Active Passive Pro User Manual AP-Pro AP-LBE AP-UBE
Contents
1. elle s SupplY eel Difere Active Passive Pro User Manual AP Pro AP LBE AP UBE Physiotherapy Apparatus for Upper and Lower Limbs Wellness Supply Group LLC WELLNESS 1685 Woodland Avenue Columbus OH 43219 h 3 Tel 800 653 8037 Supply Group Fax 614 474 1483 E mail info wellnessSG com www wellnessSG com 1 of 18 Wellness Supply Group V007 Table of Contents 1 2 10 11 12 2 of 18 Important Safety Information Intended Use Product Introduction i Product and Model ii Intended Use iii Introduction iv Product Features v Specifications Name of Components amp Installation i Name of Components ii Installation ii Instructions for Using MIONO S RM 1 emo Spasm Control HOW dO S o _ _ __ _ 665 i Upper Limbs Exercise ii Lower Limbs Exercise Exercise Mode Set up i P Mode Passive Mode li Program Setting Mode iii A Mode Active Mode iv TV Mode v Exercise Results Maintenance vvavavavavavevevevuveueueuuenenens i General Items i Preventive Maintenance otorage and Moving Product Warranty Breakdown and Diagnosis Product Identification Wellness Supply Group 007 1 Important Safety Information Please read this manual carefully from beginning to end before using the equipment for the first time T2. Earphone Jack Use to return to initial screen after action 5 Spasm Control If spasm occurs during exercise the device will pause and change direction See Set up Page 10 to control and relieve spasm A patient who has symptoms of spontaneous muscle spasm while using the unit may cause damage to muscles if the spasm is not controlled as well as not being able to realize the desired training effect Spasm Control Sequence 1 Spasm Control acts only in Passive Mode 2 Start exercise after choosing Spam Control in Passive Mode See Set up Page 10 3 If spasm occurs while patient exercises the number of spasm occurrences is registered on the screen 4 If spasm occurs unit rotates in desired direction See Set up Page 10 after pausing approximately 3 seconds 5 If the Spasm Control is initiated three 3 times during a single exercise session the unit will end the exercise session and report System Stopped 6 If session is ended by the Spasm Control function turn off main power switch to reset Turn on again after waiting at least 30 seconds CAUTION Patients with predisposition to the occurrence of spasm phenomenon should be supervised throughout exercise 8 of 18 Wellness Supply Group V007 6 i pe 9 O gt oe 9 of 18 How to Use CAUTION 2 Confirm that the power cable is properly connected prior to each use 3 When using this unit device for exercise p
3. HEX THESE PRODUCTS ARE MEDICAL DEVICES ALWAYS KEEP THIS USER MANUAL NEARBY THE PRODUCT USER MUST READ AND FOLLOW THE INSTRUCTIONS LISTED BELOW 4 of 18 Wellness Supply Group V007 i ii iii Soo UI Pe NS 5 of 18 Intended Use Product Information Product and Model Product Physiotherapy Apparatus for Upper and Lower Limbs Model AP Pro SP 1000 AP LBE SP 2000 and AP UBE SP 3000 Intended Use Reconstruction of the muscles and joints and facilitation of motion for enhanced user recovery Introduction Motor driven rehabilitation exerciser for elderly persons wheelchair users apoplexy paralytic and remedial exercise This product is developed for exercise therapy Rehabilitation is accomplished by providing motorized passive assistance and active resistance when appropriate Product Features Speed resistance time direction of rotation display on screen Spasm control Speed and resistance can be adjusted to fit the user s functional capacity Forward and reverse movement of both upper and lower body pedals Users can specify the desired amount of exercise time Biofeedback with the movement Touch screen monitor Displays exercise amount by at active exercise lower pedals limbs only Easy to use adjustable pedal positions Specification Product Size AP Pro L x W x H 59 x 71 x 108cm 23 x 28 x A9 AP LBE L x W x H 59 x 63 108cm 23 x 25 x
4. adjusted when the motor is running 3 Never reach into or attempt to take hold of moving parts of the exerciser when it is running 4 Never use the exerciser with a damaged power cord Use only the original power cord supplied with the exerciser 5 Use the rated voltage 6 To prevent electric shock never use in wet damp or very hot conditions T If the exerciser is damaged faulty or if it produces abnormal noises or smells stop the exercising session immediately unplug the power cord and contact your service engineer 8 To avoid risk of insufficient suppression of electrical disturbance this equipment must be used in a protective area ao EE E a od 3 of 18 Wellness Supply Group V007 lem parse Stet Ma ZD DEA UD Imi P puin dum arl rra dem an ben ns arpa ts 1 bees Deep ii bei te T Eey fe Tic Cus a LE T E Dx k pees bia Pid ieee Appar al es PI V 30 Pare 23 2 Tipe pard tive dem bens rd wu birra ti ov laaphaap bo iig Coo THE 3 1 C LTE uH CE MC TIT 1 4 hine D 0 6 2390 WEE Tre pertes iiie deed ard So Ai had baig b Tri TOE 3 XEC DN CR LT UDE 15
