AWL AIRCRAFT WARNING LIGHT LIOL
Contents
1. Luxsolar declines any other kind of warranty included without limitations the implicit warranty of commercial use and suitability for other uses Damage limitations Under no circumstances LUXSOLAR will be liable for incidental or accidental damages and loss of profits or savings suffered by purchaser or third part that may be caused by its products or by failure of its products This limitation will be effective even if damage and loss have been caused by Luxsolar or its representative s negligence and even if Luxsolar is informed about the possibility of such damages and losses This limitation of liability may not apply to damages relating to personal injury or death in jurisdictions where such damages may not be disclaimed as a matter of law To obtain warranty service user has to ask by fax 39 0341 577747 and obtain the authorization return number of material ARM from Luxsolar Service Centre S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 30 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl2. e Airport Stack High Building Chimney Tower crane Pipe line Bridge Radio and television tower e Transmission line Wind turbine Wind mast measurement e Radar Antenna INTERNATIONAL REGULATION e ICAO Aerodromes Annex 14 Volume 1 6 Edition July 2013 Chapter 6 Low intensity Type A B steady burning obstacle light e FAA AC150 5345 43F E B 67 Lamp type L 810 e DGAC STAC approval nr 2013A048 e CE marking info luxsolar com www luxsolar com Ph 39 0341 260926 COMBUSTION AND ENERGY Document is subject to change without any notice COMBUSTION AND ENERGY SRL rev Ol e LCS LUXSOLAR Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 4 of 30 rev 2 00 info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING AIRCRAFT WARNING LIGHTS LIOL A LIOL B Order code 1 2 3 4 5 6 7 8 L810 LXS AR gt 10 A Manufacturer code 232cd B S Single light Customer s request U T Twin light Base B Visible light infrared LEDs Junction Box J Without twilight sensor and without alarm Wall mounting amp JB W 1 With twilight sensor and alarm Side 2 With alarm and without twilight sensor 3 With twilight sensor and without alarm Customized L R Red AN Ba EI Y Yellow G Green 12 24VDC 2
3. info ce2k com Web www luxsolar com www ce2k com Via per Dolzago 21 23848 PASS LUXSOLAR LUXSOLAR AERONAUTICAL LIGHTING __ L a 1 ci ci ci ci 4 AWL CONTROL ge aem T 1 oa A L a a fl RE x UGI 2 j Lu ar I E L HcH 2 I D T feb I pz rl a a L r m s 1 L EL 4 rel g e Li X E 1 pus S S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 13 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING e LCS LUXSOLAR XL BOX LB2 nino 2 BL L IDOL B1 ENT ao XL CS 1 B X L T 09 F 9 09 9 COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl 11 C5 11 E5 11 5 11 5 11 C4 11 E4 11 C4 11 E4 AWL CONTROL PANEL Page 14 of 30 rev 2 00 LUXSOLAR AERONAUTICAL LIGHTING 7 FIXING DETAILS Each beacon can be fixed to the structure in
4. 02635860139 UF rego di COMO n REA CO270978 Campagna 82 22020 Faloppio Tel 39 031 3500011 Fax 39 031 991309 WWW Dn Imancerca t infopnmancerca 1 The dry heat test 2014 08 13 sheet 13 of 13 S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 29 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 13 WARRANTY LUXSOLAR Warranty Obstruction Lighting Combustion and Energy SRL Luxsolar warrants the purchaser and the final user of AWL LED beacons Luxsolar that at the moment of their purchase the products were exempt of shortages and conform with ICAO Annex 14 requirements 3 years warranty for materials and labor For a period of five years from the purchase date Luxsolar at its unchallengeable opinion provides to repair or replace lacking product directly or through other companies and people Warranty is applicable only in case of factory default or assembly default 3 years warranty for light degradation For a period of five years from installation date Luxsolar at its unchallengeable opinion provides repair or replace directly or through other companies and people the product having a light intensity 776 lower than the intensity required according to ICAO Annex 14 June
