KM 85/50 W Comfort KM 85/50 W Classic KM 85/50 WP Comfort KM
Contents
1. Side sealing strips gt Loosen the fastening of the sealing strip gt Replace sealing strip gt To adjust clearance to floor push a 1 2 mm thick spacer under it gt Align the sealing strip gt Tighten the fastenings of the sealing strip Replace the dust filter A Danger gt Empty and remove debris container prior to starting to replace the dust filter gt Wear a dust protection mask when working on the filter system gt Observe the safety precautions for handling fine dust gt Lock the hand brake mowia me A gt Remove safety cotter pin of the shaker rod gt Pull out rod gt Loosen fastening screws gt Remove frame gt Replace the dust filter Note Make sure when mounting the new filter that the lamella are not damaged 30 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Accessories Side brush 6 905 626 Provided with standard bristles for indoor and outdoor surfaces Soft side broom 6 906 132 For fine dust on indoor surfaces resistant to moisture Hard side broom 6 905 625 For removing stubborn external dirt damp proof profi main brush 6 906 508 KM 85 50 W Comfort and KM 85 50 W P Comfort For professional applications especially wear resistant Standard main brush 6 906 509 KM 85 50 W Classic and KM 85 50 WP Classic Wearproof and wetproof Universal bristles fo2. gt Lock push handle Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Fastening areas 1 over the push handle 2 beneath the unit s cover Note Observe markings for fastening areas on base frame chain symbols Elapsed time meter Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Elapsed time meter indicates maintenance interval times Maintenance by the customer Daily maintenance gt Check roller and side brush for wear and trapped straps gt Check the function of all operating controls Maintenance every 50 operating hours gt Check tension wear and operation of traction belts and drive chain gt Check freedom of movement of Bowden cables and moving parts gt Check sealing strips at dust filter and operation of filter shaker gt Check setting and wear of sealing strips in sweeping area gt Check sweeping pattern and operation of main brush and side brush gt Clean and check dust filter replace if necessary gt Check roller and side brush for wear and trapped straps gt Check operation of all operating devices and indicator lights Note Where maintenance is undertaken by the customer all service and maintenance work must be carried out by a qualified employee A Karcher specialist dealer can be consulted whenever support is necessary Maintenance by the customer service department Comply with service manual Maintenance after the fir
3. observed The operator must use the unit in accordance with its intended purpose She must adapt her mode of operation to the local conditions and when working with the appliance keep a look out for third parties especially children The unit can reverse and drive forwards at the same speed Therefore take care when pulling back push handle for reversing Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort The appliance may only be used by persons instructed in its handling or who have proved their capability of operating it and who are expressely authorized to use it The unit must not be operated by children and youths gt To prevent unauthorized utilization of appliances provided with an ignition key the ignition key must be removed gt The appliance must never be left unattended as long as the motor is running It is not permitted for the operator to leave the unit unless the engine is turned off the unit is secured against inadvertent movement and if applicable the parking brake is applied and the ignition key is removed On slopes the angle of inclination to the side and in the direction of motion must not exceed the value given in the operating instructions Transport gt The motor must be turned off when the appliance is transported gt To lock the parking brake gt Secure the machine with guy belts ropes or chains gt Immobilise the machine at the wheels wi
4. 2 1 351 112 0 1 351 112 0 6 435 697 0 7 343 029 0 T T 1 351 101 0 1 351 101 0 303 026 0 1 351 111 0 1 351 111 0 11 2002 1 2 YIKARCHER KM 85 50 W 6 654 141 0 1 351 112 0 ZA 6 654 140 0 1 351 112 0 a 1 351 101 0 6 654 048 0 1 251 111 0 1 351 101 0 6 654 067 0 4351141 0 5 731 585 0 11 2002 2 2 351
