept as breeding herd replacements are sent to slaughter 2 7 Production Records The qual
91. phalitis equine encephalitis and vesicular stomatitis Zoonotic Diseases transmitted from animals to humans Examples include nipah Japanese encephalitis and vesicular stomatitis rarely Environmental Contamination must always be taken into consideration PIF 9 This information was developed by staff theCenter for veterinarians at the CFSPH For more PD Food an information on these diseases visit Pubie Health www cfsph iastate edu JOWA STATE UNIVERSITY FAD PReP Swine Industry Manual Page 39 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Foot and mouth disease FMD is a highly conta gious viral disease of pigs and other cloven hooved animals such as cattle sheep and goats The last known outbreak in the United States was in 1929 however the disease is common in other parts of the world and therefore poses a risk to U S swine herds If a case of FMD is confirmed anywhere in the United States it could spread rapidly across the nation If any animal on your farm is confirmed to have FMD all may be euthanized and disposed of to control the further spread of the disease This document describes biosecurity practices you can take to prevent FMD from entering your farm These measures should be put into place IMMEDIATELY on your farm if FMD is confirmed anywhere in the U S and continued until the U S is once again declared FMD free Transmission of the D
92. plastic The ends of the building are left open during the warmer seasons and may include penning outside of the structure Straw or cornstalks are used for bedding over the dirt or concrete floors inside Hoop buildings used for finishing pigs require slightly more space per head than controlled environment facilities FAD PReP Swine Industry Manual Page 13 of 58 Hoop Buildings 3 3 Feeding Feed is the major production input to the pork production process and can account for over 65 percent of all production expenses A variety of feed ingredients are used to produce balanced diets for pigs at each stage of their lives Corn barley milo grain sorghum oats and sometimes wheat are used to provide dietary energy in the form of carbohydrates and fat Oilseed meals mainly soybean meal are the major source of protein Vitamins and minerals such as calcium and phosphorous are also included in balanced diets The average whole herd feed conversion ratio pounds of feed required per pound of live weight produced for the U S pork industry is about 3 6 to 3 8 including feed fed to sows and boars and is steadily improving getting lower Creep Feeder 3 3 1 Delivery to Farm Nearly all swine farms require some amount of feed or feed ingredient purchases from an outside vendor Smaller farms often have their own feed mixing equipment and use home grown crops feed grains such as corn wheat or barley in combination with purc
93. ractices for Foot and Mouth Disease FMD on U S Swine Operations q Appendix C Daily Visitor Log Date of Last Reason for Visit Contact with Livestock Name and Time in Time Out Phone Number FAD PReP Swine Industry Manual Page 46 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Vesicles on snout Ulcers on snout Source USDA Source Plum Island Animal Disease Center Epithelial lesion on foot Ulcer between the toes Source Plum Island Animal Disease Center Source Plum Island Animal Disease Center FAD PReP Swine Industry Manual Page 47 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Appendix E Bird and Rodent Control Measures FMD virus may be spread on the fur feathers or feet of some animals Birds and rodents may spread FMD for a short time and distance during an outbreak and can also contaminate feed and water sources Control programs should be implemented to minimize their numbers and the risk of disease spread on your farm Eliminate openings for rodents or birds to enter especially feed storage or processing areas Seal any opening greater than 4 to 2 inch with a durable material such as steel wool packed tightly into openings Use materials that cannot be easily gnawed or pecked through such as concrete sheet metal wire mesh aluminum or brick Plastic sheeting wood rubber will not be adequat
94. remises Cleaning and Disinfection The virus that causes CSF is sensitive to drying and sunlight It can also be inactivated at pH of 3 or less or pH greater than 10 Effective disinfectants include sodium hypochlorite household bleach and phenolic compounds Some quaternary ammonium compounds quats may also be effective In addition to selecting an effective disinfectant proper cleaning and disinfect ing procedures are essential in order to adequately and effectively control the spread of the virus Proper Cleaning Procedures 1 Wear personal protective equipment Gloves coveralls rubber boots or disposable boots and possibly a mask if you are cleaning an area that will generate dust Dry clean Remove all visible material by brush ing scraping and or sweeping This is the most important step as organic matter prevents many disinfectants from working effectively Disposal of waste material should be handled in such a way as to prevent contamination of other areas such as feed water or other animals Soak Soak the area with hot water and a detergent or cleaning agent Be sure to wash and soap down all equipment in the area waterers feed troughs pails etc Wash Wipe spray or scrub the area starting with the dirtiest or highest area ceiling after it has soaked for a period of time This step can be enhanced by the use of pressure washers when cleaning wood cement or other porous surfaces Use caution
95. resh air movement inside trailers Table 5 Truck Setup Procedures During Extreme Temperatures for Market Hogs Air Temp F Bedding Side Slats lt 10 Heavy 90 Closed 10 Open 10 19 Medium 75 Closed 25 Open 20 39 Medium 50 Closed 50 Open 40 49 Light 25 Closed 75 Open gt 50 Light 0 Closed 100 Open Minimum openings are needed for ventilation even in the coldest weather Source Transport Quality Assurance National Pork Board 2008 Some of the protocols in place for transport between farms are 1 Truck Wash Facility Requirements These are physical facilities commercial or private dedicated to cleaning and disinfecting trailers and tractors used for transporting livestock Private truck wash facilities are internal to the operation where only trucks trailers belonging to the farm are cleaned Commercial truck washes are facilities where several farms use the same wash bays 2 Inspection Checklists for Trailers A third party is dedicated to making sure cleaning and disinfection methods are properly followed and that the trailer is properly dried 3 Delivery Coveralls and Boot Wash Coveralls and boots worn by farm employees unloading pigs during a delivery must be completely cleaned after each use to eliminate the possibility of cross contamination between farms Ead Trys AELE sees 3333 2333 B s 1 s a 32 2s ss se oom proe siete Senta ab EFN Lite
