ZBB27450SA User Manual Fridge Freezer
Contents
1. Hc 14 Open the appliance door and the kitchen furniture door at an angle of 90 a Insert the small square Hb into guide Do a final check to make sure that Ha All screws are tightened The magnetic sealing strip is attached tightly to the cabinet If the ambient temperature is low for example in winter the size of the gasket decreases The size of the gasket increases when the ambient temperature increases b Put together the appliance door and the furniture door and mark the holes 15 Remove the brackets and mark a distance of 8 mm from the outer edge of the door where the nail must be fitted K ENVIRONMENT CONCERNS human health and to recycle waste of electrical A i i t A Recycle the materials with the symbol CJ Put and electronic appliances Do not dispose the packaging in applicable containers to K recycle it Help protect the environment and appliances marked with the symbol amp with the 14 www zanussi com household waste Return the product to your local recycling facility or contact your municipal office www zanussi com 15 www zanussi com shop NX fN 222371023 A 4720142. Food products placed in the appliance were too warm The door is not closed correct ly The water drainage plug is not correctly positioned Food products are not wrap ped properly Temperature is set incorrectly The water outlet is clogged Food products prevent that water flows into the water col lector The melting water outlet is not connected to the evaporative tray above the compressor The temperature regulator is not set correctly The door is not closed correct ly The food products tempera ture is too high Many food products are stored at the same time The thickness of the frost is greater than 4 5 mm The door has been opened of ten Check if the appliance stands sta ble Refer to Operation chapter Wait some hours and then check the temperature again Refer to climate class chart on the rating plate Allow food products to cool to room temperature before storing Refer to Closing the door Position the water drainage plug in the correct way Wrap the food products better Refer to Operation chapter Clean the water outlet Make sure that food products do not touch the rear plate Attach the melting water outlet to the evaporative tray Set a higher lower temperature Refer to Closing the door Let the food products temperature decrease to room temperature be fore storage Store less food products at the same time Defrost the applian
3. User Manual U S R MANUAL Fridge Freezer ZBB27450SA ZAN USSI Contents Safety information 2 Care and cleaning 7 Safety instructions 3 Troubleshooting 8 Operation coe eee 4 Technical information 10 DallWUSs s 2 eee eee 5 installation 11 Hints anditipsi2 255 daaa 6 Subject to change without notice A Safety information Before the installation and use of the appliance carefully read the supplied instructions The manufacturer is not responsible if an incorrect installation and use causes injuries and damages Always keep the instructions with the appliance for future reference Children and vulnerable people safety This appliance can be used by children aged from 8 years and above and persons with reduced physical sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved Do not let children play with the appliance Cleaning and user maintenance shall not be made by children without supervision Keep all packaging away from children General Safety This appliance is intended to be used in household and similar applications such as Farm houses staff kitchen areas in shops offices and other working environments By clients in hotels motels
4. Take care of not to damage the cooling system AN CAUTION When moving the cabinet lift it by the front edge to avoid scratching the floor The equipment has to be cleaned regularly 1 Clean the inside and accessories with lukewarm water and some neutral soap 2 Regularly check the door seals and wipe clean to ensure they are clean and free from debris 3 Rinse and dry thoroughly www zanussi com water ices if consumed immediately after removal from the freezer compartment can possibly cause the skin to be freeze burnt it is advisable to show the freezing in date on each individual pack to enable you to keep tab of the storage time Hints for storage of frozen food To obtain the best performance from this appliance you should make sure that the commercially frozen foodstuffs were adequately stored by the retailer be sure that frozen foodstuffs are transferred from the foodstore to the freezer in the shortest possible time not open the door frequently or leave it open longer than absolutely necessary once defrosted food deteriorates rapidly and cannot be refrozen do not exceed the storage period indicated by the food manufacturer 4 If accessible clean the condenser and the compressor at the back of the appliance with a brush This operation will improve the performance of the appliance and save electricity consumption Defrosting of the refrigerator Frost is automaticall