5. batteries is permitted only after instruction by trained personnel Observe the safety instructions of the battery manufacturer Warranty is valid only when using the batteries and charging units stipulated by Karcher A Danger Danger of burns gt Allow the machine to adequately cool down prior to all maintenance and repair work gt Do not touch hot parts such as the driving engine A Danger gt Wear safety goggles and protective clothing gt Observe regulations for the prevention of accidents as well as DIN VDE 0510 VDE 0105 T 1 A Danger Risk of fire and explosion Smoking prohibited No naked flames glowing embers or sparks in the vicinity of batteries Do not place any objects or tools on the battery because voltage is always present between the battery poles Areas in which batteries are charged must be well ventilated as highly explosive gas forms during charging Corrosive burn hazard with wet batteries gt Rinse splashes of acid from eyes or off the skin generously with clean water gt Then consult a doctor immediately gt Wash contaminated clothing with water SN Old batteries with this symbol are reusable commodities and must therefore be returned for recycling gt Used batteries not appropriately recycled must be disposed of as hazardous waste in compliance with all regulations Install battery KM 85 50 W Comfort and KM 85 50 W Classic
6. KARCHER KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic 1 351 102 0 1 351 101 0 1 351 112 0 1 351 111 0 ATi www kaercher com 5 960 502 A2007053 03 04 KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic Betriebsanleitung 3 Ersatzteilliste 351 Operating Instructions 18 Spare Parts List 351 Notice d utilisation 33 Liste des pi ces de rechange 351 Istruzioni per l uso 49 Elenco pezzi di ricambio 351 Gebruiksaanwijzing 65 Reserveonderdelenlijst 351 Instrucciones de servicio 80 Lista de piezas de requesto 351 Manual de instru es 95 Lista de pecas sobresselentes 351 Odnyies AEiToupyiac 110 AVTOAAQKTIKO 351 Driftsvejledning 127 Reservedelsliste 351 Bruksveiledning 141 Reservedels liste 351 Driftinstruktion 155 Reservdelslista 351 K ytt ohje 169 Varaosalista 351 zemeltet si utas t s 183 Cserealkatr szlista 351 N vod k obsluze 198 Seznam n hradn ch d l 351 Navodilo za upravljanje 213 Seznam nadomestnih delov 351 Instrukcja obs ugi 227 Lista cz ci zamiennych 351 Instructiunile de folosire 244 List de piese de schimb 351 letme k lavuzu 259 Yedek par a listesi 351 Cihaz n kullan m 10 y ld r PyKOBO CTBO No 3KCNIIyYaTALIMM 274 SanacHble yacTu 351 N vod k prev dzke 290 Zoznam n hradnych dielov 351 Upute za upotrebu 305 Popis rezervnih dijelova 351 Uputstvo za rukovanje 320 Sp
7. Note See accessories for recommended battery and battery charger A Warning To prevent damage to the bowden cable release it from the retaining plate gt Secure the battery 1 with a battery clamping band Reconnect bowden cable to retaining plate and adjust it if gt Pull the pin out of fork head 7 and lever 8 gt Take out pin from fork head 7 necessary gt Unscrew locking nut 6 gt Hinge adjusting nut 1 in gt Demount adjusting nut 1 from retaining plate 4 retaining plate 4 gt Tighten locking nut 6 using flat washers 3 and 5 to locking nut 2 gt Position fork head 7 to lever 8 gt Push pin through fork head 7 and lever 8 and secure it gt Place the battery 1 on the engine cradle 25 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Charge the battery KM 85 50 W Comfort gt Switch the machine off A Danger gt Always heed safety precautions for handling batteries gt Insert battery 2 into the battery gt Screw negative post wire of container battery 2 to positive post of gt Strictly comply with the operating battery 1 instructions of the battery Note charger s manufacturer When using batteries with a liquid electrolyte coat the battery terminals adequately with terminal grease to protect them from corrosion gt Screw negative post wire to batt
