Version 13.0 - February 2007 - Ride-On
Contents
1. Configured for your needs The optional Took Kit is available with our 5 gallon or 55 gallon drum Hand Pumps HP 100 Motorcycle Hand Pump with motorcycle chuck HP 200 5 Gallon pail Hand Pump HP 300 5 Gallon pail Hand Pump and Tool Kit HP 400 55 Gallon drum Hand Pump and Tool 500 55 Gallon drum Hand Pump HP 400 55 Gallon Drum Hand Pump amp Tool Kit Optional Tool Kit Installation Using 5 Gallon Pail Metered Hand Pump 1 Pull up and remove the clear plastic tab from the large opening on the top of the pail 2 Unscrew the black cap on the pail lid It has recessed tabs on the sides of the cap that can be raised to aid in removal Version 13 0 February 2007 Dosage Table Introduction IV 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual 3 Pull and remove the inner seal from the plastic tube 4 Remove the cap from the small valve fitting on the side of the pail This fitting is used to re circulate Ride On 5 Attach the quick connect chuck at the end of the pump hose onto the valve fitting located on the side of the pail just below the lid 6 Push the body of the pump into the opening all the way down to the bottom of the pail DO NOT cut the sleeve Pull the pump handle all the way up as high as it will go and then push it back down This will bleed the air out of the hose as the product is circulated b2. 360 70 24 380 70 24 420 70 24 440 65 24 445 70 24 480 65 24 495 70 24 540 65 24 48X20 00 24 11 24 5 12 24 5 13 5 24 5 275 80 24 5 285 75 24 5 305 75 24 5 Copyright 1995 2007 Inovex Industries Inc Formula CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS CHS CHS CHS Regular oz Units 34 36 41 28 31 36 40 44 53 26 166 153 Severe oz Units 43 45 51 36 83 77 108 61 132 66 152 114 138 164 134 192 81 152 216 174 110 231 209 236 239 279 315 111 128 128 152 165 182 182 209 206 242 249 230 Page 14 www ride on com Ride On Tire Protection System TPS Dosage Table Formula No 796 797 798 799 800 801 802 803 804 805 806 807 808 809 810 811 812 813 814 815 816 817 818 819 820 821 822 823 824 825 826 827 828 829 830 831 832 833 834 835 836 837 838 839 840 841 842 843 844 845 846 847 848 849 850 851 852 Version 13 0 February 2007 Tire Size Designation 11 00 25 12 00 25 13 00 25 14 00 25 15 50 25 16 00 25 17 50 25 18 00 25 20 50 25 21 00 25 23 50 25 24 00 25 26 50 25 29 50 25 25 65 25 30 65 25 355 55
3. CHS CHS CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS Regular oz Units 64 64 44 19 22 24 69 77 Severe oz Units Page 7 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 399 400 401 402 403 404 405 406 407 408 409 410 411 412 413 414 415 416 417 418 419 420 421 422 423 424 425 426 427 428 429 430 431 432 433 434 435 436 437 438 439 440 441 442 443 444 445 446 447 448 449 450 451 452 453 454 455 Version 13 0 February 2007 Designation 235 60 15 245 60 15 255 60 15 265 60 15 275 60 15 390 60 15 325 60 15 LT 195 55 15 205 55 15 225 55 15 255 55 15 195 50 15 205 50 15 225 50 15 245 50 15 265 50 15 275 50 15 295 50 15 305 50 15 325 50 15 4 50 16 5 50 16 6 00 16 6 50 16 6 50 16 LT 7 00 16 7 00 16 7 2 16 7 50 8 00 16 7 50 16 7 50 16 LT 8 00 16 8 3 16 9 00 16 9 5 16 10 00 16 11 00 16 11 2 16 12L 16 12 4 16 12 5L 16 13 6 16 325 85 16 215 85 16 235 85 16 255 85 16 155 80 16 325 80 16 LT 80 75 16 225 75 16 235 75 16 245 75 16 265 75 16 285 75 16 315 75 16 LT 235 70 16 Copyright 1995 2007 Inovex Industries Inc Formula CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CH
4. HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR Regular oz Units 150 142 162 259 288 340 187 199 231 278 324 393 451 541 642 79 97 112 129 127 78 93 101 116 131 149 150 176 199 235 117 150 261 279 341 213 247 275 576 686 676 686 682 60 82 86 124 211 248 128 254 Severe oz Units 225 213 243 389 432 510 281 299 347 417 486 590 677 812 963 119 146 168 194 191 117 140 152 174 197 224 225 264 299 353 176 225 392 419 512 320 371 413 864 1029 1014 1029 1023 90 123 129 186 317 372 192 381 Page 17 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size Formula Regular Severe Designation oz Units oz Units 620 70 42 710 70 42 650 65 42 900 50 42 45 65 45 12 4 46 13 6 46 14 9 46 18 4 46 320 90 46 380 90 46 520 85 46 420 80 46 480 80 46 270 95 48 230 95 48 18 00 49 21 00 49 24 00 49 27 00 49 320 90 50 480 80 50 30 00 51 33 00 51 36 00 51 37 50 51 50 65 51 270 95 54 320 90 54 27 56 5 30 56 5 37 00 57 40 00 57 46 90 57 48 95 57 50 90 57 33 59 5 36 59 5 39 59 5 55 80R63 Page
5. HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS CHS HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS Regular oz Units 43 19 21 22 88 81 97 97 126 104 118 127 150 112 Severe oz Units 60 24 26 132 122 146 146 189 156 177 191 225 168 Page 9 www ride on com Ride On Tire Protection System TPS Dosage Table Formula No 512 513 514 515 516 517 518 519 520 521 522 523 524 525 526 527 528 529 530 531 532 533 534 535 536 537 538 539 540 541 542 543 544 545 546 547 548 549 550 551 552 553 554 555 556 557 558 559 560 561 562 563 564 565 566 567 568 Version 13 0 February 2007 Tire Size Designation 235 80 17 LT 245 75 17 LT 235 70 17 245 70 17 LT 265 70 17 285 70 17 315 70 17 LT 275 65 17 LT 265 65 17 LT 255 65 17 LT 245 65 17 LT 235 65 17 215 65 17 305 60 17 LT 285 60 17 275 60 17 205 50 17 255 50 17 225 55 17 235 55 17 215 45 17 225 45 17 235 45 17 245 45 17 255 45 17 315 45 17 235 40 17 245 40 17 265 40 17 275 40 17 285 40 17 285 35 17 315 35 17 335 35 17 35x12 50x17 LT 37x12 50x17 LT 37x12 50x17 215 75 17 5 LT 235 75 17 5 TR 245 70 17 5 TR 355 70 17 5 8 17 5 HC 8 5 17 5 9 17 5 HC 9 5 17 5 10 17 5 HC 11 17 5 HC 14 17 5 HC 14 17 5 36X16 17 5 4 00 18 7 50 18 7 50 18 10 5 80 18 Copyright 1995 2007 Inovex Industries Inc CHS CHS C
6. metabolites from the body 5 FIRE FIGHTING MEASURES Flash Point None to Boil gt 550 F Hazardous Products of Combustion May form carbon dioxide and carbon monoxide Extinguishing Media Water fog alcohol foam carbon dioxide dry chemical Material Safety Data Sheet MSDS Inovex Industries Inc Page 3 5 Date Prepared 03 03 2003 Date Printed 2 10 2006 MSDS No 022703 001 001 RIDE ON TIRE PROTECTION SYSTEM TPS TIRE SEALANT Fire Fighting Instructions Wear a self contained breathing apparatus with full face piece operated in the positive pressure demand mode with appropriate turn out gear and chemical resistant personal protective equipment Refer to the personal protective equipment section of this MSDS No special precautions necessary when fighting fires involving this product NFPA Rating Health 1 Flammability 1 Reactivity 0 6 ACCIDENTAL RELEASE MEASURES Small Spills Absorb liquid on vermiculite floor absorbent or other absorbent material Collect material with vacuum cleaner Large Spills Persons not wearing protective equipment should be excluded from area of spill until clean up has been completed Stop spill at source dike area of spill to prevent spreading pump liquid to salvage tank Remaining liquid may be taken up on sand clay earth floor absorbent or other absorbent material and shoveled into containers 7 Handling and Storage Handling and Storage Keep container closed when not in
7. 17 MOT CHS 6 9 1107 M130 70 17 MOT CHS 6 9 1108 M140 70 17 MOT CHS 7 10 1109 M150 70 17 MOT CHS 8 11 1110 M160 70 17 MOT CHS 9 12 1111 M110 80 17 MOT CHS 5 8 1112 120 80 17 MOT CHS 6 9 1113 M130 80 17 MOT CHS 7 10 1114 M140 80 17 MOT CHS 8 11 1115 M150 80 17 MOT CHS 9 12 1116 M90 90 17 MOT CHS 4 6 1117 M120 90 17 MOT CHS 7 10 1118 M130 90 17 MOT CHS 7 10 1119 MS90 17 MOT CHS 7 9 1120 MT90 17 MOT CHS 7 10 1121 1122 3 00 18 MOT CHS 4 6 1123 3 50 18 MOT CHS 5 7 1124 4 00 18 MOT CHS 6 9 1125 4 10 18 MOT CHS 6 8 1126 4 25 18 MOT CHS 6 9 1127 4 50 18 MOT CHS 7 10 1128 4 60 18 MOT CHS 7 10 1129 M330 35 18 MOT CHS 18 27 1130 M300 35 R18 MOT CHS 16 23 Page 20 Version 13 0 February 2007 www ride on com Copyright 1995 2006 Inovex Industries Inc Ride On Tire Protection System TPS Dosage Table No 1131 1132 1133 1134 1135 1136 1137 1138 1139 1140 1141 1142 1143 1144 1145 1146 1147 1148 1149 1150 1151 1152 1153 1154 1155 1156 1157 1158 1159 1160 1161 1162 1163 1164 1165 1166 1167 1168 1169 1170 1171 1172 1173 1174 1175 1176 1177 1178 1179 1180 1181 1182 1183 1184 1185 1186 1187 Version 13 0 February 2007 Tire Size Designation M240 40 18 M250 40 18 M180 55 18 M200 55 18 M150 60 18 M160 60 18 M170 60 18 M120 70 18 M130 70 18 M140 70 18 M150 70 18 M110 80 18 M120 80 18 M130 80 18 M140 80 18 M150 80 18 MP85 18 MT85 18 M90 90 18 M100 90 18 M110 90 18 M120 90
