Home

user`s manual

image

Contents

1. and shall be easily accessible 4 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS PRODUCT DESCRIPTION L RELAY RELAY Ly INPUT OUTPUT RELAY gt N N INVERTER UPS Functionality The XVT UPS products use Line Interactive Automatic Voltage Regulation AVR UPS technology Under normal AC power operation the input power flows through the AVR circuit regulating the incoming AC power to the output of the UPS and the load connected If the input power disappears the Inverter circuit is switched on to provide output from the batteries contained within the UPS POWER ON OFF AC MODE GREEN LED CHARGE MODE YELLOW LED BATTERY MODE RED LED XVT FRONT PANEL 5 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS USB Connector 3 Battery Protected Outlets 3 Surge Only Outlets 6 Foot Power Cord Input Breaker XVT REAR PANEL Battery Surge Outlets Provides battery powered surge outlets for the connected equipment and insures uninterruptible operation of your equipment during a power failure Power Switch can be used as a master on off switch for equipment connected to the battery powered outlets Power On Indicator This LED is illuminated when the utility condition is normal and the UPS outlets are providing power free of surges and spikes Circuit Breaker rhe circuit breaker that provides ove
2. 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS REPLACING THE BATTERY QUALIFIED SERVICE PERSONNEL ONLY CAUTION Read and follow the IMPORTANT SAFETY INSTRUCTIONS before servicing the battery Service the battery under the supervision of Qualified Service Personnel knowledgeable of batteries and their precautions CAUTION use only the specified type of battery See your dealer for replacement batteries CAUTION rne battery may present risk of electrical shock Do not dispose of batteries in a fire as it may explode Follow all local ordinances regarding proper disposal of batteries CAUTION po not open or mutilate the batteries Released electrolyte is harmful to skin and eyes and may be toxic CAUTION Although the battery system voltage is only 12VDC and 24VDC the battery can present a high risk of short circuit current and electrical shock The short circuit current capability of the battery is sufficient to burn wire or tools very rapidly producing molten metal Observe these precautions when replacing the battery Remove all watches rings or other metal objects Only use tools with insulated handles Do not lay tools or metal parts on top of battery or any terminals Wear protective eye wear goggles rubber gloves and boots Disconnect the charging source before connecting or disconnecting the battery terminals mu omo web Determine if the battery is inadvertently grounded If inadvertently grounded r
3. exceed 8596 of the UPS capacity HARDWARE INSTALLATION GUIDE 1 Your new UPS may be used immediately upon receipt however charging the battery for at least 4 hours is recommended to ensure that the batteries maximum charge capacity is achieved Charge loss may occur during shipment and storage To recharge the battery plug the power cord into the correct type AC wall outlet and turn the power switch on Note Xtreme Power units will charges the battery with the power switch in either the on or off position With the UPS off and unplugged connect your computer monitor and or any other externally powered equipment into the battery power supplied outlets DO NOT plug a laser printer copier space heater vacuum or other large electrical device into the UPS The power demands of these devices will overload and possibly damage the UPS Plug the UPS into a 2 pole 3 wire grounded receptacle AC wall outlet as rated in the Specifications section of this document Make sure the wall outlet is protected by a fuse or circuit breaker and does not service equipment with large inrush electrical demands e g refrigerator copier etc Note DO NOT use extension cords or power or surge strips on the input or the output of the UPS 7 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS 4 Depress the power switch to turn the UPS on The power on LED indicator and charging LED will illuminate after the UPS i
4. instructions Please read and follow ALL instructions carefully during the installation and operation of the UPS Read this manual thoroughly before attempting to unpack install or operate CAUTION ro prevent the risk of fire or electric shock install in a temperature and humidity controlled indoor area free of conductive contaminants Please see specifications for acceptable temperature and humidity range CAUTION 7o reduce the risk of electric shock do not remove the UPS cover Qualified Service Personnel must perform ALL repairs and maintenance No user serviceable parts inside CAUTION Hazardous live parts inside can be energized by the battery even when the AC input power is disconnected CAUTION ups must be connected to an AC power outlet with fuse or circuit breaker protection Do not plug into an AC wall outlet that is not grounded If you need to de energize this equipment turn off and unplug the UPS DO NOT USE FOR MEDICAL OR LIFE SUPPORT EQUIPMENT xtreme Power does not sell products for life support or medical applications DO NOT use these UPS in any circumstances that would affect operation or safety of any life support equipment or with any medical applications or patient care NOTICE wot for use in a computer room as defined in the Standard for Protection of Electronics Computer Data Processing Equipment NOTICE 4n acceptable outlet based upon UPS Specifications shall be installed near the equipment
