User manual
Contents
1. On trailers fitted with a heater it is important to regularly check that the automatic fuses are in correct position Battery charge for the Heater s batteries will not work if the fuses are blown In cold weather this can damage the batteries First 1000 km Wash the box and the frame with low water pressure during the first weeks as it takes time for the paint to harden e The detergents used for cleaning must have a pH value between 5 8 otherwise the aluminium parts can be damaged This applies for every wash Tighten nuts and bolts on turntable steering drawbar fittings wheel nuts axles according to axle handbook For tightening of axles and suspension see axle manufacturer s hand book Check these fittings regularly and tighten when needed Maintenance Every week Regular use of the lift axle once a week is necessary to maintain the function of the lifting components e Check regularly that all lights are working and that the light covers are not damaged or cracked A non working light bulb must be fixed changed immediately as a working light bulb keeps moisture away from inside the light e Check the coupling boxes regularly for damage When changing a bulb spray the bulb holder with some vaseline grease HHS 2000 to keep moisture away 24 Every month e Check the cables and connectors of the drawbar Immediately repair cracked and damaged cables hoses Check the plugs and couplings2. Support poles for sawtimber Floor types Floor types and highest permitted fork lift axle pressure E1 5500 kg E3 8000 kg F1 5500 kg F3 8000 kg TH3 8000 kg 22 ATP certificate For all Ekeri boxes boxtrailers ordered as FNA or FRC we can apply for an ATP certificate This is a certificate that confirms that the body fulfills the ATP FRC or ATP FNA reguirements One of the conditions for this is that the trailer or body is eguipped with a fridge unit with large enough capacity If a company other than Ekeri mounts the fridge unit make sure that it is properly tested before taking it into service Other eguipment If your Ekeri product is eguipped with heater tail lift fridge unit you will find separate operating manuals for this eguipment Remember to always use Ekeri original accessories 23 Every Ekeri box body and trailer is built to the highest guality To make sure your trailer or box body is working properly please carry out the following proceedures First drive Before a new Ekeri trailer is taken onto the road the tyre pressures must always be checked before the trailer is loaded for the first time On twin mounted tyres be aware that there are two valves opposite to each other in the outer wheel Check the pressure in both tyres Before starting to use your new Ekeri trailer check that the wheel nuts are tightened Check the wheel nuts regularly and tighten when needed
3. rail by putting one of the cylinders A into the end of the strap fastener There are openings in the rails approximately each meter where the fastening strap can be let down into the rail Ekeri s load restraint system makes it easy to secure the load in exactly the right place Ekeri Surrmax is an optional eguipment which can be used to secure full width loads that cover the fastening rail Always use Ekeri original fastening straps cylinders and fasteners for maximum safety HS See how the Ekeri fastening system works Ekeri load restraint system C B A Pic 1 A Cylinder B Strap C Fastener Pic 2 D Fastening rail E Surrmax Ekeload The EkeLoad system optional Special poles are also available to developed by Ekeri permits flexible enable side loading on two levels loading on two levels When the EkeLoad beams are not in The EkeLoad system consists of use they can easily be removed or bars located on the walls and side stowed under the roof doors as well as bearing beams The recessed bars are completely flush with the wall structure to prevent the cargo from being rubbed and damaged during transport Always use Ekeri original accessories 1 Montera de tv f rsta EkeLoad bommarna Bom nr 2 har hylsa och 2 Montera alla sidostolparna monteras med hylsan bak t 2 Asenna kaikki sivutolpat paikalleen 1 Asenna kaksi ensimm ist EkeLoad puomia Holkillinen puomi 2 Mount all s