96. rge number of vehicles and people moving on and off an operation every week in order to provide routine animal care FAD PReP Swine Industry Manual Page 4 of 58 In a disease outbreak situation deliveries of certain essential items must be made in order to continue to meet the needs of the animals and employees that work with them Table 2 lists the types of vehicle movements and frequency that might be expected on a swine operation in a given month This information can be evaluated as to essential and non essential personnel in the event of an outbreak Table 2 Type and Frequency of Vehicle Personnel Movement onto Swine Operations Daily Weekly Visits per Week Monthly Seasonal Variable Employees Feed delivery 2 Receive replacement gilt E Load out weaned pigs 1 2 Load out cull animals Repair personnel Semen 2 Utility meter reader Tractor agricultural Veterinarian Veterinarian Manure removal Rendering 1 3 Garbage pick up Sales people In a study by Bates et al swine operations in California with gt 2 000 pigs had a relatively low number of animal shipments referred to as direct contacts 0 2 per month However indirect contacts service personnel veterinarians neighbors commodity truck employees were very high 807 3 per month Source e Bates TW Thurmond MC Carpenter TE Direct and indirect contact rates among beef dairy goat sheep and swine herds in three California counties with reference to control of po
97. risk for the spread of the disease of concern is vital This could be done through risk assessments or surveillance and diagnostic testing if available The final step in the process is permitting This could involve the state officials for the farm of origin if the animals are to be moved to another in state facility If it is an interstate movement officials from the origin and destination states along with all states in between will need to be in agreement on the movement This is a difficult decision and one that will be considered fully information provided by the swine operation will aid in this effort Business must continue to ensure the welfare of the animals the livelihood of the producers caring for them and product availability to consumers while ensuring that disease transmission will not occur Record keeping transparency and cooperation on all levels will be vital 1 3 Swine Disease Traceability For swine moving in interstate commerce and to slaughter animal identification has been mandatory since 1988 Ear tags and back tags are used for cull sows and boars entering the harvest chain Slap tattoos consisting of at least 4 characters applied by a tattoo hammer to the pig s shoulder area are used for market pigs at the first point of concentration usually the slaughter plant as illustrated in Figure 3 Feeder pigs moving as individuals or as commingled groups are often identified with farm specific tattoos applied to the pig s
98. ritten or electronic record describing the vehicle driver name and contact information last farm s visited and reason for visit should be maintained for tracking purposes This could be challenging for operations without personnel living on site at ula MUST Cece Si AT OFFICE Ge oRe ETTE 10 3 Disease Monitoring During an outbreak situation susceptible animals on all operations must be closely monitored for clinical signs of the highly contagious FAD that meet the case definition Animal caretakers especially on Contact Suspect or At Risk Prem ises should be aware of the clinical signs and who to contact if disease is suspected Examples of clinical signs for FMD and CSF are found in the Appendices Accurate and rapid public awareness campaigns will be used to disseminate disease recognition and reporting information to animal producers and caretakers within the Control Area and Surveillance Zone Livestock operations within the Buffer Zone will be routinely monitored utilizing slaughter surveillance serological surveys and investigation of reports of suspect disease Slaughter surveillance will also occur in the Surveillance Zone Free Area surveillance will occur through normal surveillance channels Surveillance results and approved biosecurity protocols as a proof of negative status may be required for permitted movements of susceptible animals within the Control Area FAD PReP Swine Industry Manual Page 28 of 58 1
99. rodent barrier around buildings e A3 foot wide weed free area with a gravel rock perimeter can be used to prevent weed growth and discourage rodents from burrowing Gravel at least 1 inch diameter should be placed in a band at least 3 foot wide and 6 inches deep Trap rodents to reduce vector transmission e Proper placement of traps and baits is important Set traps close to walls behind objects in dark corners in places where rodent activity is evident e Use talc or flour patches to track where rodents are active Bait rodents when trapping is not possible or effective e When using rodenticide baits first read the label carefully and fully follow the directions e Use the amount of bait indicated on the package Requirements differ between products e Protect baits from the weather e Be sure baits are not accessible to children farm or domestic animals and birds e Inspect baits regularly Check often for dead rodents and burn or bury those you find Contact a wildlife pest control operator in your state for further assistance Other control methods are available but beyond the scope of this document Check local legislation for allowable bird control measures Many birds are protected by state and or federal law FAD PReP Swine Industry Manual Page 48 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Appendix E Bird and Rodent Control Measures For More Information