8. 17X7 7 ATV 18X8 7 ATV 4 00 8 4 80 8 4 80 4 00 8 4 80 440 8 TR 5 00 8 5 30 8 5 70 8 5 70 8 16X5 50 8 16X6 8 16X6 50 8 16 5X6 50 8 16X7 50 8 18X6 50 8 18X7 8 18X7 50 8 18X8 50 8 18X9 8 18X9 50 8 18X10 8 ATV 18X11 8 ATV 18 5X8 50 8 19X7 8 19X8 8 ATV Copyright 1995 2007 Inovex Industries Inc Formula HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR CHS CHS CHS HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR Regular oz Units 5 ONN 4 10 12 13 18 18 20 17 15 16 19 22 21 21 23 31 31 17 28 20 13 Severe oz Units Page 1 www ride on com Ride On Tire Protection System TPS Dosage Table 109 110 111 112 113 114 Version 13 0 February 2007 Tire Size Designation 19X9 8 ATV 19X9 50 8 20X7 8 ATV 20X8 00 8 20X9 8 ATV 20X10 8 ATV 20X11 8 ATV 21X9 8 ATV 21X10 8 ATV 21X11 8 ATV 21X11 00 8 21X12 8 ATV 22X9 8 ATV 22X10 8 ATV 22X10 00 8 22X11 8 ATV 22X11 00 8 22X12 8 22 5X10 00 8 23X10 8 ATV 4 00 9 5 30 9 6 00 9 6 90 9 18X11 9 ATV 20X7 9 ATV 20X10 9 ATV 20X11 9 ATV 21X8 9 ATV 21X9 9 ATV 21X11 9 ATV 22X7 9 ATV 22
9. 18 Version 13 0 February 2007 www ride on com Copyright 1995 2007 Inovex Industries Inc 1018 1019 1020 1021 1022 1023 1024 1025 1026 1027 1028 1029 1030 1031 1032 1033 1034 1035 1036 1037 1038 1039 1040 1041 1042 1043 1044 1045 1046 1047 1048 1049 1050 1051 1052 1053 1054 1055 1056 1057 1058 1059 1060 1061 1062 1063 1064 1065 1066 1067 1068 1069 1070 1071 1072 1073 Version 13 0 February 2007 Tire Size Designation M130 70 10 M120 90 10 M130 90 10 3 00 10 3 50 10 110 70 11 120 70 12 M130 70 12 M120 80 12 M100 90 12 M110 90 12 M110 100 12 M130 60 13 M130 70 13 150 70 13 110 90 13 3 00 14 140 60 14 160 60 14 120 80 14 180 80 14 M60 100 14 M90 100 14 M230 60 15 120 70 15 180 70 15 140 80 15 150 80 15 M160 80 15M C 170 80 15 190 80 15 MV85 15M C M130 90 15 M140 90 15M C M150 90 15M C MU90 15M C MV90 15M C 2 50 16 3 00 16 3 50 16 5 00 16 195 50R16 M240 50R16 M130 60 16 M180 60 16 M200 60 16 120 70 16 M130 70 16 M170 70 16 M180 70 16 Copyright 1995 2006 Inovex Industries Inc Ride On Tire Protection System TPS Dosage Table Formula MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS
10. 25 800 50 25 1000 50 25 1050 50 25 54x37 00 25 66X43 00 25 66X44 00 25 67X34 00 25 13 6 26 14 9 26 16 9 26 18 00 26 18 4 26 23 1 26 28L 26 580 70 26 620 70 26 620 75 26 540 65 26 750 65 26 54X31 00 26 57X31 00 26 66X43 00 26 67X34 00 26 600 55 26 5 700 50 26 5 9 5 28 11 2 28 11 25 28 12 4 28 13 6 28 14 9 28 16 8 28 16 9 28 18 4 28 19 5L 28 21L 28 Copyright 1995 2007 Inovex Industries Inc CHS CHS HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR Regular oz Units 54 58 130 77 144 185 172 231 223 285 277 348 348 400 263 353 70 75 431 435 326 479 508 398 105 121 144 236 190 265 324 207 230 243 174 304 289 273 479 398 195 228 69 83 100 96 110 126 148 150 170 179 194 Severe 02 Units 68 73 195 96 216 278 258 347 335 428 416 522 522 600 395 530 105 113 647 653 489 719 762 597 158 182 216 354 285 398 486 311 345 365 261 456 434 410 719 597 293 342 104 125 150 144 165 189 222 225 255 269 291 Page 15 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size
11. 275 35 20 38X14 00 20 38X18 00 20 Copyright 1995 2007 Inovex Industries Inc Formula HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS CHS HDOTR HDOTR HDOTR CHS CHS HDOTR HDOTR CHS HDOTR CHS CHS CHS CHS CHS HDOTR HDOTR HDOTR CHS CHS CHS HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR Regular oz Units 117 Severe oz Units 176 30 77 Page 12 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 682 683 684 685 686 687 688 689 690 691 692 693 694 695 696 697 698 699 700 701 702 703 704 705 706 707 708 709 710 711 712 713 714 715 716 717 718 719 720 721 722 723 724 725 726 727 728 729 730 731 732 733 734 735 736 737 738 Version 13 0 February 2007 Designation 38X20 00 20 41X14 00 20 42X25 00 20 44X18 20 44X18 00 20 44X41 00 20 48X25 00 20 48X31 00 20 12 00 21 12 00 21 14 00 21 14 00 21 16 00 21 16 00 21 24 21 7 50 22 9 00 22 10 00 22 11 00 22 325 40 22 LT 305 45 22 LT 8 22 5 9 22 5 9 22 5 10 22 5 10 22 5 11 22 5 11 22 5 12 22 5 12 22 5 12 5 22 5 12 75 22 5 13 22 5 13 22 5 15 22 5 16 5 22 5 18 22 5 41 18LL 22 5 445 45 22 5 455 45 22 5 495 45 22 5 445 50 22 5 700 50 22 5 445 55 22 5 455 55 22 5 385 65 22 5 385 65 22 5 425 65 22 5 445 65 22 5 445 65 22
12. MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS Regular oz Units RODBZONTAYW ONONNATOMMANOU o an aw anon oanhaaa 4 Severe oz Units 19 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size Formula Regular Severe No Designation oz Units oz Units 1074 M80 80 16 MOT CHS 3 5 1075 M100 80 16 MOT CHS 5 7 1076 M120 80 16 MOT CHS 6 8 1077 M130 80 16 MOT CHS 6 9 1078 M140 80 16 MOT CHS 8 11 1079 M150 80 16 MOT CHS 8 11 1080 M160 80 16 MOT CHS 9 13 1081 MR85 16 MOT CHS 6 8 1082 MU85 16 MOT CHS 8 11 1083 M100 90 16 MOT CHS 5 7 1084 M110 90 16 MOT CHS 6 8 1085 M120 90 16 MOT CHS 6 9 1086 M130 90 16 MOT CHS 7 10 1087 M140 90 16 MOT CHS 8 11 1088 MT90 16 MOT CHS 7 10 1089 MU90 16 MOT CHS 8 11 1090 M90 100 16 MOT CHS 5 8 1091 1092 3 00 17 MOT CHS 4 5 1093 3 25 17 MOT CHS 4 6 1094 3 50 17 MOT CHS 5 7 1095 4 50 17 MOT CHS 5 8 1096 M300 40R17 MOT CHS 16 24 1097 M190 50R17 MOT CHS 10 14 1098 M200 50R17 MOT CHS 10 15 1099 M180 55 17 MOT CHS 9 13 1100 M120 60 17 MOT CHS 6 8 1101 M130 60 17 MOT CHS 6 9 1102 M150 60 17 MOT CHS 7 11 1103 M160 60 17 MOT CHS 8 12 1104 M170 60 17 MOT CHS 9 13 1105 M110 70 17 MOT CHS 5 8 1106 120 70
13. No 853 854 855 856 857 858 859 860 861 862 863 864 865 866 867 868 869 870 871 872 873 874 875 876 877 878 879 880 881 882 883 884 885 886 887 888 889 890 891 892 893 894 895 896 897 898 899 900 901 902 903 904 905 906 907 908 909 Version 13 0 February 2007 Designation 420 70 28 480 70 28 440 65 28 480 65 28 540 65 28 600 65 28 24 00 29 26 50 29 29 50 29 30 65 29 33 25 29 7 2 30 7 50 15 30 14 9 30 16 9 30 18 0 30 18 4 30 23 1 30 420 90 30 620 75 30 480 70 30 540 65 30 67X34 00 30 9 5 32 12 4 32 24 5 32 30 5L 32 35 5L 32 650 75 32 680 75 32 800 65 32 1050 50 32 68X50 00 32 VA73X44 00 32 76x50 00 32 78x45 00 32 18 00 33 21 00 33 24 00 33 27 00 33 29 50 33 33 50 33 35 65 33 37 50 33 DH73X44 00 33 14 9 34 16 9 34 18 4 34 20 8 34 23 1 34 290 95 34 320 85 34 Copyright 1995 2007 Inovex Industries Inc Formula HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR Regular oz Units 140 168 131 149 180 214 366 354 420 380 506 47 44 141 177 202 176 243 155 251 167 187 398 73 103 314 395 440
14. Reference Manual Ride On TPS metered hand pumps and tools are designed to to the highest engineering standards to allow a user to easily pump Ride On TPS tire sealants into tires against pressures of up to 60 psi Each hand pump is calibrated to accurately pump from one to ten ounces of Ride On TPS per pump stroke and allows the operator to adjust the volume in one ounce increments When installed during mount up you can treat a medium truck tire with Ride On in less than 2 minutes Features O Six feet of reinforced hose Withstands pressures up to 300 psi and allows for mobility and reach Drum Pumps are supplied with ten feet of hose Quick connect chuck Allows the pump hose to be attached to the valve stem securely without the need to deflate the tire Built to last Hand pumps have anodized aluminum pump bodies stainless steel ball check valves special internally lubricated o rings for smoother operation and heavy duty nylon handles and pistons and aluminum pump shafts for years of trouble free service O Easy to maintain Hand pumps have been designed to be easily dismantled for cleaning and servicing without the need for tools Optional tool kit Everything needed to install Ride On TPS in single or dual wheel axles is included with the optional pump Tool Kit The Tool Kit is supplied with 2 valve core tools 2 injection adapter tools and a 40 page Dosage Table and Installation Instructions Manual