5. 12 5 l min intemal diameter of the nozzie 6 3 mm Distance from nozzie to enclosure surface 3m 6 2 1 Photo documentation of the test set up 6 2 2 Test results L 810 LXS Water was not present inside the AR enclosure and on live parts 7 TEST EQUIPMENT Equipment used for testing are recorded and saved into the company archive as file 234664 INS doc It wil be made available if requested Page 10 of 16 Report No 234664 TRFENV S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 25 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING e LCS LUXSOLAR CLIMATIC TEST REPORT PRIMA CLIMATIC TEST REPORT CLITR 140989 1 Prima Ricerca amp Sviluppo 571 Capitale Sodale 50 000 i v Codice Fiscale e Partita IVA 02635560139 Uf di COMO n REA C0270979 Va Cana 82 1 Z202 Fatepio We 439 031 3500011 Fax 39 031 991309 EQUIPMENT UNDER TEST Lampeggiante Bassa Intensit L810 L XS CUSTOMER Combustion and energy SRL Mrs Sansoni Address Via per Dolzago 21 23848 OGGIONO LC Tet 39 0341 2600268 Fax 39 E mail a digiovine ce2k com led luxsolar com REFERENCE STANDARDS EN 60068 2 1 2007 04 Prova Ae Freddo per
6. The current sensor checks continuously the beacon status and in case of fault it automatically switches on the fault signalling lamps and the fault contact Once the system detects fault condition it is possible to understand visually which is the electronic board in this condition On the bottom right side of the boards are installed Nr 02 status LEDs Un refer to the power supply circuit so during the night it has to be on and fixed Instead R refers to the output so in this case we have two conditions Normal operation it is on and fixed Faulty operation it is off while Un is on Once the fault condition is detected please contact our technical office by phone or email for further assistance Electronic board PSU regulatory compliance The LED DRIVER PSU is designed to allow the Warning Beacons to comply with ICAO rules and FAA EASA specifications Combustion and Energy Srl as manufacturer of AWL beacons and relevant Driver Circuits declares to operate in accordance with EN ISO 9001 2000 cert nr IQ 1200 15 and 89 392 CEE 91 368 CEE 93 44 CEE 93 68 CEE directives Combustion and Energy Srl as manufacturer of AWL beacons and relevant Driver Circuits inform that the above part of devices can not be in service before that the full device on which it will be incorporated as to be declared in conformity to the rules 89 392 CEE S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39
7. campioni che dissipano calore con cambiamento graduale della temperatura cui viene richiesto di essere alimentati durante la prova EN 60068 2 2 2007 09 Prova Be prova di caldo secco per campioni dissipanti calore con vanazione graduale di temperatura e alimentati per tutta la durata della prova Test Laboratory Prima Ricerca amp Sviluppo S r l Via Campagna 92 22020 Faloppio fraz Gaggino CO Italy Site of test execution Prima Ricerca amp Sviluppo S r l Via Boscone Olgiate Comasco CO Italy Date of test samples 2014 July Date of test 2014 07 31 Dateoftestend 2014 08 02 receipt start Witness to the test Compiled by Approved by gt Ty ba f ji Nobody os CM eme MAINE Gianluigi V 5 M 3 2014 08 13 sheet 1 of 13 COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 26 of 30 rev 2 00 info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING e PRIMA CLIMATIC TEST REPORT CLITR_140989 1 RICERCA amp SVILUPPO Prima Ricerca amp Sviluppo 521 Capitale Sodale 50 000 i v Codice Fiscale e Partita IVA 02635560139 Uf d COMO n REA C0270979 Campagna 92 22020 Faloppio Co Tel 39 0313500011 Fax 39 031 991309 WWW Drimarncerca t info pnmancerca 1 5 S
8. 2004 rules Warranty does not cover 1 Advice or information complementary given by Luxsolar 2 assembly and disassembly of products 3 Fault or lacks caused by accidents modifications wrong use environment temperature gt 55 C voltage value higher than the indicated one wrong maintenance abuse wrong installation and wrong storage Warranty conditions 1 The user has to communicate and detail the shortage or the reduction of light intensity before the end of the warranty period 2 Ship the product with a copy of the purchase order and the name of the original purchaser 3 The user has to pre pay all shipping costs including insurance from plant to Luxsolar and from Luxsolar to plant for repaired and or replaced parts 4 Luxsolar is authorized to detain repaired replaced parts 5 every six months starting bill of material s date User has to send the maintenance module entirely compiled to Luxsolar service center exclusively by FAX no 39 0341 577747 If this module will not be sent warranty will not be applied to repair replacement Warranty limitations this warranty will not cover other suppliers products All the replaced repaired products will be covered by warranty only for the remaining warranty period The replaced products will not be necessarily identical to original ones though having the same functionality Repairs replacements or compensations are the only remedies agreed by this warranty
9. Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 11 TROUBLESHOOTING Very important Some of the tests below have to be done with live system For this reason they should only be undertaken by qualified experienced personnel familiar with the equipment involved Preliminary tests to be done without power supply Verify the interconnection cables installation correct pins bolts tighten Verify that all green connectors on all electrical devices inside the panel are fixed correctly to the related electronic boards Verify that all the fuses integrity Verify that all the automatic switches are in ON position Verify that the system receive 230Vac power supply or 24Vdc as option Verify if black burnt mark are present on electrical components Please find here below some fault conditions with dedicated solution All the operations that require replacement of components have to be done without power supply Fault all LIOL B beacons are off Probable causes there is no electrical power supply to the system automatic switches into off position main switch into O position fused terminals open Solutions give power supply to the system turn automatic switches into on position turn main switch into 1 position close fused terminals Fault one LIOL B beacon is in fault condition Probable causes there is no electrical power supply to the lamp one or more electronic board are in fault damaged LEDs i
10. different ways see details below RE TE i FEMALE THREAD PINS AT 120 FOR ON CRCLE 60 J BOLT FIXING 1 uU BOLT FIXING eic COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info amp luxsolar com Page 15 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 8 AWL SYSTEM OPERATIONS The AWL system is designed to work only during night time During normal operation LIOL B beacons are steady burning according to the light condition It feeded with 230VAC 50 60Hz voltage 1 phase neutral or 24Vdc as option The voltage has to be sinusoidal in VAC version only so no square UPS input voltage nor diesel generator type is allowed There are Nr 02 functional modes of the system Day mode LIOL B beacons are switched OFF Night mode LIOL B beacons are light on steady burning mode Switch between day and night mode automatically is made by the system through the twilight sensor This devices that detects the light difference between day and night has to be installed in a safe area where artificial light is not present to avoid false reading During tests phase or commissioning it is possible to force the mode condition by covering or light up the sensor It has an hysteresis of about 1 minute on the re
11. 0341 260926 E mail info luxsolar com Page 17 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 10 MAINTENANCE AWL beacons maintenance has to be done in accordance with ICAO rules Airport Service Manual Part 9 Airport Maintenance Practices 1984 par 2 6 Light Maintenance Procedure Maintenance procedure can be resumed as follow 1 AWL beacons cleaning intervention Dust and sand brought by wind to the beacons offen reduce the intensity of the light so they have to be removed The same thing has to be done for water left on the glass by bugs For this reason every two months it is necessary to clean the Beacons protection with water and suitable fluids Pay attention Do not use corrosive or oily products If there will be meteorological phenomenon with dust the beacons cleaning is required 2 Damaged beacon replacement As soon as the broken beacon is detected replace it immediately with a new one Do not try to repair it on quote test and repair the beacons only in laboratory 3 Periodic check Climatic conditions lens degrade and the reduction of the intensity emitted from light source are the causes of possible reduction of the intensity of AWL beacons ICAO rules provide that if the light intensity is reduced under the 50 of the specified value it is necessary the replacement of the
