user manual-ergo stand
Contents
1. your wheelchair 7 3 2Inspecting Tire Tread please check the tread depth regularly 7 3 4Replace the tires when the tread depth is less than 0 5mm 7 4 General Maintenance 7 4 1 You must maintain the vehicle more frequently if you drive on grass sand or gravel roads often 74 2 Do not use water oil or other chemical solutions to clean your wheelchair Be sure NOT to spray the vehicle with water as not to damage the electronic components and PCB circuit board Please clean the vehicle by wiping it with either a dry or moist cloth Please take the vehicle to an authorized KARMA wheelchair dealer for repairs and adjustments Improper adjustments could lead to wheelchair malfunction or an accident A N CAUTION e Before performing any maintenance be sure to turn the power OFF and unplug the charger if connected e DO NOT over tighten hardware This could cause damage to the frame and hardware 32 Q Do not directly spray water on your wheelchair to wash it as this could lead to a malfunction in the electric system Do not use gasoline solvents or other abrasive solutions the casing may become deformed or damaged X WARNING e After ANY adjustments repair or service and BEFORE use make sure that all hardware is tightened securely otherwise injury or damage may Occur 7 4 3 Suggested Maintenance Procedures before you use the power wheelchair make sure all nuts and bolts are tight Check all parts2. Speed equivalent to walking slowly on foot On an decline Driving Indoors or in a narrow space ooa parae to walking at a normal speed Driving in an open space On an incline 5 2 4 Forward Reverse and Braking 5 2 4 1 Push forward on the joystick to make the wheelchair move forward 5 2 4 2 Pull back on the joystick for the wheelchair to move backward 5 2 4 3 Release the joystick and the wheelchair will quickly slow down the electromagnetic brake will be activated to stop the wheelchair 5 2 4 4 Come to a complete stop before turning the power OFF 15 VAN NUL ONNE The stopping distance will vary with your forward reverse speed Therefore please gradually slow down and come to a complete stop well before any obstacles or danger To park the wheelchair be sure to park on flat ground and then turn the power to OFF NEVER use the freewheel mode when going down an incline The electromagnetic brake won t function in freewheel mode 5 2 5 Horn Button The horn will sound for the duration of time the button is pressed 5 2 6 Battery Indicator 5 2 6 1When the power is turned on the battery indicator will light up with a possible total of three red four orange and three green dots indicating the remaining power of the batteries All of the green lights being lit indicate that the batteries are fully charged If only the red dots are lit this indicates that the batteries are out of or nearly out of power
3. The drive range will be shortened when driving frequently on slopes or uneven ground as this consumes more battery power 18 5 2 8 Stand up Function Operation 5 2 8 1Turn the power on 5 2 8 2 Press the stand up actuator button 9 See 5 1 VRI Joystick Controller 5 2 8 3 Moving the joystick forward will stand up the seat in that direction 5 2 8 4 Moving the joystick backward will sit down the seat in that direction 5 2 8 5 Pressing the stand up actuator button again puts controller back in drive mode 5 2 9 Back Reclining Function Operation 5 2 9 1 Turn the power on 5 2 9 2 Press the stand up actuator button 10 See 5 1 VRU Joystick Controller 5 2 9 3 Moving the joystick backward will recline the back in that direction The maximum reclining angle can reach to 120 degree 5 2 9 4 Moving the joystick forward will move the back in that direction VANE NUS ONN The maximum speed will reduce to half while the stand up function is operated The stand up function exclusively on a flat surface away from any stairs access ramp or slope While operate the stand up function should keep the fingers or clothes away from seat bottom to reduce squeeze hazards Before the stand up function operation ensure that the chest strap and knee support are fitted securely Lubricate the sliding parts or pivots 1 to 2 times per month 19 5 3 Freewheel Levers The KP 80 is supplied with freewheel levers to allow for m
4. 16 5 2 7 The Fixed Way of Joystick Cable 1 Please use the X way 2 To pack the chair into 3 Please note the to fix the cable tie a carton the circled cable in the circled place Is not position should be fastened by the always kept on the cable tie Please direction face fasten it with a forward as shown cable tieassoonas above you unpack the A a TUPAS AMET Ns 5 Please use the cable tie to fix it tie to fix it The tie to fix it cables should be fixed inside of the two tubes 17 Q It is recommended that you charge the batteries immediately when the battery indicator shows only three or less red dots After charging or replacing new batteries drive the wheelchair for 2 3 minutes to make sure the batteries are fully charged before going ona long journey In wintertime the batteries may respond slowly and the drive range may also be reduced You must store your wheelchair indoors above freezing temperatures When driving on an incline the battery indicator light might move up and down This is normal Even if the batteries are used properly their capacity will decay over time thereby reducing the drive range maximum distance travelled per full charge Thus when the drive range becomes about 50 of what brand new batteries would offer it s time to replace them with new batteries Otherwise the batteries may die unexpectedly leaving you in a possibly precarious situation
5. 2 5 Figure 2 6 2 3 KP 80 LABELLING Please carefully read all the labeling on the wheelchair before driving it Do not remove them Protect them for future reference Circuit Breaker Press To Reset 3 EMI RFI This section provides the user with basic information about the problems with EMI known sources of EMI and protective measures either to reduce the possibility of exposure or to minimize the degree of exposure This section also shows some conditions in which unexpected or erratic wheelchair movements may occur N CAUTION e It is very important that you read this information regarding the possible effects of electromagnetic interference on your electric KARMA wheelchair 3 1 Electromagnetic Interference from Radio Wave Sources Powered vehicles may be susceptible to electromagnetic interference EMI which is interfering electromagnetic energy EM emitted from sources such as radio stations Radio Frequency Interference TV stations amateur radio HAM transmitters two way radios and cellular phones The interference from radio wave sources can cause the powered vehicle to release its brakes move by itself or move in unintended directions It can also permanently damage the powered vehicle s control system The intensity of the interfering EM energy can be measured in volts per meter V m Each powered vehicle can resist EMI up to a level of intensity This amount of resistance is called its immuni
6. a second hand KARMA wheelchair while it is still with in the warranty period bring the Owner s Manual and the vehicle to the dealership where the wheelchair was purchased for registration 45 Warranty Form You may photocopy this from Gender oFemale MM DD YYYY Date of Birth Address Model KARMA KP 80 Serial Number MM DD YYYY Date of Purchase Purchaser Signature Dealer s Data Name of store Telephone and Address If you have any suggestions on how to improve our products please don t hesitate contacting your local dealer to let us know what you think of your wheelchair Thank you and enjoy 46 National agent Sold and serviced by KARMA MEDICAL PRODUCTS CO LTD Htto www KarmaMedical com E mail globalsales karma com tw KARMA reserves the right to modify information herein without further notice 104 45029 Rev 02 MAY 2013
