CG-15010-20 DUAL 30V 60V controller manual.pub
Contents
1. 30 60 VAC Dual Power Controller CG 15010 20 User s Manual GCHEMGLASS 3800 North Mill Road Vineland NJ 08360 USA Ph 1 800 843 1794 Fx 1 800 922 4361 Web www chemglass com REV CG050614 Table of Contents page Eca UTES ae caste tetsu eee abbia testate ated 3 GeneEdl S6 ui cec ee ene te Pers Pee a eee 3 Setup amp Operation ee eti eod tette Eel e agre notan 4 SDE CICA OMS ETT 5 EF OUDICSHOOUING 3355 e DEC LEER aidan raga anise eerie eee 2 Maintenance caeiie SEN NUT TTE ERE 6 Warranty cei 6 Features 1 Selectable output voltage 30 VAC or 60 VAC Dual channels Lighted ON OFF Switch Circuit protection 20 WATTS 30 VAC 27 WATTS 60 VAC Low profile housing E d General Use The Power Controller is used to manually adjust power to a load with a simple turn of a knob It was designed for use with low voltage heating mantles The output voltage is selectable at 30 VAC and 60 VAC The approximate values for the voltage output per channel can be found in Table 1 Knob Setting 26 O 02424579 0 7 2 5 60 6242 579 28 042 5 80 23042576 46 0 42 5 Table 1 Approximate Output Voltages Actual voltage outputs can be found by using a voltmeter or digital multi meter across the heating mantle or load Setup amp Operation Connect the heater heating mantle to the load receptacle located on the rear of the unit for desired channe2. l s Plug the power cord of the Power Controller into an electrical outlet Turn the ON OFF switch to its ON position In the ON position the switch will be illuminated Select either the 30 VAC or 60 VAC output Turn the control knob to your desired power setting When the knob is pointed at 10046 full power will be applied to the load Refer to Table 1 Se ee FRONT VIEW 120VAC REAR VIEW 120VAC Receptacle Receptacle 30 60VAC Controller Power Cord 30 60VAC Controller 30 60VAC Power Power Cord Controller Mantle power cords 30 60VAC Power i Controller Mantle power cords Mantle ev OTE Do Not Exceed Wattage amp Voltage Requirements of Heating Mantle Specifications Input Voltage 120V AC 50 60 Hz Output Range 5 to 100 of rated voltage per channel Maximum Output Power 27 Watts 5 per channel Maximum Output Voltage 60 VAC 5 per channel Maximum Output Current 45 Amps 5 per channel NOTE THIS UNIT MUST ONLY BE USED WITH 30VAC or 60V AC RATED DEVICES i e HEATERS AND MANTLES Troubleshooting Possible Cause Corrective Action No Output Heating Circuit Breaker tripped Depress black button on circuit breaker NOTE if on power controller circuit continues to trip Call for service Loose connections Ensure all connections are correct and secure Burned out element in Plug an incandescent light into the power heater mantle controller s output if bulb lights then the heater
3. mantle is defective If the bulb does not illuminate then call for service Power switch does not Circuit Breaker tripped Depress black button on circuit breaker NOTE if illuminate when turned on power controller circuit continues to trip Call for service on Maintenance Do NOT connect heating mantles or heaters resistive loads that have power ratings of greater than 27 watts Do NOT connect motors inductive or capacitive loads to this unit Do NOT use aggressive solvents to clean this unit This unit should be kept away from temperatures above 60 C pls Warranty Chemglass Inc warranties this unit against defects in material and workmanship for a period of two years from the date of sale If the unit should malfunction it must be returned for evaluation If the unit is determined to have a defect in materials or workmanship then it will be repaired or replaced at no charge Tampering with the unit or damage resulting from exces sive current heat moisture vibration corrosive materials or misuse will void this warranty Programming changes or recon figurations are not covered under warranty Connecting any device to this unit that does not have a voltage rating of either 30VAC or 60VAC will void this warranty Return Policy To return this item under warranty advise the Chemglass Electronics Department of the situation and they will provide you with a return authorization number The unit will be evaluated a
4. nd repaired as required in accordance to the warranty Please contact the Chemglass Electronics Department with warranty repair information Tel 1 800 843 1794 ext 2124 Fax 1 800 922 4361 Email electronics chemglass com
Download Pdf Manuals
Related Search