User Manual User Manual
Contents
1. 4 Lower body 4 Lower body 5 Grease collector 5 Grease collector 6 Lower grill 6 Lower grill 7 Feed wire protective tube 7 Feed wire protective tube 8 Upper grill 8 Upper grill 9 Handle 9 Handle 10 Power supply cord 10 Power supply cord 11 Rubber feet 11 Rubber feet 2 www AvantcoEquipment com EQUIPMENT VANTCO OLY am VEEL Notes 1 This product is intended for commercial use only 2 Do not disassemble or modify the machine 3 Lift the upper grill assembly smoothly jerking it up may cause damage or injury 4 Before cleaning disconnect power and allow machine to cool 5 Do not immerse in water or spray water onto the grills Water may cause short circuit and injury or damage 6 To avoid damage do not jam materials onto the grill or place heavy objects there 7 When the machine is in use the body and grill plates are hot and will cause burns if touched 8 Do not use an ungrounded power supply cord Cautions 1 It is recommended that the machine be unplugged during thunderstorms to avoid potential damage from nearby lightning strikes 2 Avoid damaging the controls or grill surfaces with sharp or heavy objects 3 Turn off power after daily use 4 Do not use the machine with a damaged power cord 5 Any internal repair or maintenance should be performed by a factory authorized repair technician Important Features 1 Convenient independent temperature controls are easy to set and may resu2. Grill plates do not heat even though power Defective controller Replace controller indicators are lit Defective heater s Replace heater s Temperature can not be controlled Defective controller Replace controller Heating appears normal but power indicators Defective indicator s Replace are not lit No action when power is turned on Defective fuse or open circuit Replace fuse or reset circuit breaker breaker Do not use the machine if any of the above occur Any troubleshooting corrections should be performed by a qualified technician Daily Check Before using the machine visually inspect for any signs of damage or frayed power cord Be certain machine is on a level countertop After turning it on check for anything unusual before you use it Inspect the machine every day before using If there is any question about operation do not use www AvantcoEquipment com 5 EQUIPMENT VANTCO 462 5 CO 15 Parts List Single Grill Power Light Temperature Control with Switch Screw M4x6 Heating Cycle Indicator Lower Case Internal Wrenching Screw M6x10 Flat Washer Internal Wrenching Screw M5x25 9 Flat Spacer 10 Torsion Spring 35 Handle 11 Rear Shaft 12 Shaft Retainer 13 Internal Wrenching Screw M6x40 14 Rear Upper Cover 15 Slotted Screw M4x8 16 Spring Pin 17 Ground Screw M6x15 18 Power Cord 19 Lower Grill 20 Upper Grill Co
3. Heater Wiring Guide Tube Guide Tube Retainer Retaining Ring Upper Platen Shaft Internal Wrenching Screw M6x8 Internal Wrenching Screw M6x8 Handle Handle Frame Oil Tray Bottom Insulator Slotted Screw M4x8 Barrier Strip Mounting Plate Slotted Screw M4x8 Ceramic Terminal Board Hex Head Screw M6x20 Hex Nut M4 Rubber Foot Rubber Heater Pressure Plate Bottom Heater Internal Wrenching Screw M6x8 Bottom Cover Phillips Head Screw M4x8 TA ETIE AVANTCO AC 120V 1 75kW 2 HUS HL2 2 NS ud EH1 EH2 Heating element HL1 Power indicator HL2 Heating indicator 8 www AvantcoEquipment com EQUIPMENT VANTCO OLY am VEEL I Ww o AC 120V 1 75kW 9 HL1 HL2 EHI 2 EH1 EH4 Heating element HL1 HL3 Power indicator HL2 HL4 Heating indicator www AvantcoEquipment com 9
4. indicator will cycle at set temperature 4 When set temperature is reached lift top grill using black handle and lightly grease grill plates with vegetable oil Place food on grill and lightly press handle down Excess oil will collect in the grease collection tray Remove food when cooked The heating elements will automatically cycle as needed 5 Turn machine off when no longer needed and unplug from power source Instructions for First Time Use In order to protect the plates of your new grill during transportation a layer of food safe oil was coated on the surface prior to shipment This oil is harmless but must be removed before you begin to use To remove preheat the grill until the oil liquifies Next carefully wipe away the melted oil with a clean soft cloth Once all of the oil is removed you can begin to use your grill 4 www AvantcoEquipment com EQUIPMENT VANTCO OLY am VEEL Cleaning and Maintenance 1 Disconnect machine before cleaning and allow to cool 2 Use only a damp towel with non corrosive cleaner Do not immerse or flush with water 3 Wipe down outside surface to remove any soil 4 Store in a dry clean area when not in use Vg AC tough grease oil and carbon with this ready to use carboninzer 4N OBLE FORMULA D and degreaser Its unique formula is designed to clean ovens grills CHEMICALINC hoods and a wide variety of other surfaces Troubleshooting Problem Possible Cause Action
