4764 PCI-X Cryptographic Coprocessor Installation Manual
Contents
1. vii viii 4764 PCI X Cryptographic Coprocessor Installation Manual Safety and environmental notices Safety notices Safety notices may be printed throughout this guide DANGER notices warn you of conditions or procedures that can result in death or severe personal injury CAUTION notices warn you of conditions or procedures that can cause personal injury that is neither lethal nor extremely hazardous Attention notices warn you of conditions or procedures that can cause damage to machines equipment or programs The following DANGER notice appears in this manual DANGER To avoid a shock hazard Do not connect or disconnect any cables or perform installation maintenance or reconfiguration of this product during an electrical storm e Connect all power cords to a properly wired and grounded electrical outlet Ensure outlet supplies proper voltage and phase rotation according to the system rating plate Connect any equipment that will be attached to this product to properly wired outlets When possible use one hand only to connect or disconnect signal cables Never turn on any equipment when there is evidence of fire water or structural damage Disconnect the attached power cords telecommunications systems networks and modems before you open the device covers unless instructed otherwise in the installation and configuration procedures Connect and disconnect cables as described below when installing2. battery disposal 9 replacement 7 tray 7 8 battery powered protected memory 1 7 C caution notices coprocessor 3 7 CCA cryptographic coprocessor support program 2 certified device key coprocessor 1 contents battery replacement kit 7 coprocessor package 1 coprocessor See PCI X cryptographic coprocessor D device key certified 1 dimensions coprocessor 2 E electrostatic discharge ESD 3 8 H handling considerations coprocessor 1 hardware requirements coprocessor 2 humidity See operating environment installing coprocessor 3 J jumper settings 5 K kit contents battery replacement 7 M memory See battery powered protected memory module tamper resistant 1 N notices notices statement 11 O operating environment environmental specifications 2 power requirement 2 P package contents 1 PCI X cryptographic coprocessor caution notices 3 7 device key certified 1 dimensions 2 environmental specification 2 handling considerations 1 hardware requirements 2 installation 3 introduction to 1 package contents 1 power requirement 2 process objects 1 shipping 1 software 2 specifications 2 storage 1 support program 2 tamper sensors 1 temperature 1 power on self test POST 5 9 power coprocessor See also operating environment active mode 2 voltage 2 process objects coprocessor bulk data 1 certificates 1 cryptographic keys 1 protected memory See battery powered protected memory
3. and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver e Connect the equipment into an outlet on a circuit different from that to which the receiver is connected Consult an IBM authorized dealer or service representative for help IBM is not responsible for any radio or television interference caused by unauthorized changes or modifications to this equipment Unauthorized changes or modifications could void the user s authority to operate this equipment This device complies with Part 15 of the FCC rules Operation is subject to the following two conditions 1 this device may not cause harmful interference and 2 this device must accept any interference received including interference that may cause undesired operation 12 4764 PCI X Cryptographic Coprocessor Installation Manual Industry Canada compliance statement This digital apparatus does not exceed the Class B limits for radio
4. 2 Jumpers on the PCI X cryptographic coprocessor back side Table 2 Jumpers on the PCI X cryptographic coprocessor Jumper Number of Name of jumper Position when shipped pins J7 2 PCI X EEPROM write Shipped with jumper installed J8 2 External intrusion latch disable Shipped with jumper installed J9 2 Battery disconnect wire Shipped with jumper wire loop installed J10 3 keyed Temporary battery connector Shipped without jumper installed J11 5 External intrusion latch Shipped with jumper installed 9 10 Tt 12 13 Note Shipped with jumper installed means that the pins are connected Insert the coprocessor into the slot be sure the card is fully seated If you removed a cover from the expansion slots replace it Replace the host computer s cover Reconnect the power cable and any other cables you disconnected Turn the computer ON The PCI X cryptographic coprocessor runs its power on self test POST You have completed the procedure for the physical installation of the PCI X cryptographic coprocessor Refer to the support software documentation for information about initializing and using the coprocessor Chapter 2 Installing the coprocessor 5 6 4764 PCI X Cryptographic Coprocessor Installation Manual Chapter 3 Replacing IBM PCI X cryptographic coprocessor batteries This section describes the way to replace the batteries on the IBM 4764 001 PCI X Cryptographic Coprocessor Tw
