(2) Tandem Gravel Trucks with Cab, Box and Hoist, Sander and Plow
Contents
1. 1 4 bolt circle HUBS Rear ferrous BRAKES Rear Meritor S Cam 16 5 x 7 Q BRAKE DRUMS Rear cast outboard mounted DUST SHIELDS Rear brake furnish OIL SEALS Stemco Voyager FACTORY OPTION W o brake chamber position SHOCK ABSORBERS 4 outboard mounted on forward and axles each side SLACK ADJUSTERS Rear Rockwell automatic SUSPENSION Axle spacing 52 to 55 SPRING BRAKE CHAMBERS Quantity 4 double diaphragm type mechanical spring release 2 mounted on each axle life time SPRING BRAKE CHAMBERS Vendor MGM Model TR T tamper resistent SPRING BRAKE CHAMBERS Type 30 30 rear lifetime TRANSVERSE TORQUE RODS Both Axles LOCKING INTER WHEEL DIFFERENTIALS Driver controlled manual air valve w warning light both rear axles 10 0 AIR BRAKE AIR LINES CHASSIS Extruded nylon tubing 1 8 and 1 4 lines are single extrusion 3 8 and larger have polyester reinforced center AIR BRAKE SYSTEM Dual AIR CONTROL VALVES Vendor Bendix switches and valves where possible AIR DRYER Meritor System Saver 1200 P heated air dryer AIR RESERVOIRS Steel ANTI LOCK BRAKE SYSTEM Meritor without traction control BRAKE CONTROL VALVE SYSTEM Two 2 valve dual brake system trailer supply and tractor trailer park HAND CONTROL VALVE For trailer brakes MANUAL DRAIN VALVE LANYARD Lanyard control on supply wet tank TRAILER CONNECTIONS Full to rear of chassis includes 2 air lines and 1 seven wire cable w seven wire plug routed t2. GAUGE Fuel level GAUGES Metric roadspeed in lbs for other gauges GAUGE Speedometer w trip odemeter electronic 1 accuracy GAUGE Engine tachmometer electronic with hour meter GEAR SHIFT Dash mounted shifter auto trans push button GLASS Cab window safety tinted windshield side and rear windows GRAB HANDLES Aluminum RH and LH behind door GRILLE Silver painted w o grille surround HEADLAMP BEZEL Molded plastic argent paint HOOD AND FENDERS One piece w wheel splash aprons tilts forward 75 degrees w 2 springs assist SMC sheet molding compound HORN Air 1 HORN Electric single tone IDENTIFICATION CLEARANCE 5 marker and clearance INSTRUMENT PANEL Gray with black gage bezel INTERIOR TRIM CUSTOM FEATURES Padded vinyl headliner with integral overhead header console with storage rear panel with storage pouch black rubber floor mats with closed cell nitrile backing Dash panel and firewall covering cup holder charcoal gauge panel with black bezals Light saddle door insert panel LH and RH sun visor saddle driver s seat with vinyl sides and full fabric seat and back riders seat and tilt telescope steering column and peep window CHASSIS KEYED AT RANDOM 2 keys LOW PRESSURE INDICATOR LIGHT AND BUZZER MIRROR BRACKETS Extended for 102 width trailers MIRRORS Exterior west coast RH and LH bright finish heated MIRRORS Convex type bright finish LH and RH 8 0 dia heated mounted below lower arm of west coa
3. MOTOR VEHICLE SAFETY ACT If Applicable Vehicles shall meet the provisions of the Act and the regulations made thereunder which are in effect on the date of the manufacture of each vehicle 24 0 NATIONAL SAFETY MARK If Applicable Vehicles shall have this affixed to the vehicle Vehicles that do not bear this mark will not be accepted 25 0 DEALER INFORMATION Manuals pedigreed protection plan tech service manual provided Pilot inspection Install AB Gov t inspection sticker includes Fire ext Flares first aid kit Clean detail complete Fleet Pre delivery inspection un decking and check in Supply and install 2 dual rotating beacon lites with chrome brackets Supply and install 2 mount snow plow lights on hood Standard shipping instructions 26 0 