12. I L CABLES 3xisqmm BY CLIENT INCOMING POWER SUPPLY CABLE OUTCOMI ALARMS CABLE S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 11 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl amp uxezW FAL SSvVUg T342IN SUNYTO 318v2 Tava Addn HdMOd 4 101 HO SEOL ANOS dl NOILT23X 3 13315 NO84HYO 143197 JLON amp IxGzW pub B egbo amp LxDzM ejqpo amp xGzM pup 002 MOSNJIS IHSITMI J1HYO SHHv1v MOLLOS iv13d 338v7 S 3dis1nio Q3TTv LSMNI i 117139 729771 235 MET OT 034 Livi O 40 WAAT Q3 034 Ld MOoY38 90 WORE O31 034 na MOOY3E ZH cO ODE 31 034 LW MCOY2H 14 0 0 EO AJIA 3dis HOISTS Sd f OLIW 0 HYM ZO MOISES 04 Z HUWS MYN LOO NOLLdIM2S3U LOD d32 NW 5 2 T lt Q _ lt q gt LLJ lt t n gt lt _ a T3Nvd 10MINO TMY Page 12 of 30 rev 2 00 E mail info luxsolar com Ph 39 0341 260926 LC Italy COMBUSTION AND ENERGY SRL Oggiono LXS and LUXSOLAR are trademarks of Combustion and Energy Srl
13. LUXSOLAR AERONAUTICAL LIGHTING AWL AIRCRAFI WARNING LIGHT LIOL B TYPE OPERATION AND MAINTENANCE MANUAL S Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING INDEX LIOL B Datasheet ordering code weight and dimensions Overview ICAO rules general concepts type of lamps LIOL B beacons light emission tests Safety notice Typical general layout and system description Fixing details AWL system operations Ss d ZB de S Fault detection electronic board details and setting Maintenance eel O Troubleshooting LIOL B tests ICAO certification IP65 test Climatic test report CO N Warranty S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 2 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 1 LIOL B DATASHEET ORDERING CODE WEIGHT AND DIMENSIONS AIRCRAFT WARNING LIGHTS LOW INTENSITY OBSTRUCTION LIGHT LIOL A LIOL B e LCS LUXSOLAR rev 01 COMBUSTION AND ENERGY info luxsolar com www luxso
14. Low Intensity Obstruction Lights LIOL type B with 360 radial emission have the following intensity Switch off during day time 32 steady burning during night time Reference code number L810 LXS AR see datasheet page 5 Night mode red steady burning Measured Intensity cd m B m BR 5 m 5 m 5m 5 0 5 10 15 20 25 30 35 40 45 50 55 S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 9 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 5 SAFETY NOTICE DANGER ELECTRICAL VOLTAGE The AWL system associated with the supplied equipment uses 230VAC as option 24VDC and 170VDC voltage to supply the beacons This voltage is present in the AWL panels and also inside the beacon In addition some components installed inside the AWL panel contain capacitors that will retain their charge for several minutes after the main power has been switched off To avoid risk of injury we recommend the following precautions Maintenance should only be undertaken by qualified experienced personnel familiar with the equipment involved After isolating the power supply wait at least 5 minutes before opening the panel This allows the capacitors to drain their charge Ensure the system is electrical
15. Paolo Barbieri verificator Ke EBENEN err 2013 04 04 Testing Laboratory Nemko Spa Via del Carroccio 4 1 20853 Biassono MB Full application of Harmonised standards x Partial application of Harmonised standards I Other standard testing methods a Non standard testing methods O Nemko Spa Via del Carroccio 4 1 20853 Biassono MB Combustion and Energy Srl Luxsolar Via per Dolzago 21 23848 Oggiono LC Ite Test specification ZEN une ed EN 60529 1991 A1 2000 EN 60598 1 2008 A11 2009 partial application only 9 Non standard test method Test Report Form No TRF EN60529 ME TREE SL S soe Nemko Spa M NE LL 2009 06 Nemko Spa 1 20853 Biassono MB All rights reserved This publication may be reproduced in whole or in part for non commercial purposes as long as the Nemko Spa is acknowledged as copynght owner and source of the material Nemko Spa takes no responsibility for and will not assume liability for damages resulting from the reader s interpretation of the reproduced material due to its placement and context Test item description Indicator LED low intensity obstruction lights Trade Mark Combustion and Energy Srl Luxsolar Manufacturer Combustion and Energy Sri Luxsolar Model L 810 LXS AR Ratings 24Vdc 5W IP65 This test report may not be partially reproduced except with the prior written permission of Nemko Spa The test report mer
