Em b ed d ed So lu tio n s
Contents
1. The F18E comes with a tailored passive heat sink within 4 HP height Anyhow forced air cooling is always required inside the system The robust design of the F18E make the board especially suited for use in rugged environments with regard to shock and vibration according to applicable DIN EN or IEC industry standards The F18E is also ready for coating so that it can be used in humid and dusty environments man mikro elektronik gmbh n rnberg Technical Data F18E Data Sheet 2009 04 23 CPU Intel Core 2 Duo T7500 o Dual core 64 bit processor o 2 2GHz processor core frequency o Up to 800MHz front side bus frequency Chipset o Northbridge Intel 965GME Express o Southbridge Intel ICH8M E Enhanced Memory 4MB L2 cache integrated in Core 2 Duo Up to 4GB SDRAM system memory n Soldered o DDR2 o 667MHz memory bus frequency o Dual channel 2x64 bits 8Mbits boot Flash Serial EEPROM 2kbits for factory settings CompactFlash card interface o Via onboard IDE o Typel o True IDE o DMA support Mass Storage Parallel IDE PATA o One IDE port for local CompactFlash Serial ATA SATA o Two channels via side card connector one channel via rear I O o Transfer rates up to 300MB s o RAID level 0 1 support Graphics Integrated in 965GME Express chipset o Up to 500MHz 256 bit graphics core o Maximum resolution 2048 x 1536 pixels 60Hz 32bpp reduced blanking timing driver limi2. or incidental damages arising from the use of its products and reserves the right to make changes on the products herein without notice to improve reliability function or design MEN Mikro Elektronik does not assume any liability arising out of the application or use of the products described in this document The products of MEN Mikro Elektronik are not suited for use in nuclear reactors or for application in medical appliances used for therapeutical purposes Application of MEN s products in such plants is only possible after the user has precisely specified the operation environment and after MEN Mikro Elektronik has consequently adapted and released the product Copyright 2010 MEN Mikro Elektronik GmbH All rights reserved M an RM mikro elektronik gmbh n rnberg
3. AM n 256 MB 512 MB 1 GB 2 GB or 4 GB CompactFlash o 0 MB up to maximum available Graphics One or two DVI D connectors at front via side card o Simultaneous connection of two monitors 1 0 m Ethernet o 9 pin D Sub connector with one or two 10 100Base T ports instead of two RJ45 connectors Rear 1 0 Ethernet o One additional Ethernet channel via side card connector no side card can be used in this configuration o Via one PCI Express link on side board connector Operation Temperature Depends on system configuration CPU hard disk heat sink Maximum 60 C Minimum 40 C all processors Please note that some of these options may only be available for large volumes Please ask our sales staff for more information man mikro elektronik gmbh n rnberg F18E Data Sheet 2009 04 23 Ordering Information Standard Hardware 02F018E00 Intel Core 2 Duo T7500 2 GB DDR2 DRAM 1 Gb Ethernet 1 Fast Ethernet 2 USB VGA CPCI Express with 4 PCle links x1 on XJ2 XJ3 SATA x1 and USB x3 on rear I O XJA 0 460 C Memory 0751 0032 CompactFlash card 8 GB Type I 40 85 C fixed bit set 0751 0038 CompactFlash card 256 MB Type removable 40 85 C 0751 0039 CompactFlash card 512 MB Type removable 40 85 C 0751 0040 CompactFlash card 1 GB Type I fixed bit set 40 85 C 0751 0041 CompactFlash card 2 GB Type I fixed bit set 40 85 C 0751 0042 Compac
