HI-VAC jr-1 - Anand Medicaids
Contents
1. TERMS OF WARRANTY Anand Medicaids Private Limited warranty the high quality and workmanship of each Anand s HI VAC for a period of one year subsequent to the date of delivery by the company During this period faulty material will be replaced free of charge This warranty does not extend to components that are subject to wear and tear in the course of normal operation or due to improper treatment maintenance as per instructions Further conditions in accordance with international standard IEC 601 1 item 6 8 2b The manufacturer is only responsible for effects on the safety the reliability and the performance of the appliance if e Installation additions adjustments modifications or repairs are carried out by personnel authorized by the manufacturer e The electrical installations within the room concerned satisfy the requirements laid down by IEC e The appliance is used in full accordance with the instruction manual which is solely a guide and no substitute for professional training The safe and effective use of this product largely depends on the skill of the operator We are not liable for any damages due to mishandling or improper and unauthorised use e The company reserve the right to change technical specifications designations and catalogue numbers without prior notice Note Ensure that your electrical wirings are well earthed with 1 line and 1 neutral phase and your voltage is between 220V 240V 50 Hz Ensure that the suction2. 09 10 2010 Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For HI VAC Jr TECHNICAL Housing Spot Welded Oven baked cabinet Also available with Stainless Steel Body Capacity 700 mm Hg 10 regulable flutter free vacuum control knob 28 Ltrs min Pump type Single rotary vane pump Jar Wide mouthed 2 x 2 Ltrs Polycarbonate with self sealing bungs and mechanical over flow safety device Tubing 10 mm ID x 2 mtr PVC Vacuum Gauge Bourden type 6 25 cm Dia 0 760 mm Hg calibration Power 230 V 50 Hz 4 0 5 Amps 200 watts 110 V on request Noise Level 50 dB A 3 Almost whispers Dimension amp Weight 39 x 33 x 65 cms 25 Kg Vacuum at Altitudes The specified maximum vacuum refers to sea level According to local conditions and barometric pressure slight deviations in vacuum reading may be noted As a reference the table below shows several factors by which the indicated maximum vacuum value must be multiplied according to the altitude of location where the measurement is carried out Location Maximum Vacuum Location Sea level 1000m 2000m 4000m Factor 1 00 0 88 0 78 0 60 GUIDELINES FOR USE 1 LUBRICATION The unit must be lubricated with good quality oil Mobil oil no 40 as soon as container gets empty This way not only you get good suction but good service for years together 2 NEGATIVE PRESSURE Before the unit is put to use vacuum must be set at the required level Fully tigh
3. An ISO 9001 2008 13485 2012 Certified Company Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For HI VAC Jr CE 2195 Filter Tube Filter Pn Push in nozzle Vacuum marked nozzle Lid iB gt Patient connector Jar O Ring Oil container Jar 2 x 2 liters Vacuum gauge On off switch cum indicator Vacuum control knob Dear Customer Thank you for selecting this versatile and need oriented suction unit ASSEMBLY AND GENERAL INFORMATION Motorised pump is housed in the cabinet On the platform apart from the oil container is a filter which is the suction inlet Before the unit is put on please see that 1 The plug is connected to the grounded relevant mains outlet In case of fluctuation use voltage stabilizer 2 The vacuum control knob is not loose It must be fully tightened clockwise 3 The lids are tightly placed on the jars and the tube on the nozzle of the lids 4 The oil container is full with lubrication oil No 40 So that there is no leakage at the nozzle connector joint press and twist the connector to make it snug fit Same way while unplugging twist and pull ATTENTION 1 The unit can overheat if it is restarted while under vacuum Make sure it is between 0 and 150 mm Hg 2 Always turn the power off with the power switch after job is complete or in case of breakdown in between the use Page 1 www anandind com DOC ID NO 4202 Ay REV 01 www suction in ar Pa CO DATE