8. P Classic it is on the reverse of the instrument panel Master switch with key Raise lower side brushes Operating hour counter Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Raising lowering main brush Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort 20 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Master switch with key 1 0 setting engine OFF 2 Position I engine ON Battery charger s indicator LED 1 green Battery is charged 2 yellow Remaining operating time approx 5 10 min 3 red Machine is switched off gt Battery must be recharged Before first operating Unloading instructions The machine was secured on a pallet with stretch belts or ropes for safe transport Proceed as follows when unloading gt Cut the plastic packing tape and remove the film gt Knock away the blocks securing the wheels and lift off the machine from the pallet A Warning Do not use a fork lifter for unloading the machine can be damaged by it Side broom installation A Warning gt Remove the debris container prior to tilting the sweeper see the section on Emptying the debris container For KM 85 50 W Comfort and KM 85 50 W P Comfort it is additionally necessary to release the push handle lock gt Tilt the machine back _ ABE gt Push side bru
9. and KM 85 50 W P Comfort Danger The unit can reverse and drive forwards at the same speed Therefore take care when pulling back push handle for reversing gt Turn push handle lock anticlockwise the lock is released Press push handle forward drive forward Pull push handle back reverse KM 85 50 W Classic and KM 85 50 W P Classic Press push handle forward drive forward Usage instructions Safety instructions when sweeping A Warning Never sweep up packing straps wires or the like as this could damage the sweeping mechanism A Danger When the coarse dirt flap is open the main brush can hurl stones or stone chips forwards Make sure that nobody no animals or objects are endangered Note The coarse dirt flap must be briefly raised for sweeping up largish objects up to a height of 50 mm for example drinks cans Sweeping dry ground gt For optimum cleaning effect match the driving speed to suit the actual conditions gt Regularly clean down the filter and empty the swept material container during operation Sweeping damp or wet ground Lifted coarse dirt flap gt Open latch of debris container leave latch engaged Debris container is raised approx 8 cm Note The dust filter is protected from moisture gt Let down the coarse dirt flap Note An optimal cleaning effect can be achieved only when the coarse dirt flap is completely lowere
10. battery in a run down condition but recharge it as soon as possible gt Keep the batteries always clean and dry to prevent leaking currents Protect it from contamination for example by metallic dust gt Do not place tools or similar objects on the battery Hazard of short circuits and explosion gt Do not under any circumstances work with an open flame create sparks or smoke near a battery or in a battery recharging room Explosion hazard gt Do not touch hot parts for example the driving engine hazard of burns gt Take care when handling accumulator acid Heed the relevant safety regulations gt Used batteries are to be disposed of in an environmentally friendly way according to EC guideline 91 157 EWG 19 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Risk of overturning on too high gradients A Danger The machine could topple over when driving and turning on slopes KM 85 50 W Comfort and KM 85 50 W P Comfort Drive only on slopes up to 15 in the travelling direction Drive only on slopes up to 15 transverse to the travelling direction KM 85 50 W Classic and KM 85 50 W P Classic Drive only on slopes up to 2 in the travelling direction Drive only on slopes up to 2 transverse to the travelling direction For our environment Caution danger to the environment from used ba
11. d 22 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Driving over obstacles Empty the swept material container gt De dust the filter first before opening emptying the debris container See chapter on de dusting filter Fixed obstacles of up to 30 mm in height gt Slowly and carefully drive over them in the forward direction Fixed obstacles over 30 mm in height gt Drive the unit over a ramp gt Raise the sweep roller gt Lock the hand brake gt Pull out debris container Applies only to gt Empty the swept material KM 85 50 W Comfort and container Stop machine KM 85 50 W P Comfort gt Push in the swept material s container A Clean filter gt Engage latch at debris container Warning gt Close latch Applies only to KM 85 50 W Comfort and Note KM 85 50 W P Comfort For shut off the side brushes and the main brush must always be raised deformation hazard of main brush or side brushes The debris container is provided with transport rollers Cleaning and maintenance gt gt Stand sweeper on a flat surface gt Turn master switch Warning gt Move the handle of the filter gt Release latch gt Lock the hand brake counterclockwise to position 0 Applies only to KM 85 50 W Classic clean down device to and fro gt Turn the key beyond its 0 and KM 85 50 W P Classic several times z position and withdraw i