4. F18E Data Sheet 2009 04 23 FI8E 3U CompactPC l Express Core 2 Duo SBC ot Comsactpey The F18E is designed for performing system slot functionality in a CompactPCl Express system Equipped with the Intel high performance Core 2 Duo processor T7500 running at 2 2 GHz the F18E is a versatile 4HP 3U single slot single size Eurocard single board computer based on the latest multi core processor architecture from Intel with full 64 bit support The board delivers an excellent graphics performance and is designed especially for embedded systems which require high computing performance with low power consumption A total of six PCI Express lanes for high speed communication such as Gigabit Ethernet are supported on the F18E 1 x1 PCle link is used for one of the two onboard Ethernet interfaces 4 x1 PCle links are available via rear I O 1 x1 link is available via the side card connector and can be used for connection of an additional Gigabit Ethernet via rear I O The DDR2 DRAM is soldered to F18E to guarantee optimum shock and vibration resistance A robust IDE CompactFlash device offers nearly unlimited space for user applications In addition to parallel ATA three serial ATA lines are available The standard I O available at the front panel of F18E includes graphics on a VGA connector one Fast and one Gigabit Ethernet interface as well as two USB 2 0 ports Three USB interfaces and one SATA line can
5. be accessed via rear I O The F18E can be extended by different side cards Intel Core 2 Duo T7500 2 2 GHz Dual core 64 bit processor 4 HP CompactPCl Express system master PCI Express 4x1 links on system slot Up to 4 GB DDR2 DRAM soldered CompactFlash slot 3 SATA interfaces Video via VGA and SDVO Front 1 Gigabit PCle and 1 Fast Ethernet Rear 1 Gigabit Ethernet PCle optional 9 USB 2 0 High Definition audio Board controller Additional functions include up to two digital video input for flat panel connection via DVI multimedia a variety of different UARTs or another four USB 2 0 ports SATA for hard disk or RAID connection and HD audio Thermal supervision of the processor and a watchdog for the operating system complete the functionality of the F18E The F18E operates in Windows and Linux environments as well as under real time operating systems that support Intel s multi core architecture The Award BIOS was specially designed for embedded system applications Equipped with Intel components exclusively from the Intel Embedded Line the F18E has a guaranteed minimum standard availability of 5 years The F18E is suited for a wide range of industrial applications e g for monitoring vision and control systems as well as test and measurement Main target markets comprise industrial automation multimedia traffic and transportation aerospace shipbuilding medical engineering and robotics
6. ion 2 5 Gbits s per lane CompactPCI Express Compliance with CompactPCI Express PICMG EXP 0 R1 0 Specification CompactPCl Express connector P1 for power supply CompactPCl Express connectors J2 and J3 for four PCI Express x1 links CompactPCIG Express connector J4 for rear I O Electrical Specifications Supply voltage power consumption o 5V 3 5 3 22A no load 3 17A load 66 3 16A full load o 12V 10 10 0 39A no load 2 18A load 66 2 87A full load MTBF tbd 40 C according to IEC TR 62380 RDF2000 man mikro elektronik gmbh n rnberg Technical Data F18E Data Sheet 2009 04 23 Mechanical Specifications Dimensions conforming to CompactPCI Express specification for 3U boards Front panel 4HP with ejector Weight 420g Environmental Specifications Temperature range operation o 2 2GHz Core 2 Duo T7500 0 60 C o Airflow 1 5m s Temperature range storage 40 85 C Relative humidity operation max 95 non condensing Relative humidity storage max 95 non condensing Altitude 300m to 2 000m Shock 15g 11ms Bump 10g 16ms Vibration sinusoidal 1g 10 150Hz Conformal coating on request Safety PCB manufactured with a flammability rating of 94V 0 by UL recognized manufacturers EMC Tested according to EN 55022 radio disturbance IEC1000 4 2 ESD and IEC1000 4 4 burst BIOS Award BIOS Software Support N