15. Remove bung cap with NPT thread does not have valve fitting 2 Remove the cap from the small valve fitting on the other bung cap This fitting is used to re circulate Ride On 3 Attach the quick connect chuck at the end of the pump hose onto the valve fitting located on the bung cap 4 Push the body of the pump into the bung opening and tighten the pump bung adapter Version 13 0 February 2007 Dosage Table Introduction VI 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual 5 Pull the pump handle all the way up as high as it will go and then push it back down This will bleed the air out of the hose as the product is circulated back into the drum Always store the pump with the hose connected to the small fitting and always re bleed the hose if the product has not been used for a while 6 Rotate the tire into which Ride On is to be installed so that the tire stem is between the and 9 o clock position bottom half of the tire Use a valve core remover tool to unscrew and remove the valve core from the tire valve stem Lower tire pressure to 60 psi or less 7 Quickly connect the hose to the valve stem by pushing the quick connect fitting onto the stem One complete pump stroke with the locking collar locked right below the handle will install 10 ounces of Ride On To install less than 10 ounces per stroke line up the top of the locking collar with the hash marks on t
16. TPS Coverage Area Q Can Ride On TPS be used in a tube tire A Yes Ride On TPS has been proven effective for sealing punctures from objects up to 1 8 diameter that penetrate the tubes However since puncturing objects sometimes tear the tube there may be occasions that the tube will continue to leak It is vital to remove the puncturing object immediately from a tire containing a tube to prevent further damage to the tube Q How many punctures can a single treatment of Ride On TPS seal A Ride On TPS will seal multiple punctures that penetrate the crown area of the tire The number of punctures that can be sealed cannot be predetermined as factors such as the tire size and age tread pattern puncture size tire air pressure tire temperature and vehicle speed can affect the results Q What about using Plugs or Patches to fix flat tires A A plug by itself is an unacceptable repair The repair material used for example a combination patch and plug repair must seal the inner liner and fill the injury to be considered a permanent repair Never use a tube in a tubeless tire as a substitute for a proper repair Ride On TPS repairs punctures for the life of the tire because it seals the puncture cavity from inside to the outside Ride On TPS will not Version 13 0 February 2007 2007 Inovex Industries Inc Dosage Table Introduction X Ride On Tire Protection System Reference Manual interfe
17. d Jlli Tine Pie tec tion tem _______ Prevents F Flats 7 Extends Tite Life Balances Tires e _ DOSAGE TABLE amp INSTALLATION GUIDE Ride On Tire Protection System Reference Manual RIDE ON TIRE PROTECTION SYSTEM DOSAGE TABLES INTRODUCTION This latest version of Inovex Industries Ride On Tire Protection System TPS Dosage Table has been produced to aid in the installation of Ride On TPS by our dealers and customers We believe that these are the most comprehensive and complete tire sealant dosage tables produced Tires are listed according to increasing rim diameter Page Section Section 1 Dosage Table Intro Section 2 Size Designation by Rim Diameter 1 18 Section 3 Motorcycle Tires 19 22 Section 4 Material Safety Data Sheet MSDS 23 27 WHAT S NEW Complete Tire Listing Inovex Industries strives to provide the most complete and comprehensive Dosage Tables on the market Our engineers are constantly updating our tables adding new tire sizes and adjusting the dosages to ensure optimum performance Please contact us at 703 421 9778 or toll free at 1 888 374 3366 USA only should you find a commercially available tire that is not listed in our tables Our engineers will be happy to assist you in determining the optimum dosage requirements for your applications FORMULATIONS Commercial High Speed CHS Formula For all high speed
18. delivering to landfills the Severe Duty dosage is recommended The Regular Duty dosages are recommended for vehicles designed to operate at high speeds where tire balance is an issue When tire balance is not a concern the Severe Duty dosages are recommended TUBE TIRES The Ride On Tire Protection System is designed to work in tube and tubeless applications For tube passenger car and light truck tires designated LT it is recommended that you use the Severe dosage For example for a P235 75 15 tire use 21 ounces of the Commercial High Speed formulation Identifying Tires Containing Ride On Always identify the tires that contain Ride On to prevent double treatment You can mark the tires by using a permanent tire marker by spray painting valve stems or by using Ride On s special vehicle stickers or o rings available through your Ride On dealer Troubleshooting Air pressure vehicle weight and centrifugal force are all needed for Ride On to work effectively When a puncture does not seal properly check for the following 1 Lack of sufficient amount of Ride On TPS 2 Rips tears or belt cord damage 3 Tread separation 4 Valve leaks 5 Oily or lubricated puncturing object 6 Sidewall puncture 7 Puncturing object larger than what the sealant is designed to seal 8 Contamination of Ride On inside of the tire due to excessively wet air source and or contaminants inside tire 9 Puncturing object has been in tire for a
19. federal regulations Maintain good shopkeeping practices When working with pressurized air sources ALWAYS WEAR SAFETY GLASSES KEEP THIS PRODUCT OUT OF THE REACH OF CHILDREN Ride On TPS contains ethylene glycol If ingested consult a physician immediately For further guidance refer to Material Safety Data Sheet MSDS at the back of this manual Installation of Ride On TPS Using Metered Hand Pumps Ride On TPS is ready to use It requires no mixing shaking or stirring Be sure to have an air compressor to re inflate the tire after Ride On installation is completed The quickest and easiest time to install Ride On is during a tire mount up You can install Ride On either into the tire casing or through the valve stem remove valve core first prior to airing up the tire The additional time required to treat a tire under this scenario is less than 2 minutes as the time required for normal mounting and airing of tires is unaffected Always identify the tires that contain Ride On to prevent double treatment You can mark the tires with a permanent tire marker by spray painting the valve stems or by using Ride On s O rings Alternatively you can mark the vehicle using Ride On trailer or tractor stickers which are available at nominal cost Always wear eye protection when working with pressurized tires Version 13 0 February 2007 Dosage Table Introduction 2007 Inovex Industries Inc Ride On Tire Protection System
20. long time If an object has been in a tire for a long time the rubber takes the shape of the object This occurs because rubber loses elasticity and when the object is removed an open hole remains instead of a closed injury This is one reason why it is so important to check tires regularly for puncturing objects To help seal such a puncture re air tire and drive until tire warms up This will aid in the tire regaining elasticity The re airing driving process may need to be repeated up to three times 10 Was the vehicle driven minimum 3 miles for on the road vehicles once the object was removed If the vehicle is not driven immediately the tire may lose air pressure and the puncture may not seal properly Version 13 0 February 2007 Dosage Table Introduction 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual 11 Was Ride On used as an after the fact repair Ride On TPS is designed to be used as a preventative and is not recommended for use in applications where the tire has been punctured If Ride On is added to a tire after an object has already punctured the tire a Object Still in Tire DO NOT REMOVE OBJECT If the object is still lodged in the tire pump the severe dosage requirement of Ride On into the tire Drive the vehicle for a minimum of 5 7 miles to ensure complete distribution of product Remove object and drive the vehicle at least 2 3 more miles Make sure to re air the ti