7. and protect our planet for future generations If you do not have access to the world wide web please use your local phone directory ask for operator assistance or go to your local government center 42 for more information Various parts of this wheelchair should be recycled to the collection and recycling location nearest to you Earth Day Is every day where and how to recycle used batteries as this information varies from region to region Pb 11 2 3 Check with your local recycling center on bu torecle sedate ss gM 12 WARRANTY 12 1 Serial Number To ensure after sale service and warranty please record and fill in the vehicle identification number The serial number can be found on the steering column below the control panel 12 2 Warranty Policy 12 2 1 Contents and Duration of Warranty Contents of Warranty 12 2 1 1 Repair will be provided free of charge if the problems are due to manufacturing or defective components within the warranty period a repair of this kind will hereafter be called warranty repair 12 2 1 2 The warranty covered repair can be performed by authorized KARMA wheelchair dealers only 12 1 1 3 KARMA is not responsible for the transportation costs for repair and replacement 12 2 1 4 Replaced parts will be the property of KARMA Warranty Duration and Parts Covered by the Warranty Please contact your local dealer 12 2 2 Items Not Covered by the Warranty Items Not Covered 43 The ite
8. encountered it is the personal responsibility and obligation of the customer to contact a qualified electrician and have the two prong receptacle replaced with a properly grounded three prong wall receptacle outlet in accordance with the National Electrical Code and local laws Do not use an extension cord when charging your batteries A risk of fire and or electric shock could be encountered BATTERIES The warranty and performance specifications contained in this manual are based on the use of deep cycle sealed lead acid batteries KARMA strongly recommends their use as the power source for this unit Refer to chapter 6 Carefully read the battery and charger information prior to installing servicing or operating your wheelchair RAIN e DO NOT leave your power wheelchair in a rain of any kind e DO NOT use your power wheelchair in a shower or leave it in a damp bathroom while taking a shower e DO NOT leave your power wheelchair in a damp area for any length of time e Direct exposure to rain or dampness could cause the power wheelchair to malfunction electrically and mechanically and may cause the power wheelchair to prematurely rust WEIGHT LIMITATION The maximum weight that can be carried including goods Is stated beside Max User Weight in section 9 SPECIFICATIONS Figure 1 STAIRWAYS e DO NOT attempt to move an occupied power wheelchair between floors using a stairway See Figure 1 Never try to overco
9. freewheel mode on flat surfaces since your electromagnetic brakes are not engaged in this mode without these brakes it will roll down a hill causing injury or damage Never drive under the influence of alcohol or medication e DO NOT sit in the powered wheelchair within a moving vehicle unless it has been affixed the labels of hook mark RAMPS e DO NOT climb go up or down ramps or traverse slopes greater than the safe climbing angle for your model specified in section 9 When negotiating ramps if the joystick is released while moving forward the power wheelchair will roll backwards approximately one foot before the brake engages If the joystick is released while in reverse the power wheelchair will roll backwards approximately two and a half feet before the brake engages When going uphill always lean the trunk forward and do not change direction abruptly When going downhill always lean the trunk backward e Be sure to reduce your speed when driving on curved roads or making a turn do not drive at full soeed Please drive at a slower speed so you have complete control of the wheelchair ELECTRICAL Check to ensure that all electrical connections are secure at all times Grounding Instructions DO NOT under any circumstances cut or remove the round grounding prong from any plug Some devices are equipped with three prong grounding plugs for protection against possible shock hazards Where a two prong wall receptacle Is IV
10. k Reclining Actuator Strut d up Actuator Sta lt D O O O z O O X Y U O a C Oo 13 5 OPERATION 5 1 VRI Joystick Controller OO 0 OO Fd Without Lighting With Lighting System System 1 Joystick 9 Back Reclining Actuator Button 2 Charger Socket 10 Stand up Actuator Button 3 Battery amp Diagnostics Indicator 11 Hazards Button 4 ON OFF Button 12 Left Indictor Buttons 5 Horn Button 13 Actuator Indicator 6 Speed Indicator 14 Right Indictor Buttons 7 Speed Increase Button 15 Stand up Actuator Button 8 Soeed Decrease Button 16 Lights Button 5 2 How to Operate Your Wheelchair 5 2 1 Power ON OFF Press the power button Be sure not to touch the joystick while turning on the controller Your battery amp diagnostics indicator should light up 5 2 2 Soeed Adjustment Buttons The speed increase decrease button allows you set various forward and reverse speeds The settings are a percentage of maximum power Notice the orange dots on the speed Indicator The more orange dots the faster your speed 14 A e Please slow down before you get used to control your power wheelchair e Please slow down your speed when indoors 5 2 3 Driving Speed You can choose between 1 to 5 orange dots in the speed indicator with 5 being the maximum speed Please refer to Max Speed in section 10 SPECIFICATIONS Speed Scale Speed Equivalencies and Recommended Circumstances
11. owner s manual before using the wheelchair Improper use of the wheelchair could result in harm injury or traffic accidents Therefore for safe and enjoyable use of the wheelchair please read this owner s manual 1 2 This owner s manual includes operation instructions for the aspects of the wheelchair assembly instructions and instructions on how to deal with possible accidents 1 3 This owner s manual is written for Karma power stand up wheelchair s KP 80 1 4 The symbols used in this manual are explained below Pay special attention to the parts marked with these symbols Improper use could lead the user to severe injury or S WARNING pii eath A Improper use could lead the user to severe injury and or damage to your wheelchair Follow these instructions to keep the wheelchair in CE SUGGESTION good condition 1 5 This manual includes the repair and maintenance chart as well as the Warranty Please keep it in a safe place or with the wheelchair If someone else uses the wheelchair make sure that you give him or her this owner s manual for his or her reference 1 6 As designs change some illustrations and pictures in this manual may not correspond to the vehicle that you purchased We reserve the right to make design modifications without further notice VANE NUE ONN e Before purchasing and using KARMA wheelchairs please consult qualified professionals so as to ensure that you choose suitable products and use th