12. ed KM 85 50 W Classic and KM 85 50 W P Classic When working on downward slopes the permitted gradient is a maximum of 2 Use gt Prior to utilization the appliance and its working facilities must be checked regarding their proper condition and that they operate safely It must not be used if its condition is not faultless No modifications permitted on the machine Never absorb explosive liquids inflammable gases or undiluted acids and solvents This includes petrol paint thinner or fuel oil which can form explosive fumes due to the swirling suction air in addition acetone undiluted acids and solvents since they corrode the materials used for the appliance Do not sweep up absorb burning or smouldering objects Only if expressely marked is this appliance suitable for sucking up health hazardous dusts Comply with notices concerning safety regulations given in the operating instructions Suitable only for the surfaces listed in the operating instructions The appliance may be used on only the areas cleared for its use by the factory owner or a person authorized by him Keep clear of the danger area Its operation in explosion hazardous locations is prohibited The following applies generally Keep highly inflammable materials away from the machine explosion fire hazard Operation The rules regulations and stipulations applying to motor vehicles must always be
13. ening screws gt Remove main brush downwards gt Pay attention to the position of the bristle set when installing the new main brush Note The bristle pile is structured to an arrow which must point towards the rear wheels gt Insert new main brush and fasten AUN ays l M Z J PA Make sure that the position of the rectangular clamping plate is proper It must overlap the main brush at the top and bottom gt Insert the swept material container Checking and adjusting sweeping area of the sweeping roller gt Cover a level surface evenly with dust gt Raise the sweeping machine on the front and put it on the prepared surface gt Lock the hand brake gt Run the main brush for approx 15 30 s gt Raise the sweeping machine on the front and move it to the side The form of the sweeping pattern forms a regular rectangle that is between 30 40 mm wide Note If the sweeping pattern is uneven it can be corrected by readjusting the sweeping pattern width 28 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Setting the sweeping pattern width for KM 85 50 W Comfort and KM 85 50 W P Comfort Note The bowden cable must be readjusted if the sweeping pattern is insufficient and the bowden cable is tight when the main brush is in its lowered position gt Set sweeping pattern at the b
14. ery 1 gt Lift off cap of battery s charging socket gt Connect charger s charging plug gt Plug in power plug and if necessary switch on battery charger gt Screw positive post wire to battery 2 KM 85 50 W P Comfort gt Remove the master switch key gt Insert key in lock of unit cover shutting with the cover support during work on the unit gt Turn key by 180 gt Open unit cover gt Plug in power plug of the integrated battery charger into the plug socket 26 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 WP Classic English KM 85 50 W Classic and F KM 85 50 W Classic and State of battery charge indicator KM 85 50 WP Classic uses KM 85 50 W P Classic gt Switch the machine off A Danger gt Always heed safety precautions for handling batteries gt Strictly comply with the operating instructions of the battery charger s manufacturer KM 85 50 W Comfort and KM 85 50 W P Comfort gt Safeguard the unit cover from Load circuit F1 fuse Yellow shutting with the cover support Fuse 60 A Battery is charging during work on the unit Reset the safety cutout Control circuit F2 fuse Green Fuse 3 A Battery is charged Flashing yellow Fault gt Notify the K rcher service station When finished gt Lock the unit s cover with the master switch key gt Remove the master switch key gt Insert key in l