21. of the pump from the valve stem and inject a short burst of air to clear the tire stem passageway then reattach the hose connector and continue pumping A paper clip or similar object can also be used to help clear the valve stem Q Can Ride On TPS plug the tire valve when the tire pressure is being checked A When the proper dosage of Ride On TPS is installed almost never The centrifugal force of the rotating tire forces Ride On away from the valve stem and unto the tire However in the rare occasion when some Ride On TPS gets into the valve it is recommended that a short burst of air be injected into the tire to clear any sealant coating the inner surface of the valve stem Q Does a tire need to be completely deflated prior to using the Hand Pump to install Ride On TPS A No The hand pump can pump against tire pressures as high as 60 psi but it is recommended to reduce the pressure to as low as possible Version 13 0 February 2007 2007 Inovex Industries Inc Dosage Table Introduction XI Ride On Tire Protection System TPS Dosage Table Z 5 Version 13 0 February 2007 Tire Size Designation 2 80 4 9X3 50 4 4 10 4 11X4 00 4 12X5 00 4 3 40 5 3 40 3 00 5 4 10 5 11X4 00 5 11X6 00 5 4 00 6 4 10 6 4 10 3 50 6 5 30 4 50 6 5 30 6 8 00 6 13X5 00 6 13X6 00 6 13X6 50 6 14X4 50 6 14X8 6 15X5 00 6 15X6 00 6 15X6 50 6 15X7 6 ATV 145 70 6 16X8 7 ATV
22. vehicles cars light trucks mobile homes tractors trailers roll offs street sweepers buses delivery trucks etc The CHS formula offers protection against flats from objects up to 6 4 mm in diameter helps tires run cooler and acts as a balancing compound The CHS formula is ideal for any fleet that would like to improve its pressure maintenance program ensure that their tires wear more evenly minimize downtime and maximize the life of their tires e Heavy Duty Off Road HD OTR Formula Available for off the road commercial and industrial vehicles operating speed less than 30 MPH 50 Km H This industrial strength formula can seal punctures up to 1 2 in diameter in the tread area Ride On TPS Off Road provides extra protection for severe service and is ideal for all off road equipment farm tractors forklifts backhoes construction equipment mining and logging equipment bobcats etc e Tire Conditioner amp Sealant Designed to condition casings and help reduce rim corrosion and scale buildup for off road and agricultural tires This specially formulated Tire Conditioner and Sealant reduces porosity air loss helping tires run cooler and extending overall tire life It also helps seal bead leaks and tread punctures from objects up to Y 6 4 mm in diameter Ride On Tire Conditioner and Sealant lowers labor costs by helping with mounting and demounting of off road and agricultural tires e Tire Conditioner amp Ballas
23. 04 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 Version 13 0 February 2007 Designation 165 70 12 255 65 12 270 60 12 22X7 50 12 22X9 50 12 23X8 12 ATV 23X8 50 12 23X9 50 12 23X10 12 23X10 12 ATV 23X10 50 12 23 5X8 50 12 23 5X11 12 24 8 12 24 9 12 24 9 50 12 24 10 50 12 24 11 12 24 12 12 24 13 00 12 25X8 12 ATV 25X10 12 ATV 25 11 12 26x8 12 ATV 26X10 12 26x10 12 ATV 26X10 5 12 26x11 12 ATV 26x11 12 26X12 00 12 26 5X14 00 12 27X9 12 ATV 27X10 12 27X11 12 ATV 27X12 12 ATV 6 00 13 6 50 13 TR A78 13 TR B78 13 TR C78 13 TR 145 80 13 155 80 13 155 80 13 TR 165 80 13 175 80 13 175 80 13 TR 185 80 13 185 80 13 TR 185 80 13 155 70 13 165 70 13 175 70 13 185 70 13 195 70 13 205 70 13 165 65 13 Copyright 1995 2007 Inovex Industries Inc Formula CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS Regular oz Units 6 37 41 Severe oz Units 8 56 62 45 45 24 Page 4 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 229
24. 18 M130 90 18 ML90 18 MM90 18 MN90 18 MP90 18 MR90 18 MJ90 18 M100 100 18 M110 100 18 M120 100 18 2 5 19 3 00 19 3 25 19 3 50 19 4 00 19 4 10 19 M120 70 19 M100 80 19 M110 80 19 M120 80 19 M90 90 19 M100 90 19 M110 90 19 MJ90 19 ML90 19 MM90 19 M70 100 19 3 00 20 275 55 20 2 75 21 3 00 21 70 100 21 Copyright 1995 2006 Inovex Industries Inc Formula MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS MOT CHS Regular oz Units ONDA Y O 0 100 ON ND FOATADAAINDAINAHOAAH A Severe oz Units a a gt SMPDMDEZMONADD TOOnNGCowonn Page 21 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size Formula Regular Severe Designation oz Units oz Units M80 100 21 MOT CHS 5 M80 90 21 MOT CHS 5 M90 90 21 MOT CHS 5 MH90 21 MOT CHS 4 MH120 70 21 MOT CHS 7 NOTE Severe applications offroad motorcross reflects 45 more product Please Note at thes
25. 21X11 00 10 22X7 10 ATV 22X8 10 ATV 22X8 00 10 22X9 10 ATV 22X9 50 10 22X10 10 ATV 22X11 10 ATV 22X11 00 10 23X7 10 ATV 23X8 10 ATV 23X9 10 ATV 23X10 10 24X9 50 10 24X10 50 10 24X11 00 10 24X11 5 10 24X12 00 10 25X8 10 ATV 25X11 10 ATV 25X12 10 ATV 27X9 10 27X15 10 22X7 11 ATV 23X8 11 ATV 23X9 11 ATV 23 5X8 11 ATV 24X8 11 ATV 24X9 11 ATV 24X10 11 ATV 24 5X8 11 ATV 25 8 11 25 10 11 4 00 12 4 80 12 4 80 12 5 12 5 30 12 5 30 12 5 70 12 6 12 7 12 7 00 12 ST145 R12 145 80 12 155 80 12 205 80 12 Copyright 1995 2007 Inovex Industries Inc Formula CHS HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS MOT HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS HDOTR Regular oz Units 20 19 37 Severe oz Units 30 29 56 45 23 24 23 29 29 20 24 42 26 27 29 32 57 21 Page 3 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 2
26. 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 250 251 252 253 254 255 256 257 258 259 260 261 262 263 264 265 266 267 268 269 270 271 272 273 274 275 276 277 278 279 280 281 282 283 284 285 Version 13 0 February 2007 Designation 195 65 13 185 60 13 195 60 13 205 60 13 215 60 13 235 60 13 215 50 13 235 50 13 245 50 13 E78 14 TR F 78 14 TR G78 14 TR H78 14 TR F70 14 TR H70 14 TR 6 00 14 7 14 7 50 14 8 5L 14 9 5L 14 11L 14 175 75 14 185 75 14 195 75 14 205 75 14 205 75 14 TR 215 75 14 215 75 14 TR 225 75 14 245 75 14 175 70 14 185 70 14 195 70 14 205 70 14 215 70 14 225 70 14 235 70 14 245 70 14 165 65 14 175 65 14 185 65 14 195 65 14 215 65 14 175 60 14 185 60 14 195 60 14 205 60 14 215 60 14 225 60 14 235 60 14 245 60 14 255 60 14 265 60 14 275 60 14 255 55 14 245 50 14 Copyright 1995 2007 Inovex Industries Inc Formula CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS Regular oz Units 12 11 11 Severe oz Units 15 14 14 Page 5 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size Formula Regular Severe No Designa
27. 282 306 357 496 594 561 598 564 258 295 363 485 419 541 511 647 561 138 165 215 222 258 100 110 Severe oz Units 210 252 197 224 270 321 549 531 630 570 759 71 66 212 266 303 264 365 233 377 251 281 597 110 155 471 593 660 423 459 536 744 891 842 897 846 387 443 545 728 629 812 767 971 842 207 248 323 333 387 150 165 Page 16 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 910 911 912 913 914 915 916 917 918 919 920 921 922 923 924 925 926 927 928 929 930 931 932 933 934 935 936 937 938 939 940 941 942 943 944 945 946 947 948 949 950 951 952 953 954 955 956 957 958 959 960 961 962 963 964 965 966 Version 13 0 February 2007 Designation 380 85 34 385 85 34 420 85 34 620 75 34 650 75 34 710 75 34 480 70 34 540 65 34 600 65 34 700 55 34 21 00 35 24 00 35 29 50 35 33 25 35 37 25 35 9 5 36 11 2 36 12 4 36 13 6 36 13 9 36 230 95 36 270 95 36 11 2 38 12 4 38 13 6 38 14 9 38 15 5 38 16 9 38 18 4 38 20 8 38 320 85 38 380 80 38 580 70 38 620 70 38 710 70 38 540 65 38 600 65 38 650 65 38 33 50 39 37 50 39 40 65 39 40 5 75 39 41 25 70 39 180 95 40 230 95 40 9 5 42 12 4 42 18 4 42 20 8 42 320 90 42 520 85 42 Copyright 1995 2007 Inovex Industries Inc Formula HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR
28. 5 255 70 22 5 275 70R22 5 305 70R22 5 245 75 22 5 Copyright 1995 2007 Inovex Industries Inc Formula HDOTR Regular oz Units 129 HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS CHS CHS HDOTR CHS CHS CHS HDOTR CHS CHS CHS CHS HDOTR CHS CHS CHS HDOTR CHS CHS HDOTR CHS CHS CHS CHS 101 179 147 140 302 211 258 49 44 47 51 27 26 Severe oz Units 194 152 269 221 210 453 317 387 66 153 206 88 260 101 134 Page 13 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 739 740 741 742 743 744 745 746 747 748 749 750 751 752 753 754 755 756 757 758 759 760 761 762 763 764 765 766 767 768 769 770 771 772 773 774 775 776 777 778 779 780 781 782 783 784 785 786 787 788 789 790 791 792 793 794 795 Version 13 0 February 2007 Designation 265 75 22 5 295 75 22 5 305 75 22 5 235 80 22 5 255 80 22 5 275 80 22 5 295 80 22 5 315 80 22 5 365 80 22 5 305 40 23 LT 7 50 24 8 3 24 9 00 24 9 5 24 10 00 24 10 00 24 11 00 24 11 00 24 11 2 24 11 25 24 12 00 24 12 00 24 12 4 24 13 00 24 13 00 24 13 6 24 14 00 24 14 00 24 14 9 24 16 00 24 16 00 24 16 9 24 17 5L 24 18 4 24 19 5L 24 21L 24 280 85 24 320 70 24 320 75 24
