Solenergibox User Manual
Contents
1. The indicator is illuminated when a device is connected to the SOLENERGIBOX getting energy 230 V from its battery The indicator 8 is red when too powerful a device typically more than 250 W is connected to the SoLenercigox causing overload The indicator tells when the in built battery needs to be changed or there is an error with the battery Switch also in figure 2 is the power ON OFF button press 1 2 seconds to switch ON or OFF www solenergibox dk Page 8 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Operating the the SOLENERGIBOX Charging the SOLENERGIBOX from the sun To prepare the SoLenercizsox for operation place it first into a sunny place where the batteries can be charged with the solar panels figure 2 facing the sun Adjust the angle of the solar panel towards the sun in the way that that most lamps are on in the charging indicator figure 5 On a bright sunny day all four lamps should be on while on a normal sunny day three lamps may be on OOOO Se COILS BP SIS Figure 5 charging indicator Note that when charging the SoLenercigsox from the sun it should be switched OFF i e there shall be no lights in the warning and indicator panel figure 4 This way the charging is faster and the power in the battery is not lost at the same time If you need to use the Sotenercisox at the same time the battery is charging the uni2. SOLENERGIBOX USER MANUAL Version May 2011 User Manual SOLENERGIBOX POWERING THE WORLD Welcome to the magnificent world of SOLENERGIBOX product line the new portable power station www solenergibox dk Page 1 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Safety guidelines Thank you for purchasing the SoLENeERGIBox To get most out of it please read this user manual carefully paying special attention to the safety notes Keep the manual in a safe place for later reference and pass it on to any new owner The output of the SoLenercigox is 230 V Do not touch the output connector danger for life Do not connect any un isolated wires or any devices using other than 230 V power Do not use the SoLenercigox when it is wet or in the rain Always switch the SoLenercisox OFF when transporting it Always keep the SoLenercisox away from children www solenergibox dk Page 2 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Table of contents Safety SUIS sc niatevaomranstennnannians eavecnaccimeaneramiiaaneanelan sean nonmnral ans aradaneas 2 Introductio Nesne A E EE E E ER ES 4 Parts of the SOLENERGIBOX ssesssssssssssssesesererererrrerrrrrrerertrterrrrrrrrrerererereeeee 6 Operating the the SOLENERGIBOX ccccccssseeccceseceeseeceeseeeeeeseeeeeeeeees 9 Charging the SOLENERGIBOX from the SUN cccccsseeceeesseceeeeeeee
3. e free sealed lead acid battery with suspended electrolyte leak proof 9Ah 12 V 20 VDC 14 16 W Maximum 3 months Alternatively storage in sunny place Net weight Material Relative operating humidity Nominal output voltage Input voltage range for main operations Typical recharge time with 230 V input Typical runtime on battery Typical recharge time with solar panels 9 6 kg Stainless steel Aluminium 0 80 230 V 196 280 V 6h 1 h9 min 50 W load 25 min 100 W load 6 8h Unit has to be switched OFF Solenergibox ApS Bygveenget 12 DK 4720 Pr st Denmark Tel 45 31520679 Info solenergibox dk www solenergibox dk Page 15 Solenergibox A S
4. ed A 5 This means that the device connected to the SOLENERGIBOX is using too much power Disconnect the device and press the power button again for 1 2 seconds Q 6 Replace battery indicator is illuminated A This means that there is an error with the battery Please contact Solenergibox company _ www solenergibox dk Q 7 The charging indicator becomes warm po A 7 This is because the charging unit in the SOLENERGIBOx is delivering power to the battery and it is normal that the unit warms up little The unit will be switched OFF automatically if the internal i temperature increases 60 C and it will automatically restart after having cooled down Q 8 The solar panel becomes warm E ea a warms up a 30 40 e e the a absorbing energy trom cn However the solar panel operates best if it is not too hot Try to place the SOLENERGIBOX in a place www solenergibox dk Page 13 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 with little breeze The SOLENERGIBOX has been placed inside and there is lot of sun However only 1 or no charging Q 9 indicator leds are illuminated AY The windows limit the sun s power to the solar panels Move the SOLENERGIBOX outside for charging Q 10 _ forgot the SOLENERGIBOX outside it started to rain and now the SOLENERGIBOX is wet A110 Do not switch the SOLENERGIBOX ON Dry it with a t
5. eees 9 Fast charging the SOLENERGIBOX without the SUN ceecceeeeeee 10 Using the SOLENERGIBOX si suconisasnedusenvectictensendeunecnnaetwaseecatesiveaseeaneben 10 Frequently Asked Questions FAQ ccccccccsssseeeceeeeeeseeeeceeeeeeeeeeeseeenes 13 www solenergibox dk Page 3 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Introduction The brand new SoLenercigox receives solar energy with its solar panels converts it to 230 V electricity and stores the electricity into its battery for your use anytime anywhere Leave the Solenercisox in the sun for day time and use the electricity in evenings or whenever you need it The SOLENERGIBOX will give you absolutely green energy there are no CO emissions The unique SoLenercigox is a self standing small portable 230 V power station which generates electricity directly from the sun The generated electricity can either be used at the same time it is being generated direct use or the electricity can be stored to the battery of the SOLENERGIBOX to be used when needed in evenings or on a cloudy day The SoLenercisox has a powerful 14 18 W solar panel which is able to charge the built in battery in only 8 10 hours of sunlight The full battery will give you 30 W power for approximately 3 hours to be used to watch TV use a laptop computer or recharge your battery operated tools All in all the SoLenercigox will give you elec
