2 Pack Seed Tender User`s Manual - Par
Contents
1. es Par Kan C O M P A N Y 2 Pack Seed Tender User s Manual Par Kan Company Phone 1 800 291 5487 2915 West 900 South Phone 260 352 2141 Silver Lake IN 46982 Fax 260 352 0701 Contact Sales Department E mail GWSales par kan com Website www par kan com Important Read User s Manual Completely Prior to Operating Towing or Servicing Tender Par Kan C O M P AN Y 2 Pack Seed Tender CUSTOMER SERIAL V I N P r Kan C O M P A N Y 2 Pack Manual Table of Contents PAE Da ee Product Information PE A ES EEN SEERE Table of Contents FP Warranty PAGE 5 NE kom a Cart Dimensions PAGE 6 MEP ENNE PE EMME PE E E General Specifications amp Features PAGE REE Safety amp Operating Precautions Page ee rane ee eee eames A Operation Procedures Pages Maintenance amp Storage Page Lue Operation of Maintenance Meter Page E seen Trouble Shooting Page 12 14 Replacement Parts Page 15 sense Seed Tubes Page 16 17 Decals eg e gt A REM nam Electrical Schematic Page 19 20 Hydraulic System Page 21 aussen Towing Safety Page 22 nenne Contact Infomation Additional User Manual s Honda 390 Operator Owner Manual KSI Conveyor Manual Note This manual supersedes any other information supplied by Par Kan Company before this date and is good only for serial numbers listed in the manual 4 Par Kan CO M2. PA N Y Par Kan Company 2 Pack One Year Warranty Par Kan Company s Equipment is warranted to the original purchaser to be free from defects in material and workmanship for a period of one year from the date of purchase as dated on 2 Pack origi nal invoice Par Kan Company will replace during the warranty period subject to an examination by an au thorized representative of Par Kan Company any warranted part which proves defective in material and or workmanship under normal installation use and service Parts must be returned and transportation charges prepaid to our factory Any changes to the 2 Pack equipment as a result of modifications mis use abuse neglect accident vandalism fire flood other acts of God or improper installation will void this warranty Treating seed in unit will void the warranty Par Kan is not responsible with seed used in any unit If Par Kan receives notice of any such defect during the warranty period Par Kan will at its dis cretion repair or replace components which prove to be defective Other manufacturer s warranties may apply for components installed on 2 Pack equipment Par Kan makes no other warranty either expressed or implied with respect to this product Any special incidental or consequential damages arising from any breach of warranty are specifically excluded hereunder Manufacturer s Warranties Axles 1 Year Warranty Honda 390 3 Year Warranty KSI Conveyor All service w
3. WN nh BROWN GJ GREEN RIGHT TURN 6 Aa RED tev 18 Par Kan C O M P A N Y 2 Pack Hydraulic System B 3 Solenold u Valve 4 7 5 Relief Valve Hyd Pump 11 3 13 19 Hyd Motor 20 18 19 16 Hyd Tank 5 LII 2 Pack Hydraulic Parts Listing 410058 Hose 96 00 Long 420127 FITTING 8F5OXS ST TH CONNECTOR 440026 VALVE 3WAY 12VDC CART 420126 FITTING 8F650XS SWIVEL 37 DEG SAE ST TH 410050 HOSE 174 00 Long 410017 Hose 18 00 Long 420091 FITTING TEE 6R50X S 420129 FITTING TEE 9 16JICF X 9 16JICM X 9 16 440025 VALVE RELIEF 420125 FITTING 8C5OXS ST TH ELBOW 430044 PUMP GEAR ALP1AD11 420124 FITTING 1610F5OXS ST TH CONNECTOR 410052 Hose 57 00 Long 420123 FITTING 16CTXS MALE ELBOW 440615 Hydraulic Strainer 430700 Hyd Tank 440611 Hydraulic Oil Filter with Spin on Cartridge 410103 Hose 198 00 Long 420128 FITTING 810F5OXS ST THE CONNECTOR 430074 MOTOR CONVEYOR 20 2 Par Kan C O M P A N Y 2 Pack Towing Safety Appendix Towing the 4 pack is designed to be safe if som
4. aulics will not operate No fuel Bad connections Dead Battery Starter Hydraulic Oil Solenoid or Elec trical Connec tions Hydraulic Com ponents Plugged oil filter Hyd Motor bear ings Engine over 3 000 RPM Blown Fuse Oil Cold Tempera ture Make sure the engine is running at full power Check for blown fuse in battery box Visually check to see that there is the correct amount of hydraulic oil 6 5 gallons of 10W 30 oil required 11 Visual Meter Meter Meter Visual Check the meter con nection or switch that is not working correctly Visual Visual or Heat Visual Correction Add fuel Clean or replace Charge or replace Repair or replace Add oil Fix faulty electrical con nection or switch Replace faulty hydraulic component s Replace Replace Keep engine at 3 000 RPM Replace 10 amp fuse be hind weigh head Add Oil Change Oil to 5W30 ee Par Kan C O M P A N Y 2 Pack Tender Engine 12 Par Kan C O M P A N Y 2 Pack Tender Frame amp Bod Rear View 13 Key Description 1 18 X 6 KSI Conveyor Pro Box locking springs Plastic Covers i 14 B P r Kan C O M P A N Y 2 Pack Tender Seed Tubes 362119 6 X 4 ft Bulk Fill Tube 1 1362120 6 3 Stage 6ft 16ft 15 1 Par Kan C O M P A N Y 2 Pack Decals Personal injury or property damage m