29. HS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR Regular oz Units 19 19 19 19 22 24 30 22 Severe oz Units 24 24 21 24 25 120 Page 10 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 569 570 571 572 573 574 575 576 577 578 579 580 581 582 583 584 585 586 587 588 589 590 591 592 593 594 595 596 597 598 599 600 601 602 603 604 605 606 607 608 609 610 611 612 613 614 615 616 617 618 619 620 621 622 623 624 625 Version 13 0 February 2007 Designation 12 5 18 12 5 80 18 15 0 55 18 275 80 18 335 80 18 275 75 18 275 70 18LT 320 65 18 340 65 18 235 65 18 275 65 18 LT 285 65 18 LT 325 65 18 LT 315 60 18 LT 225 60 18 255 60 18 255 55 18 275 55 18 285 55 18 305 55 18 LT 225 45 18 245 45 18 255 45 18 295 45 18 225 40 18 245 40 18 255 40 18 265 40 18 275 40 18 215 35 18 245 35 18 275 35 18 285 35 18 35X12 5X R18 LT 335 30 18 4 00 19 260 80 19 255 45 19 255 40 19 235 35 19 8 19 5 15 19 5 15 19 50 16 5 19 5 33 16LL500 18 19 5 18 19 5 19 5 19 5 385 65 19 5 445 65 19 5 225 70 19 5 245 70 19 5 265 70 19 5 285 70 19 5 305 70 19 5 Copyright 1995 2007 Inovex Indust
30. Page 6 Version 13 0 February 2007 www ride on com Copyright 1995 2007 Inovex Industries Inc Ride On Tire Protection System TPS Dosage Table Tire Size No 343 344 345 346 347 348 349 350 351 352 353 354 355 356 357 358 358 359 360 361 362 363 364 365 366 367 368 369 370 371 372 373 374 375 376 377 378 379 380 381 382 383 384 385 386 387 388 389 390 391 392 393 394 395 396 397 398 Version 13 0 February 2007 Designation 29X12 50 15 29X14 00 15 30X8 15 30x9 5 15 LT 31x10 5 15 LT 31x11 5 15 LT 31X12 50 15 31X13 50 15 31X15 50 15 32x11 5 15 LT 32X12 15 32X15 15 33X12 50 15 33x12 5 15 LT 35x12 5 15 LT 35x14 15 LT 35X15 15 36X11 15 36X13 50 15 36x14 5 15 LT 38X16 15 8 5 90 15 195 75 15 205 75 15 205 75 15 LT 205 75 15 TR 215 75 15 225 75 15 225 75 15 TR 235 75 15 255 75 15 265 75 15 185 70 15 195 70 15 205 70 15 215 70 15 215 70 15 225 70 15 235 70 15 245 70 15 255 70 15 265 70 15 285 70 15 315 70 15 185 65 15 195 65 15 205 65 15 215 65 15 225 65 15 235 65 15 255 65 15 260 65 15 185 60 15 195 60 15 205 60 15 215 60 15 225 60 15 Copyright 1995 2007 Inovex Industries Inc Formula HDOTR HDOTR HDOTR CHS CHS CHS HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR CHS CHS CHS HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS
31. S CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS Regular oz Units 16 17 18 Severe oz Units 20 21 23 24 102 126 107 110 98 122 Page 8 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 456 457 458 459 460 461 462 463 464 465 466 467 468 469 470 471 472 473 474 475 476 477 478 479 480 481 482 483 484 485 486 487 488 489 490 491 492 493 494 495 496 497 498 499 500 501 502 503 504 505 506 507 508 509 510 511 Version 13 0 February 2007 Designation 240 70 16 245 70 16 255 70 16 265 70 16 275 70 16 305 70 16 205 65 16 215 65 16 255 65 16 320 65 16 205 60 16 215 60 16 225 60 16 235 60 16 255 60 16 275 60 16 205 55 16 215 55 16 225 55 16 235 55 16 255 55 16 205 50 16 225 50 16 235 50 16 245 50 16 255 50 16 265 50 16 275 50 16 245 45 16 265 45 16 205 40 16 13 50 16 1 14L 16 1 14L 16 1 14 5 75 16 1 16 5L 16 1 16 5L 16 1 18 4 16 1 19L 16 1 21 5L 16 1 38X20 00 16 1 8 00 16 5 LT 8 75 16 5 LT 9 50 16 5 LT 10 16 5 LT 10 16 5 12 16 5 LT 12 16 5 265 70 16 5 305 70 16 5 330 55 16 5 395 55 16 5 36x15 5x16 5 LT 37x12 5x16 5 LT 38x15 5 16 5 LT Copyright 1995 2007 Inovex Industries Inc Formula HDOTR CHS CHS CHS CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR
32. X8 9 22X10 9 ATV 22X11 9 ATV 23X11 9 ATV 24X13 9 ATV 25X11 9 ATV 25X12 9 ATV 25X13 9 6 50 10 7 50 10 9 00 10 15L 10 205 50 10 18X8 00 10 18X8 50 10 18X9 50 10 18X10 10 ATV 18X10 50 10 18X11 10 ATV 19X6 10 ATV 20X7 10 ATV 20X7 50 10 20X8 10 ATV Copyright 1995 2007 Inovex Industries Inc Formula CHS HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR HDOTR CHS HDOTR HDOTR CHS HDOTR CHS HDOTR CHS HDOTR HDOTR CHS HDOTR Regular oz Units 15 33 12 Severe oz Units 23 50 18 23 24 32 29 24 114 Page 2 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 Version 13 0 February 2007 Designation 20X10 10 ATV 20X11 10 ATV 20X12 00 10 20 5X8 0 10 21X7 10 ATV 21X8 10 ATV 21X9 10 21X10 10 ATV
33. ack into the Always store the pump with the hose connected to the small fitting and always re bleed the hose if the product has not been used for a while 7 One complete pump stroke with the locking collar locked right below the handle will install 10 ounces of Ride On To install less than 10 ounces per stroke line up the top of the locking collar with the hash marks on the pump shaft and lock in place using thumbscrew You should be able to read the corresponding marked numbers above the collar The pump shaft is marked in one ounce increments Version 13 0 February 2007 Dosage Table Introduction 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual 8 Rotate the tire into which Ride On is to be installed so that the tire stem is between the and 9 o clock position bottom half of the tire Use a valve core remover tool to unscrew and remove the valve core from the tire valve stem The lower the tire pressure the easier it is to install the product 60 psi or less Quickly connect the hose to the valve stem by pushing the quick connect fitting onto the valve stem Pump the required dosage of Ride On into the tire Remove the quick connect chuck and re install the valve core into the valve stem Do not over tighten the valve core Inflate the tire to the vehicle manufacturer s recommended tire inflation pressure Installation Using 55 Gallon Drum Metered Hand Pump 1
34. d Color Color added typically found White Yellow Blue Cream Orange red purple Odor Faint Glycol pH 8 0 10 0 Viscosity 2 300 cp 15 000 cp Freezing Point lt 40 F 40 10 STABILITY AND REACTIVITY Hazardous Polymerization Product will not undergo hazardous polymerization Hazardous Decomposition May form carbon dioxide and carbon monoxide Chemical Stability Stable 10 Toxicological Information No Data 11 Toxicological Information No Data 12 Ecological Information No Data 13 Disposal Information Waste Management Information Dispose of in accordance with all applicable local state and federal regulations Do not flush to storm sewer Material Safety Data Sheet MSDS Inovex Industries Inc Page 5 5 Date Prepared 03 03 2003 Date Printed 2 10 2006 MSDS No 022703 001 001 RIDE ON TIRE PROTECTION SYSTEM TPS TIRE SEALANT 14 TRANSPORT INFORMATION THIS MATERIAL IS NOT HAZARDOUS AD DEFINED BY 49 CFR 172 101 BY THE US DEPARTMENT OF TRANSPORTATION DOT Information 49 CFR 172 101 DOT Description This product is non flammable non hazardous and not Regulated Container Mode 275 gallon tote 55 Gallon Drum 5 Gallon Pail 8 amp 16 ounce bottles NOS Component None RQ Reportable Quantity 49 CFR 172 101 Not Applicable 15 REGULATORY INFORMATION US Federal Regulations TSCA Toxic Substances Control Act Status TSCA United States The intentional ingredients of this
35. down If individual is conscious and alert induce vomiting by giving syrup of ipecac or by gently placing two fingers at the back of the throat If possible do not leave individual unattended Skin Harmful effects are not expected from this route of exposure under normal conditions of handling and use Although rare skin contact with ethylene glycol may cause allergic skin reaction Exposure may cause mild skin irritation Symptoms may include redness and burning Remove contaminated clothing Wash exposed area with soap and water If symptoms persist seek medical attention Launder clothing before reuse Inhalation Harmful effects are not expected from this route of exposure under normal conditions of handling and use If symptoms develop move individual away from exposure and into fresh air If symptoms persist seek medical attention If breathing is difficult administer oxygen Keep person warm and quiet If person is not breathing begin artificial respiration Note to Physicians This product contains Ethylene Glycol Ethanol decreases the metabolism of ethylene glycol to toxic metabolites Ethanol should be administered as soon as possible in cases of severe poisoning since the elimination half life of ethylene glycol is 3 hours If medical care will be delayed several hours use three to four 1 ounce shots of 86 proof or higher whiskey before or during transport to the hospital Hemodialysis effectively removes ethylene glycol and its