5. all internal accessories with lukewarm water and some neutral soap so as to remove the typical smell of a brand new product then dry thoroughly WARNING Do not use detergents or abrasive powders as these will damage the finish Movable shelves The walls of the refrigerator are equipped with a series of runners so that the shelves can be positioned as desired Positioning the door shelves To permit storage of food packages of various sizes the door shelves can be placed at different heights 1 Gradually pull the shelf in the direction of the arrows until it comes free www zanussi com CAUTION If the ambient temperature is high or the appliance is fully loaded and the appliance is set to the lowest temperatures it may run continuously causing frost to form on the rear wall In this case the dial must be set to a higher temperature to allow automatic defrosting and therefore reduced energy consumption E ons u 0 2 Reposition as required Freezing fresh food The freezer compartment is suitable for freezing fresh food and storing frozen and deep frozen food for a long time To freeze fresh foods it is not necessary to change the medium setting However for a faster freezing operation turn the temperature regulator toward higher settings to obtain the maximum coldness i In this condition the refrigerator compartment temperature might drop below 0 C If this occurs reset the temp
6. connecting the appliance to the power supply This is to allow the oil to flow back in the compressor Do not install the appliance close to radiators or cookers oven or hobs The rear of the appliance must stand against the wall Do not install the appliance where there is direct sunlight Do not install this appliance in areas that are too humid or too colds such as the construction appendices garages or wine cellars www zanussi com front edge to avoid scratching the floor Electrical connection WARNING Risk of fire and electrical shock The appliance must be earthed Make sure that the electrical information on the rating plate agrees with the power supply If not contact an electrician Always use a correctly installed shockproof socket Do not use multi plug adapters and extension cables Make sure not to cause damage to the electrical components e g mains plug mains cable compressor Contact the Authorised Service Centre or an electrician to change the electrical components The mains cable must stay below the level of the mains plug Connect the mains plug to the mains socket only at the end of the installation Make sure that there is access to the mains plug after the installation Do not pull the mains cable to disconnect the appliance Always pull the mains plug Use WARNING Risk of injury burns electrical shock or fire Do not change the specification of this appliance Do n
7. when the compressor switches on or off Hints for energy saving Do not open the door frequently or leave it open longer than absolutely necessary Hints for fresh food refrigeration To obtain the best performance do not store warm food or evaporating liquids in the refrigerator do cover or wrap the food particularly if it has a strong flavour compartment let the appliance run at least 2 hours on the higher settings If large quantities of food are to be stored remove all drawers and baskets from appliance and place food on cooling shelves to obtain the best performance WARNING Make sure that foods do not exceed the load limit stated on the side of the upper section where applicable gt i In the event of accidental defrosting for example due to a power failure if the power has been off for longer that the value shown in the technical characteristics chart under rising time the defrosted food must be consumed quickly or cooked immediately and then re frozen after cooling position food so that air can circulate freely around it Hints for refrigeration Useful hints Meat all types wrap in polythene bags and place on the glass shelf above the vegetable drawer For safety store in this way only one or two days at the most Cooked foods cold dishes etc these should be covered and may be placed on any shelf Fruit and vegetables these should be thoroughly cleaned an
8. ains lead are coloured in accordance with the following code a N o A green and yellow Earth C brown Live D blue Neutral As the colours of the wires in the mains lead of this appliance may not correspond with the coloured markings identifying the terminals in your plug proceed as follows 1 Connect the wire coloured green and yellow to the terminal marked either with the 11 letter E or by the earth symbol or coloured green and yellow 2 Connect the wire coloured blue to the terminal either marked with the letter N or coloured black 3 Connect the wire coloured brown to the terminal either marked with the L or coloured red 4 Check that no cut or stray strands of wire is present and the cord clamp E is secure over the outer sheath Make sure the electricity supply voltage is the same as that indicated on the appliance rating plate 5 Switch on the appliance The appliance is supplied with a 13 amp fuse B In the event of having to change the fuse in the plug supplied a 13 amp ASTA approved BS 1362 fuse must be used WARNING A cut off plug inserted into a 13 amp socket is a serious safety shock hazard Ensure that it is disposed of safely Ventilation requirements The airflow behind the appliance must be sufficient Door reversibility WARNING Before carrying out any operations remove the plug from t
