User manual Condenser dryer ZDC 37200W
Contents
1. Cleaning and maintenance Cleaning fluff filters The filters collect all the fluff which accumulates during drying To ensure that the dryer works perfectly the fluff filters fine filters and fluff filters must be cleaned after each drying cycle A Caution Never operate the dryer without fluff filters or with damaged or blocked fluff filters AAA the Buzzer button has been pressed an acoustic signal sounds intermittently for about one minute Remove the laundry 1 Open door 2 Remove visible fluff from the fluff filters It is best to use a damp hand for this purpose see chapter Maintenance and cleaning 3 Remove laundry 4 Turn the programme selector to O off Important after each drying cycle clean the fluff filters drain the water reservoir see chapter Maintenance and cleaning 5 Close the door i The drying cycles are automatically followed by an anti crease phase which lasts around 30 minutes The drum rotates at intervals during this phase to protect the laundry from creases The laundry can be removed at any time during the anti crease phase Clean the door sea Wipe the door seal with a damp cloth immediately after the drying cycle has finished Emptying the water reservoir Empty the water reservoir after every drying cycle A Caution The condensed water is not suitable2. for drinking or for preparing foodstuffs i If the programme has been interrupted as a result of the water reservoir being full Press the Start Pause button to continue the drying cycle Cleaning condenser AA mr Important What to do if Troubleshooting by yourself Problem Possible cause Dryer not connected to mains supply Dryer does not work Loading door opened The START PAUSE button not pressed Unsatisfactory Incorrect programme set drying results Fluff filters clogged e Never operate the dryer without condenser e logged condenser cause higher energy consumption drying cycle elongation and dryer damage e Do not use sharp objects to clean Cleaning the drum A Caution Do not use abrasives or steel wool to clean the drum Lime in the water or cleaning agents may form a barely visible lining on the inside of the drum The degree to which the laundry has been dried is then no longer detected reliably The laundry is damper than ex pected when removed from the appliance Use a standard domestic cleaner e g vinegar based cleaner to wipe down the inside ofthe drum and drum ribs Clean control panel and housing A Caution Do not use furniture cleaners or aggressive cleaning agents to clean the machine Use a damp cloth to wipe down the control panel and housing Remedy Plug in at mains socket Check fuse in fuse box domesti
3. paper clips safe ty pins etc Daily use Drying at reduced temperature Drying in the tumble dryer not possible Switching machine on Turn the programme selector to any programme The ma chine switches on e Turn items with double layered fabrics inside out e g with cotton lined anoraks the cotton layer should be outermost These fabrics will then dry better Important Do not overload the appliance Observe max loading volume Laundry weights Bathrobe 1200 g Napkin 100 g Quilt cover 700 g Sheet 500 g Pillow case 200 g Tablecloth 250g Towelling towel 200 g Tea cloth 100 g Night dress 200 g Ladies briefs 100 g Man s work shirt 600 g Man s work shirt 200 g Man s pyjamas 500 g Blouse 100 g Men s underpants 100g Operating Drying options DELICATE gentle drying with reduced heat of sensitive fabrics and temperature sensitive textiles e g acrylic viscose marked on care label with COTTONS SYNTHETICS type of laundry selection for time controlled pro grammes Starting the programme Press the Start Pause button Changing programme To change a programme which has been selected by mis take once the programme has started first turn the pro gramme selector to offand then set the programme again Drying cycle complete removing laundry Once the drying cycle is complete the LED Anti crease End is on as well as warning LED s Filter and Tank If