100. s and SOP 30 13 Disposal FAD PReP NAHEMS Guidelines and SOP 30 14 Cleaning and Disinfection FAD PReP NAHEMS Guidelines and SOP 30 15 Wildlife Management and Vector Control FAD PReP NAHEMS Guidelines and SOP 30 16 International Trade 30 Acknowledgements 31 Photo and Illustration Credits 32 Acronyms 35 Glossary 37 Appendix A Swine Routes of Transmission and High Consequence Disease Examples 39 Appendix B Prevention Practices for Foot and Mouth Disease FMD on 40 U S Swine Operations Appendix C Prevention Practices for Classical Swine Fever CSF 51 FAD PReP Swine Industry Manual Page viii Swine Industry Manual Purpose This industry manual provides the reader with a broad overview of U S swine production methods and the relationship to procedures that may be established in the event of a swine susceptible highly contagious foreign animal disease FAD outbreak A highly contagious FAD outbreak could severely impact industries with susceptible livestock as well as allied industries and service providers A quick effective and well coordinated response can minimize harm to the swine industry Wide dissemination of this information is encouraged to establish open communication between regulators and producers with the goal of reducing the probability that animals or their caretakers become infected with a highly contagious FAD Intent Local state and national level officials involved in developing policy and or man
101. s may contact the Director of Equal Opportunity and Diversity 3280 Beardshear Hall ISU Ames IA 50011 515 294 7612 FAD PReP Swine Industry Manual Page i Swine Industry Manual THE IMPERATIVE FOR FOREIGN ANIMAL DISEASE PREPAREDNESS AND RESPONSE WHY FOREIGN ANIMAL DISEASES MATTER Preparing for and responding to foreign animal diseases FADs like highly pathogenic avian influenza HPAI and foot and mouth disease FMD are critical measures to safeguard our nation s animal health public health and food supply There are significant potential consequences of an FAD outbreak in the United States For example the 2001 FMD outbreak in the United Kingdom cost an estimated 8 billion 13 billion and reduced the British gross domestic product by 0 2 percent Studies have projected a likely cost of between 6 billion and 14 billion for a U S outbreak contained to California In addition to the economic impact the social and psychological impact on both producers and consumers would be severe ea t i Bere CHALLENGES OF RESPONDING TO AN FAD EVENT An FAD outbreak will be challenging to all stakeholders For example there will be disruptions to interstate com merce and international trade Response activities are complex and significant planning and preparation must be conducted before an outbreak Outbreaks can become large and widespread Large geographically dispersed and diverse teams will need to be assembled rapidl
102. s very little if any excess capacity built into the production system necessitating the uninterrupted movement of animals Any stop movement affecting flow for more than a few days could result in overcrowding conditions and disruptions of animal health schemes leading to animal welfare and animal health issues Transport disruptions of moderate duration may necessitate the euthanasia of pigs abortions of pregnant sows or the cessation of breeding programs Figure 2 Potential Movement of Swine W v y 4 gt s m ee es SS IEE ee hee am MAAT Ni wa EEan ap a N The production of pigs is generally categorized into four production phases breeding gestation farrowing nursery grow finish and each is unique in its housing feeding and animal care needs Traditionally all stages of production took place at a single location To capture economies of scale capitalize on specialized labor and for biosecurity purposes modern swine farms often separate some of these phases into physically distinct sites that may be many miles even states apart This separation of phases generates a need for the interstate movement of pigs By definition in the Code of Federal Regulations a swine production system is an enterprise that consists of multiple sites of production 1 e Sow herds nursery herds and growing or finishing herds but not including slaughter plants or live
103. short distances in droplets passed through the air from one animal to another FAD PReP Swine Industry Manual Page 44 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations Appendix B Sample Signs Sample signs to post at the farm entrance in the event of a FMD outbreak in the U S Available from the CFSPH web site at www cfsph iastate edu PROTECTIVE HONK BOOTS amp TO ANNOUNCE ARRIVAL CLOTHING ai CHECK IN REQUIRED UPON ENTRY UPON ARRIVAL ibeCepier ir i the Center for R Food Security r A M od Securit amp Public He www cfsph iasti Public cfsph iastate edu TOWA STATE UNIVERSITY www cfsph iastate edu TOWA STATE UNIVERSITY d e Only enter this farm with permission Park at the entrance or in designated parking areas Vi S i O R e Check in with farm personnel upon arrival and sign the visitor log POLICIES pA AUTHORIZED P PERSONNEL or ONLY _ BEYOND THIS POINT Cities ee Clean coveralls hats and di bl ASA ke l Icies fo r disinfected rubber boste wile provided Visitors Contactin g by the farm and must be worn while in Animals or Entering An i mal Areas Boots must be clean before enterin Signage is also available from private companies such as Gempler s DISEASE STOP Takala ALL visitors AREA n SALONS MUST REGISTER MUST CHECK IN PLEASE KEEP OUT ENTERING PREMISES AT OFFICE FAD PReP Swine Industry Manual Page 45 of 58 Prevention P
104. should be kept that includes their name address phone numbers emergency contact and information pertaining to off site animal contact In the event of a zoonotic highly contagious FAD public health officials may recommend human surveillance via diagnostic testing Contacting employees will be critical Higher risk personnel on a swine operation are those individuals that visit multiple premises within a given day and have contact with animals or their housing areas This includes employees having off farm animal contact veterinar ians and service providers such as AI technicians equipment repair personnel rendering trucks feed delivery persons and sales persons Strict adherence to biosecurity protocols should be required for farm entry and animal contact during an highly contagious FAD event 10 2 Vehicle Traffic Vehicles and equipment can indirectly expose susceptible animals through mechanical disease transmission Installing a barrier that requires vehicles to stop before entering the premises provides an additional control point and can facilitate monitoring and recording vehicle details Cleaning and disinfecting tires wheel wells and the undercarriage of all vehicles which enter or leave a farm will likely be required on all Infected or Monitored Premises It may be prudent to park vehicles that are not required on farm off site People and vehicle traffic on and off an operation during a disease outbreak should be documented A w