5. all data in the protected memory destroying the device key The PCI X cryptographic coprocessor cannot operate without the device key To protect the key follow these guidelines Temperature Do not expose the coprocessor to temperatures below 15 degrees C 5 degrees F or temperatures above 60 degrees C 140 degrees F Batteries Do not remove battery power from the coprocessor Data in the protected memory is lost when battery power is removed For information about replacing the batteries without erasing the protected memory see Chapter 3 Replacing IBM PCI X cryptographic coprocessor batteries Requirements and specifications Hardware requirement The coprocessor must be installed in an IBM eServer xSeries approved server with a PCI X Version 1 0 bus slot available No additional hardware or cabling is required Notes 1 The 9 pin D shell port is for development use only It is not intended for customer use 2 The ethernet port is blocked It is not intended for customer use Software requirement The coprocessor requires support software for example the IBM 4764 CCA Support Program for both the host machine and for its internal firmware Operating system support is determined by the support software This publication does not discuss the installation of support software For information about the latest software features available visit the product Web site at http www ibm com security cryptocards Powe
6. for reuse recycling or proper disposal of used IBM sealed lead acid nickel cadmium nickel metal hydride and other battery packs from IBM Equipment For information on proper disposal of these batteries contact IBM at 1 800 426 4333 Please have the IBM part number listed on the battery available prior to your call In Taiwan the following applies Please recycle batteries Revi Notice This mark applies only to countries within the European Union EU and Norway Batteries or packaging for batteries are labeled in accordance with European Directive 2006 66 EC conceming batteries and accumulators and waste batteries and accumulators The Directive determines the framework for the return and recycling of used batteries and accumulators as applicable throughout the European Union This label is applied to various batteries to indicate that the battery is not to be thrown away but rather reclaimed upon end of life per this Directive iy T U d Ult y T U RO vy r VIzI EU MRICS 5 BEERUE TES HT 2006 66 EC 2 SIAE dE mld vy T U tE 33 UB Vy FU EBEMIS SLOTS CORRIE RABAT LE OARE JHI TILOBFEEH SLOT EU MEI GER STi COAL BIBAT fc ER CO EZULE Y SEM 2 ED L R DT U I Mod CU Ed ot BE Li m Bio 4764 PCI X Cryptographic Coprocessor Installation Manual Les batteries ou emballages pour batteries sont tiquet s conform ment aux direc tives europ ennes 2006 66 EC norme relative aux batteries et
7. noise emissions from digital apparatus as set out in the interference causing equipment standard entitled Digital Apparatus ICES 003 of Industry Canada Avis de conformit aux normes d Industrie Canada Cet appareil num rique respecte les limites de bruits radio lectriques applicables aux appareils num riques de Classe B prescrites dans la norme sur le mat riel brouiller Appareils num riques NMB 003 dict e par industrie Canada Japanese Voluntary Control Council for Interference VCCI statement This equipment is in the 2nd Class category information equipment to be used in a residential area or an adjacent area thereto and conforms to the standards set by the Voluntary Control Council for interference by Information Technology Equipment aimed at preventing radio interference in such residential areas When used near a radio or TV receiver it may become the cause of radio interference Read the instructions for correct handling CORB HHUBRESERES BEMIS VCCI D E CHOC VPABRRMHEECT CORBIS CH c x EBICLTWET DREN IY APTLEY ay BIERICMELT HAENSe BERS SRO TCEMHVET RRR AAS CHE gt CIFL U ABU IRA G L C FSU Appendix Notices 13 14 4764 PCI X Cryptographic Coprocessor Installation Manual Glossary This glossary includes some terms and definitions from the BM Dictionary of Computing New York McGraw Hill 1994 This glossary also includes some terms and definitions from e The American National Sta
8. the procedures by which accredited organizations create and maintain voluntary industry standards in the United States A bus In a processor a physical facility along which data is transferred C card An electronic circuit board that is plugged into a slot in a system unit A plug in circuit assembly coprocessor A supplementary processor that performs operations in conjunction with another processor A microprocessor on an expansion card that extends the address range of the processor in the host system or adds specialized instructions to handle a particular category of operations for example an I O coprocessor math coprocessor or networking coprocessor cryptography The transformation of data to conceal its meaning In computer security the principles means and methods used to so transform data D Data Encryption Standard DES In computer security the National Institute of Standards and Technology NIST Data Encryption Standard adopted by the U S government as Federal Information Processing Standard FIPS Publication 46 which allows only hardware implementations of the data encryption algorithm driver A program that contains the code needed to attach and use a device E electrostatic discharge ESD An undesirable discharge of static electricity that can damage equipment and degrade electrical circuitry erasable programmable read only memory EPROM A PROM that can be erased by a special pro