4. Ekeri trailer 20 On drawbar trailers with liftaxle optional equipment the lift axle is controlled from a button in the truck cab When the axle is up make sure the load capacity of the other axles is not exceeded be exceeded a PP Lift axle Regular use of the lift axle once a week is necessary to maintain the function of the lifting components When the axle is lifted lowered make sure nobody nothing is under the trailer On some trailers the control is fitted on the trailer chassis When the Iift axle is up the load capacity of the other axles must not Check that nobody is under the trailer when operating the lift axle For optimal function the lift axle must be used once a week 21 aD For transporting sawtimber Ekeri have developed special support poles optional equipment with a foot that fits into the Ekeri load restraint rail In some specially ordered boxes there are also holes in the middle of the floor Poles with the foot turned upwards can be fitted here All new Ekeri units have a sticker on the inside wall that shows floor type and highest permitted fork lift axle pressure Always be sure to check that the fork lift axle pressure does not exceed the maximum permitted fork lift axle pressure when loading and unloading Always ensure that the the fork lift axle pressure does not exceed maximum permitted fork lift axle pressure Only use original Ekeri spare parts and accessories
5. Hisings Backa Berner amp co Tunga fordon Fyrvallav gen 4 831 43 stersund Skandinaviska Lastvagnar Torbornav gen 17 253 68 Helsingborg Contact person Fredrik Str mo Lennart Forsell Lars Nises Bert Guldstrand Jan B rjesson Mats Albertsson Sven Ingvar Bengtsson Phone 0920 253040 08 6210928 0243 17210 040 212846 031 7424844 063 574 784 042 292060 Fax 0920 253041 0243 17211 040 212847 031 527108 063 574 719 042 294410 Service network 35 Country Country code Norway 47 Norway 47 Norway 47 Great Britain England 44 Scotland 44 Holland Netherlands 31 Service point Contact person Ekeri Norge AS Trond Lundsten Hunnselvveien 10 2830 Raufoss T K Mek AS 6240 rskog K re Mathiesen Bjerlands Lakk og Karosseri Postboks 19 4652 verb Colliers Truck Builders Limited Unit 15 Blackwater Trading Estate The Causeway Maldon Essex Colin Hutton Coachworks LTD 40 Stronend Street Glasgow G22 6AR www colinhutton com Ole Gunnar Bjerland Mick Gill Burg fabriek van Jan Bunk wegtransportmiddelen B V Katwijkerlaan 75 2641 PD Pinjacker Service network Phone Fax 611 59850 611 59860 70270778 70270267 38139636 38139636 01621 843109 01621 843047 0141 336 3371 0141 336 3821 015 3694340 015 3693385 36 Appendix 1 Follow up form We aim to continually develop our products and servi
6. with the special eguipment Optional eguipment can for example be tail lift fridge units heaters and so on Side doors The side doors on Ekeri boxes are divided into two On longer boxes there is always a sections front and rear sections with 3 3 doors on midpole D between the two door short boxes and 5 5 on long boxes sections The midpole comes off in one piece by first pulling out the locking pin The doors open from the middle Open one door at and then gently pulling the pole a time and fasten it to the next door When a whole outwards section is opened it has to be secured with the door The midpole should always be put back catch which can be found inside the last door of in place before starting to close the each section The doors are closed by doing the side doors On some models The lower opposite part of the pole can be removed by To close the first pair of doors put gentle pressure opening the two locks and carefully on the second door to push it into its guides do the pulling it out and lifting it away The same with the following pair of doors and then it is Upper part of the pole can be drawn to easy to close the single mid door To be able to the side of the box while loading operate the side doors properly on a semi trailer the trailer has to be connected to the tractor unit s The side doors are lockable with keys or to the dolly s fifth wheel delivered inside the box Hold the midpole with one hand
