REA 60 Electric Actuator User Manual
Contents
1. SMS Sanayi Malzemeleri ve Sat s A S REA 60 Electric Actuator Manual TORK SMS TORK CONTENT INTRODUCTION PRODUCT IDENTIFICATION GENERAL INFORMATION AND FEATURES INSTALLATION INSTRUCTION ACTUATOR MOUNTING DETAILS OPERATION INSTRUCTION MAINTENANCE TROUBLE SHOOTING DIMENSION FOR ACTUATOR SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK INTRODUCTION This installation and operating manual explains how to install operate and maintain REA60 electric actuators Safety notices in this manual detail precautions the user must take to reduce the risk of personal injury and damage to the equipment User must read these instructions before installation operating or maintenance AN DANGER Refers to personal safety Alerts the user to potential danger or harm The hazard or unsafe practice will result in severe injury or death AN WARNING Refers to personal safety Alerts the user to potential danger Failure to follow warning notices could result in personal injury or death CAUTION Directs the user s attention to general precautions that if not followed could result in personal injury and2. Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 490 216 364 37 57 Tel 90 262 2902020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK AC OPERATION DIP SWITCH 1 DOWN DIP SWITCH 2 UP DC OPERATION DIP SWITCH 1 UP DIP SWITCH 2 DOWN me M MAINTENANCE Caution Turn off all power services before attempting to perform a service on the actuator POTENTIAL HIGH PRESSURE VESSEL Before removing or disassembling the actuator ensure the valve or other actuated devices are isolated and not under pressure Maintenance under normal conditions at six month intervals however when conditions are more severe more frequent inspections may be advisable e Ensure valve actuator alignment e Ensure wiring is insulated connected and terminated properly e Ensure all screws are present and tight e Ensure cleanliness of internal electrical devices e Ensure conduit connections are installed properly and are dry e Check internal devices for condensation e Check power to internal heater e Check enclosure O ring seals and verify the O ring is not pinched between flange e Verify declutch mechanism e Visually inspect during open close cycle e Inspect identification labels for ware and replace if necessary SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Tur
3. 0 10VDC 1 5VDC Input resistance 250 Ohm Feedback Signal 100 10 Kohm Extraction 2 3 VDC Output Signal 4 20mA DC 2 10VDC 0 5VDC 0 10VDC 1 5VDC Load Resistance 750ohm Max Control Output Relay contact 250VAC 10A Max Inductive load Number of Output Contact 2 ea Open and Close contact Delay Time Adjustment 0 7 5 sec 1 Step 0 5 sec 0 15 Step Dead Band Adjustment 0 1 4 5 Resolution Min 1 1000 Position Conversation Accuracy 1 5 Depends on installation Ambient Temperature 109C 702C Ambient Humidity 90 RH Max Non condensate Dielectric Strength 1500V AC 1 Min Input to Output Power to Ground Insulation Resistance Min 500VDC 30Mohm Vibration amp Shock X Y Z 6g based on RMF Frequency 0 2 34Hz 30 min SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 490 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK LED Signal LED Signal Blue on Power on Auto Blue Flicker Auto Setting Green on Close Red on Open Yellow on Manual OPN by card Yellow Flicker Fault in either wrong input wiring wrong PIU setting No input signal Check Operation of PCU Actuator Full Close Full Open Input Signal 4mA DC 1 VDC 2VDC 20mA
4. Interior Wiring Hdl Ov M3MOd 9NIWOONI A01 0C 0 O Suggested Customer s Wiring TWNOIS 0 YOLVOION 0 01 1 NOILISOd Proportional Control Unit Box SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Wiring Diagram for 24VAC On Off Type AC 24 V DIP SWITCH SETTING AUX CONTACT 9 2 EXTRA SWITCHS MAX 250VAC 5A 1 2 Suggested Customer s Wiring Actuator s Interior Wiring SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 20 20 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Wiring Diagram for 24V DC On Off Type 1 DIP Switch setting AUX CONTACT 2 EXTRA SWITCHS Suggested Customer Wiring Actuator s Interior Wiring SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul
5. Switch 4 SPDT Switch Cable Entry PG 13 5 x 2 Mounting Flange F03 FOS F07 acc to DIN ISO5211 Indicator M5 Bolt Hexagon Socket Head Cap Screws 147 5 Hand wheel 1 M6 Hexagon socket head cap Hand wheel 2 70 F07 ISO 4 M8TAP DP12 50 F05 ISO 4 M6TAP DP12 36 F03 ISO 4 MSTAP DP12 SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK PCU Type 970 F71SO 4 mstap DP12 6 8 DRILL DP14 50 FSISO 4 m6TAP DP12 5 DRILLDP14 Handwheel 36 F31SO s MsraP DP12 94 2 DRILL DP14 Cable Entry PG 13 5 SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com