4. Put the knob pin and the filter in their respective places If it does not start please consult the hospital engineer or the electrician If this exercise is not done immediately after the accidental entry of blood in the pump the blood will stick dry inside the pump housing and the whole pump will have to be opened cleaned lubricated and set again For this open the side door remove plastic tubing inlet point and exhaust silencer outlet point with metal point L tube To dilute the dried blood pour few drops of kerosene oil diesel and make the unit on off After it takes a start keep the unit running and gradually pour 10 20 of mobil oil in the running unit After say a run of 30 minutes or more put the tubing exhaust outlet and door back to its original position The outlet point exhaust inside the housing can be opened cleaned and gauze refill replaced in it Even otherwise replacing of gauze refill is suggested every six months 7 In long duration operations if possible put off the unit even if for a few minutes Gauge T y Filter A Release Sadie Valve O Oil Container Inlet mO Ex Outlet Oil Nozal MOTORIZED PUMP Page 3 www anandind com DOC ID NO 4202 T REV 01 www suction in la com DATE 09 10 2010 Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For HI VAC Jr TROUBLE SHOOTING Possible source of trouble Check Action to be taken Power Supply Voltage p
5. ower socket Main switch Set at ON Electrical cord Plug type plug connections damaged cord The blood has entered the pump The remedy is given above under pump cleaning if the unit makes more noise it needs lubrication Also clean the exhaust outlet Motor does Not Run Leak within the pump or in the external Isolate the source of trouble by carrying out Suction circuit the checks outlined External cause Push in connector O rings Lid gasket Condition Internal cause Tubing or mechanical components Diagram given above Inadequate Suction Performance Blockage or kink in tubing within the Isolate source of trouble as follows pump or in the external suction circuit Pull the filter upwards leave the suction connection open If the vacuum gauge now indicates zero vacuum the cause is external External cause Bacteria filter overflow valve in the Investigate the whole external suction circuit lid float valve push in connectors tubing etc for blockage s float valve sticking kinked tubing and rectify Pump does not suck however If the vacuum gauge still indicates a vacuum the cause is internal z gt gt U gt N e9 ja O Cc 09 O gt O gt gt U gt www anandind com Page 4 DOC ID NO 4202 T REV 01 www suction in la com DATE 09 10 2010 Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For HI VAC Jr
6. tened clockwise vacuum control knob means full vacuum Even otherwise replacing of gauze refill is suggested every six months 3 JARS As the flow rate is high 3 4th filling of jar is recommended otherwise splash droplets might enter the filter and if not cleaned regularly might enter the pump 4 CLEANING After each use lids overflow cut off valve suction cannulae catheters etc should be cleaned thoroughly When sterilization is necessary after infective fluid has been sucked the jars the lids cut off valve and metal cannulae can be sterilized by autoclaving and the tubing by sterilizing solution Outlet Silencer JAR MOTORIZED PUMP ce FILTER www anandind e com Page 2 DOC ID NO 4202 T REV 01 www suction in la com DATE 09 10 2010 Anand MEDICAIDS Instruction Cum User Manual PRIVATE LIMITED For HI VAC Jr 5 FILTER Filter element refill MUST be changed after every normal day s work and immediately if wetted by froth splash droplets of the infective material The filter can be pulled out upwards and the cap unscrewed Use NON ABSORBANT COTTON wool as refill 6 PUMP But if accidentally the fluid enters the pump pullout the filter and run the unit by keeping a thumb on the suction inlet for a minute or two Unscrew and take out the pin from the vacuum control knob and with the pump still on gradually pour 15 20 drops of oil in it Block the inlet OFF and ON for a couple of times
7. unit should not be lifted above human body level Dispose of used product packaging in safe manner so as not to harm stray cattle children and environment WARRANTY CARD Model No ____LL eee Lee LLL LLL INN eee eee Date of Purchase Dealer Name taal ANAND MEDICAIDS PRIVATE LIMITED Regd Office 33 16 Punjabi Bagh Extn New Delhi 110026 India Tel 91 11 25225225 25229206 42464264 Fax 91 11 25225062 E mail sales anandind com Works 1460 M I E Bahadurgarh Haryana 124507 India EC REP KALEIDOS SH VIA PONTIOA 4 2012 MILANO ITALY www anandind com Page 5 DOC ID NO 4202 ar REV 01 www suction in la com DATE 09 10 2010
Download Pdf Manuals
Related Search