Home

Battery

1. press the 2 button for 2 seconds to zero cleaning MOVEMENT TIME TIME TIME 086 8 Show movement time Long press the button for 2 seconds to zero cleaning AVERAGE SPEED AVG AVG 48 B B e Show average speed average speed trip distance movement time speed resolution is 1km h mil h full range is 99 km h or 99mil h DIAGNOSTIC CODE cr ed 1 dddd Show diagnostic code Once the system has error the diagnostic code will be shown on the screen The format is EOX E02 Motor hall sensor failure or Motor cable short circuit E03 Controller failure E04 Throttle failure E08 Under voltage alarm Hiding function To enter the hiding function you should press tandc for 3 seconds on start up interface Then all the items show up Then press 2 to choose the functions ODO TRIP AVG TIME di cc km h 6 km h WHEEL DIAMETER D1 Li of HH Press t to do the wheel diameter selection Use and to adjust the wheel size from 8 28 Default value IS 26 SPEED SENSOR SELECTION kek Press t to choose the speed sensor Use and buttons to switch the data from 1 to 12 the num ber represents this number signals output per circle SPEED UNIT SELECTION KM H MIL H 68 B B xx Press 2 to select the speed unit Use to switch between km h and mil h Default is km h WALK ASSIST FUNCTION 6KM H FUNCTION Press to ent
2. Fix the spokes The range of the e Charger broken e Test new charger battery is to short e Battery broken e Test new battery The motor turns un e Kit has been set e Change to Pedelec til it reach 25 km h as E Bike System only possible at your dealers site also without pedal ling 22 Charger is connect ed with the battery and a receptacle with 230 Volt No lamp is shining Charger is connect ed with the battery and a receptacle with 230 Volt The red lamp is shining Charger broken No electricity in the receptacle Contacts are oxi dizing Charger broken Battery broken Test new Charger Check the receptacle Clean the contacts with contact spray Test new Charger Test new Battery 23 14 Technical Data Motor Central motor Nominal power 250 Watt Maximal power 400 Watt 90 Revolution per minute Battery Li Ion battery pack with 9Ah 36V 324Wh Li Ion battery pack with 11Ah 36V 396Wh Li Ion battery pack with 15Ah 36V 540Wh Riding distance 9Ah 50 60km 11Ah 60 70km 15Ah 80 100km Charger Input voltage 230 Volt 50 Hz Charging voltage 36 Volt Charging amperage 2 Ampere Charging time 5 6 hours We hope you enjoy using your e kit and wish you always a good ride with your Schachner electric drive unit y Ai Schachner GmbH Gewerbepark Polla 6 A 3353 Seitenstetten x So Tel 43 0 7477 42973 Fax DW 13 UID Nr ATU52754700 ZY _ _ office elektrobikes com www elektrobikes
3. free The battery has to be dis charged or secured against short circuit So please take off the fuses from the battery for this purpose It is also possible to send in the old battery for example to get a new one directly to us the manufacturer 12 Safety guidlines Do never open the controller battery motor or other parts to undertake reparations or engagements yourself It would not only be too big risk of injury also the warranty time will not be prolonged Although all electric parts are shield from spray water they should not be exposed for longer time to rain or constant wetness To avoid development of condensation wa ter it would be advisable to park the bike on a dry and aerated place We want to discourage of cleaning controller motor or battery with a high pressure cleaner because water can in vade By a short circuit in the electric circuit battery or other parts can be destroyed This can require expensive reparations which can NOT be made as warranty Although the batteries voltage from only 36 Volt is not dan gerous for people currants of some hundreds Amperes can flow during a short circuit 20 To have an idea from the energy content of your small and harmless looking battery please consider that it would be possible to start a big heavy diesel engine of a truck without any problems with this battery Project the electric drive unit from moisture Avoid dropping Spraying and rain water Clean all
4. nn nn nn nn nn nn nn nn 11 Function description charger ccccccccsccceececeeeeeeeeeenenenenes 12 Function description Battery nunsnsnnnnnnnnnn nn nn nn nn nn nn nn nn nn 13 Handling and function of the LCD display ccccseneeeees 15 BIEVCIE OPETAUON nennen 19 ISOS scene cone cenecenacsaesonen snes onexeaersneneauaeaeneauanaeananaanauanaee 20 Safety QUIGIINES sisinesinasinasinasinasietmetnsisinimatnarnaanets 20 ERROR SCAT ee 22 Technical Data sans nennen 24 x To avoid faults please read the operating instructions very carefully before putting the e kit into operation This kit offers numerous functions which can only be used opti mally by using the kit in the right way This is also important to reach optimal life cycle and distance When a malfunction occurs please take the operating instruc tions check the cable connections and try to patch the fault In case a malfunction cannot be repaired from your side please contact your specialized dealer Reparations should always be done from a qualified specialized dealer 2 Warranty According to the European warranty law from 01 January 2002 we grant a legally warranty of 2 years The warranty peri od begins from handing over of the kit Please keep the invoice for time of warranty to proof the purchase respectively the hand over date When spare parts are mounted in the time of warranty the warranty time will not be prolonged x Ss The warranty for t