105. sick animals showing the signs above and contact your herd veterinarian immediately to examine sick animals Use separate facilities equipment and staff to handle isolated livestock e If this is not possible at a minimum handle or visit the isolated animals LAST e Clean and disinfect all equipment clothing boots etc that come into contact with isolated animals Quarantine any newly purchased or newly arriving animals for at least 30 days e New or returning animals e g shows competitions can be infected with a disease without showing any signs of illness right away e Quarantining the animal s before introducing them with the rest of the herd allows time for any signs of disease to develop in the animal without exposing your entire herd to the disease agent e Swine exposed to the FMD virus may take up to 14 days or more before signs of illness are seen e Quarantined animals should not share water feed facilities or bedding with your other animals e Ideally animals should be quarantined at a separate location premises Wildlife and Other Animals Prevent contact with free roaming animals wildlife cats dogs e Free roaming animals can potentially spread the FMD virus from infected to susceptible animals e Keep pets in a kennel or tied securely to avoid contact with livestock and feed areas e Ask your neighbors to do the same Control of wildlife will be difficult but should be attempted e Keep f
106. sion Strict biosecurity measures must be followed by any visitors to the farm Some visitors are essential for the continued operation of the farm Establish strict biosecurity procedures for these individuals then inform them of the measures to follow while on your farm PY Food the Center for od Securi T A amp Public Health IOWA STATE UNIVERSITY This information was developed by staff veterinarians at the CFSPH for use as educational materials in the event of a Highly Contagious Foreign Animal Disease outbreak in the United States FAD PReP Swine Industry Manual Page 40 of 58 Prevention Practices for Foot and Mouth Disease FMD on U S Swine Operations e Honk before getting out of their vehicle to announce their arrival e Check in with farm personnel upon arrival direct visitors to where they should check in e Be accompanied by someone from the farm at all times to ensure biosecurity measures are being followed e Visitors and vehicles should avoid contact with animals or animal areas unless absolutely necessary e If animal contact is necessary wear clean farm specific protective clothing e g coveralls boots while on the farm Guide visitors to where protective clothing is located These items should remain on farm when the visitor leaves Monitor and record all traffic on or off your farm Maintain a log sheet Appendix C of all visitors and vehicles that enter your farm Accurate rec
107. stock markets that are connected by ownership or contractual relationships between which swine move while remaining under the control of a single owner or a group of contractually connected owners Source e Code of Federal Regulations Title 9 Chapter I e Part 71 1 Definitions Inshipments Total number of animals In order to connect these production phases over state boundaries inshipments have become an integral part of the industry Inshipments are the total number of moved Into a state for feed NS animals moved into a state for feeding or breeding or breed j ng excl ude S purposes excluding animals brought in for immediate slaughter In 2009 hog inshipments totaled 41 million immediate sla ug hte r head making it the largest sector of livestock inshipments in the United States FAD PReP Swine Industry Manual Page 3 of 58 In 2001 North Carolina shipped between three and four million pigs to the Midwestern states for feeding Iowa received over half of U S swine inshipments in 2009 while Minnesota Indiana Missouri and Illinois each imported more than 1 million head as shown in Table 1 Table 1 Total Number of Inshipments by State in 2009 Rank State Total of Inshipments 1 lowa 23 300 000 2 Minnesota 6 080 000 3 Indiana 2 862 000 4 Missouri 1 975 000 5 Illinois 1 034 100 It is estimated that 71 percent of pigs in the U S enter the growing finishing phase at a different location from which they were
108. sure the animal is properly restrained and change the needle as appropriate to maintain cleanliness and sharpness Intramuscular injections should be given in the neck just behind and below the ear but in front of the shoulder Subcutaneous injections should be given in the loose flaps of flank skin or behind the elbow in small pigs and in the neck behind the ear at the same location as intra muscular injections in larger pigs Figure 7 Slide the needle under the skin and away from the site of skin puncture before depositing the vaccine When using needles ensure they are all accounted for before and after administration FAD PReP Swine Industry Manual Page 25 of 58 Follow recommended guidelines for needle size and length in Table 9 Some vaccines are quite viscous using the recommended larger gauge needle is needed for delivery Properly dispose of all used needles in a puncture proof container Needle free injection systems have been researched in pigs and may be an option in an outbreak situa tion depending on the type of vaccine and availability of resources Vaccines for highly contagious FADs are likely to have a withdrawal time before animals can go to slaughter for human consumption and will be indicated on the vaccine label Please refer to the FAD PReP NAHEMS Guidelines and SOP Vaccination for Contagious Diseases 2011 and Appendix A FMD Considerations and Strategies 2011 for additional details Table 9 Recommended Needle Siz
109. t e Facilities for washing and disinfecting vehicles should be provided on farm at the perimeter accounting for drainage Do not share equipment or vehicles between farms or sites People Limit employees to only those necessary for the continued operation of the farm Employees that have contact with swine at other locations including their own home should use very strict biosecurity measures while on your farm Implement strict biosecurity measures for employees coming onto the farm e Clean boots hats and coveralls must be worn while on the farm These should be provided by your farm e Protective clothing should remain on your farm and be washed and or disinfected before being worn again e Disinfect footwear before entering AND after leaving any animal housing area e Boot baths should be provided at the entrance exit of all animal areas The disinfectant solution should be changed at least daily or when visibly soiled e Hands must be washed with soap and warm water before entering AND after leaving animal areas even when gloves are used e Minimize contact with animals to only tasks nec essary for the continued operation of the farm and health and well being of the animals Educate your employees on their role in preventing disease introduction and spread They should e Understand how CSF can be spread e Understand the farm s biosecurity procedures and how to prevent the spread of the disease e Know t
