Home

Manual

1. Wash the filter thoroughly in mild soapy water Let it dry well Soften the filter in pure 2 stroke oil and squeeze the filter for redundant oil Putthe filter back in its place and fit the lid Filter Inlet Top Make sure the filter is turned the right way when refitted Air filter Make sure the cover is turned the right way when refitted Must be fitted as shown on the picture to the right 6 2 Fuel filter Dismount the house Disconnect the filter and washer from the house Clean the filter and the house as shown on the drawing If necessary replace the filter Filter Fuel cock SN Rubber washer KA a me SEE e p Sludge w e R house i gt i e i E 7 Specifications Dimension LxWxH 360x310x360 mm Engine Cooling Fan Fuel tank capacity 4 Itr 2 stroke gasoline Motor 63 cc Spark plug NHSP LD FGRTC 0 7 0 8 Generator Volt V 230 Frequency Hz 50 pe Ampere A 2 8 Effect KVA 0 65 Max effect KVA 0 80 DC out 12V 8 3A Steering system Automatic volt regulator AVR Max charge 12 hours constantly 20 8 Trouble shooting If the engine does not start check the following 1 Are there sufficient fuel in the tank If Not Add fuel 2 Are there any sparks from the spark plug If Not Replace the spark plug If the engine still does not start after these tests and changes you must cont
2. 2004 2 DK Betjeningsvejledning GB User manual Generator TGH 800 Texas A S Knullen 2 DK 5260 Odense S Denmark Tel 45 6395 5555 www texas dk post texas dk ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL ADVARSEL L s altid betjeningsvejledningen f r brug af din generator Brug aldrig generatoren i et lukket lokale omr de Udst dningsgas kan medf re kv lning Udst dningsr ret bliver meget varmt under brug V r opm rksom p ikke at r re ved udst dningsr ret umiddelbart efter brug Brug kun godkendte kabler Benzin er meget brandfarligt v r derfor forsigtig med p fyldning af br ndstof P afyld ikke benzin p en varm motor eller i n rheden af ben ild t ndte cigaretter gl der eller lignende T r altid spildt benzin grundigt op N dstr msgeneratorer til bygninger m kun tilsluttes af en autoriseret elektriker som skal rette sig efter de g ldende love Ukorrekte tilslutninger kan for rsage at str m l ber retur til generatoren Dette kan medf re at personer der kommer i kontakt med generatoren kan f elektrisk st d Efter str mmen er genoprettet kan generatoren eksplodere br nde eller medf re brand i det elektriske system Afbryd altid alle tilslutninger f r du starter maskinen Dette kan forebygge uheld Placer altid generatoren mindst 1 meter fra bygninger eller and
3. F 5 Brug af generatoren ADVARSEL For at forebygge elektrisk chok skal generatoren jordes G res kun ved station r generator Dette g res ved at forbinde generatorens stel udgang med et stel forbindelse f eks et jordspyd Monteres p jordsymbol ved stelforbindelse p generatoren BEM RK Forbind ikke generatoren til et system i f eks et hus hvor der i forvejen er elektricitet Dette kan medf re skader p b de kredsl bet og generatoren Foretag ikke ndringer p generatoren Forbind ikke flere generatorer en parallelforbindelse Forl ng ikke udst dningen p generatoren Under brug m du ikke placere generatoren i n rheden af andre elektriske kabler 5 2 Overbelastning Hvis generatoren bliver overbelastet vil generatorens rel sl fra Samtidig vil str mmen til apparatet blive afbrudt I tilf lde af dette stop generatoren og unders g kilden til overbelastningen Rel et sl r automatisk til n r generatoren er k let af uti G tid i 5 3 J vnstr m 5 3 1 Forbind ladekablerne p DC udtaget p generatoren forbind med de retm ssige poler p batteriet Plus til Plus og Minus til Minus 5 3 2 Start generatoren Monter rgd til plus og sort til minus a sail BEMARK 12 V udtaget p generatoren m kun bruges under overv gning til opladning af 12 V batterier ADVARSEL For atforhindre risikoen for at skabe en gnist n r batterie