7. Contact person Stefan Fagerstr m Lasse Kangasniemi Matti Valkama www ofekeri se Claes Olsson Bo Olsson H kan Magnusson Stefan Fagerstr m Bj rn Evensen Erik Fagerholm Anders K Larsen Isleifur Erlingsson Phone 040 5621111 040 5444752 0400 692538 0433 726 00 070 62 71005 070 62 71052 070 36 72610 358 40 5621111 61159850 61159850 75890022 22281516 520 8028 Sales network Fax 06 7887412 09 2787638 017 3622248 0433 711 83 0433 711 83 358 6 7887412 61159860 61159860 75890887 520 8010 28 Country Country code Holland Area Contact person Phone Jan Bunk 015 3694340 Sales network Fax Burg fabriek van Netherlands 31 Great Britain wegtransportmiddelen B V Katwijkerlaan 75 5641 PD Pijnacker 015 3693385 Burntwood Services Ltd 44 24 Canterbury Way Chelmsford Essex CM1 2XN Robert Wise Horst Mevissen 07966 203640 02452 7067 07966 203640 02452 87440 Mevissen Nutzfahrzeuge Germany 49 Russia Johannesstra e 20 52525 Waldfeucht Haaren www mevissen de Viktor Pakki 358 41 51 30257 Ekeri Center Helsinki Pitk sentie 23 01200 Vantaa 29 Spare parts Country Service point Contact person Phone Fax Country code Finland Ekeri Center Barbro Molander 06 7887475 06 7887479 358 K llbyv gen 1276 68800 K llby Sweden OF Ekeri Ab 0433 72600 0433 71183 46 Ulvaryds i
8. Komme User manual Safety precautions N Side doors Rear doors Ekeri load restraint system EkeLoad EkeBandup EkeHeat Front wall ladder EkeGuard Lashing bars in walls Inner lights Lift and lower controls Manometers axle pressure Draw coupling Drawbar Electrical plugs ABS brake plug and air couplings for trailer Lubrication Lift axle 21 Support poles for sawtimber 22 Floor types 22 ATP certificate 23 Other equipment 23 Maintenance 24 Sales network 28 Spare parts 30 Service network 32 Appendix 1 Follow up form 37 Appendix 2 Warranty note separate Appendix 3 Service book 38 Appendix 4 Electrical connections 43 Ver 1 4 2 2012 Contents For safe and effective use of your trailer or box body please read and follow the safety precautions DOORS Always keep the side and rear doors secured with the doorcatch when they are open Do not drive with open doors or tail lift down Always have the semi trailer connected to the fifth wheel when using the side doors FASTENING OF GOODS Never fasten the straps at 90 degree angle to the walls since this can damage the lashing bar in wall doors We recommend wrapping the strap as a U around the cargo to avoid pulling the bar out of the wall AIR SUSPENSION Always keep the controls for lift and lower in driving position when driving AN Safety precautions CONNECTING AND DISCONNECTING A TRAILER Disonnecting Conn
9. ce to support our customer s needs After you have used your Ekeri product for about 2 months we ask you to take a few minutes to complete our follow up form and faxing it to us or send by post Our fax number is 358 0 6 788 74 12 Thank you FILL OUT THE FOLLOW UP FORM AND SEND IT TO EKERI BY FAX OR MAIL CLICK HERE CD version only 37 Date Maintenance Done by Date Maintenance Done by Date Maintenance Done by Date Maintenance Done by Date Maintenance Done by Ekeri CAL CO ONS Date Front junction box nn Center junction box Mounted Led TIES lt lt lt FE no jani jani jani juni ast IND IND jon just ja Brown J Side tg lights right VBG 6 O Red 4 O Yellow VBG 2 O Green Dir indicator right VBG 3 Blue Reversing lights VBG 7a Blue Black Work light VBG 8b O White Green Rear fog light VBG 7b O Pink Interior light IN OUT VBG 8a N Interior light OUT Purple Extra Tail axle lift VBG 9 O Orange Extra Draw bar VBG 10 O Grey Extra Axle lock VBG 11 O Yellow Green Extra Yellow Red Microswitch hassis C O Chassis VBG 1 O 131 O White C O3 L O 7 54g O 154 O 6 58R O 5 R O 2 58L O 131 Electrical connections O 12 O 14 15 si O O 4 13 O 43
10. d on rear axles and on a draw bar trailer two showing load on front and rear axles Manometers The manometer closest to the rear is for rear axles and the other for front axles The load shown is not exact and should only be used as guideline 1 Axle pressure for front axle s 2 Axle pressure for rear axle s 15 Draw couplings for trucks come as optional eguipment and can be installed with or without air servo The draw coupling has a safety pin B When the handle A is lifted the safety pin comes out and the draw pin C rises A Never place any part of your body in a coupling fitted with a servo Lubricate the coupling every week with a thin oil For the best results the coupling should be open during lubrication Draw coupling Always check that the draw pin C is up before starting to connect the truck to the trailer After connecting the truck please make sure that the draw pin C is down and that the safety pin B has locked the draw pin A Handle to raise the draw pin B Safety pin C Draw pin 16 Drawbar The drawbar on Ekeri trailers is either bolted or All bolts on the drawbar including bolts for fitting drawbar extendable with air locking device The bolted drawbar to chassis have to be regularly checked and thightened can be extended by loosening the bolts on top of the when necessary The drawbar eye is either 40 mm 50 drawbar and moving the front part to desired pos
