Home

2014 chevrolet municipal vehicles technical manual

1. GENERAL ENGINE STANDARD OPTIONAL Model 1EW19 Type V6 V8 Drive Rear wheel Displacement liters cu in 3 6 217 6 0 364 EXTERIOR in rnm Horsepower rpm 30106700 35505300 Wheelbase 118 5 3010 0 Torque Ib ft rpm 26504800 38404400 Overall length 204 2 5187 0 Induction system 2 a Overall width excluding mirrors 74 8 1898 7 Compression ratio 11 3 1 10 4 1 Overall height 58 7 1490 0 Exhaust Dual Dual Front track width 62 8 1596 0 Minimum recommended fuel octane 87 87 Rear track width 63 2 1606 0 Fuel tank capacity approximate gallons liters 19 72 19 72 Turning diameter curb to curb ft m 38 0 11 7 Cooling capacity quarts liters 10 6 10 11 6 11 Ground dearance exhaust system 6 0 153 Oil with filter quarts liters 7 1 6 7 8 0 7 6 FRONT COMPARTMENT in mm TRANSMISSION Head room 38 7 984 0 Shoulder room 59 1 1501 3 Automatic electronically controlled with overdrive 6 speed 6 speed Hip room 57 5 1461 Fluid pan removal amp filter replace quarts liters 11 9 11 3 6 7 6 3 Leg room 42 2 1072 0 AXLE RATIO REAR COMPARTMENT in mm With V6 Engine m Head room 37 6 955 0 With V8 Engine includes limited slip 2 92 Shoulder room 59 0 1498 0 Hip room 57 9 1472 1 BRAKES Leg room 43 2 1098 0 4 wheel disc with ABS Disc Disc LUGG
2. GENERAL ENGINE STD Model 10706 Vortec V8 Drive 2 wheel Displacement liters cu in 5 3 325 Horsepower rpm 320 5400 EXTERIOR in mm Torque Ib ft rpm 335 4000 Wheelbase 116 0 2946 Induction system SFI Overall length 202 0 5131 Compression ratio 99 Overall width 79 0 2007 Exhaust Single Overall height 73 9 1877 Minimum recommended fuel octane 87 Lift in height load floor to ground 30 3 770 Fuel tank capacity gallons liters 26 98 Step height front door sill to ground 20 4 517 Oil with filter quarts liters 6 0 5 7 Step height rear door sill to ground 20 8 528 Cooling capacity quarts liters 183 173 Step height front running board to ground 121 307 Step height rear running board to ground 12 5 317 TRANSMISSION track width ae n Automatic electronic with overdrive 6 speed Turning diameter curb to curb 390 119 Fluid removed and filter replaced quarts liters 6 0 5 7 Ground clearance rear axle 8 0 203 AXLE FRONT COMPARTMENT in mm Ratio 3 08 Head room 41 1 1044 Shoulder room 65 2 1656 BRAKES Hip room 60 3 1532 ABS with vacuum boost Disc Disc Leg room 41 3 1049 Front swept area sq in sq cm 256 6 1655 Rear swept area sq in sq cm 248 1600 REAR COMPARTMENT in mm Total front and rear swept ar
3. MIRROR PATCH ZLA LA LAA AAD AD ADT 77 7 W VG 77 OR UPPER CORNER gi f OY 9 OF WINDSHIELD Q DID LN VIII NN 7 532 Ss 12 WY LONG W B SHOWN SHORT W B SIMILAR AIRBAG ZONE USAGE VEHICLE DESCRIPTION LHRH PASSENGER VAN WITH RH SIDE 60 40 SWING OUT DOOR A d PASSENGER VAN WITH RH SLIDING DOOR B amp C B LH RH CARGO WORK VAN DRIVER FRONT PASSENGER ONLY INNER PILLAR TRIM SURFACE 127mm 127mm 127mm 127mm BOTTOM OF WINDOWS ROOF RAIL AIR BAG DEPLOYMENT ZONES VIEWED FROM REAR Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL ANTI LOCK BRAKING SYSTEM FAQ 1 GM offers Anti Lock Brake Systems as standard or optional on all North American passenger vehicles and light truck lines The computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors monitor how
4. audible alarm may occur when the ignition key is used to open the trunk instead of the Remote Keyless Entry key SERVICE PARTS IDENTIFICATION LABEL SERVICE PARTS IDENTIFICATION DO NOT REMOVE 6G1MK5T22BL532613 PDBJCH 1EW19 AGK AG2 ALO AMF ARQ AT8 AYO 75 A76 BDR B3B B42 B86 BOV C67 DK2 EF7 E2C FEO FRY IPG 9 JL9 KDI KG4 LGD MXO 5 NK5 NI7 N99 OST QPP R7V RON R9Z SLM 753 UH8 UJM UN9 UTZ Uwe UIC U77 VT7 VeD WL9 GAN 4BB 191 3FL 6A3 6E2 6HP 6J1 6J3 7B3 7HP 7M9 7X6 8MZ 901 9MZ BC OC U 636R A Service Parts Identification SPID Label provides Vehicle Identification Number VIN specific Option Code content list Engineering Model Number Nameplate body style Exterior paint system Exterior paint color code and Interior trim level and color The SPID label for the Caprice is located on the underside of the rear compartment lid at the center of the lid inner reinforcement 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL WIRING PROVISIONS FOR 12 VOLT BATTERY POWER SUPPLY Auxiliary battery power ground relay controlled battery power and control circuits are terminated in three connectors located at the right front of the equipment mounting platform Battery power is supplied through two pre fuse assembly fusible links located at the right side of the trunk If the optional auxiliary battery RPO 55 is not present power to the pre fuse asse
5. EMISSIONS BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 FEDERAL EMISSIONS is ordered for delivery to a dealer located in California Connecticut Massachusetts Maryland New Jersey New Mexico New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one
6. 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL UPDATED JANUARY 2014 About This Publication Care must be taken during customer installation of equipment and wiring to ensure that all holes drilled in the body are corrosion protected properly sealed and that vehicle wiring harnesses piping or other components have not been displaced or damaged Aftermarket equipment installers must be mindful of applicable Federal Motor Vehicle Safety Standards This information can be obtained directly from the National Highway Traffic Safety Administration These vehicles are equipped with an air bag system The air bag system in your police vehicle includes front seat back front knee and side curtain air bags Customer installed equipment such as security barriers behind the front seats should not be mounted so that the barrier ends are within the side air bag deployment zones The sensors and other components for the air bag system must not be relocated to accommodate the installation of customer furnished equipment please refer to the service manual for sensor and other component locations For information concerning instrument panel top pad mounted equipment and air bag system deployment zones see the air bag information section in this catalog This catalog is not updated during the model year and should not be used for ordering purposes It is intended as a source of basic information All illustrati
7. FRONT COMPARTMENT SIDE VIEWS SIDE VIEW OF DRIVER SIDE AIR BAG DEPLOYMENT ZONE CENTERLINE OF DRIVER A Driver air bag deployment zone B Top of windshield C Front of steering wheel maximum downward position D Top of instrument panel SIDE VIEW OF PASSENGER SIDE AIR BAG DEPLOYMENT ZONE CENTERLINE OF PASSENGER A Passenger air bag deployment zone B Top of windshield C Inside rearview mirror D Top of instrument panel E Passenger seat in foremost position F Passenger seat in rearmost position Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 AIR BAG DIMENSIONS HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONE RIGHT SIDE SHOWN LEFT SIMILAR Door handle front end Groove in front door armrest Pillar trim Approximate shape of deployed air bag at maximum size Bottom of deployment zone Bottom of door windows Top of deployment zone along head cu
8. 600RPM 650RPM Me ree 9 zn IM NE 124 257 F 125 Q Idle Boost 2 700RPM 700 RPM Reserve capacity 80 F 27 C 130 minutes 130 minutes Idle 121 amps 1100 RPM Idle Boost 3 221 F Idle Boost 3 1100RPM 1100 RPM VEHICLE WEIGHT Lbs kg VB v8 GVWR 5247 2380 5357 2430 3 Cargo and load capacity limited by weight and distribution 10 4 EPA estimated MPG Curb weight 4043 1834 4162 1888 5 Gross Vehicle Weight Rating Payload with bucket seats 1182 536 1173 532 6 Maximum payload capacity includes weight of driver passengers equipment and cargo 10 Curb weight with 100 fuel fluids and standard base equipment excludes optional content Published dimensions indicated are at curb weight NOTE See your vehicle tire and loading information label for specific weight values See your owner s manual supplement for proper cargo loading distribution 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL s CAPRICE POLICE PACKAGE 9C1 DIMENSIONS CAPRICE POLICE PACKAGE Rear Qtr Glass 10h x12w Rear Side Glass Front Side Glass 18h x33w 18h x33w k 204 Body side moldings not available Rear Window 38h x 49w Rear Window 38h x49w Estimated material sizes to wrap Hood 56 x 60 Includes areas next to grill Hood 42 x 60 Excludes areas next to grill Front Doors 45 x 30 Rear Doo
9. E Rear Floor to Roof Zone Area F Ground Loading Zone Weight Chart Tahoe Police Package PPV Loading Zones Front Axle Weight Rear Axle Weight Total Roof 37 Ibs 17 kg 51 Ibs 23 kg 88lbs 40 kg Floor to Roof 133 Ibs 60 kg 529 Ibs 240 kg 662 lbs 300 kg Total 170 Ibs 77 kg 580 Ibs 263 kg 750 Ibs 340 kg Using heavier suspension components to get added durability might not change your weight ratings Ask your dealer to help you load your vehicle the right way 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 12 VOTES GMFLEET COM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 4WD SPECIAL SERVICE 5W4 13 Shown with aftermarket equipment Shown with optional buckefiseats UPDATES FOR 2014 NEW FEATURES CONCORD METALLIC GWU DELETED e BLUE RAY METALLIC GXH e BLACK GRANITE METALLIC 58U e SPECIALTY PAINT WHEATLAND YELLOW 253A e SPECIALTY PAINT DARK TOREADOR RED 334D e SPECIALTY PAINT DARK BLUE METALLIC 7229 e SPECIALTY PAINT BLUE 5665 e SPECIALTY PAINT GREEN 7941 e SPECIALTY PAINT WOODLAND GREEN 8015 e SPECIALTY PAINT YELLOW 9414 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 14 TAHOE 4WD SPECIAL SERVICE 5W4 NOTE THIS VEHICLE IS NOT DESIGNED NOR INTENDED FOR USE IN HIGH SPEED EMERGENCY VEHICLE OPERATIONS GM RESTRICTS THE SALE OF POLICE VEHICLES AND THEY ARE NOT T
10. Silver Ice Brownstone Cyber Gray Dark Blue Black Dark Green Summit White Victory Red Wheatland Metallic Metallic Metallic Metallic Metallic Yellow New New New NOTE Additional Charge Not avaialble with B46 rear body colored halo trim Actual colors may vary SEO PAINT AVAILABLE WA COLOR DESCRIPTION CODE 215D Yellow TBD 259L Yellow Fey TBD 451N Blue 1 TBD 4786 Yellow Rm TBD 519F Galaxy Silver Metallic mr TBD 529F Bronzemist O TBD 811K Berry Red TBD 5456 Yellow TBD 7927 Green 1 TBD 7941 Green a TBD 8867 Silver Metallic i TBD 9015 Woodland Green 9V5 9403 Doeskin Tan gv9 9414 Yellow EE TBD 9417 Tangier Drange Her 9 4 Actual Color NOTE All normally body colored non sheet metal parts will be Flat Black SEO paint orders that contain less than five vehicles will be delayed until five unit minimum is received for batch production 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL e EXPRESS TRANSPORT VAN 1LS amp 215 SPECIFICATIONS GENERAL ENGINE 1LS STD 1LS OPT ELS STD Model 633406 Type V8 V8 V8 Model 633706 Displacement liters cu in 4 8 293 6 0 366 6 6 403 Drive Rear wheel
11. 6835 C6 y C180 Ay 123 Bw c123 vC123 DW123 UNDERHOOD 6J3 JUMPER 1 LT BLU 6837 1LTGRN 6836 1GRY 6838 1 6835 gg D GN RED 6820 Qum BELOW HEADLAMP E Ac122 FORWARD OF FRONT WHEEL 2 WIRES FOR SIREN SPEAKER 2 WIRES FOR GRILLE LAMPS BLUNT CUT HEADLAMP FLASHER WIRING DIAGRAM FOR FORWARD LAMP HARNESS IN LINE CONNECTOR FOR USE WITH HEADLAMPS FLASHER MODULE OPTION 6J7 GROUND 0 8 BLK A 24 0 35 D GN WH 711 0 35 D GN WH HDLPWASH 3640 0 8 RD WH RHHDLP HI 311 0 5 L GN BK D D 311 0 5 L GN BK CONTROL 6820 0 35 D GN RD E BCM 6841 0 5 D BU YE lt oy SE ER UNDER OR Warning BCM will be damaged if 12V power is connected to the dark blue yellow wire NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 WIRING DIAGRAMS WIRING DIAGRAM FOR OPTION 6J4 IN LINE CONNECTOR AN IN LINE LOOP IS CONNECTED HERE WITH OPTION 6J4 fr enennnnnenennnnesenenneseenennnneneneenen INFLATABLE RESTRAINT STEERING 4 WHEEL H6 MODULS J2 J HRN_RLY 28 TN 0 35 A HORN SWITCH B GND ZONE 10 FUSE BLOCK POWER DISTRIBUTION UBEC A_ RELAY PCB HORN RELAY PCB HORN 15A POWER DISTRIBUTION UBEC GND ZONE 1 TO LEFT FRONT SPEAKERS UNDERHOOD GND ZONE 2 TO RIGHT FRONT SPEAKERS WI
12. See exterior lamps control on page 24 for operation description Tilt wheel with column mounted gear shift lever Vehicle PASS Key Ill and content theft unauthorized entry sounds horn and lamps flash For Content Theft Alarm disable option UTQ must be ordered see page 19 Padded with cloth trim extends on rod driver and front passenger illuminated vanity mirrors Headlamp on key in ignition driver and right front passenger safety belt unfasten and turn signal on Power with driver express down and lockout features ELECTRICAL FEATURES 100 amp ignition and main power supply wiring at lower center of instrument panel see wiring provisions for 12 volt battery power supply on page 23 100 amp auxiliary power in cargo area see page 23 Two studs located in rear compartment near bottom of liftgate opening see page 23 Prevents the power door locks from locking the driver s door if the keys are left in the ignition manually lockable with engine running Two 12 volt 20 amp located on Instrument panel and one 12 volt 20 amp in cargo area Battery power is present at all times See pages 28 through 31 for description also see Tahoe Police Package owner s manual supplement located in glove box folder with standard owner s manual Forward lamp harness in line connector for Exterior Lamps Flashing System see option 6J7 on page 19 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rea
13. WIRING Coaxial radio antenna cable RG58 roof to trunk see page 18 WIRING For customer connection to front door and windshield pillar speakers Speakers are not connected to the vehicle radio radio audio signals are routed to the rear speakers see page 21 for description WIRING For grille lamps and speaker see page 21 for description WIRING For horn siren circuit in line connection for customer furnished switch see page 21 for description WIRING Roof wires requires 6B7 or 6J5 hole in roof 2 number 10 AWG wires only see page 20 for description For standard and optional illustrations see pages 15 through 22 Note Factory installation of spotlamps and spotlamp provisions are recommended Field installation of spotlamps must not interfere with proper deployment of the roof rail airbag in the event of a crash NOTE Ship through charge is included as part of base MSRP 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 10 IMPALA LIMITED 9C1 amp 9C3 POLICE PKG SPECS GENERAL ENGINE Model 1WS19 Type V6 Drive 2 wheel front Displacement liters cu in 3 6 217 Horsepower rpm 302 6800 EXTERIOR in mm Torque Ib ft rpm 262 5300 Wheelbase 110 5 2807 Induction system SIDI Overall length 200 4 5090 Compression ratio 1151 Overall
14. 1 5 m coil of wire in the passenger s side footwell to a connector on the passenger s side of the trunk When the option 6B7 center hole is ordered two color coded 10 gauge 5 0 mm2 wires extend 24 inches 60 cm through a grommet approximately 30 inches 74 cm behind the top of the windshield at the center of the roof When option 6J5 passenger s side hole is ordered two color coded 10 gauge 5 0 mm2 wires extend 24 inches 60 cm through a grommet approximately 30 inches 74 cm behind the top of the windshield and 6 inches 15 cm inboard from the passenger s side roof joint NOTE For wiring diagram see page 25 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP 6J4 WIRING PROVISION FOR HORN SIREN GIRGUIT This provision permits customer connection of a switch to select either horn or siren operation when the horn pad is pressed A 22 gauge 0 35 mm wire is connected to an in line connector in the horn circuit of the instrument panel harness under the instrument panel The end of this harness extension is in a 5 foot 1 5 m loop of wire coiled under the instrument panel NOTE For wiring diagram see page 25 6J3 WIRING PROVISIONS FOR VEHIGLE GRILLE LAMPS AND SPEAKER SIREN A Blunt cut ends for the customer furnished grille lamps and customer furnished siren speaker B Control wires from in line connector in forward lamp harness for customer
15. LMG Vortec 00086 s s fa LC9 Vortec 7 es samer s os FE9 Federal YF5 California NG1 Northeast States TRAILERING SPECIFICATIONS AUTOMATIC TRANSMISSION RATINGS WITH BALL HITCH LMG VORTEC LC9 VORTEC 5 3L 5 31 V8 SFI FLEXFUEL V8 SFI FLEXFUEL WEIGHT LBS KG WEIGHT LBS KG 0 0 D 342 game oC O 342 with K5L heavy duty Trailering Package GCWR ENGINE REAR RATIO COMBINATION WITH AUTO TRANS GROSS COMBINATION WEIGHT RATINGS LBS KG 11000 14000 4989 6350 LMG Vortec 5 3L VB SFI FlexFuel LC9 Vortec 5 3L V8 SFI FlexFuel Lu ae L96 Vortec 6 0L Variable Valve Timing V8 SFI FlexFuel with K5L heavy duty Trailering Package 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 7 Maximum trailer weight ratings are calculated assuming a base vehicle except for any option s necessary to achieve the rating plus driver The weight of other optional equipment passengers and cargo will reduce the maximum trailer weight your vehicle can tow 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SUBURBAN COMMERCIAL FLEET 1FL s TIRES AND WHEELS ROAD TIRES COE SME DESCRIPTION SIDEWALL MOS QAN P265 70RI7 Blackwall 72 ton 2 or AND SPARE TIRES CODE SUE DESCRIPTIO
16. Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NE1 is ordered for delivery to a dealer located in California The 2014 Chevrolet Caprice Police Patrol Vehicle with the 3 6L Engine LFX and 6 0L Engine L77 with Emission Option Codes FE9 NET and YF5 is certified to EPA Tier 2 Bin 4 standards and qualifies as ULEV Ultra Low Emission Vehicle under California Air Resources Board CARB requirements meaning it is 50 state certified Emission Standard BIN4 EPA engine family or test group EGMXJ03 6166 LFX and EGMXV06 0082 177 TIRES SPEED RATED MANUFACTURER QUANTITY SIZE SPEED RATING TYPE Goodyear 4 P235 50R18 W All season Compact spare is standard full size spare is available see option SG8 on page 6 Due to specific requirements for performance durability and safety GM recommends only the original equipment tire for replacement Tire Plys Tread 2 Polyester 2 Steel 1 Nylon Sidewall 2 Polyamide Total 7 Ply Tire chains may be used with caution See your owner s manual for specific recommendations
17. REMOTE START RELEARN REMOTE KEY To access this DIC display the vehicle must be in PARK This display allows you to match the remote keyless entry transmitter to your vehicle To match a remote keyless entry transmitter to your vehicle do the following 1 Press the vehicle information button until PRESS THE RELEARN REMOTE KEY displays 2 Press the set rest button The message REMOTE KEY LEARNING ACTIVE will display 3 Press and hold the LOCK and UNLOCK buttons not the first transmitter at the same time for approximately 15 seconds A chime will sound indicating that the transmitter is matched 4 To match additional transmitters at this time repeat Step 3 Each vehicle can have a maximum of eight transmitters matched to it 5 To exit the program mode you must cycle the key to OFF NOTE A maximum of 8 keys may be learned for a vehicle immobilizer Passkey III with arandom key code Vehicles with the fleet key option RPO 6E2 or 6E8 may have an unlimited number of keys learned for the particular option fleet key and must be learned using one of the original master keys When programming RPO AMF additional 6 remote transmitters the original 2 transmitters delivered with a vehicle must also be reprogrammed at the same time A maximum of 8 remote transmitters can be programmed for a single vehicle 6F5 ROOF WIRING Option 6F5 is a universal wiring harness for roof mounted equipment The harness is routed from a 5 foot
18. TAHOE POLICE PPV VEHICLE LOAD LIMITS This information is intended for those who intend to install additional equipment to the police vehicle after it has left the factory and for those who will be driving and loading the vehicle with passengers and or cargo Two labels on your vehicle show how much weight it was designed to carry the Tire and Loading Information label and the Certification Tire label These labels are attached to your vehicle and give you the maximum load capacity the Gross Vehicle Weight Rating GVWR and the Gross Axle Weight Rating GAWR for your vehicle See Vehicle Load Limits in the owner manual Index for additional loading information The following guidelines can help you with proper loading and load distribution when installing additional equipment on the TahoePolice Package WARNING DO NOT LOAD THE VEHICLE ANY HEAVIER THAN THE GROSS VEHICLE WEIGHT RATING GVWR OR EITHER THE MAXIMUM FRONT OR REAR GROSS AXLE WEIGHT RATING GAWR THIS CAN CAUSE SYSTEMS TO BREAK AND CHANGE THE WAY THE VEHICLE HANDLES THIS COULD CAUSE LOSS OF CONTROL AND A CRASH OVERLOADING CAN ALSO SHORTEN THE LIFE OF THE VEHICLE ADDING EQUIPMENT TO YOUR VEHICLE Before adding accessories or equipment to your police vehicle there are some things you need to know The police vehicle s maximum capacity weight payload The weight of your police vehicle including a full tank of fuel but without a driver and passengers The weight of item
19. VISOR WARNING LIGHTS WARNING TONES WINDOW OPERATION 2 year 24 000 mile scheduled maintenance program covers only scheduled oil changes with filter tire rotations and 27 point inspections according to your new vehicle s recommended maintenance schedule for up to 2 years or 24 000 miles which ever comes first Does not include air filters Maximum of four service events See participating dealer for other restrictions and complete details 3 years 36 000 mile bumper to bumper limited warranty whichever comes first see dealer for details 5 years 100 000 mile powertrain limited warranty whichever comes first see dealer for details INTERIOR FEATURES Dual zone automatic climate control with pollen air filtration Bluetooth for phone and music personal cell phone connectivity to vehicle audio system voice recognition music navigator and streaming audio Bottle holder in the front doors Capture stores certified vehicle speed in digital speedometer via steering wheel controls when following another vehicle Not available Electronic with set and resume speed Front and rear dome lamps excludes map lamps The front dome lamp has switches for ON OFF and OFF to disable automatic lamp function see page 13 Monochromatic display with customization features Carpeted front and rear carpeted floor mats are available see Option B34 Option 6A3 heavy duty vinyl floor covering available requires HCQ vinyl rear seat see page 6 Solar Ray
20. competent service technician with access to the vehicle s service manual and the required tools should replace the required components after a deployment crash If my vehicle has air bags why should have to wear my safety belt Air bags are in many vehicles today and will be in most of them in the future But they are supplemental systems only so they work with safety belts not instead of them Every air bag system ever offered for sale has required the use of safety belts Even if you re in a vehicle that has air bags you still have to buckle up to get the most protection That s true not only in frontal collisions but especially in side and other collisions Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 3 TAHOE PPV amp 5W4 AIR BAG DIMENSIONS F TOP VIEW OF INSTRUMENT PANEL AND APPROXIMATE DEPLOYMENT AREA OF THE AIR BAG ZONE Passenger side instrument panel top surface zone Passenger side air bag module trim panel rear edge Passenger side door Approximate dimensi
21. single with dual outlets 17 gallon 64 liters Engine transmission and power steering oil coolers external air to oil see page 17 Extended life iridium tip spark plugs and wires that are designed to reduce radio frequency noise levels which may affect communications equipment including operating frequencies in the 38 MHz to 58 MHz range The Impala is designed with unibody construction and multiple grounding points are provided for the vehicle electrical system No additional ground straps are added for the Police Package Stability enhancement system An advanced computer controlled system that assists the driver with directional control of the vehicle in difficult driving conditions Each time the vehicle is started the StabiliTrak system is fully on StabliliTrak can be controlled by a StabiliTrak button on the instrument panel located below the dimmer control on the headlamp switch see page 17 The condition of the system is displayed by an instrument panel StabiliTrak indicator light and Driver Information Center DIC Messages Push once Performance Mode is active and Traction Control is off push and hold five seconds Traction Control and StabiliTrak are off push again and Traction Control and StabiliTrak are turned back on Prevents starter from engaging while the engine is running Power rack and pinion Heavy duty 4 wheel independent firm ride and handling with increased ride height springs heavy duty front and rear stabilize
22. transmission and axle chart on page 4 Modular with hydro formed frame rails 31 gallon 117 3 liters Auxiliary transmission oil cooler heavy duty air to oil requires 3 42 axle ratio on 1 2 ton models Vehicle stability control system with proactive roll avoidance Power rack and pinion Coil over shock with stabilizer bar Multi link with coil springs See tire and wheel chart on page 5 CHECK TIRE PRESSURE will show on Driver Information Center no sensor in spare tire See tire chart on page 5 Lockable outside winch type mounted under frame at rear Heavy duty includes trailering hitch platform 7 wire harness with independent fused trailering circuits mated to a 7 way sealed connector and VR4 2 inch trailering receiver Electronic trailer sway control and hill start assist Active single speed electronic autotrac with rotary controls does not include Neutral N Cannot be dinghy towed requires GU4 3 08 rear axle Not available on 2WD models 6 speed automatic see engine transmission and axle chart on page 4 See wheel and tire chart on page 5 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 SUBURBAN COMMERCIAL FLEET COMMERCIAL FLEET PACKAGE OPTION 1FL ENGINE AXLE 5 Standard Equipment Available dashes Not Available TRANSMISSION k MYC 6 SPEED MYD 6 SPEED GU4 GUB GT4 C5Z C6C C6P AUTOMATIC AUTOMATIC HD 3 08 3 42 3 73 7200 7400 8600 3266 3357 3901
23. 4 EPA estimated MPG 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payload capacity includes weight of driver passengers optional equipment and cargo 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL VEHICLE WEIGHT lbs kg GVWR 4 wheel drive 7300 3311 Curb weight 5627 2552 Payload with 40 20 40 split bench seat 1673 759 GCWR gross combination weight ratings 14000 6350 Maximum trailer weight 8200 3720 NOTE See owner s manual supplement for loading information 7 Maximum trailer weight ratings are calculated assuming a base vehicle except for any option s necessary to achieve the rating plus driver The weight of other optional equipment passengers and cargo will reduce the maximum trailer weight your vehicle can tow 10 Curb weight in operational status with 100 fuel fluids and standard base equipment excludes optional content Published dimensions indicated are at curb weight TAHOE SPECIAL SERVICE 5W4 VEHICLE LOAD LIMITS 21 This information is intended for those who intend to install additional equipment to the police vehicle after it has left the factory and for those who will be driving and loading the vehicle with passengers and or cargo Two labels on your vehicle show how much weight it was designed to carry the Tire and Loading Information label and the Certification Tire label These labels are atta
24. 700 CCA 70 amp hr Absorbent Glass Mat AGM with battery run down protection does not protect customer installed equipment The AGM battery is located in the trunk and is a sealed Valve Regulated Lead Acid VRLA type with the electrolyte absorbed in fine glass mat separators VRLA battery technology is spill proof under normal conditions and requires no water replenishment An optional 700 CCA 70 amp hr auxiliary battery is available see option 55 page 6 Body frame integral unibody Power 4 wheel anti lock heavy duty disc brakes with police calibration Electric cooling fans independently fused coolant hoses are EPDM ethylene propylene diene monomer coolant is DEXCOOL good for 5 years 150 000 miles whichever comes first maintenance needs vary with different uses and driving conditions see the owner s manual for information protects from 34 to 265 F and against rust and corrosion Lubed for life chassis Standard 3 6L V6 DOHC SIDI spark ignited direct injection engine with Variable Valve Timing VVT and FlexFuel gas or E85 Ethanol Optional no additional charge 6 0L V8 with FlexFuel2 gas or E85 ethanol Active Fuel Management V6 and V8 engines include wide open throttle air conditioning cut off when overhead lamps spotlamps radio antennas sirens and other emergency equipment are installed overall performance may be reduced Steel Stainless steel dual 19 gallons 71 6 Liters approximate Transmission with V6 En
25. A 4 PIN AND 7 PIN TRAILERING HARNESS e CREW CAB REDESIGNED WITH INCREASED REAR LEGROOM FOOT SWING SPACE AND UNDER SEAT VOLUME e SHEAR STYLE AND HYDRAULIC BODY MOUNTS THAT ISOLATE UP AND DOWN AND SIDE TO SIDE MOVEMENTS TO REDUCE NOISE VIBRATION AND HARSHNESS FOR A GUIET CONTROLLED RIDE e STANDARD FOUR WHEEL DISC BRAKES WITH DURALIFE ROTORS e STANDARD ELECTRIC POWER STEERING FOR EFFICIENT CORNERING AND STABILITY e IMPROVED CONNECTIVITY WITH STANDARD USB PORTS 8 AUXILIARY JACK AND SD CARD SLOT AND AVAILABLE THREE PRONG 110 VOLT OUTLET NEW AVAILABLE COLORS INCLUDE BROWNSTONE METALLIC AND TUNGSTEN METALLIC 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 1WT NOTE THIS VEHICLE IS NOT DESIGNED NOR INTENDED FOR USE IN HIGH SPEED EMERGENCY VEHICLE OPERATIONS CC15543 CK15543 CC15743 CK15743 WARRANTY MAINTENANCE AIR BAGS AIR CONDITIONING ASSIST HANDLE AUDIO SYSTEM COAT HOOKS CONSOLE CRUISE CONTROL CUP HOLDERS DOOR LOCKS DRIVER INFORMATION CENTER FLOOR COVERING INSTRUMENTATION LIGHTING MIRROR POWER OUTLETS REMOTE KEYLESS ENTRY RESTRAINT SYSTEM SEAT FRONT SEAT REAR STEERING WHEEL STEERING COLUMN VISORS MODEL AVAILABILITY 2 wheel drive 1 2 ton fleetside short box crew cab pickup 4 wheel drive 1 2 ton fleetside short box crew cab pickup 2 wheel drive 1 2 ton fleetside standard box crew cab pickup 4 wheel drive 1 2 ton fleetsid
26. DESIGNED FOR POLICE WORK UP TO AND INCLUDING HIGH SPEED EMERGENCY VEHICLE OPERATIONS GM RESTRICTS THE SALE OF POLICE VEHICLES AND THEY ARE NOT TO BE SOLD TO RETAIL CUSTOMERS CC10706 WARRANTY AIR CONDITIONING ASSIST HANDLES BLUETOOTH COMPASS CONSOLE FLOOR CONSOLE OVERHEAD CRUISE CONTROL DOME LAMPS FLOOR COVERING GLASS GLOVE BOX MIRROR NAVIGATION SYSTEM ONSTAR OUTSIDE TEMP DISPLAY RADIO RESTRAINT SYSTEM SEATS FRONT SEAT REAR SPEEDOMETER CLUSTER STEALTH MODE STEERING WHEEL THEFT DETERRENT SYSTEM VISORS WARNING TONES WINDOW OPERATION AUXILIARY POWER FRONT AUXILIARY POWER REAR GROUND STUDS LOCK OUT PROTECTION POWER OUTLETS WIRING DIAGRAMS WIRING PROVISION EXTERIOR LAMPS FLASHING MODEL AVAILABILITY Rear wheel drive STANDARD EGUIPMENT SUMMARY 3 years 36 000 mile bumper to bumper whichever comes first see dealer for details 5 years 100 000 mile limited powertrain whichever comes first see dealer for details INTERIOR FEATURES Dual zone manual climate control with individual climate settings for driver and front passenger includes auxiliary rear air conditioning and heat rear operated from front control only Front passenger and second row outboard front passenger assist handle is deleted when passenger side spotlamp is ordered Not available Standard displayed in Driver Information Center Not available Includes map lamps Electronic with set and resume speed ea la
27. Deep tinted all windows except light tinted glass on windshield driver and front passenger side glass Locking door no light Inside rearview manual day night Not available Not available Standard displayed in Driver Information Center AM FM stereo with MP3 compatible CD player seek and scan digital clock auto tone control Radio Data System RDS speed compensated volume and theftlock Tahoe received an overall 5 star frontal and side crash test rating from NHTSA Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator rollover sensor dual head curtain air bags for front and rear outboard occupants and front seat back mounted thorax pelvic air bags Cloth 40 20 40 split bench 3 passenger includes 6 way power driver seat adjuster power passenger seat is not available with manual lumbar driver and passenger manual reclining outboard head restraints center fold down storage armrest and rear storage pockets see page 14 Bucket seats available see A95 page 17 Vinyl split folding 60 40 bench with outboard seating position headrests 3rd seat not available see page 14 120 mph analog speedometer and digital trip odometer with gages for engine oil pressure fuel battery volts and coolant temperature Driver Information Center displays engine hours warnings and other information see message listing on page 16
28. Ex Three auxiliary air to oil coolers are mounted front of the engine coolant radiator The transmission cooler is connected in series with the coolant radiator end tank cooler Heavy duty mat covers floor EXTERIOR LAMPS CONTROL x Trunk Opener Headlamp Switch O NS Interior Lighting Dimmer Stabilitrak 9G8 Delete Daytime Running Lamps and Automatic Headlamps This option disables the Daytime Running Lamps and Automatic Headlamps control feature Exterior lamps are manually controlled only Option 9G8 is not available in Canada The headlamp control on the driver s side of the instrument panel operates the headlamps If your Impala does not have option 9G8 Daytime Running Lamps and Automatic Headlamps delete the Daytime Running Lamps and Automatic Headlamps can be turned off for one ignition cyde by rotating the control knob momentarily counter clockwise Rotating the headlamp switch again will turn the Daytime Running Lamps and Automatic Headlamps back on In Canada the Daytime Running Lamps and Automatic Headlamps can be turned off if the transmission is in Park See also section 1 of your Impala owner s manual Stabilitrak The Stabilitrak stability control system button is located below the dimmer control as part of the headlamp switch Refer to pages 3 or 7 of this manual for an operation description of the stablity control system or see your Owners Manual STRENGTHENED FRONT SEAT Sea
29. Hip room center 61 8 1570 Hip room rear 49 4 1255 Leg room front 41 3 1049 Leg room center 39 5 1003 Leg room rear 34 9 886 Ground to top of rear load floor 32 6 828 Load floor length to front seat at floor 101 8 2586 Load floor length to center seat at floor 69 6 1768 Load floor length to rear seat at floor 35 6 904 Inside width between wheelhousing 49 1 1247 Cargo area height 41 4 1052 Ground clearance front 10 5 267 Ground clearance rear 9 1 231 Front shock absorber diameter 1 81 46 Front stabilizer bar diameter 1 41 36 Rear shock absorber diameter 1 81 46 Rear stabilizer bar diameter 1 10 28 Turning diameter curb to curb ft m 43 0 13 1 CAPACITIES LBS KG Front axle 3600 1633 Rear axle 4200 1905 Curb weight 5824 2642 Cargo volumes cu ft liters 137 4 3891 2 Payloads 1576 715 Gross Vehicle Weight Rating5 GVWR 7400 3357 Front Gross Axle Weight Rating FGAWR 3600 1633 Rear Gross Axle Weight Rating RGAWR 4200 1905 Fuel capacity approximate gallon liters 31 117 Seating capacity front center rear 3 3 03 3 3 03 NOTE Published dimensions indicated are without optional equipment or accessories Additional accessories or equipment ordered at the customer s request can result a minor change in these dimensions 3 Cargo and load capacity limited by weight and distribution 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payl
