OVS-CHX8130SQB-40 - KOBE Range Hoods
Contents
1. PLEASE READ THIS SECTION CAREFULLY BEFORE INSTALLATION A WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK OR PERSONAL INJURY OBSERVE THE FOLLOWING 1 Installation and electrical wiring must be done by qualified professionals and in accordance with all applicable codes and standards including fire rated construction 2 When cutting or drilling into wall or ceiling be careful not to damage electrical wiring or other hidden utilities 3 Ducted fans must be vented to the outside a Before servicing or cleaning unit open the light panel and SWITCH POWER OFF AT SERVICE PANEL b Clean all grease laden surfaces frequently To reduce the risk of fire and to disperse air properly make sure to vent air outside DO NOT vent exhaust air into wall spaces attics crawl spaces or garages NOTE This warranty is void without an authorized agent s receipt or if unit is damaged due to misuse poor installation improper use mistreatment negligence or any other circumstances beyond the control of KOBE authorized agents Any repair carried out without the supervision of KOBE authorized agents will automatically void the warranty KOBE will not be held responsible for any damages to personal property or real estate or any bodily injuries whether caused directly or indirectly by the range hood A WARNING TO REDUCE THE RISK OF PERSONAL INJURY IN THE EVENT OF A RANGE TOP GREASE FIRE e Keep all fan baffle spacer filter oil tunnel oil cont2. hood E Screws package F 6 Round Plastic Collar G Hood Mounting Bracket H Duct Cover Mounting Bracket E S 3 16 x 3 8 6 Pcs Pre installed FOR MORE INFORMATION PLEASE VISIT OUR WEBSITE www KOBERangeHoods com OR CONTACT KOBE RANGE HOODS AT 626 775 8880 3 INSTALLATION PLEASE READ ENTIRE INSTRUCTIONS BEFORE PROCEEDING Calculation before installation To calculate the length of the installation please refer to Table 1 All calculation is measure in inches TABLE 1 A Height of Floor to Ceiling B Height of Floor to Counter Top Standard 36 C Preferred Height of Counter Top to Hood Bottom Recommended 26 to 30 D Height of Hood E Height of Duct Cover F D F Height of the Hood Installation A B C A SAFETY WARNING HOOD MAY HAVE VERY SHARP EDGES PLEASE WEAR PROTECTIVE GLOVES IF REMOVING ANY PARTS FOR INSTALLING CLEANING OR SERVICING NOTE BE CAREFUL WHEN USING ELECTRICAL SCREWDRIVER DAMAGE TO THE HOOD MAY OCCUR Preparation before Installation NOTE TO AVOID DAMAGE TO YOUR HOOD PREVENT DEBRIS FROM ENTERING THE VENT OPENING Decide the location of venting pipe from the hood to the outside Refer to Figure 1 A straight short venting run will allow the hood to perform more efficiently Try to avoid as many transitions elbows and long run as possible This may reduce the performance of the hood Use
3. carrier will furnish you with necessary forms for filing a claim DAMAGES CAUSED DURING TRANSIT ARE NOT COVERED UNDER OUR WARRANTY PLEASE INSPECT CONTENTS OF PACKAGE S CAREFULLY UPON RECEIVING We must be notified in writing of any damages and or missing parts within the allocated days upon your receipt of package s CLAIMS WILL NOT BE ACCEPTED AFTER THE ALLOCATED DAYS NOTE ITEMS WERE THOROUGHLY TESTED AND CAREFULLY PACKED IN OUR FACTORY BEFORE SHIPPING Products must be returned in good working condition with ALL original parts and documentation packed in ALL original cartons fillers and shipping cartons EXCHANGES OR RETURNS MAY NOT BE ACCEPTED IF ANY PACKAGING IS MISSING MAKE SURE TO INSPECT THE HOOD FOR DAMAGES AND DEFECTS BEFORE INSTALLATION Appearance flaws of the hood found after installation and not affecting hood performance is not covered under our warranty for returns or exchanges A Before Installation Return for exchange or refund please see above for acceptable returns B After Installation NO exchange or refund 17 WARRANTY WARRANTY CERTIFICATE KOBE Range Hoods referred to herein as we or us warrants to the original purchaser referred to herein as you or your all products manufactured or supplied by us to be free from defect in workmanship and materials as follows TWO YEAR LIMITED WARRANTY FOR PARTS AND LABOR ON KOBE PREMIUM BRILLIA SERIES For two years from the date o