9. 4764 PCI X Cryptographic Coprocessor Installation Manual tl Note Before using this information and the product it supports read the information inl Safety and environmental notices on page xland in Notices on page 11 Third Edition September 2008 This edition describes installation of the IBM 4764 PCI X Cryptographic Coprocessor IBM does not stock publications at the address given below This and other publications related to the IBM 4764 Cryptographic Coprocessor can be obtained in PDF format from www ibm com security cryptocards Readers comments can be communicated to IBM by using the support link on the product Web site at http www ibm com security cryptocards or by sending a letter to IBM Corporation Department VM9A MG81 Security Solutions and Technology 8501 IBM Drive Charlotte NC 28262 8563 USA When you send information to IBM you grant IBM a nonexclusive right to use or distribute the information in any way it believes appropriate without incurring any obligation to you Copyright International Business Machines Corporation 2005 2008 AlI rights reserved US Government Users Restricted Rights Use duplication or disclosure restricted by GSA ADP Schedule Contract with IBM Corp Contents Figures Tables Safety and environmental notices Safety notices World trade safety information Environmental notices Product recycling and disposal Battery return prog
10. R replacing batteries 7 S shipping coprocessor 1 softvvare coprocessor 2 specifications coprocessor environmental specifications 2 hardware 2 physical dimensions 2 power requirement 2 software 2 storage coprocessor 1 support program CCA cryptographic coprocessor 2 17 T temperature coprocessor continued shipping 1 tamper sensors coprocessor 1 storage 1 tamper resistant module 1 temperature coprocessor See also operating environment 18 4764 PCI X Cryptographic Coprocessor Installation Manual
11. a reciclar sus productos de TI Se puede encontrar informaci n sobre las ofertas de reciclado de productos de IBM en el sitio web de IBM htip www ibm com ibm environment products index shiml Notice This mark applies only to countries within the European Union EU and Norway Appliances are labeled in accordance with European Directive 2002 96 EC concerning waste electrical and electronic equipment WEEE The Directive determines the framework for the return and recycling of used appliances as applicable throughout the European Union This label is applied to various products to indicate that the product is not to be thrown away but rather reclaimed upon end of life per this Directive In accordance with the European WEEE Directive electrical and electronic equipment EEE is to be collected separately and to be reused recycled or recovered at end of life Users of EEE with the WEEE marking per Annex IV of the WEEE Directive as shown above must not dispose of end of life EEE as unsorted municipal waste but use the collection framework available to customers for the return recycling and recovery of WEEE Customer participation is important to minimize any potential effects of EEE on the environment and human health due to the potential presence of hazardous substances in EEE For proper collection and treatment contact your local IBM representative For the European Union AB 10 75 EU BHEKVYWYVI ICBWUTCTOABAENET OMAR IIL EU
12. accumulateurs en usage et aux batteries et accumulateurs us s Les directives d terminent la marche suivre en vigueur dans l Union Europ enne pour le retour et le recyclage des batte ries et accumulateurs us s Cette tiquette est appliqu e sur diverses batteries pour indiquer que la batterie ne doit pas tre mise au rebut mais plut t r cup r e en fin de cycle de vie selon cette norme In accordance with the European Directive 2006 66 EC batteries and accumulators are labeled to indicate that they are to be collected separately and recycled at end of life The label on the battery may also include a chemical symbol for the metal concerned in the battery Pb for lead Hg for mercury and Cd for cadmium Users of batteries and accumulators must not dispose of batteries and accumulators as unsorted municipal waste but use the collection framework available to customers for the return recycling and treatment of batteries and accumulators Customer participation is important to minimize any potential effects of batteries and accumulators on the environment and human health due to the potential presence of hazardous substances For proper collection and treatment contact your local IBM representative For California Perchlorate Material special handling may apply See hitp www dtsc ca gov hazardouswaste perchlorate The foregoing notice is provided in accordance with California Code of Regulations Title 22 Division 4 5 Chapter 33 Be