5. on the model and it has a cable which leads to the controller The lock protects the battery from dropping out of the carrier and from thefts 7 Function description charger For charging you can take out the bat tery or charge it directly on the bike The temperature of the battery should not drop below 5 C or exceed 35 C while charging otherwise the battery cannot be charged a As soon as the battery is out of the recommended temperature the red lamp of the charger shines Out Ss of this reason please let the battery cool down after driving and charge it only cooled down To charge the battery please act as follows Put the charger and the battery on a non flammable base for duration of charging First connect the charger with the battery and after that please connect the charger with a 230 voltage receptacle The charging procedure begins promptly The red lamp is shining The charging procedure takes about 5 hours for an empty bat tery depending on the capacity The charging rate amounts approximately 2 Ampere and the charging voltage 36 V As soon as the battery is completely loaded the charging will be stopped automatically The green lamp on the charger is light x The best time for recharging the battery is at night So N the battery will be fully loaded next morning Over loading is impossible If you are using a new battery or again after longer storage the distanc
6. SCHACHIER ELEK TROFAHRZEUGE Bedienungsanleitung Mittelmotor MM15 Preface Dear client We want to congratulate on your acquisition of a Schachner cen tral motor electric kit We are glad to inform you about opera tion maintenance and care of our e kits on the following pages You bought a product from Austria which have been technically improved during more than 24 years and is approved in Europe for 10 000 times The electric kit has been developed for people who like to be in motion but feel that riding a bike up a hill or with headwind is too hard for them It is particularly strong robust and totally maintenance free for people who attach importance to quality health security reliability and long life The Schachner e kit has been developed in Austria especially for mountain cyclists and it proved very well We hope you enjoy using your new e kit and wish you always a good secure and accident free ride best regards felachowr S y Schachner GmbH Gewerbepark Polla 6 A 3353 Seitenstetten Na Tel 43 0 7477 42973 Fax DW 13 UID Nr ATU52754700 AUSTRIA office elektrobikes com www elektrobikes com iO ON AD UM HRW N e fad e e e e A W N e O Index MOC ea 3 Waran a a 5 SCODE Ol SUD IONY ersen steeper meno eteenierecnisrecroiits 7 DFIVIRG ODEra OT 9 Function description MOtOr us2snnnnnnnnnnnn nn nn nn nn nn nn nn nn nn 11 Function description Carrier zuasnsnnnnnnnnnnnn nn
7. able The battery can for gt example when you make a tour for several days be fully recharged during the night The connector on the battery is for connecting the charger It should always be closed with the cover only open to charge to protect the contacts from dirt and moisture 9 Handling and function of the LCD display Display dimensions 102 5mm 74 5mm 28mm Pili p ia Mode On off D Press this button to power on the LCD display Long pressing the button for 2 seconds to power off Automatically shut off without any operation in 5 minutes There are 5 modes OFF ECO TOUR SPEED TURBO switching Press this _ button to adjust the power assist Default is ECO mode TURBO E TURBO fr if TURBO ff TURBO ay SPEED I SPEED E Z SPEED T f SPEED T A TOUR T TOUR T TOUR T TOUR T ECO E ECO 4 ECO E ECO W t Press this button the modes loop switch as below ODO TRIP AVG TIME The default option is ODO Normal function BACKGROUND LIGHT Press this button under the system is switched on the background light D turns on Press again to switch off again Output voltage is 6V TRIP DISTANCE TRIP BBBB Show the one way trip distance max data is 999km Under trip distance press the button for 2 seconds to zero cleaning ODOGRAPH ODO 0000 Show total mileage the max data is 9999km Under trip dis tance
8. ce controller integrated in the motor motor with connection cable and torque sensor carrier charger speed sensor with magnet crank set user manual assembling tools Battery 9Ah 11Ah 15Ah If you have acquired the e kit completely assembled you only receive a charger and this operating instruction added to the bike All other parts are already assembled Assembling schedule Display with Carrier Central motor Controller 4 Driving operation A bicycle with Schachner e kit is according to the European draft standard prEN 15197 an EPAC Electically Power Assisted Cycle also called pedelec pedal electric cycle The Schachner Pedelec is a bicycle including drive support It is equipped with an electromotive auxiliary drive with a maximum continuous rating of 250 Watt The driving speed with motor power is limited to 25 km h and the maximum power output is bounded to 400 Watt The motor performance dependens on the footwork of the cy clist Because of that pedelecs are rid of approval insurance and driving licence obligations and are not subject of age re Striction Additionally we offer a starting help which brings you in motion Safely When you pedal stronger at the start in the case of headwind and when driving up a hill the distance you can reach with a charged battery can be increased a lot With the help of the shifting system you can regulate t
9. com T AUSTRIA 24
10. e you can reach with one full load will increase during the first charging processes In the winter we recommend to store the full charged battery in a dry area As the battery discharges also when it is not in use you should load for some hours every 6 weeks so that the bat tery will not be damaged because of over discharging Before setting out the first run please load up the battery again 8 Function description Battery 9 Ah 11 Ah 15 Ah NCM Battery battery integrated in the luggage carrier riding distances 9Ah 50 60km 11Ah 60 70km 15Ah 80 100km weight 9Ah 2 8kg 11Ah 3 0kg 15Ah 3 1kg very favourable power weight ratio strong power high reach tery when you push the red button The bat tery is empty if only the red lamp is light The length of the way you can drive with a full battery charge depends decisive on structure of the way ambient temperature head wind tyre pressure weight of the driver age of the bat tery as well as how often you use the motor and how strong you pedal So you can reach a high range recharge the battery fully after every run drive mainly with a low supporting step avoid to use the electronic drive all the time Check tyre pressure every month 3 5 to 4 bar Oil the chain every 200 to 300 km For long driving distances you can take the charger x in a bag with you Eventually stop offs increase the x range of the battery not