12. 2 3 5 Abuse or misuse of the vehicle such as driving over curbs and overloading the wheelchair with passengers or goods 12 2 3 6 Driving in places where the vehicle should not normally be 44 eel L a eS aa driven or used 12 2 3 7 Damage or surface corrosion from environmental factors such as airborne fallout chemicals tree sap et cetera stones hail windstorms lighting floods and so on 12 2 3 8 Change of any material or component parts not authorized by KARMA Don t carry objects that may lead to the wheelchair being unbalanced 12 2 3 9 The wheelchair shall not be pulled or pushed by another vehicle when there is a person on the wheelchair or the rear wheels are not set to the freewheel mode and 12 2 3 10 Do not drive a wheelchair that is older than 10 years without having its structure inspected 12 2 4 The Responsibilities of the User The following items are the responsibility of the user 12 2 4 1 Proper use of the vehicle in accordance with this Owner s Manual 12 2 4 2 Performance of the daily inspections 12 2 4 3 Performance of the regular maintenance recommended by KARMA and 12 2 4 4 Keep a record of vehicle inspection and maintenance in the back of this Owner s Manual 12 2 5 Warranty Effectiveness 12 2 5 1 The warranty form must be completely filled out and stamped by the KARMA dealership where the wheelchair was purchased 12 2 6 Transfer of Warranty Rights 12 2 6 1 If you purchase
13. AND CHARGER atecsassesc se ainatcnisadeass aacvatestonsansesvatestanvouatensniadencourss 25 6 1 Charging the Batteries ccccsesssssecsssssssssecsssecssscssseessseessnecen 25 6 2 CALGON a eeessescsssssssssscsssecsssecssssccsssessssscssssccsssecessecessscssssecessecessecsssecsessecesneces 27 6 3 Batteries cccccccccccccscscscscscscscsssesesscccsscccececscscsesesesesesssscssssssscsssssssvesesevesessens 28 7 ANSPEGMON AND MAINTENANC E vsteniseusscatscnmisenonsanitnus civic 30 eM TEAM INC MEOE EAT E E eee ee 30 7 2 Regular Maintenance RECOM ccsecccsssessssssescssseccsssesessnesessneees 31 DNAS e E TE O es nena 32 7 4 General Maintenance sssssssssssesssrssssssssrssssssssrrssssssrsrrsssssererrsnsssen 22 7 5 Transporting and Storing sssssissssssssiisssssssrirrssssserirrrssserrrrsssssn 33 7 6 Battery circuit breaker tires sessir 34 S OPTONALACCESSORIE Skirner 35 J TROUBLES oa Gar a T e 39 9 1 Trouble or Problems with Your Wheelchair 39 9 2 VR II Controller Battery amp Diagnostics Indicatov 39 TO SPECIFICATIONS Gem E OSKO ernennen ES 41 11 CLEANING amp RECYCLING woo ccccesscscsesesessessscsesseseessessesssesesesseeseesees 42 TELCLEANIN G aeee a O OA 42 1 L2ZPOST CONSUMER REC YC LING rreren R R 42 LAWARRAN TY arera E E 43 12 1 Serial 01a 9 Ola cere ener ee nema nT meena Tre Te nem Trier nner ae rertnTrnTee TER 43 122 Warranty POIG assin 43 1 PREFACE 1 1 Please carefully read this
14. Figure 5 4 4 5 4 2 2 Swing Backward To make side transfer easy the chair is equipped with swing away arm support Lift and awing backward to remove See Figure 5 4 5 5 4 3 Knee Support Before standing it is important to adjust the knee support in depth and height and to adjust the u formed knee supports in the angle and width 5 4 3 1 Adjustment in the depth Screw or unscrew the adjusting bolt until you have reached the desired depth Keep 3 to 4 cm between the knee of the user and the knee support See Figure 5 4 6 5 4 3 2 Adjustment in height 3 different height To adjust remove bolt slide knee support to desired height and put the bolt back Tighten securely The upper edge of the knee support has to be below the patella See Figure 5 4 7 5 4 3 3 Angle Adjustment Loosen the fitting screws from the knee support and proceed with angle adjustment according to the morphology of the user See Figure 5 4 8 5 4 3 4 Adjustment in the width Loosen up the fitting screws from the knee supports and proceed with width adjustment right and left within the tube limits 22 Once adjusted tighten up the screws securely See Figure 5 4 9 Those adjustments will have to be optimized after a progressive standing session This will enable to avoid exaggerated pressure on the knees and to guarantee a good alignment of the limbs 5 4 4 Chest Strap See Figure5 4 10 5 4 4 1 The chest strap can be fitted at two different hei
15. Karma A Better Wheelchair A Better Fit Powered Wheelchair Owner s Manual Ergo Stand Series 80 KP CE Q ISO 9001 NERAL WARNING IMPORTANT Do not attempt to use the wheelchair before a qualified person has explained to your satisfaction how to operate it without risk to yourself or others Due to the change of design some illustrations and pictures in this owner s manual may not correspond to the wheelchair that you purchased KARMA reserves the right to make design modifications without further notice S WARNING Do not operate this wheelchair before first reading and understanding this owner s manual If you are unable to understand the warnings cautions and healthcare professional or technical instructions contact a dealer personnel if applicable before attempting to use this wheelchair otherwise injury or damage may occur If any procedures other than those described in this owner s manual it must be carry out by a qualified technician THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO CHANGE WITHOUT NOTICE S WARNING As a manufacturer of power wheelchairs KARMA endeavors to supply a wide variety of power wheelchairs to meet the many needs of the user However the responsibility of final selection of the type of power wheelchair to be used by an individual rests solely with the user and his her health care professional capable of making such a selection KARMA re
16. N personal communication devices such as cellular phones while the powered vehicle is turned ON 3 1 3 1 2 Be aware of nearby transmitters such as radio or TV stations and try to stay away from them 3 1 3 1 3 If unintended movement or brake release occurs turn the powered vehicle OFF as soon as it is safe CAUTION Some stores may have automatic sensor doors and alarm systems set at certain frequencies that might affect your power wheelchair 3 1 2 1 4 Be aware that adding accessories components or modifying the powered vehicle may make it more susceptible to EMI There is no easy way to evaluate their effect on the overall immunity of the powered vehicle 3 1 3 1 5 Report all incidents of unintended movement or brake 10 e release to your powered vehicle dealer or KARMA and note whether there was a source of EMI nearby 3 1 4 Important Information 3 1 4 1 20 Volts per meter V m is a generally achievable and useful immunity level against EMI the higher the level is the greater the protection will be 3 1 4 2This product has an immunity level of 20 V m without any accessories connected to it 11 4 KP 80 PARTS j f n Z a V N j ANTA g 4 A 7 Chest Strap 8 Controller 1 Back Support 2 Arm Support 3 Side Panel 9 Charging Socket 4 Rear Wheel 5 Drive Wheel 11 Knee Support 12 Foot Support 6 Front Small Wheel 12
17. ams and rivers destroying ecosystems and poisoning local water resources Improper disposal of batteries may also cause injury to unsuspecting others that come in contact with them If you come in contact with fluids or corroded powder from a battery rinse with water and contact a physician if necessary If contact with eyes occurs rinse for 15 minutes and then visit a physician Incinerating or burning a battery will cause it to explode Please see the end of section 11 Cleaning amp Recycling for more information Do not use an extension cord when charging your batteries A risk of fire and or electric shock could be encountered 29 7 INSPECTION AND MAINTENANCE 7 1 Daily Check Check the following items before driving If you find anything abnormal visit your KARMA wheelchair dealer for further inspection before using it e Is the joystick loose and or making noise e Can the joystick be turned left and right smoothly e Can the speed buttons be adjusted freely and do they function well Joystick a e Does the wheelchair stop when the joystick is released Controller completely e Does it light up when the power Is ON e Is there enough power for your trip e Does the horn work well ane e Is there any abnormal motor noise otor e Does the electromagnetic brake work properly Freewheel Mode e Do the freewheel levers work properly e Does the driver s seat recline e Do the seat angle adjustme