9. ard on the opposite side of the hinge 2 a 4 Make sure that the distance between the appliance and the cupboard front edge is 44 mm The lower hinge cover in the accessories bag makes sure that the distance between the appliance and the kitchen furniture is correct 5 Make sure that the clearance between the appliance and the cupboard is 4 mm 6 Open the door Put the lower hinge cover in position 7 Attach the appliance to the niche with 4 screws www zanussi com 8 Remove the correct part from the hinge cover E Make sure to remove the part DX in the case of right hinge SX in opposite case 9 Attach the covers C D to the lugs and the hinge holes 10 Install the vent grille B 11 Attach the hinge covers E to the hinge 12 Connect the appliance laterally to the kitchen furniture sidewall a Loosen the screws of the part G and move the part G till the furniture sidewall b Tighten the screws of the part G again c Attach the part H to the part G 13 Disconnect the parts Ha Hb Hc and Hd 13 a Install the part Ha on the inner side of 16 Place the small square on the guide again the kitchen furniture and fix it with the screws supplied 17 Align the kitchen furniture door and the IE ne appliance door by adjusting the part Hb aby yall he Hb Nor a a 18 Press the part Hd on the part Hb L mo CN
10. bed and breakfast and other residential type environments Keep ventilation openings in the appliance enclosure or in the built in structure clear of obstruction 2 www zanussi com Do not use mechanical devices or other means to accelerate the defrosting process other than those recommended by the manufacturer Do not damage the refrigerant circuit Do not use electrical appliances inside the food storage compartments of the appliance unless they are of the type recommended by the manufacturer Do not use water spray and steam to clean the appliance Clean the appliance with a moist soft cloth Only use neutral detergents Do not use abrasive products abrasive cleaning pads solvents or metal objects Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance If the supply cord is damaged it must be replaced by the manufacturer its Authorised Service Centre or similarly qualified persons in order to avoid a hazard Safety instructions Installation When you move the appliance lift it by the WARNING Only a qualified person must install this appliance Remove all the packaging Do not install or use a damaged appliance Obey the installation instruction supplied with the appliance Always be careful when you move the appliance because it is heavy Always wear safety gloves Make sure the air can circulate around the appliance Wait at least 4 hours before
11. ce Open the door only if necessary There is no cold air circulation Make sure that there is cold air cir in the appliance culation in the appliance If the advice does not lead to the 2 Replace the lamp with one of the same desired result contact the nearest power and shape specifically designed for Authorised Service Centre household appliances the maximum power is shown on the light bulb cover Reassemble the lamp cover Replacing the lamp Connect the plug to the mains socket a a CAUTION Open the door Disconnect the plug from the mains Make sure that the light comes on socket Closing the door 1 At the same time with the fingers expand up and down the transparent cover and unhook it in the direction of the arrows 1 Clean the door gaskets 2 If necessary adjust the door Refer to Installation 3 If necessary replace the defective door gaskets Contact the Authorised Service Centre Technical information Technical data Dimensions of the recess Height mm 1780 Width mm 560 Depth mm 550 Rising time Hours 22 Voltage Volts 230 240 Frequency Hz 50 The technical information are situated in the rating plate on the external or internal side of the appliance and in the energy label 10 www zanussi com Installation WARNING Refer to Safety chapters Positioning This appliance can be installed in a dry well ventilated indoor where the ambient temperature corresponds t
12. d placed in the special drawer s provided Butter and cheese these should be placed in special airtight containers or wrapped in aluminium foil or polythene bags to exclude as much air as possible Bottles these need a cap and should be stored on the door bottle shelf or if equipped on the bottle rack Bananas potatoes onions and garlic if not packed must not be kept in the refrigerator www zanussi com Hints for freezing To help you make the most of the freezing process here are some important hints the maximum quantity of food which can be frozen in 24 hrs is shown on the rating plate the freezing process takes 24 hours No further food to be frozen should be added during this period freeze only top quality fresh and thoroughly cleaned foodstuffs prepare food in small portions to enable it to be rapidly and completely frozen and to make it possible subsequently to thaw only the quantity required wrap up the food in aluminium foil or polythene and make sure that the packages are airtight do not allow fresh unfrozen food to touch food which is already frozen thus avoiding a rise in temperature of the latter lean foods store better and longer than fatty ones salt reduces the storage life of food Care and cleaning WARNING Refer to Safety chapters Periodic cleaning AN CAUTION Do not pull move or damage any pipes and or cables inside the cabinet CAUTION
