Counter Top Convection Oven
Contents
1. BURCQ Counter Top Convection Oven Please read and keep these instructions These instructions cover the Burco counter top convection oven model CTCO02 SKU 444441151 02 SKU 444441151 Glen Dimplex Professional Appliances Stoney Lane Prescot Merseyside L35 2XW Tel 0844 815 3755 www burco co uk INTRODUCTION To ensure you obtain full benefits from your new oven e Please read this instruction booklet carefully and follow all instructions e Ifyou are unsure of any aspect of the installation use or performance of your oven please contact the after sales number shown on the back page SPECIFICATIONS Model 17 CTCOOR SKU Number 444441151 Depth 545mm _ Weight 4g O Voltage 1 230v 50HZ Powerrating _ 24000 INSTALLATION Installation Requirements It is essential that this appliance is installed correctly Installation should comply with all local electrical and health and safety requirements WEEE directive registration WEE DKOO59TT At end of unit life dispose of appliance and any replacement parts in a safe manner via a licenced waste handler Units are designed to be dismantled easily and recycling of all material is encouraged whenever practicable Before Connection to Power Supply Remove all packaging Check the oven and parts for damage Report any damage immediately to the carrier or supplier Remove any protective plastic coating from the outer p2. The oven does not operate checked by a qualified engineer Thermostat or element thermostat or element faulty Timer does not time 5 Timer faulty Replace timer Oven light not Replace bulb GUARANTEE This convection oven is guaranteed against defective materials or faulty workmanship for a period of 12 months on labour and 36 months on parts This guarantee is given subject to the appliance being used in accordance with the instructions supplied and on the supply voltage marked on the rating label The guarantee is subject to fair wear and tear conditions The guarantee does not cover consequential damage arising out of any failure acceptable under guarantee nor does it cover damage resulting from misuse accident or unauthorised alterations to the oven Proof of purchase will be required In any communication with the supplier or manufacturer quote the model and serial number marked on the oven rating label This guarantee does not affect your statutory rights The products are intended for commercial use as detailed in these instructions The Company has a policy of continuous improvement in product quality and design The Company therefore reserves the right to change the specification at any time FAQ s WIRING DIAGRAM COUNTER TOP CONVECTION OVEN HEATING POWER INDICATOR INDICATOR AMBER GREEN OVEN THERMOSTAT od SWITCH THERMAL ELEMENT Wiring colour code Bk B
3. and disposed of safely An appropriate plug should be fitted as follows IMPORTANT The wires in the mains lead are coloured in accordance with the following code Green and Yellow Earth Blue Neutral Brown Live The wire which is coloured green and yellow must be connected to the terminal in the plug which is marked with the letter E or the earth symbol or coloured green or green and yellow The wire which is coloured blue must be connected to the terminal which is marked with the letter N or coloured black or blue The wire which is coloured brown must be connected to the terminal which is marked with the letter L or coloured red or brown Make sure that the connections are tight and that there are no loose strands of wire and no insulation trapped under the terminals Tighten the clamp in the plug making sure that it grips the outer covering of the cord If fitting a BS 1363 13A fused plug then fit a 13A fuse Tighten the plug cover securely If you are in any doubt consult a qualified electrician IMPORTANT if the supply cord is damaged it must be replaced by the manufacturer service agent or similar qualified person in order to avoid a hazard The supply cord may become warm when the appliance is in use WARNING THIS APPLIANCE MUST BE EARTHED In addition to the earth within the mains plug connect the equipotential bonding terminal on the rear panel Electrical connection 230V 50Hz 10 5A 2400W Before Use Operate t
