Getting to grips with hoisting
Contents
1. J Hoist brakes OFF unless otherwise specified in manufacturer s instructions No gt L Unlock hoist brakes V YES unless otherwise assessed oO Sling loops clips attached securely and correctly to hoist Nop O Re attach and re check Y YES 2 O Sling safety harness belt secured if there is one Nop O Fit as per handling plan Y YES O Person looks safe and comfortable O Sling smooth under person L_ Sling leg configuration correct No gt oO Re fit sling a Vv Yes J Person s legs safe distance from mast nop J Turn spreader bar Y YES giving person more leg room O Hoist with hoist legs widened unless handling plan states otherwise until straps tight L Recheck person is safe comfortable and correctly positioned L Start full hoist oO Person s position correct Are they comfortable No gt oO Hoist again then reposition WY YES LI Detach sling from hoist LI Remove sling if applicable ensuring person left in safe position ee Y YES m L Hoist amp sling suitable for next use ie clean undamaged nop LI Clean hoist and or report damage and or launder sling Yy YES following organisational procedures HO Store hoist in suitable safe place HO Recharge hoist if applicable Figure 1 Checklist using a mobile hoist 7 of 8 pages Health and Safety Executive Further reading The Guide to the Handling of People a syst2. show that two handlers are required one to operate the hoist the other to help steady things and where needed support the person s lower legs to keep them in a safe position when moving from one place to another Importantly they can also provide direct reassurance to the person being hoisted to maintain their co operation and reduce the likelinood of them contributing to unstable movement Case example Mrs W had been resident in a nursing home for two years She was unable to weight bear or move independently While being hoisted from a bath by a new care assistant who had not received training and had not used that particular type of hoist and sling before Mrs W slipped from the sling and fractured her shoulder She died as a result of a subsequent pneumonia infection The hoist and sling used required active participation of the resident and was not suitable for Mrs W or for hoisting from a bath Risk assessments and procedures for manual handling and bathing had in general not been brought to the attention of care assistants and supervision was inadequate The company was prosecuted and fined 90 000 What should I do The person Consider whether a hoist is the most suitable handling aid and if so devise a handling plan to match the individual s ability and meet their needs and those of the workers involved It should specify the appropriate hoists and slings for the individual and the type of transfers required I
3. to date moving and handling training including hoist training J Feel confident to use hoist Nop DO NOT USE V YES Check with supervisor oO Current and relevant person specific handling plan for using hoist Nop WV YES LI Person s condition ability same as when they were assessed for this equipment L Do you have consent Nop gt W YES LI Number of handlers available as per handling plan no gt Y YES J Familiar with this specific hoist amp sling No gt Y YES ENVIRONMENT Area safe for hoisting ie No gt x Ll sufficient space clear of obstacles access around under furniture _ clean dry Vv YES HOIST J Familiar with emergency stop and lowering systems Nop w Y YES cc Q SLING _ Sling compatible for use with this hoist Nop oa Y YES O Sling is one identified in handling plan and is still appropriate Nop ie right size and type cross reference with care plan Y YES Visual check made of sling ie clean and undamaged _ label legible SWL clearly displayed unique identifier No LILOLER examination service up to date 6 monthly Y YES Visual check made of hoist ie noD E battery charged O LOLER examination service up to date 6 monthly H no obvious signs of damage E hoist moves freely on castors backwards and forwards L base adjustment and lifting lowering mechanisms move freely oO emergency button set in correct position oO SWL clearly displayed and not exceeded
4. unless you have had the necessary training m Check the correct hoist and sling specified in the handling plan are available and servicing and thorough examination are in date m Ensure the equipment works and is free from observable defects before starting E Hoists and slings must not be adapted or misused E Before each use check the hoist and sling in accordance with the equipment manufacturer s guidance on inspections and pre use checks E Familiarise yourself with the hoist s emergency lowering systems m Check there is a sufficient number of handlers to carry out the task safely in accordance with the handling plan m Ensure the environment is free from obstacles and the floor free of slip and trip risks m Ensure the support surface is ready and safe to receive the person m When manoeuvring the hoist into position to connect to the sling bring the spreader bar carry bar down slowly holding where necessary to avoid contact injuries with the individual m if there are any concerns about the equipment task person environment etc handlers must follow organisational procedures immediately E Communicate with everyone involved in the task at all times m Ensure safety and comfort of the person at all times m Reassure the person at all times and involve them as much as possible m Prior to raising check the sling is positioned correctly and double check the sling attachments m Hoist the person just above the