6. drive the actuator to its true closed position clockwise rotation e Connect an ohmmeter to P1 red black resistance should be approximately 1000ohms e Loosen the point shaft gear and connect the ohmmeter to P1 red and P2 white and gently rotate until a reading of 80 120 Q is achieved 100 ohms preferred While maintaining this reading tighten the point gear set screw with a hex wrench Proportional Control Unit PCU Optional REA Series Check point before using actuator 1 Check specification Model No Main Power Control Power Options of delivered actuator meets your requirements 2 Check application such as valve damper etc 3 Check mounting of actuator on application is correct 4 Check setting of actuator such as limit switch stopper bolts indicator is correct 5 Check electrical wiring is correct 6 In case of 3 phase motor check rotating direction Check rotating direction of actuator open actuator about 5096 by manual supply power to actuator for 2 3 seconds Push close button and check if actuator moves to close direction If this actuator moves to close itis correct To reverse the motor stop the power supply to the actuator and change the 2 ofthe 3 power lines which changes the direction of the motor 7 Generally all functions of PCU is set by the factory before delivery and there is no need to set the functions again The functions should only be changed if
7. that the voltage matches the rating on the actuator nameplate e Check internal wiring against actuator wiring diagram e Check limit switch cams Actuator is receiving power but does not operate e Verify the line voltage to the actuator e Check actuator force to see if it s greater than the valve force e Checklimit switches and cams e Check that the force switches have not tripped e Check mechanical travel stop adjustment e Verify the actuator against valve rotation standard units are anti clockwise open e Check internal wiring e Check for corrosion and condensation e Verify coupler bracket are correctly installed and is not causing binding Actuator runs erratically e Check ambient temperature e Verify that the duty cycle has not been exceeded e Check the position of manual override lever Optional Equipment Potentiometer Current Position Transmitter e Check resistance value e Check potentiometer gear for jamming e Check zero and span calibration e Check board for damage SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK DIMENSION FOR ACTUATOR On Off Type Enclosure IP67 Torque 6Kg m Operation Time 13sec Position
8. DC SVDC 10VDC Output Signal 4mA DC 20mA DC Signal LED Green LED on Red LED on Auto Setting Blue LED Flicker Input Signal Failure Yellow LED Flicker SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Lay Out of PCU Card 2 225 Oz 0 508 INPUT SIGNAL on zz of Gul SELECTION Goa B oot 5829 iy 23 0 Xo ws p D YES OR 123 O 5V DC TERI NPUT LY 10v OC INPUT TRIAC POT 3 late pc POT 2 POT 1 TRIAC HERTZ OUTPUT 2 11 um 123 4 pd SIGNAL TRANSFORMER OUTPUT SIGN SELECTION SELECTION P m D ee T kki e EE 12 OK oc OUTPUT SIGNAL REGULATION LCU CONNECT LINE 7FRO OV OR 4mA SPAN 10V OR 70mA SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK OPERATION INSTRUCTION Electrical Connections and Preliminary Test e L
9. becomes tight DO NOT FORCE further as this will cause serious damage to the gearing SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com SMS TORK CED Note The override engagement lever returns automatically to auto position when the actuator is operated electrically Lubrication REA is a totally enclosed unit with a permanently lubricated gear train Moly EP Grease Once installed lubrication should not be required However periodic preventative maintenance will extend the operating life of the actuator SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK External Parts 1 Top Cover 2 Body 3 Cable Entry PG 13 5 x2 4 Drive Shaft 5 Mounting Base F03 FO5 F07 6 Manual Override Nut 7 Name Plate 8 Cover Bolt Captive Design 9 Indicator SMS Sanayi Malzemeleri Uretim ve Satisi A S Hea