18. anual pushing of the power wheelchair if required 5 3 1To select neutral from the engaged position Rotating the levers located on the top of both motors forward The wheelchair will now roll freely See Figure 5 3 1 5 3 2To engage the motors from the neutral position Rotating the levers backward the gear will engage See Figure 5 3 2 i Y A A ier El ap ve p E H A 4 K PL Figure 5 3 1 Figure 5 3 2 VAN TONNE Always ensure that the freewheel levers are engaged before you turn on the controller 20 5 4 Adjustment 5 4 1 Foot Support 5 4 1 LHeight Adjustment 7 different positions Remove the screws from the front tube of frame put the foot support on the desired height and put back the screws Tighten securely See Figure 5 4 1 5 4 1 2Swing Outward In order to transfer in or out easy the separate foot support can be lift up separately See Figure 5 4 2 Figure 5 4 3 Figure 5 4 2 Figure 5 4 3 e Adjust the height of the foot support according to the length of the user sleg e Remember that adjusting the foot support at the right height means a better pressure relief along the thigh in a seated position 21 5 4 2 Arm Support 5 4 2 1 Height Adjustment Sdifferent positions Remove the screws from the back support tube adjust The desired height and put back the screws Tighten securely See Figure 5 4 4 Figure 5 4 5
19. broadcast antenna towers and amateur HAM radios NOTE Other types of hand held devices cordless phones laptop computers AM FM radios TV sets CD players cassette players and small appliances such as electric shavers and hair dryers et cetera so far as we know are not likely to cause EMI problems 3 1 2 Powered Vehicle Electromagnetic Interference EMI 3 1 2 1 Because EM energy rapidly becomes more Intense as one moves closer to the transmitting antenna source the EM fields from hand held radio wave sources transceivers are of special concern It is possible to unintentionally bring 9 SSS SS es high levels of EM energy too close to the powered vehicle s control system while using these devices This can affect your powered vehicle s movement and braking Therefore the warnings listed below are recommended to prevent possible interference with the control system of the powered vehicle 3 1 3 Warnings 3 1 3 1 Electromagnetic interference EMI from sources such as radio and TV stations amateur radio HAM transmitters two way radios and cellular phones can affect powered vehicles and motorized wheelchairs Following the warnings listed below should reduce the chance of unintended brake release or powered vehicle movement that could result in serious Injury 3 1 3 1 1 Do not operate hand held transceivers receivers such as citizens band CB radios or turn O
20. commends that power wheelchair users NOT be transported in vehicles of any kind while in a power wheelchair As of this date the Department of Transportation U S has not approved any tie down systems for transportation of a user while on a power wheelchair in a moving vehicle of any type Itis the position of Karma that users of power wheelchairs should be transferred into appropriate seating in vehicles for transportation and make use of the restraints made available by the auto industry Karma cannot and does not recommend any power wheelchair transportation systems It is the responsibility of the Durable Medical Equipment DME Dealer therapists and other healthcare professionals to determine if a seat positioning strap is required to ensure the safe operation of this equipment by the user Serious injury can occur in the event of a fall from a power wheelchair OPERATION INFORMATION Adjustments should ONLY be made by professionals of the healthcare field or persons fully conversant with this process and the driver s capabilities Incorrect settings could cause Injury to the driver or bystanders and damage to the power wheelchair and surrounding property To determine and establish your particular safety limits practice bending reaching mounting and dismounting activities in several combinations in the presence of a qualified healthcare professional BEFORE attempting active use of the power wheelchair e For individuals wi
21. d is in the center position A joystick fault is Make sure that all 8 signals indicated connections are secure The parking brakes Check the parking brake and have a bad motor connections and 9 signals connection make sure all connections are secure An excessive voltage Check the battery 10 signalsihas been applied to connections the control system 7 signals A comunication fault Make sure that joystick is indicated cable is securely connected Speed and not damaged indicator An Actuator trip Is If more than one actuator is 8 signals indicated fitted check which actuator is not Actuator working correctly Check the indicator actuator wiring 40 10 SPECIFICATIONS 41cm 0 5kg maa a Description Frame Steel DC 24V 300W rated x 2pcs Brake System Automatic Electromagnetic Brake and Manual Parking Brake VRZ OA Wheel Size Front Wheel 3 Drive Wheel 12 5 Rear Wheels 6 Range the maximum driving distance per complete charge is estimated based on the following conditions 20 C 68 F an 80kg driver brand new fully charged batteries and a constant driving speed of 9 1km hr 41 11 CLEANING amp RECYCLING 11 1CLEANING 11 11 In order to lengthen the life of your wheelchair it is suggested that you clean the wheelchair periodically if not daily especially after it is used in the rain or snow We suggest that you don t use you
22. e or Problems with Your Wheelchair You can inspect the following before taking your wheelchair to a KARMA wheelchair dealer Checking Points and Corrective Action Is the power turned OFF Turn ON the power _ Do the batteries still have power My wheelchair Is the battery indicator light not on does not start Charge the batteries Is the charger plugged into the wheelchair Unplug the charger and put It away If you cannot solve the problem by yourself contact your KARMA wheelchair dealer for help 9 2 VR II Controller Battery amp Diagnostics Indicator The following table indicates what the gauge will display for any given State The battery needs Check the connections to Eon charging or there isa the battery Ifthe bad connection to the connections are good try battery charging the battery The left hand motor Check the connections to A proe evescomecten tana oo The left hand motor Connect your service agent 3 signals has a short circuit to a battery connection e Asignals The right hand motor Check the connections to GQ eee eee a ee a has a bad connection the left hand motor Connect your service agent The left hand motor 5 signals has a short circuit to a battery connection The wheelchair Is Please remove the charger being prevented from 6signals driving by an external Signal i 6 A joystick fault is Make sure that the joystick Signals j indicate
