Service Engineering Summary\
Contents
1. agla S031029 Pici Service Engineering Summary To Honda Field Service March 16 2002 From Service Engineering Subject March Tech Line Information Tech Line Summary for Dealer Distribution General 3 02 2003 Civic SI Monroney sticker parts content information The parts content information listed on the 2003 Civic SI Monroney sticker is the parts PAR Venice IN NTIS eARLINS content information for the entire Civic pa Cgnadian Pacts Content n l model line carline This includes Civics Ir Sources Sap ogy Marts Content manufactured in Japan Canada United NOTE Parts content does not include final States England and other countries rm assembly distribution or other non parts costs sn FOR THIS VEHICLE Fina ARDAN WILSHIRE ENGLAND Country of Origin Engine JAPAN Transmission JAP 2002 Odyssey Vehicle Identification Number error in Service Manual The Vehicle Identification Number VIN decoder on page 1 5 of the 1999 2002 Odyssey Service Manual is incomplete Add the following information to all copies of the Odyssey Service Manual dm sn h Serial Number h Serial Number 500001 U S Model 500001 U S Model 000001 Canadian Model 000001 Canada Model 2HKRL 000001 U S Model 5FNRL Current Service Manual Proposed Service Manual yepdod PGM Tester software SN211 Capabilities and Limitations 1997 2001 Civic The VIN entry screen only lists 1HG it does not conta2. hesitation is Fuel Cut OFF caused by low or delayed oil pressure To correct this hesitation check and correct the oil level or oil supply problem rt sn 027 2001 CR V DTC P0131 heated oxygen sensor If PGM Tester currently shows a low Primary HO2S voltage disconnect the sensor and recheck the Primary HO2S voltage The voltage should be approximately 3 80 volts if voltage is lower than 3 80 volts check the HO2S connector for oil contamination If the connector is clean install a known good ECM PCM ed sn Transmission 3 02 1999 2000 Civic SI Excess clearance between synchronizer and hub If the transmission appears to have too much clearance between the synchronizer and the hub when performing Service Bulletin 01 082 Grinds at upshifts check to see if you are using the correct section of the Service Manual The Civic SI S4C transmission is in a separate section of the Service Manual Do not use the S40 transmission section that applies to all models except SI pl sn E Bod Oo 3 02 7 SBoBOM MAY 02 2002 1998 2002 Accord Creaking ticking noise at glove compartment If the hook shaped dash support bracket above the dash support tube hits the right A pillar it can cause a creaking or ticking noise from the right side of the dash This noise can be intermittent and or temperature related To silence this noise remove the passenger s fuse box cover and look upward under the dash If the hook is touch
3. acy and save time rw sn A Alpha N November B Bravo O Oscar C Charlie P Papa D Delta Q Quebec E Echo R Romeo F Foxtrot S Sierra G Golf T Tango H Hotel U Uniform l India V Victor J Juliet W Whiskey K Kilo X X ray L Lima Y Yankee M Mike Z Zulu Engine SKEB a 3 02 1994 2002 Accord w VTEC Hesitation at high engine speed 1992 2002 Civic w VTEC 1993 2001 Prelude w VTEC U 1999 2002 Odyssey Qced S 2000 2002 Insight 2000 2002 2000 MAY 02 2002 Low engine oil level a dented oil pan contacting the oil pick up screen or other oil flow restrictions can cause a hesitation at high engine speeds on all VTEC models This hesitation usually occurs under the following conditions When the throttle opening vehicle speed coolant temperature and RPM indicate VTEC is needed the ECM PCM turns the VTEC solenoid ON e Assoon as the VTEC solenoid is turned ON oil pressure should immediately turn the VTEC pressure switch OFF e Ifthe VTEC pressure switch does not turn OFF immediately the ECM PCM will command Fuel Cut OFF and turn all of the injectors OFF e When the ECM PCM sees the VTEC solenoid ON and the VTEC pressure switch ON the ECM PCM normally sets DTC P1259 But if the VTEC pressure switch changes from ON to OFF before the DTC sets the engine will hesitate then run normally The customer complaint will be a brief hesitation when accelerating The cause of this
4. in 2HG and JHM prefixes Enter the VIN manually to use the PGM Tester on these vechicles EVAP Function Test If the Evaporative System Function Test results in an error message that Says Fuel vapor flow too high or too much fuel in tank check the fuel level If the fuel level is below Full see if the Purge Control Solenoid PCS is sticking or leaking If the PCS is faulty replace the PCS PGM Tester Data Transfer Module error message If the PGM Tester stops sending data and the screen says TRANSFER ABORTED when sending data through the Data Transfer Module DTM it means that the Tech Line computer detected an abnormal data bit and hung up The abnormality can be in the PGM Tester software or in the captured data If the data was difficult to duplicate and capture you must print your trigger point data and fax it to Tech Line at 310 783 3530 with your Tech Line reference number If the data was easy to duplicate reload PGM Tester software version SN211 recapture the data and send it again Reloading the PGM Tester software seems to correct these data bit abnormalities eb sn International Phonetic Alphabet To reduce the length of time you are on the phone calling Tech Line use the following International Phonetic Alphabet Using words like Alpha Bravo and Charlie will prevent confusion between similar sounding letters like m and n and b and c Not having to repeat letters will improve accur
5. ing the A pillar insert a long screwdriver between the hook shaped bracket and the body and bend it slightly to provide clearance Andy Lee Honda of Serramonte sn 4 O2 00 95 Accessories 3 02 2002 CR V Fog lights and cruise control switches do not operate properly During foglight installation it is very easy to misconnect the blue foglight switch connector and gray cruise control connector The connectors and switches are identical except color so the foglight switch will operate the cruise control and the cruise control switch will operate the foglights with the following additional symptoms e The cruise control is inoperative unless the foglight switch is also ON e The cruise control power indicator only illuminates when the headlights are ON e The foglights are inoperative unless the cruise control switch is also ON e The foglight switch indicator only illuminates when the switch and ignition are turned ON tj sn
Download Pdf Manuals
Related Search