36. e On TPS tire sealant also eliminates porosity leaks and reduces the rate of detrimental oxidation inside the tire Ride On TPS helps your tires maintain proper inflation and run cooler the result of constant air pressure and heat reduction mean increases in tire life of up to 25 or more of course this is critically dependent on how and where you drive your vehicle Another benefit of using Ride On TPS is that it helps stop slow leaks from the moment they start helping tires stay properly inflated and last longer A vehicle equipped with Ride On tire sealant will benefit from better handling better fuel economy longer lasting tires and most importantly a safer ride Q Who are some of the users of Ride On TPS A Inovex Industries takes pride in providing the most advanced tire sealant formulas available on the market Ride On TPS is the result of more than 11 years of research and rigorous field testing It has been tested and used by the military the US Postal Service police and fire departments construction companies commercial fleets and independent testing laboratories The Ride On TPS tire sealant has been proven effective in the most demanding situations Q How does Ride On TPS affect tire life A The Ride On TPS tire sealant can extend the useful life of tires by up to 25 or more Heat caused by friction amplified by underinflation is one of the primary causes of tire failure As a tire s temperature increase
37. e higher dosages you may experience some vibrations at high speeds Page 22 Version 13 0 February 2007 www ride on com Copyright 1995 2006 Inovex Industries Inc Material Safety Data Sheet MSDS Inovex Industries Inc Page 1 5 Date Prepared 03 03 2003 Date Printed 2 10 2006 MSDS No 022703 001 001 RIDE ON TIRE PROTECTION SYSTEM TPS TIRE SEALANT 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Material Identity Product Name Ride On Tire Protection System TPS Tire Sealant Product Description Water based tire sealant for pneumatic tires Company Emergency Telephone Number Inovex Industries Inc 1 800 255 3924 45681 Oakbrook Court Unit 102 Sterling VA 20166 USA Tel 703 421 9778 24 hours everyday Information Telephone Number Fax 703 421 1967 703 421 9778 1 888 374 3366 US Only Ingredient s CAS Number by weight Ethylene Glycol 107 21 1 35 55 Water 7732 18 5 45 65 Fibers and fillers no asbestos ceramics or glass Proprietary 3 6 Non heavy metal based corrosion inhibitors Proprietary 1 5 4 other ingredients that are either Balance less than 1 A Not classified by the OSHA Communication Standard to be Hazardous or B Present in concentrations less than 1 less than 1 for carcinogens in this product 3 Hazards Identification Potential Health Effects Eye Exposure may cause mild eye irritation Symptoms may include stinging tearing redness and swelling Skin Harmful effects ar
38. e not expected from this route of exposure under normal conditions of handling and use Swallowing Single dose oral toxicity is low Swallowing small amounts during normal handling is not likely to cause harmful effects swallowing large amounts may be harmful Inhalation Harmful effects are not expected from this route of exposure under normal conditions of handling and use Developmental Information This material or a component may cause birth defects in humans based on positive test results with laboratory animals Material Safety Data Sheet MSDS Inovex Industries Inc Page 2 5 Date Prepared 03 03 2003 Date Printed 2 10 2006 MSDS No 022703 001 001 RIDE ON TIRE PROTECTION SYSTEM TPS TIRE SEALANT Cancer Information This material is not expected to be carcinogenic in humans based in negative evidence of carcinogenicity in laboratory animals This material is not listed as a carcinogen by IARC NTP or OSHA Primary Routes of Entry Inhalation skin contact eye contact ingestion industrial products are not meant to be swallowed 4 FIRST AID MEASURES Eyes If symptoms develop immediately move individual away from exposure and into fresh air Flush eyes gently with water for at least 15 minutes while holding eyelids apart seek immediate medical attention Swallowing If swallowed seek medical attention If individual is drowsy or unconscious do not give anything by mouth place individual on the left side with the head
39. he pump shaft and lock in place using thumbscrew You should be able to read the corresponding marked numbers above the collar The pump shaft is marked in one ounce increments 8 Remove the quick connect chuck and re install the valve core into the valve stem Do not over tighten the valve core Inflate the tire to the vehicle manufacturer s recommended tire inflation pressure Please note It is NOT necessary to immediately drive the vehicle Once the vehicle is driven Ride On TPS is evenly dispersed over the entire tread area of the inner surface of the tire Do not be concerned with any initial vibrations Until Ride On TPS has completely coated the inside of your tires you may experience slight vibration To avoid wheel balance problems it is critical that the correct amount of Ride On TPS is installed for your tire size Ride On TPS is a stable compound that can be stored in its original closed container for up to 3 years Please store Ride On indoors or out of direct sunlight Once a pail has been opened it is very important to keep the Ride On in an airtight environment This can be accomplished by connecting the quick connect on the pump hose to the pail return spout If the product is to be stored for prolonged periods more than four weeks it is recommended that the pump be rinsed with water and the black plastic cap be replaced step 2 Version 13 0 February 2007 Dosage Table Introduction 2007 Inovex Industries I
40. ll running ROTIS is supplied with everything you need O 50 foot 3 4 steel reinforced high pressure product installation hose 50 foot 3 8 high pressure industrial air hose Quick connect installation tools for dual wheel assemblies 2 valve core removal tools dosage table and installation manual Specifications Each pump is calibrated to insure trouble free operation reliability and accuracy Maximum inlet pressure 160 psi No electrical hookup required Stall free ice free motor design requires absolutely no mechanical assist devices such as trip rods or push pins All wetted materials cyclinder plunger are made of 316 stainless steel for years of trouble free operation The pump housing is made of 304 stainless steel One year Limited Warranty refer to Limited Warranty description for Manufactured and assembled in the USA Patent pending Version 13 0 February 2007 Dosage Table Introduction 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual Q What is Ride On Tire Protection System A The Ride On Tire Protection System TPS is a high tech tire sealant specially formulated to prevent leaks seal punctures and extend tire life Ride On TPS is designed to seal most punctures in the tread area of the tire caused by nails screws thorns road debris any perforating object up to 1 4 6 35 in diameter Rid
41. n System Reference Manual Q Do nails or other puncturing objects in the tire need to be removed even though the Ride On TPS has prevented a flat A Yes Although the Ride On TPS has effectively sealed around the penetrating object if left in the tire the object will shift around as the tire rotates and will eventually create a larger hole and can potentially cause further damage to the tire If the object is a screw you must unscrew it Yanking or pulling will tear the rubber and possibly the tire s steel belts Also remember that you must drive the vehicle after pulling out the puncturing object If the puncturing object has been left in the tire for a long time it might take some time for the puncture cavity to close rubber has memory and it conforms to the shape of the puncturing object and the tire may temporarily lose some air until it is sealed Will Ride On TPS puncture in the sidewall of the tire A No Ride On TPS is not recommended for fixing sidewall damage A puncture in the sidewall of a tire treated with Ride On will likely continue to leak air No sealant can effectively seal sidewall punctures regardless of what some manufacturers may claim Inspect your tires regularly In case of a cut impact break bruise sidewall damage or continued air loss have the tire inspected by a professional tire care specialist Check your tire pressure per your tire manufacturer s recommendations whe
