MSDS Sheet - VisionCorps
Contents
1. liability whatsoever for the accuracy or completeness of the information contained herein Final determination of suitability of any material is the sole responsibility of the user All materials may present unknown hazards and should be used with caution Although certain hazards are described herein we cannot guarantee that these are the only hazards that exist NOTE Hazard Determination System HDS ratings are based on a 0 4 rating scale with 0 representing minimal hazards or risks and 4 representing significant hazards or risks Although these ratings are not required on MSDSs under 29 CFR 1910 1200 the preparer may choose to provide them HDS ratings are to be used with a fully implemented program to relay the meanings of this scale2. and face before eating drinking and smoking Do not get in eyes or on skin or clothing Do not ingest Avoid breathing vapor or mist Keep in the original container or an approved alternative made from a compatible material kept tightly closed when not in use Keep away from acids Empty containers retain product residue and can be hazardous Do not reuse container Storage Store in accordance with local regulations Store in original container protected from direct sunlight in a dry cool and well ventilated area away from incompatible materials see section 10 and food and drink Separate from acids Keep container tightly closed and sealed until ready for use Containers that have been opened must be carefully resealed and kept upright to prevent leakage Do not store in unlabeled containers Use appropriate containment to avoid environmental contamination Section 8 Exposure Controls Personal Protection Product name Exposure limits SODIUM METASILICATE silicic acid H2 Si O3 disodium salt Supplier Suggested United States water glass CEIL 2 mg m Personal Protective Equipment PPE Eyes Safety glasses Recommended Splash goggles wE kaz Body Neoprene or Nitrile or Rubber gloves Respiratory Use a properly fitted air purifying or air fed respirator complying with an approved standard if a risk assessment indicates this is necessary Respirator selection must be based on known or anticipated exposure levels the hazards
3. of the product and the safe working limits of the selected respirator Section 9 Physical and Chemical Properties Physical State Liquid Thin liquid Color Colorless Clear pH 12 2 to 12 8 Odor Mild Boiling Point 100 C 212 F Vapor Pressure Not available Specific Gravity 1 05 Vapor Density Not available Solubility Easily soluble in the following materials cold water Evaporation Rate 1 Water 1 and hot water VOC Consumer 0 g l Section 10 Stability and Reactivity Stability and Reactivity The product is stable Incompatibility Reactive or incompatible with the following materials oxidizing materials and acids Hazardous Polymerization Under normal conditions of storage and use hazardous polymerization will not occur Hazardous Decomposition Products carbon oxides CO CO2 sulfur oxides SO2 SOs etc Page 2 3 Product code 2917 Material Safety Data Sheet Product Name ZEP ENVIROEDGE TRUCK WASH Section 11 Toxicological Information Acute Toxicity disodium metasilicate LD50 Oral Mouse 770 mg kg LD50 Oral Rat 1153 mg kg Section 12 Ecological Information Environmental Effects Not available Aquatic Ecotoxicity Product ingredient name Test Result Species Exposure disodium metasilicate Acute EC50 33 53 mg L Crustaceans Water flea 48 hours Fresh water Ceriodaphnia dubia Neonate lt 24 hours Section 13 Disposal Considerations Wast
4. Safety Data Sheet Zep Inc Section 1 Chemical Product and Company Identification 1310 Seaboard Industrial Blvd Atlanta GA 30318 Product name d eee ZEP ENVIROEDGE TRUCK WASH Superior Solutions W 22P com Product use Vehicle Wash Product code 2917 Date of issue 11 01 11 Supersedes None Emergency Telephone Numbers For MSDS Information Compliance Services 1 877 I BUY ZEP 428 9937 For Medical Emergency 877 541 2016 Toll Free All Calls Recorded For Transportation Emergency CHEMTREC 800 424 9300 All Calls Recorded In the District of Columbia 202 483 7616 Prepared By Printing date 11 02 11 Compliance Services 1420 Seaboard Industrial Blvd Atlanta GA 30318 Section 2 Hazards Identification Emergency overview Hazard Determination System HDS Health Flammability Reactivity WARNING 2 Z o CAUSES EYE AND SKIN IRRITATION HARMFUL IF SWALLOWED Avoid contact with eyes skin and clothing Do not ingest Avoid breathing vapor or mist NOTE MSDS data pertains to the product as delivered in the original shipping container s Risk of adverse effects are lessened by following all prescribed safety precautions including the use of proper personal protective equipment Acute Effects Routes of Entry Dermal contact Eye contact Inhalation Eyes Causes eye irritation Inflammation of the eye is characterized by redness watering and itching Skin Causes skin irritation Skin inflam