6. en the Sotenercisox has been charged in the sun or via fast charging you are able to get 230 V power from it Switch the SoLenercisox ON by pressing the power button figure 2 for 1 2 seconds In the warning www solenergibox dk Page 10 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 and indicator panel figure 4 of the SoLenercigsox the green indicator 220 V In figure 4 and the yellow indicator On solar figure 4 will start flashing simultaneously After 4 6 seconds the green indicator will fade away while the yellow indicator will keep illuminating This means that 230 V power is now available from the connector figure 3 Just connect your device to the SoLenerGipox If the connected device is using more than 250 W power the red overload indicator will illuminate figure 4 and the SoLenercipox will automatically be switched OFF Before switching the SoLenerciBox ON again disconnect the device causing overload and press thereafter the power button for 1 2 seconds www solenergibox dk Page 11 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Figure 6 illustrates the run time of the SoLenerRcigox in minutes compared with the load W of the connected device The connected device is using 50 W power the battery power in the SoLenercisox lasts approximately for 70 minutes On the other hand if the connected device is using 150 W po
7. owel and leave it to dry for at least 3 4 hours in the sun Thereafter you may switch it ON again Q 11 It seems that there is some damp in the charging controller A 11 This is because the charging controller becomes warm and it is normal The humidity will disappear soon Q 12 connected my alarm clock to the SOLENERGIBOX and now the time of the clock is wrong A2 The output voltage from the SOLENERGIBOX is not pure 50 Hz sinus wave form and this is the reason why the clock is not accurate when connected to the SOLENERGIBOX Q 13 There is strange noise from the radio connected to the SOLENERGIBOX A 13 The output voltage from the SOLENERGIBOX is not pure 50 Hz sinus wave form and this is the reason why noise may appear from the radio when connected to the SOLENERGIBOX www solenergibox dk Page 14 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 SOLENERGIBOX Technical specifications Material and dimensions Maximum height Maximum width Maximum depth Environmental figures Operating temperature Storage temperature DC AC inverter output Output power capacity DC AC inverter input Nominal input voltage Input frequency Batteries and runtime Battery type Solar panel Output voltage Output power Winter storage Maximum interval between recharge 400 00 mm 410 00 mm 120 00 mm 0 35 C 15 45 C 210 W 350 VA 230V 50 Hz Maintenanc
8. t should be switched ON Depending on the power www solenergibox dk Page 9 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 demand of the connected device you may be using more power out from the SoLenercigox than the solar panels are able to give in to the battery The best way to charge the SoLenercipox is to take it to a sunny place for at least six hours making sure that the solar panels are facing directly to the sun During winter the power of the sun is much weaker especially in Nordic countries To charge the Sotenercisox in winter it is advisable to place it inside by the window lt see FAQ Q 9 gt ensuring that the solar panels get as much sun power as possible It is also advised that the SoLeNnerRGiBox will be charged either using sun and the solar panels or the mains see next chapter every three months even it is not used Fast charging the SOLENERGIBOX without the sun The input connector fast charger figure 3 is used for charging the SOLENERGIBOX without the sun and the solar panels if you have 230 V mains available When the SoLenercigox is connected to the mains it needs to be switched ON and the green indicator 220 V In figure 4 will illuminate It takes 6 8 hours to fully charge the battery from the mains Remember to switch the SoLenercigox OFF by pressing the power button for 1 2 seconds when the charging is complete Using the SOLENERGIBOX Wh
9. tricity all gadgets using less than 50 75 W power such as mobile phones and iPads The fully charged built in battery will give you 30 W power for 2 hours or 15 W power for 4 hours Figure 1 shows the basic operation principles www solenergibox dk Page 4 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 SOLENERGIBOX Special Charge Controler with LED indicator of solar energy transfered from panel i DC AC Inverter Charger Battery Bank T0 PARE E Figure 1 www solenergibox dk Page 5 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Parts of the SOLENERGIBOX Figures 2 3 and 4 show the main parts of the SoLENERGIBOXx AN OR Wien Figure 2 Figure 2 illustrates the solar panel shown as and the power ON OFF switch shown as The side panel warning and indicator panel is shown in details in figure 4 www solenergibox dk Page 6 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Figure 3 Figure 3 illustrates the 230 V outlet connector fast charger and the joint hinge to adjust the angle of the solar panel Sea Figure 4 www solenergibox dk Page 7 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Figure 4 shows the warning and indicator panel The uppermost indicator is illuminated when the fast charger in figure 3 is in operation
10. wer there is energy in the battery only for a little more than 10 minutes 200 Runtime Min 20 0 50 100 150 200 250 Load Watt Figure 6 www solenergibox dk Page 12 Solenergibox A S SOLENERGIBOX USER MANUAL Version May 2011 Frequently Asked Questions FAQ Q 1 There is no light in indicators On solar nor 220 V In A 1 This means that the battery of the SOLENERGIBOX is empty Place the SOLENERGIBOX in the sun for 6 8 hour to be charged from the sun by the solar panels Alternatively the SOLENERGIBOX can be charged from mains remember to switch it ON Q 2 l Only 1 green lamp is on in the charging indicator although there is a lot of sun shine A 2 This means that the SOLENERGIBOX is fully charged To test if the SOLENERGIBOx is fully charged switch it ON and check that one more lamp switch on Q 3 After the SOLENERGIBOX has been placed in the sun for 6 8 hours the battery runs fast empty A 3 The SOLENERGIBOX may have been switched ON during charging Remember to switch it OFF while _ charging in the sun Q 4 l The SOLENERGIBOX has been connected to the mains and still after 6 hours there is no power in the battery ah A 4 The SOLENERGIBOX may have been switched OFF while charging in the mains Remember that the SOLENERGIBOX must be switched ON while charging in the mains Q 5 lt Overload lamp is illuminat
Download Pdf Manuals
Related Search