11. ect the parking brake first Then disconnect the ABS and electrical cables first then the air hose and finally the drawbar or Kingpin Connecting Always connect the drawbar or Kingpin first then the air hose and finally the electrical and ABS cables Always keep the parking brake engaged when connecting or disconnecting the trailer Remember to wind down the semi trailer legs before Kingpin is released and raise when semi trailer is connected Check that nobody nothing is under the trailer when using the lift axle Lights Do not load too close to the inner lights when the lights are on Never cover the lights with an intermediate wall if you intend to keep the lights burning for a long period of time First of all we wish to thank you for choosing Ekeri We hope this delivery will be the beginning of a long relationship between us Before you start to use your Ekeri box or trailer please read this manual Symbols Contains the most important points in the chapter It is important to take special note of these Hints and tips that makes everyday use easier and more efficient A movie is included Click on the icon to start the movie Some of the details in this manual cover optional eguipment that may or may not be on your box body or trailer Your Ekeri box body or trailer may also be eguipped with some other optional eguipment that s not mentioned in this manual In this case read the instructions enclosed
12. f a GPS positioning system With this feature the exact position of the vehicle is sent as an SMS to your mobile phone When you get the coordinates as an SMS go to www ekeri fi pos and enter them to see the vehicle position on a map It s also possible to switch on and off interior lights engage disengage locks and alarm through SMS For more information about the EkeGuard system please see the separate instructions enclosed with your trailer EkeGuard protects the load and the equipment EkeGuard 12 Lashing bars in walls Ekeri boxes can also be eguipped with lashing bars in walls doors optional eguipment These can be used in combination with straps to fasten lighter goods against one or several walls It is not recommended to fasten the straps at a 90 degree angle against the walls as this can damage the lashing bar We recommend fitting the straps as a U around the cargo to avoid pulling the bar out of the wall Inner lights All Ekeri boxes have inner lights On truck bodies the lighths are switched on in the truck cab All trailers are prepared with wiring to the electrical connection so that the operator can install a button for activating the interior lighting in the truck cab Usually there is also a switch which enables interior lighting with power from the parking lights This is either a separate switch on the chassis or inside the box for lift and lowering of air suspension A In
13. heater outlet 10 With the practical ladder you can easily reach the fridge unit for maintenance work The ladder can simply be folded out and retracted in the front corner profile Opening Open the lock A hold the handle B and push the ladder first upwards then pull outwards see movie Closing Hold the handle and push in the upper part of the ladder under the upper cover Then lift the ladder over the lower edge and when in position press down Then close the lock Don t use excessive force when opening closing the ladder The Ekeri ladder reduces wind resistance and weight Fold in the ladder when it s not in use Also read the manual for the fridge unit Front wall ladder 1 Styr in vre delen av stegen under skyddsk pan p vre sidan av d rren 2 Lyft upp nedre delen av stegen ver kanten p skyddsk pan och s nk mer Detailed instructions for use of the ladder Click to enlarge 11 EkeGuard Safety with the push of a button With the EkeGuard optional it s easy to lock or unlock all doors on the trailer boxbody with the push of a button At the same time an alarm will be activated for added protection If somebody manages to open the door even with the locks engaged the alarm will be set of To lock the boxbody or the trailer push the lock button To unlock simply press the unlock button EkeGuard is also available with the extra feature o