15. fuse 28 Check the sweep roller 28 Replace the sweep roller 28 Checking and adjusting sweeping area of the sweeping roller 28 Replacing the side broom 29 Adjusting lowering of side brush 29 Adjusting raising of coarse dirt flap 29 Adjusting and replacing sealing strips 29 Replace the dust filter 30 Accessories Fault instructions Technical data Unit data Engine Filter and suction system Unit vibrations ISO 5349 Ambient conditions EC conformity declaration 31 31 31 31 31 31 32 32 32 18 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English For your own safety General notes It is mandatory to read and observe this prior to using the appliance Notify your sales outlet if during unpacking you detect damage that has occurred in transit gt Read the operating instructions of your appliance prior to putting it into operation especially the safety information The danger and caution signs attached to the appliance give important tips on its safe operation In addition to the instructions in the operating instructions general safety and accident prevention regulations from lawgivers must be followed KM 85 50 W Comfort and KM 85 50 W P Comfort To increase your safety for work on slopes with a gradient of more than 2 the accessory kit ABS Additional Brake 2 640 301 0 n must be install
16. hen the sweeping effect diminishes due to wear of the sealing strips they must be readjusted or replaced gt Unlock push handle lock by turning it anticlockwise gt Remove the debris container prior to tilting the sweeper see the section on Emptying the debris container For KM 85 50 W Comfort and KM 85 50 W P Comfort it is additionally necessary to release the push handle lock gt Tilt the machine back Front sealing strip gt Loosen the fastening screws of the sealing strip 29 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English gt Readjust the sealing strip downwards by relocating it in the elongated hole gt Tighten the fastening screws of the sealing strip gt Set the vacuum sweeper upright and push it slightly forwards 10 15 mm The clearance of the front sealing strip to the floor must be set so that its whole width folds back with a lag of 10 15 mm gt Repeat the adjustment as required Note The sealing strip must be replaced if due to being too worn the clearance of the front sealing strip to the floor can no longer be adjusted gt Unscrew the fastening screws and replace the whole sealing strip Rear sealing strip gt Remove the swept material container gt Undo screws of sealing strip at the debris container gt Replace sealing strip gt Tighten screws of sealing strip
17. in brush box Poor sweeping around the edges gt Readjust lowering of the side brush gt Replacing the side broom gt Notify the K rcher service station Raising the side brush does not function gt Check the Bowden cable of the raising mechanism gt Notify the K rcher service station Yellow LED of battery charger flashes Applies only to KM 85 50 W P Comfort and KM 85 50 W P Classic gt see battery charger s operating instructions gt Notify the K rcher service station Technical data Unit data Length x width x height 1355 x 910 x 1155 mm Weight 1 351 101 102 115 kg 1 351 111 175 kg 1 351 112 195 kg Sweeping speed 4 5 km h KM 85 50 W Comfort and KM 85 50 W P Comfort Climbing capacity max 15 with the additional brake 2 640 301 0 approved up to a max of 2 without the additional brake KM 85 50 W Classic and KM 85 50 W P Classic Climbing ability limited to max 2 Main brush diameter 250 mm Side brush diameter 410 mm Area performance 3825 m h Maximum operating time per battery charge 2 7 h Working width without side brush 610 mm Working width with side brush 850 mm Debris container volume 50 litres Degree of protection IPX 3 drip proof Engine Type Permanent magnet d c motor Voltage 24V Rated speed 2600 1 min Rated power 750 W Battery capacity 1 351 111 2 x 12 V 80 Ah low maintenance 1 351 112 2 x 12 V 100 Ah low main
18. isak rezervnih d 351 MHCTpykuMa 3a paOoTa 335 Cnucbk Ha pe3epBHu UacTu 351 2 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Contents For your own safety General notes Risk of overturning on too high gradients For our environment Caution danger to the environment from used batteries Intended use Function description sweeping machine Machine components Before first operating Unloading instructions Side broom installation Before every operation General notes Testing and maintenance work Commissioning Start machine Sweeping operation Run machine 19 19 20 20 20 20 20 20 21 21 21 21 21 21 21 21 22 22 Usage instructions Safety instructions when sweeping Sweeping dry ground Sweeping damp or wet ground Driving over obstacles Stop machine Clean filter Empty the swept material container Cleaning and maintenance Internal cleaning External cleaning Decommissioning Transport Transport instructions Maintenance intervals Elapsed time meter Maintenance by the customer Maintenance by the customer service department 22 22 22 22 23 23 23 23 23 23 23 24 24 24 24 24 24 24 Maintenance tasks 24 Preparations 24 Open close unit cover 24 Safety notes 25 Install battery 25 Charge the battery 26 Fuses 27 Reset the safety cutout 27 Replacing the