30. Horsepower rpm 28505400 323 4600 260 3100 Torque Ib ft rpm 295 4600 373 4400 525 1600 ee Er Fuel system SFI SFI Turbo Diesel 1LS 2LS 1LS 2LS Regular Extended Compression ratio 9 6 1 EXTERIOR in mm Wheelbase Wheelbase Exhaust Single Single Single Wheelbase 135 0 3429 155 0 3937 Minimum recommended fuel octane 87 87 Overall length 224 1 5692 2441 6200 Fuel tank capacity gallons liters 31 117 3 31 117 3 31 117 3 Body width 79 2 2013 79 2 2013 Overall height 81 5 2070 82 8 2103 TRANSMISSION Front bumper to axle 397 1008 397 1008 Automatic heavy duty G speed e speed speed Opening height side door 479 1217 47 9 1217 Opening height rear door 49 4 1255 49 4 1255 Opening width sliding side door m1m20 mmo AXLE Opening width rear door at beltline 57 0 1448 57 0 1448 Ratio 3 42 3 42 3 54 Step up height front door 19 4 493 19 4 493 Step up height side door 19 8 503 19 8 503 BATTERY Ground clearance front 11 279 8 8 224 Type Maintenance Maintenance Maintenance Ground clearance rear 7 1 180 7 7 196 free free free BCI group size 78 78 78 INTERIOR in mm a 1 1 Head room 1st row 39 8 1011 39 8 1011 Amp hour rating 69 69 3 Head room 2nd row 384 975 384 275 Cold cranking amps 07 18 C 600 600 Dual 770 Head room 3rd row 38 5 978 38 5 978 Reserve capacity 80 F 27 C 115 115 115 Head room 4th row 316 955 316 995 Standard on 218 with 6 61 Turbo Diesel Head room 5th row 37 6 955 Shoulder
31. MATS Color keyed carpeted front and 2nd row not available with vinyl floor covering K05 HEATER Engine block 5W4 IDENTIFIER Special Service Package 6E2 KEY COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door lock and ignition of all the vehicles in the vehide fleet key code is an alternate to SEO 6E8 key common complete vehicle fleet not compatible with 2005 and earlier Impalas 2006 and earlier Tahoes and 2011 and later Caprice 6E8 KEY COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door lock and ignition of all the vehicles in the vehicle fleet key code is an alternate to SEO 6E2 key common complete vehicle fleet not compatible with 2005 and earlier Impalas and 2006 and earlier Tahoes and 2011 and later Caprice AMF KEYLESS ENTRY TRANSMITTERS Fleet Package includes 6 additional transmitters Transmitters are not programmed Each transmitter including the two standard with the vehicle must be programmed together by a dealer at customer expense Transmitter programming is not a warranty item See also your owner s manual supplement for programming information see also page 25 for customer programming of transmitters using the vehicles Driver Information Center procedure NOTE Vehicle specific common fleet transmitter frequency not available G80 LOCKING DIFFERENTIAL TRW PROVISION FOR ROOF MOUNTED LAMP Overhead console mounted swit
32. SEO CODE 9260 Victory Red 514 ACTUAL COLOR MAY VARY NOTE All normally body colored non sheet metal parts SEO paint orders that contain less than five vehides will be delayed until five unit minimum is received for batch production 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 6 TAHOE POLICE PPV DRIVER INFORMATION CENTER UNITED STATES CERTIFIED SPEEDOMETER CLUSTER CANADIAN SIMILAR 60 70 80 50 80 100 CERTIFIED MESSAGE CENTER REPLACE BATTERY IN REMOTE KEY CHANGE ENGINE OIL SOON RIGHT REAR DOOR OPEN PRESS RESET LF RF LR RR SERVICE AIR BAG DRIVER DOOR OPEN SERVICE BATTERY CHARGING SYSTEM ENGINE HOT A C TURNED OFF ENGINE HOURS ENGINE OIL LOW ADD OIL SERVICE BRAKE SYSTEM ENGINE OVERHEATED IDLE ENGINE SERVICE BRAKES SOON ENGINE OVERHEATED STOP ENGINE SERVICE THEFT DETERRENT SYSTEM ENGINE POWER IS REDUCED SERVICE TIRE MONITOR SYSTEM FUEL LEVEL LOW TIGHTEN GAS CAP HOOD OPEN TIRE LEARNING ACTIVE LEFT REAR DOOR OPEN TRACTION CONTROL OFF OIL PRESSURE LOW STOP ENGINE TRANSMISSION HOT IDLE ENGINE PASSENGER DOOR OPEN TURN SIGNAL ON REAR ACCESS OPEN WASHER FLUID LOW ADD FLUID SPEEDOMETER CERTIFICATION 2014 Tahoe police vehicle certified speedometer calibration Specifications at ambient temperature of 10 to 120 degrees F 23 to 49 Celsius NOTE The Tahoe Police Package and Special Service Package are not Inaccura
33. TIRE SPARE P265 70R17 on off road blackwall requires QJP tires QUP TIRES P265 70R17 on off road for full size spare tire 4JP must be ordered P46 WHEELS Aluminum WX7 WIRING For customer connection to front door and windshield pillar speakers Front speakers are not connected to the vehicle radio radio audio signals are routed to the rear speakers see page 26 6J3 WIRING For grille lamps and siren speaker see page 27 6J4 WIRING For horn siren circuit in line connection for customer furnished switch see page 26 For standard and optional illustrations see pages 23 though 27 Note Factory installation of spotlamps are recommended Special tooling is used to locate and drill the spotlamp shaft hole in the pillars as well as modifying the door edge for lamp shaft clearance Interior trim covers provided with factory installed lamps are not available as service parts Field installation of spotlamps must not interfere with proper deployment of the roof rail airbag in the event of a crash 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 20 TAHOE 4WD SPECIAL SERVICE 5W4 SPECIFICATIONS GENERAL ENGINE Model CK10706 Type Vortec V8 Drive 4 wheel Displacement liters cu in 5 3 325 EXTERIOR in mm Horsepower rpm 320 5400 Whe
34. Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 Federal emissions is ordered for delivery to a dealer located in California Connecticut Delaware Massachusetts Maryland New Jersey New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NE1 CT DE ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Islan
35. activated whenever the ignition is ON The isolation relay is intended to isolate the auxiliary battery and connected load from the primary battery to avoid unintended rundown of the primary battery Whenever the ignition is ON and the engine is running the primary battery and auxiliary batteries are being charged as determined by the charging system controls A Violet Gray ignition controlled power circuit HOT in RUN START terminates in a white connector located above the auxiliary battery power junction block This same circuit is also located in the front passenger foot well upfitter harness see page 19 A 10 amp fuse EF26 protects both circuits and is located in the engine compartment fuse center The total power available for the combined front and rear circuits is 60 watts NOTE If 50 amp battery power is not present at the front compartment upfitter harness verify the connection of the topmost blue of two connectors located above the right hand rear compartment junction block For wiring diagram see pages 18 and 19 See also page 13 Rear Auxiliary Power and Ground Stud and page 16 55 Auxiliary Battery 6J7 FLASHING SYSTEM EXTERIOR LAMPS Option 6J7 provides a headlamps high beam flashing module rear lamps flashing via the Body Control Module BCM and a control wire for customer furnished switching to turn the module on and off The flasher control wire is terminated in the 16 way connector on the upfitter harnes
36. and or brake system performance are being sold in the aftermarket Some of these products imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems which deplete fluid from the master cylinder on brake apply may actually increase a vehicles stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner A properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that even a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However perform
37. are pre cut at vehicle assembly If a key is separate from AMF cut the new key blank to match the existing vehicle key 2 Using the existing key turn the ignition to ON RUN with the engine off 3 Turn the key to OFF LOCK and remove the key from the ignition 4 Insert and turn the new key and turn the ignition to ON RUN within 10 seconds of moving the existing key to the OFF LOCK position The vehicle has now learned the new key NOTE You can lock the key in the ignition on the latest 2014 Caprices with power door lock on Driver s door Turning the Driver s door lock cylinder clockwise will lock all 4 doors You can unlock the Driver s door only by turning the key in cylinder once counter clockwise You can unlock all 4 doors by turning the key cylinder in Driver s door counter clock wise twice Passenger door lock cylinder controls the passenger door only and has no effect on the other 3 doors You cannot lock all doors by use of the passenger door lock cylinder However you can press the power door lock button on the passenger door when door is open and lock all 4 doors before closing it Does not allow for any remote FOB to operate actively when any key is Detected in the ignition A unique Random keyed car will only learn 8 keys each key has a chip just like before no matter if they have a FOB or not Any combination real FOB or not of 8 keys will program no more If you lose one key and 8 were already programmed no mor
38. at rear TPM sensor not included Heavy duty includes trailering hitch platform 7 wire harness with independent fused trailering circuits mated to 7 way sealed connector VR4 2 inch trailering receiver and electric brake controller jumper harness Electronic autotrac 6 speed automatic with overdrive and tow haul mode electronically controlled transmission provides protection against over revving the engine in low gear and a mechanical low gear blockout is not required if a driver manually selects low gear and fails to manually upshift to high gear the powertrain control module automatically protects the drivetrain 17 x 7 5 argent steel Argent retained to wheel lugnuts 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 16 TAHOE 4WD SPECIAL SERVICE 51 4 POWERTRAIN ENGINE TRANSMISSION OPTION DISPLACEMENT FUEL OPTION OPTION CODE LITERS CU IN SYSTEM CODE CODE 5 3 325 Active fuel 6180 management 6 speed FlexFuel auto with OD gas or E85 ethanol EMISSIONS BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that
39. axle and P235 55R17 W rated tires 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL s IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP STD WIRING PROVISIONS FOR 12 VOLT BATTERY POWER SUPPLY Battery power is supplied through two fusible links one 50 amp and one 65 amp to three circuit breakers and two control relays located in the control center above the accelerator pedal A 50 amp circuit breaker feeds power directly from the 50 amp fusible link through a 10 gauge blunt cut wire Two 30 amp circuit breakers supply power from the 65 amp fusible link through the contacts of the control relays to 12 gauge blunt cut wires The blunt cut leads are part of a 5 foot coil on the floor under the instrument panel Each relay is to be operated by an 18 gauge control lead included in the 5 foot coil under the instrument panel An 8 gauge system ground lead is also provided in the 5 foot coil The total current available through the 12 volt power supply is 110 amps Two blunt cut wires provide ignition controlled power one is HOT when the ignition is in ACCESSORY ON the second is HOT when the ignition is in START ON A third blunt cut wire from the body control module provides a park enable signal When the transmission is in PARK zero volts not ground are present and 12 volts are present when the transmission is in any other position The circuit is designed to operate a single customer furnished relay A fourth blunt cut wire provides the V
40. beam WIRING DIAGRAM FOR OPTION 6J3 AND OPTION 6J7 BLUNT CUT 0 8 D GN RED 6820 INTERIOR 6J3 JUMPER 1LTBLU 6837 1LTGRN 6836 1 LT GRY 6838 TLTTAN 6835 0297 297 D c297 Ev C297 IP HARNESS 0 8 D GN RED 6820 1LTBLU 6837 TLTGRN 6836 1 LT GRY 6838 TLTTAN 6835 Ky C120 C123 C123 C123 C123 UNDERHOOD 6J3 JUMPER A B D 0 8 D GN RED 6820 1LTBLU 6837 1LTGRN 6836 1 LT GRY 6838 1LTTAN 6835 ON BACK OF E 122 es SIDE 2 WIRES FOR SIREN SPEAKER 2 WIRES FOR GRILLE LAMPS F BUMPER BLUNT CUT HEADLAMP FLASHER WIRING DIAGRAM FOR OPTION WX7 IN LINE CONNECTOR CHIME LEVEL ADJUSTMENT Impala police vehicles are equipped with a radio that provides an AM FM stereo with a CD player The radio asker produces a Federally mandated audible warning Output notification for the vehicle The volume level of the oa a chimes can be adjusted to be louder but cannot be turned off See Climate Controls and Audio Systems in your Impala owner s manual to adjust the chime volume or WX7 inline harness contact your dealer for assistance Sed hereta send LF and RF outputs to LR and RR speakers Blunt cut circuits from front speakers are coiled in front under the instrument panel Speakers Speakers Speaker Speaker NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNIC
41. best ABS in the one thousand two until your front bumper world cannot provide a shorter stopping reaches the marker If you do not count out distance or good steering two seconds then you are too close to the vehicle in front of you Also if the roads are wet or icy or visibility is poor you should increase your following distance ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK StabiliTrak systems help drivers maintain control of their Q How does StabiliTrak work vehicles especially during emergency lane changes or A StabiliTrak has the ability to apply control forces to avoidance maneuvers StabiliTrak uses various sensors the vehicle independent of the driver StabiliTrak uses such as steering wheel angle wheel speed yaw velocity sensors to continuously compare the path indicated by etc to detect any difference between the path requested the steering wheel position to the vehicle s actual path If by the steering wheel position and vehicle s actual path a discrepancy is detected StabiliTrak selectively controls When appropriate the system selectively controls brakes vehicle brakes and engine torque to create a yaw moment engine power and even suspension settings to enhance that helps restore the vehicle s actual path to the path control of the vehicle s direction and help keep it on course X indicated by the steering wheel position StabiliTrak has Independent studies conducted by the National Highway the ability to help
42. brake system performance are being sold in the aftermarket Some of these products imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems which deplete fluid from the master cylinder on brake apply may actually increase a vehicle s stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that even a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However performance
43. correct both understeer where the Traffic Safety Administration the Insurance Institute for vehicle is not turning as much as the steering wheel Highway Safety and others have found StabiliTrak to be position indicates and oversteer where the vehicle is highly effective in reducing vehicle crashes General Motors turning more than the steering wheel position indicates offers StabiliTrak systems on many of its passenger car The illustration at right shows how selective braking at a and light truck models particular wheel can create a compensating yaw moment See your owner s manual for additional information about to help restore the vehicle s actual path to the path the operation of StabiliTrak indicated by the steering wheel position Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you replace tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance Q How do I use StabiliTrak A StabiliTrak operates independently of the driver You should continue to drive your StabiliTrak equipped
44. diagram see pages 28 through 31 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 TAHOE PPV amp 5W 4 SPECIAL EQUIPMENT STANDARD INTERIOR EXTERIOR LAMPS CONTROL NLY 5W4 ONLY 9G8 Delete Daytime Running Lamps and Automatic Headlamps This option disables the Daytime Running Lamps and Automatic Headlamps control feature Exterior lamps are manually controlled only Option 9G8 not available in Canada Courtesy lamps including dome lamps can be turned off with a push button switch which is above the interior lamp intensity control knob When the switch is activated courtesy lamps remain off when any vehicle door is open If a door is open when the switch is activated the lamps will go off The instrument cluster and radio lighting dimmer control will override the push button switch to turn on the courtesy lamps The headlamp control on the driver s side of the instrument panel operates the headlamps If your Tahoe does not have option 968 Delete Daytime Running Lamps and Automatic Headlamps the Daytime Running Lamps and Automatic Headlamps can be turned off for one ignition cycle by rotating the control knob momentarily counter clockwise See also section 3 of your Tahoe owner s manual In Canada the Daytime Running Lamps and Automatic Headlamps can be turned off if the transmission is in Park See also your Tahoe owner s manual SERVICE PARTS IDENTIFICATI
45. driver You should continue to drive your StabiliTrak equipped vehicle with caution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part of the overall vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 32 NOTES GMFLEET COM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 2WD POLICE PACKAGE PPV 1 m Ji Hy Jl Shown with aftermarket equipment Shown with aftermarket equipment UPDATES FOR 2014 NEW FEATURES CONCORD METALLIC GWU DELETED e BLUE RAY METALLIC GXH e BLACK GRANITE METALLIC 58U e SPECIALTY PAINT WHEATLAND YELLOW 253A e SPECIALTY PAINT DARK TOREADOR RED 334D e SPECIALTY PAINT DARK BLUE METALLIC 7229 e SPECIALTY PAINT BLUE 5665 e SPECIALTY PAINT GREEN 7941 e SPECIALTY PAINT WOODLAND GREEN 8015 e SPECIALTY PAINT YELLOW 9414 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payload capacity includes weight of driver passengers optional equipment and cargo 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 TAHOE 2WD POLICE PACKAGE PPV POLICE PACKAGE OPTION PPV MUST BE ORDERED THE 2 WHEEL DRIVE TAHOE POLICE PACKAGE IS NOT INTENDED FOR TRAILER TOWING THIS VEHICLE HAS BEEN
46. emerges When an air bag deployment is commanded the forces from the inflating passenger air bag push up on the instrument panel top pad releasing special fasteners across the rearward edge of the top pad This allows the top pad to rotate upward so that the passenger air bag may emerge The top pad rotates upward to open widest at the right hand side and is usually forced upward into contact with the windshield on the right hand side of the vehicle during a deployment Instrument panel top mounted special equipment such as a radar antenna and control unit or video camera must be positioned to the left of the vehicle center line This equipment must be mounted as low as possible and securely fastened to the top pad to avoid being dislodged in the event of a crash and possible air bag deployment In the process of securely fastening special equipment to the top DO NOT fasten down the top pad itself to any other vehicle component such as the cluster trim plate As described above the top pad rotates upward during a deployment In order to enable the proper deployment of the passenger air bag specialty equipment installation MUST NOT PREVENT the top pad from rotating upward during deployment Location and attachment of special equipment should minimize added resistance or interference to upward rotation of the top pad during deployment Side Impact Air Bags for crashes to the vehicle sides The air bag system in your police vehicle includes inclu
47. fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is approaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles Does ABS reduce stopping distances Yes in braking situations where the wheels on a non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors including the
48. for details INTERIOR FEATURES Single zone manual with air filtration and environmentally friendly refrigerant R134A Not available Electronic with set and resume speed Carpeting front and rear carpeted mats are available see option B34 on page 9 Auxiliary interior sustained illumination Tinted windshield backlight and side glass Non locking without light Visor left hand and right hand with covered vanity mirrors Inside rearview is manual day night with driver and passenger map lamps Not available Not available Electronically tuned AM FM stereo with CD player seek scan digital clock auto tone control theftlock with integrated rear window antenna radio delete is not available Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator dual head curtain air bags for front and rear outboard occupants and front seat back mounted thorax pelvic air bags 40 20 40 splint bench cloth seat with folding arm rest and cup holder 6 way power driver seat with rediner and manual lumbar 6 way power passenger seat with manual reclining seat back and strengthened front seat frames for side impact resistance see page 17 Cloth bench with high density foam non folding seat back see page 8 Not available 140 mph certified analog speedometer 5 mph increments with digital trip odometer and warning lamps Driver Informatio
49. front upper corner of front door pad J Windshield pillar trim with grab handle K Visor L Deployment zone Tahoe seat rows 1 and 2 M Rear of Tahoe Tahoe Seat Air bag N Center of door trim pull handle 0 Top of surface of outboard front seat cushion P Back edge of center pillar trim HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES VIEW FROM REAR CARGO AREA 80 mm A 2 A Head curtain air bag deployment zone B Underside of headliner C Edge of headliner D Inner center pillar trim E Inner door pad F Seat centerline G Bottom of door windows H Front seat headrests I Seat mounted side impact air bags deployment zone front seat J Top surface of outboard front seat cushion Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL ANTI LOCK BRAKING SYSTEM FAG 37 GM offers Anti Lock Brake Systems as standard or optional on all North American passenger vehicles and light truck lines The
50. is mounted to the instrument panel structure forward of the glove box The center includes a plastic bracket two relays two 30 amp breakers and three 50 amp mega circuit breakers Two 30 amp breakers supply power from the underhood 60 amp mega fuse through the contacts of the control relays to a 12 gauge 3 0 mm2 blunt cut wires These two blunt cut leads are part of wire coiled under the instrument panel near the center of the vehicle Each relay is operated by a 0 5 mm blunt cut light or dark blue control lead includes in a 3 foot 91 cm loop of wire under the instrument panel Three 50 amp mega circuit breakers protected by three fusible links supply power from the underhood 125 amp fuse through three 10 gauge 5 0 mm wires Two of the wires are routed through the body harness to a split buss junction block to the left rear of the cargo area and secured near the jack and tools This 3 foot 91 cm of coiled wires can be accessed by removing the cup holder on the top of the trim panel The third 10 gauge 5 0 mm wire is a blunt cut lead which is part of the 3 foot 91 cm loop of wire coiled under the instrument panel near the center of the vehicle An 8 gauge 8 mm ground lead is also provided and it is located under the front passenger sill plate It can be accessed by removing the sill plate and pulling the loop of wire at the front of the plate the lead is 3 feet 91 cm long Blunt cut ignition control p
51. light tinted windshield driver and front passenger light tinted rear backglass Non locking door with light Center front customer console mounting platform located in 10 inch space between front seats see page 12 for description Manual day night without compass Not available Not available Standard displayed at top of radio screen Chevrolet MyLink radio AM FM stereo with CD player and Playback includes 8 diagonal color touch screen display Bluetooth for phone and music personal cell phone connectivity to vehicle audio system voice recognition music navigator streaming audio and outside Temperature Display Radio audio is provided by front door speakers and two pillar mounted tweeters Rear speakers are not available Lighting power door locks remote functions and other features can be customized using the radio touch screen see page 11 Safety belts driver and front passenger with pretensioners dual stage frontal air bags and a passenger sensing system with passenger frontal air bag ON OFF indicator Driver and front passenger head side curtain air bags knee air bags and front seat back mounted pelvic thorax air bags A Rollover Sensing System senses an impending rollover and deploys the head side curtain air bags and safety belt pretensioners in the event The head side curtain air bags are designed to remain inflated for a longer period than the frontal knee and pelvic thorax air bags to reduce the likelihood of o
52. moderate to severe side crashes In addition certain vehicles have head curtain air bags which are also designed to inflate in situations where an impending rollover condition is identified by the vehicle s rollover sensing system and or frontal or near frontal impacts if the crash severity is above the designed threshold level Safety belt pretensioners at the driver and front passenger seat positions are designed to deploy in frontal near frontal side and rear crashes that exceed the threshold level of crash severity to help reduce slack in the safety belt Safety belt pretensioners will also deploy in impending rollover situations How long will the air bag remain inflated It takes approximately 1 20th of a second to fully inflate the frontal air bags This is faster than the blink of an eye The air bags begin to deflate immediately helping to stop the occupants more gradually I ve heard that a deployed air bag produces whet appears to he smoke is the air hag hot After the bag has deployed in a crash the air bag itself will not be hot to touch Some components within the air bag module will be hot for a short time A small amount of smoke coming from a deployed air bag module is normal and should not be cause for concern Also when the nitrogen gas is vented out of the air bag small particles from inside the bag are also vented into passenger compartment These airborne particles look like smoke and some particles are dep
53. of the lower engine block forward of the oil filter Engine oil flows through the stacked plate cooler from the engine oil sump and returns to the engine Coolant flows to the cooler via a short hose from the engine block and exits to the radiator through a coupled hose connection to the radiator inlet hose NOTE Not required with V6 engine TRANSMISSION OIL COOLER TRANSMISSION COOLER The transmission cooler is positioned to the left side in front of the air conditioning condenser The cooling system is common to the V6 and V8 engines Captured Speed 77 This vehicle is equipped with a standard feature that allows an officer to capture speed of the Caprice while pacing another vehicle To activate Captured Speed the Driver Information Center must be selected to display Speed Once the pace is established push the outer button on the end of turn stalk to Capture Speed The digital speedometer will return momentary back to active speed To display Captured Speed rotate stalk wheel clockwise This Captured Speed is retained even after ignition key is turned off or up until a new speed is captured or cleared To clear the current Captured Speed push and hold the outward end of stalk button until a beep signifies that system has been reset CENTER CONSOLE EQUIPMENT MOUNTING PLATFORM Center front equipment mounting platform between front seats 27x9 inches slotted for T bolt attachment of customer equipment
54. of the overall vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 1WT 1 UPDATES FOR 2014 NEW FEATURES e IMPROVED CHASSIS AND SUSPENSION e EXTENSIVE USAGE OF HIGH STRENGTH STEEL THROUGHOUT THE FRAME AND CAB STRUCTURES FOR CAPABILITY GUIETNESS AND SAFETY EXTERIOR REDESIGN WITH IMPROVED AERODYNAMICS FOR NOISE ISOLATION AND FUEL ECONOMY INTERIOR REDESIGN WITH IMPROVED COMFORT FUNCTIONALITY AND DURABILITY ECOTEC3 POWERTRAINS FEATURING A STANDARD ALUMINUM ENGINE BLOCK DIRECT INJECTION ACTIVE FUEL MANAGEMENT CONTINUOUSLY VARIABLE VALVE TIMING AND SIX SPEED AUTOMATIC TRANSMISSION STANDARD 4 3L V 6 WITH 285 HP AND 305 LB FT OF TORQUE FUEL ECONOMY TBD AVAILABLE 5 3L V 8 WITH 355 HP AND 383 LB FT OF TORQUE CAPABLE OF UP TO 23 MPG HWY WITH A STANDARD 9 5 INCH REAR AXLE e 2 YEARS 24 000 MILES STANDARD SCHEDULED MAINTENANCE INCLUDING OIL CHANGE OIL FILTER REPLACEMENT TIRE ROTATION AND MULTI POINT VEHICLE INSPECTION WHICHEVER COMES FIRST SEE DEALER FOR DETAILS STANDARD CORNERSTEP REAR BUMPER WITH BOX RAIL GRIP POCKETS FOR EASIER ACCESS TO CARGO BOX ALSO INCLUDES STANDARD BOX RAIL PROTECTORS e AVAILABLE UNDER RAIL LED CARGO BOX LIGHTING AND ADJUSTABLE ALL METAL UPPER TIE DOWNS EACH WITH 250 LBS LOAD CAPACITY e AVAILABLE 6 6 BED ON CREW CAB MODELS AVAILABLE TRAILERING PACKAGE NOW INCLUDES BOTH
55. of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NET is ordered for delivery to a dealer located in California 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 EXPRESS TRANSPORT VAN 1LS amp 215 OPTIONS AVAILABLE OPTIONS C69 AIR CONDITIONING REAR Requires TR9 auxiliary lamps includes C36 rear heater U80 digital compass and KG3 145 amp alternator KG3 ALTERNATOR 145 AMPS Included with C69 rear air conditioning 058 AUDIO SYSTEM AM FM stereo with player seek and scan digital clock auto tone control Radio Data System RDS two front door speakers and two rear door speakers and two in the sound bar requires 702 Convenience Package U1C AUDIO SYSTEM AM FM stereo with CD player seek and scan digital clock theftlock random select and 2 front door speakers not available with NP5 leather wrapped steering wheel USR AUDIO SYSTEM FEATURE USB port included and only available with US8 AM FM stereo with MP3 compatible CD player UYS AUDIO SYSTEM WITH NAVIGATION AM FM ste
56. or avoidance maneuvers StabiliTrak uses various sensors such as steering wheel angle wheel speed yaw velocity etc to detect any difference between the path requested by the steering wheel position and vehicle s actual path When appropriate the system selectively controls brakes engine power and even suspension settings to enhance control of the vehicle s direction and help keep it on course Independent studies conducted by the National Highway Traffic Safety Administration the Insurance Institute for Highway Safety and others have found StabiliTrak to be highly effective in reducing vehicle crashes General Motors offers StabiliTrak systems on many of its passenger car and light truck models See your owner s manual for additional information about the operation of StabiliTrak Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you replace tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance Q How do use StabiliTrak A StabiliTrak operates independently of the
57. or gasoline 6L80 6 speed Optional Active Fuel Management auto with OD G80 std Limited slip no additional charge EMISSIONS BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 Federal emissions is ordered for delivery to a dealer located in California Connecticut Delaware Massachusetts Maryland New Jersey New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NE1 CT DE ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon
58. reclining split bench with fold down armrest and lockable storage compartment and manually adjustable driver lumbar AVAILABLE EXTERIOR COLORS Blue Granite Metallic Silver Ice Summit White Black Deep Ruby Victory Red Metallic Metallic SEO PAINT AVAILABLE AE7 AE7 AZ3 Blue Topaz Metallic Brownstone Tungsten Metallic Metallic New New Actual colors may vary WA COLOR DESCRIPTION CODE 9015 Woodland Green 9V5 9403 Doeskin Tan 9V9 253A Wheatland Yellow 9W3 9417 Tangier Orange 9wA 7158 Blue Metallic TBD 334D Dark Toreador red TBD 136X Unripened Green Metallic TBD 9792 Indigo Blue TBD 228A Light Autumnwood Metallic TBD 382E Pewter none TBD ACTUAL COLOR MAY VARY 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 5 POWERTRAIN Teit TRANS GVWR 165 kg MYC C5H CSW C5Y C5Z ENGINE 6 speed auto 6900 7000 7100 7200 Heavy Duty a 3130 3175 3221 3266 15543 std LV3 4 31 V6 EcoTec3 AFM DI WT Flex Fuel aluminum block opt 183 5 3L V8 EcoTec3 AFM DI VVT Flex Fuel aluminum block 15743 std LV3 4 31 V6 EcoTec3 AFM DI VVT Flex Fuel aluminum block opt 183 5 3L V8 EcoTec3 AFM DI VVT Flex Fuel aluminum block 15543 std LV3 4 31 V6 EcoTec3 AFM DI VVT Flex Fuel aluminum block opt 183 5 3L V8 EcoTec3 AFM DI VVT Flex Fuel aluminum block CK15743 std LV3 4 3L V6 EcoTec3 AFM DI VVT Flex Fuel aluminum
59. regarding conditions If the vehicle is equipped with a P235 50R18 tire size use tire chains only where legal and only when necessary Use low profile chains that add no more than 12 mm thickness to the tire tread and inner sidewall Use chains that are the proper size for the tires Install them on the tires of the rear axle Don t use chains on the tires of the front axle Tighten them as tightly as possible with the ends securely fastened Drive slowly and follow the chain manufacturer s instructions If the chains contact the vehicle stop and retighten them If the contact continues slow down until it stops Driving too fast or spinning the wheels with chains on will damage the vehicle SEATS AND INTERIOR TRIM SEAT OPTIONS STANDARD Front bucket cloth with heavy duty foam cloth rear bench includes seatback security panel HIT polypropylene rear door trim and carpeted floor covering OPTIONAL Front bucket cloth with heavy duty foam vinyl rear bench includes seatback security panel HCQ polypropolyene rear door trim and vinyl floor covering AVAILABLE EXTERIOR COLORS Gil om EET y MS Hugo Blue Heron White Red Hot Karma Metallic Phantom Black Silver Ice Mystic Green Dark Blue Jade Metallic Metallic New Meatllic Extra cost orders that contain less than 20 orders will be delayed until 20 unit minimum is received for batch production Will Require additional lead time Actual colors may vary 2 E85 is 85 etha
60. replace tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance StabiliTrak systems help drivers maintain control of their vehicles especially during emergency lane changes or avoidance maneuvers StabiliTrak uses various sensors such as steering wheel angle wheel speed yaw velocity etc to detect any difference between the path requested by the steering wheel position and vehicle s actual path When appropriate the system selectively controls brakes engine power and even suspension settings to enhance control of the vehicle s direction and help keep it on course Independent studies conducted by the National Highway Traffic Safety Administration the Insurance Institute for Highway Safety and others have found StabiliTrak to be highly effective in reducing vehicle crashes General Motors offers StabiliTrak systems on many of its passenger car and light truck models See your owner s manual for additional information about the operation of StabiliTrak Q How do use StabiliTrak A StabiliTrak operates independently of the driver You should continue to drive your StabiliTrak equipped vehicle with caution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part
61. restraint the size and shape of the object and the means by which the object is secured to the vehicle In addition to these factors the trajectory and velocity of a dislodged object can be influenced by the type and severity of vehicle crash Objects that are in the deployment zone but do not become dislodged by an inflating air bag can still affect the performance of the air bag For example such objects could tear the fabric or affect the shape of the air bag thus reducing the ability of the bag to provide restraint Is it possible to shield equipment that is installed in the passenger side frontal air bag deployment zone in a manner that will allow full and safe air bag deployment Due to the complexity of influencing variables GM is unable to evaluate the potential for shielding expected equipment configurations in all accident scenarios in order to assure that the air bag performance would be unaffected While shielding may protect certain equipment from being damaged or dislodged it may also negatively affect the inflation characteristics of the air bag The air bags shape inflation angle fold pattern and inflation rate and pressure are developed to maximize the protection capability of the inflatable restraint system Therefore GM cannot recommend the placement of any equipment in the deployment zone even if it is shielded to protect it from damage Front air bag systems and instrument panel mounted equipment Passenger ai
62. restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL AIR BAGS 13 SIDE VIEW OF DRIVER SIDE AIR BAG DEPLOYMENT ZONE A Top edge of windshield B Top of instrument panel C Inflated air bag steering wheel D Centerline of steering column at mid tilt E Driver air bag deployment zone F Front of steering wheel SIDE VIEW OF PASSENGER SIDE AIR BAG DEPLOYMENT ZONE A Top edge of windshield B Inside rearview mirror C Instrument panel top surface zone D Passenger side air bag module trim panel rear edge E Inflated air bag horizontal dimension approximate 15 4 in 390 mm F Inflated air bag vertical dimension approximate 9 3 in 490 mm G Inflated air bag instrument panel H Passenger air bag deployment zone Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instruc
63. room 1st row 68 8 1748 68 8 1748 Shoulder room 2nd row 686 742 686172 BRAKES Shoulder room 3rd row 65 8 1671 65 8 1671 ABS hydra boost Disc Disc Disc Disc Disc Disc Shoulder room 4th row 69 1 1755 69 1 1755 Front size 12 8x 1 50 12 8x 1 50 12 8x 1 50 Shoulder room 5th row 62 9 1598 Rear size 13 0x 1 14 13 0x 1 14 13 0x 1 14 Hip room 1st row 65 5 1664 65 5 1664 Hip room 2nd row 656 1666 1656 1666 TIRES Hip room 3rd row 63 3 1608 63 3 1608 Type All season All season All season Hip room 4th row 65 7 1669 65 7 1669 Size LT245 75R16 LT245 75R16 LT245 75R16 Hip room 5th row 62 9 1597 Leg room 1st row 41 3 1049 41 3 1049 WHEELS Leg room 2nd row 36 3 922 36 3 922 Type Steel Steel Steel Leg room 3rd row 36 6 930 36 6 930 Size 16 x6 5 16 x 6 5 16 x6 5 Leg room 4th row 36 6 930 36 6 930 Leg room 5th row 34 1 866 CHASSIS Ground to top of rear load floor 27 8 706 30 1 765 Fome Full length Full length Full length Load floor length to front seat at floor 126 2 3205 146 0 3708 boxed frame refer boxed frame Load floor length to engine cover at floor 153 6 3901 173 6 4409 Front suspension Independent with Independent with Independent with Inside width between wheelhousing 50 4 1280 50 4 1280 coil spring and coil spring and coil spring and Cargo area height 518 1316 51 8 1316 stabilizer bar stabilizer bar stabilizer bar Published dimensions indicated are without optional equipment or accessories Additional accessories R
64. sealing harness grommet in Two 4 inch single faced red and blue LED lamps are mounted to the deck lid inner roof hole panel Lamps are activated by the deck lid ajar mechanical switch when deck lid is opened Lamps are wired to flash alternately through a flasher located at the upper Hole is drilled on passenger side of roof panel approximately 29 inches right hand corner of the trunk opening rearward of windshield opening and approximately 6 inches inboard from Wiring is protected by fuse F8 in the rear fuse block located on top of the standard Pesos Gop nel ides da battery in the trunk NOTE Only one roof hole location may be ordered S68 FULL SIZE SPARE W2P FULL WHEEL COVER Full size spare tire is mounted under the load floor The full size spare tire includes Plastic wheel cover attaches to threaded lug nuts aTire Pressure Monitor TPM sensor which must be programmed to the TPM System after the spare tire is installed 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 e CAPRICE POLICE 9C1 SPECIAL EQUIPMENT OPTIONA 6J7 FLASHING SYSTEM EXTERIOR LAMPS MODULE LOCATION Ignition Power white connector Pre fuse assembly n Isolatio relay ground stud Option K5S Auxiliary Battery consists of a 700 CCA battery mounted at the right side of the rear compartment and is connected to the electrical system via a Pre fuse Assembly Also included is an isolation relay which is
65. system which includes internal components for the interior lamps and wiring The roof system may also include side air bag components Inflation devices may be mounted on the vehicle roof side behind the rear doors as well as air bag tethers retained to the windshield pillars Care must be taken to avoid damage to these components or interference with their operation when installing roof mounted equipment such as emergency lamps and communication antennas Recommended GM service procedures must be followed to remove and re install the instrument panel top pad to ensure that the top pad will release properly in the event of a passenger air bag deployment On the right half of the top pad closest to the passenger air bag module GM recommends that no equipment be mounted When mounting equipment on the driver side of the top pad GM recommends that the total mass of the top pad mounted special equipment not exceed 8 pounds 3 6 kilograms since some top pads tend to rotate about the left end Fasteners used to secure special equipment to the instrument panel top pad the windshield glass or to the windshield upper frame header should be selected to ensure that these devices will remain attached during a vehicle crash and possible air bag deployment Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety be
66. the left end Fasteners used to secure special equipment to the instrument panel top pad the windshield glass or to the windshield upper frame header should be selected to ensure that these devices will remain attached during a vehicle crash and possible air bag deployment Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL AIR BAGS FAG 133 Can the installation of push bumpers on the front end of the vehicle affect the deployment of the air hag General Motors is not aware of adverse effects during crash events from the many push bumpers thai have been installed on GM police vehicles Because there are many styles of push bumpers available with varying crash characteristics installation of push bumpers may or may not affect deployment timing of the air bags Push bumpers should be mounted to avoid modifying the vehicle structure and interfering with the front air bag sensors mounted on the upper radiator support cross member Two front impact sensors are installed in General Motors vehicles D
67. the upper radiator support cross member Two front impact sensors are installed in General Motors vehicles Do not relocate or disconnect the front sensors The location and orientation of the front sensors are critical for correct operation of the air bag system Avoid mounting components on or near the sensors Push bumper styles with vertical pushing members that are in foreaft alignment with the front air bag sensors are not recommended When should an air bag inflate The driver s and right front passenger s frontal air bags are designed to inflate in moderate to severe frontal or near frontal crashes But they are designed to inflate only if the impact speed is above the system s designed threshold level In addition your vehicle has dual stage frontal air bags which tailor the the amount of restraint according to crash severity For moderate frontal impacts the air bags inflate at a level less than full deployment For more severe frontal impacts dual stage frontal air bags deploy at full levels If the front of your vehicle goes straight into a wall that doesn t move or deform the threshold level of the reduced deployment is about 12 to 16mph 19 to 15 km h and the threshold level for a full deployment is about 18 to 24 mph 29 to 28 5 km h The threshold level can vary however with specific vehicle design so that it can be somewhat above or below this range If your vehicle strikes something that will move or deform
68. to give an ABS discount of 5 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 A Always maintain a safe following distance ABS does not allow you to stop on a dime Generally a 2 second following distance is considered safe in ideal conditions Watch the vehicle in front of you pass a fixed marker such as a sign Count seconds one thousand one IMPORTANT DRIVING SAFETY TIPS B Always drive carefully especially on slippery surfaces ABS cannot create friction between the tires and the road surface it can only give the driver the maximum advantage of the existing adhesion If the vehicle is traveling on a surface with no adhesion the best ABS in the 2 ANTI LOCK BRAKING SYSTEM AND STABILITRAK C Itisa good idea to practice an ABS activated stop and get the feel of the brake pedal However please make sure it s at a safe time with no obstacles in your path And you only really need to try it once or twice to know what happens one thousand two until your front bumper reaches the marker If you do not count out two seconds then you are too close to the vehicle in front of you A
69. to the complexity of influencing variables GM is unable to evaluate the potential for shielding expected equipment configurations in all accident scenarios in order to assure that the air bag performance would be unaffected While shielding may protect certain equipment from being damaged or dislodged it may also negatively affect the inflation characteristics of the air bag The air bag s shape inflation angle fold pattern and inflation rate and pressure are developed to maximize the protection capability of the inflatable restraint system Therefore GM cannot recommend the placement of any equipment in the deployment zone even if it is shielded to protect it from damage Front air bag systems and instrument panel mounted equipment Passenger air bags in GM vehicles deploy in different ways depending upon the type of vehicle and the particular instrument panel design In some vehicles the passenger air bag deploys through a discrete door located on the top surface of the instrument panel top mount air bag systems In other vehicles such as the Chevrolet Tahoe the passenger air bag deploys through a discrete door mounted on the vertical rearward surface of the instrument panel above the glove box door mid mount air bag system With these types of top mount and mid mount passenger air bag systems the top pad of the instrument panel remains in place during deployment Some GM passenger air bag systems like the system in the Chevrol
70. vehicle with caution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part of the overall vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL NOTES 29 NVEHIGLES 5 SMFLEET COM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 30 VOTES M SMFLEET COM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED POLICE PACKAGE 9C111 Shown with aftermarket equipment p E d 7 POLICE 6 5 Shown with aftermarket equipment e CARRY OVER CONTENT WITH NEW NAME IMPALA LIMITED e VICTORY RED EXTERIOR PAINT 740 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 IMPALA LIMITED POLICE PACKAGE 9C1 THIS VEHICLE HAS BEEN DESIGNED FOR POLICE WORK UP TO AND INCLUDING HIGH SPEED EMERGENCY VEHICLE OPERATIONS GM RESTRICTS THE SALE OF POLICE VEHICLES AND THEY ARE NOT TO BE SOLD TO RETAIL CUSTOMERS SOME STANDARD EQUIPMENT MAY BE REPLACED BY SPECIAL EQUIPMENT WHEN THE POLICE PACKAGE 9 1 IS ORDERED 1W519 WARRANTY AIR CONDITIONING BLUETOOTH CRUISE CONTROL CUP HOLDER DOME LAMPS FLOOR COVERING GLASS GLOVE BOX MIRRORS VISOR MIRROR REARVIEW NAVIGATION SYSTEM ONSTAR RADIO RESTRAINT SYSTEM S
71. will be registered in California CT ME MD MA NJ NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 Federal emissions is ordered for delivery to a dealer located in California Connecticut Delaware Massachusetts Maryland New Jersey New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT DE ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles NB9 Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NET is or
72. 16 Power to the blue green wire must be OFF to flash rear lamps only Warning BCM will be damaged if 12V power is connected to the dark blue yellow wire NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 20 CAPRICE POLICE PACKAGE 9C1 WIRING DIAGRAMS WIRING DIAGRAM FOR HORN SIREN WIRING DIAGRAM FOR GRILLE LAMPS CIRCUIT OPTION 6J4 AND SIREN SPEAKER OPTION 6J3 Body bid ii Module COILED UNDER INSTRUMENT PANEL Siren Grille Lamps Aa 13 P277 11 P277 12 P277 6838 6835 GY VT YE GN 1 5 1 5 1 5 100 209 101 209 97 209 98 4 P209 100 J209 101 J209 97 209 98 J209 6837 6836 6838 6835 BU GN GN YE GYNT YE GN 1 5 1 5 1 5 1 5 5 I P355 8 P355 6 7 P355 5 J355 8 J355 6 7 J355 BK WH CONNECTOR Clock Spring 6837 6836 6835 BU GN GN YE GYNT YE GN 1 5 1 5 1 5 1 5 P182 P182 P182 P182 Steering Wheel Blunt cut wires coiled at upper radiator support Two 20 gauge 0 5 mm wires are connected to an in line connector in the horn The SEO 63 wiring provision circuits are terminated in the 16 cavity connector at circuit of the instrument panel harness under the instrument panel The end of this the front of the equipment mounting platform on the passenger side The wiring harness extension is terminated with an in line connector in a 60 inch coil under circu
73. 1WT BVQ VBN V46 VJH CTD 104 PCX KNP 49 G80 NB8 NC7 NB9 YFS NE1 FES K05 L83 B30 AKO C5H C5W C5Y C5Z UF2 VK3 VXJ VXH VZX RXQ RVS ASSIST STEPS Chromed tubular 6 oval factory installed Not available with any LPO assist steps RVQ RVS VXH or VXJ BED RUG Bed cover foam backed gray colored carpet like material that covers the entire bed not available with VBR Rubber bed mat BUMPER Front chrome BUMPER Rear chrome CARGO TIE DOWNS 4 Movable upper CHEVROLET MYLINK AUDIO SYSTEM 4 2 diagonal color screen with AM FM stereo USB ports 2 auxiliary jack SD card slot Bluetooth streaming audio for music and most phones hands free smartphone integration Pandora Internet radio and voice activated technology for radio and phone See gmtotalconnect com for phone compatibility info CHROME BUMPER PACKAGE Includes VJH rear chrome bumper with BWN CornerSteps and V46 chrome front bumper COOLING Auxiliary external transmission oil cooler Included and only available with L83 5 3L V8 EcoTec3 engine DEFOGGER Rear window electric DIFFERENTIAL Heavy duty locking rear EMISSIONS OVERRIDE California allows a dealer in states that require California emissions California Connecticut Delaware Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island or Washington to order Federal emissions for a vehicle that will be re
74. 2005 and earlier Impalas and 2006 and earlier Tahoes and 2011 Caprice LAMP Red and white front auxiliary dome separately switched see page 18 for description LAMP Inoperative Dome and Courtesy Lamps see page 18 for description LAMPS Rear window auxiliary stop turn signals see page 19 for description LAMPS Alternate flashing trunk lid warning see page 19 for description LICENSE PLATE BRACKET Front bracket standard for states requiring front license plate MATS Carpeted front and rear not available with 6A3 MIRRORS Heated outside rearview power body color REAR DOOR LOCKS INOPERATIVE Rear power locks are inoperable at rear doors but operate form drivers position see page 22 for description REAR DOOR HANDLES INOPERATIVE Doors can be opened only from outside see page 22 for description REAR WINDOW SWITCHES INOPERATIVE Rear door windows only operate from driver s position see page 22 for description REAR SPOILER REMOTE VEHICLE STARTER SYSTEM Includes remote keyless entry required with option UA6 SPOTLAMP Left hand separately fused see page 20 for description SPOTLAMPS Left and right hand separately fused see page 20 for description SPOTLAMP PROVISION Left hand see page 20 for description SPOTLAMP PROVISION Left and right hand see page 20 for description TIRE SPARE Full size includes non programed Tire Pressure Monitor see page 18 for description TRUNK RELEASE Ignition controlled
75. 226 8 5 216 8 93 227 NOTE Published dimensions indicated are without optional equipment or accessories Additional accessories or equipment ordered at the customer s request can result in a minor change in these dimensions 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL ANTI LOCK BRAKING SYSTEM FAG 9 GM offers Anti Lock Brake Systems as standard or optional on all North American passenger vehicles and light truck lines The computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors monitor how fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is appr
76. 4 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 4 CAPRICE POLICE 9C1 SPECIAL EQUIPMENT OPTIONAL 6J4 WIRING PROVISION FOR HORN SIREN CIRCUT Two 16 gauge wires are connected to an in line connector in the horn circuit of the instrument panel harness under the instrument panel The end of this harness extension is terminated with an in line connector in a 60 inch 1 5 m coil under the instrument panel Connection to customer switching permits operation of the horn or siren with the horn button NOTE For wiring diagram see page 20 GNG REAR DOOR LOCKS AND HANDLES INOPERATIVE 6N5 WINDOW SWITCHES REAR DOOR INOPERATIVE Rear door window switches are inoperable Rear door power regulators are operable only from driver position switches 6J3 WIRING PROVISION FOR VEHIGLE GRILLE LA IREN VZ The SEO 6J3 wiring provision circuits are terminated at a 16 way connector on the upfitter harness at the front of the equipment mounting platform The wiring circuits are routed from under the instrument panel to a 2 foot 610 mm coil secured in the area behind the grille to the left of the hood latch assembly NOTE For wiring diagram see page 20 6C7 LAMP AUXILIARY DOME Red and white auxiliary dome lamp is located to the rear of the vehicle dome lamp red is LED and white is incandescent The auxiliary lamp is wired independently from the standard dome lamp 7X6 AND 7X7 SPOTLAMPS 7X8 AND 7X9 SPOTLAMP PR
77. 5 0 35 0 35 0 35 2 1P277 3 1P277 5 P278 6 P278 Surveillence Vehicle HOT HOT HOT Mode Speed OUT OF START ACCY Output PARK amp RUN amp RUN P277 LOCATED IN RIGHT FRONT FOOT WELL Ignition controlled power and signal circuits are also included in the 6 cavity and 16 cavity upfit connectors A violet yellow 10 amp fused circuit HOT in ACCESSORY RUN fuse EF131 is in the end of the instrument panel A violet gray 10 amp fused circuit HOT in START RUN fuse EF26 is in the engine compartment fuse block This circuit is also located at the RH side ofthe trunk in a white connector above the rear auxiliary power junction block see page 13 Total power available for the combined front and rear circuits is 60 watts A yellow Park signal from the Body Control Module BCM This circuit provides switched 12 volt power when the transmission is not in PARK P and the engine is running The electrical load attached must not exceed 0 5 amps one relay coil A white black vehide speed signal 4000 pulses per mile from the ABS module Connect only a high impedance load A white violet Surveillance Mode circuit When grounded all automatic lighting is suppressed and the radio display is OFF SURVEILLANCE MODE MODULE MODULE MODULE UNDERHOOD REAR Body Control Electonic Body Control BEC CENTER Brake Control pare BK YE 2 1 Parr 3 Vehicle HOT Surveillence Speed OUT OF Mode Output PARK When the vehicle lighting system is in the Auto
78. 5637 GOVERNMENT FLEET ACCOUNT EXECUTIVE JAMES MELLON PHONE 407 375 4801 james mellon gm com billy regarsr gm com Alabama North Caroline Florida Puerto Rico Georgia South Carolina Kentucky Tennessee US Virgin Island West Virginia GOVERNMENT FLEET ACCOUNT EXECUTIVE WILL BACHEWICH PHONE 905 644 1051 will bachewich gm com AREA Canada FLEET SERVICE MANAGERS BOB STIPEK PHONE 248 320 8615 robert stipek gm com Area MD DE PA VA DC Western NY JAY LEWIS PHONE 516 458 7994 jay lewis gm com Area NH VT MA RI CT NJ ME Philadelphia Eastern NY FLEET SERVICE MANAGERS BOB BRIEDIS PHONE 313 268 2160 bob briedis gm com Area MI OH IN RICH MOORE PHONE 630 531 1663 rich moore gm com Area IL WI MN IA ND SD FLEET SERVICE MANAGERS SCOTT BRUSKE MARK ROMANS PHONE 602 885 2229 PHONE 916 517 2418 scott bruske gm com mark romans gm com Area AZ CO NM HI Area UT WA OR ID MT Southern CA AK WY Northern CA Southern NV Northern NV FLEET SERWICE MANAGERS JERRY BARTZ MIKE HURRELL PHONE 228 396 1390 PHONE 214 604 9247 gerald i bartz gm com michael hurrell gm com Area AR OK MS LA Area MO KS NB NE Southern TX Northern TX Eastern NM FLEET SERVICE MANAGERS JOHN COSBY PHONE 513 315 8679 john a cosby gm com Area AL TN KY WZ Atlanta Northern GA KEVIN FRASZ PHONE 704 651 9390 kevin 1 frasz gm com Area FL SC NC PR VI Southern GA Fo
79. AGE COMPARTMENT CAPACITY cu ft liters Front swept area sq in sq cm 310 6 788 9 Luggage capacity includes full size spare tire and auxiliary battery 17 4 492 71 Rear swept area sq in sq cm 211 4 537 0 Total front and rear swept area sq in sq cm 522 04 3368 PASSENGEH COMPARTMENT VOLUME INDEX cu ft liters pont rotor diameter in mm 13 58 345 EPA passenger compartment volume inde 112 3171 5 Rear rotor diameter in mm 126 324 FUEL ECONOMY RATINGS CITY HIGHWAY COMBINED Front rotor thickness in mm 1 18 30 3 6L V6 engine 18 26 21 Rear rotor thickness in mm 87 22 6 0L V8 engine 15 24 18 TIRES ALTERNATOR Type Goodyear Eagle RS A all season W speed rated Type 96135 Size P235 50R18 Amps 170 CAPRICE POLICE ALTERNATOR OUTPUT WHEELS S 180 Type Steel Normal AC off size m s _ 160 pz CHASSIS NET Frame Unibody Engine cradle Steel gt 120 Suspension 4 wheel independent with coil springs front and rear stabilizer bars Patrol vehicle specific shock spring and stabilizer bar tuning a 100 Steering type Electrically assisted variable ratio rack and pinion Steering ratio non variable 17 5 1 on center 12 7 1 at full lock 2 BATTERY STANDARD OPTIONAL AUXILIARY Type Maintenance free Maintenance free 500 1000 1500 2000 BCI group size LN3 LN3 ENGINE SPEED RPM Volts 12 12 Amp hour rating 70 70 14 0V 77 F 25 C v6 V8 p mem 13 250 221 F 105 ldleBoosti
80. AINT AVAILABLE WA COLOR DESCRIPTION CODE 9260 Victory Red Requires SEO 514 ACTUAL COLOR MAY VARY NOTE All normally body colored non sheet metal parts will be Flat Black except Victory Red non sheet metal parts will match SEO paint orders that contain less than five vehicles will be delayed until five unit minimum is received for batch production 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SUBURBAN COMMERCIAL FLEET 1FL 7 WeD K47 JL1 D07 UTQ KNP KC4 G80 K05 B30 VAV VKN T96 ANJ KSL VIK G63 VLI B58 DPN UEO VBS AP3 UD7 V76 TRW NZZ UVD NGH 514 9N5 8x1 9653 515 951 AVAILABLE OPTIONS ACCESSORY Cargo net AIR CLEANER High capacity BRAKE CONTROLLER Integrated trailer CONSOLE Floor storage area and cup holders included and only available with A95 front custom cloth bucket seats CONTENT THEFT ALARM DISABLE Flashing lamps and horn warning COOLING Auxiliary transmission oil cooler Included and only available with K5L HD Trailerling Package on 1 2 ton COOLING External engine oil cooler Included and only available with K5L HD Trailerling Package on 1 2 ton DIFFERENTIAL Heavy duty locking rear ENGINE BLOCK HEATER FLOOR COVERING Color keyed carpeting includes B58 color keyed floor mats FLOOR MATS ALL WEATHER First and second row requires B30 color keyed carpeting Not available with AZE front 40 20 40 split bench on 2WD models LPO dealer i
81. AL MANUAL IMPALA LIMITED 9C1 amp 9C3 WIRING DIAGRAMS 125 WIRING DIAGRAM FOR OPTION 6 5 Roof Hole Grommet EN Blunt Cut IN RF Footwell Spotlamp LH E SPOT H7635 Minifuse 15A J2 P2 2640 Ye UNDERHOOD ev 53 CENE Big FUSE CENTER Spotlamp RH Minifuse 15A J2 P2 2740 H7635 m RD WH Q H B3 0 5 A PWR CASE GND RT SPOT 7X6 spotlamp left hand and 7X7 spotlamps left and right hand pillar mounted Unity 6 inch with replaceable H3 halogen bulb independently fused NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 26 AIR BAGS FAG Can specialty vehicle equipment e g radar devices video cameras computers meters radio trees shotguns etc still he mounted in cars with passenger side air bags Yes but care must be taken to mount the equipment outside of the deployment zone Air bags inflate with great force and will interact with any object in the deployment zone Therefore to reduce the risk of injury to vehicle occupants GM recommends that the air deployment zone be kept free of any equipment If a piece of equipment were to become dislodged it could strike an occupant in the vehicle and result in injury The likelihood of an object becoming dislodged is influenced by many factors including the proximity of the object to the inflatable
82. ALES REPRESENTATIVES Sales Service NORTHEAST NORTH CENTRAL SOUTH CENTRAL SOUTHEAST FLEET AND COMMERCIAL OPERATIONS 15 SALES SUPPORT MANAGER POLICE VEHILCE SPECIALIST BOB CASTRO PHONE 347 680 0810 robert castro gm com GOVERNMENT FLEET ACCOUNT EXECUTIVE JAY FERRARO PHONE 914 391 5493 jay ferraro gm com Massachusetts Delaware New Hampshire Rhode Island District of Columbia New Jersey Vermont Maine New York Virgina Maryland Connecticut Pennsylvania SALES SUPPORT MANAGER POLICE VEHILGE SPECIALIST TODD LITTLE GOVERNMENT FLEET ACCOUNT EXECUTIVE ANDREW REYNTJES PHONE 313 300 0528 PHONE 810 441 2781 andrew w reyntjes gm com todd little gm com Illinois Michigan Ohio Indiana Minnesota South Dakota lowa North Dakota Wisconsin SALES SUPPORT MANAGER POLICE VEHILGE SPECIALIST SERGIO GOZALEZ GOVERNMENT FLEET ACCOUNT EXECUTIVE RICH H PATTERSON PHONE 602 228 1286 PHONE 323 313 7139 rich h patterson gm com sergio m gonzalez gm com Alaska Idaho Oregon Arizona Montana Utah California Nevada Washington Colorado New Mexico Wyoming Hawaii SALES SUPPORT MANAGER POLICE WEHILCE SPECIALIST BILL HAJDUK PHONE 214 616 8166 GOVERNMENT FLEET ACCOUNT EXECUTIVE RICK MAYBURY PHONE 817 909 6457 rick maybury gm com bill hajduk gm com Arkansas Mississippi Oklahoma Kansas Missouri Texas Louisiana Nebraska SALES SUPPORT MANAGER POLICE WEHILCE SPECIALIST BILLY REGAR PHONE 386 295
83. ANK CAPACITY MONITOR OIL COOLER STABILITRAK STEERING SUSPENSION FRONT SUSPENSION REAR TIRES TIRE PRESSURE MONITOR TRANSMISSION WHEELS pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator rollover sensor and dual head curtain air bags for front and rear seat outboard occupants Vinyl high back buckets adjustable and reclining Vinyl trimmed rear bench seats and split 4 passenger last seat 12 passenger seating Analog with speedometer odometer with trip odometer fuel level volt meter engine temperature and oil pressure Tilt Vehicle theft PASS Key III Black composite Single rectangular halogen Daytime running Front Outside rearview manual foldaway Black CHECK TIRE PRESSURE no spare tire sensor Intermittent wet arm with pulse washers Power Independent with coil spring and stabilizer bar Hypoid drive axle with multi leaf springs LT245 75R16E all season blackwall with full size spare located under rear underbody CHECK TIRE PRESSURE will show on driver message center 6 speed automatic heavy duty electronically controlled with overdrive and tow haul mode and internal transmission oil cooler 16 x 6 5 steel includes Gray center cap and steel spare 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impac
84. AT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES PASSENGER SIDE SHOWN DRIVER SIDE SIMILAR A Head Curtain air bag zone front seats only E Front seat thorax pelvic air bag zone B Front door sill F Back edge of body center pillar trim at bottom of rear door window C Front door armrest G Rear most end of front head curtain D Fore most end of seat mounted thorax air bag zone H Zone extends into sail panel area 500 mm 19 7 in D E F OPTIONAL RPO AYG HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES PASSENGER SIDE SHOWN DRIVER SIDE SIMILAR A Head Curtain air bag zone front and rear seats E Front seat thorax air bag zone B Front door sill F Back edge of body center pillar trim at bottom of rear door window C Front door armrest G Zone extends into sail panel area D Fore most end of seat mounted thorax air bag zone 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PA
85. BS reduce stopping distances Yes in braking situations where the wheels on a non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors including the road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of the pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the ABS tel
86. BS telltale on the dash will be illuminated Should this happen the vehicle should be taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the brake pedal down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you Should I drive an ABS equipped vehicle differently than I would drive a vehide with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lock up When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and steer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder
87. CKAGE 9C1 AIR I O m K L EL lt gt 200 mm 200 mm 7 8 in 7 8 in HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES VIEW FROM REAR SEAT RIGHT SIDE IS MIRROR OF LEFT SIDE A Vehicle center line G Head curtain air bag zone B Headrest H Bottom of door windows C Center line of occupant Front door handle D Edge of headliner J Front seat back thorax pelvic air bag zone E Door inner trim panel K Seat back F Center body pillar trim L Door sill INSTRUMENT PANEL AND APPROXIMATE DEPLOYMENT AREA OF THE DRIVER AND FRONT PASSENGER AIR BAGS VIEW FROM TOP A Vehicle center line F Instrument cluster K Glove box B Driver center line G Rear most instrument panel L Front passenger knee air bag C Front of instrument panel at the windshield base H Steering wheel M Front passenger door trim D Driver door trim I Driver air bag N Front passenger center line E Driver knee air bag J Front passenger air bag 0 Radio stack 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more informati
88. Does ABS reduce stopping distances Yes in braking situations where the wheels on a non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors including the road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of the pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the A
89. E7 40 20 40 split bench with center 20 section removed seats are manual not power does not include floor console exposed floor areas will remain untrimmed rear seats will also be vinyl trimmed requires trim code 19V Ebony and PEG 1FL 7 Maximum trailer weight ratings are calculated assuming a base vehicle except for any option s necessary to achieve the rating plus driver The weight of other optional equipment passengers and cargo will reduce the maximum trailer weight your vehicle can tow 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL s SUBURBAN COMMERCIAL FLEET EMISSIONS BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 FEDERAL EMISSIONS is ordered for delivery to a dealer located in California Connecticut Massachusetts Maryland New Jersey New Mexico New York Oregon Pennsylvania Rhode Island and Washington State for a purchase
90. E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED UNDERCOVER POLICE PKG 9 3 5 E e CARRY OVER e VICTORY RED EXTERIOR PAINT 74U 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL s IMPALA LIMITED UNDERCOVER POLICE PKG 9C3 THIS VEHICLE HAS BEEN DESIGNED FOR POLICE WORK UP TO AND INCLUDING HIGH SPEED EMERGENCY VEHICLE OPERATIONS GM RESTRICTS THE SALE OF POLICE VEHICLES AND THEY ARE NOT TO BE SOLD TO RETAIL CUSTOMERS SOME STANDARD EQUIPMENT MAY BE REPLACED BY SPECIAL EQUIPMENT WHEN THE POLICE PACKAGE 9C1 IS ORDERED 1W519 WARRANTY AIR CONDITIONING BLUETOOTH CRUISE CONTROL FLOOR COVERING DOME LAMPS GLASS GLOVE BOX MIRRORS VISOR MIRROR REARVIEW NAVIGATION SYSTEM ONSTAR RADIO RESTRAINT SYSTEM SEAT FRONT SEAT REAR SMOKER S PACKAGE SPEEDOMETER CLUSTER STEALTH MODE STEERING WHEEL THEFT DETERRENT SYSTEM TRUNK MAT WARNING LAMPS WARNING TONES WINDOW OPERATION AUXILIARY POWER FRONT AUXILIARY POWER TRUNK GROUND STUD LOCK OUT PROTECTION POWER OUTLETS WIRING DIAGRAMS WIRING PROVISION EXTERIOR LAMPS FLASHING MODEL AVAILABILITY Front wheel drive STANDARD EQUIPMENT SUMMARY 3 years 36 000 mile bumper to bumper whichever comes first see dealer for details 5 years 100 000 mile limited powertrain whichever comes first see dealer
91. EAT FRONT SEAT REAR SMOKER S PACKAGE SPEEDOMETER CLUSTER STEALTH MODE STEERING WHEEL THEFT DETERRENT SYSTEM TRUNK MAT WARNING LAMPS WARNING TONES WINDOW OPERATION AUXILIARY POWER FRONT AUXILIARY POWER TRUNK GROUND STUD LOCK OUT PROTECTION POWER OUTLETS WIRING DIAGRAMS WIRING PROVISION EXTERIOR LAMPS FLASHING MODEL AVAILABILITY Front wheel drive STANDARD EQUIPMENT SUMMARY 3 years 36 000 mile bumper to bumper whichever comes first see dealer for details 5 years 100 000 mile limited powertrain whichever comes first see dealer for details INTERIOR FEATURES Single zone manual with air filtration and environmentally friendly refrigerant R134A Not available Electronic with set and resume speed Cup holder with storage tray between seats Auxiliary interior sustained illumination Carpeting front and rear carpeted mats are available see option B34 on page 9 Tinted windshield backlight and side glass Non locking without light Visor left hand and right hand with covered vanity mirrors Inside rearview is manual day night with driver and passenger map lamps Not available Not available Electronically tuned AM FM stereo with CD player seek scan digital clock auto tone control theftlock with integrated rear window antenna radio delete is not available Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing s
92. ENTER POLICE RELAYS NOTE Connectors J P 446 and B are located above the rear auxiliary battery power junction block at the right hand rear compartment 3 J446A SA2850 SY P446A 2650 Bi BK 0 5 0 5 1A P479 AUXILARY BATTERY ISOLATION RELAY Ground Dist G402 Ground Dist 3 P278 2 P280 G405 Police relay outputs and control circuit connections are terminated in 3 connectors atthe supply power from the fusible links through the contacts of the control relays to 12 right front of the equipment mounting platform Battery power is supplied through two gauge 3 0 mm wires Each relay is operated by an 18 gauge 1 0 mm brown or blue fusible links one 100 amp and one 60 amp to three circuit breakers and two control yellow control lead terminated in the 6 cavity connector A 8 gauge 8 0 mm ground relays located in the trunk relay center A 50 amp circuit breaker feeds power directly lead is provided in the 2 cavity connector The total current available through the 12 volt from the fusible links through a 10 gauge 6 0 mm wire Two 30 amp circuit breakers power supply is 110 amps 1320 watts 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C1 WIRING DIAGRAMS 19 WIRING DIAGRAM FOR CONTROLLED POWER AND SIGNAL CIRCUITS WITH 12 VOLT POWER SUPPLY MODULE MODULE MODULE UNDERHOOD Body Control Electonic Body Control BEC Brake Control EF26 381 5810 539 343 WH BK YE VT GY VT YE 0 3
93. ERING Heavy duty vinyl replaces production carpeting carpeted mats not available see page 22 for description HEATER Engine block HOLE IN ROOF On center line requires 6F5 wiring not available with 6J5 hole see page 20 for description HOLE IN ROOF On passenger side requires 6F5 wiring not available with 6B7 hole see page 20 for description KEYLESS ENTRY TRANSMITTERS Fleet Package includes 6 additional transmitters Transmitters are not programmed Each transmitter including the two standard with the vehicle must be programmed together by a dealer at customer expense Transmitter programming is not a warranty item See you owner s manual supplement for programming information see also page 20 for customer programming of transmitters using the vehicles Driver Information Center procedure NOTE Vehicle specific common fleet transmitter frequency not available KEY COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door locks and ignition of all the vehicles in the vehicle fleet key code is an alternate to SEO 6E8 key common complete vehicle fleet not compatible with 2005 and earlier Impalas 2006 and earlier Tahoes and 2011 Caprice KEY COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door locks and ignition of all the vehicles in the vehicle fleet key code is an alternate to SEO 6E2 key common complete vehicle fleet not compatible with