14. i r CO u i n JS 2 Electrical connectors and plugs 3 ABS brake plug Always engage the parking brake before connecting or disconnecting the trailer When disconnecting the trailer first apply the If the truck does not have ABS the ABS plug can parking brake Then disconnect the ABS brake be fitted on a holder on the drawbar For semi plug and electrical plug After that the Air trailers it is important to always wind down the couplings and finally the drawbar or Kingpin This support legs before disconnecting the Kingpin The is a safety precaution to prevent the trailer from support legs must be wound up after the Kingpin moving while connecting or disconnecting has been connected Remember to connect and disconnect the couplings in correct order Always wind down the support legs before disconnecting the Kingpin On trailers with EBS brakes the EBS plug should always be connected to the truck regardless if the truck is eguipped with EBS or ABS Fit the ABS brake plug on the holder if it s not in use a app 19 On Ekeri drawbar trailers there are lubrication tubes on the chassis for example to lubricate the turntable steering on front axles The tubing comes out on the left side of the front axle construction where grease fittings for vaseline can be found Regular lubrication increases the life of your trailer Regular lubrication increases the life of your trailer Lubrication A Grease fittings on an
15. ide supports nro 2 asennetaan holkki taaksep in 1 Mount the two front EkeLoad bars Bar no 2 has a socket and is mounted with the socket facing to the rear 3 VIKTIGT F st stagen mellan alla sidostolparna och framtill F st 4 Montera EkeLoad bommarna s l ngt som lasten kr ver ocks stagen baktill i sista EkeLoad bommen eller i bakkarmen 4 Asenna kuorman vaatima m r EkeLoad puomeja 3 HUOM Kiinnit tuet tolppien v liin ja eteen Kiinit my s takana ole 4 Mount the EkeLoad bars as required vat tuet viimeiseen EkeLoad puomiin tai takakarmiin 3 NOTE Fasten the stay between all side supports and in front Also fasten the last stay in the last EkeLoad bar or in the rear doorframe EkeBandup EkeBandUp optional fastens the straps to the roof when loading from the side The EkeBand Up keeps the straps at a 90 angle under the roof to facilitate maximum loading space The EkeHeat heater is optional eguipment for ke H e at boxbodies and trailers Hot air from the heater enters the upper part of the front wall and flows over the load through the loadspace The heating is efficient and distributes the heated air evenly over the loadspace When the air has cooled it returns below the load back to the heater EkeHeat is mounted in an compact box on the front of the boxbody or trailer A Remember to check the automatic fuses for heater s regularly A Do not put flammable objects near the
16. ition mm or 57 mm in diameter The truck must have a draw After adjusting the bar replace the bolts and tighten with coupling the same diameter as the trailer s drawbar eye correct force see below All drawbars can be raised or lowered with the crank which is fitted on the left side in the front of the trailer A Remember to tighten the bolts after initial few days of use Tightening force dry A 195 Nm B 125 Nm C 600 650 Nm 17 The drawbar with air locking can either be adjusted from a button in the truck cab or from a control on the drawbar To adjust the drawbar release the lock from the button or from the control and move forward or in reverse depending on if you want to extend or shorten the drawbar Put on the lock by pushing the button or the control and move forward or reverse until the lock engages Drawbar Before adjusting the length always make sure to apply the trailer brakes The lock has to be released regularly to maintain the function in the locking device A When adjusting the drawbar the brakes on the trailer must be set A To maintain the functionality of the air locking drawbar run the drawbar once a week Regular lubrication will give the drawbar better performance and a longer life 18 Electrical plugs When the drawbar or Kingpin has been connected the following A 5 S D ra ke u couplings must be connected in the following order 1 Air couplings Duo Matic A