4. TALLAT R LAD lt tid AS 6 1 Luftfilter ADVARSEL Brug aldrig benzin eller anden brandbar v ske til at rense luftfilteret med FREMGANGSM DE Vask skumfilteret grundigt i mildt opvaskevand Lad luftfilteret t rre grundigt V d filteret i ren 2 taktolie og pres det overskydende ud med fingrene S t filteret p plads i holderen og monter l get S kumfilter Indsugning Top V r opm rksom p at luftfilteret vender rigtigt n r det monteres igen Luftfilter V r opm rksom p at d kslet vender rigtigt n r det monteres igen Det er vigtigt at den vender som p billedet til h jre 6 2 Br ndstoffilter Afmonter huset Adskil filter og pakning fra huset Reng r filteret og hus som vist p tegningen Udskift evt filteret Br ndstofhane 7 Specifikationer Filter Slamhus Dimension og v gt LxBxH 360x310x360 mm Motor K ling Bl serk let Br ndstoftank kapacitet 4 Itr 2 takt benzin Motor 63 cc T ndr r NHSP LD FGRTC 0 7 0 8 Generator Volt V 230 Frekvens Hz 50 AC ud Ampere A 2 8 Effekt KVA 0 65 Max effekt KVA 0 80 DC ud 12V 8 3 A Styresystem Automatisk volt regulator AVR Maksimal belastning 12 timer konstant 8 Fejlfinding Hvis motoren ikke starter unders ges f lgende 1 Er der br ndstof i tanken Hvis nej P fyld br ndstof 2 Er der gnist
5. act your local dealer 21
6. et udstyr under brug V r opm rksom p hvordan generatoren stoppes og forst alle funktioner Overlad aldrig brugen af generatoren til personer der ikke har modtaget instruktioner om brugen Hold b rn v k fra generatoren under brug Brug af generatoren med v de h nder kan medf re elektrisk st d Brug ikke generatoren i regn eller sne S rg altid for at generatoren ikke bliver v d 1 Indholdsfortegnelse 2 Kontrolpanel 4 3 F r start olie 4 3 2 F r start luftfilteret 5 3 3 F r start jord 5 4 Start rekyl 5 5 Brug af generatoren 6 5 2 Overbelastning 6 5 3 J vnstr m 7 5 4 Stop 7 6 Vedligeholdelse 8 6 1 Luftfilter 9 6 2 Br ndstoffilter 10 7 Specifikationer 10 8 Fejlfinding 11 Reservedele Reservedelstegning over det p g ldende produkt findes p vores hjemmeside www texas dk Finder du selv varenumre giver det en hurtigere ekspedition For k b af reservedele kontakt venligst din n rmeste forhandler Du finder forhandlerliste p Texas hjemmeside lt tid AS 2 Kontrol Panel 230 V udtag Termo rel sikring On off Panel til luftfilter Choker Br ndstofhane 3 F r start Olie P fyld br ndstof blandet med olie Anvend blyfri oktan 95 Der anvendes alm to takts olie i forholdet 25 1 Ved brug af Motex 2TX olie er forholdet 50 1 2 Blandeforhold I l get til tanken er der monteret en 1L 0 02L blandekop brug forhold som er vis
7. filter Check that the air filter is clean and in good condition Never use the generator without the air filter This will lead to dirt being sucked into the carburetor of the engine 3 3 Before start Grounding Before use the generator must be grounded However this only applies for a stationary generator Connect the ground take off on the generator with a frame connection e g an earth auger Not included Must be connected to the grounding symbol on the frame connection of the generator 4 Start Recoil Disconnect all connections to the generator before start Before use the generator must be grounded However this only applies for a stationary generator Connect the ground take off on the generator with a frame connection e g an earth auger Not included Must be connected to the grounding symbol on the frame connection of the generator Open the fuel cock O Open Turn the choke to ON left Turn the engine switch to ON Pull slowly in the starting cord of the engine until you feel resistance Thereafter you pull one heavy long draw Never let the starting cord run back by it self always follow it with your hand Let the engine run for et short time then turn off the choke to the right OFF Choke ON Choke OFF 5 Use of the generator Before use the generator must be grounded However this only applies for a stationary generator Con