19. ock of unit cover gt Plug in power plug and if necessary switch on battery charger When finished gt Lock the unit s cover with the master switch key gt Turn key by 180 Load circuit F1 fuse gt Open unit cover Automatic cutout 50 A Control circuit F2 fuse Fuse 3 A 27 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Replacing the fuse gt Remove cover using a screwdriver gt Replacing the fuse gt Replace cover Note The automatic cutout must be depressed Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Check the sweep roller gt Lock the hand brake gt Remove the swept material container gt Remove tapes and string from the sweep roller gt Insert the swept material container Replace the sweep roller Replacement is necessary when the main brush cannot be readjusted any more and sweeping efficiency obviously deteriorates due to worn bristles gt Release push handle lock by turning it counterclockwise Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort A Danger gt Remove the debris container prior to tilting the sweeper see the section on Emptying the debris container For KM 85 50 W Comfort and KM 85 50 W P Comfort it is additionally necessary to release the push handle lock gt Tilt the machine back gt Unscrew the left and right fast
20. owden cable gt Check the sweep mirror again Setting the sweeping pattern width for KM 85 50 W Classic and KM 85 50 W P Classic gt Turn the rotary knob 1 Turning it counterclockwise the sweeping pattern is increased Turning it clockwise the sweeping pattern is reduced gt Check the sweep mirror again Replacing the side broom Replacing it is necessary when the sweeping effect visibly deteriorates due to wear of the bristles gt Unlock push handle lock by turning it anticlockwise gt Remove the debris container prior to tilting the sweeper see the section on Emptying the debris container For KM 85 50 W Comfort and KM 85 50 W P Comfort it is additionally necessary to release the push handle lock gt Tilt the machine back underside of the side brush gt Take off the side broom gt Slide new side brush onto shaft gt Fasten with screws 3 pieces gt Tilt the machine back upright Adjusting lowering of side brush Readjustment is necessary when the sweeping efficiency of the side brush deteriorates due to worn bristles gt Unscrew the locking nut gt Readjust the setscrew gt Tighten the locking nut Adjusting raising of coarse dirt flap Readjustment is necessary when it is not posible to sufficiently raise or lower the coarse dirt flap gt Unscrew locking nut gt Readjust the setscrew gt Tighten locking nuts Adjusting and replacing sealing strips W
21. r indoor and outdoor cleaning Dust filter 5 731 585 Wetproof washable Filter efficiency gt 99 9 corresponds to category C of ZH 1 487 of BIA Battery recommended KM 85 50 W P Comfort 6 654 141 100 Ah maintenance free KM 85 50 W Comfort 6 654 093 75 Ah maintenance free KM 85 50 W Classic and KM 85 50 W P Classic 80Ah low maintenance 6 654 048 Battery charger KM 85 50 W P Comfort 24 V 6 654 140 KM 85 50 W Comfort 24 V 6 654 102 KM 85 50 W P Classic 24 V 6 654 067 Fault instructions Machine will not start gt Charge the battery gt Check fuses if necessary depress automatic cutout or replace affected fuse gt Notify the Karcher service station Motor running but machine not moving gt Check belts and chain gt Release push handle lock Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort gt Notify the Karcher service station Machine remains stationary on inclines gt Select flatter route gt Notify the K rcher service station Machine not sweeping properly gt Check the main brush and the side brushes gt Check belt for tension and operation replace if necessary gt Re adjust main brush gt Replace the sweep roller gt Notify the K rcher service station Machine making dust gt De dust or replace the dust filter gt Empty debris container gt Adjust or replace the sealing strip gt Replace seal at debris container and ma