94. F and against rust and corrosion Vortec 5300 V8 SFI with variable valve timing VVT active fuel management AFM FlexFuel capable of running on gasoline or E85 ethanol mixtures top speed fuel cutoff at 98 MPH Full perimeter modular with hydroformed frame rails 26 gallon 98 liters Engine and transmission auxiliary air to oil and power steering see page 24 for description Grounding straps at five additional locations see page 23 for location Extended life iridium tip Stability enhancement system An advanced computer controlled system that assists the driver with directional control of the vehicle in difficult driving conditions Each time the vehicle is started the StabiliTrak system is fully on StabliliTrak can be controlled by a StabiliTrak button on the instrument panel located below the air conditioning fan control see page 24 The condition of the system is displayed by an instrument panel StabiliTrak indicator light and Driver Information Center DIC Messages Push once Traction Control is off push and hold five seconds Traction Control and StabiliTrak is off push again and Traction Control and StabiliTrak are turned back on Power rack and pinion Coil over shock with stabilizer bar Multi link with coil springs with stabilizer bar P265 70R17 all season SBR CHECK TIRE PRESSURE will display in driver message center no spare tire sensor Full size spare lockable with outside winch type carrier mounted under frame
95. Front and rear dealer installed LPO CHROME FUEL DOOR Dealer installed LPO CHROME RECOVERY HOOKS Dealer installed Requires V76 Black recovery hooks LPO FLAT SPLASH GUARDS Black Dealer installed Not available with VQK Black molded splash guards LPO LPO FRONT AND REAR MOLDED SPLASH GUARDS Black Dealer installed Not available with SB1 flat Black splash guards LPO LPO METAL BED STORAGE BOX Dealer installed Not available with 5JY soft folding tonneau cover LPO or VPB vinyl tonneau cover with integrated support bows LPO LPO POLISHED EXHAUST TIP Dealer installed LPO REAR UNDERSEAT STORAGE Composite storage bin Dealer installed LPO RUBBER BED MAT Dealer installed Not available with VZX bed liner LPO LPO SOFT FOLDING TONNEAU COVER Dealer installed Requires UF2 LED Lighting cargo box Not available with VPB vinyl tonneau cover with integrated support bows LPO or RW6 metal bed storage box LPO LPO TAILGATE LINER Dealer installed Not available with VZX bed liner LPO LPO TONNEAU COVER HARD TRI FOLDING WITH VINYL COVER Dealer installed Not available with VPB soft tonneau cover LPO 5JY soft folding tonneau cover LPO or RW6 metal bed storage box LPO LPO VINYL TONNEAU COVER WITH INTEGRATED SUPPORT BOWS Dealer installed Requires UF2 LED Lighting cargo box Not available with 5JY soft folding tonneau cover LPO or RW6 metal bed storage bo
96. LEET ASSIST STEPS DEFOGGER DOOR HANDLES DOOR LOCKS FASCIA FRONT FASCIA REAR HEADLAMPS KEYLESS ENTRY KEYS LUGGAGE RACK MIRRORS REAR LIFTGATE RECOVERY HOOKS WINDSHIELD WIPERS ALTERNATOR BATTERY BRAKES ENGINE FRAME FUEL TANK CAPACITY OIL COOLERS STABILITRAK STEERING SUSPENSION FRONT SUSPENSION REAR TIRES TIRE PRESSURE MONITOR TIRE SPARE TIRE SPARE CARRIER TRAILERING EQUIPMENT TRANSFER CASE TRANSMISSION WHEELS EXTERIOR FEATURES Black mounted between front and rear wheels Electric rear window Black Power programmable with lockout protection door lock cylinder no longer available on passenger front door and rear liftgate Color keyed Black when special paint is ordered Color keyed Black when special paint is ordered Dual halogen composite with automatic exterior lamp control and flash to pass feature Includes two transmitters Single two sided random code for ignition and drivers door only Roof mounted Black side rails center rails and luggage rack delete are available Outside heated power adjustable manual folding Black Liftgate liftglass with rear window washer and wiper power liftgate not available Two front Black Chrome only available on LTZ Intermittent wet arm with flat blade and pulse washers CHASSIS FEATURES 160 amp 660 CCA maintenance free rundown protection and retained accessory power 4 wheel antilock 4 wheel disc vac power See engine
97. Load floor length to center 2nd seat at floor in mm 49 4 1255 TIRES Inside width between wheel house in mm 49 1 1247 Type S Rated All Season Cargo area height in mm 41 7 1059 Size P265 70R17 Cargo volume maximum behind front seat cu ft liters 108 9 3084 Cargo volume maximum behind second seat cu ft liters 60 3 1707 WHEELS NOTE For additional dimensional data go to gmupfitter com Type Steel S Rated All Season PASSENGER COMPARTMENT VOLUME INDEX cu ft liters 32 x75 Passenger compartment volume index 121 8 3449 CHASSIS FUEL ECONOMY RATINGS CITY HIGHWAY COMBINED Full perimeter steel 5 3L engine AWD 15 21 17 Front suspension Independent single Projected EPA label values actual mileage will vary with options driving conditions driving coil over shock with stabilizer bar habits and vehicles condition Rear suspension Multi link with coil spring ALTERNATOR Steering type Power rack and pinion me 7 REMY _ Steering ratio 17 75 1 Amps 77 F 25 C 160 BATTERY TAHOE POLICE ALTERNATOR OUTPUT Type Maintenance free BCI group size LN3 Volts 12 Amp hour rating 80 ee Cold cranking amps 0 F 18 C 660 Reserve capacity 80 F 27 C 135 minutes CURRENT AMPS 400 600 800 1200 1400 1600 1800 2000 2200 2400 ENGINE SPEED RPM NORMAL IDLE SPEED 600 650 RPMS UN COMPUTER CONTROLLED IDLE SPEED RANGE PARK 800 1000 RPM 3 Cargo and load capacity limited by weight and distribution
98. N USAGE MODELS On off road HOAD WHEELS COD SME DESCRIPTION SIDEWALL USAGE MOMS NU As Mel So ad ton 17 x 7 5 4 5 spoke SPARE WHEELS CODE SME DESCRIPTION SIDEWALL USAGE MODELS NOTE Polished forged aluminum includes chrome center caps and steel spare SEATS AND INTERIOR TRIM 5 Standard Equipment Available dashes Not Available INTERIOR LIGHT LIGHT CASHMERE TITANIUM DARK DARK CASHMERE 1 TITANIUM STANDARD Front 40 20 40 AZ3 Premium cloth 19C 33C COMMERCIAL 1FL reclining split bench AVAILABLE Front 40 20 40 Vinyl 19V COMMERCIAL 1FL reclining split bench OPTIONAL Front high back A95 Premium cloth 19C 33C COMMERCIAL 1FL reclining bucket INTERIOR EXTERIOR COLOR TOUCH UP LIGHT TITANIUM DARK CASHMERE SOLID PAINT CODE PAINT NUMBER DARK TITANIUM LIGHT CASHMERE MU WABSS 0A Aa gt GA WATOS 0A A sou WA9A AA 0 Aa gt GN WASSER A A AA GW JA U WA 103V Champagne Silver Metallic GWT WA 102V A PA 1 Extra Cost 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 6 SUBURBAN COMMERCIAL FLEET 1FL AVAILABLE EXTERIOR COLORS i D Silver Ice Black Mocha Steel Summit White Crystal Red Concord Champagne Metallic Metallic Tintcoat Metallic Silver Metallic New NOTE Additional Charge Actual colors may vary SEO P
99. N BFR 9382 Blue BFC BGG 9403 Tan BEO BFS ACTUAL COLOR MAY VARY 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 IMPALA LIMITED 9C1 amp 9C3 PAINT SCHEMES SED COLOR SCHEME W001 OPTION CODE 1PA PANT CODE1 LEGEND cope2 TT SED COLOR SCHEME W002 OPTION CODE 1PB Paint CODE1 LEGEND cope 2 SEO COLOR SCHEME WO003 OPTION CODE 1PC Paint CODE1 LEGEND cope 2 TT SEO COLOR SCHEME W006 OPTION CODE 1PF PAINT COE1 LEGEND cope 2 TT SEO COLOR SCHEME W008 OPTION CODE 1PH PANT CODE1 LEGEND cope TT SEO COLOR SCHEME W009 OPTION CODE PI PAINT COE1 LEGEND cope 2 TT SED COLOR SCHEME W012 OPTION CODE 1PL PANT CODE1 LEGEND cope 2 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 DRIVER INFO CENTER 15 UNITED STATES CERTIFIED SPEEDOMETER CLUSTER CANADIAN SIMILAR DRIVER INFORMATION MESSAGE CENTER SPEEDOMETER CERTIFICATION at ambient temperature of 1010 120 degres F 23 49 Celis Inaccuracies due to vehicle speed sensing are included ACTUAL VEHICLE SPEED INDICATED SPEED 0 TO 120 MPH i 2 MPH Message may not be displayed in Police Package 0 TO 193 KPH 8 KPH tt Message flashes at engine start ttt Can be set as default condition The speedometer calibration is for the 3 6L engine automatic transmission with a 2 44
100. N HOT IDLE ENGINE ICE POSSIBLE DRIVE WITH CARE WATER FLUID LOW ADD FLUID OPEN THEN CLOSE DRIVER PASSENGER WINDOW CAPTURED SPEED 2014 Caprice police cars certified speedometer calibration Specifications at ambient temperature of 10 to 120 degrees F 23 to 49 Celsius Inaccuracies due to speed sensing are included ACTUAL VEHICLE SPEED INDICATED SPEED 0 TO 120 MPH 2 MPH UE IE 0 TO 193 KPH 3 KPH Note Vehicle may arrive with TRANSPORT MODE activated The speedometer calibration is for the 6 0L V8 engine automatic to conserve battery life during transportation Contact transmission with a 2 92 axle and P235 50R18 tires and the 3 6L V6 a GM dealer for proper completion of Pre Delivery engine automatic transmission 2 92 axle and P235 50R18 W rated tires Inspection PDI 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 10 CAPRICE POLICE 9C1 DRIVER CUSTOMIZATION FEATURE 70809 CERTIFIED DRIVER INFORMATION MESSAGE CENTER VIEWING THE DRIVER INFORMATION CENTER DIC REQUIRES THE ENGINE TO BE RUNNING THE DIC IN THE CENTER OF THE INSTRUMENT CLUSTER DISPLAYS INFORMATION AND WARNINGS ABOUT THE VEHICLE DRIVER INFORMATION SELECTOR VF d The DIC is operated via the controls on the Turn Signal lever at the left side of the steering column The SET CLR button sets or clears the displayed menu The MENU button displays the SPEED UNIT The momentary ROTARY SWITCH control will scroll
101. ND 7X7 SPOTLAMPS 7X8 AND 7X9 SPOTLAMP PROVISIONS Spotlamp left hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused Spotlamps left and right hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused Spotlamp provision left hand provision for customer installed spotlamp includes hole through pillar mounting bracket and accessible power connector 7 9 Spotlamp provision left and right hand includes same components as option 7X8 NOTE Lamp bulbs are halogen 12volt 100 watt H 3 rated at 245 000 candle power For wiring diagrams and fuse location see page 25 Customer furnished spotlamp assembly must be installed to avoid interference with deploying passenger airbag Factory installation of spotlamps and spotlamp provisions are recommended Field installation of spotlamps must not interfere with proper deployment of the roof rail airbag in the event of a crash BB7 AND 6J5 HOLE IN ROOF PANEL Hole is drilled near center line of roof panel approximately 29 inches rearward of windshield opening Hole is drilled on passenger side of roof panel approximately 29 inches rearward of windshield opening and approximately 6 inches inboard from passenger side door NOTE Only one roof hole location may be ordered SEO 6F5 roof wiring is required when SEO 6B7 or SEO 6J5 are ordered AMF PACKAGE OF 6 TRANSMITTERS WITHOUT WITH REMOTE START
102. O BE SOLD TO RETAIL CUSTOMERS CK10706 WARRANTY AIR CONDITIONING ASSIST HANDLES BLUETOOTH COMPASS CONSOLE OVERHEAD CRUISE CONTROL DOME LAMPS FLOOR COVERING GLASS GLOVE BOX MIRROR NAVIGATION SYSTEM ONSTAR OUTSIDE TEMP DISPLAY RADIO RESTRAINT SYSTEM SEAT FRONT SEAT REAR SPEEDOMETER CLUSTER STEALTH MODE STEERING WHEEL THEFT DETERRENT SYSTEM VISORS WARNING TONES WINDOW OPERATION AUXILIARY POWER FRONT AUXILIARY POWER REAR GROUND STUDS LOCK OUT PROTECTION POWER OUTLETS WIRING DIAGRAMS WIRING PROVISION EXTERIOR LAMPS FLASHING MODEL AVAILABILITY 4 wheel drive STANDARD EQUIPMENT SUMMARY 3 years 36 000 mile bumper to bumper whichever comes first see dealer for details 5 years 100 000 mile limited powertrain whichever comes first see dealer for details INTERIOR FEATURES Dual zone manual climate control with individual climate settings for driver and front passenger includes auxiliary rear air conditioning and heat rear operated from front control only Front passenger and second row outboard front passenger assist handle is deleted when passenger side spotlamp is ordered Not available Standard displayed in Driver Information Center Includes map lamps Electronic with set and resume speed Dome lamps cargo lamp with sustained lamps feature and map lamps see page 24 interior exterior lamp control to turn off dome light Black vinyl floor and load floor behind second row
103. ON LABEL 1GNLC2E0BR8152140 PDBJCH CC10706 AGK AG2 ALO AMF ARQ AI8 AYO 75 A76 BDR B3B B42 B86 C67 DK2 E2C FE9 FRY IPG JA9 KDI KG4 LGD MXO NK5 NT7 N99 OST QPP R7V R N R97 SLM T53 UM UNG UI7 Uwe U7 Vi7 V8D WL9 ZFH 190 HU 191 3FL GAS 6E2 6HP 61 6J3 6J4 7B3 7HP 7M9 7X6 8MZ PPV 9MZ BC CC U 636R A Service Parts Identification SPID Label provides Vehicle Identification Number VIN specific Option Code content list Engineering Model Number Nameplate body style Exterior paint system Exterior paint color code and Interior trim level and color The SPID label for the Tahoe is located on the inner surface of the instrument panel storage compartment glove box STABILITRAK CONTROL The Stabilitrak stability control system control button is located below the air conditioning fan control See pages 3 or 15 of this manual for an operation description of the stability control system or see your Owner s Manual 2014 CHEVROLET MUNICIPAL ENGINE OIL COOLER Engine oil cooler located in the left hand radiator tank Cooler consists of an inlet and an outlet pipe attached to the engine oil filter adapter which transmits the oil to the cooler and then back to the engine The cooler itself consists of numerous flat plates through which the hot oil flows transmitting heat to the coolant and cooling the oil TRANSMISSION OIL COOLER External air to oil cooler is mounted in front of coolant radiat
104. ONS CC15543 CK15543 CC15743 CK15743 eWD Short Box 4WD Short Box 2WD STD Box 4WD STD Box Crew Cab Crew Cab Crew Cab Crew Cab SPECIFICATIONS Front shock absorber diameter in mm 1 81 46 1 81 46 1 81 46 1 81 46 Front stabilizer bar diameter in mm 1 35 34 1 35 34 1 35 34 1 35 34 Rear shock absorber diameter in mm 1 38 35 1 38 35 1 38 35 1 38 35 Turning diameter curb to curb ft m 47 2 14 4 47 2 14 4 48 6 14 8 48 6 14 8 CAPACITIES Front axle Ibs kg 3 650 1 656 3 950 1 792 3 650 1 656 3 950 1 792 Front spring capacity Ibs kg 3 650 1 656 3 950 1 792 3 650 1 656 3 950 1 792 Rear axle2 Ibs kg 3 950 1 792 3 950 1 792 3 950 1 792 3 950 1 792 Rear spring capacity Ibs kg 3 950 1 792 3 950 1 792 3 950 1 792 3 950 1 792 Curb weight Ibs kg 4 942 2 242 5 139 2 331 5 000 2 268 5 197 2 357 Cargo volume cargo box cu ft liters 53 4 1 512 3 53 4 1 512 3 61 0 1 727 5 61 0 1 727 5 Payload Ibs kg 2 007 910 1 957 888 1947 883 1 883 854 Gross Vehicle Weight Rating GVWR Ibs kg 6 900 3 130 7 100 3 221 6 900 3 130 7 100 3 221 Front Gross Axle Weight Rating GAWR Ibs kg 3 650 1 656 3 950 1 792 3 650 1 656 3 950 1 792 Rear Gross Axle Weight Rating GAWR bs kg 3 950 1 792 3 950 1 792 3 950 1 792 3 950 1 792 Fuel capacity approximate gallon liters 26 98 26 98 26 98 26 98 Seating capacity 6 6 6 6 1 Mass values are calculated assuming nominal equipment Actual values may vary due to equipment loading 2 Mass values are calculated assuming
105. OVISIONS Spotlamp left hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused Spotlamps left and right hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused Spotlamp provision left hand provision for customer installed spotlamp includes hole through pillar mounting bracket and accessible power connector Spotlamp provision left and right hand includes same components as option 7X8 NOTE Lamp bulbs are halogen 12volt 100 watt H 3 rated at 245 000 candle power For wiring diagrams and fuse location see page 20 Customer furnished spotlamp assembly must be installed to avoid interference with deploying passenger airbag Factory installation of spotlamps or spotlamp provisions are recommended The windshield pillars are designed with ultra high strength steel to enhance crash worthiness and special tooling is used to locate and drill the lamp shaft holes The spotlamp brackets are attached with special fasteners to avoid drilling the high strength steel reinforcement 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE 9C1 SPECIAL EQUIPMENT OPTIONAL 15 B42 MAT TRUNK COVERING FLOOR Custom fitted heavy duty vinyl molded edge to keep spills contained removable for easy cleaning T53 LAMPS TRUNK LID WARNING Hole is drilled near center line of roof panel approximately 29 inches rearward of windshield opening Includes
106. RING DIAGRAM FOR OPTION TRW EMERGENCY ROOF LAMP Power Distribution Fuse PDM LBEC Page Igt_int 3 Page pwr_list 21 H 15A I Lamps interior BCm via MBEC 230 BEACONSW DIM 240 EMERG LP BATT Switch Emergency Lamp 900 sw emerg Ip 002 UPC FNA BACKLIGHT Emergency Lamp SW INDICATOR 15491277 5990 WH 0 5 POA_OHCNSL 1050 BEACONSW GND L Ground Distribution GND Zone 10 Page Gnd Dist 12 Power Distribution Fuse S ROOF USEC Page pwr_dist 11 ROOF_BCN_BATT 3140 RD WH 9 0 POA_CHCNSL Relay Roof Beacon 900_relay_beacon_roof 001 UPC FNA 12110541 5589 D i 3 0 POA_OHCNSL GN 885989 Blunt Cut 1050 BEACONSW Park Green H LI Ground Distribution GND Zone 10 Page Gnd Dist 12 AT ROOF NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL BA1050 Blunt Cut Black 1060 JBEACONSW_GND 1 i 1 Ground Distribution GND Zone 10 Page Gnd Dist 10 VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 WIRING DIAGRAMS WIRING DIAGRAM FOR OPTION WX7 IN LINE CONNECTOR Speaker Output Output oF oF A a E WX7 inline harness added here to send LF and RF outputs to LR and RR speakers Blunt cut circuits from front speakers are coiled in front under the instrument panel To LF To RF To LR To RR Speakers Speakers Speaker Speak
107. S _ Steel x25 Amps 77 F 25 C 170 KW7 IMPALA POLICE ALTERNATOR OUTPUT CHASSIS 200 Frame Unitized body 190 Engine cradle Aluminum 180 Front suspension Independent MacPherson Strut 170 coil spring over strut and stabilizer bar Rear suspension Independent Tri Link MacPherson Strut coil spring over strut and stabilizer bar 105 Steering type Power rack and pinion un Steering ratio center 14 11 BATTERY 110 Type Maintenance free 100 BCI group size 34 Sus Volts 12 ENGINE SPEED RPM Amp hour rating 70 Boost Level Park Neutral Drive Cold cranking amps 0 F 18 720 TT Reserve capacity 80 F 27 C 125 minutes 7 m VEHICLE WEIGHT Ibs kg a 93 3 Cargo and load capacity limited by weight and distribution 4 EPA estimated MPG 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payload capacity includes weight of driver passengers optional equipment and cargo 10 Curb weight in operational status with 100 fuel fluids and standard base equipment excludes optional content Published dimensions indicated are at curb weight GVWR 4938 2240 4938 2240 Curb weight 3736 1695 3743 1698 Payload includes 5 passengers and space saver spare tire 1140 517 1173 532 NOTE See your vehicle tire and loading information label for specific weight values See your
108. TECHNICAL MANUAL AIR BAGS FAG 1 Can specialty vehicle equipment e g radar devices video cameras computers meters radio trees shotguns etc still be mounted in cars with passenger side air hags Yes but care must be taken to mount the equipment outside of the deployment zone Air bags inflate with great force and will interact with any object in the deployment zone Therefore to reduce the risk of injury to vehicle occupants GM recommends that the air deployment zone be kept free of any equipment If a piece of equipment were to become dislodged it could strike an occupant in the vehicle and result in injury The likelihood of an object becoming dislodged is influenced by many factors including the proximity of the object to the inflatable restraint the size and shape of the object and the means by which the object is secured to the vehicle In addition to these factors the trajectory and velocity of a dislodged object can be influenced by the type and severity of vehicle crash Objects that are in the deployment zone but do not become dislodged by an inflating air bag can still affect the performance of the air bag For example such objects could tear the fabric or affect the shape of the air bag thus reducing the ability of the bag to provide restraint Is it possible to shield equipment that is installed in the passenger side frontal air bag deployment zone in a manner that will allow full and safe air bag deployment Due
109. TS FRONT SUSPENSION TIRES TIRE PRESSURE MONITOR TRACTION CONTROL TRANSMISSION WHEELS WHEEL CENTER CAP EXTERIOR FEATURES Two sided galvanized steel for all exterior body panels except roof where not needed Optional See option B86 on page 9 Electric rear window Power non programmable automatic door locking and unlocking feature is disabled child safety locks in rear doors Driver door lock key cylinder only key lock cylinder is not available in the front passenger door Dual halogen composite includes flash to pass feature and automatic lamps control with daytime running lamps to delete automatic control see option 9G8 on page 9 and exterior lamps control on page 17 Dual note Includes two transmitters with non functional panic button the keyless entry system used on the police Impala includes a stealth mode feature When the unlock or lock button is depressed no exterior lamps or audible sounds are activated however the interior OEM dome lamp will illuminate unless option 7Y6 lamps Inoperative Dome and Courtesy Lamps is ordered during remote start feature running lamps will remain illuminated additional transmitters are available see option AMF on page 9 Two sided random code for ignition driver door and trunk only single key locking system to operate entire fleet is available fleet coded single key is available see 6E2 and 6E8 option on page 9 Mounting hardware located in glove box front bracke
110. Theft Deterrent is not an orderable option See your dealer for additional information Driver and passenger with covered mirrors not illuminated Brake safety belt air bag anti lock check engine Sport Mode StabiliTrak high beam and cruise control Key in ignition driver door open and safety belt reminder chime Power front and rear Express Down front only with rear window lockout controls located on front door panels 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 6 MyLink functionality varies by model Full functionality requires compatible Bluetooth smartphone and USB connectivity for some devices MyLink on Spark and Sonic does not include functionality such as enhanced voice recognition Gracenote and CD player 7 The Bluetooth word mark is a registered trademark owned by Bluetooth SIG Inc and any use of such mark by GM is under license Go to gm com Bluetooth to find out which Bluetooth phones are compatible with the vehicle 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C13 ELECTRICAL FEATURES AU
111. ULTS IN BOLD DISPLAY SETTINGS Home Page Menu Display Off VEHICLE LOCATOR LIGHTS On Off VEHICLE SETTINGS EXIT LIGHTING gt Off gt 30 sec gt 60 sec gt 120 sec HOME PAGE MENU gt Customize gt Sort gt Restore Home Page Defaults DOOR OPEN ANTI LOCKOUT gt On Off DISPLAY OFF This selection blanks radio screen touch screen anywhere AUTO DOOR LOCK gt On Off to restore AUTO DOOR UNLOCK gt All Door gt Driver Door gt Off DELAY DOOR LOCK gt On Off VEHICLE SETTINGS CLIMATE AND AIR QUALITY COMFORT AND CONVENIENCE REMOTE UNLOCK FEEDBACK gt Flash Lights gt Off LIGHTING REMOTE LOCK FEEDBACK gt Lights Horn gt On Off gt Lights Only POWER DOOR LOCKS gt On Off gt Horn Only gt On Off gt Off REMOTE LOCK UNLOCK START REMOTE DOOR UNLOCK gt Driver Door gt All Doors RETURN TO FACTORY SETTINGS Yes No INBOX Select Contact Listen Reply Call SETTINGS Manage Predefined Messages NOTE REFER TO THE OWNERS MANUAL FOR DETAILED HOME PAGE ICON SETUP AND OTHER RADIO FUNCTION INFORMATION MENU ITEMS IN RED DESCRIBE CUSTOMIZATION TYPICAL FOR LAW ENFORCEMENT USAGE BOLD STATUS IS FACTORY DEFAULT CONDITION REMOTE TRANSMITTERS DO NOT FUNCTION WHEN A KEY IS DETECTED IN THE IGNITION 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 12 CAPRICE POLICE 9C1 SPECIAL EQUIPMENT STANDARD V8 ENGINE OIL COOLER Engine Oil Engine Coolant The oil to coolant engine oil cooler system is mounted on the left side
112. VERING Full length Black rubberized vinyl MIRROR Inside rearview manual day night POWER OUTLETS Two auxiliary on engine console with cover 12 volt AM FM stereo seek and scan digital clock and 2 front door speakers RADIO SEATS FRONT SEATS REAR SEATING SPEEDOMETER CLUSTER STEERING COLUMN THEFT DETERRENT EXTERIOR FEATURES BUMPER FRONT BUMPER REAR DOORS Painted Black Painted Black with step pad Swing out side 60 40 split on passenger side only Solar Ray deep tinted enhanced technology rear most side glass All windows except light tinted on windshield and driver and front passenger side glass enhanced technology rear most side GLASS windows 3 layer special glass is designed to help reduce the risk of ejection during a crash swing out rear cargo door windows swing out side door windows GRILLE HEADLAMPS LAMPS LICENSE PLATE KIT MIRRORS TIRE PRESSURE MONITOR WINDSHIELD WIPERS CHASSIS FEATURES ALTERNATOR 105 amp without rear A C 145 amp with rear A C 145 amp standard on 2LS model BATTERY 600 CCA with run down protection and retained accessory power on 1LS model Dual heavy duty 770 CCA standard on 2LS model 4 wheel disc with 4 wheel anti lock Vortec 4 8L V8 SFI FlexFuel or 6 6L V8 turbo diesel Aluminized stainless steel muffler and tailpipe 31 gallon 117 3 liters Oil life External transmission Vehicle stability control BRAKES ENGINE EXHAUST FUEL T
113. XILIARY POWER FRONT Wiring provision for total of 110 amp auxiliary power at right front corner of the center floor mounting plate Three connectors provide 50 amp battery power and ground two 30 amp relay controlled battery circuits and signal circuits for ignition control HOT in START RUN and ACCESSORY RUN vehicle speed signal park enable and a customer switched surveillance circuit See page 13 CAPTURED SPEED This standard feature allows the officer to capture the speed of the Caprice while pacing another vehicle see page 12 AUXILIARY POWER TRUNK Two auxiliary battery power connection studs in trunk provide a total of 120 amps See page 13 GROUND STUD Auxiliary located in trunk see page 13 LOCK OUT PROTECTION Feature is programmable ON or OFF via the vehicle radio customization menu The factory default is Lock Out Protection OFF Remote keyless entry will not function when vehicle is locked with key in the ignition under this condition a spare key is required to operate door lock cylinder for entry POWER OUTLET One 12 volt 20 amp located on the lower instrument panel Battery power is present when ignition is in RUN position Power will remain on for approximately 10 minutes after the ignition is turned to the OFF position RETAINED ACCESSORY POWER Power windows and audio system remain operational after ignition is switched off for 10 minutes or until a door is opened WIRING PROVISION FOR EXTERIOR LAMPS FLASHING Forward lamp
114. XTERIOR BODY COLORED PARTS Victory Red special painted exterior body parts in lieu of glossy Black color normally installed with special painted bodies Victory Red painted parts will consist of front fascia rear bumper fascia rear liftgate license plate applique and rear liftgate handle door handles and body side moldings Mirrors rear D pillar applique and liftgate spoiler will remain Black Requires SEO TGK special paint and special paint color WA9260 Victory Red Includes RPO B85 body side moldings 6J7 FLASHER SYSTEM HEADLAMPS AND TAIL LAMPS DRL compatible headlamp flasher module with control wire and body control module rear lamp flashing see page 27 B30 FLOOR COVERING Color keyed carpeting indudes rear cargo floor B58 FLOOR MATS Color keyed carpeted front and 2nd row not available with vinyl floor covering K05 HEATER Engine block PPV IDENTIFIER Police Package 6E2 KEY COMMON Complete vehide fleet provides a single key cut with a specific code that is common to the door lock and ignition of all the vehicles in the vehide fleet this key code is an alternate to SEO 6E8 key common complete vehicle fleet not compatible with 2005 and earlier Impalas 2006 and earlier Tahoes and 2011 and later Caprice 6E8 KEY COMMON Complete vehide fleet provides a single key cut with a specific code that is common to the door lock and ignition of all the vehicles in the vehide fleet this key code is an alternate to SEO 6E2 key common co
115. aint orders that contain less than five vehicles will be delayed until five unit minimum is received for batch production 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 18 TAHOE 4WD 5W4 DRIVER INFORMATION CENTER UNITED STATES SPEEDOMETER CLUSTER CANADIAN SIMILAR MESSAGE CENTER CHANGE ENGINE OIL SOON SERVICE AIR BAG CHECK TIRE PRESSURE SERVICE BATTERY CHARGING SYSTEM PRESS RESET LF RF LR RR ENGINE HOURS DRIVER DOOR OPEN SERVICE BRAKE SYSTEM ENGINE HOT A C TURNED OFF ENGINE OIL LOW ADD OIL ENGINE OVERHEATED IDLE ENGINE ENGINE OVERHEATED STOP ENGINE ENGINE POWER IS REDUCED FUEL LEVEL LOW HOOD OPEN LEFT REAR DOOR OPEN OIL PRESSURE LOW STOP ENGINE PASSENGER DOOR OPEN REAR ACCESS OPEN REMOTE KEY LEARNING ACTIVE REPLACE BATTERY IN REMOTE KEY RIGHT REAR DOOR OPEN SERVICE BRAKES SOON SERVICE THEFT DETERRENT SYSTEM SERVICE TIRE MONITOR SYSTEM SERVICE TRACTION CONTROL SERVICE STABILITRAK STABILITRAK OFF SERVICE 4 WHEEL DRIVE TIGHTEN GAS CAP TIRE LEARNING ACTIVE TRACTION CONTROL OFF TRANSMISSION HOT IDLE ENGINE TURN SIGNAL ON WASHER FLUID LOW ADD FLUID NOTE The Tahoe Police Package and Special Service Package are not equipped with DIC buttons The instrument cluster odometer trip stem is used to display the following messages odometer engine hours trip odometer tire pressure remote keyless entry relearn remote key programming and DIC language See the Tah
116. al or near frontal crashes But they are designed to inflate only if the impact speed is above the system s designed threshold level In addition your vehicle has dual stage frontal air bags which tailor the the amount of restraint according to crash severity For moderate frontal impacts the air bags inflate at a level less than full deployment For more severe frontal impacts dual stage frontal air bags deploy at full levels If the front of your vehicle goes straight into a wall that doesn t move or deform the threshold level of the reduced deployment is about 12 to 16mph 19 to 15 km h and the threshold level for a full deployment is about 18 to 24 mph 29 to 28 5 km h The threshold level can vary however with specific vehicle design so that it can be somewhat above or below this range If your vehicle strikes something that will move or deform such as a parked car the threshold level will be higher The driver s and right front passenger s frontal air bags are not designed to inflate in rollover side impacts or rear impacts because inflation would not help the occupant Seat mounted side impact air bags are designed to inflate in moderate to severe side crashes The side impact air bags will inflate if the crash severity is above the designed threshold level The threshold level can vary with specific vehicles design The side impact air bags are not designed to inflate on frontal or near frontal impacts or rear impac
117. also located in the front passenger foot well upfitter harness A 10 amp fuse EF131 protects both circuits and is located in the engine compartment fuse center The total power available for the combined front and rear circuits is 60 watts NOTE If 50 amp battery power is not present at the front compartment upfitter harness verify the connection of the topmost blue of two connectors located above the right hand rear compartment junction block For wiring diagram see pages 18 and 19 See also page 13 Rear Auxiliary Power and Ground Stud and page 16 55 Auxiliary Battery For wiring diagram see page 17 EXTERIOR LAMPS CONTROL WS Delete Daytime Running Lamps and Automatic Headlamps This option disables the Daytime Running Lamps and Automatic Headlamps control feature Exterior lamps are manually controlled only Option VVS is not available in Canada The headlamp control on the driver s side of the instrument panel operates the headlamps If your Caprice does not have option VVS Daytime Running Lamps and Automatic Headlamps Delete the Daytime Running Lamps and Automatic Headlamps can be turned off for one ignition cycle by rotating the control knob momentarily counter clockwise Rotating the headlamp switch again will turn the daytime running lamps or automatic headlamps back on In Canada the Daytime Running Lamps and Automatic Headlamps can be turned off if the transmission is in Park See also Caprice owner s manual 201
118. amps manually will override the flashing module and the high beam headlamps will operate continuously During night time conditions the tail lamps will turn on automatically If Option 968 is present the low beam headlamps and tail lamps will not come on Two 4 inch red single faced lamps are mounted behind rear seatback to be viewed automatically The Center Mounted Stop Lamp will operate only when the service through rear window The turn signal circuits extend in loops coiled in the right front brakes are applied foot well for customer connection to control switching These lamps function as auxiliary turn signal stop lamps and vehicle hazard flashers A 15 amp fuse labeled HDLP MDL protects the flasher module circuit The fuse is located in the under hood fuse block in the engine compartment on the passenger side of the vehicle See also the Owner Manual for more information Activation of the headlamps flashing and rear lamps flashing can be separated by opening the dark blue yellow BCM circuit at the flasher module connector C122 F and applying a customer switched ground to the harness side of the wire at the connector Power to the dark green 1209 wire must be OFF to flash the rear only Warning BCM will be damaged if 12V power is connected to the dark blue yellow wire NOTE For wiring diagram see page 24 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 o MPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP OPT 7X6 A
119. ance is reduced Do insurance companies give a discount for ABS Yes many insurance companies give discounts that range from 596 to 1096 In the states of New York and Florida all insurance companies are required to give an ABS discount of 596 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 28 ANTI LOCK BRAKING SYSTEM IMPORTANT DRIVING SAFETY TIPS A Always maintain a safe B Always drive carefully C Itisa good idea to practice an following distance ABS does not especially on slippery surfaces ABS cannot ABS activated stop and get the feel allow you to stop on a dime Generally a create friction between the tires and the road of the brake pedal However please make 2 second following distance is considered surface it can only give the driver the sure it s at a safe time with no obstacles in safe in ideal conditions Watch the vehicle maximum advantage of the existing your path And you only really need to try in front of you pass a fixed marker such as a adhesion If the vehicle is traveling on a it once or twice to know what happens sign Count seconds one thousand one surface with no adhesion the
120. andard or optional on all North American passenger vehicles and light truck lines The computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors monitor how fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is approaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles
121. assenger side The wiring circuits are routed from under the instrument panel to a 1 foot 30 cm coil secured in the area behind the grille There are four 16 gauge 1 0 mm wires for connecting to the grille lamps GRY TAN and siren speaker LT BU LT GN The SEO 6J3 wiring provision also includes one 18 gauge 0 8 mm control wire for the SEO 6J7 Exterior Lamps Emergency Flashing System When option 6J7 is installed without option 6J3 only the dark green red control wire is proved for connection to custo mer furnished 12 volt switching to turn the Emergency Flashing System on or off NOTE For wiring diagram see page 29 WX7 WIRING PROVISION FOR FRONT SPEAKERS Approximately 60 inches 1 5 m of auxiliary speaker wiring is routed from the front door and windshield pillar speakers and coiled under the instrument panel The wiring permits connection of the front speaker pairs to customer installed communication equipment Vehicle radio front speaker outputs are re routed to the rear speakers to maintain the required open door key in ignition audible warning NOTE For wiring diagram see page 31 6J4 WIRING PROVISION FOR HORN SIREN CIRCUIT This provision permits customer connection of a switch to select either horn of siren operation when the horn pad is pressed A 22 gauge 0 35 mm2 wire is connected to an in line connector in the horn circuit of the instrument panel harness under the instrument panel The end of this harn
122. ate friction between the tires and the road surface it can only give the driver the maximum advantage of the existing adhesion If the vehicle is traveling on a surface with no adhesion the best ABS in the world cannot provide a shorter stopping distance or good steering o ANTI LOCK BRAKING SYSTEM AND STABILITRAK C Itisa good idea to practice an ABS activated stop and get the feel of the brake pedal However please make sure it s at a safe time with no obstacles in your path And you only really need to try it once or twice to know what happens two seconds then you are too close to the vehicle in front of you Also if the roads are wet or icy or visibility is poor you should increase your following distance ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK Q How does StabiliTrak work A StabiliTrak has the ability to apply control forces to the vehicle independent of the driver StabiliTrak uses sensors to continuously compare the path indicated by the steering wheel position to the vehicle s actual path If a discrepancy is detected StabiliTrak selectively controls vehicle brakes and engine torque to create a yaw moment that helps restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak has the ability to help correct both understeer where the vehicle is not turning as much as the steering wheel position indicates and oversteer where the vehicle is turning mor
123. available included with HCQ vinyl rear seat see page 15 for description HOLE IN ROOF On center line not available with 6J5 hole with sealing harness grommet in roof hole HOLE IN ROOF On passenger side not available with 6B7 hole with sealing harness grommet in roof hole KEYS AND KEYLESS ENTRY TRANSMITTERS 6 cut keys with integrated remote keyless entry includes Remote Vehicle Start Transmitters are not programmed Each transmitter including the two standard with the vehicle must be programmed together by the customer or by a dealer at customer expense Transmitter programming is not a warranty item See your owner s manual for additional programming information see page 17 for description Note Common frequency keyless entry for fleet keyed vehicles not available each fleet keyed vehicle will have a different keyless entry frequency KEYS COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door locks and ignition for all the vehicles in the vehicle fleet key code is an alternate to SEO 6E4 key common complete vehicle fleet NOTE Not compatible with previous year Caprice Impala and Tahoe police vehicles KEYS COMMON Complete vehicle fleet provides a single key with a specific code that is common to the door locks and ignition of all the vehicles in the vehicle fleet key code is an alternate to SEO key common complete vehicle fleet NOTE Not compatible with previous year Cap
124. bags are not designed to inflate in rollover side impacts or rear impacts because inflation would not help the occupant Seat mounted side impact air bags are designed to inflate in moderate to severe side crashes The side impact air bags will inflate if the crash severity is above the designed threshold level The threshold level can vary with specific vehicles design The side impact air bags are not designed to inflate on frontal or near frontal impacts or rear impacts because inflation would not help the occupant Roof rail mounted head curtain air bags are designed to inflate in moderate to severe side crashes In addition certain vehicles have head curtain air bags which are also designed to inflate in situations where an impending rollover condition is identified by the vehicle s rollover sensing system and or frontal or near frontal impacts if the crash severity is above the designed threshold level Safety belt pretensioners at the driver and front passenger seat positions are designed to deploy in frontal near frontal side and rear crashes that exceed the threshold level of crash severity to help reduce slack in the safety belt Safety belt pretensioners will also deploy in impending rollover situations How long will the air bag remain inflated It takes approximately 1 20th of a second to fully inflate the frontal air bags This is faster than the blink of an eye The air bags begin to deflate immediately helping to sto
125. ble at rear doors but NET from driver position 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL e TAHOE PPV amp 5W4 SPECIAL EQUIPMENT OPTIONAL 7X6 AND 7X7 SPOTLAMPS 7X6 Spotlamp left hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused 7X7 Spotlamps left and right hand pillar mounted unity 6 inch with replaceable H3 halogen bulb independently fused NOTE Lamp bulbs are halogen 12 volt 100 watt H 3 rated at 245 000 candle power For wiring diagrams and fuse location see page 31 Customer furnished spotlamp assembly must be installed to avoid interference with deploying passenger airbag Factory installation of spotlamps are recommended Special tooling is used to locate and drill the spotlamp shaft hole in the pillars as well as modifying the door edge for lamp shaft clearance Interior trim covers provided with factory installed lamps are not available as service parts Field installation of spotlamps must not interfere with proper deployment of the roof rail airbag in the event of a crash 6J3 WIRING PROVISIONS FOR VEHICLE GRILLE LAMPS AND SPEAKER SIREN A Blunt cut ends for the customer furnished grille lamps and customer furnished siren speaker B Control wires from in line connector in forward lamp harness for customer furnished grille lamps and speaker The SEO 6J3 wiring provision has a 5 foot 1 5 m harness coiled underneath the instrument panel on the p
126. block opt L83 5 3L V8 EcoTec3 AFM DI VVT Flex Fuel aluminum block 1 Requires NHT Max Tailering Package 2 Required with NHT Max Trailering Package EMISSIONS BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 FEDERAL EMISSIONS is ordered for delivery to a dealer located in California Connecticut Massachusetts Maryland New Jersey New Mexico New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Maine Maryland Massach
127. cal dimension approximate 9 3 in 490 mm G Inflated air bag instrument panel H Passenger air bag deployment zone Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use Safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 36 TAHOE PPV amp 5W4 AIR BAG DIMENSIONS HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES PASSENGER SIDE SHOWN DRIVER SIDE SIMILAR L K A B C N H mm P 12 G Tahoe Rows 1 and 2 Top of deployment zone along head curtain at edge of headliner Back of deployment zone at rear top corner of rear door pad Rear quarter window Bottom outside edge of rear quarter window Bottom of air bag deployment zone parallel to outside bottom edge of rear quarter glass F Top edge of rear door pad G Top edge of front door pad H Dimension at mirror patch from top edge of front door pad C 500 mm 20 in 75mm 3 0 in M Front of deployment zone at
128. ccupant head and torso excursion outside the passenger compartment if a rollover should occur Combined front and rear seat row head side curtain air bags1 are available see option AYG on page 6 NOTE Safety belt extenders are available in 9 inch part number 19259268 and 15 inch part number 19259267 through your dealer at no charge Cloth bucket seats with heavy duty foam sculpted for gun belts high wear fabric bolsters and seat back security panel Driver and passenger 4 way power with lumbar and manual recline manual fore aft movement 10 inches of space between front seats an equipment mounting platform is located between front seats Cloth bench non folding seat back vinyl rear seat available see option HCQ on page 6 requires 6A3 heavy duty vinyl floor covering Column shift lever Not available 160 mph certified analog display with 1 mph increments Driver Information Center DIC has different displays which are accessed using the control buttons on the tum signal lever at the left side of the steering wheel The DIC displays speed trip vehicle information and warning messages see page 9 Circuit is terminated in the 16 cavity upfitting connector for connection to customer switching to ground all automatic interior and exterior lighting is extinguished and radio is blacked out All manual lighting control remains functional see description on page 19 Tilt and telescoping with cruise and audio controls PASS Key III Content
129. ce tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance StabiliTrak systems help drivers maintain control of their vehicles especially during emergency lane changes or avoidance maneuvers StabiliTrak uses various sensors such as steering wheel angle wheel speed yaw velocity etc to detect any difference between the path requested by the steering wheel position and vehicle s actual path When appropriate the system selectively controls brakes engine power and even suspension settings to enhance control of the vehicle s direction and help keep it on course Independent studies conducted by the National Highway Traffic Safety Administration the Insurance Institute for Highway Safety and others have found StabiliTrak to be highly effective in reducing vehicle crashes General Motors offers StabiliTrak systems on many of its passenger car and light truck models See your owner s manual for additional information about the operation of StabiliTrak Q How do I use StabiliTrak A StabiliTrak operates independently of the driver You should continue to drive your StabiliTrak equipped vehicle with caution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part of the overal
130. ch and wiring to the roof upfitter to install and connect a roof mounted warning lamp instructions provided in owner s manual supplement see page 25 6B2 REAR DOOR HANDLES INOPERATIVE Rear door inoperative doors can be opened only from outside see page 25 6N6 REAR DOOR LOCKS INOPERATIVE Rear power locks are inoperable at rear doors but operate form drivers position see page 25 6N5 REAR DOOR WINDOW SWITCHES INOPERATIVE Rear window only operates from driver s position see page 25 AP3 REMOTE VEHICLE STARTER SYSTEM Includes remote keyless entry AZ3 SEATS Front custom cloth 40 20 40 split bench power driver seat only see page 16 A95 SEATS Front bucket with custom cloth 6 way power with center console to delete center floor console 9N5 must be ordered see page 16 515 SEATS Front cloth with vinyl rear seat see page 16 NZZ SKID PLATES PACKAGE TGK SPECIAL PAINT SOLID One color all normally body colored non sheet metal parts will be gloss Black This includes front and rear facias liftgate handle and applique D pillars and upper liftgate applique Mirrors and door handles will be grained Black parts B85 body side moldings are not available except with SEO option 574 exterior body colored parts May require extended lead time Required with any SEO paint selection May require extended lead time 7X6 SPOTLAMP Left hand separately fused see page 26 7X7 SPOTLAMP Left and right hand separately fused see page 26 4JP
131. ched to your vehicle and give you the maximum load capacity the Gross Vehicle Weight Rating GVWR and the Gross Axle Weight Rating GAWR for your vehicle See Vehicle Load Limits in the owner manual Index for additional loading information The following guidelines can help you with proper loading and load distribution when installing additional equipment on the TahoePolice Package WARNING DO NOT LOAD THE VEHICLE ANY HEAVIER THAN THE GROSS VEHICLE WEIGHT RATING GVWR OR EITHER THE MAXIMUM FRONT OR REAR GROSS AXLE WEIGHT RATING GAWR THIS CAN CAUSE SYSTEMS TO BREAK AND CHANGE THE WAY THE VEHICLE HANDLES THIS COULD CAUSE LOSS OF CONTROL AND A CRASH OVERLOADING CAN ALSO SHORTEN THE LIFE OF THE VEHICLE ADDING EQUIPMENT TO YOUR VEHICLE Before adding accessories or equipment to your police vehicle there are some things you need to know The police vehicle s maximum capacity weight payload The weight of your police vehicle including a full tank of fuel but without a driver and passengers The weight of items you plan on adding to your police vehicle like roof mounted light bar s push bumpers security barrier s rear storage organizer highway flares fire extinguishers weapons ammunition radios and video equipment The weight and number of passengers you intend to carry in your vehicle The total weight of any additional cargo you intend to carry in your vehicle When planning your vehicle equipment installation
132. cies due to vehicle speed sensing are included equipped with DIC buttons The instrument cluster odometer trip stem is used to display the following messages odometer engine hours trip odometer tire pressure remote keyless entry relearn remote key programming and DIC language See the Tahoe owner s manual for operation description The speedometer calibration is for the 5 3L engine automatic transmission with a 3 08 axle and P265 60R17 V rated tires REMOTE KEY LEARNING ACTIVE ACTUAL VEHICLE SPEED INDICATED SPEED 0 TO 120 MPH 2 MPH 0 TO 193 KPH 3 KPH 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 2WD POLICE PACKAGE PPV OPTIONS AVAILABLE OPTIONS WITH TAHOE PPV POLICE PACKAGE KST BATTERIES DUAL 660 CCA 80 amp hour rating parallel connected B85 BODY SIDE MOLDINGS On 4 doors 1LR BRAKE SYSTEM CITY Uses base friction material that wears better at lower temperatures and city service The city brakes are not optimal for track performance The rotor does not have the radial drilled holes The parts are physically interchangeable for service however the parts should be substituted as complete four wheel sets UTQ CONTENT THEFT ALARM DISABLE Flashing lamps and horn warning This option is recommended for customers that do not intend on using keyless entry remote fobs 968 DELETE DAYTIME RUNNING LAMPS AND AUTOMATIC HEADLAMPS Exterior lamps are operated manually see page 24 for description 514 E
133. ck tubular assist step LPO VXJ 4 round chrome tubular assist step LPO or BVQ 6 chrome tubular assist step LPO BED LINER Dealer installed Not available with VUK tailgate liner LPO LPO BED NET Dealer installed LPO BLACK TUBULAR ASSIST STEPS 4 round Dealer installed Not available with RVQ 6 oval Black tubular assist step LPO VXJ 4 round chrome tubular assist step LPO VXH 6 oval chrome tubular assist step LPO or BVQ 6 chrome tubular assist step 4 3L V6 EcoTeG engine 5 3L V8 EcoTec3 engine Not available with NHT Max Trailering Package 4 3L V6 EcoTec3 engine L83 5 3L V8 EcoTec3 engine Not available with NHT Max Trailering Package SH S 8 Visit OnStar com for coverage map system limitations and details 10 Go to gm com bluetooth to find out which Bluetooth phones are compatible with the vehicle 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 7 RVQ RWS VGL SDA SB1 VQK RW6 VQZ VBJ VBR 5JY VUK VAT VPB SFE DL8 DF2 UET VAV Kl4 GU4 GUS AQQ AZ3 U2M RHM ZBZ RC4 RCS RC3 JL1 PCR LPO BLACK TUBULAR ASSIST STEPS 6 oval Dealer installed Not available with RVS 4 round Black tubular assist step LPO VXJ 4 round chrome tubular assist step LPO VXH 6 oval chrome tubular assist step LPO or BVQ 6 chrome tubular assist step LPO CARPETED FLOOR MATS
134. computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors monitor how fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is approaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles Does ABS reduce stopping distances Yes in braking situations where the wheels on a
135. ctions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SILVERADO 1500 CREW CAB PICKUP WORK TRUCK WARNING TONES AIR DAM BUMPERS FRONT BUMPERS REAR CORNER STEP DAYTIME RUNNING LAMPS DOOR HANDLES GLASS GRILLE HEADLAMPS LAMPS MIRRORS RECOVERY HOOKS WINDSHIELD WIPERS ALTERNATOR BATTERY BRAKES COOLING ENGINE EXHAUST FRAME FUEL TANK REAR AXLE STABILITRAK STEERING SUSPENSION FRONT SUSPENSION REAR TAILGATE TIRE PRESSURE MONITOR TIRE SPARE CARRIER TIRES TIRE CARRIER LOCK TRANSFER CASE TRANSMISSION WHEELS Headlamp on key in ignition driver and passenger buckle up reminder and turn signal on EXTERIOR FEATURES Black Black Black Rear bumper Automatic exterior lamp control Black Solar Ray light tinted all windows Black surround Halogen reflector Cargo area cab mounted with separate switch on center switch bank Outside manual Black Front black Standard on 4WD available on 2WD Front intermittent wet arm with pulse washers CHASSIS FEATURES 150 amps Heavy duty 600 CCA maintenance free with rundown protection and retained accessory power 4 wheel disc with DURALIFE rotors 4 wheel antilock External engine oil cooler heavy duty 4 3L V6 EcoTec3 with Active Fuel Management Direct Injection and Variable Valve timing includes aluminum block construction with FlexFuel capability capble of running on unleaded or up to 85 ethanol Aluminized stainless steel m
136. d Vermont and Washington Required when option code NET is ordered for delivery to a dealer located in California The 2014 Chevrolet Impala Police Patrol Vehicle with the 3 6L Engine LFX with Emission Option Codes FE9 NE1 and YF5 is certified to EPA Tier 2 Bin 4 standards and qualifies as ULEV Ultra Low Emission Vehicle under California Air Resources Board CARB requirements meaning it is 50 state certified Emission Standard BIN4 EPA engine family or test group EGMXJ03 6166 TIRES SPEED RATED MANUFACTURER QUANTITY SIZE SPEED RATING TYPE Goodyear Four P235 55R17 SBR blackwall W All Season BW NOTE Compact spare is standard full size spare is available see option RUF on page 9 Due to specific requirements for performance durability and safety gm recommends only the original equipment tire for replacement Tire Plys Tread 2 Polyester 2 Steel 1 Nylon Sidewall 2 Polyster Total 7 Ply Do not use tire chains See your Owner s Manual for more information SEATS AND INTERIOR TRIM SEAT OPTIONS STANDARD Front Cloth buckets power driver and passenger ARQ Rear Vinyl bench non folding seat back OPTIONAL Front Cloth buckets power driver and passenger ARQ Rear Cloth bench non folding seat back AVAILABLE EXTERIOR COLORS Silver Ice Black Summit White Ashen Gray Metallic Metallic NOTE For special paint and paint schemes see page 12 through 14 Actual colors may vary 2
137. d curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 12 Model tested with standard head curtain side impact air bags SABs Government 5 Star Safety ratings are part of the National Highway Traffic Safety Administration s NHTSA s New Car Assessment Program www SaferCar gov 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 2WD POLICE PACKAGE ASSIST STEPS BODY SIDE MOLDINGS DEFOGGER DOOR HANDLES DOOR LOCKS FASCIA FRONT FASCIA REAR FOG LAMPS HEADLAMPS HORNS KEYLESS ENTRY KEYS LUGGAGE RACK MIRRORS REAR LIFTGATE RECOVERY HOOKS UNDER HOOD LAMP WINDSHIELD WIPERS AIR CLEANER ALTERNATOR BATTERY BRAKES COOLING ENGINE FRAME FUEL TANK CAPACITY OIL COOLERS PROP SHAFT RADIO SUPPRESSION SKID PLATE SPARK PLUGS STABILITRAK STEERING SUSPENSION FRONT SUSPENSION REAR TIRES TIRE PRESSURE MONITOR TIRE SPARE TRAILERING EQUIPMENT TRACTION CONTROL TRANSMISSION WHEELS WHEEL CENTER CAP EXTERIOR FEATURES Black mounted between front and rear wheels Optional see option B85 on page 7 Electric rea
138. delivery to a dealer located in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NET is ordered for delivery to a dealer located in California NOTE The 2014 Chevrolet Tahoe Police Patrol Vehicle and Special Service Vehicle with the 5 3L Engine LMG with Emission Option Codes NET and YF5 is certified to EPA Tier 2 Bin 4 standards and qualifies as ULEV Ultra Low Emission Vehicle under California Air Resources Board CARB requirements meaning it is 50 state certified when ordered with NE1 or YF5 Emission Option Code FE9 Federal is Federal only certified and not intended for registration in Arizona California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Emission Standard BIN4 for Option Code NE1 or YF5 BIN5 for Option Code FE9 EPA engine family or test group EGMXT05 3381 for Option Code or YF5 EGMXT05 3373 for Option Code FE9 TIRES SPEED RATED MANUFACTURER QUANTITY SIZE SPEED RATING TYPE GOODYEAR 5 P265 60R17 All season BW NOTE Due to specific requirements for performance durability and safety GM recommends only the original equipment tires for replacement Tire Plys Tread 2 Polyester 2 Steel 2 Nylon Sidewall 2 Polyster Total 8 Ply Tire chains may be used with caution See your owner s manual for specific recomm
139. deployment zones No The side air bags inflate extremely fast because of the nature of side crashes to the vehicle Mounting a security barrier behind the front seats with the ends placed within the side air bag deployment zones will result in unintended interaction between the barrier and the inflating side air bags To reduce the risk of injury to the vehicle occupants GM recommends that the side air bag zones be kept free of any customer installed equipment Customer furnished equipment installed to the vehicle roof Your police vehicle is designed with an interior roof cover system which includes internal components for the interior lamps and wiring The roof system may also include side air bag components Inflation devices may be mounted on the vehicle roof side behind the rear doors as well as air bag tethers retained to the windshield pillars Care must be taken to avoid damage to these components or interference with their operation when installing roof mounted equipment such as emergency lamps and communication antennas Recommended GM service procedures must he followed to remove and re install the instrument panel top pad to ensure that the top pad will release properly in the event of a passenger air bag deployment On the right half of the top pad closest to the passenger air bag module GM recommends that no equipment be mounted When mounting equipment on the driver side of the top pad GM recommends that the total mass of th
140. dered for delivery to a dealer located in California NOTE The 2014 Chevrolet Tahoe Police Patrol Vehicle and Special Service Vehicle with the 5 3L Engine LMG with Emission Option Codes NET and YF5 is certified to EPA Tier 2 Bin 4 standards and qualifies as ULEV Ultra Low Emission Vehicle under California Air Resources Board CARB requirements meaning it is 50 state certified when ordered with NE1 or YF5 Emission Option Code FE9 Federal is Federal only certified and not intended for registration in Arizona California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Emission Standard BIN4 for Option Code NE1 or YF5 BIN5 for Option Code FE9 EPA engine family or test group EGMXT05 3381 for Option Code NET or YF5 EGMXT05 3373 for Option Code FE9 TIRES SPEED RATED MANUFACTURER QUANTITY SIZE SPEED RATING TYPE Random 5 P265 70R17 S All season BW NOTE Optional on off road tire is available see option 4JP on page 19 Tire Plys Tread 2 Polyester 2 Steel 1 Nylon Sidewall 2 Polyster Total 7 Ply Tire chains may be used with caution See your owner s manual for specific recommendations regarding conditions If the vehicle is equipped with a P265 60R17 tire size use tire chains only where legal and only when necessary Use low profile chains that add no more than 12 mm thickness to the tire tread and inner sidewall Use chains that a
141. des roof rail mounted Head Curtain side air bags The vehicle is also equipped with seat back mounted upper body air bags located on the outboard side of the driver and front passenger seat backs Together the Head Curtain and seat mounted side air bags are intended to protect the head and upper body in the event of a side crash Some vehicles may also be equipped with an optional air bag mounted on the inboard side of the driver seat back Can Specialty Vehicle Security Barriers be mounted within the side air hag deployment zones No The side air bags inflate extremely fast because of the nature of side crashes to the vehicle Mounting a security barrier behind the front seats with the ends placed within the side air bag deployment zones will result in unintended interaction between the barrier and the inflating side air bags To reduce the risk of injury to the vehicle occupants GM recommends that the side air bag zones be kept free of any customer installed equipment Customer furnished equipment installed to the vehicle roof Your police vehicle is designed with an interior roof cover system which includes internal components for the interior lamps and wiring The roof system may also include side air bag components Inflation devices may be mounted on the vehicle roof side behind the rear doors as well as air bag tethers retained to the windshield pillars Care must be taken to avoid damage to these components or interference with their
142. ding lights illuminates entry feature and backlit instrument panel switches Inside rearview manual day night 2 auxiliary instrument panel mounted with covers 12 volt 2 transmitters panic button and content theft alarm Remote keyless entry is part of PCR Package Package includes power mirrors Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator rollover sensor dual head curtain air bags for first and second row outboard occupants and front seat back mounted thorax pelvic air bags 40 20 40 vinyl split bench 3 passenger driver and front passenger manual reclining with outboard head restraints and center fold down armrest with storage 60 40 vinyl bench folds up 3 passenger includes child seat top tether anchor Includes theft deterrent locking feature Tilt wheel adjustable with brake transmission shift interlock Driver and front passenger sliding with clip and illuminated passenger vanity mirror 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instru
143. e can be added You will need to remove all of the keys in memory just like before and have the addition keys FOBs to get back to 8 You can then relearn the existing keys FOBs along with the replacement key FOB giving you 8 functioning keys FOBs A fleet keyed car will allow programming of any amount of keys with or without real FOBs Mix and match all you want however only the first 8 FOBs learned to the vehicle will have their FOB functionality intact Meaning that FOB 9 will only be able to start the vehicle The lock unlock functionality will not work UPDATED JANUARY 2014 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 18 CAPRICE POLICE PACKAGE 9C1 WIRING DIAGRAMS WIRING DIAGRAM FOR 12 VOLT BATTERY POWER SUPPLY Optional Auxiliary Battery RPO K5S includes Isolation Relay BATTERY Auxiliary CONNECTOR Aux Fusebox 1 Ground Aux Battery G405 CUSTOMER CONNECTION FUSELINK FUSELINK GROUND STUD LOCATED 16 ll ln AT AUXILLARY BATTERY TRAY AO ETE 10 J4 102 J2 AV TO PRIMARY BATTERY PREFUSE CONNECTOR J2 A or AUXILIARY BATTERY ISOLATION RELAY R WITH RPO K5S NOTE FUSES IN AUXILIARY FUSEBOX 1 ARE NOT SERVICEABLE INDIVIDUALLY Maxi Breaker 30A N Maxi Breaker 30A Maxi Breaker 50A 30A Police 1 30A Police 2 50A Police 3 REAR COMPARTMENT AUXILIARY 12088555 12088553 15319848 POWER STUDS AT RH SIDE FOR CUSTOMER CONNECTION CONNECTOR AUX FUSEBOX 2 ELECTRICAL C
144. e for Highway Safety and others have found StabiliTrak to be highly effective in reducing vehicle crashes General Motors offers StabiliTrak systems on many of its passenger car and light truck models See your owner s manual for additional information about the operation of StabiliTrak Q How do use StabiliTrak A StabiliTrak operates independently of the driver You should continue to drive your StabiliTrak equipped vehicle with caution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part of the overall vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL For Information 1 800 FLEET OP 353 3867 www gmfleet com GM Fleet and Commercial Specialty Vehicles 100 Renaissance Center 20th Floor Detroit MI 48265 1000
145. e for registration in California EMISSIONS California state requirements EMISSIONS Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington state requirements EMISSIONS Federal requirements ENGINE BLOCK HEATER ENGINE 5 31 V8 EcoTec3 with Active Fuel Management Direct Injection and Continuously Variable Valve Timing includes aluminum block construction with Flex Fuel capability capable of running on unleaded or up to 85 ethanol FLOOR COVERING Color keyed carpeting with rubberized vinyl floor mats includes second row floor mats GLASS deep tinted GVWR 6900 LBS 3130 KG Requires 2WD models and LV3 GVWR 7000 LBS 3175 KG Requires 2WD models and L83 GVWR 7100 LBS 3221 KG Requires 4WD models and LV3 GVWR 7200 LBS 3266 KG Requires 4WD models and L83 LED LIGHTING Cargo box LICENSE PLATE KIT Front will be shipped to orders with ship to states that require front license plate LPO ASSIST STEPS Chromed tubular 4 round Dealer installed Not available with RVS 4 round Black tubular assist step LPO RVQ 6 oval Black tubular assist step LPO VXH 6 oval chrome tubular assist step LPO or BVQ 6 chrome tubular assist step LPO ASSIST STEPS Chromed tubular 6 oval Dealer installed Not available with RVS 4 round Black tubular assist step LPO RVQ 6 oval Bla
146. e is unlocked or the key is removed from the ignition switch B The push on push off right switch with a Dome Lamp symbol on the front dome lamp assembly turns the front and rear dome lamps On and Off LOCATIONS OF SPORT MODE AND STABILITRAK BUTTONS Located on instrument panel left side of steering column CAPRICE POLICE 9C1 SPECIAL EQUIPMENT STANDARD 13 AUXILIARY POWER AND GROUND STUD IN TRUNK 50 amp battery power to front compartment upfitter harness Rear compartment power studs Circuit breakers and relays for front compartment auxiliary power An auxiliary power junction block is located at the right side of the trunk The junction block is at the rear of the auxiliary battery tray and contains a split buss with two terminals for customer connection to 12 volt battery power The split bus is connected to the primary battery located at the left side of the trunk When the optional auxiliary battery RPO 55 is present the split bus is connected to the auxiliary battery through an isolation relay Two 60 amp fusible links connect the bus to the battery Maximum combined capacity of the two circuits is 1440 watts An 8 mm ground stud for customer connection is located at the inboard front corner of the right side battery tray A Violet Yellow ignition controlled power circuit HOT in RUN START terminates in a white connector located above the auxiliary battery power junction block This same circuit is
147. e it s at safe time with no obstacles in your path And you only really need to try it once or twice to know what happens two seconds then you are too close to the vehicle in front of you Also if the roads are wet or icy or visibility is poor you should increase your following distance ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK Q How does StabiliTrak work A StabiliTrak has the ability to apply control forces to the vehicle independent of the driver StabiliTrak uses sensors to continuously compare the path indicated by the steering wheel position to the vehicle s actual path If a discrepancy is detected StabiliTrak selectively controls vehicle brakes and engine torque to create a yaw moment that helps restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak has the ability to help correct both understeer where the vehicle is not turning as much as the steering wheel position indicates and oversteer where the vehicle is turning more than the steering wheel position indicates The illustration at right shows how selective braking at a particular wheel can create a compensating yaw moment to help restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak systems help drivers maintain control of their vehicles especially during emergency lane changes or avoidance maneuvers StabiliTrak uses various sensors such as steering whe
148. e pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the ABS telltale on the dash will be illuminated Should this happen the vehicle should be taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the brake pedal down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you Should I drive an ABS equipped vehicle differently than I would drive a vehicle with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lockup When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and s
149. e released Customer and dealer costs associated with accommodations and travel for in person review of special paint are the responsibility of the dealer TO ORDER SPECIAL PAINT RPO White 50U or RPO Black 41U must be ordered The 4 digit special paint code in paint code 1 paint code 2 fields will be replaced by options denoting code 1 and code 2 colors Paint scheme codes will be replaced by options Solid color option is AAS 2 tone color option is AAT When special paint schemes are ordered only class A surfaces will be painted mirrors and handles are NOT painted For additional costs to have the handles and mirrors painted please contact Kerr Industries at 905 725 6561 It is recommended that all vehicles be ordered in Black 41U before special paint is applied For paint colors not listed in this brochure please contact Kerr Industries directly at 905 725 6561 Example for Ordering Special Paint If a dealer wants a Silver and Blue car with scheme W002 order 50U or 41U White or Black RPO paint options BEP code 1 Blue BFR code 2 Silver 1PB paint scheme W002 and AAT 2 tone paint SPECIAL PAINT WARRANTY Warranty claims for special paints must be directed to Kerr Industries at 905 725 6561 AFTER YOU HAVE ORDERED SPECIAL PAINT After the vehicles have been ordered for special paint Kerr Industries will contact the dealer directly regarding colors and verification of the scheme Once verified a special paint build sheet will b
150. e safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL s AIR BAGS FAG Can the installation of push bumpers on the front end of the vehicle affect the deployment of the air bag General Motors is not aware of adverse effects during crash events from the many push bumpers thai have been installed on GM police vehicles Because there are many styles of push bumpers available with varying crash characteristics installation of push bumpers may or may not affect deployment timing of the air bags Push bumpers should be mounted to avoid modifying the vehicle structure and interfering with the front air bag sensors mounted on the upper radiator support cross member Two front impact sensors are installed in General Motors vehicles Do not relocate or disconnect the front sensors The location and orientation of the front sensors are critical for correct operation of the air bag system Avoid mounting components on or near the sensors Push bumper styles with vertical pushing members that are in foreaft alignment with the front air bag sensors are not recommended When should an air hag inflate The driver s and right front passenger s frontal air bags are designed to inflate in moderate to severe frontal or near frontal crashes But they are designed to inflate only if the impact speed is above the system s designed t
