OWNER`S MANUAL - E
Contents
1. and Warranty Claim Procedures Refer to publication 052580 111 Carefree Major Product Limited Warranty available online at www carefreeofcolorado com Register your Carefree products on line at www carefreeofcolorado com Publications available on line www carefreeofcolorado com 052522 002 Apex Installation Manual 052522 230 Apex Owner s Manual 052522 301 Apex Service Manual IMPORTANT NOTICE It is strongly recommended that adjustments and repairs not described in this book be performed by trained technicians at your Authorized Carefree Dealer Work performed by non authorized persons or businesses may void warranty 11 Carefree of Colorado 2145 W 6 Avenue Broomfield CO 80020 a Scott Fetzer company www carefreeofcolorado com 052522 230r3 Printed in USA February 20122. 433 MHz remote uses a battery Radio Shack p n 23 279 or equivalent that should provide a long period of service To access Remove the small screw from the back of the case and carefully snap off the back Lift the old battery out and insert the new battery Batteries are available through your local battery outlets Battery life is dependent on frequency of use environmental conditions and condition of remote APEX MULTI AWNING REMOTES Stop All Stop All All Awnings All Awnings Extend Retract Se Extend Retract ETS Driver Side Extend Retract Passenger Side A PEPI PERT A n A a a a dias rant E Individual Awnings Extend Retract 2 Awning Remote 4 Awning Remote taosg Extend ___ Press and release The awning will extend out to the full extension and stop automatically During normal operation the awning will extend out completely then roll back slightly to provide tension to the fabric Retract Press and release The awning will retract and stop automatically when the awning is fully retracted Press and release During extend and retract functions the operator may stop the awnings by pressing this button To stop an individual awning during an operation press and release the SAME button a second time Example press the extend button to extend the awning press the same extend button to stop the awning before the awning is fully extended THIS DOES NOT APPLY TO THE EXTEND RETRACT ALL BUTTONS IMPORT
3. The red light will go out after the receiver learns the remote signal A CAUTION When the receiver learns the transmitter signal the system will perform the operation of the button pressed Example Pressing an Extend button during the learning phase will cause the awning to extend when the receiver learns the signal Use caution to avoid unexpected movement by the awning 6 Repeat for each additional remote OPERATIONAL NOTES The transmitter and receiver operate on a frequency of 433MHz The receiver exits the program mode after ten seconds If the light does not come on in step 2 the memory is full and must be cleared If the light still does not come on check the continuity of the cord between the boxes and repair or replace as required Pin 1 of the 1 connector goes to pin 1 of the 2 connecior etc If the light does not go out above the receiver knows the transmitter signal or the battery in the Remote needs to be replaced To clear the memory PRESS AND HOLD the receiver learn button While holding the button the indicator light should be OFF for the full 5 seconds then come on The receiver may be programmed for up to 5 remotes Additional remotes may be ordered separately APEX MANUAL OVERRIDE If 110V power is not available to the coach the Apex awning can still be safely retracted using the manual override 1 The bypass is located inside the A 6 case near the end cap
4. To pen pen J access remove the large rubber CEA mone plug on top of the awning I Manual located toward the rear of the X Override Ko case on the motor side Close Close 2 Chuck the supplied 7mm hex key into a 3 8 battery powered drill Lead Rail S 3 Insert the hex key into the LH Motor RH Motor manual override on the awning RTA015a 4 Operate the drill in the direction shown in the diagram to open and close the awning 5 When done reinsert the rubber plug AWNING CARE Maintaining a Carefree Awning is easy Just follow these basic steps e Always operate the awning according to the instructions e Periodically check that the fasteners are tight Tighten if necessary e Keep the awning fabric and arms clean FABRIC CARE A CAUTION Do not use oil based cleaners or any caustic granulated or abrasive type cleaners on your Carefree product 1 One of the best ways to keep the fabric looking good and to delay the need for deep or vigorous cleanings is to hose fabrics off on a monthly basis with clear water This practice will help prevent dirt from becoming deeply imbedded in the fabric In most environments a thorough cleaning will be needed every two to three years 2 When it s time for a thorough cleaning the fabric can be cleaned while still on the awning frame e For Acrylic Fabric Use a stiff brush and warm water with soap 3 When cleaning the fabric it is important to obse