17. ndustriomr de Arne Persson 0433 72601 Box 11 070 6672601 S 285 21 Markaryd Norway Ekeri Norge AS Trond Lundsten 61159850 61159860 47 Hunnselevveien 10 2830 Raufoss Iceland Stilling h f Gardar Skarph dinsson 520 8028 52080021 354 Skeifan 11 824 8028 108 Reykjavik Holland Burg fabriek van Jan Bunk 015 3694340 015 3693385 31 wegtransportmiddelen B V Katwijkerlaan 75 2641 PD Pijnacker England Colliers Truck Builders Ltd Mick Gill 1621 843109 1621 843047 44 Unit 15 Blackwater Trading Estate The Causeway Maldon Essex 30 Country Country code Scotland 44 Germany 49 Russia Service point Colin Hutton Coachworks Ltd 40 Stronend Street Glasgow G22 6AR Mevissen Nutzfahrzeug GmbH Johannesstra e 20 52525 Waldfeucht Haaren www mevissen de Rustruck Puschkin St Petersburg Contact person Horst Mevissen Viktor Pakki Spare parts Phone Fax 141 336 3371 141 336 3821 245 7067 2452 87440 358 41 51 30257 31 Country Country code Finland 358 Finland 358 Finland 358 Finland 358 Finland 358 Finland 358 Finland 358 Service point Ekeri Center K llbyv gen 1276 68800 K llby Suomen Kuljetuslaite Hakkilankaari 4 01380 Vanda Kuorma Autoasennus JM Oy Hakalahdentie 13 70460 Kuopio Per vaunu Ky Vuola Voivalantie 28 20780 Kaarina AH Kaross Larvv gen 18 66590 Vassor Toplift Hopeatie 54100 Joutseno Asen
18. ner light switch 13 All Ekeri trailers have lift and lower valves for the air suspension On semi trailers there is one control and on drawbar trailers two The control has to be moved to the left or right depending on desired movement The control has five positions see picture If moved to the left the trailer lowers and stops at a factory pre set position If moved to the right the trailer rises to a factory pre set position If the trailer is required to stop in a position other than the pre set move the control to stop The controls must always point downwards driving position when driving The left control is for the front and the right is for the rear The box also contains an air outlet that can be used with the supplied air hose for cleaning the fastening rails Lift and lower controls When the control s point downwards the trailer is set in driving position This should always be the case when driving The lift and lowering valves are normally placed on the left side of the trailer in an aluminium box If there are two controls the left one A controls the front and the right one controls the rear B A Lift lower control for front B Lift lower control for rear C Air outlet 14 Ekeri trailers usually have manometers as standard see picture These can be found in the same aluminium box as the controls for lift lower valves On a semi trailer there is one manometer showing loa
19. nuals For maintenance on axles follow instructions given by axle manufacturer hand book Maintenance The following cleaning methods are recommended for vehicle safety markings Wash with sponge cloth or soft brush using water and detergent The cleaner must be non abrasive without strong solvents and with a pH value between 3 and 11 Automatic truck car wash or standard high pressure hand spray Maximum pressure 1200 PSI 80 bar Maximum water wash solution temperature 140 F 60 C Minimum of 12 inches 30cm distance of cleaning jet s from markings Cleaning wand or jets to be at no greater angle than 45 degrees from perpendicular to the marking surface When using metal brighteners follow manufacturer s recommendations for dilution Thoroughly rinse from markings after soaking vehicle Remember to always use original Ekeri spare parts and service 26 Thank you for reading this user manual For more information or other guestions please contact us Ab Ekeri Oy K llbyv gen 1276 www ekeri fi FIN 68800 Kallby 27 Country Country code Finland 358 Finland 358 Sweden 46 Norway 47 Denmark 45 Iceland 354 Area Ab Ekeri Oy Ekeri Center Helsinki Kuopio OF Ekeri Ab Southern Sweden Northern Sweden Ekeri Norge AS Hunnselvveien 10 2830 Raufoss Lastas A S Energivej 35 8722 Hedensted Stilling h f Skeifan 11 108 Reykjavik
20. nusty M Ahlgvist Oy Vahdontie 163 21290 Rusko Contact person H kan Sundgvist Ronny K cko Veijo Varonen Carrier 24 h Hannu Pekkarinen Jouko Penttinen Mikko Salolahti Jarmo Vuola Alf Hellman Kennet Hellman Pekka Ravattainen Janne Ik heimonen Phone 06 7887471 06 7887472 010 6503112 040 7247831 010 6503155 017 3644333 020 7118830 0400 530305 06 3464239 05 6100500 020 749 8220 040 082 7936 Service network Fax 06 7887479 06 7887479 010 6503190 017 3644350 020 7118831 06 3464205 05 6100559 020 749 8221 32 Country Country code Finland 358 Finland 358 Finland 358 Sweden 46 Sweden 46 Sweden 46 Service point Cargofix Oy Halmekuja 2 01360 Vanda Korihuolto Moksi Juvantasku 7 02920 Esbo Wetteri Power Oy Poikkimaantie 31 90400 Ule borg B stab Ab Flintv gen 4 26941 stra Karup Ume Nya Bromsservice Stackv gen 4 90137 Ume Bj rn Johansson Karosseri Ab Fallvindsgatan 4 65221 Karlstad Contact person Oksa Janne Korjaamo Vaihde Oulu Kajaani Rovaniemi Kuusamo Kemi Kennet Forsell Janne Samuelsson Bj rn Johansson Phone 045 1371877 020 7209898 020 778870 0400 890868 0400 680102 0400 690888 0400 685089 0400 392555 0431 74720 090 144433 054 851535 Service network Fax 020 7209899 020 7788796 0431 74095 090 148260 054 851535 33 Coun