5. ay occur from improper use 9 Read and understand operators manual before using this equipment Phone 800 291 5487 for replacement manual Part No 250063 NOTICE 10 Thoroughly clean out unit after handling treated seed to prevent contamination of untreated seed or 250069 commercial grain Par Kan Silver Lake Indiana m www par kan com Jack Legs are ql 4 spring loaded Pinch points urt a watch your 280 hands CONVEYOR MUST BE q2 STOWED PRIOR TO Read users manual TOWING prior to operation towing or servicing P N 250105 BE CAREFUL 16 2 Pack Decals Description 3 Round Orange Reflector 3 Round Red Reflector Decal Treated Seed Decal Caution Pinch Point Decal Warning Read User s Manual GW Decal Made In The USA Decal Be Careful Overhead Wires No Arrow Decal Watch Your Step Decal Caution Manual Replacement Decal Par Kan 6 1 4 X 4 1 2 Decal Keep Hands Clear Decal Conveyor Must be Stowed 17 T Par Kan CO M P A N Y 2 Pack Electrical Schematic for Switch Panel Yellow from Remote Coil Red to Battery Gel Bos Red Orange from Remote Black To Ground 2 Pack Trailer Electrical Schematic WHITE ERAKE WIRE TO CHARGER RED AUX TO CHARGER BLUE BRAKE W RE TO BREAKAWAT UNIT BLUE WRITE ST R 5 WHITE RING TEs GREEN TELL I om 2 BRUV
6. e basic precautions are taken Itis your responsibility to make sure these procedures are followed for the safety of yourself and others on the road In addition due to the variety of laws you should check local and or state requirements Some common reasons for towing accidents include the following Failure to properly connect the coupler and or safety chains Overloading trailer towing vehicle or safety devices Towing with excessive speeds Damaged or improperly maintained towing equipment Items to consider before towing the 4 Pack unit You should check the payload rating on your towing vehicle s and equipment to ensure they can meet the re quirements of pulling our trailer Regular inspections should be made to safeguard against failure due to damaged towing and safety equipment Some of these items include safety chains hydraulic brake system and turn signals taillights If one or more of the links or fittings on the safety chain is stretched broken or deformed it should be replaced Always replace entire chain assembly Safety chains shall be connected to the towing vehicle and trailer so that the slack for each length of chain is ap proximately the same when the vehicles are aligned on a common front to rear centerline There shall be no more slack than necessary to permit proper turning of the vehicles The safety chains shall be crossed under the trailer tongue and connected to the hitch assembly or to other to
7. location to deliver seed make sure conveyor is locked in trans port position and safety pin is in place Check engine oil and fuel before starting engine Run engine and hydraulic system for 5 minutes to pre warm hydraulic fluid prior to operat ing conveyor unit Display the conveyor to deliver seed Slide conveyor carriage to the front or rear position Open the seed door on the pro box and on the conveyor discharge chute Once the grain has entered the conveyor turn the conveyor on and you are delivering seed Deliver the desired amount of seed required Close seed door on the pro box and on the conveyor discharge chute Store conveyor in transport position and pin in position Always clean out bin and conveyor belt after using treated seed 2 Pack Maintenance amp Storage Daily Check List Check engine oil level do not overfill Fill gas tank for daily operation Check for oil leaks Check hydraulic oil level do not overfill SAE 10W30 Fill full 6 5 gallons Inspect for loose nuts and bolts Inspect for belt alignment and belt damage Inspect and check that lights are working properly Inspect safety chains for damage Grease top and bottom conveyor pulley bearings refer to KSI manual Check tire pressure should be 80 PSI cold Check and inspect for loose wheel lug nuts Re torque Lug Nuts to 90 120 ft lbs after 250 Miles Seasonal Check List Inspect and pack wheel beari
