User`s Manual & Operating Instructions
Contents
1. 2014 Pinnacle Products International Inc A Eh Se AY Ss A7 Tools Needed Phillips Head screw driver mm open end wrench wy Tip Use a power screwdriver and locking wrench for easier assembly 5 Slide side supports into upper brackets align holes and insert screws to tighten 6 Slide upper handle brackets onto front handle align holes and insert screws to tighten 7 Slide rear handle into upper handle brackets align holes and insert screws to tighten Turbo Electric Fan Heater User s Manual PROGTEMP NEVER LEAVE HEATER UNATTENDED WHILE CONNECTED TO A POWER SOURCE Operation Operation 1 Position the fan heater so that it stands Automatic Overheat Safety Control upright on a firm level surface and at a This heater is equipped with safety internal safe distance from wet environments and heat limiting thermostat and overheat flammable objects protection circuit When a potential overheat 2 Connect the fan heater to the proper electrical temperature is reached the system will power See Grounding instructions automatically shut the heater off Page 8 Figure 2 3 Set the thermostat dial to the maximum Thermostat Instructions At first set the thermostat to and let the temperature heater operate with full power input When 4 The fan heater will switch on when the the room temperature reaches the required function selector dial is set to one of the three v2. User s Manual amp PROTEMP erating Instructions Model Numbers PT 515 120 PT 53 240 C US LISTED Intertek 4006316 CONSUMER READ AND SAVE THESE INSTRUCTIONS USE THIS HEATER ONLY AS DESCRIBED IN THIS MANUAL ANY OTHER USE AWARNING NOT RECOMMENDED BY THE MANUFACTURER MAY CAUSE FIRE ELECTRIC SHOCK OR INJURY TO PERSONS 2013 Pinnacle Products International Inc 668 Stony Hill Road 302 Yardley PA 19067 USA Toll Free 800 641 6996 Fax 215 891 8461 Web www protemp us Email info pinnacleint com Ph iion PINNACLE INTERNATIONAL 821000430 14 NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Table Of Contents Safety Iniormaton ir Fei Liu ieuun 1 2 Maintenance nu YY I I LI LL nuuniu 8 Specifications and Features ees 3 Troubleshooting Guide 9 PASS ue E A O WV LC EE 10 Ale le EE 7 8 Safety Information RISK OF FIRE To prevent a possible fire Do not block intakes or exhaust in any AWARNING manner Do not use on soft surfaces like a bed where openings may become blocked Heater must be kept clear of all obstructions Maintain a 3 foot minimum clearance from front and 12 inches from sides and rear Heaters must be kept clean of lint dirt and debris see maintenance instructions Page 8 AWARNING RISK OF FIRE DO NOT use heater with extension cord Plug PT 515 120 heater directly into a 120VAC receptacle Plug PT 53 240 heater directly
3. ELL NO USER SERVICEABLE PARTS INSIDE 2014 Pinnacle Products International Inc 1 Turbo Electric Fan Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Safety Information Turn the electrical power off at the electrical panel board circuit breaker AWARNING or fuse box and lock or tag the panel board door to prevent someone from turning on the power while you are working on the heater When using electrical appliances basic precautions should always be followed to reduce the risk of fire electric shock and injury to persons including the following AWARNING Read all instructions before AWARNING RISK OF ELECTRIC SHOCK using this heater Extreme caution is necessary when any Avoid using an extension cord because the heater is used by or near children or invalids extension cord may overheat and cause a risk of fire However if you have to use an extension cord use only a 14 AWG or better This heater is not intended for use in extension cord bathrooms laundry areas and similar indoor locations Never locate heater where it may fall into a bathtub or other water container Do not use outdoors ALWAYS use only the electrical power voltage and freguency specified on the model plate of the heater Do not use heater in wet ist locations O not use neater In Wet OF MOIST lOCatlons ALWAYS use only three prong grounded Always locate hea
4. a Front Guard Figure 1 O 2014 Pinnacle Products International Inc 3 Turbo Electric Fan Heater User s Manual PROGTEMP NEVER LEAVE HEATER UNATTENDED WHILE CONNECTED TO A POWER SOURCE Assembly Instructions What s In The Box Inner Lower Handle Outer Lower Handle 2 Bracket 2 Bracket 2 rrF YFF 24 mm Bolts 16 Small Washers 32 Large Washers 2 Lock Washers 2 Side Supports PN gr a A5 2014 Pinnacle Products International Inc 4 Turbo Electric Fan Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Assembly Instructions AIRE XO AR QS AYES 2014 Pinnacle Products International Inc 5 Turbo Electric Fan Heater User s Manual PROTEMP NEVER LEAVE HEATER UNATTENDED WHILE CONNECTED TO A POWER SOURCE Assembly Instructions me lt er ep o W Dy 1 ORARIN A VX KE AM Ge ANS PY LA hi wi LA Ge CN f a Y y Gem NOS NWN Ae e es Remove heater and all packaging materials from the shipping carton wy Tip Be sure to remove the handles and side supports from the Styrofoam packaging 1 Align holes in heater leg frame with lower inner bracket 2 Attach lower outer bracket to lower inner bracket using screws 3 Align lower inner bracket with side support 4 Attach side supports to heater using tilt adjustment knob
