User Manual
Contents
1. received from the freight carrier After opening of boxes concealed damage should be noted and reported immediately to Dansereau and the freight carrier All freight is shipped FOB Corona CA and although Dansereau is not responsible for the damage we will Support you in all claims and will send replacement parts immediately PRODUCT RETURNS Dansereau manufactured products are custom made and all orders are non cancellable WARRANTIES Dental chair electric motors wiring harnesses oil less bushings base and chair frame integral parts 10 years 5 Years 100 5 Years Prorated accordingly 3 SIMPLE ASSEMBLY GUIDE Remove Chair Base from Pallet Locate Molex Connectors 5 Under Chair Toe Remove Chair Top from Box Plug Molex Connectors Together 2 and Insert in Hole in Chair Frame Insert Seat Back Bolt Thru Yoke and Motor Shaft D DO NOT REMOVE THIS 3 AND WASHER Remove Upper Base Cover 4 Screws Plug Chair into Power Source and Raise Chair REMOVE THIS NUT Bottom of Chair AND WASHER Set Seat on Chair Base Thread on ALL 4 BOLTS to Align the Bolts thru Holes secure Chair Top to Chair Base 2 In the Front and 2 in the Back Re install Upper Base Cover Dental Chair is Assembled OPERATING INSTRUCTIONS Push to Activate lt Seat Back Forward amp Back Seat Back Push to Activate Controls Chair Base Up amp Down Push to Activate Auto Exit Feature SPE2. splashing water NLS etis erc ti Lom WARNING TN ention Consult accompanying documents THIS DEVICE SHOULD BE CONNECTED TO HOSPITAL GRADE OUTLETS FAILURE TO DO SO MAY RESULT IN C OFF _ ELECTRICAL SHOCK DUE TO IMPROPER GROUNDING u 2 ATTENTION ON CET APPAREIL ETRE BRANCHE A UNE PRISE DE E TERRE ADEQUATE i 27 f ADVERTENCIA equipment R ESTE DISPOSITIVO CONECTARSE NICAMENTE Protected against electrical shock TOMACORRIENTES DE GRADO HOSPITALARIO 51 AS PUEDE PRODUCIRSE UN CHOQUE EL CTRICO A CAUSA DE UNA PUESTA A TIERRA INADECUADA 2 Dangerous voltage 70 22090 5 11 CALIFORNIA DENTAL CHAIR ASSEMBLY GUIDE Table of Contents 1 Terms Conditions Testing Labs Specifications 2 Labeling and Technical Description 3 Procedures and Policy 4 Simple Installation Guide 5 Operation Features 6 Care and Maintenance of Surfaces and Cushions 7 Chair Specs and Measurements 8 Warranty PAYMENT PROCEDURES Personal and Business Checks Master and Visa Credit Cards Wire Transfers Cashiers Checks and Money Orders DAMAGED FREIGHT Dansereau utilizes superior packaging procedures however shipping accidents can occur It is your responsibility to note any unusual conditions or subsequent damage to the shipping crate on the Bill of Laden prior to acceptance and signa ture for the product
3. 2716 DENTAL CHAIR SPECIFICATIONS Lift Patient Capacity 400Lbs Dental Chair Weight 360lbs Dental Equipment Classification B Inside Use Only IPX4 DANSEREAU HEALTH PRODUCTS INC AMERICA S DENTAL EQUIPMENT COMPANY TECHNICAL DESCRIPTION The dental chair is used to position the patient so the oral cavity is in the desired position for the dentist to perform various dental procedures The Dental chair is electromechani cally operated There are two dynamic functions the base up down and the back forward back These functions are activated by use of either a foot switch or hand operated touch pad The dental chair has the provision to mount additional dental equipment over the patient delivery system refer to following sections for more information therefore a stable base is included with the dental chair to accommodate such additions Power to the chair is either 115volts or 230volts The power is delivered at 115volts directly to the circuit board microprocessor 230volts is delivered thru a 230 transformer and to the circuit board microprocessor Software in the microprocessor controls the movement of the dental chair The dentist can program preset positions with this dental chair The dental chair is classified as a Class 1 product under rule 1 of Annex IX of the MDD 93 42 EEC accordingly the provisions of Annex VII apply NOTE Regarding International Electrical Specification Dansereau does not supply provi