7. ote that 64 bit hardware technology requires 64 bit operating system support Windows including Vista Linux VxWorks on request QNX on request Intel Virtualization Technology allows a platform to run multiple operating systems and applications in independent partitions one computer system can function as multiple virtual systems For more information on supported operating system versions and drivers see Software man mikro elektronik gmbh n rnberg F18E Data Sheet 2009 04 23 Diagram Frontpanel p7 Intel connector i Options mM Rear I O Corea Duo connector System Memory DDR2 SDRAM System Memory 965GM Express DDR2 SDRAM Memory Controller Graphics Controller Watchdog IDE PATA CompactFlash USB 2 0 USB 2 0 USB 2 0 USB 2 0 USB 2 0 USB 2 0 Side Card Connector HD Audio PCIe x1 ICH8 M DH l O Controller Hub Rear I O PCIe x1 PCIe x1 CompactPCI Express PCle x1 J2 J3 PCle x1 Rear I O mikro elektronik gmbh n rnberg F18E Data Sheet 2009 04 23 Configuration amp Options Standard Configurations Article No CPU Type Clock System RAM CFlash Side Card Slot Operation Temperature 02F018E00 T7500 2 2 GHz 2 GB 0 MB right 0 60 C Options CPU Core 2 Duo T7500 2 2GHz 35W Core 2 Duo L7500 1 6 GHz 17W Core 2 Duo U7500 1 06GHz 10W Memory System R
8. tFlash card 4 GB Type I fixed bit set 40 85 C Miscellaneous Software Windows 13T003 70 Windows chipset driver Intel for F14 F15 F17 F18 F18E F19P D9 D6 D7 D601 A19 and A20 Documentation 20F018E00 F18E User Manual For the most up to date ordering information and direct links to other data sheets and downloads see the F18E online data sheet under www men de man mikro elektronik gmbh n rnberg F18E Data Sheet 2009 04 23 Contact Information Germany France USA MEN Mikro Elektronik GmbH MEN Mikro Elektronik SA MEN Micro Inc Neuwieder Strake 5 7 18 rue Ren Cassin 24 North Main Street 90411 Nuremberg ZA de la Ch telaine Ambler PA 19002 Phone 49 911 99 33 5 0 74240 Gaillard Phone 215 542 9575 Fax 49 911 99 33 5 901 Phone 33 0 450 955 312 Fax 215 542 9577 E mail info men de Fax 33 0 450 955 211 E mail sales amp menmicro com www men de E mail info men france fr www menmicro com www men france fr The date of issue stated in this data sheet refers to the Technical Data only Changes in ordering information given herein do not affect the date of issue All brand or product names are trademarks or registered trademarks of their respective holders Information in this document has been carefully checked and is believed to be accurate as of the date of publication however no responsibility is assumed for inaccuracies MEN Mikro Elektronik accepts no liability for consequential
9. ted VGA connector at front panel Two SDVO ports available via side card connector o Two additional DVI connectors at front panel optional via side card 1 0 USB o Two USB 2 0 ports via Series A connectors at front panel o Four USB 2 0 ports via side card connector o Three USB 2 0 ports via rear I O connector J4 o UHCI implementation o Data rates up to 480Mbits s Ethernet o One 10 100 1000Base T Ethernet channel via RJ45 connector at front panel o Ethernet controller connected by one x1 PCle link o One 10 100Base T Ethernet channel via RJ45 connector at front panel o Connected to Southbridge via LCI o One 10 100 1000Base T Ethernet channel via rear I O optional o Connected via side card connector o Onboard LEDs to signal activity status and connection speed High Definition HD audio a Accessible via side card connector Front Connections Standard a VGA Two USB 2 0 Series A Two Ethernet RJ45 Miscellaneous Board controller Real time clock buffered by a GoldCap or alternatively a battery 5 years life cycle Watchdog timer Temperature measurement One user LED Reset button PCI Express One xl link to connect local 1000Base T Ethernet controller o Data rate 250MB s in each direction 2 5 Gbits s per lane Four xl links for rear I O on J2 J3 o Data rate up to 1GB s in each direction 2 5 Gbits s per lane s One x1 link via side card connector o Data rate 250MB s in each direct
Download Pdf Manuals
Related Search