110. tate University Photo source Veterinary Diagnostic and Production Animal Medicine Iowa State University Graphic illustration by Dani Ausen Iowa State University Bottom An example of a grow to finish facility in which animals are kept until they reach market weight Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Page 11 A typical hog confinement building left A close up of manure pit fans and side curtains on a confinement building right Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Page 12 Top Graphic illustration of an isolation building situated 300 yards away from a swine building in order for it to be effective Graphic illustration by Dani Ausen Iowa State University Bottom There are multiple different phases of production in the swine industry Sows gilts in a breeding gestation barn where they stay until they are close to farrowing top Piglets in a farrowing crate which prevents the mother from lying on her piglets and protects handlers from a mother s aggressive behavior center Most housing for newly weaned pigs has slotted floors to allow the pigs waste to fall through into a holding pit or gutter This keeps floors drier and cleaner to keep pigs comfortable and growing bottom Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Page 13 An outdoor rearing system top Individual farro
111. tential foot and mouth disease transmission Am J Vet Res 2001 62 1121 1129 1 2 3 Diverse Workforce The workforce on United States swine operations can be very diverse Cultural and language differences may present a barrier to communication and hinder response efforts in the event of a highly contagious foreign animal disease outbreak Some workers may also be skeptical and afraid of government officials and could complicate containment efforts if they leave the operation area As a regulatory official or someone assigned to visit an operation effective communication with all involved will be necessary to conduct the disease investigation or to carry out eradication efforts Many integrated swine production systems utilize veterinarians to supervise the animal health staff Their experience with and understanding of the workforce is an important human resource for performing animal health response activities Establishing relationships prior to an outbreak will help build trust but timing may not always allow for this Understanding some general concepts about the primary workforce will help establish a successful working relationship Authority figures may be viewed very differently by certain workers so identifying who is regarded as the primary facility manager is important Working with that person to communicate tasks to the other employees will help with acceptance and with coordination of the work A translator can be very beneficial to overc
112. terinary Diagnostic and Production Animal Medicine Iowa State University Graphic illustration by Dani Ausen Iowa State University Page 6 Figure 3 Animal Identification Tattoos Graphic illustration of a pig with photo closeups of the ears denoting tattoos assigned to their farm and a 4 digit slap tattoo on the shoulder Photo sources Cargill left Tyson Foods center USDA Food Safety and Inspection Service right Graphic illustration by Dani Ausen Iowa State University Page 7 Figure 4 Concept of Pig Flow Pig flow ultimately begins with breeding and gestation which includes gilts brought in for their initial breeding and sows Semen is brought in from boar studs to inseminate the gilts sows The pigs are moved to individual farms right before farrowing The piglets are then either moved to the nursery or a wean to finish building Nursery pigs are eventually sent off to a finishing barn until they reach market weight Gilts are then selected as replacements and sent to the breeding gestation barn and the cycle starts all over again Content provided by Dan Whitney Iowa State University Graphic illustration by Dani Ausen Iowa State University Page 8 Top These photos depict different phases of swine production A breeding gestation facility where sows gilts are kept until they are almost ready to farrow left Piglets in farrowing crates side by side center Pigs kept in a finishing facility until they reach market weight right P
113. to the movement delays Controlled movement plans should be implemented so that the welfare of the animals is not adversely affected 8 5 Vaccination 8 5 1 Routine Personnel Records Vaccines are generally purchased when they are needed for nursery and finisher pigs In the event vaccines are needed during a disease response the operation should contact its normal distributor to ensure the vaccines can still be delivered or to make other arrangements Breeding and gestation facilities are not as restricted to pre determined vaccination schedules A delay of 1 2 weeks of incoming vaccines can be tolerated and the normal vaccination structure should stay intact Vaccination crews either company owned or for hire have the potential to introduce or spread disease among operations If this service is used for routine vaccinations during a disease outbreak biosecurity precautions should be followed and strict records should be kept pertaining to the crew Details such as company name if for hire crew member names and contact information exposure to other swine units in the previous 5 days the identity of animal buildings they entered on the operation name s of products and date s administered This information may be needed in the event of a traceback 8 5 2 Specific to Disease Event Depending on the type of disease outbreak the response may include vaccinating the animals in an attempt to limit spread Optimal vaccination strategies w