22. sh onto shaft gt Fasten with screws 3 pieces gt Tilt the machine back upright Before every operation Commissioning Note Initial operation permissible only General notes if the unit s cover is closed gt Stand sweeper on a flat surface gt Shut off the engine gt Set parking brakes on the front of the swivel caster gt Turn the push handle lock clockwise The lock is engaged Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Start machine Testing and maintenance work gt Check battery charge status at the battery charger indicator Check the side brush Check the sweep roller Clean filter Empty the swept material container See chapter on maintenance gt Release parking brake work See chapter on shutting off the machine To lock push handle idling Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort gt Turn push handle lock clockwise lock is interlocked The unit can be moved manually 21 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English gt Turn master switch clockwise to position I Note The sweep roller and side broom rotate Sweeping operation Lower side brush gt Release lever lock Lower main brush Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort gt Release lever lock Run machine KM 85 50 W Comfort
23. st month or 5 operating hours First inspection Maintenance every 50 operating hours Maintenance every 100 operating hours or half yearly Maintenance every 500 hours or yearly Note To safeguard warranty rights during the warranty period all service and maintenance work must be performed by an authorised Karcher after sales service Maintenance tasks Preparations gt Stand sweeper on a flat surface gt Lock the hand brake gt Lock push handle Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Open close unit cover Note The unit cover is lockable and can be opened and locked only with the master switch key The key cannot be removed unless the unit cover is properly locked gt Remove the master switch key gt Insert key in lock of the unit cover 24 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English gt Turn key by 180 gt Open unit cover gt Safeguard the unit cover from shutting with the cover support during work on the unit When finished gt Lock the unit s cover with the master switch key Safety notes A Danger The engine takes approx 3 4 s to run down after being shut off It is imperative to keep away from the area of the drive unit during this period Note Comply with the operating instructions of the battery charger s manufacturer Work on
24. t For parking the side brush must Internal cleaning always be raised otherwise danger A of distorting it Danger Wear dust mask Wear safety goggles gt Blow out with compressed air gt Clean with a rag External cleaning Clean with a moist rag gt Raise the side broom gt Unhinge latch Note Do not use aggresive cleaning agents 23 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Decommissioning Transport Maintenance intervals Please observe the following points when the machine will not be used for a lengthy period Ne aeea Garage the machine in a sheltered and dry storage place Stand sweeper on a flat surface Remove the master switch key Lock the hand brake Safeguard the sweeping machine from rolling away Lock push handle Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort VVVV v vN Raise main brush Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort gt Raise the side broom ve Clean inside and outside of sweeper Disconnect the batteries Recharge the battery at intervals of approx 2 months VYR Transport instructions A Warning When it is transported the machine must be secured against dislocation gt Lock the hand brake gt Disconnect the batteries gt Secure the machine with stretch belts or ropes gt Secure the machine with wedges on the wheels
25. tenance Filter and suction system Dust filter filtering surface 2 3 m 31 Operating Instructions KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 W P Classic English Filter application category for non health hazardous dusts L Nominal vacuum intake system 4 mbar Intake system nominal volumetric flow 45 l s Unit vibrations ISO 5349 Upper limbs 0 4 m s Ambient conditions Temperature 5 40 C Air humidity non dew developing 0 90 Noise emission Sound pressure level EN 60704 1 66 dB A Guaranteed sound power level level 2000 14 EU 83 dB A EC conformity declaration We hereby declare that the machine specified below as the marketed desigh the machine specified below complies with the relevant fundamental safety and health requirements of the EC directives listed below Modification of the machine without our approval invalidates this declaration Product Sweeper Type 1 351 xxx Relevant EC directives EC machine directive 98 37 EC EC directive on electromagnetic compatability 89 336 EEC amended by 91 263 EEC 92 31 EEC 93 68 EEC EC guideline on noise emissions 2000 14 EU Applied harmonised standards DIN EN 60 335 1 DIN EN 60 335 2 29 DIN EN 60 335 2 72 DIN EN 55 014 1 2000 A1 2001 DIN EN 55 014 2 1997 DIN EN 61 000 3 2 2000 DIN EN 61 000 3 3 1995 A1 2001 Applied na