16. R ANS 7 SF ACCREDIA LAB N 1244 6 TEST CONDITIONS AND RESULTS 6 1 IP 6X Test performed in a dust chamber containing talcum powder able to pass through a square meshed sieve whose nominal wire diameter is 50 um and whose nominal free distance between wires is 75 Test proceeds as follows The luminaire was suspended outside the dust chamber and operated at rated supply voltage until operating temperature was reached b The luminaire whilst still operating was placed with the minimum disturbance in the dust chamber c The door of the dust chamber was closed d The fan blower causing the talcum powder to be in suspsension was switched on After 1 min the luminaire was switched off and allowed to cool for 3 hours whilst the talcum powder remained in suspension 6 1 1 Photo documentation of the test set up 6 1 2 Test results IP6X Result dust test The requirements are Dust was not present inside the Lewusan _ Page 9 of 16 Report No 234664TRFENV COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 24 of 30 rev 2 00 info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING LAB N 1244 6 2 IP X5 ERNE A eR aR een 55 15 min NEAR ISP
17. UMMARY OF TEST RESULTS COLD TEST OPERATING Test Ae y PASS FAIL e Temperatura 20 C e Durata 24 h DRY HEAT TEST OPERATING Test Be PASS FAIL e Temperatura 50 e Durata 24h 2014 08 13 sheet 6 of 13 S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 27 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING PRIMA CLIMATIC TEST REPORT CLITR 140989 1 RICERCA amp SVILUPPO Prima Ricerca amp Sviluppo 571 Capitale Sociale 50 000 iv Codice Fiscale e Partita 02635860139 Uf regsTo di COMO n REA C0270979 Campagna 32 22020 Faloppio Co Tel 439 031 3500011 Fax 39 031 991309 Www 2 info iipnmaricerca 1 The cold test 2014 08 13 sheet 11 of 13 S e COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 28 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING e PRIMA CLIMATIC TEST REPORT CLITR 140989 1 RICERCA amp SVILUPPO Prima Ricerca amp Sviluppo 571 Capitale Sodale 50 000 iv Codice Fiscale e Partita
18. W White 24 48VDC 3 B Blue 115VAC 4 230VAC 5 115 230 6 Order Code 2 B Base W Wall Mounting and JB FEMALE THREAD N 3 PINS AT 120 FOR M4x8 U BOLT FIXING J Junction Box U BOLT FIXING rev 01 COMBUSTION AND ENERGY info luxsolar com www luxsolar com Ph 39 0341 260926 S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 5 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 2 OVERVIEW The beacons are pre assembled in factory and can operate with their own power supply circuits he necessary power feed the beacon is 1 10 of the power needed for the same beacon incandescent type This manual has to be read and understood before doing maintenance on the system or doing the start up For the system functioning and first start up please refer to document F A T included in the data book Each lamp has a special breathing valve to prevent moisture presence This device Equalizes pressures to protect housing enclosures and seals Prevent contamination to protect electronics Reduce condensation to protect against corrosion E Q Q Q Air passes through the membrane SEX ES Liquid and Water vapor molecules part
19. ading so the change over is not immediate For the start up please refer to the step by step instruction included in the FAT document Each LIOL B beacon is feeded through Nr 01 current sensor code 323 LXS 134 CS components in the drawings used check the lamp status For further details please refer to Section 9 Once the system has been switched on and tested it works automatically through the twilight sensor so manually change the status mode is not necessary A system with multiple lights can be controlled in this way on the AWL Control Panel are installed fault status lamps one for each beacon of fault beacon level while inside the panel are installed fault signal contacts one for each beacon S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 16 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 9 FAULT DETECTION ELECTRONIC BOARDS DETAILS AND SETTING Each LIOL B beacon is power supplied with Nr O1 current sensor code 323 LXS 134 CS components in the drawings These sensors check the lamp status by reading its current value LIOL beacon has Nr 05 trimmer and the correct configuration is the following For all CS 1 2 Undercurrent No Memory value 20 Hysteresis 7 5 4s Tt 3s