23. em correctly as well For safety reasons if there is any risk due to the user s movement in the wheelchair or other environmental factors that might cause the wheelchair to tip or the person on the wheelchair to fall off ex an amputee besides the safety belts anti tippers that have been installed KARMA recommends that you install other additional safety accessories When using the wheelchair ALWAYS follow the Highway Code when outdoors and the guidelines written in this manual 2 SAFETY 2 1 Before Driving 2 1 1 The user must be familiar with the use and operation of this wheelchair before driving 2 1 2 Therefore please always keep these safety guidelines in mind 2 1 3 Traffic Rules 2 1 3 1 Pedestrian traffic rules apply to this wheelchair Please be sate Drive only on pedestrian areas such as the sidewalk Never drive the wheelchair on the highway 2 1 3 2 Be aware of other vehicles when crossing all roads 2 1 3 3 Be extremely cautious when driving your wheelchair in heavy traffic or the shopping mall 2 1 3 4 DO NOT drive your wheelchair when you feel tired or consume alcohol 2 1 3 5 Please do not drive your wheelchair at night 2 1 3 6 Please follow pedestrian traffic lights 2 1 4 Practice Driving 2 1 4 1 Before you are familiar with the operation of your wheelchair please practice in a wide and open area like a park To avoid 2 falling off your wheelchair please practice all kinds of driving m
24. er 6 for more detail about battery Battery fixing belt Please note there are two fixing belts You have to connect two belts together to fix the 36Ah batteries into the position if you use 50Ah batteries you won t need to connect these two fixing belts but just use them to fasten the batteries separately l 36AH Battery fixing direction 50AH Battery fixing direction 7 6 2 Circuit breaker To prevent an over loading of power from damaging the chair the circuit breaker will trip to cut the circuit route of the power If no power supply happened please also check the circuit breaker 7 6 3 Tires You don t need to inflate the tires if you use solid tires Buta regular inspection once a month of tire wear is essential When 34 you find the depth of tire tread is lower than 1mm or there is any crack on the tires please contact the service agent to check the tires and replace them if needed If you use pneumatic tires please assure the pressure of tire is sufficient for normal driving In the normal condition the solid tires and pneumatic tires have the same lifetime 8 OPTIONAL ACCESSORIES 8 1 H shaped Safety Belt see Figure 8 1 8 2 Lighting Include front tail light turning signal 8 3 pelvic seat belt 8 4 Swing away controller bracket Figure 8 1 8 5 Mudguard 8 6 Hand brake 8 Knee support 8 8 50AH Battery 8 9 headrest 8 9 1 Headrest installation Instructions 8 9 1 1 This Karma headr
25. es to Avoid 2 2 4 1 Avoid roads with heavy traffic mud excessive gravel or bumps snow and ice These conditions may damage your wheelchair Avoid roads that are too narrow or by a canal waterway without any fence hedge Also avoid places where your wheels might get stuck slip or not have traction Do not drive in a gale at night or in rainy snowy foggy misty weather These conditions may cause your wheelchair to rust See Figure 2 2 2 2 4 2 Do not drive in a S curve do doughnuts or make sudden turns 2 2 4 3 Do not take an escalator 2 2 5 Mobile Phones and Other Electric Equipment 2 2 5 1 Do not use a mobile phone or other wireless communication devices while driving See Section 3 EMI RFI 2 2 5 2 Do not charge the mobile phone or other electric devices from your wheelchair s batteries 2 2 6 Ramps Inclines and Drops 2 2 6 1 Do not drive onto a steep ramp Refer to Safe Climbing Slope in section 9 SPECIFICATIONS for your wheelchair s safe climbing angle S OOL 2 2 6 2 When climbing up to an inclined road please set the speed higher than the medium speed and drive carefully See Figure 2 3 When going down an inclined road set the speed to 1 and never use reverse 2 2 6 3 Do not drive on a road with many bumps and holes close to each other such as potholes or washboard roads See Figure 2 4 2 2 6 4 Do not make sudden turns when driving on gravel roads or ramps 2 2 6 5 The maximum surmountable obstacle height
26. est provides excellent head support 8 9 1 2 The new design allows compact folding while still attached to the wheelchair 8 9 1 3 This headrest is designed for wheelchairs with 22mm rear push handle tubes 8 9 1 4 Available sizes 8 9 1 4 1 Large for wheelchair seat widths between 42cm 50cm 8 9 1 4 2 Medium for wheelchair seat widths between 36cm 44cm and 8 9 1 4 3 Small for wheelchair seat widths between 30cm 36cm 8 9 1 5 Adjustable back forth up down and the headrest component can rotate 360 35 Attachments instructions 1pc M5 bolt amp nut 2 sets M5 5m wrench 2 pcs M3 3m wrench 1pc packng 1pc Assemby figure head support packing back forth sliding tube coupling knob Back forth gt J vr f oe m J up down d Up down Y c 6 left bracket M5 bolt amp nut 8 9 1 6 This headrest is designed to be used only as indicated in the pamphlet The manufacturer can t be held liable for any injuries sustained or damage to the wheelchair due to modification made to this device 8 9 1 7 To avoid injuries or possible damage to the wheelchair please read the owner s manual carefully before installing this device 8 9 2 Product Operation 8 9 2 1 How to Install Unfold wheelchair Loosen bolts A to allow inner tubes to slide freely Fit a p brackets C onto the curved part of push handles then tighten bolts D Have a person help by slightly pushing
27. for damage or wear and have a qualified technician replace it if necessary Check all parts for proper adjustment 7 4 4 Ensure that the batteries are properly maintained and charged as required Inspect brake for proper operation The wheels and tires should be checked periodically for cracks and wear and should be replaced by a qualified technician 7 4 5 Regularly check for loose nuts and or bolts in the front and rear wheels If loose have them adjusted by a qualified technician Clean dirt dust and grease from exposed components A qualified technician can be found with an authorized distributor dealer 7 5 Transporting and Storing 7 5 1 In order to transport easy the backrest can be folded Swing out the ring and pull out the lock pin and then the backrest can be folded see Figure7 1 Reverse the order for reassembly and make sure that the ring is put back its original position see Figure 7 2 7 5 2 Please store the wheelchair in a location where it is out of direct sunlight rain and dew When stored for a long time please charge the batteries to full and then disconnect the battery terminals For 33 more details consult your KARMA wheelchair dealer Figure 7 1 Figure 7 2 7 6 Battery circuit breaker tires 7 6 1 Battery Fully empty of power shall damage the battery and thus reduce the lifetime of the battery Please charge the batteries when they are in the condition of low power Please refer to Chapt
28. ghts between the upholstery fastening strip and backrest tube Figure 5 4 10 Figure 5 4 11 5 4 4 2 To adjust the height remove the screw put the chest strap to the desired height and put the screw back 23 WARNING Make sure that the chest strap does not get caught in the spokes when it release This chest strap is not to be used as a Safety belt in a vehicle The chest strap should be fitted below the armpit and should not loop the arm over trunk in order to avoid the hazard causing by the trunk slipping down See Figure 5 4 11 5 5 Transferring In and Out 5 5 1 Transferring In 5 5 1 1Turn off the power and engage the parking brake 5 5 1 2 Flip up the foot support 5 5 1 3 Lower the occupant into the seat and use the arm support for support 5 5 1 4 Restore the foot support 5 5 2 Transferring Out 5 5 2 1 Make sure that the chair is near your final destination 5 5 2 2 Turn off the power and engage the parking brake 5 5 2 3 Flip up the foot support or and arm support 5 5 2 4 Move your body to the destination N CAUTION Never stand on the foot support when getting in or out of the chair 24 6 BATTERIES AND CHARGER Before you attempt charging ensure you read and understand the instruction manual supplied with the battery charger and you choose the correct input voltage for battery charger 6 1 Charging the Batteries Charge your batteries if any of the following condit