42. n the tires are cold Does the vehicle need to be driven after a penetrating object has been removed A Yes Ride On TPS coats the inner surface of the tire As the tire rotates the tire pressure and centrifugal force push Ride On TPS to the puncture As the tire flexes and the hole expands the fibers enter the puncture cavity The fibers form a flexible plug similar in action to that of a beaver dam If the vehicle is not driven there will not be any centrifugal force or tire flexing to aid Ride On TPS to enter and seal the puncture cavity Q What is the effectiveness and coverage area of Ride On TPS A Ride On TPS covers crown of the tire Ride On TPS will not cover the outside 1 2 to 1 of a tire closest to the shoulder areas This area of a tire is outside of the belt package and is a flex point Tire manufacturers do not recommended using conventional repairs to fix punctures in these areas You should have the tire inspected by a professional to determine if a conventional plug and patch repair or a section repair is necessary For further information refer to your tire manufacturer s repair manual i e Goodyear s Radial Truck Tire and Retread Service Manual Using Ride On TPS does not guarantee that you will never get any flat tires Our effectiveness in sealing punctures in the crown of the tire is 85 95 in tubeless tires and 55 65 in tube tires Tubes have a tendency to tear or rupture when punctured Ride On
43. nc Ride On Tire Protection System Reference Manual Installation of Ride On TPS Using ROTIS Pump Please ask your Ride On Representative for a copy of the ROTIS installation instructions ROTIS Ride On Tire Injection System is a pneumatic drum pump designed to install Ride On TPS tire sealants into tires without the need to deflate them The air that s in the tire stays in the tire which means the job gets done faster Whether you are on a service call in the yard or working a service bay ROTIS will save you time and money With ROTIS you accurately inject Ride On into fully pressurized tires up to 115 psi on or off your vehicles up to 50 feet away from the product source No more hand pumping And no more wasted time reinflating tires You can remotely reset the pump for installation in multiple tires without needing to walk back to the control panel Controls are where you need them at your fingertips ROTIS includes it s own air line for inflating any tire There s no need to run separate air lines Quality Durability Features Fast accurate and efficient Just set the meter to the desired dosage and the ROTIS pump does the rest shutting off when the desired amount is installed Now it s possible to install Ride On into an 11R22 5 tire at 100 psi in less than 30 seconds In field tests under rigorous real world working conditions ROTIS pumps turned more than 10 million cycles and are sti
44. product are listed CERCLA RQ 40 CFR 302 4 Component RQ bs Ethylene Glycol 5000 SARA 302 Components 40 CFR 355 Appendix A None International Regulations Inventory Status DSL CANADA The intentional ingredients of this product are listed State and Local Regulations California Proposition 65 None New Jersey RTK Label Information Ethylene Glycol 107 21 1 Pennsylvania RTK Label Information 1 2 Ethanediol 107 21 1 16 OTHER INFORMATION The information accumulated herein is believed to be accurate but is not warranted to be whether originating with the company or not Recipients are advised to confirm in advance of need that the information is current applicable and suitable to their circumstances Aae Tire Protection System iNOVEX INDUSTRIES INC 45681 Oakbrook Court Unit 102 Sterling Virginia 20166 USA Phone 703 421 9778 http www ride on com e mail info ride on com Fax 703 421 1967 Member Tire Association of North America American Trucking Association Tire Reatread Information Bureau Solid Waste Association of North America
45. r soluble This is particularly important to our fleet and commercial clients that wish to retread their tire casings Ride On TPS contains ethylene glycol which is commonly used in antifreeze and in cooling and heating systems Good industrial hygiene work practices should be used when installing or removing Ride On Please refer to the Material Safety Data Sheet Please refer to your federal state or local regulations for disposing or recycling of glycol based products Q What if we install in wheels that are rusted A Ride On should be installed in rims that are in good condition or refurbished by powder coating Otherwise Ride On will bind to any rusted surface to prevent the rust from spreading However this rust will also contaminate the product and cause it to break down and become less effective The color of the product will also change to a reddish hue Q How does Ride On Tire Protection System seal a hole in the tread of the tire A As the tire rotates the tire pressure and centrifugal force draw Ride On TPS to the puncture As the tire flexes and the hole is expanded the proprietary formulation containing aramid fibers that are six times stronger than steel enter the puncture cavity Ride On TPS also contains corrosion inhibitors that protect steel and aluminum wheels and tire belts against rust Version 13 0 February 2007 2007 Inovex Industries Inc Dosage Table Introduction IX Ride On Tire Protectio
46. re as necessary to avoid driving on a flat tire The re airing driving process may need to be repeated up to 3 times before the puncture is sealed b Ifthe object is no longer in the tire Pump the severe dosage requirement of Ride On into the tire Drive the vehicle for a minimum of 5 7 miles to ensure complete distribution of product Re air tire and drive until tire warms up This will aid in the tire regaining its elasticity The re airing driving process may need to be repeated up to 3 times before the puncture is sealed Vibration and Other Ride Disturbances It is important to recognize that not all vehicle vibrations are related to tire balance The following are some of the reasons that a tire may be vibrating in an up and down direction 1 out of round tires or wheels 2 flat spots on tires 3 worn shock absorbers struts ball joints kingpins 4 shifted tire belts 5 mismounted tire wheel assembly 6 excessive tire wheel assembly run out If the tire is vibrating from side to side wobbling look for the following potential causes 1 bent wheels 2 bent axles 3 improper wheel installation 4 loose or damaged wheel bearings 5 loose front end components If the Severe Duty dosages or the Off Road Formula is used you may experience some vibration in high speed vehicles Precautions Handling Spill amp Waste Disposal Use absorbent material to soak up small spills Dispose of waste material in accordance with local state and
47. re with the use of conventional plugs and patches in tires Warranty amp Insurance Questions Q Is Ride On Tire Protection System tire sealant covered by product liability insurance A Yes Ride On TPS has product liability insurance with the Hartford Group Q How does Ride On TPS affect the tire manufacturer s warranty A Ride On TPS is an inert tire sealant that does not attack or damage tires or wheels Ride On TPS contains corrosion inhibitors to help protect steel or aluminum wheels and tire belts from rust Ride On TPS has obtained letters from Bridgestone Firestone Continental General Tire Yokohama Michelin Goodyear and Toyo Tires stating that the use of Ride On TPS does not void their warranties unless the damage to the tire or wheel has been caused by the sealant Q What Warranty does Ride On TPS offer to its customers A Inovex Industries Inc warrants Ride On TPS to be free from manufacturing defects The Company shall not be liable for any consequential or other damage or remedy The Company s sole obligation and your exclusive remedy are limited to product replacement Inovex Industries Inc expressly disclaims all other warranties and or conditions whether express or implied including but not limited to the implied warranties and conditions of merchantability satisfactory quality and fitness for a particular purpose Inovex Industries shall not under any circumstance be liable for towing expenses