114. tural or artificial mating 2 2 2 Genetics Genetic selection varies among producers but important criteria are reproductive traits e g number of pigs born number of pigs weaned litter weights etc and performance traits e g growth rate feed efficiency backfat etc and the heritability of these traits Most if not all commercial production in the U S utilizes a crossbred female bred to a purebred boar 2 2 3 Timing The timing of mating 1s critical for optimal fertilization to reduce the incidence of nonproductive sows and to maintain production movement schedules Sows and gilts are often induced to farrow at a specific time to facilitate a narrow range between piglet ages within a farrowing group 2 2 4 Natural Mating There are two types of natural mating in swine production pen mating and hand mating Pen mating where one or more boars is placed with a group of sows is frequently used in pasture systems This approach requires less labor for the producer but provides little information about when or if a sow is bred making it difficult to predict farrowing times FAD PReP Swine Industry Manual Page 8 of 58 Hand mating involves placing one boar with one sow and observing to make sure mating occurs This is commonly used in controlled environment facilities as well as outdoor facilities that have a boar on site This method requires more labor and time but provides very accurate information upon which to base fu
115. ture management decisions 2 2 5 Semen Handling and Artificial Insemination Artificial insemination AI does not require a boar on site rather semen is obtained from a boar stud For biosecurity reasons semen is either delivered to the farm by a private courier or a farm employee picks it up at a designated collection site Semen is often transported interstate from boar stud to breeding gestation facility The only adult male pigs on the breeding gestation farm are a minimal number of sterile males vasectomized or epididymized used to stimulate the females and verify pregnancy in bred females Semen collection is described under 3 1 7 Boar Stud AI requires the highest level of management expertise and labor of all the mating systems Insemination of the sow or gilt begins by stimulating the animal with adjacent boars Once the sow gilt is stimulated an insemination rod is inserted into the cervix and semen is deposited This mating process takes about 2 to 5 minutes per female AI has become the predominate method of breeding swine on U S farms of all sizes especially in controlled environment facilities where breeding efficiency is a major factor affecting production This method enables more rapid genetic advancement than natural options while minimizing the risk of disease transmission 2 2 6 Boars Boars reach puberty around 5 6 months of age Boars of high genetic merit are used for natural mating and in semen collection f
116. tying it to allow for cleaning and disinfecting before the next group of pigs arrives This process breaks the disease cycle by preventing the mixing of pigs of different ages and different immunological and disease statuses From the grow finish operations pigs are moved to slaughter facilities when they weigh between 240 280 pounds at approximately 5 to 6 months of age In 2008 113 million market hogs were slaughtered 7 million came to the U S from Canada Additionally sows that are no longer used for breeding purposes are slaughtered with numbers reaching 3 37 million head in 2008 561 000 came from Canada Assuming slaughter facilities run five days a week approximately 625 000 pigs can be in transport on any given day in the United States Movement is critical to each stage of the swine industry to maintain animal welfare and domestic markets Sources e Steve Meyer Paragon Economics personal communication e John Lawrence Shane Ellis December 2008 Hog and Pig Report Down 2 Percent Iowa State University accessed at http www econ iastate edu outreach agriculture periodicals ifo info Dec 2008 20HP pdf 1 2 2 Routine Deliveries Swine operations rely upon routine deliveries to farm sites from a variety of support industries In addition to the transportation of live animals on and off the premises deliveries of items such as feed supplies semen pharmaceu ticals and equipment generate quite a bit of traffic This results in a la
117. typically works best on small farms due to the fact that it takes a few hours to complete center A compost pile bottom Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Page 20 Tractor pulling a manure wagon that is used to haul liquid manure to the field to be injected into the ground Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Page 21 Concrete lined storage pit holding pig manure with a fence around it to prevent entry Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine Page 22 Table 6 Summary of Premises Designations Content provided by USDA APHIS Graphic illustration by Dani Ausen Iowa State University Page 23 Top Table 7 Summary of Zone and Area Designations Content provided by USDA APHIS Graphic illustration by Dani Ausen Iowa State University Bottom Figure 6 Control Zones Graphic illustration by USDA APHIS Page 24 Table 8 General Estimates on Average Feed Consumption Content provided by Alex Ramirez Veterinary Diagnostic and Production Animal Medicine Iowa State University Graphic illustration by Dani Ausen Iowa State University Page 25 Top An automatic dosing syringe often called a vaccine gun consistently releases the same amount of vaccine in every use and is very useful when vaccinating livestock Photo source National Pork Board Bottom Figure 7 Injection Sites in Swine T
118. ual Page 15 of 58 For additional information refer to e Transport Quality Assurance Manual National Pork Board http www pork org Producers docs TQA_08 pdf e On Farm Euthanasia of Swine Options for the Producer National Pork Board American Association of Swine Veterinarians joint publication www pork org 4 1 Movement Within the Same Premises Movement of animals within the same premises can be a daily occurrence for some operations When pigs are loaded out of either a segregated weaning facility or a finishing barn it is best to move small groups directly from the home pens to the truck For finishing pigs 150 pounds or greater it is recommended that 3 to 6 pigs be moved at a time For smaller pigs larger numbers may be moved Pigs should be moved in a manner that does not cause them to bunch or pile up Pigs are very sensitive to distractions such as shadows reflections and small moving objects These small distractions can impede pig movement through single file races alleys truck loading ramps and into conveyor restrainers or carbon dioxide chambers Common distractions on farm sites are poor lighting air drafts people and noises 4 2 Movement Off Farm Off Premises Transportation of pigs off the premises is most commonly done by truck and trailer These can be owned by the opera om tion or hired from a commercial entity to haul pigs In either Livestock Trailer case the trailer should have adequate ventilation