10. ce Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Short time duty S2 The operation time ata constant load is short so that ther mal eguilibrium is not reached The pause is long enough for the machine to cool down to ambient temperature The duration of the short time operation is limited to 15 min 10 min 30 min Intermittent duty S4 The duty is a seguence of identical cycles which consist of starting time operation time with constant load and rest period The rest period allows the machine to cool down so that so that thermal equilibrium is not reached The relative on time at S4 25 or S4 50 is limited to 25 and 50 respectively Heater Condensation in the actuator is possible due to wide fluctuation of the ambient temperature The heater integrated in the control unit prevents this in general Manual Hand Wheel and Lever REA actuators are provided with a manual operation system The REA60 actuator comes standard with a manual override nut This is located on the bottom of the unit and can be easily operated with a 5M wrench Turn the hand wheel until the valve reaches the required position Turn clockwise to open and counter clockwise to close AN When nut
11. d Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Internal Parts amp amp 6 1 2 Indicator 3 Open limit switch 4 Additional open limit switch 5 Potentiometer Unit 6 Terminal 7 Heater 8 Capacitor SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 490 216 364 37 57 Tel 90 262 290 20 20 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK INSTALLATION INSTRUCTION Pre Installation for use in General Services Verify the actuators name plate to ensure correct model number force operating speed voltage and enclosure type before installation and use It is important to verify that the output force of the actuator is appropriate for the force requirements of the valve and that the actuator duty cycle is appropriate for the intended application WARNING Read this installation and maintenance manual carefully and completely before attempting to install operate or trouble shoot the REA actuato
12. ey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Limit Switch Setting e Rotate the actuator hand wheel manually to closed position e Using hex wrench loosen the set screw on the CLOSE limit switch cam e Rotate the CLOSE cam towards CW limit switch lever until the switch clicks Tighten the set screw with hex wrench e Rotate the actuator hand wheel manually to open position e Using hex wrench loosen the set screw in the open limit switch cam e Rotate to open cam towards CCW limit switch lever until the switch clicks fig 2 e Tighten set screw with hex wrench AN Danger HAZARDOUS VOLTAGE Make sure all power is disconnected prior to mounting Close Limit Switch Close limit Switch Cam clockwise 2mm Hexagon socket screw Key SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Position Feedback Potentiometer Optional Calibration Potentiometer The potentiometer has been calibrated at the factory however if re calibration is reguired proceed as follows e Apply power or use manual override to
13. key Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 20 20 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Warning Treat cover with care Gap surfaces must not be damaged or dirtied in any way Do not jam cover during fitting Tools e 1 Metric Allen Key Hex Wrench e Screw Driver e 1 Metric Spanner e 1Wrench 200mm e 1Wrench 300mm e 1 Wire Stripper Long Nose e 1 Multi Meter AC DC Resistance e 1 DC Signal Generator 4 20mA PCU Board Option e 1mA Meter 0 25mA PCU Board Option TROUBLE SHOOTING The following instructions are offered for the most common difficulties encountered during installation and start up Manual override nut hard to turn Valve stem improperly lubricated Lubricate with grease Actuator lubricant has broken down Clean out old grease and replace with recommended lubricant Valve packing gland too tight Loosen gland nuts as necessary SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 20 20 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Actuator does not respond e Verify the line voltage to the actuator e Check
14. oosen the screws on the actuator cover and lift it off e Make sure that the power supply voltage is in accordance with the data on the actuator name plate e Connect wires according to the enclosed wiring diagram e Move the valve manually to a half open position operate and electrical opening and check that the motor rotates in the right direction e Standard units are counter clockwise to open set e Test the actuator and check the limit switches work correctly e Check all the cable glands are correctly tightened applicable cable glands should be selected to be meet the applications condition Over the grade IP67 of cable gland recommended in potentially explosive atmospheres e Mount cover and tighten cover bolts Wiring Diagram for 230V AC On Off Type AUX CONTACT INCOMING POWER 2 EXTRA SWITCHS AC IPH V MAX 250VAC 3A Suggested Customer s Wiring Actuator s Interior Wiring OO 999009000 z om ir ons CONDENS amp we SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Wiring Diagram for 230V AC PCU Type OO OOOO ORO Actuator s