13. al standards bodies established to promote the development of standards to facilitate the international exchange of goods and services and to develop cooperation in intellectual scientific technological and economic activity J jumper K key In computer security a sequence of symbols used with an algorithm to encipher or decipher data P power on self test POST A series of diagnostic tests that are run automatically by a device when the power is turned on R random access memory RAM A storage device into which data is entered and from which data is retrieved in a non sequential manner A wire that joins two unconnected circuits read only memory ROM Memory in which stored data cannot be modified by the user except under special conditions Rivest Shamir Adleman RSA algorithm A process for public key cryptography developed by R Rivest A Shamir and L Adleman 16 4764 PCI X Cryptographic Coprocessor Installation Manual RS 232C A standard that defines the specific physical electronic and functional characteristics of an interface line that uses a 25 pin connector to connect a workstation to a communication device RSA algorithm Rivest Shamir Adleman encryption algorithm S security For computers the protection of data system operations and devices from accidental or intentional ruin damage or exposure Numerics 4764 IBM 4764 PCI X Cryptographic Coprocessor Index B
14. battery unit available vvhen you call C002 Your Replacement Battery Kit should include e Two good replacement batteries A battery tray with connecting wires Two sets of spare battery attention labels To replace the on board batteries follow these steps 1 Turn OFF the computer and all attached devices 2 Disconnect all cables including the power cable DANGER Electrical voltage and current from power telephone and communication cables are hazardous To avoid a shock hazard Do not connect or disconnect any cables or perform installation maintenance or reconfiguration of this product during an electrical storm e Connect all power cords to a properly wired and grounded electrical outlet Ensure outlet supplies proper voltage and phase rotation according to the system rating plate Connect any equipment that will be attached to this product to properly wired outlets When possible use one hand only to connect or disconnect signal cables Never turn on any equipment when there is evidence of fire water or structural damage Disconnect the attached power cords telecommunications systems networks and modems before you open the device covers unless instructed otherwise in the installation and configuration procedures Connect and disconnect cables as described below when installing moving or opening covers on this product or attached devices To Disconnect a Turn everything OFF unless inst
15. bulk data These cryptographic functions are performed within a tamper resistant module that is designed to meet the FIPS PUB 140 2 Level 4 standard of detecting and responding to unauthorized attempts at physical access and security compromise due to environmental conditions such as voltage and temperature You can install the coprocessor a standard height short type PCI X adapter card only in an IBM eServer xSeries approved server with a PCI X expansion slot available Before installing a coprocessor check the IBM product Web site http www ibm com security cryptocards for the approved server list Contents of the coprocessor package Your package includes the following items The IBM 4764 PCI X Cryptographic Coprocessor e Safety Notices GC28 6849 Statement of Limited Warranty GC28 6850 License Agreement for Machine Code GC28 6851 If any item is missing or damaged contact your local IBM representative or your IBM Business Partner Special considerations for handling and storage Each IBM 4764 PCI X Cryptographic Coprocessor is shipped from the factory with a certified device key This electronic key which is stored in the card s battery backed protected memory digitally signs test messages to confirm that the PCI X cryptographic coprocessor is genuine and that no tampering has occurred Note If any of the secure module s tamper sensors is triggered by tampering or accident the coprocessor erases zeroizes
16. cess and then reused T expansion card A circuit board that a user can install in an expansion slot to add memory or special features to a computer Synonym for card expansion slot One of several receptacles in a personal computer or RS 6000 machine into which a user can install an expansion card F feature Part of an IBM product able to be ordered separately Federal Communications Commission FCC A board of commissioners appointed by the President under the Communications Act of 1934 having the power to regulate all interstate and foreign communications in the United States that are transmitted by wire or radio 15 Federal Information Processing Standard FIPS A standard published by the US National Institute of Science and Technology H hertz Hz A unit of frequency equal to one cycle per second Note In the United States line frequency is 60 Hz or a change in voltage polarity 120 times per second in Europe line frequency is 50 Hz or a change in voltage polarity 100 times per second interface A shared boundary between two functional units defined by functional characteristics signal characteristics or other characteristics as appropriate The concept includes the specification of the connection of two devices having different functions T Hardware software or both that links systems programs and devices International Organization for Standardization ISO An organization of nation