5. recommendations Manufacturer assumes no responsibility for any alterations or repairs 15 of 18 Wellness Supply Group V007 i General Items 1 Inspect regularly for any damage and normal operation to use the device safely Replace worn or damaged parts particularly high wear parts discovered through routine inspection 3 When checking or replacing consumable parts be sure to turn off main power switch and remove power cord from the power outlet 4 Repair and readjustment of product must be done by certified technician or manufacturing company ii Preventive Maintenance a Daily Inspection Items 1 Always shut off power before checking Please polish monitor and outside of unit Use soft cotton material Do not use abrasive cleaners Do not use cleaners that contain ammonia or acids 3 Inspect and remove any foreign substances in and around turning parts knobs pedal bearings etc Inspect cleanliness of foot pedals and handles Inspect power plug and all cables for visible damage Maintain a clean environment around the exercise device b Weekly Inspection Items 1 Check monitor Check pedals and handles for proper tightness and eliminate any unusual play c Main Component Routine Inspection Schedule Power plug cord Monitor Frame Pedals Turning knobs Fixed knobs Inspect C Clean d Prohibited Random Alteration and Reconstruction 1 Product cannot be altered outside of ma
6. set direction of rotation Pressing the button again changes direction SNS CARE ge Select arm training or leg training Both exercise regions CANNOT be selected at the same time The circle next to the selected region button will light up SNS CARE Select SPEED button Set desired speed by pressing or button 4 60 rpm SNS CARE oelect DURATION button Set desired time by pressing or button 1 99 min SNS CARE Select SPASTIC AUTOMATION button to set spasm control function circle will light up SNS CARE A amp Press START button on control panel and begin exercise Wellness Supply Group V007 When the exercise session ends 10 Press MENU button on control panel to exercise results will be displayed on return to initial screen monitor SNS CARE PEDAL MENU Duration wens Distance a Activity Left amp Right Rate ii S Program Setting Mode Allows the user or therapist to define the parameters of an individual exercise program time spasm settings and setting suitable sensitivity control systems according to the patient s state a Function Spasm Sensitivity It consists of 3 steps of Fine Medium and Rough Sensitivity is set according to patient s spasm degree During exercise the spasm control function acts according to set sensitivity Spasm Control Select direction of rotation after spasm control according to exercise dire
7. A3 AP UBE L x W x H 59 x 71 x 108cm 23 x 28 x A3 Product Weight AP Pro 50kg 110 AP LBE 40kg 88 AP UBE 53kg 117 Rated Voltage 110V 60Hz Condition for operation 10 C sts 40 3096 rH lt 75 7OkPa lt p lt 106kPa Condition for transport and storage 40 C lt t lt 70 C 1096s rH lt 100 5OkPa s p lt 106kPa 1 year limited warranty Circuit diagrams component part lists descriptions calibration instructions or other information available upon request Wellness Supply Group V007 3 Name of Components amp Installation i Name of Components AP Pro uses upper limbs or lower limbs AP LBE uses only lower limbs O I OF ox 9 10 Handlebar Exercising handles Control pad inclination adjuster of handlebar upper body exerciser Locking screw with knurled knob for adjusting height Power switch Footrest Transport wheels Exercise stand Transmission casing Calf support 11 Monitor AP UBE uses only upper limbs 6 of 18 Wellness Supply Group V007 ii Installation WARNING 1 Take care to minimize impact when moving this product 2 Never use the exerciser with a damaged power cord 3 This product should be connected to a properly grounded socket 4 To prevent electrical shock this product must never be used in moist or humid environments 5 To avoid risk of electrical shock this equipment must only be connected to a supply mains and