151. e sent to the dealer for final confirmation This sheet will need to be signed by the dealer and returned to Kerr Industries before painting will commence NOTE The attached list of paint options contain the same WA numbers in the code 1 and code 2 columns It is extremely important that the dealer order the correct code 1 and code 2 options so the upfitter knows how to paint the vehicles NOTE For paint colors not listed please contact Kerr Industries directly at 905 725 6561 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 SPECIAL PAINT AVAILABLE 13 OPTIONS WA COLOR DESCRIPTION CODE 1 CODE 2 121A Adriatic Blue EY BEA BFE 311B Olive BEB BFF 5120 Blue Sa BEQ BFU 5236 Neutral BEC BFG 5322 Driftwood Ld BER BFV 5665 Blue C BED BFH 5749 Gold BES BFW 5845 Beige BEE BFI 7153 Blue BET BFX 7158 Blue BEF BFJ 7262 Brown BEU BFY 7801 Brown Es BEG BFK 7840 Silver a BEV BFZ 7868 Blue Ld BEH BFL 7888 Blue BEW BGA 7889 Blue BEP BFT 7964 Green ae BEI BFM 7999 Blue a BEX BGB 8380 Blue BEJ BEN 8381 Gray BEY BGC 8401 Yellow ME BEK BFO 8412 Green HE BEZ BGD 8431 Rose Metallic Her BEL BFP 8554 White BFA BGE 8555 Black 410 a BEM BFQ 8624 Summit White 50U BG8 BGK 8743 Blue Black EE BFB BGF 9021 Silver BE
152. e standard box crew cab pickup STANDARD EQUIPMENT SUMMARY 3 years 36 000 miles bumper to bumper whichever comes first see dealer for details and 5 years 100 000 miles limited powertrain whichever comes first see dealer for details both above maintenance warrant 2 years 24 000 miles scheduled vehide maintenance induding oil change oil filter replacement tire rotation and multi point vehicle inspection whichever comes first see dealer for details INTERIOR FEATURES Dual stage frontal and side impact driver and front passenger and head curtain and seat mounted side impact front and rear outboard seating positions with Passenger Sensing System Single zone Front passenger on A pillar 4 2 Color Display AM FM stereo with USB ports 2 auxiliary jack and SD card slot Rear driver and passenger side Floor not available Electronic with set and resume speed steering wheel mounted Front and rear Power Odometer trip odometer and message center monitors numerous systems depending on vehicle equipment level including low fuel turn signal on transmission temperature and oil change notification Driver Information Center controls are operated through the trip button unless UK3 steering wheel mounted audio controls is ordered Graphite colored rubberized vinyl no floor mats included 6 gauge cluster featuring speedometer fuel level engine temperature tachometer voltage and oil pressure Interior with dome and rea
153. e than the steering wheel position indicates The illustration at right shows how selective braking at a particular wheel can create a compensating yaw moment to help restore the vehicle s actual path to the path indicated by the steering wheel position Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you replace tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance StabiliTrak systems help drivers maintain control of their vehicles especially during emergency lane changes or avoidance maneuvers StabiliTrak uses various sensors such as steering wheel angle wheel speed yaw velocity etc to detect any difference between the path requested by the steering wheel position and vehicle s actual path When appropriate the system selectively controls brakes engine power and even suspension settings to enhance control of the vehicle s direction and help keep it on course Independent studies conducted by the National Highway Traffic Safety Administration the Insurance Institut
154. e top pad mounted special equipment not exceed 8 pounds 3 6 kilograms since some top pads tend to rotate about the left end Fasteners used to secure special equipment to the instrument panel top pad the windshield glass or to the windshield upper frame header should be selected to ensure that these devices will remain attached during a vehicle crash and possible air bag deployment Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL AIR BAGS FAG 27 Can the installation of push bumpers on the front end of the vehicle affect the deployment of the air bag General Motors is not aware of adverse effects during crash events from the many push bumpers thai have been installed on GM police vehicles Because there are many styles of push bumpers available with varying crash characteristics installation of push bumpers may or may not affect deployment timing of the air bags Push bumpers should be mounted to avoid modifying the vehicle structure and interfering with the front air bag sensors mounted on
155. ea sq in sq cm 504 6 3255 Head room 39 2 996 Front rotor diameter in mm 13 0 330 Shoulder room 65 2 1656 Rear rotor diameter in mm 13 5 343 Hip room 60 6 1539 Front rotor thickness in mm 1 2 30 Leg room 39 0 991 Rear rotor thickness in mm 79 20 TIRES Load floor length to center of front seat at floor in mm 81 4 2068 Load floor length to center of 2nd seat at floor in mm 49 4 1255 Type Goodyear V rated all season Inside width between wheel house in mm 49 1 1247 Size P265 60R17 Cargo area height in mm 41 7 1059 Cargo volume maximum behind front seat cu ft liters 108 9 3084 WHEELS Cargo volume maximum behind second seat cu ft liters 60 3 1707 Type Steel NOTE For additional dimensional data go to gmupfitter com ae i PASSENGER COMPARTMENT VOLUME INDEX cu ft liters CHASSIS Passenger compartment volume index 121 8 3449 Frame Full perimeter steel FUEL ECONOMY RATINGS CITY HIGHWAY COMBINED Fentsuspension Vr ene 53L engine 2WD 15 2117 coil over shocks with stabilizer bar m Rear suspension Multi link with coil spring Projected EPA fabel values actual mileage will vary with options driving conditions driving Steering type Power rack and pinion habits and vehicle condition Steering ratio 17 75 1 ALTERNATOR Type remy pr44m BATTERY Amps 77 F 25 C 160 Type Maintenance free BCI group size LN3 TAHOE POLICE ALTERNATOR OUTPUT Volts 12 Amp hour rating 80 lt Cold cranking amp
156. ear suspension Hypoid driver axle Hypoid driver axle Hypoid driver axle or equipment order at customer s request can result in a minor change in these dimensions w multi leaf springs w multi leafsprings w multi leaf springs CAPACITY Steering type Speed sensitive Speed sensitive Speed sensitive Curb weight Ibs kg 6087 2761 6406 2906 EVO variable ratio EVO variable ratio EVO variable ratio Cargo volume regular with seats cu ft liters 92 1 2608 3 127 2 3602 3 integral power integral power integral power Cargo volume regular with seats removed cu ft3 liters 216 2 6122 8 252 8 7159 3 Steering ratio center stop 17 21 17 21 17 21 Payload Ibs kg 3461 1570 3142 1425 Gross Vehicle Weight GVWR Ibs kg 9600 4354 9600 4354 ALTERNATOR Front Gross Axle Weight Rating FGAWR Ibs kg 4600 2087 4600 2087 Type Standard with rear AC TBD TBD AD244 Rear Gross Axle Weight Rating RGAWR Ibs kg 6084 2760 6084 2760 Amps 105 105 145 Seating capacity front 2nd 3rd 4th 2 3 3 3 2 3 3 3 4 Amps idle TBD TBD 59 3 Cargo and load capacity limited by weight and distribution Without Rear air conditioning 145 amp required with rear air conditiong 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payload capacity includes weight of driver passengers optional equipment and cargo 2014 CHEVROLET MUNICIPAL VEHICLES
157. ecialty equipment installation MUST NOT PREVENT the top pad from rotating upward during deployment Location and attachment of special equipment should minimize added resistance or interference to upward rotation of the top pad during deployment Side Impact Air Bags for crashes to the vehicle sides The air bag system in your police vehicle includes includes roof rail mounted Head Curtain side air bags The vehicle is also equipped with seat back mounted upper body air bags located on the outboard side of the driver and front passenger seat backs Together the Head Curtain and seat mounted side air bags are intended to protect the head and upper body in the event of a side crash Some vehicles may also be equipped with an optional air bag mounted on the inboard side of the driver seat back Can Specialty Vehicle Security Barriers be mounted within the side air bag deployment zones No The side air bags inflate extremely fast because of the nature of side crashes to the vehicle Mounting a security barrier behind the front seats with the ends placed within the side air bag deployment zones will result in unintended interaction between the barrier and the inflating side air bags To reduce the risk of injury to the vehicle occupants GM recommends that the side air bag zones be kept free of any customer installed equipment Customer furnished equipment installed to the vehicle roof Your police vehicle is designed with an interior roof cover
158. ed circuit HOT in START RUN Fuse split PWR Drop CRNK is in the underhood fuse block Ayellow black 20 gauge transaxle park signal from the Body Control Module BCM This circuit provides switched power 12 volts when the transmission is not in PARK P and the engine is running The electrical load attached to the park circuit must not exceed 0 5 amps one relay coil A brown 22 gauge 0 35 vehicle speed signal 4 000 pulses mile from the ABS module Connect only high impedance load 8 RED 302 At base of Passanger C362 Side Front Door Pillar 8 RED 302 Ring Terminal F Ring Terminal Junction Block Trunk NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 24 IMPALA LIMITED 9C1 amp 9C3 WIRING DIAGRAMS WIRING DIAGRAM FOR FORWARD LAMP HARNESS IN LINE CONNECTOR FOR USE WITH HEADLAMPS FLASHER MODULE OPTION 6J7 Warning BCM will be damaged if 12V C122 power is connected to the 1256 dark blue yellow wire GROUND 250 0 35 D GN WH 0 35 D GN WH LH HI BEAM uL hn EE HEER 2940 0 8 RD WH RF HI BEAM 0 5 L GN BK D D 0 5 L GN BK 6820 3 E wire under CONTROL 0 35 D GN RD instrument panel F BCM 6841 0 5 D BU YE FUSE HDLP MDL FUSE BLOCK UNDERHOOD From blunt cut This connector is located at the rear passenger side of the bumper
159. eed to try it once or twice to know what happens one thousand two until your front bumper reaches the marker If you do not count out two seconds then you are too close to the vehicle in front of you Also if the roads are wet or icy or visibility is poor you should increase your following distance world cannot provide a shorter stopping distance or good steering ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK Q How does StabiliTrak work A StabiliTrak has the ability to apply control forces to the vehicle independent of the driver StabiliTrak uses sensors to continuously compare the path indicated by the steering wheel position to the vehicle s actual path If a discrepancy is detected StabiliTrak selectively controls vehicle brakes and engine torque to create a yaw moment that helps restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak has the ability to help correct both understeer where the vehicle is not turning as much as the steering wheel position indicates and oversteer where the vehicle is turning more than the steering wheel position indicates The illustration at right shows how selective braking at a particular wheel can create a compensating yaw moment to help restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak systems help drivers maintain control of their vehicles especially during emergency lane changes
160. ehicle Speed Signal VSS NOTE For wiring diagram see page 23 FUSE BLOCK BATTERY POWER SUPPLY SERVICING RELAYS AND CIRCUIT BREAKERS The following information shows you where the relays and circuit breakers are located in the fuse block viewed upward from driver floor A Instrument panel carrier B Relay center for circuit breakers and control relay C Instrument panel harness branch AUXILIARY BATTERY POWER JUNCTION BLOCK IN TRUNK The auxiliary battery power junction block is mounted in the trunk of your Impala police vehicle It is located on the passenger side support strut behind the rear wheel housing This junction block is split to provide two circuits and can be used to connect customer furnished equipment directly to the battery through 8 gauge 8 mm2 body wiring and fusible links A maximum of 100 amps 1200 watts can be connected Torque the connections to the studs to 11 lb ft 15 N m It is fed by two fusible links of 50 amps each NOTE For wiring diagram see page 23 TRUNK GROUND STUD 10 mm ground stud can be found in the trunk on the passenger s side of the vehicle The stud is located above the trunk auxiliary junction block See Trunk Auxiliary Battery Power Junction Block for more information on location A 10 mm flanged hex nut grounds the 10 mm bolt to the vehicle Recommended torque for the flanged nut is 26 lb ft 35 N m plus or minus 4 lb ft 5 N m A 10 mm hex nut is provided for custome
161. el angle wheel speed yaw velocity etc to detect any difference between the path requested by the steering wheel position and vehicle s actual path When appropriate the system selectively controls brakes engine power and even suspension settings to enhance control of the vehicle s direction and help keep it on course Independent studies conducted by the National Highway Traffic Safety Administration the Insurance Institute for Highway Safety and others have found StabiliTrak to be highly effective in reducing vehicle crashes General Motors offers StabiliTrak systems on many of its passenger car and light truck models See your owner s manual for additional information about the operation of StabiliTrak Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you replace tires check the recommendations in your owner s manual On GM vehicles the original equipment tires have a TPC Tire Performance Criteria code on the sidewall Replacing the tires with the same TPC code will help assure proper StabiliTrak performance Q How do use StabiliTrak A StabiliTrak operates independently of the driver You should continue to drive your StabiliTrak equipped vehicle with ca
162. elbase 116 0 2946 Torque Ib ft rpm 335 4000 Overall length 202 0 5131 Induction system SFI Overall width 79 0 2007 Compression ratio 9 9 1 neat ala aa uen us ift in height load floor to groun 5 Step front door T ground 22 3 567 m recommenda he 2i Step height rear door sill to ground 22 8 580 uel tank capacity gallons liters 26 98 Step height front running board to ground 14 0 356 Oil with filter quarts liters 6 0 5 7 Step height rear running board to ground 14 5 369 Cooling capacity quarts liters 18 3 17 3 Front track width 68 2 1732 Rear track width 67 0 1701 TRANSMISSION Turning diameter curb to curb ft m 39 0 11 9 Automatic electronic with overdrive 6 speed Ground clearance front axel 10 5 266 7 Fluid pan removed and filter replaced quarts liters 6 0 5 7 Ground clearance rear axel 9 1 231 FRONT COMPARTMENT in mm AXLE Head room 41 1 1044 Shoulder room 65 2 1656 BRAKES Hip room 60 3 1532 ABS with vacuum boost Disc Disc Leg room Front swept area sq in sq cm 256 6 1655 REAR COMPARTMENT in mm Rear swept area sq in sq cm 248 1600 Head room 39 2 996 Total front and rear swept area sq in sq cm 504 6 3255 Shoulder room 65 2 1656 Front rotor diameter in mm 13 0 330 tom E Rear rotor diameter in mm 13 5 343 Front rotor thickness in mm 1 2 30 CARGO Rear rotor thickness in mm 9 20 Load floor length to center front seat at floor in mm 81 4 2068
163. elts Even if you re in a vehicle that has air bags you still have to buckle up to get the most protection That s true not only in frontal collisions but especially in side and other collisions Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use Safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 12 AIR BAGS F TOP VIEW OF INSTRUMENT PANEL AND APPROXIMATE DEPLOYMENT AREA OF THE AIR BAG ZONE Passenger side instrument panel top surface zone Passenger side air bag module trim panel rear edge Passenger side door Approximate dimensions of inflated air bag Passenger side air bag deployment zone Passenger centerline Inside rearview mirror Vehicle centerline Driver centerline Driver side air bag deployment zone Front of steering wheel Driver side door gt Shift selector arc Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child
164. endations regarding conditions If the vehicle is equipped witha P265 60R17 tire size use tire chains only where legal and only when necessary Use low profile chains that add no more than 12 mm thickness to the tire tread and inner sidewall Use chains that are the proper size for the tires Install them on the tires of the rear axle Don t use chains on the tires of the front axle Tighten them as tightly as possible with the ends securely fastened Drive slowly and follow the chain manufacturer s instructions If the chains contact the vehicle stop and retighten them If the contact continues slow down until it stops Driving too fast or spinning the wheels with chains on will damage the vehicle SEATS AND INTERIOR TRIM SEAT OPTIONS STANDARD Front cloth bucket with NO center console power driver and passenger A95 and 9N5 Rear vinyl 60 40 split bench 515 OPTIONAL Front cloth 40 20 40 split bench power driver side seat only AZ3 Rear vinyl 60 40 split bench 515 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 2WD POLICE PACKAGE PPV 5 AVAILABLE EXTERIOR COLORS Champagne Mocha Steel Crystal Red Silver Ice Black Concord Summit White Silver Metallic Metallic Tintcoat Metallic Metallic New Actual colors may vary Additional Charge SEO PAINT AVAILABLE WA COLOR DESCRIPTION
165. eplete fluid from the master cylinder on brake apply may actually increase a vehicle s stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner A properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that even a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However performance is reduced Do insurance companies give a discount for ABS Yes many insurance companies give discounts that range from 5 to 10 In the states of New York and Florida all insurance companies are required
166. equired to give an ABS discount of 5 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 A Always maintain a safe following distance ABS does not allow you to stop on a dime Generally a 2 second following distance is considered safe in ideal conditions Watch the vehicle in front of you pass a fixed marker such as a sign Count seconds one thousand one IMPORTANT DRIVING SAFETY TIPS B Always drive carefully especially on slippery surfaces ABS cannot create friction between the tires and the road surface it can only give the driver the maximum advantage of the existing adhesion If the vehicle is traveling on a surface with no adhesion the best ABS in the e ANTI LOCK BRAKING SYSTEM AND STABILITRAK C Itisa good idea to practice an ABS activated stop and get the feel of the brake pedal However please make sure it s at safe time with no obstacles in your path And you only really need to try it once or twice to know what happens one thousand two until your front bumper reaches the marker If you do not count out two seconds then you are too close to the vehicle in front of
167. er Spotlamp LH Minifuse 15A J5 P5 2640 H7635 Papa M i USE CENTER ui 5 Spe e FUSE CENTER GND SEOB1 Spotlamp RH Minifuse 15A J2 P2 4540 H7635 EE amp Q H 03 0 5 PwR GND 7X6 spotlamp left hand and 7X7 spotlamps left and right hand pillar mounted Unity 6 inch with replaceable H3 halogen bulb independently fused NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 32 AIR BAGS FAG Can specialty vehicle equipment e g radar devices video cameras computers meters radio trees shotguns etc still he mounted in cars with passenger side air bags Yes but care must be taken to mount the equipment outside of the deployment zone Air bags inflate with great force and will interact with any object in the deployment zone Therefore to reduce the risk of injury to vehicle occupants GM recommends that the air deployment zone be kept free of any equipment If a piece of equipment were to become dislodged it could strike an occupant in the vehicle and result in injury The likelihood of an object becoming dislodged is influenced by many factors including the proximity of the object to the inflatable restraint the size and shape of the object and the means by which the object is secured to the vehicle In addi
168. er driver seat adjuster with manual lumber control driver and passenger manual reclining outboard head restraints center fold down covered storage in armrest center lower seat cushion storage and rear storage pockets Custom cloth 60 40 split folding bench with center armrest 50 50 split bench 3 passenger with premium cloth safety belts removable seat 120 mph analog speedometer trip odometer fuel level volt meter engine temperature oil pressure and tachometer Tilt wheel adjustable with brake transmission interlock Vehicle theft PASS Key 11 content theft deterrent is disabled to enable content theft deterrent option UA6 must be ordered Padded with cloth trim extends on rod driver and front passenger illuminated vanity mirrors Headlamp on key in ignition driver and right front passenger safety belt unfasten and turn signal on Power with driver express down and lockout features 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SUBURBAN COMMERCIAL F
169. es to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED UNDERCOVER POLICE PKG 9 3 7 BODY PANELS BODY SIDE MOLDINGS DEFOGGER DOOR LOCKS HEADLAMPS HORNS KEYLESS ENTRY KEYS LICENSE PLATE MIRRORS REARVIEW PAINT TRUNK LAMP TRUNK RELEASE UNDER HOOD LAMP WINDSHIELD WIPERS ALTERNATOR BATTERY BODY BRAKES COOLING CHASSIS LUBRICATION ENGINE EXHAUST SYSTEM FUEL TANK CAPACITY OIL COOLERS RADIO SUPPRESSION STABILITRAK STARTER INTERRUPT STEERING STRUTS FRONT SUSPENSION TIRES TIRE PRESSURE MONITOR TRACTION CONTROL TRANSMISSION WHEELS WHEEL COVERS EXTERIOR FEATURES Two sided galvanized steel for all exterior body panels except roof where it is not needed Optional See option B86 on page 9 Electric rear window only key lock cylinder is not available in the front passenger door Dual halogen composite includes flash to pass feature and automatic lamp control with daytime running lamps to delete automatic control see option 968 on page 9 and exterior lamps control on page 17 _ Dual note Includes two transmit
170. ess extension is a 5 foot 1 5 m loop of wire coiled under the center of the instrument panel NOTE For wiring diagram see page 30 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 SPECIAL EQUIPMENT OPTIONAL 6J7 EXTERIOR LAMPS EMERGENCY 6J7 EXTERIOR LAMPS EMERGENCY FLASHING SYSTEM MODULE LOCATION FLASHING SYSTEM Option 6J7 provides a headlamps high beam flashing module rear lamps flashing via the Body Control Module BCM and a control wire for customer furnished switching to turn the module on and off The flasher control wire is part of the The Option 6J7 Exterior Lamp Emergency Flashing System flashing module is blunt cut upfitter harness coiled under the instrument panel in the front passenger mounted on a front sheet metal vertical surface forward of the passenger side side foot well The flashing module is located below the passenger side headlamp front wheel inner wheelhouse and below the passenger side headlamp and forward of the passenger side front wheel on the inner front fender sheet metal The headlamp flashing module is activated by the application of 12 volts to a dark green red wire in the upfitter harness When activated the headlamp high beams and the high beam instrument cluster indicator will flash alternately at 2 4 flashes per second When the flashing module is turned on the module sends a signal to the BCM which alternately flashes the stop lamps and backup lamps at t
171. et Impala deploy from beneath the instrument panel top pad These are considered 3 4 mount air bag systems with a deployable top pad The entire instrument panel top pad is the deployment door from under which the inflating air bag emerges When an air bag deployment is commanded the forces from the inflating passenger air bag push up on the instrument panel top pad releasing special fasteners across the rearward edge of the top pad This allows the top pad to rotate upward so that the passenger air bag may emerge The top pad rotates upward to open widest at the right hand side and is usually forced upward into contact with the windshield on the right hand side of the vehicle during a deployment Instrument panel top mounted special equipment such as a radar antenna and control unit or video camera must be positioned to the left of the vehicle center line This equipment must be mounted as low as possible and securely fastened to the top pad to avoid being dislodged in the event of a crash and possible air bag deployment In the process of securely fastening special equipment to the top DO NOT fasten down the top pad itself to any other vehicle component such as the cluster trim plate As described above the top pad rotates upward during a deployment In order to enable the proper deployment of the passenger air bag specialty equipment installation MUST NOT PREVENT the top pad from rotating upward during deployment Location and attac
172. ettings for driver and right front passenger includes auxiliary rear air conditioning and heat Front passenger and second row outboard front passenger assist handle is deleted when passenger side spotlamp is ordered Mini with map lamps Electronic with set and resume speed Interior dome lamp driver and passenger side door switch with delayed entry feature cargo lamps remote keyless entry activated illuminated entry and map lamps in front and second seat position Black rubberized vinyl not available with B39 cargo mat Deep tinted all windows except light tinted glass on windshield driver and front passenger side glass Inside rearview auto dimming Delete option available 12 volt two located on instrument panel and one in rear cargo area AM FM stereo with MP3 compatible CD player seek and scan digital clock auto tone control Radio Data System RDS six speakers speed compensated volume and theftlock Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator rollover sensor dual head curtain air bags for first and second row outboard occupants and front seat back mounted thorax pelvic air bags includes 3rd row outboard seating position when 3 passenger third row 50 50 split bench option AS3 is ordered Split bench 40 20 40 with custom cloth 3 passenger includes 6 way pow
173. forced body components Power 4 wheel anti lock disc brakes with police calibration and heavy duty front brake pads Heavy duty high capacity with 225 watt fans and extended life coolant coolant hoses are EPDM ethylene propylene diene monomer rubber silicone hoses are not required coolant is DEX COOL good for 5 years 150 000 miles protects from 34 F to 265 F and against rust and corrosion see also page 17 Lubed for life chassis 3 6L V6 DOHC SIDI spark ignited direct injection engine with with Variable Valve Timing VVT with FlexFuel gas or E85 ethanol includes wide open throttle air conditioning cut off when overhead lamps spotlamps radio antennas sirens and other emergency equipment are installed overall performance may be reduced Stainless steel single with dual outlets 17 gallon 64lites gt Engine transmission and power steering oil coolers external air to oil see page 17 Extended life iridium tip spark plugs and wires that are designed to reduce radio frequency noise levels which may affect communications equipment including operating frequencies in the 38 MHz to 58 MHz range The Impala is designed with unibody construction and multiple grounding points are provided for the vehicle electrical system No additional ground straps are added for the Police Package Stability enhancement system An advanced computer controlled system that assists the driver with directional control of the vehicle in difficul
174. furnished grille lamps and speaker The SEO 6J3 wiring provision has a 5 foot 1 5 m harness coiled underneath the instrument panel on the passenger side The wiring circuits are routed from under the instrument panel to a 1 foot 30 cm coil secured in the area behind the grille There are four 16 gauge 1 0 mm2 wires for connecting to the grille lamps GRY TAN and siren speaker LT BU LT GN The SEO 6J3 wiring provision also includes one 18 gauge 0 8 mm control wire for the SEO 6J7 exterior lamps Emergency Flashing System When option 6J7 is installed without option 6J3 only the dark green red control wire is provided for connection to customer furnished 12 volt switching to turn the Emergency Flashing System on or off See also page 19 NOTE For wiring diagram see page 24 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL WX7 WIRING PROVISION FOR FRONT SPEAKERS Approximately 60 inches 1 5 m of auxiliary speaker wiring is routed from the front door and windshield pillar speakers and coiled under the instrument panel The wiring permits connection of the front speaker pairs to customer installed communication equipment Vehicle radio front speaker outputs are re routed to the rear speakers to maintain the required open door key in ignition audible warning NOTE For wiring diagram see page 24 2 IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP OPT Pas Rear door locking rods are disabled Rear door locks are inope
175. g the road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of the pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the ABS telltale on the dash will be illuminated Should this happen the vehicle should be taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the bra
176. ge your weight ratings Ask your dealer to help you load your vehicle the right way 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 SPECIAL EQUIPMENT STANDARD 23 AUXILIARY BATTERY POWER JUNGTION BLOCK AND GROUND STUDS An auxiliary power junction block is located within the driver s side rear cargo area jack stowage compartment This junction block is split to provide two circuits for connection to customer furnished equipment directly to the battery through separate 50 amp circuit breakers These circuit breakers are located in the breaker relay panel forward of the instrument panel glove box A maximum load of 100 amps 1 200 watts can be connected This junction block is connected to a coiled 5 foot 1 5 m branch of rear body harness and fastened near the jack Mounting of the junction block can be at customer selected rear cargo area locations permitted by the branch harness length and using customer furnished mounting hardware The junction block should not be attached to the interior trim plastic components without appropriate backing hardware to the mounting bolts Grounding studs are located on the left and right sides of the liftgate opening RADIO SUPPRESSION GROUND STRAPS 1 1 05 KINE Police Package is equipped with additional the n locations Left hand front frame body mount bracket to underbody Left hand rear frame body mount bracket to rear underbody Right hand rear fra
177. gine and Transmission with V8 Cooler not required with electronically assisted power steering Extended life iridium tip spark plugs and wires that are designed to reduce radio frequency noise levels which may affect communications equipment including operating frequencies in the 38 MHz to 58 MHz range The Caprice is designed with unibody construction and multiple grounding points are provided for the vehicle electrical system No additional ground straps are added for the Police Package Stability enhancement system An advanced computer controlled system that assists the driver with directional control of the vehicle in difficult driving conditions Each time the vehicle is started the StabiliTrak system is fully on StabliliTrak can be controlled by a StabiliTrak button on the instrument panel located on the left side of steering column see page 13 The condition of the system is displayed by an instrument panel StabiliTrak indicator light and Driver Information Center DIC Messages Push once StabiliTrak is in Performance Mode and Traction Control is On push and hold five seconds StabiliTrak and Traction Control are Off push again and Traction Control and StabiliTrak are turned back on See transmission and Sport Mode below for Sport Mode functions Prevents starter from engaging while the engine is running Electrically assisted rack and pinion speed sensitive variable assist 4 wheel independent with coil springs front and rear stabilize
178. gistered in a state that has Federal emission requirements Do not use for vehicles that will be registered in California Connecticut Delaware Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island or Washington Requires FE9 Federal emissions requirements Not available in Maine or Vermont EMISSIONS OVERRIDE Federal for vehicles ordered by dealers in Federal emission states with YF5 or NET emissions Not required for vehicles being shipped to California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington Requires YF5 California state emissions requirements or NE1 Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington state emissions requirements EMISSIONS OVERRIDE State specific for dealers ordering vehicles in YF5 or NET emission states California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington Allows a California dealer YF5 emissions to order NE1 emissions with NB9 emissions override code for registration in NET states or a Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington dealer NE1 emissions to order YF5 emissions with NB9 emissions override cod
179. he passenger side frontal air bag deployment zone in a manner that will allow full and safe air bag deployment Due to the complexity of influencing variables GM is unable to evaluate the potential for shielding expected equipment configurations in all accident scenarios in order to assure that the air bag performance would be unaffected While shielding may protect certain equipment from being damaged or dislodged it may also negatively affect the inflation characteristics of the air bag The air bag s shape inflation angle fold pattern and inflation rate and pressure are developed to maximize the protection capability of the inflatable restraint system Therefore GM cannot recommend the placement of any equipment in the deployment zone even if it is shielded to protect it from damage Front air bag systems and instrument panel mounted equipment Passenger air bags in GM vehicles deploy in different ways depending upon the type of vehicle and the particular instrument panel design In some vehicles the passenger air bag deploys through a discrete door located on the top surface of the instrument panel top mount air bag systems In other vehicles such as the Chevrolet Tahoe the passenger air bag deploys through a discrete door mounted on the vertical rearward surface of the instrument panel above the glove box door mid mount air bag system With these types of top mount and mid mount passenger air bag systems the top pad of the in