5. 7 Short Circuit Breaker BATTERY Battery Type Sealed Maintenance free lead acid pata Qty amp 1 12V 7AH 1 12V 9AH 2 12V 7AH 2 12V 9AH Recharge less than 10 hours to 90 capacity Backup Time full load amp half 3 min full load 2 6 min 50 load load Charge Current 1 5A Max PHYSICAL MC WxDxH WxDxH WxDxH WxDxH inches inches inches inches Product 3 7 x 14 6 x 3 7 x 14 6 x 4 9 x 16 9 x 4 9 x 16 9 x Dimensions 6 2 6 2 8 7 8 7 Shipping 6 1 x 16 2 x 6 1 x 16 2 x 7 5 x 18 9 x 7 5 x 18 9 x Dimensions 10 2 10 2 12 8 12 8 Product Weight 15 3 Ibs 16 8 Ibs 27 6 Ibs 31 3 Ibs Shipping Weight 17 6 Ibs 19 2 Ibs 29 8 Ibs 32 4 Ibs Line Cord 6 ft NEMA 5 15P Receptacles 6 NEMA 5 15R 3 SURGE PROTECTED 3 UPS USB Communications nterface Bezel Color Brushed Metallic Outer Black Inner Included in box PowerManager CD USB cable Manual ENVIRONMENT Jast Humidity 0 90 Audible Noise lt 45dB Altitude 5000 ft 1500 m above sea level WARRANTY Warranty Two years electronics One year batteries APPROVALS North America UL cUL FCC 17 UNINTERRUPTIBLE POWER SUPPLY UPS XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS 120V Model XVT 600 XVT 800 XVT 1200 XVT 1500 amp Green LED on Orange LED on Red LED off no beep Charging Battery Orange LED on
6. Battery Mode Green LED and Orange LED off Red LED flash buzzer slow beep Battery Low Green LED and Orange LED off Red LED on buzzer fast beep SHIPPING LIST 1 1 UPS 2 1 User s and Installation Manual 3 1 Intelligent monitoring software 4 1 USB computer port cable 18 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS OBTAINING SERVICE If the UPS requires Service 1 Usethe TROUBLESHOOTING section in this manual to eliminate obvious causes 2 Verify there are no circuit breakers tripped 3 Call your dealer for assistance If you cannot reach your dealer or if they cannot resolve the problem call Xtreme Power Conversion Corp Technical Support at 800 582 4524 Technical support inquires can also be made at support xpcc com Please have the following information available BEFORE calling the Technical Support Department a Your name and address The serial number of the unit Where and when the unit was purchased All of the model information about your UPS Any information on the failure including LED s that may or may not be illuminated A description of the protected equipment including model numbers if possible A technician will ask you for the above information and if possible help solve your problem over the phone In the event that the unit requires factory service the technician will issue you a Return Material Authorization number RMA If y
7. R SUPPLY UPS nstall5hield Wizard X Select Components Select the options you want to install Select the components you want lo install clear the components you do not want Io install Chinese Simplified Chinese T raditional French German Italian Japanese Portuguese Spanish zl InstallShield lt Back Cancel Choose software language and click Next Setup Status PoweM anacerll Setup performing the requested operations InstallShield Software will install automatically 11 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS nstallShield Wizard InstallS hicld Wizard Complctc The InstallShield ward has successfully installed PowerManagerl Click Finish to exit wizard Mies tatnen riu mU Q m Q l Choose Will you run Powermanager II right now and click Finish 2015 Syrtes View Control Yelp ih WO AD 24 7 mu x 51121180240 Bane Setting Shatdorn Setting Crisis Process Saved setting h 120180240 IN OV rece Local UPS Testing V otuthertretion oH Your UPS can not be monitored by rewcte computer when you use the serial port to connect it If yon vant to do it DUT W utpot Voltage use the USB port C Remote UFS ID 112 18 0 130 scorch Frequency Aut
8. WER SUPPLY UPS SAFETY INSTRUCTIONS ATTENTION ro safely interact with and enjoy all the features and benefits of these Xtreme Power Conversion Uninterruptible Power Supplies UPS please read and follow all installation and operation instructions completely These UPS are designed to provide power protection for connected electronic equipment Please read this manual before installing the XVT Series UPS models XVT 600 XVT 800 XVT 1200 and XVT 1500 as it provides important information that should be followed during installation and maintenance of the UPS and batteries allowing you to correctly set up your system for the maximum safety and performance Included is information on customer support and factory service if it is required If you experience a problem with the UPS please refer to the Troubleshooting section in this manual to correct the problem If the problem is not corrected please collect information so that the Technical Support personnel can more effectively assist you CAUTION Any changes or modifications not expressly approved by the manufacturer of this device could void the user s authority to operate the equipment FCC Notice This equipment has been tested and found to comply with the limits for a Class B Digital Device pursuant to Part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in residential installation This equipment generates uses and can ra