15. or equipment damage PRODUCT IDENTIFICATION The actuator name plate is located on the top cover of the actuator The name plate contains the following e TORK logo trade mark e Electrical power supply e Model e Type e Rated current e Operating time seconds e Serial No e Option SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Initial Inspection Upon receipt of the actuator inspect the condition of the product and ensure the name plate matches the order sheet or your requirements also check for any damage that may have occurred during shipment If the wrong product has been shipped immediately or is damaged report to the coordinator Storage Actuators must be stored in a clean cool and dry area The unit shall be stored with the cover fastened and the conduit openings sealed Storage must be off the floor covered with a seal dust protector When actuators are stored outdoors they must be stored off the ground high enough to prevent being immersed in water or buried in snow GENERAL INFORMATION AND FEATURES REA series electric actuators are designed to provide reliable and efficient operation of 90 degree
16. quarter turn valves dampers etc Performance eco 6 ua f s ms o 3 5 SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanci Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 90 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Technical Data Enclosure Rated Enclosure Power Supply Motor Limit Switches Auxiliary Limit Switches Indicator Manual Space Heater Conduit Entries Lubrication Ambient Temperature External Coating Weatherproof IP67 High grade aluminium alloy corrosion coated 110 220 VAC 1 Ph 24 VAC 24VDC 50 60Hz Reversible motor 2 x open close SPDT 250 VAC 10A rating 2 x open close SPDT 250 VAC 10A rating Continuous position indicator Manual Override Nut 2W 2xPG 13 5 Grease moly EP 202C 709C Dry powder polyester REA Option Technical Data PIU Potentiometer unit 0 1K 0 PCU Proportional control unit input output 0 10 VDC or 4 20mA DC CPT Current position transmitter output 4 20mA DC Duty Cycle Duty cycle is rated IEC60034 S4 50 S2 30 min Exceeding the actuators rated duty cycle may cause thermal overload Type of duty according to VDE 0530 IEC 60034 1 SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Offi
17. rs Actuator Mounting Note e Prior to mounting the part turn actuator it must be checked for damage e Damaged parts must be replaced by original spare parts Mounting is most effectively carried out with the valve shafting pointing vertically upwards however mounting is also possible in any other position The REA series actuators are supplied with a Union Joint and nut which is removable for ease of machining AN CAUTION e Do not attempt to work on your REA actuator without first shutting off Incoming power e Do not attach ropes or hooks to the hand wheel for the purpose of lifting by hoist SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK ACTUATOR MOUNTING DETAILS Direct mounting ISO ISO standard Bracket Mounting Star Adapter 14mm 11mm 11mm 9mm Square Adapter 14mm 11 mm 11mm 9mm AN Danger HAZARDOUS VOLTAGE Make sure all power is disconnected prior to mounting SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turk
18. the customer wishes to adjust the limit switches to set the function the PCU is required To set simply push the Auto Setting button after putting actuator in the 5096 open or close position PCU automatically sets all the functions by itself 8 Disassembly modification without factory consent may affect the performance of the actuator SMS Sanayi Malzemeleri Uretim ve Satisi A S Head Office Bostanc Yolu Cad Kuru Sok No 16 Y Dudullu 34776 mraniye Istanbul Turkey Factory erke li OSB Mah Dilovas MES OSB 5 Cad No 6 Kocaeli Turkey Tel 490 216 364 34 05 pbx Fax 90 216 364 37 57 Tel 90 262 290 2020 Fax 90 262 290 20 21 www sms tork com TORK SMS TORK Before installing or operating the actuator please read this manual to lean how to install and operate The contents of this manual are subject to change due to quality improvement without individual notice General Performance PCU is the local actuator controller using 12 bit A D converter and 8 bits Microprocessor which operate the actuator to open and close according to the signal from the main controller After operating actuator it detects the current position of the actuator and transmits a feedback output signal advising of the current position to the main controller Standard Specification Model PCU REV 3 1 Model 85V 280 VAC 10 50 60Hz 4VA Max New wide range of voltage Input Signal 4 20mA DC 2 10VDC 0 5VDC
Download Pdf Manuals
Related Search