48. ries Inc Formula HDOTR HDOTR HDOTR HDOTR HDOTR CHS CHS HDOTR HDOTR CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS CHS HDOTR HDOTR CHS CHS CHS CHS CHS HDOTR CHS HDOTR HDOTR CHS CHS HDOTR CHS CHS CHS CHS CHS CHS Regular oz Units 74 74 83 62 82 24 24 67 75 18 23 25 29 Severe oz Units 111 111 125 93 123 30 30 101 113 23 29 Page 11 www ride on com Ride On Tire Protection System TPS Dosage Table Tire Size No 626 627 628 629 630 631 632 633 634 635 636 637 638 639 640 641 642 643 644 645 646 647 648 649 650 651 652 653 654 655 656 657 658 659 660 661 662 663 664 665 666 667 668 669 670 671 672 673 674 675 676 676 677 678 679 680 681 Version 13 0 February 2007 Designation 40X19 19 5 7 50 20 7 50 20 8 25 20 8 25 20 8 50 20 9 00 20 9 00 20 9 50 20 10 00 20 10 00 20 10 00 10 5 20 11 00 20 11 00 20 11 2 20 11 50 20 12 00 20 12 00 20 12 4 20 12 5 20 12 5 20 13 00 20 13 00 20 13 6 20 14 00 20 14 00 20 14 5 20 14 75 80 20 15 5 80 20 16 00 20 13 80 20 260 80 20 275 80 20 335 80 20 365 80 20 395 85 20 405 85 20 375 75 20 425 75 20 380 70 20 405 70 20 420 65 20 275 60 20 LT 325 60 20 LT 275 55 20 LT 265 50 20 305 50 20 LT 325 50 20 LT 295 45 20 295 45 20 LT 245 40 20 295 40 20 305 40 20 LT
49. s the rate of oxidation and subsequent polymerization resulting in stiffness and chemical degradation also increase Ride On TPS also helps eliminate porosity leaks and reduces the rate of detrimental oxidation Ride On TPS also helps hydrodynamically balance tires resulting in more uniform tire wear and reduction in vibration both of which cause heat buildup Technical Questions Q Does Ride On Tire Protection System react chemically with tires or wheels A No Ride On TPS tire sealant is chemically inert and will not react negatively with tires or wheels Ride On TPS contains corrosion inhibitors that protect steel aluminum yellow metals as well as wheels and tire belts against corrosion Ride On TPS tire sealant can easily be washed out of tires with water It will not affect the use of patches or other tire repairs if necessary Ride On TPS actually helps preserve tire casings making retreads more effective Q Is Ride On TPS Hazardous A Ride On TPS is not considered to be a hazardous material as defined by the US EPA and DOT Ride On TPS is biodegradable non flammable and non explosive Please refer to the Material Safety Data Sheet MSDS and Environmental Impact Testing Report for more details Q Is the Ride On TPS water dispersible A Yes Since there is no chemical bonding of Ride On TPS tire sealant to the tire it can be easily washed out of a tire with water In fact Ride On TPS is more than 95 wate
50. t Designed to condition casings and help reduce rim corrosion and scale buildup for off road and agricultural tires Ride On Tire Conditioner amp Ballast lowers labor costs by helping with mounting and demounting of off road and agricultural tires Version 13 0 February 2007 Dosage Table Introduction I 2007 Inovex Industries Inc Ride On Tire Protection System Reference Manual e Passenger amp Light Truck PLT Formula Exclusively manufactured for passenger and light trucks The Ride On PLT formula is the only known product in the world capable of being balanced on dynamic spin balancers The PLT formula offers excellent protection for cars and light trucks against punctures from objects up to 1 8 3 2 mm in diameter e Motorcycle Formula A high speed formulation for motorcycles dirtbikes and scooters e Ride On TPS for Bikes Bike On Designed especially for bicycles REGULAR DUTY amp SEVERE DUTY Our Dosage Tables include columns for Regular Duty and Severe Duty dosages The Regular Duty dosages are prescribed for vehicles operating in normal conditions i e vehicles used in non extreme or mostly on road environments The Severe Duty dosages are recommended if a vehicle is expected to encounter a large number of puncturing objects i e construction vehicles vehicles operating in landfills street sweepers etc For vehicles in dual use highway and off road conditions i e trash hauler
51. tion 02 Units oz Units 286 265 50 14 CHS 17 21 287 23X8 50 14 HDOTR 29 36 288 24X8 50 14 HDOTR 38 57 289 25X8 50 14 HDOTR 33 50 290 27x8 5 14 CHS 16 20 291 27x9Rx14 ATV CHS HDOTR 22 28 292 27x11Rx14 ATV CHS HDOTR 26 33 293 294 7 14 5 MH CHS 13 16 295 8 14 5 MH CHS 15 19 296 9 14 5 MH CHS 18 23 297 298 E78 15 TR CHS 13 16 299 F78 15 TR CHS 15 19 300 G78 15 TR CHS 15 19 301 H78 15 TR CHS 17 21 302 2 5 15 HDOTR 41 62 303 3 00 15 HDOTR 58 87 304 4 00 15 HDOTR 19 29 305 5 00 15 HDOTR 24 36 306 5 70 15 HDOTR 27 41 307 5 90 15 25 38 308 6 00 15 32 48 309 6 40 15 27 41 310 6 70 15 29 44 311 6 70 15 LT CHS 15 19 312 7 00 15 HDOTR 44 66 313 7 00 15 LT CHS 16 20 314 7 50 15 HDOTR 50 75 315 7 50 15 CHS 19 24 316 7 60 15 HDOTR 34 51 317 7 75 15 CHS 14 18 318 8 25 15 HDOTR 57 86 319 8 25 15 CHS 22 28 320 8 55 15 CHS 17 21 321 9 00 15 HDOTR 68 102 322 9 00 15 CHS 25 31 323 9 5L 15 HDOTR 52 78 324 10 00 15 HDOTR 76 114 325 10 00 15 CHS 27 34 326 11 00 15 HDOTR 83 125 327 11 00 15 CHS 31 39 328 12 5L 15 HDOTR 63 95 329 14 50 15 HDOTR 95 143 330 250 15 HDOTR 52 78 331 300 15 HDOTR 72 108 332 25X7 50 15 HDOTR 34 51 333 25X10 50 15 HDOTR 41 62 334 25X12 50 15 HDOTR 55 83 335 27X8 50 15 HDOTR 40 60 336 27X9 50 15 HDOTR 44 66 337 27X10 50 15 HDOTR 50 75 338 28X9 15 HDOTR 44 66 339 28X12 15 HDOTR 62 93 340 28X13 15 HDOTR 67 101 341 29X8 15 HDOTR 42 63 342 29x9 5 15 LT CHS 19 24
52. tire repair or replacement expenses or for any claims or damages including any special incidental or consequential damages or any damage to tires wheels vehicles drivers passengers or any other entities or property arising from operating a vehicle failing to inspect or maintain tires properly or failing to follow instructions for the proper handling of punctures and other damage to tires Re How often should the wheel balance be checked A Ride On TPS is designed to hydrodynamically balance tire wheel assemblies thus reducing tire imbalance and vibrations These vibrations increase the tire s operating temperature and promote irregular tread wear This feature is especially useful for fleets that do not balance the tires on their Class 3 8 vehicles and trailers Many trucking fleets are switching from conventional tire balancing powders to Ride On TPS to help them balance their truck tires and to help them with their pressure maintenance programs Our long haul customers have reported tire life improvements of up to 25 or more Q Can Ride On TPS be used only in new tires A No Ride On TPS can be used in new and old tires Q Can Ride On TPS plug the tire valve as itis being inserted A Very Rarely Sometimes when Ride On TPS is being pumped into the tire the fibers used to seal punctures will enter the valve stem opening in such a manner as to create a blockage If this occurs remove the connector
53. use It is recommended that containers of product be stored indoors or out of direct sunlight Precautions should be taken when lifting containers to prevent injury Empty containers should be cleaned thoroughly of product residues prior to reuse 8 EXPOSURE CONTROLS PERSONAL PROTECTION Eye Protection Chemical splash goggles in compliance with OSHA regulations are advised however OSHA regulations also permit other type of safety glasses Consult your safety representative Skin Protection Harmful effects are not expected from this route of exposure under normal conditions of handling and use However as part of good industrial hygiene practices wear resistant gloves such as neoprene nitrile rubber natural rubber and polyvinyl chloride Respiratory Protection Harmful effects are not expected from this route of exposure under normal conditions of handling and use Exposure Guidelines Component ETHYLENE GLYCOL 107 21 1 OSHA VPEL 50 000 ppm Ceiling ACGIH TLV 50 000 ppm Ceiling vapor and mist Material Safety Data Sheet MSDS Inovex Industries Inc Page 4 5 Date Prepared 03 03 2003 Date Printed 2 10 2006 MSDS No 022703 001 001 RIDE ON TIRE PROTECTION SYSTEM TPS TIRE SEALANT PHYSICAL AND CHEMICAL PROPERTIES Boiling Point Greater than 250 121 Vapor Pressure N A Specific Vapor Density N A Specific Gravity 1 06 1 10 H20 1 Percent Volatile No Data Evaporation Rate Not Data State Liqui
Download Pdf Manuals
Related Search