4. America s Dental Equipment Company Clinic Operatoru Owners uide e Dansereau 800 423 5657 WWW DHPDENTAL COM 2 15 DANSEREAU HEALTH PRODUCTS INC AMERICA S DENTAL EQUIPMENT COMPANY Dansereau Health Products Inc has been manufacturing Dental Equipment for over 40 years We have compiled a significant amount of data and information regarding the manu facturing use and maintenance of dental equipment Information contained in this manual will assist you in use and maintenance of your Dansereau equipment We offer the most comprehensive 10 year warranty on USA manufactured dental equipment today Our Customer Service Department is the most progressive within the dental industry with an ever growing series of support documents and video available thru Email and the Inter net They are easily accessible and completely descriptive for the dentist staff or any tech nician to use in the long term support of Dansereau Health Products Inc SUPPORT ACCESS Dansereau Health Products Inc 1581 Commerce Street Corona CA 92880 Toll Free 800 423 5657 Phone 951 549 1400 Fax 951 549 1411 Website WWW DHPDENTAL COM TESTING LABORATORIES ETL Testing Lab Report 530937 Medical and Dental Equipment Catelgory 6 UL 544 2nd Ed CAN CSA Testing Laboratories Report 531003 Canadian Standard for Medical Electrical Equip No 601 1 M90 US Food and Drug Administration Medical Device Registry 20
5. CIAL NOTE Right Side of Chair is a Locking Switch Left Side is Momentary SPECIAL NOTE If the Auto Return Button is in its Locked Position and another button is depressed you may Blow the Fuse See Below how to reset the fuse California Chair Reset Fuse Correct Position If Button is out Firmly Press in to correct position Foot Controls Push to Activate Chair Base Up amp Down Push to Activate Seat Back Forward amp Back CALIFORNIA CHAIR PARTS California Chair Pillow DA1131 P 95 California Chair Headrest Pad DA1131 C P 75 California Chair Arm Slings California Chair DA1123 AS 90 Seat Back Cushion DA1136 250 California Chair Seat Cushion DA1136 SC 300 California Chair Pivot Pin Assembly DA1152 PA 65 California Chair Toe Cover DA1136 TC 25 California Chair Pa Upper Base Cover DA1145 U 95 gy n California Chair Lower Cover 1145 L 165 California Chair Base Plate Cover California Chair DA1146 165 Reset Fuse DA California Chair Internal Parts 1 Chair Top Motor 2 e Gi Mot California Chair Base Motor Momentary D Swi N witch 3 Limit Switches DA 4 Wiring Harness California Chair Locking Switch DA NOTE Prepositioning Circuit Board is Optional Item on Ch
6. air Contact Dansereau for Parts A Touch Pad Switches DA CLEANING amp DISINFECTING DENTAL EQUIPMENT Infection control in the dental facility continues to be a high priority for all staff working within the dental office OSHA the ADA and CDC are all involved in this complex is sue Dansereau will not attempt to specify the required intervals for disinfection nor can they recommend the overall best surface disinfectant You can refer to the appro priate organizations for more information on disinfecting your dental equipment Techniques Barrier Technique Dansereau does advocate the barrier technique whenever possible the use of dispos able barriers with changes between patients will ensure the finish and appearance of your Dansereau dental equipment will be preserved Chemical Disinfection If Chemical Disinfection is the disinfection method of choice it is imperative that a mild soap and warm water be used once per day to mitigate the residual effects of Chemi cal Disinfection Solutions When using Chemical Disinfection Solutions always pay strict attention to use detail including appropriate measurements when using concen trated disinfection solutions Disinfection Solutions used in the recommended strength can be relatively harmless to the surface of your Dansereau dental equipment Unacceptable Disinfectants Disinfectants with the following compositions will harm the surface finishes of d
7. ental equipment and are not recommended Use of these products will void your warranty Chemical Composition Chemical Composition Strong Phenols lodophors Phenol Alcohol Combinations Mild Phenols Sodium Hypochlorite Household Bleach Glutaraldehyde Phenol Sprays Alcohol Alcohol Based Wipes oynergized Super Quat Household Cleaners Phenol Water Sprays Damage and discoloration of the surface finishes caused by disinfectants are NOT covered by warranties lodophor based disinfectants will cause yellow staining on many surfaces Regular washing with soap and water will minimize this staining lodophor neutralizers such as Promedyne are also available 6 CALIFORNIA DENTAL CHAIR DIMENSIONS 4 AMP FUSE CALIFORNIA CHAIR SPECIFICATIONS emeng quuni mii oe amt SPECIFICATIONS CHAIR BACK MOTOR 115V 60HZ 1 8 HORSEPOWER SINGLE PHASE THERMALLY PROTECTED TIME RATING INTERMITTENT DUTY 2 AMP BASE MOTOR 115V 60HZ 1 3 HORSEPOWER SINGLE PHASE RPM 3250 THERMALLY PROTECTED CAPACITOR 68 MFD 440V TIME RATING INTERMITTENT 4 AMP RESET FUSE MOUNTING DELIVERY SYSTEM ON DENTAL CHAIR Remove Delivery System from Box careful as Delivery System is Top Heavy Delivery System weight about 7516 Raise Chair to highest position Slide the Mounting Plate under the chair steel plate and insert and tighten the 5 Bolts for attaching the delivery system to the dental A ratc