4. reversal at your cost Special accessories e stack kit i Available from your Service Force Centre or your specialist dealer These intermediate installation kits can be used to ar range the dryer and an washing machine 60 cm wide front loaded as a space saving washer dryer stack The washing machine is at the bottom and the dryer is at the top Product description O B I El 4 Ey E Control panel o els o DO g 5 E Me Read carefully the instructions supplied with the kit e drain kit i Available from your Service Force Centre or your specialist dealer Installation kit for direct draining of condensate into a basin siphon gully etc The condensate tank then no longer has to be drained it must however remain in its intended position in the machine Read carefully the instructions supplied with the kit e pedestal with the drawer 4 Available from your Service Force Centre or your specialist dealer To situate the dryer in optimal high and have some additional space to store e g laundry Read carefully the instructions supplied with the kit Worktop Rating Plate Heat exchanger Water reservoir Heat exchanger door KA Control pane Fluff filters REN Loading door El Ventilation grille Adjustable feet Programme knob and O OFF switch Delicate button Cotton Synthetic selection button Fun
5. The feet must never be removed Do not restrict the floor clearance by using deep pile carpets strips of Clean the micro fine filter and fine strainer after each drying cycle Spin the laundry well before drying 9 Energy consumption depends on spinning speed set in washing machine Higher spinning speed lower energy consumption Environmental information The packaging materials are environmentally friendly and can be recycled The plastic components are identified by markings e g gt PE lt gt PS lt etc Please dispose of the packaging materials in the appropriate container at the community waste disposal facilities A Warning When the unit is no longer being used Pull the plug out of the socket e Cut off the cable and plug and dispose of them e Dispose ofthe door catch This prevents children from trapping themselves inside and endangering their lives wood or similar This might cause heat built up which would interfere with the operation of the appliance Important e The hot air emitted by the tumble dryer can reach tem peratures of up to 60 C The appliance must therefore not be installed on floors which are not resistant to high temperatures hen operating the tumble dryer the room tempera ture must not be lower than 5 C and higher than 35 C as it may affect the performance of the appli ance e Should the appliance be moved it must be transported vertically e The a
6. c buttons and hold down for approx 5 sec onds 13 15 www zanussi com shop Ss EH CE 136910961 01 22032010
7. c installation Close loading door Press the START PAUSE button Set suitable programme 2 Clean fluff filters 3 Heat exchanger clogged Clean heat exchanger 3 Max loading exceeded Respect max loading volume Covered ventilation grill Uncover ventilation grill in base area Residue inside the drum Clean the drum inside Ensure min 5cm free space around the appli To little free space around the appliance g Loading door does not close Install fine filter and or snap course filter into place Empty water reservoir press START PAUSE Filters not locked in place Programme in 3 ogramme Full water reservoir active button Drying cycle to Small laundry volume Too dry laundry for se Select time programme or higher drying level short lected programme e g EXTRA DRY Fluff filters clogged Clean fluff filters A To high loading volume Respect max loading volume Drying cycle to long 4 Laundry insufficiently spun Spun adequately the laundry Particularly higniroomtemperature NO TG oyer the room temperature if possible chine fault 1 Switch the dryer off Set programme time Press the START PAUSE button 2 follow program recommendation see Programme overview chapter 3 see Care and cleaning chapter 4 Note After around 5 hours the drying cycle ends automatically see Drying cycle complete section Technical data Parameter Value Height x width x depth 85 x 60 x 58 c
8. ction status led Drying Anti crease End Condenser Filter Tank lights Start Pause button Before first use In order to remove any residues which may have been produced during production wipe the dryer drum with a Programme chart Programmes COTTON EXTRA DRY COTTON STRONG DRY COTTON STORAGE DRY COTTON DAMP 1 COTTON IRON DRY 1 SYNTHETICS EXTRA DRY SYNTHETICS STOR AGE DRY SYNTHETICS IRON DRY JEANS 1 In accordance with IEC61121 Programme chart in accordance with IEC61121 Time in minutes about 140 130 125 110 85 90 40 30 125 gt en ke amp GE de o D z ke 2 E 7 kg 7 kg 7 kg 7 kg 7 kg 3 kg 3 kg 3 kg 7 kg with damp cloths in the machine Application properties Thorough drying of thick or multi layered fabrics e g terry towelling items bathrobes Thorough drying of thick or multi layered fabrics e g terry towelling items bathrobes Thorough drying of fabrics of even thicknesses e g terry towelling items knitwear towels For thin textiles which are still to be ironed e g knitted items cotton shirts For thin fabrics which are also to be ironed e g knitwear cotton shirts Thorough drying of thick or multi layered fabrics e g pullovers bedding table linen Forthin fabrics which are not ironed e g easy care shirts table linen baby clothes socks lingerie wi