PERFORMANCE GRAPHICS TECH DATA Ambient temperature 77F 25 0C Back of cab interferences vertical exhaust 9 228 mm from back of cab consists of 6 boc to rear edge of muffler and 3 for cab motion clearance 27 0 DELIVERY DATE F O B Delivery Didsbury Mountain View County requires delivery within 90 days from awarding of tender State delivery date in quantitative number of weeks days 28 0 OTHER REQUIREMENTS SERVICING Units must be fully serviced prior to delivery so that they may be put into service immediately upon receipt by the purchaser Vendors shall correct any faults in material or workmanship which may become evident during the purchasers inspection If the c
4. WRAP VEHICLE OVERSPEED All conditions 75 mph VEHICLE OVERSPEED Fueled only 75 mph ENGINE OVERSPEED Severe 2350 rpm ENGINE OVERSPEED All conditions 2150 rpm ENGINE OVERSPEED Fueled only 1850 rpm IDLE LOGGING DELAY 2 min PART II SANDER AND PLOW 14 0 GENERAL PLOW Variable controlled angle two way hydraulic 12 feet wide 42 inches high minimum Adjustable verticle angle to road surface to accommodate carbide blades 90 Adjustable screw type skid shoes Full safety trip with adjustable spring tensioners Quick detach with front plate supplied and installed Parts Book Paper to Be Supplied Price separately and in detail 15 0 COMPLETE TURN KEY HYDRAULIC PACKAGE Complete mounting package to be mounted on truck of our choice tandem gravel extended frame Package will include piston pump valving hoses and controls for plow sander and box hoist Controller to be mounted inside cab on pedestal at right side of driver s seat Would prefer to use only one 1 front mount pison pump for plow sander and box hoist cylinder Controller to match Prefer Compo tech AS3 Specify requirements of GPM etc so proper pump and tank may be supplied Page 7 Mountain View County PART Ill BOX AND HOIST 16 0 GRAVEL BOX Gravel box to be proposed to supply mounted on chassis 15 foot 34 sides plus sideboards 1 4 HD floor plate AR200 Controller integral with hydraulic package Large capacity hydraulic tank 50 gallon Manual box tar
5. package 3 0 ENGINE TRANSMISSION ENGINE 500 HP min 1950 RPM 1850 lb ft max torque 1400 RPM TRANSMISSION 6 speed automatic Allison 4500 RDS 6 4 70 0 67 rugged duty series includes transmission cooler external oil cooler internal filter and oil level sensor Page 1 Mountain View County YES NO Alternative or Substitute 4 0 ENGINE EQUIPMENT AIR COMPRESSOR Meritor Wabco 318 18 7 CFM AIR CLEANER 11 x 30 279 mm x 762 mm under hood single element dry type w air intake from both sides of hood Bendix Westinghouse air governor MTD on firewall AIR INTAKE Inside outside w in cab control ALTERNATOR Delco 12V 145A 24Sl BATTERIES 3 950 CCA Batteries Total 2850 CCA COOLANT PROTECTION To below 40 degrees fahrenheit 40 degrees celsius coolant conditioner COOLING PERFORMANCE Standard cooling performance ENGINE BRAKE Jacob ENGINE BLOCK HEATER Gomack Phillips 1000 1500 Watt 110 Volt ENGINE HOSES AND TUBING Silicone does not include heater and radiator hoses EXHAUST Single vertical exhaust w curved stack Poly v fan belt with automatic tensioner FAN DRIVE Horton On Off water sensing with plastic fan blades FLYWHEEL HOUSING Lightweight aluminum FUEL WATER SEPARATOR Manual drain valve integral w primary fuel filter Hand primer fuel pump HOSES Radiator heater gates blue stripe RADIATOR Copper core front PTO provision SERVICE INTERVAL Lube oil system ESI plus w two spin on full flow oil filters w centri
