Glass Island Extractor
Contents
1. E g gas boilers e Ensure the requirements of the local authorities are adhered to concerning the discharge of exhaust air e Ensure adequate room ventilation is provided when the extractor is used in the same room as appliances supplied with energy other than electricity Never duct into a hot air flow such as a central heating duct AN We strongly advise that all exterior outlets be fitted with a non return flap or louvred slatting Remove the frame assembly from the packaging and remove the 2 screws A to separate the upper part from the lower part Fig 2 Fig 2 Exclusive to Howdens J oinery co Page 9 LAM ONA Appliances Installing Your Extractor Position the hole template on the ceiling paying attention that the arrow is positioned on the same side as the appliance controls Fig 3 Drill 4 28 holes in the ceiling and drive in 3 screws without completely tightening them Pay attention not to insert the screw into the hole marked with an X on the hole template the fixing must be into a suitable structure that will support the weight of the extractor securing to plasterboard alone is not sufficient Fig 3 Take the upper part of the structure B and insert the 3 slots onto the 3 screws that are not completely tightened rotating slightly to fit Fig 4 Drive in the fourth screw X and tighten the remaining 3 to fully secure the upper part of Page 10 www howdens com U2. Electrical products can be dangerous to children Keep children away from the product when it is operating and do not allow them to play with or near the product The packaging materials will be dangerous for children Keep the packaging materials away from children Please dispose of all parts of the packaging according to environmental standards Safety When Working with Electricity In case of any damage switch off the product and disconnect it from the mains To do this turn off the fuse at the fuse box Make sure that fuse rating is compatible with the product www howdens com User manual LAM2603 General Information amp Operation Parts Identification On opening your box you will find the extractor body complete with glass canopy a two piece telescopic frame a two piece decorative chimney a bag of fixings and a ducting connector Upper Frame Lower Frame Upper Chimney Section Lower Chimney Section Extractor body Glass Canopy Not Shown Recirculation Diverter 2 x Grease filters Vent Adapter U APUNE sD A Power On Light D Extractor Power Level 2 B Extractor Power Off E Extractor Power Level 3 C Extractor Power Level 1 F Extractor Light On Off Exclusive to Howdens J oinery co Page_ 5 LAM ONA Appliances Care and Maintenance A Before cleaning or attempting any type of maintenance always make sure that the electricity supply is disconnected A To avoid the possibi
3. Glass Island Extractor LAM 2603 User amp Installation Guide LAMONA Exclusive to Howdens Joinery Co LAM ONA Appliances Dear Customer Congratulations on your choice of a LAMONA domestic appliance which has been designed to give you excellent service The user manual will help you use your product quickly and safely e Please read this user manual before installing and using the product e Always follow the safety instructions e Keep this user manual within easy reach for future reference e Please read any other documents supplied with the product Explanation of symbols Throughout this user manual the following symbols are used A Important information or useful tips about usage AN Warning for possible hazards to health and property A Warning possibility of electric shock This product s packaging material is recyclable Help recycle it and protect the environment by dropping it off in the municipal receptacles provided for this purpose Your product also contains a great amount of recyclable material It is marked with this label to indicate the used appliances that should not be mixed with other waste This way the appliance recycling organised by your manufacturer will be done under the best possible conditions in EE compliance with European Directive 2002 96 EC on Waste Electrical and Electronic Equipment Contact your town hall or your retailer for the used appliance collection points closest to your hom
4. a problem Please ensure you have ready e The product s model amp serial numbers e Howdens Proof of Purchase document e Your full contact details Call the Service Line on 0845 00 60 006 Exclusive to Howdens J oinery co Page 17 LAM ONA Appliances Page 18 www howdens com User manual LAM2603 Product Information Commission Regulation EU No 66 2014 LAMONA Model LAM2603 AEC 169 7 kWh a f 2 F FDEhoog 9 40 EElhood 106 1 a A 235 m3 h Peep 183 1 Pa Qmax 402 m3 h Weep 127 9 W W 80 W E middle 579 lux Exclusive to Howdens J oinery co Page 19 Issue 12 2014 If supplied please stick your self adhesive product rating plate here or make a note of the product serial number below in the box below for future reference Serial NUImbelL enisinia nannan aaan ide le toner ts MA N Y MIX 44 HOWDENS zz MIN YD JOINERY CO MAKING SPACE MORE VALUABLE responsible sources Sa FSC C081735 printed on FSC certified paper
5. e We thank you doing your part to protect the environment Page 2 www howdens com Index Before using the extractor Safety General Safety for children Safety when working with electricity General information and operation Extractor Parts Identification Control panel layout Care and maintenance General Cleaning Grease Filters Carbon Filters Replacing the Lamps Installation Methods of extraction Extraction Via Ducting Extraction Via Recirculation Modes of Installation Installing your extractor Decorative Chimney Fitting Electrical Connections Troubleshooting Technical specification Your Guarantee 16 17 Exclusive to Howdens J oinery co User manual LAM2603 Page 3 LAM ONA Appliances Before using the Extractor e Make sure that you have removed all packaging wrappings stickers and films from the Extractor e tis recommended that you clean the extractor s surface before using for the first time Safety AN This appliance is for domestic extraction purposes only It must not be used for other purposes Commercial use will void the guarantee The manufacturer shall not be liable for any damage caused by improper use installation or handling errors General This product is not intended to be used by persons with physical sensory or mental disorders or unlearned or inexperienced people including children unless they are supervised by a person who will be responsible for their safety o