9. cts such as coins safety pins nails screws stones or any other hard sharp material can cause extensive damage and must not be placed into the ma chine In order to avoid danger of fires caused by excessive drying do not use appliance to dry the following items Cushions quilts and the like these items accumulate heat f Sorting and preparing laundry___________ 8 Daily use 8 Cleaning and maintenance 9 What to do if 10 Technical data 11 Machine settings 12 Subject to change without notice e Items such as foam rubber latex foam shower caps waterproof textiles rubber backed articles and clothes or pillows fitted with foam rubber pads should not be dried in the tumble dryer Always unplug the appliance after use cleaning and maintenance e Under no circumstances should you attempt to repair the machine yourself Repairs carried out by inexper ienced persons may cause injury or serious malfunc ioning Contact your local Service Centre Always in ist on genuine spare parts ems that have been soiled with substances such as cooking oil acetone petrol kerosene spot removers turpentine waxes and wax removers should be washed in hot water with an extra amount of detergent before being dried in the tumble dryer Danger of explosion Never tumble dry items that have been in contact with inflammable solvents petrol me thylated spirits dry cleaning fluid and the like As these substances are vo
10. latile they could cause an ex plosion Only tumble dry items washed with water Risk of fire items that have been spotted or soaked with vegetable or cooking oil constitute a fire hazard and should not be placed in the tumble dryer If you have washed your laundry with stain remover you must execute an extra rinse cycle before loading your tumble dryer Please make sure that no gas lighters or matches have accidentally been left in pockets of garments incase they are loaded into appliance UN A e A Warning e Risk of fire Never stop a tumble dry before the end of the drying cycle unless all items are quickly removed and spread out so that the heat is dissipated e Lint must not be allowed to accumulate around the tumble dryer e Riskofelectric shock Do not spray down the appliance with jets of water e The final part of a tumble dryer cycle occurs without heat cool down cycle to ensure that the items are left at a temperature that ensures that items will not be damaged e The tumble dryer is not to be used if indus icals have been used for cleaning e Ensure you have good ventilation in the installation room to avoid the back flow of gases into the room from appliances burning other fuels including open fires Installation e This appliance is heavy Care should be taken when moving it e When unpacking the appliance check that it is not damaged If in doubt do not use it and con
11. loured in accordance with the following code Blue Neutral cord clamp Brown Live Green and Yellow Earth The wire coloured green and yellow must be connected to the terminal marked with the letter E or by the earth symbol or coloured green and yellow The wire coloured blue must be connected to the terminal N or coloured black The wire coloured brown must be connected to the ter minal marked L or coloured red Upon completion there must be no cut or stray strands of wire present and the cord clamp must be secure over the outer sheath A Warning A cut off plug inserted into a 13 amp socket is a serious safety shock hazard Ensure that the cut off plug is disposed of safely A Warning The plug must be accessible after installing the machine Permanent connection In the case of permanent connection it is necessary that you install a double pole switch between the appliance and the electricity supply mains with a minimum gap of 3 mm between the switch contacts and ofa type suitable for the required load in compliance with the current elec trical regulations The switch must not break the yellow and green earth cable at any point Door reversal To make it easier to load or unload the laundry the door can be reversed A Warning The door must only be reversed by an authorised service engineer Please contact your local Service Force Centre The en gineer will carry out the door