8. Left amp RightRate Left 48 confirm exercise settings Setting of resistance speed and time while exercising is the same with Passive Mode set up See Set up Page 10 Press MENU button on control panel to return to initial screen 13 of 18 Wellness Supply Group V007 iii A Mode Active Mode Mode for exercise using patient s force Helps increase muscular power by providing resistance against activity a Function Resistance turning load amount during exercise 2 Balance Biofeedback During exercise displays force that is imposed by left and right by 9o lower limbs exercise only b Howto Set Select P Mode in initial screen on In next screen set desired resistance by monitor pressing or button Then select A Mode 3 Press START button on control panel Monitor screen displays present speed Start exercise by patient s force exercise time resistance and left right balance for lower limbs only during exercise Duration 02 03 5 Press STOP button to end exercise 6 Press MENU button on control panel to session Exercise results will be return to initial screen displayed on monitor Rl Duration Spastic Distance Activity Left amp Right Rate __ 48 Right 52 14 of 18 Wellness Supply Group V007 ivy TV Mode A function that allows the user to watch TV while exercising in either P or A Mode TV cable or DVD player must be connected H
9. atient must always maintain a straight upright position 4 Patient must use the device with a chair or wheelchair in the proper comfortable position Improper positioning can cause discomfort in the knee hip elbow or shoulder Upper Limbs Exercise Twist the two horizontal knobs counter clockwise and rotate the upper body exercise handles into the proper position for upper body exercise Twist knobs clockwise to lock into position Use the device while sitting in chair or wheelchair Adjust height using the height control knob on vertical mast to a proper exercise position Do NOT let the mast descend uncontrolled into the lowest position lower with care Twist knob clockwise until fully tightened to maintain selected vertical height Do not use the device while standing Ensure that chair or wheelchair is stable and locked and does not move Turn on main switch Begin exercise after completing set up See Set up Page 10 Lower Limbs Exercise Twist the two horizontal knobs counter clockwise and rotate the upper body exercise handles away from the display and user Twist knobs clockwise to lock into position Control height using height control knob Turn on main switch Use device while sitting on chair or wheelchair Ensure that chair or wheelchair is stable and locked and does not move Control pedal position by selecting PEDAL positioning button User s foot can be easily put into pedal Fix foot on pedal of d
10. cal shock Class Protection against harmful ingress of water Ordinary IP20 Methods of sterilization Not applicable Stability of use in an Oxygen Rich Environment Not suitable for use in an Oxygen Rich Environment Mode of operation Continuous operation Serial number Marked separately Date of manufacture Marked separately Packing unit One 1 unit Manufacturer Sungdo MC Co Ltd OLLI IS IS N QOO 18 of 18 Wellness Supply Group V007
11. ction After spasm control regardless of present direction it rotates unconditionally only to forward direction After spasm control regardless of present direction it rotates unconditionally only to backward direction 1 After spasm control it rotates to opposite direction of present direction Motor Power Used to maintain the amount of power torque to correspond to the strength of the upper or lower limbs It consists of 3 steps of Fine Medium and Rough Exercise Time Set exercise time Control from 1 to 99 minutes initial setting 15 min b Howto Set Select S Program in initial screen on 2 Set desired exercise time in next screen monitor by pressing or button Max 99 min SNS CARE Settings 7 dar l Ol amooo 12 of 18 Wellness Supply Group V007 3 Select SPASM DETECTOR button Set desired sensitivity by pressing Fine Medium or Rough 5 Select MOTOR POWER button Set desired power by pressing Fine Medium or Rough 4 Select SPASTIC AUTO button Set desired direction by pressing forward backward or reverse direction arrow 6 Press MENU button on control panel to store settings Pressing P will also store settings 7 Press START button on control panel and 8 Press P button on monitor screen to begin exercise 9 When the exercise session ends exercise results will be displayed on monitor D ARR Duration Spastic Distance Activity a d