8. fra t ndr ret Hvis nej Udskift t ndr ret Hvis motoren stadig ikke starter efter ovenn vnte tests og evt udbedringer skal du tage kontakt til et autoriseret v rksted WARNING WARNING WARNING WARNING WARNING WARNING WARNING WARNING WARNING WARNING WARNING WARNING Always read the user manual thoroughly before using the generator Never use the generator in a closed room area Exhaust may cause suffocation The exhaust pipe becomes very hot during operation Do not touch the exhaust pipe after use Only use approved cables Fuel is very flammable be careful when filling with gasoline Do not fill when you are close to open fire lighted cigarettes sparks or similar Always clean up spilled gasoline Standby power generators for buildings must only be connected by an authorized electrician who must comply with the regulations in question Incorrect connection can make the power electricity run back to the generator This can cause an electric shock if a person gets in contact with the generator After the power has been restored the generator may explode burn or cause a burn in the electric system Always inspect all connections before you start the machine This can prevent an accident Always place the generator at least 1 meter away from buildings or other equipment during operation Draw attention to how the generator is to be stopped and understand all its funct
9. g batteries which are still mounted in cars itis important that the frame cable has been removed from the pole of the battery After charging the frame cable shall be connected to the correct pole This procedure prevents the risk of a short circuit between generator and the chassis of the car NOTE Do nottry to start a car while the generator is connected to the battery of the car The generator may be damaged Always check that the generator has been correctly connected to the battery Always respect the indicated instructions for use of battery 5 4 Stop 1 Turn the apparatus off and remove the plug from the generator Turn the generator off on the ON OFF Turn off the fuel 17 6 Maintenance The purpose of the maintenance is to keep the generator in its best possible shape Repairs should always be carried out by an authorized Texas Dealer Every Every month Every 3 month time Part or or 50 hours 150 hours Fuse Check X i X ANNET Clean A Replace if necessary i X Fuel filter Clean Replace if necessary Check should be carried out more often ifthe generator is being used in dusty areas Major improvements or repairs must be carried out by your local dealer who must be instructed by an electrician LAD lt tid AS 6 1 Air filter Never use gasoline or other flammable fluids to clean the air filter PROCEDURE
10. ions Never leave the use of the generator to persons who have not received any instruction about the operation Keep children away from the generator during operation Using the generator with wet hands may lead to electric shock Never use the generator in rain or Snow Always make sure that the generator does not become wet 12 1 Contents 2 Control panel 14 3 Before start fuel 14 3 2 Before start air filter 15 3 3 Before start grounding 15 4 Start recoil 15 5 Use of the generator 16 5 2 Overload 16 5 3 Direct current 17 5 4 Stop 17 6 Maintenance 18 6 1 Air filter 19 6 2 Fuel filter 20 7 Specifications 20 8 Trouble shooting 21 Spare parts Part list and explosive drawings for the specific product can be found on our website www texas dk If you help find part numbers yourself it will ease the service For purchase of spare parts please contact your dealer 2 Control Panel lt tid AS 230 V output Thermo relay fuse 3 Before start fuel On off Panel for air filter Choke Fuel cock Tank fuel mixed with oil Use regular unleaded gasoline octane 95 Use ordinary two stroke oil mixed 25 1 4 When using Motex 2TX oil the mix is 50 1 2 Mix LL 0 02 L 2L 0 04L 3L 0 06L 4L 0 08 L CoMo Co Qo The lid of the tank may be used as a mixing cup See drawing to the left 3 2 Before start Air