12. m Drum volume 108 Depth with loading door open 109 cm Height can be adjusted by 1 5 cm Weight when empty approx 38 5 kg Loading volume depends on programme max 7 kg Voltage Frequency 230 240 V 50Hz Reguired fuse 13A Total power 2350 W Energy efficiency class C 11 Parameter Value Energy consumption 7 kg of cotton pre drained at 1000 ane 4 4 kWh Average annual energy consumption 298 7 kWh Use Domestic Permissible ambient temperature 5 C to 35 C Consumption values The consumption values have been established under standard conditions They may deviate when the machine is operated in domestic circumstances Programme Energy consumption in kWh average drying time in min 4 4 130 7 kg load pre drained at 1000 rom 4 2 7 kg load pre drained at 1200 rom 3 COTTON CUPBOARD DRY 3 9 7 kg load pre drained at 1400 rom 3 4 7 kg load pre drained at 1800 rom COTTON IRON DRY 3 3 41 100 7 kg load pre drained at 1000 rom SYNTHETICS CUPBOARD DRY 3 1 36 48 3 kg load pre drained at 1200 rpm 1 Different loading volume data may be needed in some countries as a result of different measuring methods 2 in accordance with EN 61121 3 Hints for test institutes cycle has to be checked in accordance with EN 61121 Machine settings BUZZER permanent off 3 The buzzer is by default always off 1 Turn the programme selector to any programme 2 Press simultaneously the Delicate and Cotton Syntheti
13. or the environment and human health which could otherwise be caused by inappropriate waste handling of this product For more detailed information about recycling of this product please contact your local council your household waste disposal service or the shop where you purchased the product Environmental tips e In the dryer laundry becomes fluffy and soft Fabric softeners are not therefore needed when washing e Your dryer will function most economically if you Always keep the ventilation slots on the base of the dryer unobstructed Use the loading volumes specified in the pro gramme overview Ensure you have good ventilation in the installation room Installation Important The appliance must be moved in vertical position for transport Appliance positioning e Itis recommended that for your convenience the ma chine is positioned close to your washing machine e The tumble dryer must be installed in a clean place where dirt does not build up Air must be able to circulate freely all round the appli ance Do not obstruct the front ventilation grille or the air intake grilles at the back of the machine To keep vibration and noise to a minimum when the dryer is in use it should be placed on a firm level surface Once in its permanent operating position check that the dryer is absolutely level with the aid of a spirit level If it is not raise or lower the feet until it is e
14. ppliance must not be installed behind the lock able door a sliding door a door with a hinge on the opposite side to that of the appliance in such a way that ull opening of the dryer is restricted e fe Ensure min 5cm free space around the appliance Removing transport safety packaging A Caution Before use all parts of the transport packaging must be removed A 1 Open loading door 2 Pull off adhesive strips from inside machine on top of drum 3 Remove foil hose and polystyrene padding from the machine Electrical connection Details on mains voltage type of current and the fuses required should be taken from the rating plate The rating plate is fitted near the loading aperture see Product de scription chapter Connect the machine to an earthed socket in accordance with current wiring regulations A Warning The manufacturer declines any responsibility for damage or injury through failure to comply with the above safety precautions Should the appliance power supply cable need to be replaced this must be carried out by an authorised service engineer or a qualified electrician The appliance is supplied with a 13 amp plug fitted In the event of having to change the fuse in the plug supplied a 13 amp ASTA approved BS 1363 A fuse must be used m gt 13A lt The wires in the mains lead are co
15. tact the Service Centre All packaging must be removed before use Serious damage can occurto the product and to property if this is not adhered to See relevant section in the user manual e Any electrical work required to install this appliance should be carried out by a qualified electrician or com petent person e fthe machine is situated on a carpeted floor please djust the feet in order to allow air to circulate freely under the appliance fter having installed the appliance check that it is not pressing or standing on its electrical supply cable e fthe tumble dryer is placed on top of a washing ma chine it is compulsory to use the stacking kit optional accessory Use e This appliance is designed for domestic use It must not be used for purposes other than those for which it was designed rial chem jat e gt e Only wash fabrics which are designed to be machine dried Follow the instructions on each garment label e Do not dry unwashed items in the tumble dryer e Donotoverload the appliance See the relevant section in the user manual Clothes which are dripping wet should not be placed in the dryer Garments which have been in contact with volatile pe troleum products should not be machine dried If vol atile cleaning fluids are used care should be taken to ensure that the fluid is removed from the garment be fore placing in the machine Never pull the power s