9. c gt lt T REME gt O W CONVERSION Xtreme Value Tower Series XVT User s amp Installation Manual Xtreme Power Conversion Corporation XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS TABLE OF CONTENTS SAFETY INSTRUCTIONS a L rennen debts ete iret s te ES een Era ehe ede ye ona tan ee ep to RON ES 3 PRODUCT DESCRIPTION ou 7 titre ert un nte een a Feet Cer aa ka eto i clue o cut ey er aeneae Settee ses 5 DETERMINING THE POWER REQUIREMENTS OF YOUR EQUIPMENT em nnn nnns 7 HARDWARE INSTALLATION GUIDE 55 32255 eene oc ru eth etta an terrea eee eoe ee ER ra Ye nba a ayasa ays 7 QUICKSTART SOFTWARE INSTALLATION GUIDE eene nmn enne nnne eren enne ene 9 REPLACING THE BATTERY iret oe rre ree Se Ra Ha E PE Re REGE TUR Y ed eR e ERES 14 DEFINITIONS FOR LED INDICATORS i eee ertet e oerte tet Er Eee neret tha 15 DE dub EL 15 TROUBEESRHOOTING 2 2 ner ore nee aday S aa eee ee e eee ahay eben ege eoa pe rena ee quaa d eund 16 SPECIFICA TONS u a E ER 17 SHIPPING US T ree erroe ee a E e EAEE KEAN SOE EEES 18 aa aea aed eere ie be eb ete EAR ed ete HE RR dania ala 19 XTREME POWER CONVERSION XPC CORPORATION LIMITED WARRANTY 20 2 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE PO
10. d States and Canada this warranty covers repair or replacement at the sole discretion of XPC Corporation The customer is responsible for the costs of shipping the defective product to XPC Corporation XPC Corporation will pay for ground shipment of the repaired or replacement product This warranty applies only to the original purchaser If equipment provided by XPC Corporation is found to be Dead on Arrival DOA XPC Corporation will be responsible for the costs of shipping product to and returning equipment from the customer in a timely manner as agreed to with the customer once the customer has requested and received a Return Material Authorization RMA number DOA equipment is defined as equipment that does not properly function according to user documentation when initially received and connected in conjunction with proper procedures as shown in the user documentation or via support provided by XPC Corporation personnel or authorized agents This warranty shall be void if a the equipment is repaired or modified by anyone other than XPC Corporation or a XPC Corporation approved third party b the equipment is damaged by the customer is improperly used or stored is subjected to an adverse operating environment or is operated outside the limits of its electrical specifications or c the equipment has been used or stored in a manner contrary to the equipment s operating manual intended use or other written instructions Any technical advic
11. diate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications There is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures 1 Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver Connect the equipment into an outlet on a circuit different from that to which the receiver is connected 4 Consult the dealer or an experienced technician for help Any special accessories needed for compliance must be specified in the instruction CAUTION shielded type power cord is required in order to meet FCC emission limits and to prevent interference to the nearby radio or TV reception It is essential that only the supplied power cord be used Use only shielded cables to connect I O devices to this equipment CAUTION Any changes or modifications not expressly approved by the manufacturer of this device could void the user s authority to operate the equipment 3 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS IMPORTANT SAFETY INSTRUCTIONS SAVE THESE INSTRUCTIONS This manual contains important safety
12. e furnished by XPC Corporation or a XPC Corporation authorized representative before or after delivery with regard to the use or application of Xtreme Power Conversion equipment is furnished on the basis that it represents XPC Corporations best judgment under the situation and circumstances but it is used at the recipient s sole risk EXCEPT AS STATED ABOVE XPC Corporation DISCLAIMS ALL WARRANTIES EXPRESSED OR IMPLIED INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE EXCEPT AS STATED ABOVE IN NO EVENT WILL XPC Corporation BE LIABLE FOR DIRECT INDIRECT SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING OUT OF THE USE OF Xtreme Power Conversion EQUIPMENT including but not limited to any costs lost profits or revenue loss of equipment loss of use of equipment loss of software loss of data cost of substitutes or claims by third parties Purchaser s sole and exclusive remedy for breach of any warranty expressed or implied concerning Xtreme Power Conversion equipment and the only obligation of XPC Corporation under this warranty shall be the repair or replacement of defective equipment components or parts or at XPC Corporations sole discretion refund of the purchase price or substitution of an equivalent replacement product 20 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS 21