5. Health and Safety Executive Getting to grips with hoisting people A short guide from the sling For example access toileting slings give a great degree of access but very little support This information sheet explains the problems and their use should therefore be restricted to associated with hoisting people and sets out guidance toileting purposes where appropriate to deal with them It covers fixed mobile and E Incompatibility of the hoist and sling resulting overhead hoists The advice is intended for health and in insecure attachment between the two For social care providers or other organisations who move example incorrectly attaching a loop on a sling and handle people and will help them to comply with to a spreader bar designed for a clip attachment their legal duties or attaching a clip on a sling to a spreader bar designed to take a loop attachment Follow the manufacturer s advice and refer any concerns What are the issues about sling hoist design supply manufacturer s instructions or compatibility claims to the MHRA The use of hoists has become an integral part of the regulator for medical devices delivering health and social care services Although www mhra gov uk the use of hoists can reduce musculoskeletal risks E Failure of equipment due to poor maintenance you should consider the other risks associated with lack of inspection inappropriate laundering hoisting people Each year a significant number o
6. ems approach Sixth edition BackCare 2011 ISBN 978 0 9530 5281 3 Back in work Back pack 22 June 2010 www nhsemployers org HealthyWorkplaces MSDs Pages Backinwork backpack aspx Managing medical devices DB2006 05 Medicines and Healthcare products Regulatory Agency 6 November 2006 Further information For information about health and safety or to report inconsistencies or inaccuracies in this guidance visit www hse gov uk You can view HSE guidance online and order priced publications from the website HSE priced publications are also available from bookshops This guidance is issued by the Health and Safety Executive Following the guidance is not compulsory unless specifically stated and you are free to take other action But if you do follow the guidance you will normally be doing enough to comply with the law Health and safety inspectors seek to secure compliance with the law and may refer to this guidance This document is available at www hse gov uk pubns hsis3 pdf Crown copyright If you wish to reuse this information visit www hse gov uk copyright htm for details First published 06 11 Amended 12 11 Published by the Health and Safety Executive HSIS3 09 12 8 of 8 pages
7. f processes or as a result of inadequate repair or incidents are reported in which people have been modification injured while being moved using hoisting equipment m Leaving a vulnerable person unattended in a hoist Between April 2001 and December 2007 there were or in a position where they might be at risk of falling 163 hoisting accidents reported to the Health and from the bed or chair Safety Executive under the Reporting of Injuries E Hoist overturning when manoeuvring over difficult Diseases and Dangerous Occurrences Regulations surfaces transporting an individual over a long RIDDOR An average of 120 incidents per year are distance on a hoist or not following manufacturer s reported to the Medicines and Healthcare products instructions for use or safe systems of work Regulatory Agency MHRA E Not using the safety harness attachment if the sling specified for the individual has one The degree of injury varies depending on the vulnerability of the hoisted person the nature and consequences of the fall and what the falling person makes contact with Falls during hoisting have resulted in severe injuries from broken bones through to fatalities Note Sling sizes and coding varies between manufacturers There is a risk of using an inappropriately sized sling if you make assumptions without checking the suitability of a specific sling for the individual What can go wr ong For example two large slings from differen
8. g the potential risks how to use the specific equipment they have in their workplace and how to implement individual handling plans Health and Safety Executive It is important that supervisors also receive training so that they are able to monitor identify and correct poor practice There is no firm rule about how often training should be given However skills will inevitably deteriorate over time Provide update or refresher training periodically or when competency assessment identifies the need for further training You will also need to provide training when new lifting aids are introduced or there are changes to the method of work Case example An immobile 90 year old patient Mrs B suffering from dementia had been on a rehabilitation unit for some time following a fall She was assessed by a nurse as needing a small sized full body sling for all transfers in hospital No other patients on the ward at that time required the small sling and the sling was usually found in her wardrobe The sling had not been detailed on her moving and handling risk assessment or care plan which simply stated hoist for all transfers plus two people When two staff who had not been on duty for some weeks were getting the dependent patients up and washed they found the small sling in Mrs B s room Mrs B protested that it wasn t the right sling and that the sling had hurt her So instead they used the large full body sling wh
9. hoist to its docking station where appropriate for charging when not in use m Ensure the tracking and pathway is clear of obstructions E Be familiar with how freely the motor moves on the tracking E If using a portable lifting pod motor develop implement and follow guidance for a safe way of transporting and attaching m Do not drag the pod motor using the lifting tape as it may cause damage to the hoist Additional guidance for standing hoists m The person must be able to consistently and reliably bear weight through their legs and have sufficient upper body muscle strength sitting balance m The person must be able to co operate and physically participate in the hoisting process E Some standing hoists need using with care if the person has knee problems sensitivity or vulnerable skin on their legs 4 of 8 pages Additional guidance for slings Ensure the sling is compatible with the hoist Double check the loops clips are attached to the spreader bar throughout the hoisting procedure Use the correct loop clip configurations as identified in the handling plan Ensure the sling and attachments are not caught stuck on any equipment when starting the lift Additional guidance for bath hoists Make sure staff are fully trained on the specific bath hoist and with the equipment in the bathrooms For example height adjustable baths etc Ensure the environment is safe For example floors not slippery wet sufficient