16. th bones or Wires For thin fabrics which are also to be ironed e g knitwear cotton shirts For leisure clothing such as jeans sweat shirts etc of different material thicknesses e g at the neck cuffs and seams The appliance should be tested based on time controlled programmes damp cloth or carry out a brief drying cycle ca 30 min J K PN LI OG Of 9 L JE PN PN C J S PN ZA Z OO O FR PN C FR PN PN ZB O Q Sorting and preparing laundry Sorting laundry e Sort by fabric type Cotton linen for programmes in COTTONS pro gramme group Mixtures and synthetics for programmes in SYN THETICS programme group e Sort by care label The care labels mean O Drying in the tumble dryer possible in prin ciple CJ Drying at normal temperature PN Important Do not place in the appliance any wet laundry which is not specified on the care label as being suitable for tumble drying This appliance can be used for all wet laundry items which are labelled as suitable for tumble drying e Do not dry new coloured textiles together with light coloured laundry items Textile colours may bleed e Do not dry cotton jersey and knitwear with the EXTRA DRY programme Items may shrink Preparing laundry e To avoid laundry becoming tangled close zips button up duvet covers and tie loose ties or ribbons e g of aprons e Empty pockets Remove metal items
17. u U S E R Condenser dryer MANUAL la vita bella ZANUSSI ITALIAN SINCE 1916 ZDC 37200W Contents Important safety information Environment Installation Product description Control panel Before first use Programme chart Y Y O O BE NN Important safety information Important In the interest of your safety and to ensure the correct use before installing and first using the appliance read this user manual carefully including its hints and warnings To avoid unnecessary mistakes and accidents itis important to ensure that all people using the appliance are thoroughly familiar with its operation and safety features Save these instructions and make sure that they remain with the appliance if it is moved or sold so that everyone using itthrough its life will be properly informed on appliance use and safety Please read the instruction book before using this appliance General safety e Itis dangerous to alter the specifications or attempt to modify this product in any way e This appliance is not intended for use by persons in cluding children with reduced physical and sensory conditions or lack of experience and knowledge un less they have been given supervision or instruction concerning use of the appliance by a person respon sible for their safety Make sure that small children and pets do not climb inside the drum To avoid this please check into the drum before using Any obje
18. upply cable to remove the plug from the socket always take hold of the plug itself Never use the tumble dryer if the power supply cable the control panel the working surface or the base are damaged so that the inside of the tumble dryer is ac cessible Fabric softeners or similar products should be used as specified by the fabric softener instructions Caution hot surface Do nottouch the door light cover surface when the light is switched on Only dryers equipped with internal drum light Child safety e This machine is not intended for use by young children or infirm persons without supervision e Children often do not recognise the hazards associated with electrical appliances Children should be super vised to ensure that they do not play with the appliance A Warning e Danger of suffocation The packaging compo nents e g plastic film polystyrene can be dan gerous to children Keep them out of children s reach e Keep all detergents in a safe place out of children s reach e Make sure that children or pets do not climb inside the drum Environment The symbol A onthe product or on its packaging indicates that this product may not be treated as household waste Instead it should be taken to the appropriate collection point for the recycling of electrical and electronic equipment By ensuring this product is disposed of correctly you will help prevent potential negative consequences f
Download Pdf Manuals
Related Search