5. e Information Waste must be disposed of in accordance with federal state and local environmental control regulations Consult your local or regional authorities for additional information Waste Stream Code D002 Classification Hazardous waste Origin RCRA waste Section 14 Transport Information Regulatory information UN number Proper shipping name Classes PG Label DOT Classification Not regulated Z i IMDG Class Not regulated z NOTE DOT classification applies to most package sizes For specific container size classifications or for size exceptions refer to the Bill of Lading with your shipment PG Packing group Section 15 Regulatory Information U S Federal Regulations SARA 313 toxic chemical notification and release reporting No products were found Clean Water Act CWA 307 No products were found Clean Water Act CWA 311 No products were found Clean Air Act CAA 112 regulated toxic substances No products were found All Components of this product are listed or exempt from listing on TSCA Inventory TSCA 8 a IUR Alcohols C10 14 ethoxylated United States inventory TSCA 8b Not determined State Regulations California Prop 65 No products were found Section 16 Other Information To the best of our knowledge the information contained herein is accurate However neither the above named supplier nor any of its subsidiaries assumes any
6. mation is characterized by itching scaling or reddening Inhalation May cause irritation of respiratory tract coughing shortness of breath Ingestion Harmful if swallowed May cause burns to mouth throat and stomach Chronic effects Repeated or prolonged contact with spray or mist may produce chronic eye irritation and severe skin irritation Repeated or prolonged exposure to spray or mist may produce respiratory tract irritation leading to frequent attacks of bronchial infection Carcinogenicity Ingredients Not listed as carcinogen by OSHA NTP or IARC Product ingredient name Not available Additional Information See Toxicological Information Section 11 Section 3 Composition Information on Ingredients Name of Hazardous Ingredients CAS number by Weight ALCOHOLS C4 10 ETHOXYLATED Alkoxylated alcohol 66455 15 0 1 10 SODIUM XYLENE SULFONATE 1300 72 7 1 10 SODIUM METASILICATE silicic acid H2 Si O3 disodium salt water glass 6834 92 0 1 5 Section 4 First Aid Measures Eye Contact Check for and remove any contact lenses Immediately flush eyes with plenty of water for at least 15 minutes occasionally lifting the upper and lower eyelids Get medical attention immediately Skin Contact In case of contact immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes Wash clothing before reuse Clean shoes thoroughly before reuse Get medical atten
7. tion immediately Inhalation Move exposed person to fresh air If not breathing if breathing is irregular or if respiratory arrest occurs provide artificial respiration or oxygen by trained personnel Loosen tight clothing such as a collar tie belt or waistband Get medical attention immediately Ingestion Wash out mouth with water Do not induce vomiting unless directed to do so by medical personnel Never give anything by mouth to an unconscious person Get medical attention immediately Page 1 3 Product code 2917 Material Safety Data Sheet Product Name ZEP ENVIROEDGE TRUCK WASH National Fire Protection Association U S A Section 5 Fire Fighting Measures Flash Point Not available Flammable Limits Not available Flammability Non combustible Fire hazard In a fire or if heated a pressure increase will occur and the container may burst Fire Fighting Use an extinguishing agent suitable for the surrounding fire Procedures Section 6 Accidental Release Measures Spill Clean up Stop leak if without risk Move containers from spill area Dilute with water and mop up if water soluble Alternatively or if water insoluble absorb with an inert dry material and place in an appropriate waste disposal container Dispose of via a licensed waste disposal contractor Section 7 Handling and Storage Handling Put on appropriate personal protective equipment see section 8 Workers should wash hands
Download Pdf Manuals
Related Search