6. Mountain View County Request for Proposal to Supply Two 2 Tandem Gravel Trucks with Cab Box and Hoist Sander and Plow VENDOR DATE REQUEST FOR PROPOSAL NO 9 2015 SPECIFICATIONS YES NO Alternative or Substitute VEHICLE Tandem Gravel Trucks Box and Hoist Sander amp Plow QUANTITY 2 PART TANDEM GRAVEL TRUCKS WITH CAB 1 0 ORDER CUSTOMER VEHICLE INFORMATION INITIAL REGISTRATION LOCATION Canada Alberta TYPE OF SERVICE Municipal VEHICLE APPLICATION CLASS Vocational Class C Unlimited operation on concrete asphalt or maintained gravel packed dirt with a maximum 3 grade limited operation on unmaintained surfaces with maximum 5 grade limited operation on concrete asphalt or maintained gravel packed dirt with maximum 8 grade 3 Axles 78000 Max GVW CARRIER APPLICATION Not available VEHICLE TYPE Straight Truck VEHICLE USE AND BODY TYPE Snow Plow On Off Hwy COMMODITIES Gravel FILE STATUS Quote 2 0 BVS FRT AXLE POS WHEELBASE PLATFORM CHASSIS BASE MODEL Rear Tandem FRAME RAILS 10 625 x 3 25 x 3125 5 16 main rail minimum Steel constant section combined rating w inside channel reinforcement Section Modulus 23 79 cu in RBM 2 854 800 in lbs per rail WHEELBASE Concern for exhaust stack amp 15 foot gravel box PLATFORM 196 LP 4978 mm 65 AF 1651 mm used with 210 WB FRAME REINFORCEMENT Inside 1 4 full length of main rail ext to front extension snow plow extension provision and snow
7. lack urethane PAINT Front wheels without optional spoke wheel paint FRONT WHEELS Pre finished silver white or black REAR WHEELS Pre finished silver white or black 13 0 VEHICLE ELECTRONICS ROAD SPEED LIMIT RSL 75 mph LOWER GEAR ROAD SPEED LIMIT LGRSL 65 mph LOWER GEAR ROAD LIMIT TRANS RATIO 0 67 MAXIMUM CRUISE CONTROL SPEED 70 mph MINIMUM CRUISE CONTROL SPEED 35 mph ENGINE BRAKE DELAY IN CRUISE Furnish ENGINE BRAKE ENGAGEMENT DELAY IN CRUISE 2 mph ENGINE BRAKE DISENGAGMENT DELAY IN CRUISE INHIBIT CRUISE CONTROL WITH PTO ON Furnish CRUISE CONTROL AUTO RESUME Furnish GOVERNOR SETTINGS GOVERNOR TYPE HIGH IDLE max no load RPM 2100 rpm ENGINE OVERSPEED FAULT THRESHOLD 2350 rpm LOW IDLE min no load RPM 650 rpm TAMPER RESISTANCE Page 6 Mountain View County YES NO Alternative or Substitute DETECT LOSS OF SIGNAL FROM MPH SENSOR Furnish LIMIT POWER IF NO MPH SENSOR SIGNAL Furnish ENGINE LOAD THRESHOLD FOR NO MPH SIGNAL Fault FAILED MPH SENSOR ENGINE POWER LIMIT HAND THROTTLE CONTROL ELECTRONIC HAND THROTTLE EHT EHT Maximum road speed 10 mph EHT Engine speed limit 2100 rpm EHT Maximum set speed 2100 rpm EHT Minimum set speed 625 rom EHT Ramp rate rpm second EHT Single speed control rom 625 rpm EHT Single speed control SSC Omit ENGINE PROTECTION SYSTEM Engine shutdown and warning w manual override switch COOLANT TEMPERATURE SHUTDOWN Furnish OIL PRESSURE SHUTDOWN Furnish DATA SAVE MODE
8. max centrifugal oil filter extended service interval Starter 12 volt gear reduction starter 5 0 TRANSMISSION EQUIPMENT DRIVELINES TRANSMISSION BELL HOUSING Aluminum Trans oil cooler SYNTHETIC LUBRICANT Transmission transynd synthetic lube for Allison trans VOCATIONAL PACKAGE Allison Allison vocational pkg 99113 rugged duty series RDS on off highway DRIVELINE Main meritor 17N HD w coated splines DRIVELINE Interaxle meritor 17N HD w coated splines 6 0 CAB INTEGRAL W heater combination heavy duty heater defroster conditioner AIR CONDITIONING COMPRESSOR Rotary freon AIR RESTRICTION MONITOR INTAKE Graduated lock up type w memory dash mounted CAB Conventional welded steel galvanized shell includes rust preventative procedures CAB MOUNTIN Air suspension CERTIFIED WEIGHT COAT HOOK 1 on rear wall behind rider s seat DRIVER S CUPHOLDERS Page 2 Mountain View County YES NO Alternative or Substitute DASH MOUNTED SWITCHES 6 additional switches DOME LIGHT 1 w self contained switch DOOR INTERIOR TRIM PANELS Padded vinyl ENGINE SHUTOFF Key type FENDER EXTENSIONS FLOOR COVERING Black rubber mats w closed cell vinyl nitrile foam backing GAUGE Air pressure GAUGE Voltmeter GAUGE CLUSTER Exhaust pyrometer engine transmission oil temperature manifold pressure and air application gauges air bag pressure for weight estimates GAUGE Engine coolant temperature GAUGE Engine oil pressure