5. alue turn the thermostat to the left until it power settings switches off Setting Function The thermostat will then switch on and off oO untisof automatically to control the room temperature according to the preset value and keep the Fan Runs No heating room temperature constant E When using the heater for the first time you may notice a slight emission of smoke This is guite normal and it stops after a short time The heating element is made of steel and was coated with a layer of protective oil 5 Once the room reaches the desired during production The smoke is caused by temperature turn the thermostat dial back the leftover oil as it is heated until heating element turns off NOTE The fan will run continuously while the heater is operating 2014 Pinnacle Products International Inc T Turbo Electric Fan Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Operation Grounding Instructions PT 515 120 PT 53 240 This heater is for use on 120 Volts The This heater is for use on 240 or 208 volts cord has a plug as show at A below An The cord has a plug as shown in D below adapter as shown at C is available for No adapter is available for this blade connecting three blade grounding type plugs configuration and none should be used The two slot receptacles The green grounding type outlet is a 240 or 208 volt grounding lug extending fro
6. efective the item will be returned freight collect This Limited Warranty is in lieu of all other express warranties Pinnacle Products International Inc disclaims al warranties for products that are purchased from sellers other than authorized dealers or distributors AFTER THE PERIOD OF THE ONE 1 YEAR EXPRESS WARRANTY EXPIRES Pinnacle Products International Inc DISCLAIMS ANY AND ALL IMPLIED WARRANTIES INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR APPLICATION FURTHER Pinnacle Products International Inc SHALL HAVE NO LIABILITY WHATSOEVER TO PURCHASER OR ANY THIRD PARTY FRO ANY SPECIAL INDIRECT PUNITIVE INCIDENTAL OR CONSEQUENTIAL DAMAGES Pinnacle Products International Inc assumes no responsibility for any defects caused by third parties This Limited Warranty gives the purchaser specific legal rights a purchaser may have other rights depending upon where he or she lives Some states do not allow the exclusion or limitation of special incidental or consequential damages or limitations on how long a warranty lasts so the above exclusion and limitations may not apply to you Pinnacle Products International Inc does not authorize any person or company to assume for it any other obligation or liability in connection with the sale installation use removal return or replacement of its equipment and no such representations are binding on Pinnacle Products Internationa
7. heat shuts 1 Fan runs continuously while 1 Heater is operating correctly off the heater is operating 1 Fan speed stays constant 1 Heater is operating correctly Setting changes amount of heat output only Fan speed stays the same when changing settings Heating element is made of 1 Heater is operating correctly stainless steel and will not glow red to produce heat Heating element does not glow red No power to heater Check power connections connect heater to power supply Desired room temperature Thermostat will shut off once reached desired room temperature is Do not feel heat or air flow reached Heater is operating correctly Heater does not heat area Heater is operating correctly in front of heater it will disperse heat throughout room to heat entire space 2014 Pinnacle Products International Inc 9 Turbo Electric Fan Heater User s Manual PROTEMP LIMITED WARRANTY Pinnacle Products International Inc warrants this heater to the original retail purchaser only to be free from defects in material and workmanship for a period of one 1 year from the date of initial purchase This product must be properly installed maintained and operated in accordance with the instructions provided Pinnacle Products International Inc reguires reasonable proof of your date of purchase from an authorized retailer or distributor Therefore you should keep your sales slip invoice or cance
8. into a 208 240VAC receptacle AWARNING RISK OF FIRE Do not use as a residential or household heater AWARNING OVERHEATING OR FIRE MAY OCCUR Do not place heater behind doors AWARNING BURN HAZARD This heater is hot when in use To avoid burns do not let bare skin touch hot surfaces If provided use handles when moving the heater AWARNING RISK OF ELECTRIC SHOCK OR INJURY Do not run cord under carpeting Do not cover cord with throw rugs runners or similar coverings Do not route cord under furniture or appliances Arrange cord away form the traffic area where it will not cause a tripping hazard Do not operate any heater with a damaged cord or plug or after heater malfunctions or has been dropped or damaged in any manner Discard heater or return to authorized service facility for examination and or repair RISK OF ELECTRICAL SHOCK Connect to properly grounded outlets only Do AWARNING geg not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock or fire or damage the heater Unplug heater before performing any maintenance or when not in use To disconnect heater turn control to low then remove plug from outlet AWARNING CALIFORNIA RESIDENTS This product contains chemicals including lead known to the State of California to cause birth defects or other reproductive harm Wash hands after handling CAUTION RISK OF ELECTRIC SHOCK DO NOT OPEN HEATER SH