180. he same flash rate as the headlamps Depressing the brake pedal will override the stop lamp flashing and placing the transmission in Reverse will override the backup lamps flashing During daylight conditions the Daytime Running Lamps DRL are automatically turned off whenever the headlamps flashing module is activated During night time conditions the low beam headlamps automatically turn on while the high beam lamps flash Turning on the high beam headlamps manually will override the flashing module and the high beam headlamps will operate continuously During night time conditions the tail lamps will turn on automatically If Option 968 is present the low beam headlamps and tail lamps will not come on automatically The Center Mounted Stop Lamp will operate only when the service brakes are applied A 20 amp fuse labeled HEADLAMP WASH protects the flasher module circuit The fuse is located in the under hood fuse block in the engine compartment on the driver side of the vehicle See also the Owner Manual for more information Activation of the headlamps flashing and rear lamps flashing can be separated by opening the dark blue yellow BCM circuit at the flasher module connector C122 F and applying a customer switched ground to the harness side of the wire at the connector Power to dark green red wire must be OFF to flash rear only Warning BCM will be damaged if 12V power is connected to the dark blue yellow wire NOTE For wiring diag
181. hield requires 4 wheel drive model STEERING WHEEL Heated standard on LTZ trim TRANSFER CASE Active 2 speed electronic autotrac with rotary controls includes neutral position for dinghy towing requires 4WD models SPECIAL EQUIPMENT OPTIONS AVAILABLE EXTERIOR BODY COLORED PARTS Victory Red with special paint WA9260 Victory Red painted front and rear fascias rear liftgate handle and rear license plate applique body side moldings and door handles Required with Victory Red special paint WA9260 FLOOR CONSOLE DELETE Deletes floor console and associated audio equipment that is included with premium cloth high back buckets seats requires PEG 1FL and RPO A95 bucket seats LABEL FASTEN SAFETY BELTS On Left hand and right hand front door window glass OFF ROAD SUSPENSION Off road suspension 4x4 commercial or low uplevel d cor includes 771 off road suspension components skid plate and high capacity air cleaner does not include body side 771 decals requires model K10906 option QJP P265 75R17 on off road tires PEG 1FL Suburban 115 or 1LT Uplevel Package and a fleet or government type order SEATS CLOTH FRONT VINYL REAR Vinyl 2nd row rear seats and cloth front seats if AS3 third row seat is ordered it will be vinyl Requires AZ3 front custom cloth 40 20 40 bench seat or A95 front custom cloth high back bucket seat trim code 19D Ebony and PEG 1FL SEATS DRIVER AND PASSENGER FRONT INDIVIDUAL SEATS IN VINYL TRIM Derived from RPO A
182. hment of special equipment should minimize added resistance or interference to upward rotation of the top pad during deployment Side Impact Air Bags for crashes to the vehicle sides The air bag system in your police vehicle includes includes roof rail mounted Head Curtain side air bags The vehicle is also equipped with seat back mounted upper body air bags located on the outboard side of the driver and front passenger seat backs Together the Head Curtain and seat mounted side air bags are intended to protect the head and upper body in the event of a side crash Some vehicles may also be equipped with an optional air bag mounted on the inboard side of the driver seat back Can Specialty Vehicle Security Barriers be mounted within the side air bag deployment zones No The side air bags inflate extremely fast because of the nature of side crashes to the vehicle Mounting a security barrier behind the front seats with the ends placed within the side air bag deployment zones will result in unintended interaction between the barrier and the inflating side air bags To reduce the risk of injury to the vehicle occupants GM recommends that the side air bag zones be kept free of any customer installed equipment Customer furnished equipment installed to the vehicle roof Your police vehicle is designed with an interior roof cover system which includes internal components for the interior lamps and wiring The roof system may also include side ai
183. hreshold level In addition your vehicle has dual stage frontal air bags which tailor the the amount of restraint according to crash severity For moderate frontal impacts the air bags inflate at a level less than full deployment For more severe frontal impacts dual stage frontal air bags deploy at full levels If the front of your vehicle goes straight into a wall that doesn t move or deform the threshold level of the reduced deployment is about 12 to 16mph 19 to 15 km h and the threshold level for a full deployment is about 18 to 24 mph 29 to 28 5 km h The threshold level can vary however with specific vehicle design so that it can be somewhat above or below this range If your vehicle strikes something that will move or deform such as a parked car the threshold level will be higher The driver s and right front passenger s frontal air bags are not designed to inflate in rollover side impacts or rear impacts because inflation would not help the occupant Seat mounted side impact air bags are designed to inflate in moderate to severe side crashes The side impact air bags will inflate if the crash severity is above the designed threshold level The threshold level can vary with specific vehicles design The side impact air bags are not designed to inflate on frontal or near frontal impacts or rear impacts because inflation would not help the occupant Roof rail mounted head curtain air bags are designed to inflate in
184. i link with coil springs shocks and heavy duty stabilizer bar Goodyear P265 60R17 all season V rated blackwall CHECK TIRE PRESSURE will display in driver message center spare tire includes sensor must be programmed when mounted see page 18 Full size spare lockable with outside winch type carrier mounted under frame at rear includes TPM sensor not programed Not available on Police Package PPV Deactivated when Police Performance Mode is engaged Enhanced calibration 6 speed automatic with overdrive electronically controlled transmission provides protection against over revving the engine in low gear and a mechanical low gear blockout is not required if a driver manually selects low gear and fails to manually upshift to high gear the powertrain control module automatically protects the drivetrain 17 x7 5 heavy duty black steel Polished finish bolt on metal 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 TAHOE 2WD POLICE PACKAGE PPV POWERTRAIN ENGINE TRANSMISSION OPTION DISPLACEMENT FUEL OPTION OPTION CODE LITERS CU IN SYSTEM CODE CODE 5 3 325 Active fuel 6180 management 6 speed FlexFuel auto with OD gas or E85 ethanol EMISSIONS must BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connec
185. icle Mounting a security barrier behind the front seats with the ends placed within the side air bag deployment zones will result in unintended interaction between the barrier and the inflating side air bags To reduce the risk of injury to the vehicle occupants GM recommends that the side air bag zones be kept free of any customer installed equipment Customer furnished equipment installed to the vehicle roof Your police vehicle is designed with an interior roof cover system which includes internal components for the interior lamps and wiring The roof system may also include side air bag components Inflation devices may be mounted on the vehicle roof side behind the rear doors as well as air bag tethers retained to the windshield pillars Care must be taken to avoid damage to these components or interference with their operation when installing roof mounted equipment such as emergency lamps and communication antennas Recommended GM service procedures must be followed to remove and re install the instrument panel top pad to ensure that the top pad will release properly in the event of a passenger air bag deployment On the right half of the top pad closest to the passenger air bag module GM recommends that no equipment be mounted When mounting equipment on the driver side of the top pad GM recommends that the total mass of the top pad mounted special equipment not exceed 8 pounds 3 6 kilograms since some top pads tend to rotate about
186. imited number of keys learned for the particular option fleet key and must be learned using one of the original master keys When programming the RPO AMF additional 6 remote transmitters the original 2 transmitters delivered with a vehicle must also be reprogrammed at the same time A maximum of 8 remote transmitters can be programmed for a single vehicle TRW WIRING PROVISIONS FOR EMERGENCY WEHICLE ROOF LAMP Battery power is supplied through a 30 amp fuse to a wiring harness located in the roof Power is controlled with a switch located in the overhead console The customer or vehicle upfitter must complete the installation to an added accessory such as an emergency beacon lamp Maximum rated electrical load is 21 amp 250 watts The added electrical requirements must not exceed 21 amp 250 watts Running the accessory for long periods of time with the engine off may run the battery down A 25 39 inches 645 mm B 17 32 inches 440 mm 3 94 inches 100 mm square D Roof centerline E Roof edge NOTE For wiring diagram see page 30 6B2 REAR DOOR HANDLES INOPERATIVE Inside rear door handles are disconnected Rear doors can only be opened from the outside BN5 SWITCHES REAR WINDOW ous Rear door window switches are 02227 Rear door power regulators operable only from driver position switches 6N6 REAR DOOR LOCKS INOPERATIVE AV Rear door NET rods are disabled Rear door locks are inopera
187. in line connector for Exterior Lamp Flashing System see option 6J7 on page 6 WIRING DIAGRAMS See pages 18 through 21 for description or the owner s manual EXTERIOR FEATURES ANTENNA Radio roof mounted center of roof near rear window BODY SIDE MOLDINGS Not available DEFOGGER Electric rear window DOOR HANDLES Black DOOR LOCKS Power door locks automatically locks doors when transmission is out of Park Customer can re program to disable door locking and unlocking via the radio vehicle customization menu See page 11 A key lock cylinder is standard on driver and front passenger doors child safety locks in rear doors Options 6N5 and 6N6 are available to disable rear door windows and rear door latch locks HEADLAMPS Halogen automatic lamp control with daytime running lamps For Daytime Running Lamps Delete see option VVS on page 6 HORN Dual note high and low KEYLESS ENTRY Includes two integrated keys and transmitters the keyless entry system is programmed in stealth mode When the remote transmitter unlock or lock is operated no exterior lamps or sounds are activated Interior lights will come On when the remote lock unlocks are activated unless the front overhead console dome lamp switch is Off NOTE Remote Transmitters do not function when a key is detected in the ignition KEYS 2 keys with integrated remote keyless entry side milled two sided with folding feature see page 17 for description random code for igniti
188. increased front stabilizer bar 26mm from 24mm Increased ground clearance 6 0 in from 5 6 in Folding blade key FOB replaces solid shaft with standard Remote Keyless Entry and remote vehicle start New exterior color Mystic Green GZ7 Inside rearview manual day night mirror without compass Auxiliary Battery 700 70 Amp Hour Fleet Key new configuration 6 MyLink functionality varies by model Full functionality requires compatible Bluetooth smartphone and USB connectivity for some devices MyLink on Spark and Sonic does not include functionality such as enhanced voice recognition Gracenote and CD player 7 The Bluetooth word mark is a registered trademark owned by Bluetooth SIG Inc and any use of such mark by GM is under license Go to gm com Bluetooth to find out which Bluetooth phones are compatible with the vehicle 12 Not compatible with all devices Shown with aftermarket equipment Detective Package Option 9C3 front center console with armrest and 2 auxiliary outlets Floor mounted shift lever Inside rearview mirror with compass Driver 8 way power seat adjuster Front passenger 8 way power seat adjuster Option AGF Battery auxiliary 600 CCA 70 AMP Option K4S Power rack and pinion steering Overhead sunglass storge compartment Power Steering oil cooler Inoperative dome lamp Option 7Y6 Alto Grey Metallic GGG Content Theft Alarm Radio Mute wiring provision Jet Black in
189. is located in the under hood fuse block in the engine compartment on the passenger side of the vehicle See also the Owner Manual for more information Activation of the headlamps flashing and rear lamps can be separated by opening the blue green BCM circuit at the flasher module connector P181 F and applying a customer switched ground to the blue green wire in the upfitter harness 16 cavity connector P277 16 at the right side of the equipment mounting platform Power to the green wire must be OFF to flash rear lamps only Warning BCM will be damaged if 12V power is connected to the dark blue yellow wire NOTE For wiring diagram see page 18 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE 9C1 SPECIAL EQUIPMENT OPTIONAL 17 KEYS AND TRANSMITTERS KEYS PART NUMBER DESCRIPTION 13585404 Key Transmitter Assembly Door Lock and Ignition Lock CUT KEY Master AX2 Random Cut 13585687 Key Transmitter Assembly Door Lock and Ignition Lock UNCUT KEY Master AX2 Key Blank See Dealer Key Transmitter Assembly Door Lock and Ignition Lock CUT KEY Fleet AU7 Keyed Alike 6E3 See Dealer Key Transmitter Assembly Door Lock and Ignition Lock CUT KEY Fleet AU7 Keyed Alike 6E4 13585688 Key Transmitter Assembly Door Lock and Ignition Lock UNCUT KEY Fleet AU7 Key Blank 6E3 6E4 92271667 Key Door Lock and Ignition Lock UNCUT KEY Master AX2 Ke
190. is reduced Do insurance companies give a discount for ABS Yes many insurance companies give discounts that range from 596 to 1096 In the states of New York and Florida all insurance companies are required to give an ABS discount of 596 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL ANTI LOCK BRAKING SYSTEM AND STABILITRAK A Always maintain a safe following distance ABS does not allow you to stop on a dime Generally a 2 second following distance is considered safe in ideal conditions Watch the vehicle in front of you pass a fixed marker such as a sign Count seconds one thousand one IMPORTANT DRIVING SAFETY TIPS B Always drive carefully especially on slippery surfaces ABS cannot create friction between the tires and the road surface it can only give the driver the maximum advantage of the existing adhesion If the vehicle is traveling on a surface with no adhesion the best ABS in the C Itisa good idea to practice an ABS activated stop and get the feel of the brake pedal However please make sure it s at safe time with no obstacles in your path And you only really n
191. is supplied through two fusible links one 50 amp and one 65 amp to three circuit breakers and two control relays located in the relay center above the accelerator pedal 50 amp circuit breaker feeds power directly from the 50 amp fusible link through a 10 gauge 5 0 mm blunt cut wire Two 30 amp circuit breakers supply power from the 65 amp fusible link through the contacts of the control relays to 12 gauge 3 0 mm blunt cut wires The blunt cut leads are part of a 5 foot 1 5 m WIRING DIAGRAM FOR AUXILIARY BATTERY POWER JUNCTION BLOCK WIRING DIAGRAM FOR CONTROLLED POWER AND SIGNAL CIRCUITS WITH 12 VOLT POWER SUPPLY ABS Power Distribution Vehicle I Schematics in Speed Wiring System Signal BCM Park Enable Hot Out of Park Fuse Block Underhood START RUN Fuse Block Instr Pnl ACCY RUN 5810 818 YE BK BN 0 5 0 35 Fusible Fusible Blunt Cut at Right Front Floor Link Link BU BK BU BK 3 3 Bunt cut ignition controlled power and signal circuits are also included in the following 5 foot 1 5 m right foot loop The spotlamp fuses are located in the S RED 702 passenger side underhood fuse block See Fuses and Circuit Breakers in your B 360 owner s manual index for more information 8 RED 702 A yellow 20 gauge 0 5 mm 10 amp fused circuit HOT in ACCESSORY RUN A or RAP Retained Accessory Power Fuse is in the end of the instrument panel A pink 20 gauge 0 5 mm2 10 amp fus
192. its are routed from the passenger compartment to a 2 foot 30 cm coil secured the instrument panel Connection to customer switching permits operation of the in the area behind the grille There are four 16 gauge 1 5 mm wires for horn or siren with the horn button connecting to the grille lights and siren speaker WIRING DIAGRAM FOR WINDSHIELD PILLAR MOUNTED SPOTLAMP OPTION 7X6 AND 7X7 Spotlamp LH Minifuse 15A J281 P281 5440 H7635 ELECTRICAL CENTER 41 Spotlamp RH Minifuse 15A H7635 EM ner SPE v 5540 Ge 5 A 0 5 A PWR CASE GND 7X6 spotlamp left hand and 7X7 spotlamps left and right hand pillar mounted Unity 6 inch with replaceable H3 halogen bulb independently fused NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C1 WIRING DIAGRAMS 21 WIRING PROVISION 25MM ACCESS HOLE RH DASH PANEL below RH end of A Blanking grommet through front of dash below the oval wire grommet B Bulkhead in filter chamber 0 Possible upfit harness routing 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 22 AIR BAG FAG Can specialty vehicle equipment e g radar devices video cameras computers meters radio trees shotguns etc still he mounted in cars with passenger side air bags Yes but care must be taken to m
193. ke pedal down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you NOTE All dimensions are approximate and subject to change Should I drive an ABS equipped vehicle differently than would drive a vehicle with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lockup When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and steer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder and or brake system performance are being sold in the aftermarket Some of these products imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems
194. l A coil of sufficient length to reach either corner of the trunk is secured to the right inner wheelhouse There is no hole in the roof panel 867 LAMP AUXILIARY DOME RUF FULL SIZE SPARE TIRE pd Dome lamp located between visors with switch at base of lamp red LED white Cover is provided for spare tire and wheel Full size spare tire is mounted on top of incandescent auxilary wired independently from standard dome lamp the standard trunk trim covering the space saver spare tire tub If full size spare tire is removed tub is exposed The full size spare tire includes a Tire Pressure Monitor TPM sensor which must be programmed to the TPM System after the spare tire is installed see page 17 T53 LAMPS TRUNK LID WARNING Two 4 inch red single faced lamps are mounted to the deck lid inner panel Lamps are activated by the deck lid ajar mechanical switch when deck lid is opened Lamps are wired to flash alternately through a flasher located at the upper right hand corner of the trunk opening Wiring is protected by fuse HTDSEAT in the engine compartment fuse block 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP 19 BJ7 EXTERIOR LAMPS EMERGENCY 6J7 EXTERIOR LAMPS EMERGENCY FLASHING SYSTEM MODULE LOCATION This option 6J7 Exterior Lamp Emergency Flashing System module is mounted Option 6J7 provides a headlamps high beam flashing module rear la
195. l down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you NOTE All dimensions are approximate and subject to change Should I drive an ABS equipped vehicle differently than would drive a vehicle with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lock up When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and steer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder and or brake system performance are being sold in the aftermarket Some of these products imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems which d
196. l vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SUBURBAN COMMERCIAL FLEET 1FL 1 UPDATES FOR 2014 NEW FEATURES CONCORD METALLIC DELETED e BLUE RAY METALLIC GXH e BLACK GRANIT METALLIC 580 e SPECIALTY PAINT WHEATLAND YELLOW 253A e SPECIALTY PAINT DARK TOREADOR RED 334D e SPECIALTY PAINT DARK BLUE METALLIC 722J e SPECIALTY PAINT BLUE 5665 e SPECIALTY PAINT GREEN 7941 e SPECIALTY PAINT WOODLAND GREEN 8015 e SPECIALTY PAINT YELLOW 9414 e NO 3 4 TON MODELS FOR 2014 MODEL YEAR 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 SUBURBAN COMMERCIAL FLEET 1FL NOTE This vehicle is NOT designed nor intended for use IN HIGH SPEED EMERGENCY VEHICLE OPERATIONS CC10906 CK10906 WARRANTY AIR CONDITIONING ASSIST HANDLES CONSOLE OVERHEAD CRUISE CONTROL DOME LAMPS FLOOR COVERING GLASS MIRROR ONSTAR POWER OUTLETS RADIO RESTRAINT SYSTEM SEAT FRONT SEAT REAR SEAT THIRD ROW SPEEDOMETER CLUSTER STEERING COLUMN WHEEL THEFT DETERRENT VISORS WARNING TONES WINDOW OPERATION MODEL AVAILABILITY Rear wheel drive 1 2 ton 4 wheel drive 1 2 ton STANDARD EQUIPMENT SUMMARY 3 years 36 000 miles bumper to bumper whichever comes first see dealer for details 5 years 100 000 miles limited powertrain whichever comes first see dealer for details INTERIOR FEATURES Tri zone manual climate control with individual climate s
197. linder no longer available on passenger front door and rear liftgate child safety locks included in rear doors Color keyed Color keyed with step pad Not available Dual halogen composite with flash to pass feature automatic exterior lamp control and daytime running lamps to delete automatic lamp control see option 9G8 on page 17 Dual note Includes two transmitters with non functional panic button stealth mode feature includes exterior lamps and horn disable if remote start Option AP3 is included running lamps will remain illuminated additional transmitters are available see option AMF on page 19 Two sided random code for ignition and driver door only Not available Outside heated power adjustable manual folding Matte Black Liftgate liftglass with washer and wiper power liftgate not available and no lock cylinder on liftgate Two front Not available Intermittent with washer CHASSIS FEATURES High capacity 160 amp with idle boost transmission in PARK or NEUTRAL based on battery energy level 660 CCA 80 amp hour rating with battery rundown protection does not protect customer installed equipment 4 wheel anti lock front and rear disc with vacuum boost power assist Heavy duty high capacity radiator electric fans and extended life coolant coolant hoses are EPDM ethylene propylene diene monomer rubber silicone hoses are not required coolant is DEX COOL good for 5 years 150 000 miles protects from 34 F to 265
198. line This equipment must be mounted as low as possible and securely fastened to the top pad to avoid being dislodged in the event of a crash and possible air bag deployment In the process of securely fastening special equipment to the top DO NOT fasten down the top pad itself to any other vehicle component such as the cluster trim plate As described above the top pad rotates upward during a deployment In order to enable the proper deployment of the passenger air bag specialty equipment installation MUST NOT PREVENT the top pad from rotating upward during deployment Location and attachment of special equipment should minimize added resistance or interference to upward rotation of the top pad during deployment Side Impact Air Bags for crashes to the vehicle sides The air bag system in your police vehicle includes includes roof rail mounted Head Curtain side air bags The vehicle is also equipped with seat back mounted upper body air bags located on the outboard side of the driver and front passenger seat backs Together the Head Curtain and seat mounted side air bags are intended to protect the head and upper body in the event of a side crash Some vehicles may also be equipped with an optional air bag mounted on the inboard side of the driver seat back Can Specialty Vehicle Security Barriers be mounted within the side air bag deployment zones No The side air bags inflate extremely fast because of the nature of side crashes to the veh
199. ll be gloss Black This includes front and rear facias liftgate handle and applique D pillars and upper liftgate applique Mirrors and door handles will be grained Black parts B85 body side moldings are not available except with SEO option 514 exterior body colored parts May require extended lead time Required with any SEO paint selection May require extended lead time 7X6 SPOTLAMP Left hand separately fused see page 26 7X7 SPOTLAMPS Left and right hand separately fused see page 26 WX7 WIRING For customer connection to front door and windshield pillar speakers Front speakers not connected to the vehicle radio radio audio signals are routed to the rear speakers see page 26 6J3 WIRING For grille lamps and siren speaker see page 27 6J4 WIRING For horn siren circuit in line connection for customer furnished switch see page 26 For standard and optional illustrations see pages 23 through 27 Note Factory installation of spotlamps are recommended Special tooling is used to locate and drill the spotlamp shaft hole in the pillars as well as modifying the door edge for lamp shaft clearance Interior trim covers provided with factory installed lamps are not available as service parts Field installation of spotlamps must not interfere with proper deployment of the roof rail airbag in the event of a crash 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 8 TAHOE 2WD POLICE PACKAGE PPV SPECIFICATIONS
200. lly switched at the lamp base Remote lock unlock audible visual functions are OFF horn chirp OFF when a door is open with remote lock requested WIRING DIAGRAM FOR HEADLAMP AND REAR LAMPS FLASHING SYSTEM 6J7 MODULE 12 VOLT SEPARATION OF FRONT ON CONNECTION AND REAR FLASHING w y 15 P277 16 P277 ELECRICAL CENTER EF16 EF35 EF16 TO UNDERHOOD BATTERY 6841 BU GN 0 5 SA6841 6841 D BU YE 0 5 0 53 I X209 J126 P126 7 126 7T P126 Gnd Dist 68204 G104 uU GN 0 5 P181 C P181 D P181 181 F P181 B J181 J181 P181 INLINE CONNECTOR FOR HEADLAMP FLASHER MODULE AT TOP RIGHTHAND RADIATOR SUPPORT WH 14 LF High Beam RF High Beam An in line connector in the forward lamp harness permits installation of a compatible flasher module for the exterior lamps Emergency Flashing System The in line flasher module connector is located at the RH end of the upper radiator support and includes two wiring circuits to the front compartment foot well A green wire is intended for customer connection to switched 12 volt power to activate the flasher module A second blue green wire permits optional separate control of the headlamp flashing and rear lamps flashing Separate control of the rear lamps flashing requires opening the blue green control circuit at the in line connector terminal P181 F and application of switched vehicle ground to the control wire in the forward compartment P277
201. lso if the roads are wet or icy or visibility is poor you should increase your following distance world cannot provide a shorter stopping distance or good steering ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK Q How does StabiliTrak work A StabiliTrak has the ability to apply control forces to the vehicle independent of the driver StabiliTrak uses sensors to continuously compare the path indicated by the steering wheel position to the vehicle s actual path If a discrepancy is detected StabiliTrak selectively controls vehicle brakes and engine torque to create a yaw moment that helps restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak has the ability to help correct both understeer where the vehicle is not turning as much as the steering wheel position indicates and oversteer where the vehicle is turning more than the steering wheel position indicates The illustration at right shows how selective braking at a particular wheel can create a compensating yaw moment to help restore the vehicle s actual path to the path indicated by the steering wheel position Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you repla
202. ltale on the dash will be illuminated Should this happen the vehicle should be taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the brake pedal down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you Should I drive an ABS equipped vehicle differently than I would drive a vehicle with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lock up When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and steer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder and or
203. lts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL AIR BAGS FAQ 1 Can the installation of push bumpers on the front end of the vehicle affect the deployment of the air bag General Motors is not aware of adverse effects during crash events from the many push bumpers thai have been installed on GM police vehicles Because there are many styles of push bumpers available with varying crash characteristics installation of push bumpers may or may not affect deployment timing of the air bags Push bumpers should be mounted to avoid modifying the vehicle structure and interfering with the front air bag sensors mounted on the upper radiator support cross member Two front impact sensors are installed in General Motors vehicles Do not relocate or disconnect the front sensors The location and orientation of the front sensors are critical for correct operation of the air bag system Avoid mounting components on or near the sensors Push bumper styles with vertical pushing members that are in foreaft alignment with the front air bag sensors are not recommended When should an air hag inflate The driver s and right front passenger s frontal air bags are designed to inflate in moderate to severe front
204. matic Mode Headlamp switch in the AUTO position and night time conditions exist the exterior lighting will automatically come ON In day time conditions the Daytime Running Lamps DRL will be ON Surveillance Mode is a standard feature in the Caprice Police vehicle The Surveillance Mode circuit is terminated in cavity 1 of the 16 cavity upfitter connector P277 located at the passenger side front of the equipment mounting platform When Surveillance Mode is activated by applying a ground to the White Violet wire in cavity 1 all automatic lighting functions are suppressed All manually operated lighting controls remain functional e g exterior lamps turn stop If RPO VVS DRL and AUTO HEADLAMPS Disabled is present exterior light is manually controlled all other listed items are suppressed when Surveillance Mode is activated Radio Display is OFF If the radio is ON the audio remains on in the Surveillance Mode Instrument Cluster is OFF PRNDL remains barely discernable per FMVSS 101 Low Beam Headlamps are OFF DRL are OFF during daytime High Beam Headlamps are OFF Flash to Pass remains functional Tail Lamps are OFF Stop Lamps and Turn Signals remain functional License Lamps are OFF Dome Lamps are disabled inoperative at the lamp switches and remain off when a door is opened All interior lighting is OFF e g controls HVAC glove box trunk Auxiliary Dome Lamp RPO 607 is functional but loca
205. may protect certain equipment from being damaged or dislodged it may also negatively affect the inflation characteristics of the air bag The air bags shape inflation angle fold pattern and inflation rate and pressure are developed to maximize the protection capability of the inflatable restraint system Therefore GM cannot recommend the placement of any equipment in the deployment zone even if it is shielded to protect it from damage Front air bag systems and instrument panel mounted equipment Passenger air bags in GM vehicles deploy in different ways depending upon the type of vehicle and the particular instrument panel design In some vehicles the passenger air bag deploys through a discrete door located on the top surface of the instrument panel top mount air bag systems In other vehicles such as the Chevrolet Tahoe the passenger air bag deploys through a discrete door mounted on the vertical rearward surface of the instrument panel above the glove box door mid mount air bag system With these types of top mount and mid mount passenger air bag systems the top pad of the instrument panel remains in place during deployment Some GM passenger air bag systems like the system in the Chevrolet Impala deploy from beneath the instrument panel top pad These are considered 3 4 mount air bag systems with a deployable top pad The entire instrument panel top pad is the deployment door from under which the inflating air bag
206. mbly is supplied by the primary battery Three circuit breakers and two control relays are located in the right side of the trunk The relay center is connected via the body harness to the front compartment auxiliary power and signal connectors A 50 amp circuit breaker feeds power directly from the 100 amp fusible link via a 10 gauge 5 0 mm wire Two 30 amp circuit breakers supply power from fusible links through the contacts of the control relays to 12 gauge 3 0 mm wires Each relay is operated by control leads terminated in the front compartment 6 cavity connector A 10 gauge 5 0 mm ground circuit is terminated in the 2 cavity connector with the 50 amp battery power A total of 1320 watts of 12 volt power is available in the front compartment 1440 watts of 12 volt power is available at the trunk junction block NOTE If 50 amp battery power is not present at the front compartment upfitter harness verify the connection of the topmost blue of two connectors located above the right hand rear compartment junction block For wiring diagram see pages 18 and 19 See also page 13 Rear Auxiliary Power and Ground Stud and page 16 55 Auxiliary Battery DOME LAMPS CONTROL Buttons are located in front dome lamp assembly A The push on push off left switch with a Doors Open symbol on the front dome lamp assembly controls the front and rear dome lamps When activated the dome lamps will remain Off whenever any door is opened the vehicl
207. me body mount bracket to rear underbody Right hand center frame body mount bracket to center underbody Exhaust pipe hanger rod to rear frame hanger TIRE PRESSURE MONITOR Your vehicle is equipped with a Tire Pressure Monitor TPM System which warns of low tire pressure The TPM System on your Tahoe Police Package has a spare tire sensor but is not programmed to read the spare tire pressure When the spare tire from your vehicle or an unused spare tire from another Police Package is placed in use as a road wheel the system will not read the presence of the new TPM sensor and must be calibrated Refer to your owner s manual for additional information on the Tire Pressure Monitor and Sensor Programming The Special Service Package 5WA does not have sensor in spare tire WIRING PROVISIONS FOR 12 VOLT BATTERY POWER SUPPLY Your vehicle is equipped with wiring provisions for a 12 volt battery power supply Refer to the following information when adding electrical system The wiring harness is located below the instrument panel near the center of the vehicle The following information describes the breaker and relay location The 12 volt battery power is supplied through two underhood mega fuses one 125 amp and one 60 amp This underhood power is fed to the breaker relay center via a harness that passes through the driver side front of the dash and routed across the instrument pane to a position forward of the glove box The breaker relay center