5. AVANTCO User Manual Panini Grills Models P80 P82 Please read and keep these instructions Indoor use only www AvantcoEquipment com 1 EQUIPMENT User Manual VANTCO Thank you for purchasing and using our Panini Sandwich Grill To make best use of this product and avoid damage and injury please read this manual carefully before using the machine and keep it handy for future reference The Sandwich Grill design combines the advantages of stylish design efficient construction ease of operation and simple maintenance The grill temperature can be easily adjusted to suit cooking requirements and while mainly used for sandwich grilling the grill may be used for other foods WARNING Any modifications or incorrect installation unauthorized adjustments or maintenance by unauthorized per sonnel may result in property loss or injury Please contact the supplier for any necessary adjustment or repair which should only be done by trained professionals CAUTION For your safety do not place or store any flammable liquid or gas items near the sandwich grill WARNING This equipment must be connected to a grounded power outlet for your safety External Structure amp Parts List Single Grill Double Grill Models P80 Models P82 1 Power Indicator 1 Power Indicator 2 On Off switch amp temperature control 2 On Off switch amp temperature control 3 Heating cycle indicator 3 Heating cycle indicator
6. lt in overall power savings double unit 2 Grill temperatures may be set for different uses at the same time double unit 3 External shell and grease collector tray are stainless steel 4 The grills are designed to be easy to use and maintain www AvantcoEquipment com 3 EQUIPMENT User Manual VANTCO Specifications Single Panini Grill Double Sandwich Grill Model Number P80 P82 Voltage 120V 60 Hz 120V 60 Hz Power 1 75 Kw 2x1 75 Kw Temp Controls 1 2 Temp Range 120 F 570 F 120 F 570 F Upper Grill overall 13 x 8 3 4 8 7 16 x 16 7 8 Lower Grill 13 x 8 3 4 9 1 16 x 18 3 16 Overall Size 17 x 12 x 10 22 7 16 x 15 9 16 x 8 1 4 Notes 1 This machine is intended for use at 120V 60 Hz only 2 A suitable circuit protector fuse circuit breaker etc should be located near the machine 3 Be certain cable is properly connected to voltage source 4 Do not place any hard objects on the grill Do not slam the grill closed 5 Recommended temperature range for normal use is 392 482 F 6 The machine is intended for use where room temperature is below 113 F and humidity below 85 7 Do not use caustic or abrasive products for cleaning Operating Instructions Be sure power cord is properly connected to a proper source 120V 60 Hz 2 Power indicator should indicate power available light on 3 Set to desired temperature heating indicator will come on Warm up time is approximately 7 8 minutes Heating
7. ver 21 Slotted Screw M4x8 22 Top Cover 23 Slotted Screw M4x8 24 Upper Insulator 52 Bottom Cover 54 Hex Nut M6 26 Upper Platen 27 Upper Heater Wiring Guide Tube Wiring Guide Tube Stop Guide Tube Retainer Retaining Ring Upper Platen Shaft Internal Wrenching Screw M6x8 34 Internal Wrenching Screw M6x8 Handle Frame 36 Grease Collector 53 Oil Tray Bottom Insulator Bottom Pan Slotted Screw M4x8 Barrier Strip Mounting Plate Slotted Screw M4x8 Ceramic Terminal Board Hex Head Screw M6x20 Hex Nut M4 Rubber Foot Rubber Heater Pressure Plate Bottom Heater Internal Wrenching Screw M6x8 Phillips Head Screw M4x8 www AvantcoEquipment com EQUIPMENT User Manual Parts List Double Grill Power Light Temperature Control with Switch Screw M4x6 Heating Cycle Indicator Lower Case Internal Wrenching Screw M6x10 Flat Washer Internal Wrenching Screw M5x25 9 Flat Spacer 10 Torsion Spring 11 Rear Shaft 12 Shaft Retainer 13 Internal Wrenching Screw M6x40 14 Rear Upper Cover 15 Slotted Screw M4x8 16 Spring Pin 17 Ground Screw M6x15 18 Power Cord 19 Lower Grill 20 Upper Grill Cover 21 Slotted Screw M4x8 22 Top Cover 23 Slotted Screw M4x8 24 Upper Insulator 51 Hex Nut M6 www AvantcoEquipment com 26 27 Upper Platen Upper
Download Pdf Manuals
Related Search