12. evice utilizing the Velcro pedal straps Begin exercise after completing set up See Set up Page 10 CAUTION 1 Close supervision is necessary when used by with or near children invalids or physically challenge persons 2 Confirm that all adjustment knobs and straps are tightened prior to starting exercise Wellness Supply Group V007 T Exercise Mode Set up i PMode Passive Mode 1 Mode which uses force of unit to provide joint movement and muscle rehabilitation exercise for patients who do not move naturally because of arm or leg disability 2 During P Mode exercise if user increases the speed through active assistance pedaling faster than set rpm the device will transition to Active Mode A Mode If user decreases speed to below the set rpm the device transitions back to P Mode a Function Resistance Set resistance value in case exercise is converted from P Mode to A Mode e Available to set from 1 to 15 levels initial setting level 1 Increase decrease 1 level by pressing button once Increase to maximum value or reduce to smallest value by pressing continuously Touch the number for a keypad for direct input Resistance setting can be changed during exercise Set resistance is applied to all speeds Resistance value is applied when exercise is changed to A Mode without being applied in P Mode Speed e Available to set from 4 to 60 rpm initial setting 4 rpm Increa
13. his exercise equipment is designed and built for optimum safety However certain precautions are applied whenever you operate a set of exercise equipment Make sure to read the entire manual before assembling and operating this machine Also please note the following safety precautions The symbols used in this instruction manual and on the exerciser are intended to point out potential dangers when using the exerciser WARNING If you do not follow these precautions it may cause death or serious injury CAUTION If you do not follow these precautions it may cause serious injury wagNING Potential shock hazard Do not modify this equipment without authorization of the manufacturer Intended for supervised use only Patients must not use without being supervised by an assistant Leave standing at least one hour at room temperature after transporting or before first use Always place on a level and non slip surface so as to ensure maximum stability Always wear snug fitting clothing when using the exerciser Designed to be used in a sitting position only Operate the equipment correctly in order to utilize the most functions of the equipment 0 Close supervision is necessary when used by with or near children invalids or physically challenged persons AN CAUTION 1 If using a wheelchair with the exerciser please engage the wheelchair s brake and secure its stability before exercising 2 hecrank length must not be
14. nufacturer s original product specifications Product alterations or changes are not warranted so that all the losses that might occur are not compensated 3 product warranty shall not apply if there is any modification to the product or accessories or if there is a failure to provide maintenance as outlined in the manual 16 of 18 Wellness Supply Group V007 4 The product warranty does not cover damage or equipment failure resulting from misuse abuse or failure to comply with electrical codes 5 he buyer s remedy for breach of the expressed warranties contained herein shall be limited to the return of the product and accessories and repayment of the original purchase price Provided however at manufacturer selection it may repair and replace the non conforming goods or parts 6 Manufacturer shall not be liable for any incidental or consequential damages Note The owner of the product is responsible for proper disposal of used or discarded product in compliance with all applicable federal state and local waste disposal laws and regulations 9 Storage and Moving i Storage Method Keep product in clean dry environment Keep product in sealed packing to eliminate dirt dust and moisture Keep separate power supply cord detached while in storage rc ii Moving Method Move product using transfer wheels Requires more than 2 persons to transfer product over steps or up stairs Do not transfer device with power sup
15. ow to Watch 1 lnitiate TV Mode after beginning exercise session 2 Select TV button during exercise 3 Channel selection window and exercise information are displayed on screen 4 Touching the screen with hand causes channel selection window and exercise information to disappear from screen 5 Touching the screen causes the exercise information and channel selection window to reappear 6 Change channel by pressing channel button on screen Control volume by VOL buttons of control panel 7 Touch program or exercise mode to change display to program window and exercise mode window 8 Press TV icon to return to TV Mode v Exercise Results 1 Exercise Time minutes seconds e Displays total exercise time 2 Exercise Distance km Duration e Displays total exercise distance Distance 3 Spasm number of times e Displays number of spasm control Activity episodes during exercise session Left amp Right Rate 4 Active Exercise Ratio 96 e Displays total active exercise amount 5 Active Exercise left 9o for lower limb exercise only e Displays active exercise grade of left side 6 Active Exercise right for lower limb exercise only e Displays active exercise grade of right side 8 Maintenance WARNING 1 When initiating repair process turn off main power switch User may suffer injury from malfunction of the product 2 Do not repair the device outside of manufacturers