17. df El ic A 2 8666 621 ds 1H 2002 96 EC WEEE O 7 v D H SNC WET S YI EU stp icu H7 2 8 vr Z s OO E YH AORT Z EDT ET IDFRNMNI di HZ Z ZE Te BP ICT IC oO CIBER LET A p ZS 2 2 d 5 MW 6 f amp OoN mE Hk TU TE Remarque Cette marque s applique uniquement aux pays de l Union Europ enne et la Norv ge Safety and environmental notices xi L tiquette du syst me respecte la Directive europ enne 2002 96 EC en mati re de D chets des Equipements Electriques et Electroniques DEEE qui d termine les dispositions de retour et de recyclage applicables aux syst mes utilis s travers l Union europ enne Conform ment la directive ladite tiquette pr cise que le produit sur lequel elle est apposee ne doit pas tre jet mais tre r cup r en fin de vie Battery return program This product may contain sealed lead acid nickel cadmium nickel metal hydride lithium or lithium ion battery s Consult your user manual or service manual for specific battery information The battery must be recycled or disposed of properly Recycling facilities may not be available in your area For information on disposal of batteries outside the United States go to http Wwww ibm com ibm environment products or contact your local waste disposal facility In the United States IBM has established a return process
18. es the contents of the coprocessor packages shipping handling and storage considerations and requirements and specifications of the PCI X cryptographic coprocessor e Chapter 2 Installing the coprocessor describes the procedure to physically install the PCI X cryptographic coprocessor e Chapter 3 Replacing IBM PCI X cryptographic coprocessor batteries describes the way to replace the batteries on the PCI X cryptographic coprocessor Notices contains notices for various countries trademark information and information about the product warranty extended by IBM A glossary and an index complete the manual Where to find more information Visit the IBM product Web site at http www ibm com security cryptocards to obtain IBM 4764 related publications This and other publications are available as Adobe PDF files that you can read and print with the Adobe Acrobat Reader Before installing a coprocessor check the IBM product Web site http www ibm com security cryptocards for the approved server list XV XV 4764 PCI X Cryptographic Coprocessor Installation Manual Chapter 1 Introduction This section details the contents of the coprocessor package and describes the following information Special considerations for handling and storage Requirements and specifications The IBM 4764 PCI X Cryptographic Coprocessor uses dedicated hardware to process cryptographic keys certificates and
19. lectrical voltage and current from power telephone and communication cables are hazardous To avoid a shock hazard Do not connect or disconnect any cables or perform installation maintenance or reconfiguration of this product during an electrical storm Connect all power cords to a properly wired and grounded electrical outlet Ensure outlet supplies proper voltage and phase rotation according to the system rating plate Connect any equipment that will be attached to this product to properly wired outlets When possible use one hand only to connect or disconnect signal cables e Never turn on any equipment when there is evidence of fire water or structural damage Disconnect the attached power cords telecommunications systems networks and modems before you open the device covers unless instructed otherwise in the installation and configuration procedures Connect and disconnect cables as described below when installing moving or opening covers on this product or attached devices To Disconnect a Turn everything OFF unless instructed otherwise b Remove power cords from the outlet c Remove signal cables from connectors d Remove all cables from devices To Connect a Turn everything OFF unless instructed otherwise b Attach all cables to devices c Attach signal cables to connectors d Attach power cords to outlet e Turn device ON D005 Remove the cover from the expansion s
20. lots according to the directions provided vvith your computer Choose a PCI X expansion slot able to accommodate a standard short type adapter card 6 If the expansion slot has an individual cover remove the bracket holding screw and the cover Attention Electrostatic discharge ESD can damage the card and its components Wear an ESD wrist strap while handling and installing the card or take the following precautions Limit your movements this helps prevent static electricity building up around you Prevent others from touching the card or other components Before removing the card from the anti static bag touch the bag to an unpainted metal surface on your computer and hold it there for at least two seconds Handle the card by its edges only Do not touch exposed circuitry and components 7 Remove the PCI X cryptographic coprocessor from its static protective bag 8 Verify that the jumpers on the card are positioned correctly 2 on page 5 J7 5 Ok BT1 J9 S o O J8 i Eth net Secure Crypto Module R s 2 BT2 3 2 l Front Side Figure 1 Jumpers on the PCI X cryptographic coprocessor front side 4 4764 PCI X Cryptographic Coprocessor Installation Manual Eth net N 0 N 0 Z Back Side Figure
