Operating Instructions
Contents
1. unit stop To stop the ice maker always use the mains on off switch 41 Upon each re starting the unit goes through the procedure as described in initial Start up monitor light description f The electric ice makers have five warning lights located on the front of the cabinet that monitor the following situations Glows to indicate that unit is switched on Glows to indicate that the bin is full Glows to indicate that there has been an interruption in the water supply Glows to signal an alarm due to either too high or too low a temperature reached by the cooling condenser call service agent p B NN Blinks 3 minute delay time at start up Glows freezer auger wrong rotation call service agent Blinks to signal alarm freezer temperature gt too high call service agent lt daily precautions 43 To prevent bacteria accumulation on the ice it is necessary to observe the following points Do not store anything in the ice storage bin 44 Keep ice scoop clean and disinfected 45 SS Keep the bin door closed 46 During the cleaning of the floor near the machine pay attention that dust does not get sucked in the unit by the fan motor To avoid damage to the unit Never shut off the water supply with the machine in operation S CA Open and close the bin i qx door with gentle D movement never slam or kick it 49 Do not place o2. cooling air drawn into and exhausted out of the compartment to maintain a proper condensing operation Position the ice maker in its final location and make sure that there is everything for its installation namely Maintenance and cleaning operations must be performed by authorised service agents must be fitted with the correct and set up properly using fuse rating with a minimum spiralled hose which clearance of 3mm between should have a minimum open contacts fall of 3cm per metre 19 manual paying close several years to come If the unit is to be It is recommended that S attention to the warnings If in any doubt you a moved be sure to lift it Power supply disconnect The minimum ambient max 40 C the interior of the and advice that are given Whenever should contact your local distributor rather than damage the switch temperature should not be storage bin is cleaned communicating with the manufacturer about levelling feet lower than 10 C and the with an appropriate mild your machine always indicate the model and 5 maximum ambient min 10 C disinfectant solution serial number temperature higher than The Manufacturer 40 C General Information accepts no responsibility i eda el any amage or injury to at Del Ivery people resulting from 28 Important a is ee There are no heat sources Carefully read this user manual before installing Water supply kitchen ovens grills near the
3. the spout or ice chute Does water supply have too high a salt content Flake Ice Maker FMIF 120 installation and operating instructions Operating instructions Foster Refrigerator Oldmedow Road King s Lynn Norfolk PE30 4JU England Tel 01553 691122 Fax 01553 691447 Website www fosterrefrigerator co uk Email sales foster uk com a Division of ITW UK Ltd FSERIESICEFLAKER OP INS 10 04 REFRIGERATOR a IDD AMSA Wi TW N DISPOSAL REQUIREMENTS 1 7 50 EN If not disposed of properly all refrigerators have components that can be wv POSTE R Ko POSTE R harmful to the environment All old refrigerators must be disposed of by i er REFRIGERATOR appropriately registered and licensed waste contractors and in accordance with National laws and regulations preface safety instructions 11 location 26 330 Attention The electrical isolator switch Water drain is connected es 4 This publication is intend ed to acquaint you with the correct use of this ice For the correct unit machine and with the care operation you must that is required for trouble carefully read this free operation and optimum manual and adhere to performance It is important its instructions by to adhere to the instructions doing this your indicated We suggest that machine will operate you thoroughly read this safetly and last for A minimum clearance of 15cm 6 in must be left at the sides of the machine for routing
4. cessor system which has proved each of the Installed machine P are inside the ice storage The electrical suppy to be reliable and more precise than the bin Make sure water available corresponds electromechanical controls used on the earlier series AN a are also to machine FN Bin a re specifications as indicated on the unit nameplate