5. power is on A CAUTION It is strongly recommended that the power switch be set to OFF whenever the awning is not being operated and during transport This acts as a safety to prevent the awning from being accidently opened Press and release During extend and retract functions the operator may stop the awnings by pressing this button Extend Press and release The awning will extend out to the full extension and stop automatically During normal operation the awning will extend out completely then roll back slightly to provide tension to the fabric Retract Press and release The awning will retract and stop automatically when the awning is fully retracted APEX To stop an individual awning during an operation press and release the SAME button a second time Example press the extend button to extend the first awning press the same extend button to stop the first awning before the awning is fully extended THIS DOES NOT APPLY TO THE EXTEND ALL OR RETRACT ALL BUTTONS IMPORTANT NOTE When using the Extend All or Retract All commands the awnings continue until FULLY extended or retracted To stop the awnings press the stop button THE AUTO RETRACT SYSTEM The system is active when the awning power is on and disabled when the power is shut off To turn on the system press the power button ON The Direct Response system detects awning motion caused by windy conditions The motion sensor is located in the lead rail The syste
6. ANT NOTE When using the Extend All or Retract All commands the awnings continue until FULLY extended or retracted To stop the awnings press the stop button Key Pad Remote Battery The remote uses two standard AAA Batteries that should provide a long period of service To access open the access cover on the back of the case Batteries are available through your local battery outlets Carefree of Colorado PROGRAMMING THE RF RECEIVER FOR A REMOTE When adding or replacing a remote control it is necessary to program the transmitter and receiver 1 2 3 Power to the control box must be on Locate the receiver box Press and release the Press to Learn Transmitter button on the bottom of the receiver The receiver is in program mode when the red light comes on For Single Awning Key FOBS Press and release the STOP button on the remote The red light will go out after the receiver learns the remote signal Press to Learn Transmitter NOTE Pressing the stop button will cause the blue up arrow button to Indicator Program default as the open extend Light Button function If a function button is pressed to train the receiver it will be programmed as the open extend button Example Pressing the bottom button will program the bottom button for extend and the top button as retract For Multiple Awning Remotes Press and release the ANY button on the remote It is recommended to use the stop button
7. auto retract system is a guarantee against severe or destructive weather the effects of wind and rain on an awning are unpredictable and may cause severe damage to the awning and or vehicle If wind or extended periods of rain are expected retract the awning Carefree of Colorado USING THE REMOTE CONTROL A remote control is provided with the Direct Response system In simple terms the remote is a wireless key pad that functions in the same manner that the stationary control panel The remote provides the advantage of allowing you to operate the awning from any convenient location The remote has a maximum operating range of 50 feet Actual distance may vary depending on the specific installation and location of the receiver in the vehicle Remotes transmit on a frequency of 433MHz To use turn system power ON at the control panel NOTE Power ON OFF and the Auto Retract system can only be operated at the control panel SINGLE AWNING KEY FOB A remote control Key FOB is furnished with the single awning installation To use turn system power ON Extend Press and release The awning will extend out to the full extension and stop automatically Retract Press and release The awning will retract and stop Function automatically when the awning is fully retracted Buttons Stop Press and release During extend and retract Stop functions the awning may be stopped by pressing this button DR010 Key FOB Battery The