10. ich was draped over the hoist to lift her from the bed to a commode During hoisting Mrs B slipped down through the access aperture in the sling and rapidly fell striking her head Mrs B died and the hospital was subsequently prosecuted and fined 20 000 plus costs for failing to ensure her safety because the correct sling size had not been communicated to staff nor did they know how to correctly size and select a sling for this individual The annexes to this guidance provide safety checks and other measures for employers and those hoisting people to consider to help them ensure safe handling Figure 1 provides a checklist for using a mobile hoist in the form of a useful flowchart 3 of 8 pages Annex 1 Checklist to help with hoisting The following checklist compiled by a group of manual handling professionals represents safe handling practice and will remind those hoisting people of points to consider to reduce the risk The list does not aim to cover every individual circumstance and assumes that the handler has received relevant and current training in the transfers and equipment used Checklist All hoisting tasks m Read the handling plan and ensure it is current and relevant m Review the person s condition prior to each transfer to ensure continued suitability for hoisting and the use of the equipment m Ensure the person s weight does not exceed the SWL of both the hoist and sling m Do not use the hoist sling
11. ies to ceiling track certain mobile hoists m the castors move freely ie free from carpet filbres fluff etc mobile and standing hoists and m the base adjustment hoist legs move freely mobile and standing hoists Slings Ensure E the sling is the correct size and type for the client and is fit for purpose E sling and hoist are compatible E all labels are legible and show the SWL and unique identifier and size m there are no signs of fraying tears or deterioration etc E all stitching is present and intact m the velcro if applicable is clean and free of filbres fluff etc m the buckle if applicable has no signs of damage etc E the loops clips have no obvious signs of damage fraying etc and m it has been cleaned Health and Safety Executive Environment Ensure E the environment is prepared for the task m there is sufficient soace and access around and under furniture to use the hoist safely m the floor is clear of obstacles eg trailing cables and m there is a suitable and safe area to store and charge if applicable the hoist If you identify a fault with either the hoist or sling withdraw from use immediately and follow the organisation s reporting procedures These guidelines have been developed in conjunction with National Back Exchange Yorkshire branch 6 of 8 pages Health and Safety Executive START THE TASK L Had up
12. space Using bath oils bubble bath lotion talc etc may make the surfaces slippery and affect the use of the equipment Check the temperature of the water Ensure correct fitting of lap strap also known as safety belt seat belt safety harness unless otherwise risk assessed Mobile and ceiling track hoists may also be used for bathing see mobile and ceiling track hoist guidance Health and Safety Executive 5 of 8 pages Annex 2 Equipment safety checks prior to each use m ls the equipment as specified in the handling plan m Do the hoist and sling have a CE mark on them m ls the person s weight below the SWL of both the hoist and sling m Are hoists and slings within LOLER thorough examination dates E Has the hoist been serviced in accordance with manufacturer s instructions E Has there been any change in the individual s circumstances since the handling plan was devised m Has a visual check of the equipment been carried out prior to using it m Is the environment ready m Is there sufficient space to use the hoist safely Hoists mobile electric and hydraulic ceiling track systems stand aid bath Ensure m the hoist is fully charged the battery and any leads are fitted correctly E there are no obvious signs of damage or fluid leaks from the hoist m the raise lower mechanism works and the emergency stop button is set correctly m the lifting tape is intact and not frayed appl
13. surface from which Health and Safety Executive they are being lifted to obtain sufficient clearance m Check attachments remain secure and the person is comfortable before proceeding further m If there are any problems lower the person into a safe position and seek further advice m Follow manufacturer s instructions and local policies and procedures with regard to care and cleaning of the hoist m Place battery powered hoists on charge as identified in the instructions when not in use or ensure back up battery is charged m Do not leave the person unattended in a hoist Additional guidance for mobile hoists m Avoid using the hoist to transport over distances thresholds or different surfaces unless otherwise stated in the handling plan m Do not apply brakes during hoisting with mobile hoists unless otherwise stated by the manufacturer and handling plan Note This does not apply to certain types of equipment where the brakes need to be applied for example standaids m Ensure hoist legs are in the most stable position E Store the hoist in a safe place with boom jib in lowest position and with brakes on when not in use Additional guidance for ceiling track overhead hoisting systems m The motor should be directly overhead and make sure the lifting tape is vertical to the lift to avoid wear and tear and or malfunction m Elevate the spreader bar to its highest possible position when not in use m Return the