13. emove the source of the ground Contact with a grounded battery can result in electrical shock The likelihood of such shock will be reduced if such grounds are removed during installation and maintenance applicable to a UPS and a remote battery supply not having a grounded circuit 14 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS DEFINITIONS FOR LED INDICATORS LED 1 LED 2 LED 3 green yellow red Unit Status ON OFF On AC Power OFF OFF FLASH On Battery Charge Overheat x x ON Low Battery Overload Protection Short Circuit Note means any situation LED 1 GREEN LED 3 RED ALARMS Alarm Indication Unit Status Buzzer every 5 sec DC start Buzzer every 1 sec Self test 2 buzzer every 1 sec Low battery 4 beep every 2 4 sec Overload 3 buzzer every 1 sec Overheat Input is off long beep power off after 5 sec 15 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Full time surge protection outlets stop providing power to equipment Circuit breaker has tripped due to an overload Turn the UPS off amp unplug at least one piece of equipment Wait 10 sec replace the fuse with a fuse of like size amp rating amp turn the UPS on The UPS does
14. horization ichcous Dizeonnected Auto start PonayManager UI when login cystas anufacturer UPS Model UPS Ver O8 4t E After the UPS switches on please choose the System Setting tab from the drop down box 12 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS System Setting gt Base Setting Shutdown Setting Crisis Process Saved setting Local UPS Authorization Your UPS can not be buter when you use the serial port to connect it If you want to do it use the USB port Remote UPS Lig 18 D0 130 search Authorization F chcomm Auto start PowerManager UI when login system Click Local UPS and choose USB click OK Syston View Control Help C 8 4 9 30 80 3120459 amp D 30 8 3012150 1N 118 DUT 118 Input Voltage Output Voltage op 40 9 gu p 100 252 t uu EF Tenperatur F 61 Q0Hz Frequency Battery Capability Load e Connected e AL Worssl bntiers Formal WS Formal Qu Self Test e UPS OnLine State Data Tine Bent Information 08 01 07 09 51 09 Rexuse 06 01 07 09 50 58 Fail 06 01 07 09 50 58 UPS Connected 06 01 01 03 40 38 Di Connected Manufacturer UPS Modal UPS Ver 09 51 24 The UPS is now connected and in normal operation 13 XVT 600 XVT 800 XVT 1200 XVT
15. nitial test to indicate the UPS is switched ON 5 f an overload is detected an audible alarm will sound and the UPS will emit one long beep every 2 4 seconds To correct this turn the UPS off and unplug at least one piece of equipment from the battery powered outlets Wait 10 seconds Make sure the circuit breaker is depressed and then turn the UPS on 6 Your UPS is equipped with an auto charge feature When the UPS is plugged into an AC wall outlet and there is acceptable AC voltage present the battery will automatically recharge Charging is controlled by firmware to rapidly charge units to 15VDC 600 800VA units and 29VDC 1200 1500VA units After this threshold is met the XVT places a float charge to maintain battery energy and the charging light will continue to stay on during this time 7 To maintain optimal battery charge leave the UPS plugged into an AC wall outlet with the power switch turned on at all times 8 To store your UPS for an extended period of time cover and store it with the battery fully charged Recharge the battery every two months to maintain battery life 8 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS QUICKSTART SOFTWARE INSTALLATION GUIDE Pwn a Locate the USB Cable inside the box Insert one end of the USB Cable into the UPS and the other into a USB port on your computer Insert the CD into your computers CD drive When the software interface req
16. not supply expected runtime Battery not fully charged Recharge the battery for at least 4 hours The battery is defective Contact Xtreme Power Conversion about replacement of batteries The UPS will not turn on The on off switch is designed to prevent damage by rapidly turning it off and on Turn the UPS off Wait 10 sec amp then turn the UPS on The UPS is not plugged into an AC wall outlet Connect the UPS to an 110 120V 60Hz AC wall outlet The battery is defective Contact Xtreme Power Conversion about replacement of batteries Mechanical problem Contact Xtreme Power Conversion The UPS shuts down when there is loss of AC power The UPS is not providing battery power Shutdown your load amp turn the UPS off Wait 10 sec amp turn the UPS back on This should reset the UPS 16 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL SPECIFICATIONS 120V Model XVT 600 XVT 800 XVT 1200 XVT 1500 INPUT Voltage 94 144 5V Capacity VA W 600 VA 360 W 800 VA 480 W 1200 VA 720 W 1440 VA 900 W Frequency 60HZ 5Hz OUTPUT Voltage 105 134 VAC 120V 12 Waveform Pure Sine Wave Typical Frequency AC mode follow utility Battery mode 60 0 5Hz Transfer Time 4ms Typical Surge Protection 320 Joules Input Protection Compliance with IEEE 58