4. 7 Figure 8 her Figure 9 OPERATING INSTRUCTIONS Model No OVS CHX8130SQB 40 30 OVS CHX8136SQB 40 36 Note For best results turn fan on prior to any preparation or cooking and keep fans running while cooking Adjust speed as needed To operate the fan function e Press On Off Control to turn on the power e Once the On Off Control is turned on the prior fan selection will turn on Press the Speed Controls Low High or QuietMode to select the desired speed e QuietMode supersedes all other fan control Turn off QuietMode to use Low or High speed e Press On Off Control to turn fan off To operate the light function e Press the Light Control to turn lights on and off Note The Power Control switch is the main power controller MAINTENANCE ASAFETY WARNING NEVER PUT YOUR HAND INTO AREA HOUSING THE FAN WHILE THE FAN IS OPERATING To Clean Hood Surface A CAUTION NEVER USE ABRASIVE CLEANERS PADS OR CLOTHS DO NOT USE PAPER TOWEL ON STAINLESS STEEL For optimal operation clean range hood and all baffle spacer filter oil tunnel oil container regularly Regular care will help preserve the appearance of the hood 1 Use only mild soap or detergent solutions Dry surfaces using soft cloth 2 If hood looks splotchy stainless steel hood use a stainless steel cleaner to clean the surface of the hood Avoid getting cleaning solution onto or into the control panel Follow directio
5. ICAL CONNECTING WIRES SWITCH POWER OFF AT SERVICE PANEL AND LOCK SERVICE PANEL TO PREVENT POWER FROM ACCIDENTALLY If hood is operating normally connect three DONE BY QUALIFIED IN ACCORDANCE WITH CODES BEFORE BEING SWITCHED ON wires black white and green to house wires and cap with wire connectors Store wires in the wiring box Duct Cover Installation NOTE BE CAREFUL WHEN USING ELECTRICAL SCREWDRIVER DAMAGE TO THE HOOD MAY OCCUR 6 Using reference E from Table 1 and measurements on pages 11 12 mark the leveling point for duct cover bracket Secure the duct cover mounting bracket to the wall with two screws not provided Make sure all screws are tightened Refer to Figure 5 NOTE Inner duct cover will cover the duct cover bracket Slide the entire duct cover onto the hood Refer to Figure 6 Figure 4 Figure 5 NOTE BE CAREFUL WHEN USING ELECTRICAL SCREWDRIVER DAMAGE TO THE HOOD MAY OCCUR 9 Secure the outer duct cover to the hood mounting bracket with 4 3 16 x 3 8 screws provided Refer to Figure 7 10 Secure the inner duct cover with 2 3 16 x 3 8 screws to the duct cover mounting Bracket Refer to Figure 8 Install Accessories 11 Place baffle filters underneath the hood Refer to Figure 9 Final Assembly 12 Turn power ON in control panel Check all lights and fan operation 13 Make sure to leave this manual for the homeowner Figure
6. KOBE KOBE Range Hoods Brillia Series Model No OVS CHX8130SQB 40 30 OVS CHX8136SQB 40 36 USER MANUAL INSTALLATION GUIDE IMPORTANT READ THIS FIRST READ BEFORE INSTALLATION 1 Carefully check all contents of packages 2 Thoroughly inspect the unit for any cosmetic damages or defects 3 Test the unit before installation 4 Have a certified contractor electrician do the installation IF THERE IS ANY PROBLEM 1 DO NOT INSTALL THE UNIT AND KEEP ALL ORIGINAL PACKAGING MATERIAL 2 Have your original invoice as proof of purchase and product serial number ready 3 Call 1 877 BUY KOBE 289 5623 or e mail to info koberangehoods com to report the problem NO RETURN NO REFUND NO EXCHANGE IF 1 PRODUCT HAS BEEN INSTALLED 2 KNOCK OUT HOLES HAVE BEEN PUNCTURED 3 MISSING ORIGINAL PACKAGING MATERIAL AND OR PARTS ENGLISH READ AND SAVE THESE INSTRUCTIONS CONTENTS IMPORTANT SAFETY INSTRUCTION S lilla alal 4 COMPONENTS OF PFAOKAGE sel 3 A A O 4 ORERATINO INSTRUCTIONS criminalidad 8 MAINTENANCE ia 9 O Ws HO era 10 MEASUREMENTS 8 DIAGRAMS o 11 PARTS EiS aida 13 CIRCUIDIAGRAM sale 15 TROUBLE gt ROO TINO eta 16 PIC 17 WARRANT I Liliaceae 18 PRODUO TREGISTRA RON opener 20 READ ALL INSTRUCTIONS CAREFULLY BEFORE STARTING ALL WIRING MUST BE DONE BY A PROFESSIONAL AND IN ACCORDANCE WITH NATIONAL AND LOCAL ELECTRICAL CODES Ca 221547 IMPORTANT SAFETY INSTRUCTIONS