8. ey OWNER S MANUAL haree APEX WITH DIRECT RESPONSE ELECTRONICS TABLE OF CONTENTS METRO CRUE TN OND Eorann ODOT ANION sasine nicin a aa aE a aiaa SAE Aaaa Single Awning Control Panel ccccccceeeccccceeeseeeseeeceeeesseeeeeeeeeeeessaaeeeeeeeeeas Multiple Awning Control Panels cccccccccceccccseessseeseeeeeeeeeeeeeeeeeseseaaeeeeseess The Auto Retract System ccccccccsssseeccceeeeeeeeeeeeeeeeseeeeeceeeesssaeaeeseeeesssaaageess Using the Remote Control ccccccccccccsssseeceeeeeeeeeeeeeeeeeeesseeeeeeeeeeseeaaeeeeeeees Single Awning Key FOB cccccccccceceseeeseeceeeeeeseeeeeeeeeeesssaeeeeeeeeeeeeas Multi AWning Remotes ccccseececcseeeeeceeeeecseeeeeseeeeeseaeeeesseeeeesaeeeesees Programming the RF Receiver for a Remote ceeeeeeeeeeeeeeeeeees ite Wee OVE eee te neenees ee nee ment e pene eee eee eee AWNING CIE eee eee E ee eerrer eee ee ee eee eer ree Fe UNE AI T E E E E nesters A aetna arena E E E E hea ues FOCO ee a a iaseseaenseedag cere eeeasteesotesanseaesers Carefree Major Product Limited Warranty ssssssnnnnnnnnnnnnnnnunnnnnnnnnnnnnnnnnnnnnnnnn 11 Carefree of Colorado INTRODUCTION From it s beginning in the early 70 s Carefree of Colorado has emerged as the premier manufacturer of quality awnings and accessories for Recreational Vehicles RVs Our full line of products can provide the accessories that match your life style no matter what t
9. m oy 0 0 0 operates by gauging the vertical motion of the a awning s leading edge When persistent motion exceeds the factory preset threshold value for 2 Monan a el seconds or longer the system automatically retracts the awning The control panel provides 4 factory preset sensitivity values threshold values You may have to experiment to find the best setting for your preferences RTAO39c Low ____The lower the selection less motion is required before the system closes automatically High____ The higher the selection more motion is required before the system closes automatically Gust detection is incorporated into the software When the motion value is suddenly and sharply increased above a safe maximum value then the 2 second persistence measure Is overridden and the awning closes immediately IMPORTANT NOTE FOR MULTIPLE AWNING CONFIGURATIONS Each awning has an independent motion sensor During windy conditions the awnings may not retract concurrently NOTE If the Indicator LED flashes slow pulse this indicates that a motion sensor has been disengaged or otherwise disabled the affected awning s are not protected by the auto retract system The awning must be retracted using the command buttons Immediately contact a Carefree service center for service A CAUTION The Carefree Direct Response System is a premiere electronic auto retract system that provides protection against adverse elements but no
10. ol each awning individually or together Operational Notes Ignition Lockout Sensors If the optional Carefree EL ignition lockout is installed the system will disable the extend function while the vehicle ignition key is in the ON position Special order RTL ignition lockouts will fully retract the awning and disable the extend function when the vehicle ignition key is in the ON position Functions will return to normal operation when the ignition key is turned OFF Coach manufacturers may install their own lockout design Refer to the coach literature for AC power for accessories Awning Motor The awning motor is equipped with a thermal protection circuit to protect the motor from overheating Operating the awning repeatedly over a short time period may cause the circuit to sense a overheat condition and shut off the motor If this occurs wait approximately 15 minutes to allow the motor to cool then operate the awning in normal fashion CAUTION FOR MULTIPLE AWNINGS ONLY PRESSING MULTIPLE BUTTONS AT THE SAME TIME MAY CAUSE THE AWNINGS TO APPEAR TO MOVE ERRATICALLY IF THIS OCCURS PRESS THE STOP BUTTON USE THE INDIVIDUAL CONTROLS TO SET THE AWNING S TO THE DESIRED POSITION APEX SINGLE AWNING CONTROL PANEL LED Indicator LED Indicator On Off Ss o LED is Steady ON when power is ON Extend o LED will dim and fast flash when a function key is pressed o LED will slow flash if a motion sensor Retract is disengaged or di
11. rve the following e Always use a natural soap never detergent e Water should be cold to lukewarm never more than 100 F e Air dry only Never apply heat to the fabric e Always allow the fabric to dry thoroughly before retracting the awning POOLING When water collects on the top of the fabric this is known as pooling This can occur during inclement weather or if a running air conditioner discharges over the awning The water is dumped when the awning is retracted It is recommended that if water accumulates on the top retract the awning in steps 8 12 to dump the water This will help prevent the fabric from stretching or distorting Carefree of Colorado NOTES APEX CAREFREE MAJOR PRODUCT LIMITED WARRANTY Carefree of Colorado hereafter referred to as Carefree warrants to the first retail Purchaser that the Carefree Product is free of defects in material and workmanship within the terms and conditions as set forth in the warranty statement available online at www carefreeofcolorado com Carefree s obligation under this warranty is limited to the repair or replacement at Carefree s option of any defective component with new or factory refurbished components OWNER MUST RETAIN THE ORIGINAL PROOF OF PURCHASE AND OR HAVE THE PRODUCT WARRANTY REGISTRATION ON FILE AT CAREFREE FOR WARRANTY CLAIMS THIS WARRANTY IS NOT TRANSFERABLE For Warranty Duration Warranty Coverage and Exclusions Warranty Terms of Coverage