29. ifting your wheelchair DO NOT operate the power wheelchair until you have checked that the Surroundings are clear and that the area is safe for Travel DO NOT use stand up function on a slope Please pay attention to the environment and to keep away from the hazard of external flame When the user is smoking pay attention to safety and make sure to extinguish the fire when finished Be alert to the environment when someone nearby is smoking or using a cigarette lighter keep away from the hazard and use fire proof cloth DO NOT use parts accessories or adapters other than those authorized by Karma Before attempting to sit in or exit the power wheelchair turn the power OFF This will ensure that the power wheelchair will not drive Turn the power OFF while the wheelchair is not in use Otherwise injury and or damage to the wheelchair and surrounding property may occur DO NOT connect any medical device i e a ventilator life support machine et cetera to the battery This could cause unexpected failure of the device and the power wheelchair KARMA specifically disclaims responsibility to all personal injury and property damage that may occur during use which does not comply with applicable federal state and local laws and ordinances e DO NOT stand on the footplates of the power wheelchair while the wheelchair is in the seating position e DO NOT tow the wheelchair by other vehicles cars motorcycles or bicycles etc Only use
30. ions occur 6 1 1 If you have used your wheelchair for more than an hour continuously 6 1 2 You ve used more than one third of the total charge 6 1 3 When you haven t used the wheelchair for more than two weeks 6 1 4 If the current charge is not enough to reach your final destination 6 1 5 Be sure to follow the procedures precisely listed below 6 1 6 Turn the wheelchair OFF 6 1 7 Connect the charger s cord to a power outlet 6 1 8 Connect the charger s plug to the charging socket See Figure 6 1 6 1 9 The charging time is at least 6 hours but it could be as long as 10 hours depending on the status of the batteries and temperature 6 1 10 When the charging is completed disconnect the cord and pull out the round plug from the charging socket Figure 6 1 25 Do not disconnect the charger cord if the charging is not completed The battery life will be seriously shortened or decayed if the batteries are repeatedly used without being fully charged Therefore be sure to always charge the batteries fully Always complete the charging by letting the charge LED light turn green NEVER stop charging before it is complete When finished charging disconnect the charger plug from the charging socket as soon as possible Even when the charger is turned OFF the electric power will slowly discharge if the cord is not disconnected DO NOT leave the charger ON connected to the wheelchair for more than 24 hours Charging time de
31. is 5cm for your wheelchair Exceeding this obstacle height will damage your wheelchair and negate your warranty See Figure 2 5 2 2 6 6 When negotiating an obstacle slow down put your seat into the full upright position and approach it head on perpendicular Just before the obstacle speed up until the entire wheelchair has conquered the obstacle Negotiating an obstacle at an angle may cause your wheelchair to tip over Don t do it 2 2 6 7 When climbing down a curb slow down just before you get to it and only speed up after the entire wheelchair has lowered to the road Again descending obstacles should be done perpendicularly See Figure 2 6 2 2 6 8 Karma does not design wheelchairs to take jumps over or off obstacles Doing so will negate your warranty S WARNING e Do not set the wheelchair in freewheel mode when on an incline or decline If you breakdown on railroad tracks first check for an oncoming train Ifa train is coming get out of its way immediately If no train is coming set to freewheel mode and push the wheelchair off the tracks 2 2 Maximum User Weight Limit 2 2 7 1 Refer to Max User Weight in section 9 SPECIFICATIONS Loads exceeding maximum capacity can damage your wheelchair and cause malfunctions yielding a safety hazard The warranty does not cover damage caused by improper operation of the wheelchair Caution Figure 2 2 Figure 2 3 Figure 2 4 Caution Caution Figure
32. me an obstacles superior to 50 mm e Use an elevator to move an occupied power wheelchair between floors If moving a power wheelchair between floors by means of a stairway the occupant MUST be removed and transported independently of the power wheelchair Extreme caution Is advised when it is necessary to move an UNOCCUPIED power wheelchair up or down stairs Karma recommends disassembling the wheelchair and transporting the components independently up or down stairs Make sure to use ONLY secure non detachable parts on each component for hand held supports e DO NOT attempt to lift a power wheelchair by any removable detachable parts Lifting by means of removable detachable parts may result in injury to the user or assistants or damage to the wheelchair ESCALATORS SORRY DO NOT use an escalator to move a power wheelchair between floors Serious bodily injury and damage to the wheelchair may occur YOU AND YOUR KARMA SERVICE PROVIDER e No tools are required for assembly Your wheelchair should be assembled by your authorized Karma dealer Your authorized Karma dealer is also your service provider Unauthorized repairs upgrades and add ons will void your warranty Anything wheelchair related that requires tools should be performed by your authorized Karma service provider Your Karma service provider has the necessary service manual for your wheelchair e Ifyou have any defective parts or lose any parts please contact your
33. ms listed below are not covered 12 2 2 1 Consumable parts such as brake shoes or pads clutch shoe and lining light bulbs fuses upholstery and seating brake cable oil seal packing and gasket screws bolts and washers lubricant oil and grease carbon brush inside the motor battery liquid footrest carpet et cetera 12 2 2 2 Those that do not affect the quality and functioning of the wheelchair such as noise or vibration 12 2 2 3 Wear and tear resulting from usage as well as conditions resulting from lapse of time e g normal aging and deterioration of paint electroplating plastic parts etc 12 2 2 4 Damage due to a lack of maintenance or improper operation and storage 12 2 2 5 Fees for routine inspections adjustments adding oil cleaning and other maintenance 12 2 2 6 Fees for regular inspections and maintenance and 12 2 2 7 Any fees incurred as a result of warranty repair loss or compensation because of the unavailability of the wheelchair teleohone use shipping car rental travel costs et cetera 12 2 3 Problems Not Covered Problems caused by the following reasons are not covered 12 2 3 1 Failure to carry out the regular inspection and maintenance recommended by this owner s manual 12 2 3 2 Improper storage 12 2 3 3 Tampering by changing or adding components to the vehicle which are not approved by KARMA 12 2 3 4 Damage caused by using non KARMA genuine parts or other parts not recommended by KARMA 12
