CT-445 Countertop Reverse Osmosis System
Contents
1. NA Q gt filters The performance of your drinking water system is directly related to ANK ES Q ms the quality of the water being treated and the particular application for which it RE 53 is used Therefore the manufacturer s liability is limited to the cost of repair Q ms IX NA or replacement at our option of any defective part and does not include IX ms ROE incidental or consequential damage of any kind This warranty gives you ms specific legal rights and you may also have other rights which vary from state KA NEKS BEES e y to state XA DKE b System must be installed and operated in accordance with the manufacturer s IX NA recommended procedures and guidelines IX e gt EXD c Warranty is void if product failure or damage results from freezing neglect KNEKNEKNEKNEK NERS DUOMO e gt misapplication fouling with sediment or scale or failure to operate the system e y in accordance with the instructions contained in the owner s manual IX d The following operating conditions must also be followed for this warranty to be valid The hardness of the water can not exceed 7 grains per gallon or 120 ppm OPIOID KEK ES XY 3 e Iron should be less than 0 3 ppm RR IK The pH of the water must not be lower than 3 or higher than 11 IX QOD e Incoming Total Dissolved Solids can not exceed 1000 ppm NE2. carefully check for any damage CHECKLIST See lt fig 1 gt 1 Spigot 2 Transformer N A with CT 445NF 3 Countertop RO System 4 Special aerator CT 322 with 2 adapters 13 16 15 16 5 Series CT Manual Series CT Manual SPIGOT INSTALLATION Wipe the inside of the water reservoir and rinse with clean water Install the spigot as shown in lt Fig 2 gt It is important that the rubber washer be installed on the outside of the reservoir Hand tighten by turning the spigot Do not over tighten Reservoir Wall Plastic Nut Water Reservoir lt Fig 2 gt Series CT Manual FAUCET AERATOR INSTALLATION Male thread faucet Female thread faucet a Thick Washer n Thin Washer 7 CT 322 Special aerator Snap adapter Plastic collar Hose to RO Snap adapter ie Wing valve lt Fig 3 gt Remove the existing aerator from the faucet and attach the new special aerator CT 322 included with the RO unit Consult lt fig 3 gt The special aerator included with the RO unit will fit most standard faucets However if the aerator does not fit your faucet consult your dealer Most hardware or plumbing stores carry a complete line of faucet adapter fittings When tightening the fitting use a pair of pliers and tighten carefully wrap tape around the jaws to prevent marring the fittings To attach the faucet snap adapter to the special aerator pull down on the snap adapter plastic collar and push o
3. ARS CNAN PINKS O ms Limitations and Exclusions KK NEKS EES e gt The manufacturer will not be responsible for any implied warranties including RE 53 those of merchant ability and fitness for a particular purpose The manufacturer IX will not be responsible for any incidental or consequential damages including IX REY IIS Q ms travel expense and telephone charges Loss of revenue loss of time IX OIXE XD inconvenience loss of the equipment or damage caused by the equipment and its failure to function properly are excluded This warranty sets forth all of the NEKREKNEARE RANA manufacturer s responsibilities regarding this equipment IX KS gt PRINT IN USA 11 CAT MAN CT G2005
4. INSTALLATION amp SERVICE MANUAL Countertop Reverse Osmosis Systems Series CT N System Tested and Certified by WQA against NSF ANSI Standard 58 for the reduction of Arsenic Barium Cadmium Copper Cyst Hexavalent Chromium Lead Radium 226 228 Selenium TDS Trivalent Chromium as verified and substantiated by test data Member ALY O Manufactured by s Assocanon y Topway Global Inc Test and Certified Brea Calif 92821 U S A by WQA Series CT Manual Thank you for choosing a Series CT counter top reverse osmosis drinking water system With proper care your water filtration system will produce high quality drinking water for many years Read carefully and follow the instructions in this manual before installation Pay particular attention to all warnings cautions and notes Failure to do so could result in personal injury or damage to the equipment or other property System and installations need to comply with state and local laws and regulations There are many benefits from using reverse osmosis water Not only will you enjoy high quality drinking water but also will find the water unsurpassed for e Cooking Juices Coffee and Tea Ice Cubes Low Sodium Diets Baby Formulas Weight Loss Diets Steam Irons Car Batteries e Household Plants e Windshield Washers e Humidifiers Pets Aquariums A Aerator O as Transformer Countertop System lt Fig 1 gt Remove the unit