7. ainer and grease laden surfaces clean Grease should not be allowed to accumulate on fan baffle spacer filter oil tunnel oil container Always turn hood ON when cooking Use high settings on cooking range ONLY when necessary Do not leave cooking range unattended when cooking Always use cookware and utensils appropriate for the type and amount of food prepared Use this unit only in the manner intended by the manufacturer Before servicing switch power off at service panel and lock service panel if possible to prevent power from switching on accidentally e Clean ventilating fan frequently What to Do In The Event Of a Range Top Grease Fire SMOTHER FLAMES with a tight fitting lid cookie sheet or metal tray and then turn off the burner KEEP FLAMMABLE OR COMBUSTIBLE MATERIAL AWAY FROM FLAMES If the flames do not go out immediately EVACUATE THE AREAAND CALL THE FIRE DEPARTMENT or 911 NEVER PICK UP A BURNING PAN You May Get Burned DO NOT USE WATER including wet dishcloths or towels a violent steam blast will result Use an extinguisher ONLY if a You have a Class A B C extinguisher and know how to operate it b The fire is small and contained in the area where it started c The fire department has been called d You can fight the fire with your back to an exit What to Do If You Smell Gas Extinguish any open flame Do not try to turn on the lights or any type of appliance Open all doors and windows to disp
8. ct Cover ia Inner RA0930DC 29 7 8 758 Outer Original 15 380 Inner RA0946DC 46 7 8 1190 Outer Original 15 380 Original Outer Duct Cover a Di ion 47 7 16 1205 MIN Dimension 30 7 16 773 MIN ici OSO ur i 44 1118 MAX 12 PARTS LIST MODEL NO OVS CHX8130SQB 40 30 OVS CHX8136SQB 40 36 DESCRIPTION MODEL SIZE PART NO i LED Light Fixture 3W NO ES E 2 i E i Ca i ca A ES 7 Speeaswtenom ttososoo MOM i i NO i OE AAA ES E NC a MOS po 13 MODEL NO OVS CHX8130SQB 40 OVS CHX8136SQB 40 Er SJ CIRCUIT DIAGRAM OVS CHX8130SQB 40 MODEL NO OVS CHX8136SQB 40 NMOUd go I I I I I I I I L CAPACITOR agy Erre MOVIE CI q MOVIA NMOUSA MOTISA ALIHM agy J3 N18 BLACK WHITE BLACK 15 TROUBLE SHOOTING Issue ___ PossibleCause_________ Solution n both motors and ON Use a voltage meter to check the power supply ights are not working Check the power input and power output on the processor board If it s needed replace the processor board Replace the motor S amp Lights are The motor s is defective Replace the motor working but The capacitor s is defective Replace capacitor s motor s is not The control panel is defective Replace the control panel The range hood The blower system is not secure Tighten th
9. duct tape to seal the joints between pipe sections Temporarily wire the hood to test for proper operation before installing If necessary prepare back wall frame with cross framing lumber for secure installation Using references on Table 1 and the measurements on pages 11 12 decide the level of the lumber Refer to Figure 2 Peel protective film off the duct cover and the hood if any Hood Installation A CAUTION If required to move the cooking range to install the hood turn off the power on an electric range at the main electrical box SHUT OFF THE GAS BEFORE MOVING A GAS RANGE 1 Using references on Table 1 and measurements on pages 11 12 mark the leveling point for hood mounting bracket on the wall Secure 3 mounting screws not provided on the wall leaving 1 8 away from the wall Refer to Figure 3 Align hood mounting bracket to the mounting screws on the wall and hook hood into place Secure and tighten the mounting screws CAUTION MAKE SURE THE HOOD IS SECURE BEFORE RELEASING Figure 1 DUCT COVER Figure 2 WALL STUDS Figure 3 Ductwork Installation di Use 6 round steel pipe not provided to connect the plastic exhaust on the hood to the ductwork above Use duct tape to make all joints secure and air tight Refer to Figure 4 Wiring to Power Supply d THIS RANGE HOOD MUST BE PROPERLY GROUNDED MAKE SURE THIS IS ELECTRICIAN ALL APPLICABLE NATIONAL AND LOCAL ELECTR
10. e squirrel cage and air chamber is vibrating The squirrel cage is not balanced Replace the squirrel cage Hood is not secured in place Check the installation of hood tighten the mounting bracket The motor is LED s is defective Replace the LED s working but the S lights are not The light wiring s is loose Check wire continuity from light transformer to light working housing s Light driver is defective Check power input and power output on the light driver If it s needed replace the light driver The control panel is defective Replace the control panel The range hood is not venting out correctly The range hood is installed outside of the Adjust the clearance between the range hoods and manufacture recommended clearance cook