Manual - Northern Tool + Equipment
Contents
1. NPower XRP SERIES SS EE MORE POWER MORE STABILITY MORE QUA SOLAR BATTERY CHARGER User s Manual For 7Watt 18Watt Solar Panels 14106 14105 Specifications and Included Items 14106 Power Rating Up to 7 Watts Maximum rating Under optimum conditions Current 460 Ma 15Volts 14105 Power Rating Up to 18 Watts Maximum rating Under optimum conditions Current 1 2 Amps 15Volts Includes 12 Volt plug Alligator Batterv Clamps Wire extensions Solar Panel 4 Stainless Steel Mounting Screws 4 Twist Turn brackets 2 Support stakes LED Voltage Indicator Light Stripped wire for charge controller 14105 only Warning Avoid Electrical Hazards when installing wiring operating and maintaining your Solar Module The solar module included generates DC electricity when exposed to sunlight or other light sources For use in 12 Volt systems only Observe proper polarity throughout entire power cable wiring route Work Safely Do not wear jewelry when working with electrical or mechanical equipment Use protective evewear when working with batteries or drills Use extreme caution when on ladders or on a roof Follow all Safety Precautions of the battery manufacturer Some batteries can release flammable hydrogen gas Do not produce sparks when working in locations where flammable gases or vapors exist Shield skin and eyes from battery acid Wash thoroughly with water if skin or clothing come in contact with aci2. aintenance to the unit should be performed by qualified service personnel or contact our experienced customer service team NOTE These Solar Batterv chargers have a built in blocking diode to prevent reverse discharge FAQ What types of batteries can my solar charger charge All 12 Volt batteries similar to those used in cars boats RV s motorcvcles and personal water craft Can l overcharge my battery Yes It is recommended to buy the N Power 7 Amp charge regulator to not overcharge the battery with item 14105 Will the Solar Charger keep my battery fully charged The Solar Charger charges your battery with the power of the sun Can l extend the wire The 12 wire can be extended up to a maximum of 27 without Loss of power or voltage How many batteries can charge using 1 unit This Solar Charger is capable of charging a bank of batteries but the charge will be divided Ensure positive to positive and negative to negative connections to ensure 12Volts Can this Solar Charger run my whole house No This panel is best used to recharge 12Volt Batteries How can I run 110 Volt appliances with my Solar Chargers By using an Inverter connected to the battery that Converts DC Power to AC Power Is my Solar Charger Weatherproof Yes these panels are fully weatherproofed Can I run an appliance directly from my Solar Charger without a battery Yes although the Solar Charger might have inconsistent voltages and will affect r
3. d or any corrosive matter which may have accumulated on the battery Keep the terminals and casing clean Use a Charge Controller for wattages higher than 15 watts Do not attempt to charge non rechargeable batteries Always connect charge controller to battery first e When disconnecting always disconnect battery last Features e Weather resistant quick connect and disconnect to the battery No direct sunlight needed will work in cloudy conditions Five year limited warranty Maintenance free Weatherproof Full mounting options included General INSTALLATION 3 easy steps 1 Place panel in best possible sun light choose proper mounting option 2 Connect extension cables 3 Connect to batteries through various connection options 1 mounting panel General Mounting Securelv place the solar panel in the sun Included mounting kit can be used if necessarv for permanent installation To allow for heat dissipation use a heat resistant spacer between the panel and the mounting surface when possible Mounting with Screws Use screws to permanentiv fix panel through the 4 corners of the panel This will work well for anv non moving structure such as a roof top or shed top or at a worksite One can use silicone around holes if waterproofing is required Secured mounting with screws Follow steps above but also attach twist turn brackets The brackets twist turn into the back of the panel frame Look for a channel in the frame attac
4. h the twist turn brackets turn 90 degrees and thev will be secured Place screw through other end of the bracket for additional securitv Ground Stake Mounting For temporarv backvard setup use included ground stakes fix ground stakes into back of panel channel of frame Please see image 2 Connectextension cables Connect to and to Use included wires to connect wires out of panel to extension and then choose proper connection to battery 3 Connect to Battery A Installation through the 12 Volt plug Plug the Male Adapter 12 Volt Plug into the Female 12 Volt socket in vehicle Make sure both ends are secure and are aligned correctly The panel with the black side up should face directly towards the sun for optimal charging power B Installation to Battery by Alligator Clamps Connect the alligator clamps correctly by matching the red clamp which is positive to the positive terminal on your battery Connect the black clamp which is Negative to the Negative terminal on your battery Follow this carefully to not cause any bodily harm The panel with the black side up should face directly towards the sun for optimal charging power It is strongly recommended to use a 7 Amp Solar Charge Controller to prevent the battery from overcharging item 14105 only 18W panel Maintenance Instructions Cleaning of the glass may be performed by the user by utilizing a clean damp cloth Any other m
5. unning the appliance It is recommended to charge 12Volt batteries only TROUBLESHOOTING I am not sure if my panel is functioning Ensure battery is operational Over time a battery s ability to recharge will deteriorate Ensure the distance of the wires is not longer than 30 feet and all connections are secure Measure the panel voltage with a voltmeter The voltage reading should be between 16 to 25 volts in the sun Warranty This product is covered by a 5 year limited warranty N Power will warrant to the original purchaser that this product is free from defects in materials and workmanship for the period of two years from date of purchase To obtain warranty service please contact N Power for further instruction at 1 800 222 5381 Proof of purchase including date and an explanation of complaint is required for warranty service Distributed by Northern Tool Equipment Company 2800 South cross Drive Burnsville MN 55306 www northerntool com NP010611
Download Pdf Manuals
Related Search