5. al dissolved solids and that product water shall be tested periodically to verify that the system is performing properly Series CT Manual TROUBLESHOOTING PROBLEM CAUSE SOLUTIONS Milky colored W Air in system Air in the system is a normal occurrence water with initial start up of the RO system The milky look will disappear during normal use within 1 to 2 weeks Slow V Low water pressure C Add a booster pump production Y Crimps in tubing Y Clogged prefilters Y Fouled membrane C Make sure tubing is straight CI Replace prefilter CI Replace membrane Water taste or smell offensive Post carbon depleted Y Fouled membrane Replace post carbon Replace membrane No drain water Leaks Y Clogged flow restrictor VY Fittings are not tightened Y Twisted O ring Replace flow restrictor C Tighten fittings as necessary C Replace O ring 10 ANK Limited One Year Warranty 1 What your warranty covers IX NA Series CT countertop reverse osmosis systems are warranted to the original NAX DII OEK owner to be free of defects in material and workmanship from the date of IX S ANANKA gt manufacture for one year excluding the replaceable filters XY x3 Conditions of warranty IX LD xe a System must be maintained and serviced with approved replacement parts and NEARS
6. ed contaminants from the membrane Restricting this flow allows the impurities to build up on the membrane and the membrane will be damaged Make sure that this flow yields 1 2 glass or cup in 30 seconds 110 200 m1 30 seconds This will protect the membrane To clean the reservoir use baking soda and a soft cloth To sanitize the water reservoir let stand for 1 hour Rinse thoroughly before using the unit OVERFLOW It is important that the hose lay flat on the counter for the overflow system to work properly Do not use with water that is unsafe or of unknown quality without adequate disinfection before or after the system Systems certified for cyst reduction may be used on disinfected waters that contain filterable cysts Model CT 445 CT 445P Pressure 50 90 10 90 pH Range 3 11 3 11 Temperature 40 100 F 40 100 F Daily Production Rate 22 3GPD 43GPD Recovery Rate 30 2 35 4 Storage Capacity 1 25 Gallon 1 25 Gallon System Dimension In 11x10x14 5 11x10 14 5 Shipping Weight Lb 15 20 Recovery Rating means the percentage of the influent water to the membrane portion of the system that is available to the user as reverse osmosis treated water when the system is operated without a storage tank or when the storage tank is bypassed Series CT Manual INSTALLATION GUIDE TANK LEVEL CONTROL TLC LAYOUT Q Q Over Flow hag Pure Water lt Fig 5 gt 1 3 pin connection for sens
7. nto the special aerator until it seats Release the plastic collar The plastic collar will snap into place It is important that the hose lay flat on the counter with no sharp bends or kinks This will allow the overflow failure to function properly Series CT Manual START UP Open the plastic wing valve see lt fig 3 gt two full turns counterclockwise And slowly turn on the cold water NOTE Do not allow hot water to enter the unit This will permanently damage the membrane Water will fill the unit and also flow from the bottom outlet of the wing valve Do not completely shut off the reject water This will damage the membrane The reservoir will slowly fill The rate at which the reservoir fills will vary with water pressure and water temperature Typical water production will be to 1 gallon per hour Discard the first two full reservoirs before using This will insure that any loose filter material is flushed from the system prior to use NOTE 1 Do not connect to hot water 2 Do not allow to freeze 3 Do not restrict the reject flow wing valve beyond 4 6 oz per 30 seconds 110 200 m1 30 seconds A Faucet B Plastic wing valve C Electrical outlet aa ea lt Fig 4 gt Typical layout of CT Series Series CT Manual HELPFUL HINTS Proper reject flow It is important that the reject water flow from the wing valve at all times This flow of reject water removes the unwant
8. or wire 2 2 pin connection for pump 3 2 pin connection for transformer Power Powered with world wide primary voltage available 100V 120V 230V Series CT Manual CT 445 FILTRATION PROCESS To Storage Tank Feed Water Please contact your local dealer at Or call TOPWAY GLOBAL INC at 800 840 1688 for your local dealer listing phone number Replacement Part No Part No Descriptions Service life 1 FI SED010S _ Inline sediment filter 6 12 months 2 FI CBA010S Inline GAC filter 6 12 months 3 MM TFF45 75 TFC membrane 35GPD 2 3 years 4 FI CBA010S Inline GAC filter 12 18 months This system contains a replaceable treatment component critical for the effective reduction of total dissolved solids and that product water shall be tested periodically to verify that the system is performing properly Series CT Manual CT 445P FILTRATION PROCESS To Storage Tank Feed Water Please contact your local dealer at Or call TOPWAY GLOBAL INC at 800 840 1688 for your local dealer listing phone number Replacement Part No Part No Descriptions Service life 1 FI SED010S Inline sediment filter 6 12 months 2 FI CBA010S _ Inline pre carbon filter 6 12 months 3 MM TFF45 75 TFC membrane 35GPD 2 3 years 4 FI CBAO10S _ JInline post carbon filter 12 18 months This system contains a replaceable treatment component critical for the effective reduction of tot
Download Pdf Manuals
Related Search