26. th chocks Maintenance Repairs may only be carried out by approved customer service centres or by technical personnel trained in this field which are familiar with all relevant safety regulations Industrially used appliances in changing locations are subject to the safety inspection according to VDE 0701 The battery plug and the battery itself of battery powered units must be disconnected for work on the electrical installation Prior to cleaning and performing maintenance on the unit or replacing parts or resetting it to another operation the unit is to be switched off and if applicable the ignition key removed Unless expressly permitted the unit may not be cleaned with hose or high pressure water jets Danger of short circuits or other impairments Accessories and spare parts Only accessories and spare parts cleared by the manufacturer may be used Genuine accessories and spare parts guarantee that the unit can be operated safely and trouble free Use only the brushes provided with the delivered unit or those specified in the operating instructions Using other brushes can impair safety Battery driven appliances Warranty is valid only when you use the batteries and charging units recommended by Karcher gt It is mandatory to comply with the battery manufacturer s operating instructions Heed the legislative recommendations on handling of batteries gt Never leave a
27. tional standards Applied conformity valuation method Appendix V Measured sound pressure level 82 dB A Guaranteed sound pressure level 83 dB A Internal measures ensure that the in series produced units always comply with the requirements of current EC directives and applied standards The signatories act for and in authority of management 5 957 709 08 02 Alfred Karcher Limited Partnership Registered office Winnenden Registration court Waiblingen HRA 169 Personally liable partner Karcher Reinigungstechnik GmbH Registered office Winnenden 2404 Waiblingen Company Register HRB Managing directors Dr Bernhard Graf Hartmut Jenner Georg Metz Alfred Karcher GmbH 8 Co KG Cleaning Systems Alfred Karcher Strasse 28 40 P O Box 160 D 71349 Winnenden Phone 49 7195 14 0 Fax 49 7195 14 2212 se Bios Reiser Jenner 32 KM 85 50 W Comfort KM 85 50 W Classic KM 85 50 W P Comfort KM 85 50 WP Classic YIKARCHER KM 05 50 W 1 351 102 0 1 351 102 0 1 351 112 1 351 112 0 E 1 351 101 0 5 440 157 0 1 351 111 0 5 440 156 0 5 321 606 0 Y 1 351 102 0 1 351 112 0 1 351 101 0 i 6 431 228 0 1 i 6 634 201 0 p 7 307 512 0 Tey 4036 6 431 211 0 4 351 112 0 5 321 115 0 7 306 145 0 IB 5 515 068 0 1 351 102 0 1 351 112 0 i 6 435 222 0 7 343 007 0 i T T 7 306 041 0 1 351 102 0 1 351 102 0 a
28. tteries SN Do not dispose of exhausted batteries as ordinary household garbage Ensure environmentally compatible disposal Intended use Function description sweeping machine Machine components This sweeper is intended for sweeping inside and outside surfaces t complies with the L application category for non health hazardous dusts It is not intended for use on public traffic routes Suitable surfacings Asphalt Industrial floor Screed Concrete The KM 85 50 W and the KM 85 50 W P operate according to the throw over principle The side brush 3 cleans corners and edges of the sweeping surface and transports the dirt in the path of the main brush The rotating main brush 4 transports the dirt directly into the debris container 5 The dust swirled up in the container is separated by way of the dust filter 1 and the filtered clean air removed by the suction turbine 2 NOO BWND co Push handle Lever for coarse dirt flap Unit cover Unit cover s lock Swivel caster with parking brake Side brush Debris container with transport rollers Filter shaker for the dust filter Push handle lock Applies only to KM 85 50 W Comfort and KM 85 50 W P Comfort Na RW Battery charger s indicator LED Battery charge plug Does not apply to KM 85 50 W P Comfort for KM 85 50 W Classic and KM 85 50 W
Download Pdf Manuals
Related Search