21. moving or opening covers on this product or attached devices To Disconnect 1 Turn everything OFF unless instructed otherwise 2 Remove power cords from the outlet 3 Remove signal cables from connectors 4 Remove all cables from devices To Connect 1 Turn everything OFF unless instructed otherwise 2 Attach all cables to devices 3 Attach signal cables to connectors 4 Attach power cords to outlet 5b Turn device ON D005 Electrical voltage and current from power telephone and communication cables are hazardous The following CAUTION notice appears in this manual CAUTION Only trained service personnel may replace this battery The battery contains lithium To avoid possible explosion do not burn or charge the battery Do Not Throw or immerse into water Heat to more than 100 C 212 F Repair or disassemble Exchange only with the IBM approved part Recycle or discard the battery as instructed by local regulations In the United States IBM has a process for the collection of this battery For information call 1 800 426 4333 Have the IBM part number for the battery unit available when you call C002 World trade safety information Several countries require the safety information contained in product publications to be presented in their national languages If this requirement applies to your country a safety information booklet is included in the publications package shipped with the pr
22. ndard Dictionary for Information Systems ANSI X3 172 1990 copyright 1990 by the American National Standards Institute ANSI Copies may be purchased from the American National Standards Institute 11 West 42 Street New York New York 10036 Definitions are identified by the symbol A following the definition The Information Technology Vocabulary developed by Subcommittee 1 Joint Technical Committee 1 of the International Organization for Standardization and the International Electrotechnical Commission ISO IEC JTC1 SC1 Definitions of published parts of this vocabulary are identified by the symbol 1 following the definition definitions taken from draft international standards committee drafis and working papers being developed by ISO IEC JTC1 SC1 are identified by the symbol T after the definition indicating that final agreement has not yet been reached among the participating National Bodies of SC1 A American National Standard Code for Information Interchange ASCII The standard code using a coded character set consisting of 7 bit characters 8 bits including parity check that is used for information interchange among data processing systems data communication systems and associated equipment The ASCII set consists of control characters and graphic characters A American National Standards Institute ANSI An organization consisting of producers consumers and general interest groups that establishes
23. nts You can send license inquiries in writing to IBM Director of Licensing IBM Corporation North Castle Drive Armonk NY 10504 1785 U S A For license inquiries regarding double byte DBCS information contact the IBM Intellectual Property Department in your country or send inquiries in writing to IBM World Trade Asia Corporation Licensing 2 31 Roppongi 3 chome Minato ku Tokyo 106 Japan The following paragraph does not apply to the United Kingdom or any other country where such provisions are inconsistent with local law INTERNATIONAL BUSINESS MACHINES CORPORATION PROVIDES THIS PUBLICATIONS AS IS WITHOUT WARRANTY OF ANY KIND EITHER EXPRESS OR IMPLIED INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF NON INFRINGEMENT MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE Some states do not allow disclaimer of express or implied warranties in certain transactions therefore this statement may not apply to you Any references in this information to non IBM Web sites are provided for convenience only and do not in any manner serve as an endorsement of those Web sites The materials at those Web sites are not part of the materials for this IBM product and use of those Web sites is at your own risk This information could include technical inaccuracies or typographical errors Changes are periodically made to the information herein these changes will be incorporated in new editions of the publications IBM may make impr
24. o lithium batteries mounted on the IBM 4764 001 PCI X Cryptographic Coprocessor supply power to the card s components including protected memory Your support software or application software can query the coprocessor to determine whether the batteries need to be replaced When shipped from the factory the protected memory contains a certified device key If your coprocessor has been initialized by support software the protected memory contains secret data including a master cryptographic key user profiles and user passwords Attention If you remove either of the batteries without first backing up the power with a fresh battery the data in protected memory can be lost The Replacement Battery Kit for the IBM 4764 PCI X Cryptographic Coprocessor Feature 1008 provides the battery tray needed to provide backup power while you replace the batteries To order the kit contact your local IBM representative or your IBM Business Partner CAUTION Only trained service personnel may replace this battery The battery contains lithium To avoid possible explosion do not burn or charge the battery Do Not Throw or immerse into water Heat to more than 100 C 212 F Repair or disassemble Exchange only vvith the IBM approved part Recycle or discard the battery as instructed by local regulations In the United States IBM has a process for the collection of this battery For information call 1 800 426 4333 Have the IBM part number for the