top to 27 to 30 For Island range hood the clearance between the range hoods and cook top is 30 to 36 range hood by creating a sufficient make up air suggested pipe size suggestion coming into the missing from the installation backflow 16 DISCLAIMER 1 CAREFULLY INSPECT ALL ITEMS FOR DAMAGES BEFORE ACCEPTING DELIVERY NOTE ANY DAMAGES ON THE FREIGHT BILL OR EXPRESS RECEIPT REQUEST NAME AND SIGNATURE OF THE CARRIER S AGENT AND KEEP COPY TO SUPPORT YOUR CLAIM Upon acceptance of items owner assumes responsibility for its safe arrival Report damages to the carrier and file a claim immediately Failure to do so may result in the denial of your claim The
11. erse the gas If you still smell gas call the Gas Company and Fire Department right away CAUTION For general ventilation use only Do not use to exhaust hazardous or explosive materials and vapors To reduce the risk of fire use only metal ductwork Sufficient air is needed for proper combustion and exhausting of gases through the flue chimney to prevent back drafting Follow the heating equipment manufacturer s guideline and safety standards such as those published by the National Fire Protection Association NFPA and the American Society for Heating Refrigeration and Air Conditioning Engineers ASHRAE and code authorities Activating any switch on may cause ignition or an explosion Due to the size and weight of this hood two people installation is recommended WARNING ELECTRICAL SHOCK HAZARD Can result in serious injury or death Disconnect appliance from electric power before servicing If equipped the fluorescent light bulb contains small amounts of mercury which must be recycled or disposed of according to Local State and Federal Codes a e COMPONENTS OF PACKAGE Must keep all material for returns or refunds Range Hood Box Model OVS CHX8130SQB 40 30 OVS CHX8136SQB 40 36 For the operation manual please refer to our website A BRILLIA Range Hood KOBERangehoods com B Warranty Registration Card C Instructions Manual WEBSITE D Baffle Filter x 2 30 hood x 3 36
12. f your original invoice from a KOBE authorized dealer we will at our sole discretion choose to repair or replace the product free of charge that failed due to manufacturing defects It is your sole responsibility to ensure the product is readily accessible for the service technician to perform repairs The service technician will not under any circumstance remove alter or modify any fixture built around and or connected to the product to gain access to perform repairs During the two year Limited Warranty period additional charges may apply which include but are not limited to e Service technician travel charges if the requested service location is 30 miles out of KOBE s authorized service area e Parts shipping expenses e Un installation of defective product and Installation of replacement product Warranty Exclusions This warranty does not cover including but not limited to the following Improper installation Any repair alteration modification not authorized by KOBE Duct alteration modification and connection Incorrect electric current voltage or wiring Normal maintenance and service required for the product Consumable parts such as light bulbs and carbon filters Improper usage of the product that it is not intended for such as commercial use outdoor use and multi family use Normal wear and tear Chips scratches or dents by abuse or misuse of the product Damages caused by accident fire flood and other Acts of God Ex
13. in Canada or To report a problem please contact Toll Free 1 626 775 8880 Email customer service koberangehoods com Your notes 20 KOBE Range Hoods 11775 Clark Street Arcadia CA 91006 USA http www KOBERangeHoods com This hood is made for use in the USA and CANADA only We do not recommend using this hood overseas as the power supply may not be compatible and may violate the electrical code of that country Using a this hood overseas is at your own risk and will void your warranty Ce capot est concu pour une utilisation aux Etats Unis et au Canada seulement Nous ne recommandons pas d utiliser cette hotte a l tranger que l alimentation peut ne pas tre compatible et peut violer le code de l lectricit de ce pays L utilisation d un cette hotte a l tranger est a vos propres risques et annulera votre garantie Esta campana esta hecha para su uso en los EE UU y Canada No se recomienda el uso de esta campana en el extranjero como la fuente de alimentaci n puede no ser compatible y puede violar el codigo el ctrico de ese pais El uso de un esta campana en el extranjero es a su propio riesgo y anulara la garantia Information subject to change without notice VER 141205