9. o rear of chassis breakaway safety valve and 2 valve system tractor park tractor trailer park and supply Page 5 Mountain View County YES NO Alternative or Substitute 11 0 ELECTRICAL BACK UP ALARM Ecco back up alarm 575 constant sound level BATTERY BOX ES Steel BATTERY BOX COVERS Polished aluminum BATTERY BOX Mounting single L H Battery box standard location BATTERY DISCONNECT SWITCH W rotary handle in cab on floor between driver s seat and door CAB DOME With switch DAYTIME RUNNING LIGHTS DOUBLES TRAILER ELECTRICAL PACKAGE INCLUDES 12 gauge wire for turn signals 12 gauge wire and 20 amp circuit w relay for clearance and marker lamps 10 gauge wire and 20 amp circuit for stop lamps 12 gauge wire and 20 amp circuit w relay for tail lamps and 8 guage wire for ground ELECTRIC CIRCUIT PROTECTION PACKAGE 12 volt w fuses except headlamp and windshield wiper circuits utilize circuit breakers BODY LINK Body builder electrical interface HEADLIGHTS Halogen 7 round w integral turn signal HEADLIGHTS Auxiliary dash control and power supply for aux headlights includes 24 wiring tied to grill snow plow lights supplied and mounted REAR LIGHTING Standard tail lights SIGNAL FLASHER TYPE Transistorized flasher for turn signal WIRING Furnish electrical schematic only illustrate chassis spec 12 0 PAINT PAINT Cab urethane base coat w o clear coat white PAINT Cab interior tan on grey PAINT Chassis running gear b
10. orrections have to be made in the supply dealerships repair shops the dealer is responsible for the cost of transportation of the units to and from place of delivery SERVICE WARRANTY Warranty shall be the responsibility of the vendor or the manufacturer or both R F P s shall state the duration of the warranty period Page 9 Mountain View County YES NO Alternative or Substitute R F P s shall include a copy of the Warranty Statements including any conditions or limitations with the R F P R F P s shall indicate whether optional extended warranties are available and the costs for TYPE Bumper to Bumper 12 Months Unlimited TYPE Standard Extended Powertrain DESCRIPTIVE LITERATURE Detailed descriptive literature of the equipment as tendered shall accompany the submission PRICE Price shall be quoted F O B Didsbury CASH PRICE Per unit no trade F O B Didsbury GST Other Taxes Charges specify TOTAL CANADA MOTOR VEHICLE SAFETY ACT Vehicles shall meet the provisions of the Act and the regulations made thereunder which are in effect on the date of the manufacture of each vehicle NATIONAL SAFETY MARK Vehicles shall have this affixed to the vehicle Vehicles that do not bear this mark will not be accepted Page 10
11. p cover driver s side Tailgate inside skinned flat 17 0 DELIVERY DATE State delivery date in quantitative number of weeks days 18 0 SERVICING Vehicles must be fully serviced prior to delivery so that they may be put into service immediately upon receipt by the purchaser Vendors shall correct any faults in material or workmanship which may become evident during the purchasers inspection If the corrections have to be made in the supply dealerships repair shops the dealer is responsible for the cost of transportation of the vehicles to and from place of