16. ply cord attached Transfer after tightening all adjustment knobs DS pcs 10 Product Warranty 1 1 year limited warranty Product warranty does not cover damage or equipment failure resulting from mis use abuse or external impact 3 Product warranty will not apply if there is any modification to the product outside the manufacturers recommendations 11 Breakdown and Diagnosis No power Be sure power cord is properly EN correctly in outlet and connected main body connector Pedal not positioned properly Press PEDAL position control Turn power off and on again to button reset If there is no change request factory assistance Spasm Control function does Confirm exercise is in Passive Choose ROUGH spasm not work Mode Make sure Spasm control setting in Passive Control is selected Mode Upper limb cranks do not Make sure arm exercise is Choose arm exercise in rotate selected Passive Mode 17 of 18 Wellness Supply Group V007 Lower limb cranks do not Make sure leg exercise is Choose leg exercise in rotate selected Passive Mode TV does not turn on Be sure cable wire is Insert cable into the connected connection on frame If you are still experiencing problems please contact your dealer or authorized service center 12 Product Identification Name of item Physiotherapy Apparatus for Upper and Lower Limbs Type AP Pro SP 1000 AP LBE SP 2000 and AP UBE SP 3000 Protection against electri
17. properly grounded 1 This product should be placed on a horizontally flat floor in accordance with safety and cautions in use Please keep a minimum of 15 inches side distance between this product and other things The power has to connect to a properly grounded power outlet Turn on the main switch 0 T9 iii Instructions for Using 1 This product is intended for supervised use only Therefore patients must not use without being supervised by an assistant 2 Do not use for any other purpose 3 Begin exercise sessions slowly and then increase the level of intensity gradually according to the user s physical capabilities 4 Leave standing at least one hour at room temperature after transporting or before first use 5 Children must be constantly supervised when exercising on this product 6 Never reach into or attempt to take hold of moving parts of the exerciser e g cranks crank length adjuster footrests etc when it is running 7 Donotdisassemble during use or while plugged in 8 If this product is damaged please contact your dealer or authorized service center 4 Monitor Please see the table below for the control pad functions e passivity Passive Mode _ Settings Setting Mode otop Button Active Mode E TV Mode _ Start Button 7 of 18 Wellness Supply Group V007 Pedal Position Control Button Volume Button Pedal and turning knob are oet volume in TV Mode positioned Menu Button
18. se decrease 2 steps by pressing button once Increase to maximum value or reduce to smallest value by pressing continuously Touch the number for a keypad for direct input Speed setting can be changed during exercise Time Available to set from 1 to 99 minutes initial setting 15 min Increase decrease 1 minute by pressing button once Increase to maximum value or reduce to smallest value by pressing continuously Touch the number for a keypad for direct input Time setting can be changed during exercise Direction of Rotation Set direction of rotation of arm and leg exercise Press icon until the desired direction arrow mark lights up Available to select Forward direction or Backward direction Direction can be changed during exercise Spasm Control Set Spasm Control availability in case spasm happens while patient exercises See Spasm Control Set up Page 8 Spasm Control setting CANNOT be changed during exercise Arm and Leg Exercise Select and set exercise region Upper limb and lower limb exercise CANNOT be accomplished at the same time Exercise region upper limb or lower limb CANNOT be changed during exercise 10 of 18 Wellness Supply Group V007 11 of 18 How to Set Select P exercise mode in initial screen on monitor oelect POWER button Set desired resistance value by pressing or button Level 1 15 SNS CARE 2 Select FORW BACKW button to
Download Pdf Manuals
Related Search