9. l Inc Always be sure to specify the model number and serial number when making any claim with Pinnacle Products International Inc For your convenience use the space provided below to list this information Register Your Product Online at http www protemp us Product_Registration php Locating Your Serial Number Your serial number can be found on the heater s rating label It will begin with the letters PEFH followed by 9 digits For Example PEFH120900170 Have your Serial Number ready before calling customer service at 800 641 6996 Model Serial Date of Purchase 2014 Pinnacle Products International Inc XXXXXXXXXXXXXXXXX XXXXXXXXXXXXXXXXX XXXXXXXXXXXXXXXXX Serial Number Label XXXXXXXXXXXXXXXXX A XXXXXXXXXXXXXXXXX XXXXXXXXXXXXXXXXX Ta XXXXXXXXXXXXXXXXX XXXXXXXXXXXXXXXXX XXXXXXXXXXXXXXXXX 10 Turbo Electric Fan Heater User s Manual E TEE eegen PINNACLE INTERNATIONAL 2013 Pinnacle Products International Inc 668 Stony Hill Road 302 Yardley PA 19067 USA Toll Free 800 641 6996 Fax 215 891 8461 Web www pinnacleint com e Email info pinnacleint com
10. lled check from the original purchase This Limited Warranty shall be limited to the repair or replacement of parts which prove defective under normal use and service within the warranty period and which Pinnacle Products International Inc shall determine at its reasonable discretion This warranty does not apply to products purchased for rental use This Limited Warranty does not cover any failures or operating difficulties due to normal wear and tear accident abuse misuse alteration misapplication improper installation or improper maintenance and service by you or any third part Failure to perform normal and routine maintenance on the heater shipping damage damage related to insects birds or animals of any kind and damage due to weather conditions are also not covered In addition the Limited Warranty does not cover damage to the finish such as scratches dents discoloration rust or other weather damage after purchase All transportation costs for the return of damaged product or parts will be the responsibility of the purchaser Upon receipt of damaged item Pinnacle Products International Inc will examine the item and determine if defective Pinnacle Products International Inc will repair or replace and return the item freight pre paid NEVER LEAVE HEATER UNATTENDED WHILE CONNECTED TO A POWER SOURCE lf Pinnacle Products International Inc finds the item to be in normal operating condition or not d
11. m the adapter must be outlet When properly installed it provides a connected to the permanent ground such as ground connection through the cord to the a properly grounded outlet box The adapter heater to protect the operator from electric should not be used if a three slot grounded shock receptacle is available Grounding Methods O Metal Screw Ir Grounding Means B Grounding Pin Figure 2 Maintenance Cleaning and Maintenance Before cleaning the appliance disconnect it from the outlet and let it cool down In order to protect the enclosure do not splash water onto the heater and never use a solvent like gasoline isoamyl acetate The enclosure is easy to get dirty Wipe it toluene etc to clean the heater often with a soft sponge For very dirty parts wipe with a sponge dipped in lt 122 F water and mild detergent then dry the heater enclosure with a clean cloth Be careful not to let the water enter the inside of the appliance 2014 Pinnacle Products International Inc 8 Turbo Electric Fan Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Troubleshooting Locating Your Serial Number Your serial number can be found on the heater s rating label It will begin with the letters PEFH followed by 9 digits For Example PEFH120900170 Have your Serial Number ready before calling customer service at 800 641 6996 Fan stays on when
12. ter on a stable and level outlet and extension cord rface ES ALWAYS unplug the heater when not in use ALWAYS install the heater so that it is not directly exposed to water spray rain dripping water or wind Do not place the heater against paperboard or low density fiberboard surfaces CAUTION HOT WHILE AWARNING IN OPERATION DO NOT TOUCH KEEP CHILDREN ANIMALS CLOTHING AND COMBUSTIBLES AWAY FROM HEATER Keep all combustible materials away from this heater Minimum Clearance From Combustibles ER Look for this icon throughout the manual for helpful tips on how to assemble use and clean your Electric Fan Heater 2014 Pinnacle Products International Inc 2 Turbo Electric Fan Heater User s Manual NEVER LEAVE HEATER UNATTENDED WHILE PROTEMP CONNECTED TO A POWER SOURCE Specifications subject to change without notice Features PT 515 120 PT 53 240 xt F Sel lt NZ b unction Selector SIM Or Handle SEK a e Ar e I Thermostat Knob NN ER HN SN UU NC ae JA i Power Light U Kaf AMM EE Eft Gei ech D MUG ODM AO DDO Sws y v A Kg y ve A i U Y AN SPORE Heater Coil Adjustment Knob PAY Ke ye e ML CEA Zeie Gier Ji Cu VAN EE OELE A FAU d XX ABA Ke t INSEE De Md K AU LA EE WA Zei AAT at re Stay DCK A AA ROX RAIA SOOO INNS Ce YNYD Ae Gem Fan a
Download Pdf Manuals
Related Search