119. ucer The sows and boars are sorted into separate loads based on specification set by the packers and sent to slaughter as commingled lots FAD PReP Swine Industry Manual Page 18 of 58 The marketing chain for pigs consists of packers processors purveyors retailers and foodservice operators All play an important role in adding value to pigs by producing pork products that meet the needs and desires of consumers worldwide 4 2 6 Mortalities The disposal of livestock mortalities is regulated by the respective state in which the farm is located The four most common methods include burial rendering incineration and composting It is important to realize that each State has specific laws regulating the proper disposal of livestock 1 Animal burial is a common procedure on some farms particularly smaller facilities Timeliness of burying impermeable soil greater depth to water table from trench pit bottom and prompt covering of the car casses are critical to maintaining a biosecure and aesthetically acceptable burial site Most states regulate separation distances of burial site from wells surface water and the property line and limit the number of animals that can be buried in an area Some states have maps that show where animals can be buried safely and lawfully In a large scale disease outbreak this may be the method of choice for the disposal of large numbers of cattle depending on risk to groundwater contamina tion and av
120. uggested amount of time Contact time of the disinfectant is impor tant for the product to inactivate or kill the micro organism present 3 Final rinse Remove all disinfectant by applying a low pressure water rinse on all surfaces starting with the highest area and working your way to the floor 4 Dry Allow the area to completely dry before allowing animals to contact the area or item that was just cleaned and disinfected Proper Boot Bath Procedures 1 Mix solution to the proper concentration according to the label instructions 2 Clean all dirt manure and debris off of boots BEFORE stepping into the disinfectant solution The presence of organic material dirt manure etc will prevent most disinfectants from working 3 Allow the disinfectant solution to have ample con tact time with the boot surface This will vary with the disinfectant selected Consult the product label 4 Change solutions at least daily or when visibly dirty Proper Storage If the equipment or area will not be used immediately it is important to avoid contamination between uses Small items can be placed into plastic bags and sealed larger items can be placed into closed cabinets Equipment and housing areas are more difficult to protect for long periods of time and may need to be rinsed again before allowing animal contact Barns and Buildings Clean and disinfect anything that has had contact with animals manure or animal secretions FAD
121. uthority for responders planners and policy makers FAD PReP Swine Industry Manual Page iii Swine Industry Manual Industry Manuals e These manuals describe the complexity of industry to emergency planners and responders and provide industry a window into emergency response Disease Response Plans e Response plans are intended to provide disease specific information about response strategies These documents offer guidance to all stakeholders on capabilities and critical activities that would be required to respond to an FAD outbreak Critical Activity Standard Operating Procedures SOPs e For planners and responders these SOPs provide details for conducting 23 critical activities such as disposal depopulation cleaning and disinfection and biosecurity that are essential to effective preparedness and response to an FAD outbreak These SOPs provide operational details that are not discussed in depth in strategic documents or disease specific response plans Continuity of Business Plans Developed by public private academic partnerships e Secure Egg Supply SES Plan The SES Plan uses proactive risk assessments surveillance biosecurity and other requirements to facilitate the market continuity and movement of eggs and egg products during an HPAI outbreak e Secure Milk Supply SMS Plan Currently under development the SMS plan will help facilitate market continuity for milk and milk products during an FMD outbreak
122. wine Routes of Transmission and High Consequence Disease Examples Disease causing agents can be spread from animal to animal or animal to human and vice versa through a variety of transmission routes Aerosol Droplets are passed through the air from one animal to another Examples include foot and mouth disease FMD nipah and rinderpest Direct Contact A susceptible animal becomes exposed when the disease agent directly touches open wounds mucous membranes or the skin through blood saliva nose to nose contact rubbing or biting Examples include African swine fever FMD nipah classical swine fever CSF rinderpest and vesicular stomatitis Reproductive A subtype of direct contact that includes diseases spread through mating or to the fetus during pregnancy An example would be CSF Fomite An inanimate object carrying a disease agent from one suscep tible animal to another Examples include African swine fever CSF FMD rinderpest and vesicular stomatitis Traffic A subtype of fomite transmission in which a vehicle trailer or human spreads organic material to another location Oral Consuming disease causing agents in contaminated feed water or licking chewing on contaminated environmental objects Examples include African swine fever CSF FMD and nipah Vector borne An insect acquires a disease agent from one animal and transmits it to another Examples include African swine fever CSF Japanese ence