11. nect the ground take off on the generator with a frame connection e g an earth auger Not included Must be connected to the grounding symbol on the frame connection of the generator Donotconnect the generator to a closed system in e g a house This may cause damages on both the circuit and the generator Donotmake any amendments to the generator Do not connect more generators in a parallel connection Do not extend the exhaustion on the generator During operation you must not place the generator close to any other electric cables 5 2 Overload If the generator is overloaded the relay will cut the circuit At the same time the power to the outlet plug will be disconnected In this case stop the generator and check the source of the overload The relay will connect automatically when the generator has cooled off 16 iN lt tid Ww 5 3 Direct current 53 3 Connect the charging cables on the DC output on the generator to the correct poles on the battery Plus to Plus and Minus to Minus 5 3 4 Startthe generator Connect red to plus and black to minus NOTE 12 V output on the generator must only be used for charging 12 V automobile batteries In order to prevent the possibility of a spark close to the battery you must first connect the charging cable to the generator and thereafter to the battery When dismounting start by dismounting by the battery When chargin
12. t forbind da f rst ladekablet med batteriet derefter med generatoren Afmonter f rst kablet ved generatoren Ved opladning af batterier der stadig er monteret i biler er det vigtigt at bilens stelkabel er fjernet fra batteriets pol Efter endt opladning monteres stel kablet p den retm ssige pol Denne procedure udelukker muligheden for en kortslutning mellem generator og bilens chassis Fors g ikke at starte en bil mens en generator er forbundet til bilens batteri Generatoren kan blive beskadiget Check altid at generatoren er rigtig forbundet til batteriet ADVARSEL F lg altid de foreskrevne regler for brug af batterier 5 4 Stop Sluk for redskabet og fjern stikket fra generatorens stik S t generatorens kontakt p OFF Luk br ndstofhanen 6 Vedligeholdelse BEM RK Form let med vedligeholdelsen er at holde generatoren i bedst mulig stand Reparationer b r altid blive udf rt p et autoriseret v rksted Hver gang 1 m ned hver 3 mdr Del eller eller 50 timer 150 timer T ndr r Check X AE Reg i Udskfthvis n dvendig Bee dl i Udskift hvis n dvendigt 1 Check b r udf res oftere hvis generatoren bruges i st vede omgivelser 2 St rre forbedringer og reparationer b r udf res p et autoriseret v rksted VED REPARATIONER P GENERATORANL G SKAL MEKANIKEREN V RE INSTRUERET AF EN INS
13. t i skemaet 2L 0 04L 3L 0 06L 4L 0 08L Coo Co Qo 3 2 F r start Luftfilteret Check at luftfilteret er rent og i god stand ADVARSEL Brug aldrig generatoren uden luftfilter Dette resulterer i at skidt og snavs bliver suget ind i motorens karburator 3 3 F r start J ord ADVARSEL F r brug skal generatoren jordes Dette g lder dog kun ved en station r generator Dette g res ved at forbinde jordingsudtaget p generatoren med en stel forbindelse evt et jordspyd DETTE MEDF LGER IKKE men skal monteres p jordsymbol ved stelforbindelse p generator 4 Start Rekyl ADVARSEL Afbryd alle tilslutninger til generatoren f r start ADVARSEL F r brug skal generatoren jordes Dette g lder dog kun ved en station r generator Dette g res ved at forbinde jordingsudtaget p generatoren med en stel forbindelse evt et jordspyd DETTE MEDF LGER IKKE men skal monteres p jordsymbol ved stelforbindelse p generator er for br ndstof hanen O ben S t chokeren til ON venstre Tryk motorkontakten til ON Tr k langsomt i motorens startsnor indtil der f les modstand Tr k derefter kraftigt i t langt tr k Lad aldrig startsnoren l be tilbage af sig selv f lg den altid tilbage med h nden Lad motoren k re kort tid hvorefter chokeren sl s fra til h jre S t chokeren p OFF Choker ON Choker OF

Manual

Contents

Download Pdf Manuals

Related Search

Related Contents