21. on the drawbar When changing the couplings and electrical plugs spray with vaseline grease HHS 2000 to prevent moisture ingress On trailers with a heater fitted it is important to regularly check that the automatic fuses are in correct position The batteries will not charge if the fuses are blown In cold weather this can damage the batteries Every year Open up all lights and spray the bulb holders with vaseline grease HHS 2000 or similar e For the Ekeri Roca roof interior light use bulb type 24V 21W BA 15 s for example Philips type 13498 or Osram type 7511 Maintenance General Lubrication Regularly check and lubricate all grease fittings on the trailer and all grease points advised by the axle manufacturer In order to keep the side doors functioning the side door mechanism should be lubricated regularly with vaseline If the trailer is equipped with central lubrication points see Lubrication in this handbook fill the reservoir regularly Chassis The chassis welds and bolt fastenings should be checked regularly Regularly check all rubber bushes and tighten if needed Regularly check fittings for shock absorbers and air bellows and thighten when needed Heavy loads should be avoided in severe cold Empty the air tanks regularly 25 Other maintenance Read maintenance and service manuals for other eguipment such as tail lifts or heaters which have separate ma
22. try Country code Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Service point AO Lastbilsverkstad Pikullav gen 1 702 27 rebro Lastbilsteknik Ab Planerargatan 5 781 70 Borl nge Lastvagnsteknik i G teborg Ab Transportgatan 7 422 46 Hisings Backa STS Sydhamnens Trailerservice Kabelv gen 9 553 02 J nk ping STS Sydhamnens Trailerservice Pj ltv gen 3 616 34 by Norrk ping Sandstr ms Center Ab Treh gsgatan 11 213 76 Malm Sandstr ms Center Ab V stbergav gen 14 16 126 30 H gersten Contact person Anders S derberg Martin Melchert Anders Svensson Peter Lappalainen Lennart Emilsson Mats Pettersson Semir Berhamovic Johan Sandstr m Phone 019 270751 0243 217900 031 582228 036 314999 011 166311 040 221120 08 7114916 Fax 019 272130 0243 16648 031 581816 036 314998 011 166401 040 221121 08 6211230 Service network 34 Country Country code Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Sweden 46 Service point Sandstr ms Center Ab Ektj rnsv gen 2 975 91 Lule Sandstr ms Center Ab Avestagatan 61 163 53 Sp nga Sl p amp Kaross Ab Paketgatan 12 784 72 Borl nge restads Trailer amp Sk pservice Hindbyv gen 4 213 74 Malm Karosseriteknik i G teborg Ab Tagnev gen 4 422 59
23. when the locks on the midpole are opened Always put the midpole in place when closing the side doors See how to close and open the side doors A B C Side door locks D Midpole Click to enlarge s gt gt The rear doors have either single or double lock handles To open the rear doors always start by opening the right hand door first To open doors with double locks both lock handles have to be opened at the same time and when closing the doors both locks have to be closed at the same time The lock handles have to be put back in place before the rear doors are turned against the side otherwise they might cause damages to the sides Always close the lock handles before turning the rear doors to the sides Always secure the doors with the door catch The rear doors can be locked with a padlock g SPP See how to open and close the rear doors Rear doors When the doors are open always make sure they are secured with the door catch which can be found on the side under the box or with the rubber catch on the side on FNA FRC The rear doors can be locked with a padlock on the right hand door A Rear door locks B Fastening for padlock C hooks Click to enlarge All Ekeri box bodies are delivered with Ekeri s patented load restraint system as standard Inside the box there is a load restraint rail D let into the floor on both sides The fastening straps B are fitted into the
Download Pdf Manuals
Related Search