11. er into 6km h function Then press to switch on off the starting aid Default is off 10 Bicycle operation Put your battery into the carrier lock it and detract your key Press the MODE button on the display to switch on the display The bicycle is ready for driving To use the starting aid press i button and to switch it on The starting aid will support your for maximum 10 seconds af terwards it will stop automatically When you start to ride please choose your accurate supporting level of the motor After that you can ride your E bike just like a normal bike and pedal as you like and the motor will support you during riding Depending on your chosen motor support lev el the motor will support you more or less As the torque sensor is integrated in the motor system the force you put on the pedal is measured and according to the chosen support level you will get more or less motor support Example If you drive upwards a hill or mountain you have to pedal stronger The torque sensor will recognize that and will output more power to support you and to disburden you 11 Disposal The battery needs to be disposed according to the guideline 2006 66 EG from European parliament and council with separate waste and may not be disposed with the normal garbage As consumer you are legally liable to dispose the old battery pack according to the regulations You can give the old battery to every public collection point
12. he battery is half a year because Ss it is a consumable article We offer you a half year more for our high quality batteries We can only guarantee handling by warranty if you submit the battery including invoice For batteries which can not be sold for longer time you have to secure regular charging If not the warranty time will not be prolonged The warranty does not refer to damages occurred by improper use and irresistible force all parts of a bicycle which are subject to a wear and tear conditional on the function as far as there are no produc tion or material faults damages occurred by improper or defectively care and reparations modifications or exchanges which have not been done professionally belated added parts which do not belong to the scope of supply at time of hand over or damages that occur of not professional assembly of those added parts damages occurred by oxidation corrosion and environmen tal impacts Entitled warranty demands are present if a production or material fault exists the complained damage or fault already existed at the time of hand over to the customer the damage or the fault causally occurred because of an in tended deallocation from Schachner GmbH The warranty includes all necessary spare parts Further demands are excepted 3 Scope of supply When you acquire an e kit from Schachner GmbH it consists of the following parts LCD display with button devi
13. he pedal ing speed in relation to the driving speed You need least of power when you pedal 40 to 60 times a minute Athletes pedal around 100 times a minute When you drive up a hill and the driving speed gets lower you can switch to another gear to keep the regular pedalling frequency P You can regulate the assistance of the e kit also with KA out throttle grip but with pedalling frequency To do x this please pull out the connector of the throttle grip from the controller and switch on the controller again The complete power unit is very light and when the motor is turned off it is totally separated from the bike Also without switching on the e kit you have a very manageable and smooth ly running bike x First of all please ride the bike without help of the motor to familiarize with ride comfort function of shifting system and brakes 5 Function description Motor You have acquired a totally maintenance free high performance central motor The nominal speed is 90 revolutions per minute the nominal performance is 250 Watt and the maximal performance is 400 Watt The motor is mounted in the bottom bracket instead of the bot tom bracket To avoid damages it is recommendable to let reparations be done by professional workshops which also check and secure the correct function of the brakes 6 Function description Carrier The battery is located in the carrier or directly fixed in the frame depending
14. parts of the electric drive unit only with a soft cloth and not with stridently polish and cleaning agents Please put charger and battery always on an not flammable base for the time of charging Do never cover battery and charger Only use the supplied charger The height of the charging currant and automatically cut off af ter charging is very important for the lifetime of the battery 21 13 Error search Electric kit cannot be e Switched on No lamp is shining The controller can be turned on but turns off automati cally itself after a short time when use the throttle grip You can hear a crack from front wheel under pollu tion Battery is empty e Battery fuse bro ken e Main cable broken e Controller broken e Display broken e Display cable bro ken e Battery is empty e Battery fuse bro ken e Battery is broken e Carrier is broken e Connector broken e Controller got too warm e Controller is bro ken e Not enough grease on the freewheel or toothed wheels in motor e Spokes are loose e Charge battery e Check or replace the fuse e Check the main cable e Test new controller e Test new display e Test new display cable e Charge battery e Check or replace the fuse e Test new battery e Test new carrier e Test new connectors e Cool down the control ler and try again e Test new controller e Letthe freewheel and toothed wheels grease with molykot grease e

Battery

Contents

Download Pdf Manuals

Related Search

Related Contents