13. erature regulator to a warmer setting Place the fresh food to be frozen in the second compartment The maximum amount of food that can be frozen in 24 hours is specified on the rating plate a label located on the inside of the appliance The freezing process lasts 24 hours during this period do not add other food to be frozen Ice cube production This appliance is equipped with one or more trays for the production of ice cubes Do not use metallic instruments to remove the trays from the freezer 1 Fill these trays with water 2 Put the ice trays in the freezer compartment Thawing Deep frozen or frozen food prior to being used can be thawed in the refrigerator compartment or at room temperature depending on the time available for this operation Small pieces may even be cooked still frozen directly from the freezer in this case cooking will take longer Storage of frozen food When first starting up or after a period out of use before putting the products in the Hints and tips Normal operating sounds The following sounds are normal during operation A faint gurgling and bubbling sound from coils sound when refrigerant is pumped A whirring and pulsating sound from the compressor when refrigerant is pumped A sudden cracking noise from inside appliance caused by thermic dilatation a natural and not dangerous physical phenomenon A faint click noise from the temperature regulator
14. he power socket A CAUTION To carry out the following operations we suggest that this be made with another person that will keep a firm hold on the doors of the appliance during the operations 12 1 Loosen the upper pin and remove the spacer 2 Remove the upper pin and the upper door hinge 4 Remove the lower door 5 Loosen the lower pin 6 Install the lower pin on the opposite side 7 Tighten the middle hinge 8 Install the upper door 9 Tighten the spacer and tighten the upper pin Do a final check to make sure that All screws are tightened The magnetic seal adheres to the cabinet The door opens and closes correctly If the ambient temperature is cold i e in Winter the gasket may not fit perfectly to the cabinet In that case wait for the natural fitting of the gasket In case you do not want to carry out the above mentioned operations contact the nearest Authorised Service Centre The Authorised Service specialist will carry out the reversibility of the doors at your cost www zanussi com Installing the appliance Make sure that the mains cable can move freely 1 If necessary cut the adhesive sealing strip and then apply it to the appliance as shown in figure 2 Push the appliance in the direction of the arrows 1 until the upper gap cover stops against the kitchen furniture 3 Push the appliance in the direction of the arrows 2 against the cupbo
15. ns socket This appliance contains hydrocarbons in the cooling unit Only a qualified person must do the maintenance and the recharging of the unit Regularly examine the drain of the appliance and if necessary clean it If the drain is blocked defrosted water collects in the bottom of the appliance Disposal WARNING Risk of injury or suffocation Disconnect the appliance from the mains supply Cut off the mains cable and discard it Remove the door to prevent children and pets to be closed inside of the appliance The refrigerant circuit and the insulation materials of this appliance are ozone friendly The insulation foam contains flammable gas Contact your municipal authority for information on how to discard the appliance correctly Do not cause damage to the part of the cooling unit that is near the heat exchanger A medium setting is generally the most suitable However the exact setting should be chosen keeping in mind that the temperature inside the appliance depends on room temperature how often the door is opened the quantity of food stored the location of the appliance www zanussi com 1 Turn the Temperature regulator toward lower settings to obtain the minimum coldness 2 Turn the Temperature regulator toward higher settings to obtain the maximum coldness Daily Use Cleaning the interior Before using the appliance for the first time wash the interior and
