Little Buddy
Contents
1. Only be used in a well ventilated area Can produce carbon monoxide which has no odor Using it in an enclosed space e g caravan tent car mobile home may cause death Gas Safety Certified AS 2658 2008 Cert GSCS20192 SAI Global p PRIMUS PRIMUS CUSTOMER SERVICE 1300 555 197 PT ei enquiries primusaustralia com au Bundoora Victoria 3083 www primusaustralia com au2. COVER Step 3 e Depress ON button to light pilot flame repeat until pilot lights and continue to hold for 30 60 seconds e After lighting pilot release ON button to light heater Shut Down Instructions Pa To shut off heater press the OFF button CAUTION After turning heater off wire guard will remain hot Allow to thoroughly cool before storing Do not operate store or remove cylinder near flammable items or ignition sources CYLINDERS MUST BE DISCONNECTED FROM HEATER WHEN NOT IN USE i N Ke N Maintenance Appliance is only to be serviced or repaired by an authorised service centre Return appliance to place of purchase or contact Primus Customer Service contact details on back cover Pilot Flame Always keep the heater area clear and free from combustible materials gasoline and other flammable vapors and liquids Keep the vent areas slots in the bottom and the top at the front and rear of heater clear at all times Oxygen Depletion Sensor Visually inspect the pilot flame and burner Il l periodically during use The pilot flame should be blue in color not yellow and will extend beyond the thermocouple The flame will surround the thermocouple just below the tip A slight yellow flame may occur where the pilot flame and main burner flame meet The burner should be bright orange with a slight blue color around the border a red orange h
3. an above ground open air situation with natural ventilation without stagnant areas where gas leakage and products of combustion are rapidly dispersed by wind and natural convection CARBON MONOXIDE HAZARD THIS APPLIANCE CAN PRODUCE CARBON MONOXIDE WHICH HAS NO ODOUR USING IT INAN ENCLOSED SPACE FOR EXAMPLE CARAVAN TENT CAR MOBILE HOME MAY CAUSE DEATH HIS APPLIANCE IS ONLY TO BE USED ON SOLID AND STABLE HORIZONTAL SURFACES N Safety after installation Caution The purpose of this section is to direct your attention to the possibility of accidents that can be avoided e This appliance is not to be used in enclosed areas and must be operated away from any type of flammable material or liquid e This appliance must be operated a minimum of 100mm from all solid or non combustible surfaces e During the operation of this appliance all air openings and vents must be kept free from obstructions to ensure correct operation e Remember the appliance produces heat therefore some parts will get hot Allow to cool before touching e Do not leave children unattended near the appliance when in use e Do not store or use petrol or other flammable liquids in the vicinity of this or any other appliance e Do not modify this appliance e Do not use adaptors e Do not allow clothing to pass over or lay on the appliance e Protect the appliance from wind and drafts when in use e Do not operate appli
4. F GAS CONTAINERS 3 Never leave heater unattended when in use CAUTION accessible parts may be very hot Keep young children away 4 Always use oven mitts oven gloves when handling the heater after use Installation operation and maintenance instructions Safety information if you smell gas e If there is a leak on your appliance smell of gas immediately attempt to turn off e Remove the appliance to a well ventilated location away from any ignition source e Only check for leaks outdoors using soapy water e Do not try to detect leaks using a flame e When leak has stopped ventilate and disperse gas from the area before continuing IMPORTANT read this instruction for use carefully Familiarise yourself with the appliance before connecting it to the gas bottle This appliance is for use with disposable propane cartridges only e Do not remove regulator connect to high pressure canister or use adaptors e When changing gas cartridge ensure that it is undertaken in a well ventilated area preferably outside and away from sources of ignition such as naked flames pilot flames electrical and heating equipment and people e To check if cartridge has sufficient gas pick up cartridge and shake from side to side If there is movement or the sounds of liquid moving inside the cartridge then it will contain gas FOR OUTDOORS USE ONLY ONLY USE IN WELL VENTILATED AREAS This appliance shall only be used in
5. Mic Heater by PRIMUS Little Buddy COMPACT PROPANE HEATER Part No MH4B User Manual and Product Specifications IMPORTANT Read these instructions for use carefully Familiarise yourself with the appliance before connecting it to its gas container Keep these instructions for future reference DO NOT Operate this appliance before reading the instruction booklet DO NOT Place articles on or against this appliance DO NOT Store chemicals flammable materials or spray aerosols near this appliance DO NOT Operate with panels covers or guards removed from this appliance DO NOT Operate in an enclosed area without ventilation DO NOT Operate in a boat caravan or tent Image for representation purposes only and may differ from actual product Safety Instructions 77 Important 1 Please read all instructions carefully 2 Dispose of all polythene packaging carefully and keep out of the hands of young children Safety warning Please read all safety warning and assembly instructions before use Retain all information for future reference Failure to follow the instructions may cause personal injury and or damage 1 Never use in unventilated or enclosed areas This heater consumes air and could endanger life if used in unventilated or enclosed areas 2 Onlynon refillable 468g disposable cylinders are to be used with this appliance CAUTION IT MAYBE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES O