34. nt knobs or buttons work Driver s Seat properly e Does the surface of the seat remain or break 7 e Are there any cracks or other damage to the tires ires e Check the tire tread depth and air pressure Other Je Is there any abnormal noise N CAUTION e Visit a KARMA wheelchair dealer for inspection and maintenance if you find anything abnormal 30 7 2 Regular Maintenance Record To make sure your wheelchair is in good condition visit your KARMA wheelchair dealer regularly for maintenance and keep records accordingly every six months after purchasing A maintenance service fee may apply e Even if you don t use the wheelchair for a long time the wheelchair should still be maintained regularly You should clean your wheelchair inside and out regularly to keep it beautiful and safe I Inspection A Adjustment A Repair 3 Replacement T Tightening L Add Ol itenfPeriod Gn Months 1 6 2 38 24 30 joysickContlunt SYS ls rer Tritt aly a va prt hal DEOR af f Connection to the Electrical System I Ea I Loose or Corroded Terminals Connection to the Electrical Batteries System Damage to the Electrical Cord Cable 31 Set CCT a AAAA Tires TreadDepth oiei Abnormal WearPatemn al Wheel fightnessofBottsandNuts t 1 kim Wear or Deformation Around Tres ws ws 7 3 Tires 7 3 1The condition of the tires is affected by the way you drive and use
35. otions such as accelerating stopping turning reversing and going up and down ramps Please set the speed to medium when you first start practicing Be safe Make sure someone accompanies you In case you need assistance 2 1 4 2 Be sure you are able to control and operate your wheelchair easily and confidently before you move the speed higher 2 1 5 No Passengers 2 1 5 1 KARMA wheelchairs are limited to one single driver Do not carry passengers including children on your wheelchair 2 1 6 No Hauling Heavy Goods 2 1 6 1 Do not use this wheelchair to carry or haul heavy goods 2 1 6 2 The maximum weight that can be carried including goods is Stated beside Max User Weight in section 10 SPECIFICATIONS 2 1 7 RAIN 2 1 7 1 This product is not guaranteed to be water resistant Please do not drive In the rain through puddles or spray water to clean this product Figure 2 1 2 2 WHILE MOVING 2 2 1 Please carry out daily inspections Refer to section 7 1 DAILY CHECK 2 2 2 General Warning 2 2 2 1 Do not lean over the side of the wheelchair as such an action may cause you to lose balance and fall Use caution to assure your clothing doesn t get tangled with the wheels 2 2 3 Railroad Crossing 2 2 3 1 Before crossing the tracks please stop completely and look both ways Cross the tracks perpendicular to avoid your wheels getting stuck 2 2 3 2 Do not drive at full soeed over railroad tracks 2 2 4 Circumstanc
36. pends on the surrounding temperature it takes longer in the winter Please follow the guidelines below to avoid accidents while charging Be sure to only use a KARMA approved battery charger and charge the battery completely every time The battery can be damaged if a non genuine charger is used Never disassemble or modify the charger This will negate the warranty Please charge in a well ventilated area where the battery is not directly exposed to sunlight Do not charge the battery under rainfall in morning dew or in an area where the humidity is high Do not cover the wheelchair with any waterproof cloth or other objects while charging Don t charge in temperatures less than 10 C 14 F or higher than 50 C 122 F as the charger may not work well and the battery may become damaged The charger is not guaranteed to be water resistant Valve Regulated Lead Acid batteries do not have a memory function like cell phone batteries have Please get in the habit of recharging your VRLA batteries frequently S WARNING e Keep your wheelchair away from flammable objects while charging as it may lead to fire or explosion of the battery Since the battery may produce hydrogen do not smoke while charging and charge in a well ventilated area Never connect or disconnect the plug cord with wet hands or if the plug cord is wet to avoid possible electric shock Never attempt to recharge the batteries by attaching cables direc
37. r wheelchair in the rain or snow If you are traveling and get caught in the rain we suggest you try to find shelter and turn OFF your wheelchair while waiting it out If you can t find shelter proceed to your destination However we do not recommend you do this often as it may shorten the life of your wheelchair or cause damage 11 1 2 Driver s seat upholstery use soapy water Wring out the sponge cloth before scrubbing Do not use the wheelchair until it is dry 11 1 3 Frame wipe with a damp cloth but be sure not to splash spray the wheelchair with water as doing so may damage the motor electrical wiring and battery If compressed air is available you can use the compressed air to clean your wheelchair do not exceed 7Kg cm 2 and keep the nozzle at least 10cm away from your wheelchair 11 1 4 Casing wipe with a damp cloth After it is dry coat the casing with a light layer of wax if desired 11 2POST CONSUMER RECYCLING 11 2 1 A post consumer recycling plan should follow the Environmental Protection Administration s regulations The items listed below are for reference only as local law and regulation may vary Aluminum alloy Recyclable Motor Reduction Gear Recyclable 11 2 2 There are many organizations in many countries you can find on the internet that will accept used goods for charity or disassemble electronic equipment and batteries to recycle them Please search the information highway to help less fortunate individuals
38. rear handles of wheelchair apart Cjbracket simultaneously lift the center joint B as d F high as possible in order to obtain A tanto adequate support tension for headrest then tighten bolts A 36 8 9 2 2 How to use X p er Tt When using wheelchair unfold wheelchair first then prop up the headrest 4 Conversely when folding wheelchair first pull down the headrest to release the support tension then fold wheelchair 8 9 3 Maintenance 8 9 3 1Routine Maintenance Keep headrest clean Check the rotation Check bolts and tighten and dry mechanism of headrest Apply some lubricant on Avoid water don tlet it become the bolts Don t expose to direct loose sunlight for extended Tighten the bolts of periods of time headrest and wheelchair 8 9 3 2 Self Inspection Ensure the headrest Mechanism is not loose Check frame for cracks unfolds and the side or cracked tubes are folded Check bolts of frame for upward looseness Headrest is tightened Headrest is clean 3 8 9 3 3 Suaton Situation Possible Problem Headrest is unstable The bolts are loose Check bolts of the frame and tighten them The headrest can tbe The bolts are Please loosen the bolts overtightened a little The inner outer tubes Clean the inner tubes are dirty and apply a little lubricant between the inner and outer tubes 38 9 TROUBLE SHOOTING 9 1 Troubl
39. s an extremely durable steel frame with tough accessory and does not suffer in dramatic extremes of temperature neither user nor attendant need touch metal parts in normal use e The stand up function operates exclusively on a flat surface away from any stairs access ramp or slope vii e Check with your local government as to legislation pertaining to mobility vehicles to assure your legal requirements to drive on public roads have been met i e a safety belt lighting registration or licensing CE MARKING e This power wheelchair complies with the requirements of the Medical Devices Directive 93 42 EEC vill TABLE OF CONTENTS LARR EPA E cect a AR arse ates pve se pierces ess coe ena eae 1 APET Y oe E EEA 2 DM BETONE DIVIN G eee n E 2 ZNN AILE MOVING srein Mecca cs teeed casa does ecaecanatacatateacaeadee eciceet aie 4 23 KP G0 ABE LIN G srein a bana ulcah ase E theta acess 7 EMR eects case ame toctntg aaa tum E ete meee 8 3 1 Electromagnetic Interference From Radio Wave Sources 8 RP OO PART aa ee een re ee 12 OPERA TORNE A E cate ase aan atin ceca tegen eeaitas sad tet ale aaa 14 5 1 VRI Joystick Controller occ ccsssessssessssecsssecsssecsseessneessneeen 14 5 2 How to Operate Your wheelchair 14 5 3 Freewheel LOVES ou ecccsesssssssssssessssecsssecssssecsssecsssecssnecssneecssscesssecesneces 20 BGS OM acre 21 5 5 Transferring IN AN OUt iu ecccsssessssssesssssecsssseccsssseccesssecsesneecessee 24 O BATTERIES