16. o the climate class indicated on the rating plate of the appliance Climate Ambient temperature class SN 10 C to 32 C N 16 C to 32 C ST 16 C to 38 C T 16 C to 43 C Some functional problems might occur for some types of models when operating outside of that range The correct operation can only be guaranteed within the specified temperature range If you have any doubts regarding where to install the appliance please turn to the vendor to our customer service or to the nearest Authorised Service Centre Electrical connection Before plugging in ensure that the voltage and frequency shown on the rating plate correspond to your domestic power supply The appliance must be earthed The power supply cable plug is provided with a contact for this purpose If the domestic power supply socket is not earthed connect the appliance to a separate earth in compliance with current regulations consulting a qualified electrician The manufacturer declines all responsibility if the above safety precautions are not observed This appliance complies with the E E C Directives www zanussi com Electrical Connection CAUTION Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person AN WARNING This appliance must be earthed The manufacturer declines any liability should these safety measures not be observed The wires in the m
17. ot put electrical appliances e g ice cream makers in the appliance unless they are stated applicable by the manufacturer Be careful not to cause damage to the refrigerant circuit It contains isobutane R600a a natural gas with a high level of environmental compatibility This gas is flammable f damage occurs to the refrigerant circuit make sure that there are no flames and sources of ignition in the room Ventilate the room Do not let hot items to touch the plastic parts of the appliance Do not put soft drinks in the freezer compartment This will create pressure on the drink container Do not store flammable gas and liquid in the appliance Do not put flammable products or items that are wet with flammable products in near or on the appliance Do not touch the compressor or the condenser They are hot Do not remove or touch items from the freezer compartment if your hands are wet or damp Do not freeze again food that has been thawed Obey the storage instructions on the packaging of frozen food Operation Switching on Insert the plug into the wall socket Switching off To turn off the appliance turn the temperature regulator to the 0 position Temperature regulation The temperature is regulated automatically Care and cleaning WARNING Risk of injury or damage to the appliance Before maintenance deactivate the appliance and disconnect the mains plug from the mai
18. wet hands Hands can freeze to the goods 3 Switch on the appliance After three hours reload the previously removed food into the freezer compartment Periods of non operation When the appliance is not in use for long periods take the following precautions 1 Disconnect the appliance from electricity supply 2 Remove all food 3 Defrost if necessary and clean the appliance and all accessories 4 Clean the appliance and all accessories 5 Leave the door doors open to prevent unpleasant smells WARNING If the cabinet will be kept on ask somebody to check it once ina while to prevent the food inside from spoiling in case of a power failure The appliance does not operate The mains plug is not connec ted to the mains socket cor rectly There is no voltage in the mains socket The appliance is switched off Switch on the appliance Connect the mains plug to the mains socket correctly Connect a different electrical appli ance to the mains socket Contact a qualified electrician www zanussi com ee emee a The appliance is noisy The compressor operates contin ually Water flows inside the refrigera tor Water flows on the floor The temperature in the appliance is too low too high www zanussi com The appliance is not supported properly Temperature is set incorrectly Many food products were put in at the same time The room temperature is too high
19. y eliminated from the evaporator of the refrigerator compartment every time the motor compressor stops during normal use The defrost water drains out through a trough into a special container at the back of the appliance over the motor compressor where it evaporates It is important to periodically clean the defrost water drain hole in the middle of the refrigerator compartment channel to prevent the water overflowing and dripping onto the food inside Defrosting the freezer CAUTION Never use sharp metal tools to scrape off frost from the evaporator as you could damage it Do not use a mechanical device or any artificial means to speed up the thawing process other than those recommended by the manufacturer A temperature rise of the frozen food packs during defrosting may shorten their safe storage life i About 12 hours prior to defrosting set a lower temperature in order to build up sufficient chill reserve for the interruption in operation A certain amount of frost will always form on the freezer shelves and around the top compartment Defrost the freezer when the frost layer reaches a thickness of about 3 5 mm Troubleshooting WARNING Refer to Safety chapters What to do if 1 Switch off the appliance or pull out electrical plug from the wall socket 2 Remove any stored food wrap it in several layers of newspaper and put it in a cool place WARNING Do not touch frozen goods with
Download Pdf Manuals
Related Search