25. oduct The booklet contains the safety information in your national language with references to the US English source Before using a US English publication to install operate or service this IBM product you must first become familiar with the related safety information in the booklet You should also refer to the booklet any time you do not clearly understand any safety information in the US English publications X 4764 PCI X Cryptographic Coprocessor Installation Manual Environmental notices Product recycling and disposal This unit must be recycled or discarded according to applicable local and national regulations IBM encourages owners of information technology IT equipment to responsibly recycle their equipment when it is no longer needed IBM offers a variety of product return programs and services in several countries to assist equipment owners in recycling their IT products Information on IBM product recycling offerings can be found on IBM s Internet site at htip vvvvvv ibm com ibm environment products index shiml Esta unidad debe reciclarse o desecharse de acuerdo con lo establecido en la normativa nacional o local aplicable IBM a los propietarios de equipos de tecnologia de la informaci n TI que reciclen responsablemente sus equipos cuando strecomiendaos ya no les sean tiles IBM dispone de una serie de programas y servicios de devoluci n de productos en varios pa ses a fin de ayudar a los propietarios de equipos
26. ovements and or changes in the product s and or program s described in this publication at any time without notice IBM may use or distribute any of the information you supply in any way it believes appropriate without incurring any obligation to you Licensees of this program who wish to have information about it for the purpose of enabling i the exchange of information between independently created programs and other programs including this one and ii the mutual use of the information which has been exchanged should contact IBM Corporation Department VM9A MG39 201 11 8501 IBM Drive Charlotte NC 28262 8563 U S A Such information may be available subject to appropriate terms and conditions including in some cases payment of a fee Trademarks The following terms are trademarks of the IBM Corporation in the United States or other countries or both IBM eServer RS 6000 xSeries The following terms are trademarks of other companies Adobe Acrobat Adobe Systems Inc RSA RSA Data Security Inc Windows 2000 Microsoft Corp Java Sun Microsystems Inc Electronic emissions Federal Communications Commission FCC statement This equipment has been tested and found to comply with the limits for a Class B digital device pursuant to Part 15 of the FCC Rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses
27. r requirement The power requirement for the IBM 4764 001 PCI X Cryptographic Coprocessor is Voltage supply 3 3V 10 percent Total power requirement 12 50 watts maximum Environmental specifications The environmental specifications for the IBM 4764 001 PCI X Cryptographic Coprocessor are shown in Table 1 Operating storage and shipping specifications Operating environment Storage environment Shipping environment Temperature 10 C 40 C 1 C 60 C 15 C 60 C 50 F 104 F 33 8 F 140 F 5 F 140 F Relative humidity 8 80 5 80 5 100 Wet bulb 27 C 80 6 F 29 C 84 2 F 29 C 84 2 F Pressure minimum 768 mbar 700 mbar 550 mbar Physical dimensions The coprocessor is a standard height short type PCI X adapter card 4 2 in by 6 9 in 107mm by 175mm 2 4764 PCI X Cryptographic Coprocessor Installation Manual Chapter 2 Installing the coprocessor This section describes installing the IBM 4764 PCI X Cryptographic Coprocessor Note Install the software before installing a coprocessor To install the coprocessor into the host computer follow these steps 1 Locate your computer s instructions for installing expansion cards Throughout this procedure follow the safety instructions in that manual Turn OFF the computer and all attached devices Disconnect all cables including the power cable DANGER E
28. ram BM cryptographic coprocessor card retum program About this manual How this manual is organized Where to find more information Chapter 1 Introduction Contents of the coprocessor package Special considerations for handling and storage Temperature Batteries Requirements and specifications Hardware requirement Software requirement Power requirement Environmental specifications Physical dimensions Chapter 2 Installing the coprocessor Chapter 3 Replacing IBM PCI X cryptographic coprocessor batteries Appendix Notices Trademarks Electronic emissions Federal Communications Commission FCC statement Industry Canada compliance statement Avis de conformit aux normes d Industrie Canada Japanese Voluntary Control Council for Interference VCCI statement Glossary Index Xiii XV XV XV HH HH AH Co 11 12 12 12 13 13 18 15 17 V 4764 PCI X Cryptographic Coprocessor Installation Manual Figures 1 2 3 Jumpers on the PCI X cryptographic coprocessor front side Jumpers on the PCI X cryptographic coprocessor back side J10 connector and battery locations on the PCI X cryptographic coprocessor ou vi 4764 PCI X Cryptographic Coprocessor Installation Manual Tables 1 Operating storage and shipping specifications 2 Jumpers on the PCI X cryptographic coprocessor