8. het will be required to tighten the bolts TELESCOPING ARM INSTALLATION 2 Insert Telescoping Arm Pin into the N Telescoping Arm Bracket on the Unit Post Insert HVE Tubing into Amalgam Cannister and Hang HVE Saliva ejector and syringe on assistants package Dental Junction Box Ready for Installation of Dental Equipment Chrome Angle Stops with Vacuum Line Dansereau 3 8 Compression Fitting supplies fitting NOTE If you Dental Junction Box Plumbing and Electrical DOES NOT look like this you are not ready for installation of your Dental Equipment DENTAL JUNCTION BOX INSTALLATION gt Dental Junction Box Remove Lid Insert Master Valve Into Tighten Angle Stop Nut 3 8 Angle Stop Fitting with Open End Wrench Make Sure Master Valve is completely inserted Vacuum Tubing Hose Fitting Insert Vacuum Tubing on to the Hose Fitting Installed Vacuum Line Lubricant will assist Attaching Dental J Box to Floor can be done either with Screws or Double Side Tape Recommended DENTAL LIGHT INSTALLATION Remove Dental Light Slide Light Cord down Light Arm is properly Arm from Box Careful thru the post You may seated on the light itis a spring arm need to us a pull wire post Remove Light T Head from Connect Light Slide Connector Align Holes and Head to Light and Light Hub Insert Screw with Arm Connection into Light Ar
9. m Allen Wrench CAUTION Make sure Light Collar is on prior to attaching light connections DENTAL LIGHT TRANSFORMER INSTALLATION Mount the Transform under the Delivery system Mounting Plate Plug the light cord into the dental light transformer plug Make sure the pins align properly and make good connection If the Transformer Plug is not plugged into the Dental Chair Outlet proceed with the plugging into Dental Chair Outlet WIRING SCHEMATIC NO PRESET SEAT WIRING CA ul HHH v ene 1 LS 71 Cl d E 3 MICRO BASE WIRING CA HANNING MOTOR ma CHAIR CA SWITC R HES WIRING 100 50 00 WIRING SCHEMATIC WITH PRESET n RED w wt Le RED TO LIMIT SWITCH UP pen Fees mam ls BLUE TO SWITCH DOWN WHITE s ooo BROWN RED GREEN PREPOSITION RELAY BOARD YoU ono VON WEISE MOTOR BLACK HE POWER LINE WITH PREPOSITION CALIFORNIA MANUFACTURER S WARRANTY Dansereau has the most comprehensive product warranty programs avail able to the dentist today We offer a 10 Year Warranty on our Dental Chairs complete features listed below Upon Installation you Dental Chair is registered automatically with the Dansereau 10 Year Warranty 5 Years 100 6 10 Years Prorated Annually Dental Chair Electric Motors Chair Ba
10. se Frame Chair Frame and Wiring Harness s 1 Year 10026 Circuit Board and Prepositioning Switches 6 Months 100 Dental Chair Cushions Seam s and Foam Broken or User Damaged are Not Covered under Warranty Minimum Maintenance is required in order to guarantee full use of warranties Dansereau Dental Chairs do not require any lubrication or service Dental Cushions will require routine cleaning in order to maintain asepsis in the Dental Office care shall be taken to use approved cleaning solutions in order to maintain the finish and integrity of the dental seating GUARANTEE Dansereau will guarantee against defects in material and workmanship Defective parts will be repaired or replaced no claim for labor or conse quential damages will be allowed All replacement parts claimed defective will be filled in the usual manner such invoice being subject to adjustment after the alleged defective material has been returned and inspected by the manufacturer The warranty does not cover damage resulting from im proper installation maintenance accident or misuse
11. sions for international power requirements This will be configured by the equipment dealer in the country of destination SAFETY AND IDENTIFICATION MARKINGS CAUTION Failure to carefully follow the Safety Labels described procedure may result in damage to the equipment RISK EXPLOSION IF USED JN THE 2 PRESENCE OF FLAMMABLE ANESTHETICS gt WARNING Failure to carefully follow the amp RISQUE O EXPLOSIGN FN PRESENCE DE descri rocedure ma result in damage to PRODUITS ANESI HETIOUES INFLAMMABLES SSC bed 771 RIESGO DE EXPLOSION SI SE UTILIZA 4 the equipment and operator PRESENCIA DE ANESTESICOS INFLAMABLES Ji ELECTRIC SHOCK HAZARD DO NOT REMQUE REFER SERVICING QUALIFIED d Risk of electrical snock present Make sure SERVICE PERSONNEL 44 power disconnected before attempting this RISQUE Q ELECTROCUTION NE PAS OUVRIR procedure LE COUVERCLE FAIRE APPEL UN TECHNICIEN QUALIFI RIESGO CHOQUE ELECTRICO NO QUITE LA IEC Symbols CUBIERTA CONTRATE EL SERVICIO CON PERSQNAL DE SERVICIO CALIFICADO The following symbols conform to labeling standards gt be located throughout the product gt CAUTION gt d WA CAUTION Alternating Current See Definitions of Symbols section Protective earth Ground IPxy Protected against
Download Pdf Manuals
Related Search