4. anels Check the following parts have been supplied with your oven 2 x Oven shelves Check the available power supply corresponds to that shown on the oven rating label Location This oven is for indoor use only Do not install the oven in a cabinet it is for counter top use only Allow at least 200mm clearance above the oven The oven is only to be installed in locations where its use and maintenance is restricted to trained personnel The mains lead should reach from the mains socket without straining the connections Do not let the mains lead hang over the edge of the table or counter and keep it away from any hot surfaces Do not let the mains lead run across an open space Do not place the oven where the mains lead could fall into a sink Do not place the oven near a hot gas or electric burner Ensure the oven is level both from side to side and front to back to ensure even cooking There are adjustable feet on each corner tighten the locknuts after adjustment The oven should be positioned such that it can be loaded and unloaded easily and the controls can be operated conveniently Important DO NOT OBSTRUCT THE VENTILATION SLOTS IN THE BASE AND REAR OF THE OVEN Electrical Connection Fitting a plug The mains lead of this oven will already be fitted with a BS1363 13A plug If the fuse has to be replaced use a 13 amp fuse complying with BS 1362 If the plug is not suitable for your socket then the plug must be cut off
5. he oven for approximately 30 minutes at the highest temperature to remove any fumes or odour which may be emitted this is due to oil used during manufacture or from the oven insulation but is not harmful 545mm USER GUIDE DO NOT COVER THE OVEN ELEMENT OR OVEN SHELVES WITH METAL FOIL DURING USE THE OVEN BECOMES HOT BE CAREFUL NOT TO TOUCH HOT SURFACES TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG WHEN NOT IN USE BEFORE CLEANING AND BEFORE REPLACING ANY PARTS Heating indicator amber Thermostat Timer Power indicator green Controls green power indicator will be illuminated whenever power is connected to the oven Turn the thermostat to the desired oven temperature oven fan will start and the interior light will be illuminated The amber heating indicator will be illuminated whenever the element is on e Once the oven is up to temperature shown by the amber heating indicator cycling on and off open the door and load the oven with product Avoid delays in loading the oven with the door open as this will delay the oven s temperature recovery e Set the timer to desired time To set the timer turn the knob clockwise to the required time At any stage the time can be adjusted in either direction Note This 120 minute timer is completely independent of the oven control e Time up when the timer reaches 0 minutes the bell will sound e Unload oven Cooking Guide Baking T
6. his convection oven will cook food faster at a lower temperature and more evenly than a conventional oven Roasting Set the oven temperature to 150 170 C The hot air circulating in the oven reduces moisture loss and shrinkage Roasting times are reduced by approximately 10 minutes per kg compared to a conventional oven Cleaning ALWAYS TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG BEFORE CLEANING THIS OVEN IS NOT WATERPROOF DO NOT USE A WATER JET SPRAY TO CLEAN THE INTERIOR OR EXTERIOR OF THE OVEN OR USE A WATER JET IN THE VICINITY OF THE OVEN Exterior Clean with a good quality stainless steel cleaning compound Do not use harsh abrasive cleaners as this could damage the surface finish Interior Ensure that the oven chamber is cool Do not use wire brushes steel wool or sharp utensils Clean the oven regularly with a good quality oven cleaner Take care not to damage the fan or the tube at the top of the oven which controls the thermostat Oven shelves To remove slide out to the stop position raise the front edge up and lift out Clean with hot water and detergent Oven door glass To remove slide out of slots in door Clean with a good quality glass cleaner Trouble shooting No power to the oven Check supply socket is switched on Check fuse and circuit breaker Check green power indicator is illuminated Thermal cutout has Allow to cool If the thermal cutout operated operates repeatedly then have the oven
7. lack Bn Brown Bu Blue Gn Y Gn Y Green Yellow Or Orange W White Y Yellow INLET TERMINAL BLOCK SPARES LIST ALWAYS TURN OFF THE POWER SUPPLY AND REMOVE THE PLUG BEFORE REPLACING ANY PARTS 082558001 Thermostat Vo 926016900 Lampassembly Mo 081797200 7 7 Customer helpline For spares and after sales service please contact Burco on T 0844 815 3755 F 0844 815 3748 E info gdha com Glen Dimplex Professional Appliances A Division of Glen Dimplex Home Appliances Stoney Lane Prescot Merseyside L35 2XW www burco co uk GLEN DIMPLEX PROFESSIONAL APPLIANCES 082756502 07 2011
Download Pdf Manuals
Related Search