NTB93-051
Contents
1. as 9 11 Parts Location Affected Meter Cluster And Ventilator Duct SYMPTOM Buzzing noise develops around the instrument panel while driving REPAIR INFORMATION Repair the looseness of the ventilator ducts and their shut valve linkages according to the following procedures Tools Required Screwdriver Silicone Grease Permatex Dielectric Grease P N 67VR or equivalent Method 1 Remove the steering column cover lower instrument cover switch panel and cluster lid A 2 Tighten screws securing cluster lid A and the ventilator duct 3 Apply silicone grease to the ventilator shut valve linkages and the shafts inside and outside of the shafts 4 Install any parts removed Cluster lid A Ventitator grile EZ Apply silicone grease 3 BEES Apply silicone grease Ventilator duct 10 11 Parts Location Affected Glove Box SYMPTOM A buzzing noise develops in the vicinity of the glove box while driving REPAIR INFORMATION Wrap the electrical harness for the glove box lamp with Foam Tape to insulate the harness from contact with the glove box Tools Required 3M 1 4 Black Vinyl Foam Tape P N 051131 06370 or equivalent Method 1 Remove the glove box from the instrument panel 2 Wrap 3M 1 4 Black Vinyl Foam Tape P N 051131 06370 or equivalent around the part of the harness that contacts the glove box 3 Install the glove box in2. is operating 7 Instrument panel While driving Buzz 8 Glove box While driving Buzz 2 11 Locations Of Noise Numbers preceding noises correspond with those shown in the table on the previous page 3 11 Parts Location Affected Rear Air Outlet Grille SYMPTOM Squeaking noise develops around the rear window and rear parcel shelf trim while driving REPAIR INFORMATION Parts required Non Woven Cloth Tape P N 68239 13E00 Method Using the following procedures repair the looseness of the air outlet grille with the rear parcel shelf trim and the contact between the air outlet grille and the rear window 1 Remove the air outlet grille from the rear parcel shelf trim 2 Apply non woven cloth tape to the ribs and clips of the air outlet grille 3 Install the air outlet grille to the rear parcel shelf trim NOTE Make sure that the rear of the air outlet grille is secured Locations Of Noise 1 3 Air outlet griile Air outlet grille Panel 2 Air outlet grille Air outlet grile 4 11 Parts Location Affected Rear Parcel Shelf Trim Clip SYMPTOM Buzzing noise develops around the rear parcel shelf trim while driving REPAIR INFORMATION Parts Required Non Woven Cloth Tape P N 68239 13E00 Knife Method 1 Remove the rear seat and the rear parcel shelf trim 2 Remove clips from the rear parcel shelf trim 3 Apply the non woven cloth tape on to the clip bosses 4 Using a knife cu
3. r nut plate and the rear panel twist the rear parcel panel with the screwdriver NOTE Do not deform the panel 3 Install the rear panel shelf trim and the rear seat into the vehicle Rear parcel panel Child seat anchor nut plate 7 11 Parts Location Affected Roof Panel Around Sun Roof SYMPTOM Creaking noise develops while driving from the roof panel around the sunroof REPAIR INFORMATION Tools Required Screwdriver flat blade Method 1 Remove the sunroof glass from the vehicle 2 Insert a screwdriver between the roof panel and body reinforcement twist the screwdriver a little at both sides of the sunroof NOTE Be careful not to damage the roof panel 3 Install the sunroof glass Section A A Roof panel Roof panel JH GUNG A Ormin Reinforcement Screwdriver 8 11 Parts Location Affected Sun Roof Glass Weatherstrip SYMPTOM While the sunroof is opening or closing a squeaking noise develops between the sun roof glass weatherstrip and the roof panel REPAIR INFORMATION Tools Required 3M Squeak Reduction Tape P N 5430 or equivalent Method 1 Open the sunroof fully 2 Apply 3M Squeak Reduction Tape P N 5430 or equivalent to the contact surface between the roof panel and sunroof glass weatherstrip as illustrated below Section A A Roof panel Slip tape Paste tape below the comer of roof panei Slip tape Sun roof glass A LLL a EN Z TLA EE
4. t a hole in the tape for the clip 5 Install clips on the bosses NOTE Make sure there is no looseness between the clip and the boss 6 Install the rear parcel shelf trim and the rear seat into the vehicle 3 4 Rear parcel ve shelf trim Rear parcel sheif trim 5 11 Parts Location Affected Electronic Control Stereo Amplifier And Its Bracket SYMPTOM Buzzing noise develops around the rear window while driving REPAIR INFORMATION Parts Required Non Woven Cloth Tape P N 68239 13E00 Method 1 Remove the rear seat and the rear parcel shelf trim 2 Remove the electronic control stereo amplifier with its bracket from the rear parcel panel Tighten down the screws securing the amplifier and its bracket Apply the non woven cloth tape to the contact surface between the rear parcel panel and the amplifier bracket Install the amplifier together with its bracket Install the rear parcel shelf trim and the rear seat into the vehicle Foo D o Electronic control amplifier and its bracket its bracket Electronic control amplifier and gt Taa 6 11 Parts Location Affected Child Seat Anchor Nut Plate And Rear Parcel Panel SYMPTOM Clicking noise develops in the vicinity of the rear panel while driving REPAIR INFORMATION Tools Required Screwdriver flat blade Method 1 Remove the rear seat and the rear parcel shelf trim 2 Insert a screwdriver between the child seat ancho
5. to the instrument panel CLAIMS INFORMATION Please consult the applicable Main Sub Code section of the appropriate 1991 or 1992 93 Nissan Flat Rate Manual Select the proper warranty coding PNC OpCode FRT that reflects the noise reduction repair s as performed 11 11
6. yO NISSAN NORTH AMERICA INC NISSAN Copyright SERVICE BULLETIN Classification BF93 010 NTB93 051 March 9 1993 MAXIMA REDUCING SQUEAK AND RATTLE NOISE APPLIED VEHICLE S 1989 93 Maxima J30 SERVICE INFORMATION The following repair procedures should be used to diagnose and repair squeaks and rattles some of which may be found in the Maxima J30 When removing the components identified be certain to follow all NOTES and CAUTIONS found in the BF Section of the 1993 Maxima J30 Service Manual Also before applying tape be certain to clean surfaces with a degreaser solvent such as Permatex Plastic Cleaner P N 403D 3M Prep Sol 70 or equivalent SERVICE PROCEDURE Service Materials e Vinyl Electrical Tape 3M Super 33 Tape P N 054007 06133 or equivalent in temperature and moisture performance e Silicone Grease Permatex Dielectric Grease P N 67VR or equivalent e Non Woven Cloth Tape Nissan P N 68239 13E00 e Slip Tape 3M Squeak Reduction Tape P N 5430 e Foam Tape 3M 1 4 Black Vinyl Foam Tape P N 051131 06370 or equivalent 1 11 Locations Of Noise No Location of Noise Condition Noise Type 1 Around rear window While driving Squeak parcel shelf trim 2 Around rear parcel shelf trim While driving Buzz 3 Around rear window While driving Buzz 4 Around rear parcel panel While driving Click 5 Roof panel around sun roof While driving Creak 6 Sun roof While sun roof Squeak glass
Download Pdf Manuals
Related Search
NTB93 051