delivery 19 0 SERVICE WARRANTY Warranty shall be the responsibility of the vendor or the manufacturer or both RFP shall state the duration of the warranty period in Months RFPs shall include a copy of the Warranty Statements including any conditions or limitations with the RFP RFP shall indicate yes or no whether optional extended warranties are available and the costs TYPE TYPE Documentation on warranty options are to be included with RFPs submissions 20 0 DESCRIPTIVE LITERATURE Detailed descriptive literature of the equipment as in the RFP shall shall accompany the submission 21 0 PRICE Price shall be quoted F O B Didsbury 22 0 CASH PRICE Per unit no trade F O B Didsbury GST Other Taxes Charges specify TOTAL Page 8 YES NO Alternative or Substitute Mountain View County YES NO Alternative or Substitute 23 0 CANADA
12. st mirror PARKING BRAKE On indicator light POWER OUTLETS Two additional 12 volt supplementary RADIO ACCOMMODATION PKG Includes antenna power supply and two speakers RADIO ANTENNA Cab mounted behind LH door AM FM RADIO Mounted Page 3 Mountain View County YES NO Alternative or Substitute POWER LEADS 5 way binding posts for CB radio mounted on top of dash REAR WINDOW Fixed type SEAT Driver bostrom talladega 915 hi back air suspension SEAT Rider fixed mid back non suspension enclosed storage under seat SEAT ARM RESTS Inboard mounted arm rest driver s seat only SEAT COVERING Cloth vinyl trim driver and rider SEATBELTS RETRACTORS Lap and shoulder w cab mounted shoulder belt w adjustable d ring for driver and rider seats W O roof vent ventilation SIDE MARKERS Lamps and reflectors STARTER SWITCH Key type STEERING COLUMN Adjustable tilt telescope STEERING WHEEL 18 two spoke w soft feel black Urethane rim finish STORAGE ACCESSORIES Padded vinyl with header storage shelf with door DISPATCH BOX MTD on back panel SUN VISOR Exterior fiberglass cab color SUN VISOR Interior both sides padded vinyl TURN SIGNALS Front integral with fender WINDOW CONTROLS Power windows and door locks both sides WINDSHIELD WASHERS Electric wiper mounted w reservoir mounted under hood WINDSHIELD WIPERS 2 speed electric motor w intermittent feature 7 0 FRAME EQUIPMENT FUEL TANKS BUMPER Front s
13. wept back steel channel ext 113 2870 mm BBC 92 6 W x 10 0 H CROSSMEMBERS Back of cab Boc steel rolled flange Il beam Without fifth wheel mounting angles FRONT FRAME EXTENSION 20 extension of parent frame for snow plow mount TOWING DEVICE Front hooks FUEL TANK LH 55 gallon 22 diameter steel FUEL TANK RH 55 gallon 22 diameter steel 8 0 FRONT AXLE EQUIPMENT TIRES FRONT AXLE 20 000 Ib front axle TIRES BRAND TYPE Front Goodyear tubeless radial ply 2 315 80R22 5 18 J G291 Unisteel all pos WHEELS Front steel disc 10 hole 2 22 5 x 12 25 accuride 10 hole hub piloted 11 1 4 286mm BC HUBS Front ferrous BRAKES Front Meritor S Cam type 16 5 X 5 Q BRAKE DRUMS Front cast outboard mounted BELLY BAND Front spring rear bracket crossmember DUST SHIELDS Front brake furnish OIL SEALS Front wheels stemco voyager Page 4 Mountain View County YES NO Alternative or Substitute SHOCK ABSORBERS Front SLACK ADJUSTERS Front Rockwell automatic SPRINGS Front multileaf 20 000 lbs ground load rating STEERING M110P 9 0 REAR AXLE EQUIPMENT TIRES RATIOS REAR AXLE SUSPENSION 48000lb 20866kg Meritor RT46 160 single reduction W PDLO air 48000lb capacity TIRES BRAND TYPE Rear Goodyear tubeless radial ply 8 11R22 5 14 G G164 RTD unisteel traction CARRIER RATIO Rear axle malleable housing 4 56 ratio WHEELS Rear steel disc 10 hole 8 22 5 x 8 25 210 mm Accuride 10 hole hub piloted 11
Download Pdf Manuals
Related Search