14. t manufacturers may be different sizes the body of the sling may be a different length or People can fall during hoisting for a variety of reasons the number of loop attachments may differ resulting in a different Problems include lifting position Additionally sling designs can alter over time so a new sling from a manufacturer may differ in size or attachment strap re length from one previously purchased Some slings come with a m Selection of the wrong size sling resulting in range of different length loops for attachment to the hoist These discomfort if the sling is too small anda risk of the can be used to increase the comfort of the individual or put them person slipping through the sling if itis too large in a more reclined or upright position However you should take Em Selection of the wrong type of hoist or sling for great care to choose the correct loops for the individual so that they eae a eai are not at risk of slipping from the sling and to use the same loop the individual or for the specific task resulting n configuration on both sides to reduce the risk of the person falling inadequate support and increased risk of falling from the sling sideways 1 of 8 pages E Instability when moving someone on a mobile hoist resulting in them striking objects This is likely to cause injury especially to those with vulnerable skin and will increase the risk of a fall or overturn In many cases assessment will
15. t should also take into account the views and preferences of the individual being hoisted If in any doubt seek competent advice The handling plan should cover the range of activities where a person may require assistance with moving and handling eg transfers bed to chair into bath etc The plan should be easy to read and clearly state the control measures for moving and handling the individual including specific equipment needed techniques to be used number of handlers required sling attachment loops to be used and where applicable leg configurations etc Health and Safety Executive Examples of a patient moving and handling assessment form and safer handling plan can be found in the All Wales NHS Manual Handling Training Passport and Information Scheme http www wales nhs uk documents NHS_manual_ handling_passpor pdf The equipment Lifting equipment is subject to additional requirements including a thorough examination by a competent person Hoists and slings are medical devices and the equipment manufacturer is required to provide suitable instructions for use including compatibility information and guidance on the checks you should carry out before each use The staff Share the handling plan with all those involved to ensure that workers know how to handle each individual They may also be able to contribute to the development of the handling plan to ensure the chosen options are workable Make sure tha
16. t staff are trained in the specific equipment and techniques so that they have the skills and competence to carry out the handling plan and understand the risks and measures to control them The Management of Health and Safety at Work Regulations 1999 require employers to have access to competent persons who can assist them in the measures needed to comply with health and safety requirements Employees have duties too they should m follow appropriate systems of work as identified for individuals in their handling plan and use the equipment provided E co operate with their employer and let them know of any problems and m take care to ensure that their activities do not put others at risk The lift Before hoisting undertake an assessment of the risks taking account of the individual s handling plan and put in place actions to reduce the risk of injury Lifting operations should be properly planned and carried out in a safe manner in accordance with the Lifting Operations and Lifting Equipment Regulations 1998 LOLER The Workplace Health Safety and Welfare Regulations 1992 require those in control of workplaces to make sure that floors and traffic routes are maintained in good condition and free from obstructions and that there is suitable lighting and ventilation in the workplace 2 of 8 pages Maintenance Ensure there are adequate systems in place for maintenance and inspection of hoists and slings in line with
17. the manufacturer s instructions the Provision and Use of Work Equipment Regulations 1998 PUWER and LOLER The MHRA device bulletin on managing medical devices DB2006 05 gives some guidance on this topic LOLER Where lifting equipment including hoists and slings is used by people at work the Lifting Operations and Lifting Equipment Regulations apply In addition to routine maintenance and servicing LOLER requires lifting equipment to be inspected and thoroughly examined Thorough examination by a competent person is required either at six monthly intervals or in accordance with a written scheme of examination drawn up by a competent person A competent person is someone with the relevant technical knowledge and practical experience of lifting equipment to enable them to detect defects or weaknesses and to assess their importance in relation to the safety and continued use of the specific equipment being examined Monitoring Check that handling plans are being followed and revise and update if the needs of the individual or other factors affecting the plan change Training Employers need to make sure that staff receive adequate training and information on people moving and handling Practical training has an important role to play in ensuring that staff have the skills and confidence to hoist people safely In addition to practising equipment selection and use staff need to understand the principles of hoistin
Download Pdf Manuals
Related Search