20. beacon By the way it is strongly prompted to replace the beacon if the light intensity is less than 7076 A simple light sensor used overnight can indicate the light intensity value that has to be compared with the ICAO one The optimum working period of AWL beacons LED type can be define in 5 years before beacons replacement S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 18 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING MAINTENANCE MODULE Please send us this report every six months starting from bill of materials date at Luxsolar by fax nr 39 0341 577747 Others way of sending will not be considered The compilation of this module is necessary for the warranty Date of document _ Person in charge Company Report number State of State of functioning and preservation and preservation Device LIOL B LED beacons Control panels Internal wiring Twilight sensor Interconnection cables S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 19 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and
21. ely corresponds to the test sample The phase of sampling collection of equipment under test is cared out by the customer Page 1 of 16 Report No 234664TRFENV COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 22 of 30 rev 2 00 info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING Nemko Hac wuA aii LAB N 1244 ENV TEST REPORT Type Model L 810 LXS AR Equipment Indicator LED low intensity obstruction lights Applicant Combustion and Energy Sri Luxsolar Address Via per Dolzago 21 23848 Oggiono LC Italy Manufacturer Combustion and Energy Sri Luxsolar Address Via per Dolzago 21 23848 Oggiono LC Italy Date of receipt of test sample 2013 03 27 Testing commenced on 2013 04 02 Testing concluded on 2013 04 03 Test Result according to the standards on page 4 POSITIVE The test report merely corresponds to the test sample Page 2 of 16 Report No 234664TRFENV S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 23 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl e LCS LUXSOLAR AERONAUTICAL LIGHTING LUXSOLA
22. icles pass through the membrane are repelled amp S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 6 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 3 ICAO RULES GENERAL CONCEPTS TYPE OF LAMPS Rules References ICAO International Standards and Recommended Practices Annex 14 Aerodromes Volume Aerodrome Design and Operations 6th July 2013 ICAO Aerodrome Design Manual Part 4 Visual AIDS 4 edition 2004 ICAO Airport Service Manual Part 9 Airport Maintenance Practices 1984 par 2 6 Light Maintenance Procedure Aircraft Warning Light AWL beacons are designed in accordance with ICAO rules These rules define optical characteristics number to be installed and allowed configurations of the lights Please refer to the table below Peak intensity cd at given Background Light Type Type Distribution flash rate Day Above Twilight Night Table 500cd m 50 500cd m Below 50cd m een _ N N Low intensity Type A fixed obstacle Low intensity Type B fixed obstacle NM Um ub N N Type C N mobile obstacle 60 20 fpm N Low intensity 200 Table 6 2 vehicle ps 20 000 20 000 2 000 Table 63 mer aw Da
23. lar com Ph 39 0341 260926 S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 3 of 30 rev 2 00 LUXSOLAR info ce2k com n www luxsolar com www iat com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING AIRCRAFT WARNING LIGHTS LIOL A LIOL B KEY FEATURES Based on LED technology RED steady burning light gt 10 cd LIOL A 232 cd LIOL B Long life time gt 10 years life expectancy Low consumption Stabilised light output Lightweight and compact Low wind load factor Easy to install No RF radiations Patented beacon Germany 20 2011 107 787 3 France 1160162 OPTICAL FEATURES Cd emission 6 and 10 Horizontal beam radiation 360 Vertical beam spread 10 Optical reflector OPTIONS e Twin version two galvanically separate circuits in the same fixture Fault alarm Infrared available Beacon support bracket Automatic changeover from normal to backup light ELECTRICAL FEATURES Power Supply AC or DC e Power consumption LIOL B 4W e LED feeded at costant current LXS MECHANICAL FEATURES e Anodised aluminium body with heat sink pins on the bottom Policarbonate UV Resistant Dome Silicon gasket Degree of protection IP65 Operating temperature 25 C to 55 C Storage temperature 25 C to 55 C Lamp unit weight 0 6 Kg APPLY TO