29. re the card is fully seated Replace the host computer s cover Reconnect the power cable and any other cables you disconnected Turn the computer ON The PCI X cryptographic coprocessor runs its power on self test POST The batteries are lithium 3 3 volt batteries Recycle or dispose of the old batteries as required by local law You have completed the procedure for replacing the PCI X cryptographic coprocessor batteries Chapter 3 Replacing IBM PCI X cryptographic coprocessor batteries 9 10 4764 PCI X Cryptographic Coprocessor Installation Manual Appendix Notices This information was developed for products and services offered in the U S A IBM may not offer the products services or features discussed in this document in other countries Consult your local IBM representative for information on the products and services currently available in your area Any reference to an IBM product program or service is not intended to state or imply that only that IBM product program or service may be used Any functionally equivalent product program or service that does not infringe any IBM intellectual property right may be used instead However it is the user s responsibility to evaluate and verify the operation of any non IBM product program or service IBM may have patents or pending patent applications covering subject matter described in this document The furnishing of this document does not give you any license to these pate
30. ructed otherwise b Remove power cords from the outlet c Remove signal cables from connectors d Remove all cables from devices To Connect a Turn everything OFF unless instructed otherwise b Attach all cables to devices c Attach signal cables to connectors d Attach power cords to outlet e Turn device ON D005 3 Remove the cover from the expansion slots according to the directions provided vvith your computer 4 Open the Battery Replacement Kit Attention Electrostatic discharge ESD can damage the card and its components VVear an ESD wrist strap while handling and installing the card or take the following precautions Limit your movements this helps prevent static electricity building up around you Prevent others from touching the card or other components Handle the card by its edges only Do not touch exposed circuitry and components 5 Remove the PCI X cryptographic coprocessor from the PCI X bus slot in the host computer 6 Insert one of the new batteries into the battery tray provided with the kit Align the on the battery with the on the battery tray the end with the red wire Connect the tray s wires to the J10 connector located near the RS 232 serial port see TOITE The connector is polarized to ensure a proper connection Note The J10 connector has three pins The top pin closest to the J7 jumper is the pin while the bottom pin farthest from the J7 jumper i
31. s the pin 8 4764 PCI X Cryptographic Coprocessor Installation Manual O Ob BT1 J9 4b o o 48 lol 19 io JO gt Eth net Secure Crypto Module R S 2 BT2 3 2 m Front Side Figure 3 J10 connector and battery locations on the PCI X cryptographic coprocessor 11 12 13 14 15 16 17 Attention Any loss of power erases data stored in the card s protected memory To prevent loss ensure that the battery tray contains a fresh battery and is attached to the J10 connector Remove the battery attention labels from the battery holders on the card These labels can be torn off and discarded They are to be replaced by the spare labels included in the kit Remove the battery in the BT1 position To eject the battery turn the coprocessor over and insert a small object such as a screwdriver through the hole to eject the battery Replace the battery in the BT1 position with a new battery Replace the battery in the BT2 position with the battery in the battery tray The new battery already installed in the BT1 position provides power to the PCI X cryptographic coprocessor while you perform this step Remove the battery holder from the J10 connector Reapply the spare battery attention labels onto the holders on the card covering the batteries Re insert the coprocessor into the PCI X bus slot be su
32. st Management Practices for Perchlorate Materials This product part or both may include a lithium manganese dioxide battery which contains a perchlorate substance IBM cryptographic coprocessor card return program This machine may contain an optional feature the cryptographic coprocessor card which includes a polyurethane material that contains mercury Please follow Local Ordinances or regulations for disposal of this card IBM has established a return program for certain IBM Cryptographic Coprocessor Cards More information can be found at IBM Cryptographic Coprocessor lt ela J ga c JS Ag ca lit Ay kali le gini di 23 Sla oi A Cryptographic Coprocessor uie sisi p yla de S 9 l 3 ceo s SN ida Gye Gal AS sad EA a ka ji 2 ill ii ela O IBM Cryptographic 5 oaa pil Y ga alas IBM As y cat Coprocessor g gall 555 cla cla UA jel http www ibm com ibrm environment products prp shtrml Safety and environmental notices xiii X V 4764 PCI X Cryptographic Coprocessor Installation Manual About this manual The BM 4764 PCI X Cryptographic Coprocessor Installation Manual is written for personnel installing the IBM 4764 PCI X Cryptographic Coprocessor hardware How this manual is organized This manual is organized as follows e Safety and environmental notices on page ix describes important general safety information e Chapter 1 Introduction describ
Download Pdf Manuals
Related Search