40. th balance problems practice mounting and dismounting activities WITH AN ASSISTANT in the presence of a qualified healthcare professional e Ifso equipped DO NOT operate the wheelchair without anti tippers being installed Anti tippers MUST BE attached at all times e DO NOT attempt to reach objects if you have to move forward in the seat or pick them up from the floor by reaching down between your knees as this may cause loss of balance e DO NOT lean over the back of the chair to reach objects behind you as this may cause the power wheelchair to tip over e DO NOT shift your weight or sitting position toward the direction you are reaching as the power wheelchair may tip over DO NOT use an escalator to move a power wheelchair between floors Serious bodily injury may occur DO NOT operate in car lanes on roads streets highways etc DO NOT attempt to move up or down an incline with a water ice or oil film DO NOT attempt to ride over curbs or obstacles Doing so may cause your power wheelchair to turn over and cause bodily harm and or damage to the power wheelchair DO NOT make sharp turns in forward or reverse at excessive speeds DO NOT attempt to lift the power wheelchair by its casings and seat DO NOT attempt to lift the power wheelchair by any detachable parts Lifting by means of any detachable parts of a power wheelchair may result in injury to the user or damage to the power wheelchair Please hold onto the frame when l
41. the vehicle Exceeding the specified temperature range can lead to either freezing or overheating of the batteries This will damage the batteries and shorten their lives 6 3 2The batteries used on your wheelchair are maintenance free sealed lead acid batteries 6 3 3Thus it is not necessary to change or refill the battery liquid S WARNING Do not open the battery seal cap at any time After ANY adjustments repair or service and BEFORE use make sure that all hardware is tightened securely Otherwise injury or damage may occur When removing installing batteries keep all foreign objects especially metal away from battery terminals e Place the power wheelchair in a well ventilated area where work can be performed without risking damage to carpeting or floor covering e Failure to use the correct battery size and or voltage may cause damage to the power wheelchair and give unsatisfactory performance S WARNING There are many risks involved with improper disposal of batteries whether damaged or not Batteries may contain heavy metals and be considered hazardous waste Many regions around the world now strictly enforce laws to help protect Our environment By not disposing of batteries properly you may be liable for fines from your local through national government By not recycling batteries they end up in landfills that are already low on Space From these land fills lead and other chemicals may leach into stre
42. tly to the battery terminals or clamps DO NOT jump start your wheelchair Do NOT attempt to recharge the batteries while the power wheelchair is in operation New batteries MUST be fully charged prior to initial use of the power wheelchair Always charge new batteries before initial use or battery life will be reduced As a general rule recharge batteries as frequently as possible to assure the longest possible life and to minimize required charging time Plan to recharge them when use of the power wheelchair is not anticipated 6 2 Charger The battery charger supplied by Karma is for indoor use only and it must be protected from moisture and external heat source e Before charging make sure to set the 115V lt gt 230V switch to match the local AC voltage e If the switch is improperly set to a lower or higher voltage position it will cause damage to the charger and battery Change the 115V lt 230V switch settings only when charger is disconnected from AC line voltage 2 Oc e The fan inside the charger will start to work when you turn on the charger 8A will start to work as temperature is over 50 C and stop running under 50 C e If you find that the fan does not function properly DO NOT use the charger Otherwise the charger may overheat and start a fire 6 3 Batteries 6 3 1Do not expose the batteries to temperatures below 10 C 14 F or above 50 C 122 F when charging or storing
43. ty level The higher the immunity level is the greater the protection will be At this time current technology is capable of achieving at least a 20 V m immunity level which would provide useful protection from the more common sources of radiated EMI This powered vehicle model with no further modification has an immunity level of 20 V m without any accessories There are a number of sources of relatively intense electromagnetic 8 ee Sey fields in our everyday environment Some of these sources are obvious and easy to avoid Others are not apparent and exposure could be unavoidable However we believe that by following the warnings listed below your risk to EMI can be greatly minimized 3 1 1 The sources of radiated EMI can be broadly classified into three types 3 1 1 1 Hand held portable transceivers transmitter receivers with the antenna mounted directly on the transmitting unit such as citizens band CB radios walkie talkies security and fire or police transceivers cellular teleohones and other personal communication devices NOTE Some cellular telephones or similar devices transmit signals while they are ON even though they are not in use 3 1 1 2 Medium range mobile transceivers used in police cars fire trucks ambulances and taxis usually having the antenna mounted on the outside of the vehicle and 3 1 1 3 Long range transmitters and transceivers such as commercial broadcast transmitters radio and TV
44. yi dealer for repair and or replacement Please only use parts authorized by Karma Use of parts that are not authorized by Karma will negate your warranty e Part numbers are listed on our bill of materials explosion drawings which we give to our authorized dealers and service providers Customers should order parts through their dealer as well as all repairs and scheduled maintenance e Customers should go to their dealership for all service needs to guarantee their warranty is not void Always go to an authorized service provider e Unauthorized repairs will void your warranty Procedures other than those described in this manual must be performed by a qualified technician e They also have the service manual with a complete list of maintenance required to keep your Karma wheelchair in top performance Check the warranty section of this manual to find out what Karma guarantees and what maintenance and parts you will have to pay for e Karma does not have an official list of service providers at this time Please contact your dealer for service If you cannot contact your dealer please contact another authorized Karma dealer for service If all else fails contact Karma directly via our website or give us a call and we can refer you to your new service provider CLASSIFICATION amp INTENDED USE e KP 80 is classified as a class A mobility product for indoor use This wheelchair is suitable for users up to 135 kg in weight It also ha
Download Pdf Manuals
Related Search