24. ly isolated before attempting maintenance on cables DANGER HIGH BRIGHTNESS Do not look directly the light source LED during system functioning Considering the high brightness of this source there is an high risk to be dazzled and or to have temporary or permanent sight injury If during maintenance it wil be necessary to leave the light on it will be mandatory to use adequate protection glasses for the whole time S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 10 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 6 TYPICAL GENERAL LAYOUT AND SYSTEM DESCRIPTION LIOL B AWL system is used when the structure is higher or equal than 45m Lights are installed on the top of the MARKED structure and composed by the following material At base structure Nr 0O1 Base AWL Panel Nr 01 Twilight Sensor AT top level Nr 01 or 03 or 04 LIOL B beacons quantity depends on the shape and diameter of the structure In the next pages it is shown the typical interconnection diagram of the system For further details please refer to the dedicated electrical drawing LIOL B1 LIOL B2 LIOL B3 LIOL B4 Nr 04 LIOL B POWER PPLY CABLE 3G61 5sqmm BY CLIENT 1 AWL CONTROL PANEL a s Lbl
25. mm om me ecu Tip LN 200 000 20 000 2 000 Table 6 3 High intensity Flashing _ el 100 000 20 000 2 000 s Document extract from ICAO Annex 14 Aerodromes Volume Table 6 1 Characteristics of obstacle lights A A 0 00 A A A A A A A A S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 7 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING ICAO defines three categories of lights Low Intensity Medium Intensity High Intensity Differences between these categories are related to luminous intensity colours steady burning or flashing mode and functioning during day and or night Combinations of lights are possible for example Medium Intensity Light Type AB white flashing during daytime and red flashing during night time When flashing lights are installed on a structure they have to be synchronized S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 8 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 4 LIOL B BEACONS EMISSION TESTS
26. nside the beacon wrong interconnection Solutions give power supply to the lamp replace the electronic board replace the beacon change the interconnection S COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com Page 20 of 30 rev 2 00 LUXSOLAR info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl LUXSOLAR AERONAUTICAL LIGHTING 12 LIOL B TESTS ICAO CERTIFICATION IP65 TEST CLIMATIC TEST REPORT e LCS LUXSOLAR ad wats Ressources territoires et habi nergie et climat p veloppement durable Pr vention des risques Infrastructures transports et m er ICAO CERTIFICATION Libert Libert galit Fraternit Fraternit R PUBLIQUE FRANGAISE MINISTERE DE L COLOGIE DU D VELOPPEMENT DURABLE DES TRANSPORTS ET DU LOGEMENT Direction g n rale de l aviation civile CERTIFICATE OF COMPLIANCE Service technique de l aviation civile ae ro n e utica ro n d ig hti n g D partement S ret Equipements STAC approval n 2011A102 Division Equipements Issued to Date 09 12 2011 PROMIC 46 rue de la Pierre Plant e 42650 ST JEAN BONNEFONDS France Material manufacturer 8 red LEDs LUXEON L810 LXS 100 AR Elevated Red REBEL LXML PHO1 0050 The above referred fitting is compliant with obstacle light low intensity type B req
27. uirements The operating range is limited from 25 C to 50 C by manufacturer requirements The material approval is five years valid the expiration date is 08 12 2016 Standards STAC Feux de balisage d obstacles Sp cifications techniques PRO STAC SE VIS 6003 V3 dated 22 07 2011 ICAO Annex 14 volume 1 5 edition Industrial s technical documentation STAC Tests Report RESAN STAC SE PROMIC 11 5403 dated 09 12 2011 Measurements 253 254 255 256 257 258 292 PP 248 249 250 259 260 261PC Pr sent Any optical or mechanical modification must be submitted to the STAC and apply to an approval extension pour rj avenir BP 53735 9 avenue du docteur Maurice Grynfogel 31037 Toulouse Cedex T l 01 49 56 83 00 Fax 01 49 56 83 02 www developpement durable gouv fr www stac aviation civile gouv fr STAC COMBUSTION AND ENERGY SRL Via per Dolzago 21 23848 Oggiono LC Italy Ph 39 0341 260926 E mail info luxsolar com info ce2k com Web www luxsolar com www ce2k com LXS and LUXSOLAR are trademarks of Combustion and Energy Srl Page 21 of 30 rev 2 00 e LCS LUXSOLAR AERONAUTICAL LIGHTING LUXSOLAR IP65 TEST REPORT ACCREDIA LAB N 1244 TEST REPORT ENVIRONMENTAL EN 60529 1991 A1 2000 Report Reference No 234664TRFENV Tested by project handler Cristian Simone project handler lt AS Verified by verificator
Download Pdf Manuals
Related Search