6. he mains fuse maybe Check fuses in the fuse box If necessary operate defective or has tripped replace or reset them Product is not connected Check all power connections properly AN If you cannot eliminate the problem after following the instructions in this section consult your depot or the Authorized Service Agent Never try to repair a nonfunctional product yourself Technical specification TECHNICAL INFORM ATION General Total power consumption 310W Fuse 3A Voltage Frequency 220 240 V 50 Hz Cable type section 0 75mmz2 2 core or equivalent Cable length max 1m Lamps 4 x G4 20W each Page 16 www howdens com User manual LAM2603 Your Guarantee Product Guarantee Details UK only Your appliance has the benefit of a comprehensive manufacturer s guarantee which covers the cost of breakdown repairs Details of which are shown on your Proof of Purchase Document e Anyclaim during the period of the guarantee MUST BE ACCOMPANIED BY THE PROOF OF PURCHASE e The product must be correctly installed and operated in accordance with the manufacturer s instructions and used for normal domestic purposes e This guarantee does not cover accidental damage misuse or alternations which are likely to affect the product e The guarantee is invalid if the product is tampered with or repaired by any unauthorised person The guarantee in no way affects your statutory or legal rights What to do if you need to report
7. lity of fire adhere strictly to all of the recommendations included in this booklet paying particular attention to the grease filters to ensure grease deposits do not build up The manufacturer declines all liability in cases where the instructions for the appropriate installation maintenance and use of the extractor hood are not observed If the power cable is cut or damaged in any way disconnect the extractor from the electricity supply and call the service number on the rear cover of this booklet or a suitably qualified repairer General Cleaning Wipe the external surfaces of the appliance regularly using warm water and a mild detergent NEVER use abrasive cleaners The Grease Filters The grease filter is of a metallic material and should be washed using a neutral detergent To Remove the grease filters 1 Push latch 2 Lower filter 3 Unhook and remove The Carbon Filters Carbon filters have a limited life We advise you to change them when there is a noticeable drop in performance The intervals between changing the filter will depend entirely upon the amount of cooking you do but on average they will last about 6 months Please quote the part reference number HJA2912 pack of 2 when re ordering e To gain access to the carbon filters first of all remove the grease filters as above e Remove the old filters and install new charcoal filters Page 6 www howdens com User manual LAM2603 Replacing
8. proceed as follows The wire which is coloured blue must be connected to the terminal which is marked with the letter N or coloured BLACK The wire which is coloured brown must be connected to the terminal which is marked with the letter L or coloured RED Blue Neutral o FUSE ON DP zsov Nsurpty Exclusive to Howdens J oinery co Page_ 15 LAM ONA Appliances Troubleshooting TROUBLESHOOTING GUIDE coc B dae A replacement lam is EDU ide MEN TR the ane ly necessary but ore adjusting or replacing the first ch ck that th lam In earrecty fitted into its Remember that The extractor lam S may ecome fo e amps are not therefore ensure the bulb has coole covered by the guarantee sufficiently before replacing e Poweris cut Check if there is power Check the fuses in the fuse ox If necessary replace or reset the fuses Motor is on but fa e Clogged filters can reduce Clean the grease filters with warm water does not seem to be the products efficiency and mild detergent and or replace any as efficient as usual eck the charcoal filters C grease an charcoal filters if fitted also ensure any venting is not obstructed The extractor works e Clogged filters can reduce clean the pease filters with warmi water normally but smells the product s efficiency and mild detergent and or replace any inger and may cause unwanted charcoal filters Product does not e T
9. r who will instruct them accordingly in the use of the product e Do not operate the product if the power cable is damaged Call a qualified service agent e Do not carry out any repairs or modifications on the product However you may remedy some of the problems that do not require any repairs or modifications See Troubleshooting at the rear of this manual e Never wash down the product with excessive water as there is the risk of electric shock e Never use the product when your judgment or coordination is impaired by the use of alcohol and or drugs e Product must be disconnected from the mains during installation maintenance cleaning and repair procedures e Repair procedures must always be performed by qualified service agents The manufacturer shall not be held responsible for damages arising from procedures carried out by unauthorised persons which may also void the guarantee Page 4 e Keep all ventilation slots clear of obstructions as this may cause premature failure of the appliance e Do not trap the mains cable during installation and do not route it over surfaces which may become hot The cable insulation may melt and cause a fire as a result of a short circuit e Make sure that the product function buttons are switched off after every use e Product must be installed by a qualified person in accordance with the regulations in force otherwise the guarantee may become void Safety for Children