6. ance below ground level or in areas where unburned gas could build up e Do not move appliance while operating e Clean after use e Do not use this appliance if it is leaking damaged or does not work properly e Do not use this appliance if it has damaged or worn seals e This appliance must only be serviced by an authorised person e Store the gas cartridge outdoors in a well ventilated area or in a storage area compliant with AS1596 NEVER assemble or operate the unit on unstable or uneven ground Always operate in open and well ventilated areas NEVER operate inside a tent caravan camper trailer vehicle or boat NEVER leave the unit unattended whilst operating NEVER open the control panel or disassemble unit This appliance is not intended for use by young children or infirm person unless they have been adequately supervised by a responsible person to ensure that they can use the appliance safely Young children should be supervised to ensure that they do not play with the appliance This appliance is to be installed as per local regulation and in accordance with AS5601 AG601 Product Identification 1 ON button 2 OFF button 3 Burner tile 4 Propane cartridge 5 Support strap Safety Instructions ka This appliance shall only be used in an above ground open air situation with natural ventilation without stagnant areas where gas leakage and products of combustion are rapidly dis
7. aze that is visible on the ceramic tile is acceptable and without a noticeable flame A blue flame that rolls out at the top of the ceramic tile indicates an accumulation of dust lint or spider webs inside the casing assembly and main burner assembly If the pilot is yellow or the burner has a noticeable flame cleaning may be required Use the following procedure to inspect the casing assembly and main burner assembly Replacement Parts List Pa LO Ga N EI ig ia No Part Description No Part Description 15161 Regulator Valve Assembly 5158 Reflector Ring 15151 Orifice 5162 Wire Guard Off Button Wire 5138 Burner Assembly 15126 Left Housing 5155 ODS Pilot Assembly 15128 Right Service Housing 5153 Burner Bracket 15122 On Button 5145 Off Switch 3 5 5 jari PUNI E ol Q as Off Button 403 Tipover Switch 15165 Off Button Spring 48 Pilot Fuel Line 15124 Tank Base 54 Heat Shield Reflector Panel z OCOANDA AONI OONDYN oOo N w as a a N Troubleshooting Instructions Problem Remedy Check spark electrode if defective replace ODS Oxygen Depletion Sensor Check igniter wire is correctly attached to spark If spark electrode does not produce electrode spark Check igniter wire if damaged replace Check piezo igniter if defective replace control valve No gas to heater install disposable c
8. persed by wind and natural convection Any enclosure in which the appliance is used shall comply with one of the following A An enclosure with walls on all sides but with no overhead cover B Within a partial enclosure that includes an overhead cover and no more than two walls C Within a partial enclosure that includes an overhead cover and more than two walls the following shall apply 1 At least 25 of the total wall area is completely open 2 30 or more in total of the remaining wall side back and front wall areas is open and unrestricted 3 In the case of balconies 20 or more of the total wall area shall remain open and unrestricted Lighting and Operating Instructions Step 1 WARNING Always inspect propane cylinder and heater propane connections for damage dirt and debris before attaching propane cylinder Do not use if head of cylinder is damaged punctured or deteriorated IMPORTANT e Fit disposable cartridge into plastic base and position elastic straps over the threaded outlet on top of cartridge e Screw disposable propane supply cylinder ONE Step 2 eZ clockwise from bottom into portable heater until hand tight and fit cylinder into stand e Check cylinder connection for leaks with soapy water at the threaded connection under the domed plastic cover where the cylinder screws into the regulator SEE WARNING ON PLASTIC
9. ylinder or connect hose and filter where required and turn on If spark electrode produces spark but valve at remote cylinder pilot does not light Check is pilot is blocked from spider web or dirt clean pilot see MAINTENANCE Pilot Ignition button not held long enough to purge air from line Retry If pilot flame is not surrounding thermocouple clean If pilot flame does not stay lit when button pilot see MAINTENANCE is released Check if pilot assembly is defective replace Check if tip switch wires are disconnected connect Check off switch and off switch wiring Check if main burner orifice is blocked clean burner see MAINTENANCE Check if pilot is blocked clean pilot see If heater keeps shutting OFF during MAINTENANCE If main burner does not ignite normal operation Tip over switch may have been activated from bumping heater Re light Specifications Part No MH4B Dimensions 432 x 254 x 210mm including cylinder Net Weig ht 2 16kg excluding cylinder Injector Size 0 65mm Gas Consumption 4 5 Mj hr 79 7 g hr Appliance This Must only be serviced by an authorised person Suitable for camping use only Shall NOT be exposed to moisture or rain Shall only be used with a propane gas cartridge certified to DOT2P UN2037 EN417 May be hazardous to attempt to fit other types of gas containers
Download Pdf Manuals
Related Search