123. wing houses known as farrowing huts center A typical hoop building which can be used for gestation or finishing pigs bottom Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Page 14 Top A typical creep feeder used for piglets left Pelleted feed center Meal feed right Photo source Iowa State University Veterinary Diagnostic and Production Animal Medicine all Bottom A feed truck emptying feed into a farm s onsite storage bins top A typical row of feed bins next to a swine building center An example of an automated feeding and watering system bottom Photo sources Iowa State University Veterinary Diagnostic and Production Animal Medicine top amp center National Pork Board bottom Page 15 Figure 5 A Pig s Flight Zone Point of Balance and Blind Spot This illustration shows where the handler should stand to start and stop animal movement Content and graphic illustration provided by Transport Quality Assurance Handbook National Pork Board 2008 Interpreted by Dani Ausen lowa State University Page 16 Top A trained handler using a herding panel to move animals top A 2 tier livestock trailer used to move pigs center A typical ramp with cleats used for loading pigs onto a truck bottom Photo sources National Pork Board top Iowa State University Veterinary Diagnostic and Production Animal Medicine center and bottom Bottom Table 4 Transport Space Recommend
124. y Oy IOWA STATE UNIVERSITY College of Veterinary Medicine rm O Sp z ro NVE vereRinA Classical Swine Fever CSF also known as hog cholera is a highly contagious viral disease of pigs Eradicated from the United States in 1978 the disease is common in other parts of the world and therefore poses a risk to U S swine herds If CSF is confirmed anywhere in the U S it could spread rapidly across the nation Pigs and herds con firmed to have CSF may need to be euthanized to con trol the further spread of the disease This document describes biosecurity practices you can take to prevent CSF from entering your farm These measures should be immediately put into place on your farm if CSF is confirmed anywhere in the U S and con tinued until the U S 1s once again declared CSF free Transmission of the Disease Understanding how CSF is spread to and between pigs can help highlight the importance of biosecurity measures needed on your farm and help you recognize areas that may need additional work to prevent disease introduction and spread see Appendix A CSF is primarily spread orally by ingestion of contami nated garbage swill or meat products Once swine become infected the virus is rapidly spread to other pigs through direct contact The virus can be found in all body fluids of infected pigs including nasal secretions blood urine feces saliva and even semen The virus can also be spread reproductively This
125. y also have cool cell systems which are evaporative coolers through which intake air passes lowering the temperature of the air entering the facility A few high biosecurity facilities e g genetic suppliers are experimentally installing virus particle air filtering systems for all intake air Confinement Building Manure Pit Fans and Side Curtains 3 1 1 Isolation and Acclimation The most likely route of disease entry into a swine production system is the introduction of an infectious agent via infected carrier pigs Direct contact between infected and susceptible pigs is the most efficient way to spread disease Isolation of incoming stock provides a safeguard against such transmission Isolation gives the producer the oppor tunity to test animals for certain pathogens and observe them for clinical signs of disease before herd introduction FAD PReP Swine Industry Manual Page 11 of 58 The isolation facility should be located as far from other swine as possible 300 yards is considered the critical distance to achieve follow all in all out procedures and be thoroughly cleaned and disinfected between groups Pigs should remain in isolation for at least 30 60 days In most cases Isolation Facilities Isolation T Building a isolation is only practiced for new additions to Breeding Gestation Farrowing BGF farms and _300 Yards Boar Studs Critical Distance DN Acclimation occurs in the same facility as isolation The
126. y and must react quickly The response effort must have the capability to be rapidly scaled up involving many times more resources personnel and countermeasures As such responding to an FAD large or small may be a very complex and difficult effort LESSONS LEARNED FROM PAST FAD OUTBREAKS Past outbreaks both in the United States and other countries have allowed us to learn important lessons that can be applied to preparedness and response efforts To achieve successful outcomes in future FAD outbreaks it 1s vital to identify understand and apply these lessons learned e Provide a unified State Federal Tribal industry planning process that respects local knowledge e Ensure the unified command sets clearly defined and obtainable goals e Have a unified command that acts with speed and certainty to achieve united goals e Employ science based and risk management approaches that protect public health and animal health stabilize animal agriculture the food supply and the economy e Ensure guidelines strategies and procedures are communicated and understood by responders and stakeholders e Acknowledge that high expectations for timely and successful outcomes require the rapid scale up of resources and trained personnel for veterinary activities and countermeasures and capability to quickly address competing interests before or during an outbreak e Execute FAD tracing which is essential for the efficient and timely control of FAD outbr
127. yproducts that can be used in manufacturing insulation rubber antifreeze plastics and fertilizer Figure 1 Figure 1 Products and Byproducts of Swine amp e GAN F te S Animal health is paramount to swine production and modern operations production systems often have the neces sary biosecurity measures in place to aid in preventing the entry or containing the spread of disease Regulatory authorities managing a highly contagious FAD outbreak are encouraged to work individually with managers of these production systems and utilize their knowledge and skills in the areas of swine transportation and biosecurity both within and among herds Many swine production systems have also developed control and mitigation strategies in the event of a highly contagious FAD incursion Regulatory authorities and swine producers are encouraged to work together to evaluate these plans and understand their merits prior to an animal health event A customized interaction with key manage ment personnel will help minimize the extra time effort and cost that will accompany a one size fits all approach to containing and ultimately eradicating the outbreak 1 1 Swine Numbers As of December 2009 the U S inventory of hogs was 65 3 million head on approximately 71 450 operations Inventory continues to slightly increase while the num ber of hog operations decreases This inventory equates to 32 7 billion pounds of p

Swine Industry Manual - American Association of Swine Veterinarians

Contents

Download Pdf Manuals

Related Search

Related Contents