8. ng parts while in operation Make no adjustments while cart is running The tender must be hitched prior to loading and should be on level ground while loading Do not load rear compartment only Do not touch or allow unit to come in contact with overhead electrical wires Gasoline tank should not be filled while engine is running or hot Consult the Honda manual for operating instructions before using Do not operate Honda Engine over 3 000 RPM Do not transport without conveyor locked in position 2 5 16 receiver must be adjusted for the unit to be level Do not load in excess of tire manufacturer ratings for either the 2 pack tender or the towing vehicle Towing vehicle should be of adequate capacity The total tender weight should not exceed 8 800 Ibs Wheel lug nuts must be torqued to 90 120 ft lbs Be aware of all information caution warning and danger signs on the unit 18 19 Be aware of hot hydraulic fluid in case of a hydraulic line break Below 10 degrees F change hydraulic oil to SAE 5W30 motor oil The operation of this tender must comply with all federal and state laws 4 P r Kan C O M P A N Y 2 Pack Operating Procedures Un pin pro box slide locks so the locks spring outward Load pro boxes from the side making sure the slide gates of the pro box are outward Once pro boxes are loaded slide lock mechanism into place and pin locking system Prior to traveling to desired
9. ngs Inspect for conveyor belt wear or damage Inspect discharge hood for excessive wear or damage refer to KSI manual Grease top and bottom conveyor pulley bearings refer to KSI manual Clean battery terminals Service Honda engine See Honda manual Empty gas tank for seasonal storage Change hydraulic filter after first 50 hrs of operation and every 300 hrs of operation there after Wash and wax to maintain powder coat finish Check all fasteners for tightness Par Kan C O M P A N Y 2 Pack Operation of Maintenance Meter Multi Function Maintenance Meter Hour Meter Tachometer and Service Alarm Hour Tachometer These functions are fully automatic Upon engine start the meter will show rpm s At engine shutdown the meter displays the total accumulated running time which cannot be reset Service Alarms This function is also fully automatic The meter has a dual flash alert display ing CHG OIL amp LUBE at 25 operation hour intervals The meter will begin flashing 1 hour be fore the 25 hour increment and stop flashing 1 hour after Note Consult the Honda Manual for the engine s proper maintenance schedule Also consult this manual for the proper Seed Weigh system maintenance schedule 10 2 Pack Trouble Shooting Engine will not start Selective hydraulic components not working Conveyor Motor Conveyor speed slow Hydraulic oil overheating Hydraulics will not operate Hydr
10. ork performed by KSI P r Kan CO M P A N Y Dimensions for a 18 ft Conveyor Length O zi N gt N MN RT t M Add n ig INT Q a ONOAAR WD N ND NN PNP VY mm a ca HS SS SS HS S m CO oO PEN 0O CO OSI 0 01 PEN 4 Par Kan C O M P A N Y 2 Pack General Specifications amp Features Capacity 2 Box Discharge Rate Speed 18 units min Overall Height 13 1 Shipping Height 8 10 Overall Width 98 1 2 Trailer Length 17 6 Overall Length 23 6 Discharge height 10 2 Unit Empty Weight 3100 Side reach 13 0 Deck Height 68 Hydraulic tank 6 5 gallon Gas tank 1 4 gallon KSI conveyor 8 conveyor belt in 6 tube 1 1 4 cleats 18 long Entire unit powder coated Honda Engine 390cc 18 amp with eleciric start Wireless remote Hydraulically Driven Conveyor Belt Appropriate DOT Standards with 24 000 safety chains 5 200 axles all with electric brakes Tires 8 Wheel 15 8 PLY 6 HOLE 225R15 Hand crank jack standard Ball coupler 2 5 16 rated at 25 000 Ibs Towing Capacity 8 800 Maximum Towing Vehicle Hitch MUST be Rated at 8 800 Ibs O o Se PC EE uu AH Q N 14 15 16 17 20 4 P r Kan CO M PA N 2 Pack Safety and Operating Precautions Observe all safety precautions listed in this manual No riders Stand clear of all movi
11. wing vehicle members Note Crossing the chains under the tongue typically reduces the probability of stressing or breaking the chains when turning Figure 3 Standard Ball Coupler 2 5 16 Part 280057 21 Contact Information Par Kan Company Phone 1 800 291 5487 2915 West 900 South Phone 260 352 2141 Silver Lake IN 46982 Fax 260 352 0701 Contact Sales Department E mail GWSales par kan com Website www par kan com 22
Download Pdf Manuals
Related Search