14. ns of the stainless steel cleaner Caution Do not leave on too long as this may cause damage to hood finish Use soft towel to wipe off the cleaning solution gently rub off any stubborn spots Use dry soft towel to dry the hood 3 DO NOT allow deposits to accumulate or remain on the hood 4 DO NOT use ordinary steel wool or steel brushes Small bits of steel may adhere to the surface and cause rusting 5 DO NOT allow salt solutions disinfectants bleaches or cleaning compounds to remain in contact with stainless steel for extended periods Many of these compounds contain chemicals which may be harmful Rinse with water after exposure and wipe dry with a clean lint free cloth To Clean Baffle Filter Oil Tunnel CAUTION DRAIN OIL FROM BAFFLE FILTERS SPACERS amp OIL TUNNEL REGULARLY TO PREVENT OVERFLOW 1 Remove all the baffle filters spacers and oil tunnel Using a sponge wash with warm soapy water Dry completely before returning into place CAUTION SHARP EDGES Note Baffle Filters are top rack dishwasher safe SPECIFICATIONS MODEL SIZE COLOR CONSUMPTION AMPERE NUMBER OF BLOWER DESIGN BLOWER TYPE EXHAUST CONTROLS LIGHTS HOOD DIMENSION W x D x H OPTIONAL ACCESSORIES W x D x H WEIGHT Ibs SPEED Air Capacity CFM Sone dB OVS CHX8130SQB 40 30 OVS CHX8136SQB 40 36 18 Gauge Commercial Grade Stainless Steel 180W 1 5A 4 Seamless Satin Finish Double Horizontal S
15. penses incurred for service located outside of the designated service area Purchases from unauthorized dealers Removal fees of defective product and Installation fees associated with replacement product ATT OSPR 3 If we determine that the warranty exclusions listed above apply or if you fail to provide all necessary documentation for warranty service you will be responsible for all expenses associated with the requested service including parts labor shipping travelling and any other expense related to the service request 18 To qualify for warranty service you must Have the ORIGINAL proof of purchase Be the ORIGINAL purchaser of the product Have the model number Have the serial number Have a description of the nature of any defect in the product or part TO REQUEST WARRANTY SERVICE PLEASE CONTACT THE KOBE RANGE HOODS SERVICE CENTER Oh IN KOBE Service Center USA Only Tel 1 855 800 KOBE 5623 E mail kobe adcoservice com For service in Canada or To report a problem please contact Toll Free 1 626 775 8880 Email customer service koberangehoods com 19 PRODUCT REGISTRATION Fill in the blanks and keep this paper with the original invoice ina safe place for future service purpose 1 Date of purchase 2 Model No 3 Serial No For warranty service or spare parts purchase contact KOBE Service Center USA ONLY Toll Free 1 855 800 KOBE 5623 Email kobe adcoservice com For service
16. quirrel Cage Top 6 Round Rocker Switch 3 watt LED light x 2 OVS CHX8130SQB 40 29 3 4 x 19 11 16 x 12 3 16 OVS CHX8136SQB 40 35 1 4 x 19 11 16 x 12 3 16 1 30 Stainless Steel Back Panel SSP30 30 x 1 10 x 32 2 36 Stainless Steel Back Panel SSP36 36 x 1 10 x 32 3 1 Piece Inner Extension Duct Cover RA0930DC 10 5 8 x 7 7 8 x 29 7 8 4 1 Piece Inner Extension Duct Cover RA0946DC 10 5 8 x 7 7 8 x 46 7 8 Net Gross OVS CHX8130SQB 40 30 33 42 8 OVS CHX8136SQB 40 36 37 46 8 QuietMode Low High 260 380 560 1 0 2 2 5 0 One Sone is equivalent to the sound of a refrigerator at 40 decibels Specifications subject to change without notice 10 MEASUREMENTS amp DIAGRAMS m All measurements in are millimeters n All inch measurements are converted from millimeters Inch measurements are estimated OLE LOL E ZI Op 9L 6 1 Front View 12 3 16 310 1 9 16 40 14 3 4 375 11 Inner 15 380 Outer 15 380 Dimension 16 1 8 410 MIN 29 1 8 740 MAX Bottom View O mm O 29 3 4 756 35 1 4 896 19 11 16 500 With Optional Purchase Model No RA0930DC With Optional Purchase Model No RA0946DC Replace Original Inner Duct Cover with 1 piece Extension Duct Cover ii Replace Original Inner Duct Cover with 1 piece Extension Du
Download Pdf Manuals
Related Search