User Manual - Mobility Elevator & Lift Co.
Contents
1. Verify general components Rollers Fluid level Oil leaks Battery fluid level optional system 8 0 Diagnosis Telecab goes up but does not come down Verify the underpan sensor Pull down on it to ensure the pan is not stuck in the activated position Telecab goes down but does not go up Verify the power supply breaker cord battery etc Verify the floor plug switches Lift the floor plug to ensure it is not stuck in the activated position Telecab does not move Verify if the key is on Verify if the door is closed Verify if the emergency stop is pushed in It should be pulled out If the cab is at the bottom landing verify the floor plug switches as explained above If the cab is at the top landing verify the underpan sensor as explained above 30 MONTH LIMITED WARRANTY SERVICES INDUSTRIELS SAVARIA INC warrants to the original consumer purchaser of this Savaria lift that the company will repair or exchange at its option any part of the lift that fails by reason of defective material or workmanship as follows gt Repair or replace parts for a period of 30 months from date of lift purchase This warranty does not cover labour charges incurred in the removal repair or replacement of parts To obtain warranty service you must promptly notify the Savaria dealer from whom the lift was purchased within the warranty period This Warranty does not cover Batteries and mal2. pull on the steel cable located in the manual lowering box the cab comes down This mechanism should be used in case of emergency only MANUAL LOWERING BOX STEEL CABLE 6 2 12V DC PUMP A key switch allowing to lower the platform manually is located on the side of the Telecab Insert the key the same one than for the call send control and turn it in the operating position to lower the platform This mechanism should be used in case of emergency only 7 0 MAINTENANCE EVERY TWO MONTHS Verify general operation of the telecab Verify the operation of the safety devices Underpan safety switches Floor plug safety switches Door contact Door lock Emergency stop The lift should never run when those devices are activated or the door is not closed These verifications can be made by the owner EVERY SIX MONTHS Emergency lowering system Safety brake see Complementary reference of installation manual for procedure Verify safety components Chains Chain connecting links Chain pulleys and shafts Parts holding the chains on the rollers supports Chain tensionners on the rail ensure they are tight Cylinder head cotter pins cracks welds Hydraulic system leaks Verify every fastening device for looseness Up relays verify that any of the two up relays are not stuck in the activated position Use a multimeter to verify that every N O contact is open when the relays are not activated
3. SERVICES INDUSTRIELS pasan SAVARIA INC SUE TELECAB OWNER S MANUAL 07 2003 4 OPERATION OF THE TELECAB 1 0 OPERATING THE TELECAB Insert the key and turn it in the operating position on any call send control FIGURE 1 0 The key is in the operating position when it can not be pulled out Always take the key out when the unit is not in operation Apply constant pressure on the appropriate button to move the Telecab in the desired direction The Telecab will not move if the door is open or if an object activates the underpan sensor or the floor plug sensor FIGURE 1 0 UP BUTTON l KEY SWITCH 0 DOWN BUTTON 2 0 OPENING THE DOOR The door will unlock automatically for a few seconds when the cab reaches the landing You need to put a little pressure on the door in the closing direction in order to release the latch mechanism If you need to reopen the door after the delay is over turn the key on and depress the call button once again bottom one if you want to open the door at the bottom landing and top one if you want to open the door at the top landing This will unlock the door once again FIGURE 2 0 3 0 4 0 KEY SWITCH DOWN BUTTON UP BUTTON EMERGENCY STOP ALARM LIGHT CAB CONTROLS Key switch Up button Down button Emergency stop Alarm button Light switch SAFETY DEVICES See figure 3 0 Underpan sensor Floor plug sensor Door switch Needs to be on to activate the operati
4. function or damage to lift parts caused by accident misuse abuse or lack of proper maintenance neglect improper adjustment modification alteration the structural condition of your building overloading failure to follow the lift operating instructions or acts of God i e weather lightning flood etc This warranty is void if gt Lift has been installed or maintained by someone other than an authorized Savaria dealer Lift has been modified or altered in any respect from its original design without written authorization by Services Industriels Savaria Inc The user does not join a preventive maintenance program offered by an authorized Savaria dealer and does not have the lift inspected at least once every 6 months or more freguent as use or environment dictates
5. ng buttons Will move the Telecab in the up direction Will move the Telecab in the down direction Will stop the machine instantly Overrides the call stations The alarm will go on Will activate the alarm Will turn on the light Located under the Telecab it will stop it if something is hit during the down travel Located between the floor plug and the top of the cab it will stop the machine if there is something unusual standing on the floor plug example person Will prevent the cab from moving with the door opened FIGURE 3 0 5 0 5 1 5 2 5 3 FLOOR PLUG UNDERPAN SENSOR EMERGENCY DOOR OPENING The door can be opened manually by using a 1 4 inch allen key Insert the key in the hole on the door and turn it See figure 4 0 There are two allen keys provided with the Telecab One of them should always be kept inside the cab and the other one should be kept in a safe place in the house This key should be used in case of emergency only Never leave the key in the exterior hole while moving the cab because it will catch in the floor opening and damage the cab The user should learn to open the door both from inside and outside in order to be ready in case of emergency FIGURE 4 0 MS MOLES FOR EXTERIOR INTERIOR EMERGENCY DOOR OPENING 6 0 REMOTE EMERGENCY MANUAL LOWERING DEVICE 6 1 FIGURE 5 0 120V AC PUMP The manual lowering box is located on the side of the Telecab When you
Download Pdf Manuals
Related Search