12. sabled Motion Sensitivity Low High Single Awning RTA039a Power _ Press ON Press Off The power switch must be on before any awning functions can be used When the power is ON the LED indicator will illuminate The Direct Response Auto Retract is active when awning power is on A CAUTION It is strongly recommended that the power switch be set to OFF whenever the awning is not being operated and during transport This acts as a safety to prevent the awning from being accidently opened Extend Press and release The awning will extend out to the full extension and stop automatically During normal operation the awning will extend out completely then roll back slightly to provide tension to the fabric NOTE If the optional Carefree ignition lockout is installed the system will disable the extend function while the vehicle ignition key is in the ON position Functions will return to normal operation when the ignition key is turned OFF Coach manufacturers may install their own lockout design Refer to the coach literature for AC power for accessories Press and release During extend and retract functions the operator may stop the awning by pressing this button Retract Press and release The awning will retract and stop automatically when the awning is fully retracted When the button is pushed the LED will illuminate and stay on until another function is activated All function buttons are press ON The auto func
13. tions continue until the awning is fully extended or fully retracted or when the button is pressed a second time to stop the function It is not necessary to hold the button while the function is active See Page 4 for descriptions of the Auto Retract settings Carefree of Colorado MULTIPLE AWNING CONTROL PANELS LED Indicator F St op All Awnings Power Carette On Off frees e Awning Control Extend __Retract a tm All Awnings Extend Retract Individual Awnings Extend Retract Motion Sensitivity Low High 2 Awning LED Indicator Power carere All Awnings On Off ower va a T All Awnings Extend Retract Individual Awnings maa a Extend RetractN p a m Driver Side i Extend Retract Passenger Side Extend Retract Motion Sensitivity Low High 4 Awning RTA039b The controls are divided into specific groups The individual controls allow you to extend or retract awnings individually The combination controls can be used to simultaneously extend or retract all of the awnings LED Indicator o LED is Steady ON when power is ON o LED will dim and fast flash when a function key is pressed o LED will slow flash if a motion sensor is disengaged or otherwise disabled Power _ Press ON Press Off The power switch must be on before any functions can be used When the power is ON the LED indicator will illuminate The Direct Response Auto Retract is active when awning
14. ype of RV you own Check with your dealer to discover the products that can make your life more Carefree The Apex Patio Awning offers the coach owner an awning system that provides as much or as little shade as required The versatile awning system is available as a single awning or as a 2 or 4 awning combination with all awnings controlled at a single master control panel Each unit is equipped with Apex lateral support arms that are the strongest available on the market No vertical arms interfere with coach sidewalls or equipment that may be mounted on the roof These arms can also be adjusted to vary the canopy pitch up to 2 feet it is strongly recommended that service and adjustments be performed by trained technicians The canopy is made from acrylic fabric The canopies are housed in an aluminum case that easily blends in with the coach roof The unique and innovative 110V electronic control system provides Carefree s Direct Response system with interior pushbutton controls for standard extend retract functions At the master control panel the auto retract system sensitivity can be set to respond to a variety of wind speed conditions An RF remote is included as standard OPERATION The Direct Response system provides a wide range of awning controls with control panel operation in one convenient location Standard operation is straight forward with the buttons clearly labeled The control panel is designed to allow the user to contr
Download Pdf Manuals
Related Search