10. raction via recirculation attach charcoal exhaust pipes connected to the outside are filters above the metal grease filters see page 6 already operating unless perfect ventilation can be Part reference HJA2912 guaranteed A Before attempting to change or fit the charcoal filters ensure power to the extractor is switched off e Connect the external ducting kit to the outlet of the extractor A Charcoal filters are not required if the extractor Remove the grease filters is to be ducted out e Fitthe carbon filters into the aperture see page 6 Replace the grease filters before the power supply is turned back on Page 8 www howdens com User manual LAM2603 Installing Your Extractor AN This instruction must be strictly adhered to Failure to comply could result in overheating and serious damage to your appliance It is recommended that the installation is carried out by two people A Ensure the ceiling to whith this extractor it to be installed is strong enough to support the weight of the extractor Do not secure to plasterboard alone A Before drilling or chiselling the ceiling or wall check for pipes and power cables e If ducting externally ensure the ducting tube is kept as short as possible and with the minimum of bends to permit smooth airflow Maximum length 3 metres Ducted air must not be discharged into a flue which is used for exhausting fumes from appliances supplied with energy other than electricity
11. ser manual LAM2603 Installing Your Extractor Take the lower part of the telescopic structure C and insert it into the upper structure B Fig 5a Adjust the height of the frame assembly X by referring to the dimensions indicated in Fig 6 and secure it using the 8 screws G that are supplied Fig 5b Fig 5a X C 90 40 650 B Exclusive to Howdens J oinery co Page 11 Fig 6 LAM ONA Appliances Installing Your Extractor Recirculation installation Ducting out installation Fix the flexible pipe to the deflector M and secure deflector to frame as indicated in Fig 8 Fix the flexible pipe to the prepared air evacuation hole Fig 7 The active carbon filters must be applied to the suction unit positioned inside the hood Fig 9 Fig 8 Fig 7 If your product is supplied with a connector flange F fit it to the upper part of the cooker hood suction assembly using the 2 screws E Fig 9 Fig 9 Page 12 www howdens com User manual LAM2603 Installing Your Extractor Fit the upper chimney piece to the frame using the 2 screws A Fig 10 Attach the lower chimney piece to the upper one and fix it carefully using adhesive tape L Fig 11a Partially unscrew the 2 screws O a maximum of 3 mm Fig 11a Insert the extractor body into the frame paying attention that the previously unscrewed screws O hook into
12. the Lamps The extractor hood is fitted with four G4 20W halogen lamps that may need to be replaced periodically To do this ensure that the power is switched off and the lamps have had time to cool Use a flat bladed screwdriver to gently prize open the glass cover and trim that sits over the bulb e Thelight bulb can then be pulled away from the light fitting and disposed of appropriately e Replace the bulb with an appropriate G4 20W max bulb and clip the class cover back into place AN Lamp replacement is not covered by your guarantee The lamps on this appliance should only be used during operation of the cooker hood They should not be left on permanently and used as a main lighting source The extractor is for domestic use only Exclusive to Howdens J oinery co Page 7 LAM ONA Appliances Installation Methods of Extraction The very best method of clearing the kitchen of unwanted odours is by connecting the appliance to an exhaust duct and venting to the outside atmosphere via the ceiling or an exterior wall Suitable Ducting kits part ref APL2807 may be purchased from the depot where you bought the extractor You do not need charcoal filters when using the external Ducting mode Extraction Via Ducting Extraction Via Recirculation Ducting mode APL2807 ducting Kit Recirculation mode Supplied Separately Charcoal filters required Never use the hood in areas where devices with For ext
13. the slots in the lower part as indicated in Fig 11b Tighten in the 3 screws N and the 2 screws O Fig 11b Exclusive to Howdens J oinery co Page 13 LAM ONA Appliances Installing Your Extractor Fix the air evacuation pipe H not supplied onto the connection flange F Fig 12 Fig 13 Fig 12 Remove adhesive tape L and rest the lower chimney piece above the cooker hood Fig 13 Page 14 www howdens com User manual LAM2603 Electrical Connections AN IMPORTANT Ensure that the electricity supply is switched off before connecting Your appliance must be connected to fixed wiring via the use of a double pole switched fused spur outlet with at least 3mm contact separation The isolation switch must be accessible after installation See technical data for fuse rating We strongly recommend the appliance is connected by a qualified electrician A The terminology DOUBLE POLE means that both the live and neutral supplies are switched and disconnected at the same time The terminations labelled SUPPLY are the connections for the internal house wiring and the terminations labelled LOAD are for connection to the appliance IMPORTANT The wires in the mains lead are coloured in accordance with the following code Blue Neutral Brown Live As the colours of the wires in the mains lead of this appliance may not correspond with the coloured markings identifying the terminals in your spur box
Download Pdf Manuals
Related Search