User Manual Quick Stand Economy
Contents
1. 400 QUIK STAND ECONOMY OPERATING MAINTENANCE amp CLEANING MANUAL e Kerry n 89726 Compan 035 INDEX PAGE SPECIFICATIONS 2 SPARE PARTS 3 SAFETY PRECAUTIONS 4 OPERATING INSTRUCTIONS 4 BATTERY CHARGING AND CARE 6 MAINTENANCE INSTRUCTIONS 7 SPECIFICATIONS DIMENSIONS Length 1100mm Width 670mm Height 970mm Effective lift range 950mm 1700mm Leg gating inside 510mm 900mm Under base clearance 25mm Base height 100mm Leg height from floor 110mm LIFT SPEED 35mm per second LIFT DRY WEIGHT LIFT CAPACITY CASTORS FINISH ELECTRICAL ITEMS KH 400GE 36 Kg with battery Max load 150kg 125mm Total lock rear polyurethane castor O 75mm Swivel grey rubber castors front Note Larger castors available on request Easier to move Epoxy powder coated Padded kneepad vinyl Tested by Linak Australia to standards AS 3108 1990 AS 3200 1 1990 2 QUIK STAND ECONOMY HOIST poston TS SZ Hane O y oda o Meu 92 135 1108 LNMOW WABHZ SZ 135 03345 3986 10 00 919 JIONYH HSNd DHd809 EZ OU ee YITIONLNOD 03345 319 6 010100 00 00 2 97 12 0 0 39009 6 03345 319 6 YOLYNLIY 1 41 ei a TAIHM IYW 82. 1 2 FRONT BACK BATTERY CHARGING AND CARE CHARGING Before the hoist can be operated the battery pack will need to be charged Minimum 4 hours for flat battery Please follow the instructions below Plug the charger unit into the 240 Volt supply outlet The unit is now ready to accept a battery that requires charging To charge the battery simply locate the charging plug securely into the female socket on the base of the battery a two battery system 15 going to be used replace the first battery once charged with the second battery Charge as above NOTE A battery pack may remain on charge indefinitely without any detrimental effects to the battery or charging unit BATTERY CARE The hoist uses fully sealed lead acid batteries They are made to be recharged on a regular basis To care for your batteries and obtain the maximum life DO NOT allow the batteries to run totally flat before recharging The controller is fitted with an audio low battery warning alarm When this warning alarm sounds complete the lift process then change the battery and recharge Kerry Equipment recommends that a 2 battery system be used this allows one battery to always be on charge while the other is in use and hence the hoist may never be out of service with a flat battery KH 400GE 6 QUIK STAND ECONOMY HOIST MAINTENANCE INSTRUCTIONS The hoist requires periodical lubrication These points are CASTORS lt is always best
3. 8 NBE 9 S Pod tos __ 90 39009 90 30009 30009 az on OLW 201 1 4 9 626 0 910 lt 6 05X001 5492 3699100 0600418 135 1108 10 931 0288214 vs 9 1392 LOAId 009 JIL 50 35007 T3AIMS T33HM JTONIS 104 SLO 8 1 Nts BREAN 10 3000 6 04 311 14109 39 QUIK STAND ECONOMY HOIST 3 KH 400GE SAFETY PRECAUTIONS The hoist is manufactured and tested with safety and function for the carer and patients as the utmost importance The MAXIMUM safe working load 15 150 Kg s EMERGENCY LOWERING The emergency lowering button can be used to lower the hoist if there is a handset failure The switch is located on the controller under the big red emergency stop switch Simply press using a ballpoint pen or similar object DO NOT use a sharp object such as a compass point Always use the correct slings on the hoist For safety precautions only properly trained personal should use the hoist OPERATING INSTRUCTIONS BATTERY PACK INSTALLATION Simply locate the battery on the mounting bracket and clip the release lever into the secure position The Hoist is now ready for use HANDSET RAISE LOWER The hoist operates via a hand controller To raise or lower the hoist simply p
4. practice to remove all hair and lint from the castors as soon as possible always allowing free movement of all the wheels The head bearing will need lubricating monthly Simply spray TAC 2 up into the bearing while rotating the castor The wheel also requires lubricating every month To do this the wheel must be unbolted and removed from the castor frame TAC 2 can then be sprayed into the hub centre to lubricate the internal bearings BASE PIVOT POINTS and FOOT PEDAL All pivot points will need to be lubricated regularly with TAC 2 or similar lubricant Simply spray the points for a second or two on either side The hoist has to be turned onto its side for access to the following lubrication points To do this 2 people are required Both people are to stand on one side of the hoist One near the push handle the other by the side of the hoist The person near the push handle locks the total lock castors In conjunction with one another pull the hoist towards the side lowering the hoist onto the floor You now have access to all the lubrication points under the base pivot points leg lever and leg pivot Simply spray TAC 2 on all the pivot points KH 400GE 7 QUIK STAND ECONOMY HOIST ARM AND ACTUATOR PIVOT POINTS The arm and actuator pivot points will need to be lubricated regularly with TAC 2 or similar lubricant Simply spray on each side of the recommended points for a second or two 2 is a CRC prod
5. ress the required switch on the touch pad KH 400GE 4 QUIK STAND ECONOMY HOIST GATING To OPEN CLOSE the Gate legs simply press foot to open or close legs SLINGS AVAILABLE KH400SF PREMIUM STANDING SLING Medium with Velcro waist strap KH400SFB PREMIUM STANDING SLING Medium with buckle waist strap These slings are used for patients that are to 110 KH400SL PREMIUM STANDING SLING Large with Velcro waist strap KH400SLB PREMIUM STANDING SLING Large with buckle waist strap These slings are used for patients that are between 100 150 kg s SLING FITTING INSTRUCTION When using a seating sling for example the front mounting points are used for the chest straps and the back for the leg straps Please refer to the fitting instructions relevant to your choice of sling BACK For your convenience Kerry Equipment has supplied a User Records Chart located at the back of this manual It is used to record patient lifting preferences to which mounting points and sling colours best suit them Hint Copy the chart and keep the original with this manual KNOB RECOMMENDED USAGE When using the standing hoist there are two recommended mounting points relevant to patient size The front knobs are used for patients over 56 165cm and the back knobs are used for shorter patients ie below 56 165cm KH 400GE 5 QUIK STAND ECONOMY HOIST
6. uct and is available from most automotive outlets or from Kerry Equipment KERRY EQUIPMENT SERVICE VAN READY FOR ALL YOU NEEDS CALL 08 9240 2944 CLEANING INSTRUCTIONS 1 The hoist can be cleaned with a low strength detergent warm water and a soft textured cloth This includes all Epoxy powder coated framework and yoke 2 CAUTION Do not immerse any parts in water Do not allow water cleaning liquid to enter the battery or controller Clean up spills immediately 3 SLING CARE Protect from direct sunlight Repair any cuts or fraying immediately Slings are machine washable Please refer to care instructions on the sling Distributed by Kery Equipment AustiPty Ltd 4 71 147 ee Balcatta Perth Equi pment Australia 8021 Telephone 61 8424 2944 eo Facsimile 61 69240 1469 A Ff Hilis Company omalligkerry equipment com au Witty Kerry equipment com au Manufactures of amp Home Equipment KH 4UUGE QUIK STAND ECONOMY HOIST
Download Pdf Manuals
Related Search