5. n top and around the ice maker any sort of goods which can limit proper ventilation and jeaopardise hygienic conditions cleaning and maintenance 52 Warning Before proceeding with any cleaning and maintenance operation make sure that the power line of the unit is disconnected and water line is closed 53 The following should be undertaken monthly Wipe clean the ice storage bin liner using a mild detergent solution diluted in lukewarm water Rinse it and then thoroughly disinfect its surfaces wiping them with a liquid algaecide For the cleaning of the exterior cabinet use a soft cloth with a mild detergent solution specific for Stainless Steel 54 Cleaning of Water Circuit The water system should be cleaned at least twice per year and this should be undertaken by your authorised service agent A recommended brand of Ice Machine cleaner should be used to remove any mineral deposits and scale build up failure analysis What to do before calling a service agent If the machine does not work All warning lights are off Is the hand disconnect switch in ON position Blown fuses at fuse box Electric plug not fitted correctly Ice making capacity reduced or inefficient Is the water shut off valve open Is water and ambient temperature too high Are there heating sources close to the machine or is there poor ventilation If the flake ice is not correct too wet Is the ice jamming in
6. nt batches will be good quality unit description 3 The units described in this manual are self contained flake ice makers namely with a built in ice storage bin These flakers use the famous ice making system with vertical freezing cylinder In the storage bin a light sensor combination controls the collected ice level When the light sensor stops unit operation a 23 For moving the o max 40 C Minimum water Aa e sear kat in temperature is not lower aae Tho than 5 C and min5 C 2 maximum water temperature does not exceed 40 C The level can be corrected by means of the levelling feet 24 Minimum water pressure is not below 1 For the unpacking of the unit observe the pictorial view corresponding warning light located on the bar and eee 32 machine front monitor panel will glow water pressure does max 5 bar l aaa i Lv Make the connection to The five warning lights are nothing more than not exceed 5 bar minibar fig the water supply using the five LED which are integrated in the PC ar mie hoses supplied with the Board of the ice maker machine The PC Board governs the flake ice making 7 process and protect the mechanisms against Ly l some common adverses conditions and situations h E wat EE Make sure that the ice therefore the outstanding feature of these machinesis TPE a ut o t a ve boa e within han scoop and leg package the advanced micropro
7. r Connect the power lead to a The unit is equipped with a The illustrations shown in this manual are generic switch must be within tra NSPO rt Attention suitable electrical supply 3 minute time delay and can differ in some details from the delivered hand reach of the Make sure that water machine installed machine 15 available is connected NOTE The sound level of the unit in operation should to a cold drinking be lower than 70bd A water supply If in doubt consult the installer for the possible installation of a water Any illustration schematic or documents supplied with the machine belong to the manufacturer who reserve copyright and expressly forbids any reproduction of them without written permission As transport protection the ice maker is packed in a heavy cardboard crate 38 The Manufacturer s policy is one of continuous 8 filter or water P N 1 improvement and reserves the right to make Oon ond aner 30 E AN at ss are ade changes at any time without prior notice or ee an l Chek Machine iael A hy a Toner ie ae incurring any obligation whatsoever o not remove any To gain full advantage from this unit in terms of inspectio ates panel secured performance and durability also make sure that interior with screws The first pieces of flake ice 16 cad p will drop into the storage bin within approximately 3 minutes from start up The first batch of ice will be of poor quality but subseque
8. the machine ba connection with machine and the environment is 35 2 14 shut off valve a too cen o ae Warning Please ensure there Is a pen water snut o Please note the Disconnect the electrical power before beginning ifakeenethat ine o r of etal valve following guidelines any maintenance or cleaning operation cabinet PE E rom walls to alow enough air eThat the packing does circulation mains electrical supply complete with an earth connection 6 Make sure your hands are properly wiped dry not show any sign of damage eThat the unit corresponds to what is Waste drain water how the installation connection specified on the INFORMATION FOR THE CORRECT USE OF THE IS made purchase order MACHINE eThat the machine is The Icemaker must be connected to a POTABLE Important not damaged externally and no parts are missing eThat during transport certain integral parts have not been damaged WATER SUPPLY Ice Storage Bin is for the storage of ice only DO NOT store chill cans or bottles The manufacturer cannot be held responsible for improper use of the machine as specified The machine installation has to be performed by Authorised Service Personnel 37 Switch the main switch to In case of severe damage or parts missing report 7 29 the ON position At this immediately to the delivering carrier and your a on this User Manual stage the unit will start up distributor The electrical isolato
Download Pdf Manuals
Related Search