17. ou are returning the UPS to Xtreme Power for service please follow these procedures 1 Pack the UPS in its original packaging If the original packaging is no longer available as the Technical Support Technician about obtaining a replacement set of packaging material It is important to pack the UPS properly in order to avoid damage in transit Never use Styrofoam beads for a packing material 2 Include a letter with your name address daytime phone number RMA number a copy of your original sales receipt and a brief description of the problem 3 Mark the RMA number on the outside of all packages Xtreme Power cannot accept any package without the RMA number marked on the outside of the boxes 4 Return the UPS by insured prepaid carrier to the address provided by the Technician Refer to the Warranty statements in this manual for additional details on what is covered 19 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS XTREME POWER CONVERSION XPC CORPORATION LIMITED WARRANTY Xtreme Power Conversion XPC Corporation warrants Xtreme Power Conversion equipment when properly applied and operated within specified conditions against faulty materials or workmanship excluding batteries for a period of two years for XVT Series products from the date of purchase XPC Corporation warrants internal batteries for a period of one year from the date of purchase For equipment sites within the Unite
18. rload and fault protection USB Port protocol that provides communication between the UPS and PC Network 6 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS DETERMINING THE POWER REQUIREMENTS OF YOUR EQUIPMENT 1 Make sure the total Volt Amp VA requirements of your connected equipment does not exceed the maximum VA rating for the UPS The maximum VA ratings are shown in the Specifications section of this document Ensure that the equipment plugged into the battery powered outlets does not exceed the UPS rated capacity If UPS rated capacities are exceeded an overload condition may occur and cause the UPS to shut down and trip the circuit breaker If the power requirements of your equipment are listed in values other than Volt Amps VA convert Watts W or Amps A into VA by doing the calculations below Note The equation below only calculates the maximum amount of VA that the equipment can use not what is typically used by the equipment at any given time Users should expect usage requirements to be approximately 6096 of the value to estimate power requirements Watts W x 1 67 VA or Amps A x 120 VA Add the totals for all of the equipment and multiply this total by 0 65 to calculate actual power requirements Note Many factors can affect the amount of power that your computer system will require The total load that you will be placing on the battery powered outlets should not
19. uests a serial number locate and input the serial number from the CD software jacket Follow the software setup prompts Quickstart Software Installation Guide InstallShield Wizard E Welcome to the InstallShield Wizard for PowerM anagerll The InstallShield Wizard will install PowerManagerll on your computer To continue click Next Cancel 9 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWER SUPPLY UPS InstallShield Wizard gt Customer Information Please enter your information Please enter your name the name of the company for whom you work and the produc serial number User Name Customer Company Name Xtreme Power Conversion Corporation Serial Number insert CD SERIAL HERE InstallShield lt Back Next Cancel Input user name company name and serial number into the software interface Note the serial number is on the CD software jacket InstallShield Wizard Choose Destination Location Select folder where Setup wil Install files Setup will instal Power anagerll in the following folder To install to this folder click Nest To irstal to a diferent folder click Browse and select another folder Destination Folder pun Files richconm PowerM anagerll Browse InstallShield Choose installation location and click Next 10 XVT 600 XVT 800 XVT 1200 XVT 1500 USER S MANUAL UNINTERRUPTIBLE POWE

Download Pdf Manuals

image

Related Search

Related Contents

@ml or or atom  Recharge and discharge estimation in data poor areas. User guide  Samsung MAX-DA66 Εγχειρίδιο χρήσης  Definitive Technology CS-8080HD User's Manual  Vivanco Metal Earphones  Hardware Installation Guide  OPERATING INSTRUCTIONS FOR “LDPHCD    ht club 40 handbook 18-11-09:Layout 1.qxd  305924.  

Copyright © All rights reserved.
Failed to retrieve file