208. mplete vehide fleet not compatible with 2005 and earlier Impalas 2006 and earlier Tahoes and 2011 and later Caprice AMF KEYLESS ENTRY TRANSMITTERS Fleet Package includes 6 additional transmitters Transmitters are not programmed Each transmitter including the two standard with the vehide must be programmed together by a dealer at customer expense Transmitter programming is not a warranty item See also your owner s manual supplement for programming information see also page 25 for customer programming of transmitters using the vehicle Driver Information Center procedure NOTE Vehicle specific common fleet transmitter frequency not available G80 LOCKING DIFFERENTIAL Heavy duty TRW PROVISION FOR ROOF MOUNTED LAMP Overhead console mounted switch and wiring to the roof upfitter to install and connect a roof mounted warning lamp instructions provided in owner s manual supplement see page 25 6N6 REAR DOOR LOCKS INOPERATIVE Rear power locks are inoperable at rear door but operate from drivers position see page 25 6B2 REAR DOOR HANDLES INOPERATIVE Rear door inoperative doors can be opened only from outside see page 25 6N5 REAR DOOR WINDOW SWITCHES INOPERATIVE Rear windows only operate from drivers position see page 25 AP3 REMOTE VEHICLE STARTER SYSTEM Includes remote keyless entry 515 SEATS Front cloth with vinyl rear seat see page 4 TGK SPECIAL PAINT SOLID One color all normally body colored non sheet metal parts wi
209. mps cargo lamp with delayed entry feature and map lamps see page 24 interior exterior lamp control to turn off dome ight Black vinyl floor and load floor behind second row seats Deep tinted all windows except light tinted glass on windshield driver and front passenger side glass Locking door and no light Inside rearview manual day night Not available Not available Standard displayed in Driver Information Center AM FM stereo with MP3 compatible CD player seek and scan digital clock auto tone control Radio Data System RDS speed compensated volume and theftlock Tahoe received an overall 5 star frontal and side crash test rating from NHTSA Safety belts driver and front passenger with pretensioners dual stage driver and passenger frontal air bags passenger sensing system and frontal air bag ON OFF indicator rollover sensor dual head curtain air bags for front and rear outboard occupants and front seat back mounted thorax pelvic air bags Cloth bucket seats 6 way power driver and passenger seat adjusters with manual reclining seat back and lumbar controls and adjustable head restraints see page 4 Vinyl split folding 60 40 bench with outboard seating position headrests 3rd seat not available see page 4 140 mph certified analog speedometer 1 mph increments and digital trip odometer with gauges for engine oil pressure fuel battery volts and coolant temperature Driver Information Center displays engine hours warning
210. mps flashing on the front of the right hand upper radiator support below the upper radiator via the Body Control Module BCM and a control wire for customer furnished air baffle switching to turn the module on and off The flasher control wire is part of the NOTE For wiring diagram see page 24 blunt cut upfitter harness coiled under the instrument panel in the front passenger side foot well The flashing module is located is located on the front side of the upper radiator support at the inboard end of the passenger side headlamp assembly BJ B LA M PS R EA R WI N D OW The headlamp flashing module is activated by the application of 12 volts to a dark green red wire in the upfitter harness When activated the headlamp high beams and the high beam instrument cluster indicator will flash alternately at 2 4 flashes per second When the flashing module is turned on the module sends a signal to the BCM which alternately flashes the stop lamps and backup lamps at the same flash rate as the headlamps Depressing the brake pedal will override the stop lamp flashing and placing the transmission in Reverse will override the backup lamps flashing During daylight conditions the Daytime Running Lamps DRL are automatically turned off whenever the headlamps flashing module is activated During night time conditions the low beam headlamps automatically turn on while the high beam lamps flash Turning on the high beam headl
211. n Center includes 1 mph redundant digital speed display see message center listing on page 15 See exterior lamps control on page 17 for operation description Tilt wheel with column mounted gear shift lever Vehicle PASS Key Ill content theft deterrent is disabled to enable content theft deterrent option UA6 must be ordered Heavy duty see page 17 Brake safety belt air bag anti lock brake and check engine see page 15 for additional information Key in ignition driver door open driver and passenger safety belt not buckled headlamps on Power with driver express down rear window lockout switch ELECTRICAL FEATURES 100 amp ignition and main power supply wiring under lower right side of instrument panel see wiring provisions for 12 volt battery power supply on page 16 100 amp auxiliary power outlet in trunk see page 16 Auxiliary located in trunk see page 16 Not available driver door can be locked with the key in the ignition Lock out protection feature cannot be activated Two 12 volt 20 amp located on lower center of instrument panel Battery power is present at all times See pages 23 through 25 for description also see Impala Police Package owner s manual supplement located in glove box folder with standard owner s manual Forward lamp harness in line connector for Exterior Lamp Flashing System see option 6J7 on page 9 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuri
212. n a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However performance is reduced Do insurance companies give a discount for ABS Yes many insurance companies give discounts that range from 596 to 1096 In the states of New York and Florida all insurance companies are required to give an ABS discount of 596 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 1 Always maintain safe following distance ABS does not allow you to stop on a dime Generally a 2 second following distance is considered safe in ideal conditions Watch the vehicle in front of you pass a fixed marker such as a sign Count seconds one thousand one one thousand two until your front bumper reaches the marker If you do not count out IMPORTANT DRIVING SAFETY TIPS B Always drive carefully especially on slippery surfaces ABS cannot cre
213. ne monomer rubber silicone hoses are not required coolant is DEX COOL good for 5 years 150 000 miles protects from 34 F to 265 F and against rust and corrosion Vortec 5300 V8 SFI with variable valve timing VVT active fuel management AFM FlexFuel gasoline or E85 ethanol top speed fuel cut off at 139 mph includes air conditioning wide open throttle cut off Full perimeter modular with hydroformed rails 26 gallon 98 liters Heavy duty engine transmission and auxiliary air to oil power steering see page 23 Steel 3 5 inch diameter Grounding straps at five additional locations see page 23 for locations Front underbody shield starting behind front bumper and running to 2nd cross member protecting front underbody and oil pan Extended life iridium tip Stability enhancement system An advanced computer controlled system that assists the driver with directional control of the vehicle in difficult driving conditions Each time the vehicle is started the StabiliTrak system is fully on StabliliTrak can be controlled by a StabiliTrak button on the instrument panel located below the air conditioning fan control see page 25 The condition of the system is displayed by an instrument panel StabiliTrak indicator light and Driver Information Center DIC Messages Push once Traction Control is off push again and Traction Control and StabiliTrak are turned back on Power rack and pinion Coil over shock with stabilizer bar Mult
214. nel design In some vehicles the passenger air bag deploys through a discrete door located on the top surface of the instrument panel top mount air bag systems In other vehicles such as the Chevrolet Tahoe the passenger air bag deploys through a discrete door mounted on the vertical rearward surface of the instrument panel above the glove box door mid mount air bag system With these types of top mount and mid mount passenger air bag systems the top pad of the instrument panel remains in place during deployment Some GM passenger air bag systems like the system in the Chevrolet Impala deploy from beneath the instrument panel top pad These are considered 3 4 mount air bag systems with a deployable top pad The entire instrument panel top pad is the deployment door from under which the inflating air bag emerges When an air bag deployment is commanded the forces from the inflating passenger air bag push up on the instrument panel top pad releasing special fasteners across the rearward edge of the top pad This allows the top pad to rotate upward so that the passenger air bag may emerge The top pad rotates upward to open widest at the right hand side and is usually forced upward into contact with the windshield on the right hand side of the vehicle during a deployment Instrument panel top mounted special equipment such as a radar antenna and control unit or video camera must be positioned to the left of the vehicle center
215. nol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL e CAPRICE POLICE PACKAGE 9C1 OPTIONS AYG G80 K5S VVS L77 6J7 6A3 6B7 6J5 AMF 6E3 GE4 6C7 T53 B42 B34 DR9 6N6 6N5 HCQ SGT 7X6 7X7 7X8 7X8 S68 6J3 6J4 WeP AIR BAG HEAD CURTAIN ROOF RAIL MOUNTED Combined front and rear passenger see page 24 and 25 for description AXLE Limited slip with V6 engine Standard on V8 engine BATTERY AUXILIARY Optional 700 cca 70 amp hour AGM battery to power customer installed equipment The auxiliary battery is connected to the charging system through an isolation relay to prevent emergency equipment electrical loads from depleting the vehicle primary battery if the engine is not running and the ignition is OFF Located at the passenger side of the trunk see page 16 for description DELETE DAYTIME RUNNING LAMPS AND AUTOMATIC HEADLAMPS Exterior lamps are operated manually see page 13 for description ENGINE 6 0L V8 SFI with active fuel management includes FlexFuel capability no additional charge FLASHER SYSTEM EXTERIOR LAMPS DRL compatible headlamp flasher module with wiring provisions to the front compartment for ON OFF control and optional separate flashing of front and rear lamps see page 16 for description FLOOR COVERING Heavy duty vinyl replaces production carpeting carpeted mats not
216. nominal equipment Actual values may vary due to equipment loading 3 Maximum payload capacity includes weight of driver passengers optional equipment and cargo DIMENSIONS t tin mm CC15543 CK15543 CC15743 CK15743 2WD Short Box AWD Short 2WD STD Box 4WD STD Box Crew Cab Crew Cab Crew Cab Crew Cab LOCATION Wheelbase 143 5 3 645 143 5 3 645 153 0 3 886 153 0 3 886 Overall length 230 0 5 843 230 0 5 843 239 6 6 085 239 6 6 085 Body width 80 0 2 032 80 0 2 032 80 0 2 032 80 0 2 032 Overall height 74 2 1 884 74 0 1 879 73 7 1 873 73 8 1 875 Head room front 42 8 1 087 42 8 1 087 42 8 1 087 42 8 1 087 Head room rear 40 5 1 029 40 5 1 029 40 5 1 029 40 5 1 029 Shoulder room front 66 0 1 677 66 0 1 677 66 0 1 677 66 0 1 677 Shoulder room rear 65 7 1 670 65 7 1 670 65 7 1 670 65 7 1 670 Hip room front 60 7 1 543 60 7 1 543 60 7 1 543 60 7 1 543 Hip room rear 60 3 1 531 60 3 1 531 60 3 1 531 60 3 1 531 Leg room front 45 3 1 150 45 3 1 150 45 3 1 150 45 3 1 150 Leg room rear 40 9 1 040 40 9 1 040 40 9 1 040 40 9 1 040 Cab to axle 32 0 812 32 0 812 41 5 1 053 41 5 1 053 Inside length at floor 69 3 1 761 69 3 1 761 78 9 2 003 78 9 2 003 Inside height 21 1 536 21 1 536 21 1 536 21 1 536 Front bumper to back of cab 150 9 3 833 150 9 3 833 150 9 3 833 150 9 3 833 Inside width between wheel housing Fleetside 51 0 1 296 51 0 1 296 51 0 1 296 51 0 1 296 Ground clearance 8 7 222 8 9
217. non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors including the road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of the pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the ABS telltale on the dash will be illuminated Should this happen the vehicle should be
218. nstalled FLOOR MATS ALL WEATHER Third row requires B30 color keyed carpeting and AS3 third row 50 50 split bench seats Not available with AZE front 40 20 40 split bench on 2WD models LPO dealer installed FOG LAMPS Front halogen GLASS Non deep tinted HEAVY DUTY TRAILERING PACKAGE Includes auxiliary transmission oil cooler and external engine oil cooler Includes 3 42 ratio rear axle LUGGAGE RACK CENTER RAILS Roof mounted Black LUGGAGE RACK Delete MAT REAR CARGO Requires B30 color keyed carpeting Not available with ATD third row seat delete LPO dealer installed MATS Color keyed carpeted first and second row removable included and only available with B30 floor covering MIRRORS Outside heated power adjustable vertical camper manual folding extension and integrated turn signal indicators ONSTAR Delete REMOTE 2 WAY ADVANCED LPO dealer installed REMOTE VEHICLE STARTER SYSTEM Includes remote keyless entry REAR PARKING ASSIST Ultrasonic with led display and audible warning requires JF4 power adjustable pedals RECOVERY HOOKS Front frame mounted Black Chrome only available on LTZ ROOF MOUNTED LAMP Provisions included with VYU Snow Plow Prep Package SKID PLATE PACKAGE Requires 4 wheel drive model indudes aluminum front underbody shield starting behind front bumper and running to first cross member protecting front underbody oil pan differential case and transfer case frame mounted s
219. nsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NET is ordered for delivery to a dealer located in California NOTE The 2013 Chevrolet Impala Police Patrol Vehicle with the 3 6L Engine LFX with Emission Option Codes FE9 NET and YF5 is certified to EPA Tier 2 Bin 4 standards and qualifies as ULEV Ultra Low Emission Vehicle under California Air Resources Board CARB requirements meaning it is 50 state certified Emission Standard BIN4 EPA engine family or test group DGMXJ03 6166 TIRES SPEED RATED MANUFACTURER QUANTITY SIZE SPEED RATING TYPE Goodyear 4 P235 55R17 SBR blackwall All Season BW NOTE Compact spare is standard full size spare is available see option RUF on page 9 Due to specific requi
220. nt such as a radar antenna and control unit or video camera must be positioned to the left of the vehicle center line This equipment must be mounted as low as possible and securely fastened to the top pad to avoid being dislodged in the event of a crash and possible air bag deployment In the process of securely fastening special equipment to the top DO NOT fasten down the top pad itself to any other vehicle component such as the cluster trim plate As described above the top pad rotates upward during a deployment In order to enable the proper deployment of the passenger air bag specialty equipment installation MUST NOT PREVENT the top pad from rotating upward during deployment Location and attachment of special equipment should minimize added resistance or interference to upward rotation of the top pad during deployment Side Impact Air Bags for crashes to the vehicle sides The air bag system in your police vehicle includes includes roof rail mounted Head Curtain side air bags The vehicle is also equipped with seat back mounted upper body air bags located on the outboard side of the driver and front passenger seat backs Together the Head Curtain and seat mounted side air bags are intended to protect the head and upper body in the event of a side crash Some vehicles may also be equipped with an optional air bag mounted on the inboard side of the driver seat back Can Specialty Vehicle Security Barriers be mounted within the side air bag
221. ntal or near frontal impacts if the crash severity is above the designed threshold level Safety belt pretensioners at the driver and front passenger seat positions are designed to deploy in frontal near frontal side and rear crashes that exceed the threshold level of crash severity to help reduce slack in the safety belt Safety belt pretensioners will also deploy in impending rollover situations How long will the air bag remain inflated It takes approximately 1 20th of a second to fully inflate the frontal air bags This is faster than the blink of an eye The air bags begin to deflate immediately helping to stop the occupants more gradually I ve heard that a deployed air bag produces whet appears to be smoke is the air hag hot After the bag has deployed in a crash the air bag itself will not be hot to touch Some components within the air bag module will be hot for a short time A small amount of smoke coming from a deployed air bag module is normal and should not be cause for concern Also when the nitrogen gas is vented out of the air bag small particles from inside the bag are also vented into passenger compartment These airborne particles look like smoke and some particles are deposited as residue on and around the air bag I ve heard that the dusts that are released into the passenger compartment from the air bag are harmful is this true For most people the only effect the dusts will produce is some irritation
222. o not relocate or disconnect the front sensors The location and orientation of the front sensors are critical for correct operation of the air bag system Avoid mounting components on or near the sensors Push bumper styles with vertical pushing members that are in foreaft alignment with the front air bag sensors are not recommended When should an air bag inflate The driver s and right front passenger s frontal air bags are designed to inflate in moderate to severe frontal or near frontal crashes But they are designed to inflate only if the impact speed is above the system s designed threshold level In addition your vehicle has dual stage frontal air bags which tailor the the amount of restraint according to crash severity For moderate frontal impacts the air bags inflate at a level less than full deployment For more severe frontal impacts dual stage frontal air bags deploy at full levels If the front of your vehicle goes straight into a wall that doesn t move or deform the threshold level of the reduced deployment is about 12 to 16mph 19 to 15 km h and the threshold level for a full deployment is about 18 to 24 mph 29 to 28 5 km h The threshold level can vary however with specific vehicle design so that it can be somewhat above or below this range If your vehicle strikes something that will move or deform such as a parked car the threshold level will be higher The driver s and right front passenger s frontal air
223. oaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles Does ABS reduce stopping distances Yes in braking situations where the wheels on a non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors including the road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of th
224. oad capacity includes weight of driver passengers optional equipment and cargo 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 10 AIR BAGS FAG Can specialty vehicle equipment e g radar devices video cameras computers meters radio trees shotguns etc still be mounted in cars with passenger side air bags Yes but care must be taken to mount the equipment outside of the deployment zone Air bags inflate with great force and will interact with any object in the deployment zone Therefore to reduce the risk of injury to vehicle occupants GM recommends that the air deployment zone be kept free of any equipment If a piece of equipment were to become dislodged it could strike an occupant in the vehicle and result in injury The likelihood of an object becoming dislodged is influenced by many factors including the proximity of the object to the inflatable restraint the size and shape of the object and the means by which the object is secured to the vehicle In addition to these factors the trajectory and velocity of a dislodged object can be influenced by the type and severity of vehicle crash Objects that are in the deployment zone but do not become dislodged by an inflating air bag can still affect the performance of the air bag For example such objects could tear the fabric or affect the shape of the air bag thus reducing the ability of the bag to provide restraint Is it possible to shield equipment that is installed in t
225. oe owner s manual for operation description 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 4WD SPECIAL SERVICE 5W4 OPTIONS 1 AVAILABLE OPTIONS WITH TAHOE 51 4 SPECIAL SERVICE PACKAGE KST BATTERIES DUAL 660 CCA 80 amp hour rating parallel connected B85 BODY SIDE MOLDINGS On 4 doors JL1 BRAKE CONTROLLER Integrated trailer 963 CHASSIS PACKAGE OFF ROAD SUSPENSION Requires QJP tire and includes NZZ skid plates K47 high capacity air cleaner no 771 decal 9N5 CONSOLE DELETE Between seats Requires A95 UTG CONTENT THEFT ALARM DISABLE Flashing lamps and horn warning 968 DELETE DAYTIME RUNNING LAMPS AND AUTOMATIC HEADLAMPS Exterior lamps are operated manually see page 24 514 EXTERIOR BODY COLORED PARTS Victory Red special painted exterior body parts in lieu of glossy Black color normally installed with special painted bodies Victory Red painted parts will consist of front fascia rear bumper fascia rear liftgate license plate applique and rear liftgate handle door handles and body side moldings Mirrors rear D pillar applique and liftgate spoiler will remain Black Requires SEO TGK special paint and special paint color WA9260 Victory Red Includes RPO B85 body side moldings 6J7 FLASHER SYSTEM HEADLAMPS AND TAIL LAMPS DRL compatible headlamp flasher module with control wire and body control module rear lamp flashing see page 27 B30 FLOOR COVERING Color keyed carpeting includes rear cargo floor B58 FLOOR
226. of the throat and eyes and that is only if the occupant remains in the vehicle for many minutes after the air bag deployment with no ventilation and windows closed However some people with asthma may develop an asthmatic attack from inhaling the dusts If this happens they should first treat themselves the same way their doctor has advised them to treat any other asthma attack and then immediately seek medical treatment Can the air bag system he re used No The air bags are designed to inflate only once After inflation some new parts will be required These will include the air bag module and possibly other parts A competent service technician with access to the vehicle s service manual and the required tools should replace the required components after a deployment crash If my vehicle has air bags why should have to wear my safety belt Air bags are in many vehicles today and will be in most of them in the future But they are supplemental systems only so they work with safety belts not instead of them Every air bag system ever offered for sale has required the use of safety belts Even if you re in a vehicle that has air bags you still have to buckle up to get the most protection That s true not only in frontal collisions but especially in side and other collisions 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 24 AIR BAG FAG 500 mm 200 mm 19 7 in 7 9 in D E F G STANDARD HEAD CURTAIN AND FRONT SE
227. on NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 CAPRICE POLICE PACKAGE 9C1 AIR BAGS NM A SIDE VIEW OF DRIVER STEERING WHEEL AIR BAG Q67 in DEPLOYMENT ZONE CENTER LINE OF DRIVER VIEW FROM RIGHT SIDE Rear most instrument panel Topof windshield Driverair bag zone Driver air bag Driver seat Driver knee air bag Instrument cluster zz 880 mm 26 7 in SIDE VIEW OF FRONT SEAT PASSENGER AIR BAG DEPLOYMENT ZONE CENTER LINE OF PASSENGER VIEW FROM RIGHT SIDE Rear most instrument panel Top of windshield Front passenger air bag zone Front passenger air bag Front passenger seat Front passenger knee air bag Glove box door gt 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C1 AIR BAGS 27 GM offers Anti Lock Brake Systems as st
228. on driver door and trunk options 6E3 or 6E4 available for single key locking of entire fleet see page 6 LICENSE PLATE FRONT Mounting hardware included LOCK CYLINDER Driver and front passenger doors with key lock cylinder in truck lid MIRRORS OUTSIDE REARVIEW Black electric left hand and right hand remote with manual folding heated available see option DR9 on page 6 PAINT Base coat clear coat REMOTE VEHICLE START Remote vehicle starter system includes Remote Keyless Entry TRUNK LAMP Standard TRUNK LOCK CYLINDER Standard TRUNK RELEASE Electric ignition controlled switch located on both front door interior panels UNDER HOOD LAMP Not available WINDSHIELD WIPERS Intermittent 2 speed with variable dwell 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 CAPRICE POLICE PACKAGE 9C1 CHASSIS FEATURES ALTERNATOR AXLE BATTERY BODY BRAKES COOLING CHASSIS LUBRICATION ENGINES ENGINE CRADLE EXHAUST SYSTEM FUEL TANK CAPACITY OIL COOLERS RADIO SUPPRESSION STABILITRAK STARTER INTERRUPT STEERING SUSPENSION TIRES TIRE PRESSURE MONITOR TRACTION CONTROL TRANS AND SPORT MODE WHEELS WHEEL CENTER CAP 170 amp with idle boost transmission in PARK or NEUTRAL controlled by battery energy level sensing 2 92 axle ratio with limited slip standard with V8 Limited slip optional with V6
229. ons and specifications in this literature are based on the latest product information available at the time of publication General Motors reserves the right to make changes at any time without notice For further details consult your local dealer or visit www gmfleet com A note about vehicle alterations by independent suppliers This catalog shows pictures of vehicles that have been altered or upfitted with equipment or components supplied to Chevrolet or its dealers by independent suppliers Chevrolet is not responsible for the safety or quality of design features materials or workmanship of any alterations by a supplier 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL INDEX LAW ENFORCEMENT PRODUCT COUNCIL DISTRICT SALES MANAGERS AND FLEET SERVICE MANAGERS CAPRICE POLICE PATROL CAR OPTION 9C1 IMPALA LIMITED POLICE PATROL CAR OPTION 9C1 IMPALA LIMITED UNDERCOVER CAR OPTION 9C3 TAHOE POLICE PATROL SUV OPTION PPV TAHOE SPECIAL SERVICE SUV OPTION 5W4 EXPRESS TRANSPORT VAN OPTION 1LS amp 2LS SUBURBAN COMMERCIAL FLEET SUV OPTION 1FL SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 1WT 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL LAW ENFORCEMENT PRODUCT COUNCIL CHEV R OLE pOLICR lt LAU lt r 1 SSE y far C VEHICLES 1 Mission Statement To pledge an integrated partnership between General Motors and Law Enforcement Together we will identify evaluate and promote enhancements to p
230. ons of inflated air bag Passenger side air bag deployment zone Passenger centerline Inside rearview mirror Vehicle centerline Driver centerline Driver side air bag deployment zone Front of steering wheel Driver side door gt Shift selector arc Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 AIR BAG DIMENSIONS 35 SIDE VIEW OF DRIVER SIDE AIR BAG DEPLOYMENT ZONE A Top edge of windshield B Top of instrument panel C Inflated air bag steering wheel D Centerline of steering column at mid tilt E Driver air bag deployment zone F Front of steering wheel SIDE VIEW OF PASSENGER SIDE AIR BAG DEPLOYMENT ZONE A Top edge of windshield B Inside rearview mirror C Instrument panel top surface zone D Passenger side air bag module trim panel rear edge E Inflated air bag horizontal dimension approximate 15 4 in 390 mm F Inflated air bag verti
231. ontal air bags This is faster than the blink of an eye The air bags begin to deflate immediately helping to stop the occupants more gradually I ve heard that a deployed air bag produces whet appears to be smoke is the air hag hot After the bag has deployed in a crash the air bag itself will not be hot to touch Some components within the air bag module will be hot for a short time A small amount of smoke coming from a deployed air bag module is normal and should not be cause for concern Also when the nitrogen gas is vented out of the air bag small particles from inside the bag are also vented into passenger compartment These airborne particles look like smoke and some particles are deposited as residue on and around the air bag I ve heard that the dusts that are released into the passenger compartment from the air bag are harmful is this true For most people the only effect the dusts will produce is some irritation of the throat and eyes and that is only if the occupant remains in the vehicle for many minutes after the air bag deployment with no ventilation and windows closed However some people with asthma may develop an asthmatic attack from inhaling the dusts If this happens they should first treat themselves the same way their doctor has advised them to treat any other asthma attack and then immediately seek medical treatment Can the air bag system be re used No The air bags are designed to inflate only once Af
232. onvenience Package KO5 ENGINE BLOCK HEATER Included and only available with V10 Cold Climate Package which requires L96 Vortec 6 0L V8 SFI FlexFueP engine B30 FLOOR COVERING Full floor color keyed carpeting with front and rear rubberized vinyl floor mats V22 GRILLE Chrome with dual composite halogen headlamps included and only available with ZR7 Chrome Appearance Package KOB HEAT GENERATOR Auxiliary fuel operated supplemental heat source to cooling system to improve heat out put induded with V10 and LGH Duramax 6 6L turbo diesel C36 HEATER REAR AUXILIARY Included with C69 rear air conditioning UF3 HIGH IDLE SWITCH Requires G33 06 L96 Vortec 6 0L V8 SFI or 6 6L V8 L6H diesel engine and 203 Convenience Package TRY LAMPS Lamps auxiliary with reading and underhood lamps requires C69 rear air conditioning Includes DH6 driver and front passenger visor vanity mirrors DE5 MIRRORS Outside left hand and right hand remote control electric manual foldaway with defog feature requires 702 UD7 REAR PARK ASSIST Requires UM7 AM FM stereo US8 AM FM stereo with CD MP3 player or UYS AM FM stereo with MP3 compatible CD DVD player and navigation UVC REAR VISION CAMERA Display integrated into rearview mirror integrated into navigation screen when UYS AM FM stereo with MP3 compatible CD DVD player and navigation is ordered ATG REMOTE KEYLESS ENTRY Includes 2 transmitters and remote panic button BIV REMOTE VEHICLE STARTER SYSTEM Incl
233. operation when installing roof mounted equipment such as emergency lamps and communication antennas Recommended GM service procedures must be followed to remove and re install the instrument panel top pad to ensure that the top pad will release properly in the event of a passenger air bag deployment On the right half of the top pad closest to the passenger air bag module GM recommends that no equipment be mounted When mounting equipment on the driver side of the top pad GM recommends that the total mass of the top pad mounted special equipment not exceed 8 pounds 3 6 kilograms since some top pads tend to rotate about the left end Fasteners used to secure special equipment to the instrument panel top pad the windshield glass or to the windshield upper frame header should be selected to ensure that these devices will remain attached during a vehicle crash and possible air bag deployment Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL AIR BAG FAG 23 Can the installation of push bum
234. or and A C condenser at the center and is connected in series with the integral transmission oil cooler in the right end tank of the coolant radiator Black heavy duty one piece Replaces production carpeting VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 SPECIAL EQUIPMENT OPTIONAL 25 AMF PACKAGE OF 6 TRANSMITTERS WITH REMOTE WITH REMOTE START AND START AND POWER LIFTGATE LIFTGLASS on AND LIFTGLASS WITHOUT REMOTE REMOTE START SIMILAR SIMILAR RELEARN REMOTE KEY To access this DIC display the vehicle must be in PARK This display allows you to match the remote keyless entry transmitter to your vehicle To match a remote keyless entry transmitter to your vehicle do the following 1 Press the trip odometer reset stem until PRESS THE RELEARN REMOTE KEY displays 2 Press and hold the trip reset stem for 3 seeconds The message REMOTE KEY LEARNING ACTIVE will display 3 Press and hold the LOCK and UNLOCK buttons on the first transmitter at the same time for approximately 15 seconds A beep will sound indicating that the transmitter is matched 4 To match additional transmitters at this time repeat Step 3 Each vehicle can have maximum of eight transmitters matched to it 5 To exit the program mode turn the key to the LOCK position NOTE A maximum of 8 keys may be learned for a vehicle immobilizer Passkey III with a random key code Vehicles with the fleet key option RPO 6E2 or 6E8 may have an unl
235. or more severe frontal impacts dual stage frontal air bags deploy at full levels If the front of your vehicle goes straight into a wall that doesn t move or deform the threshold level of the reduced deployment is about 12 to 16mph 19 to 15 km h and the threshold level for a full deployment is about 18 to 24 mph 29 to 28 5 km h The threshold level can vary however with specific vehicle design so that it can be somewhat above or below this range If your vehicle strikes something that will move or deform such as a parked car the threshold level will be higher The driver s and right front passenger s frontal air bags are not designed to inflate in rollover side impacts or rear impacts because inflation would not help the occupant Seat mounted side impact air bags are designed to inflate in moderate to severe side crashes The side impact air bags will inflate if the crash severity is above the designed threshold level The threshold level can vary with specific vehicles design The side impact air bags are not designed to inflate on frontal or near frontal impacts or rear impacts because inflation would not help the occupant Roof rail mounted head curtain air bags are designed to inflate in moderate to severe side crashes In addition certain vehicles have head curtain air bags which are also designed to inflate in situations where an impending rollover condition is identified by the vehicle s rollover sensing system and or fro
236. or not programed see page 15 for description WIRING For grille lamps and siren speaker see page 14 for description WIRING For horn siren circuit in line connection for customer furnished switch see page 14 for description WHEEL COVERS FULL Replaces bolted on center cap and hardware see page 15 For standard and optional illustrations see pages 12 through 17 Note Factory installation of spotlamps or spotlamp provisions are recommended The windshield pillars are designed with ultra high strength steel to enhance crash worthiness and special tooling is used to locate and drill the lamp shaft holes The spotlamp brackets are attached with special fasteners to avoid drilling the high strength steel reinforcement Vehicle may arrive with TRANSPORT MODE activated to conserve battery life during transportation Contact a GM dealer for proper completion of Pre Delivery Inspection PDI 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C1 SPECIFICATIONS 7
237. osited as residue on and around the air bag I ve heard that the dusts that are released into the passenger compartment from the air bag are harmful is this true For most people the only effect the dusts will produce is some irritation of the throat and eyes and that is only if the occupant remains in the vehicle for many minutes after the air bag deployment with no ventilation and windows closed However some people with asthma may develop an asthmatic attack from inhaling the dusts If this happens they should first treat themselves the same way their doctor has advised them to treat any other asthma attack and then immediately seek medical treatment Can the air hag system be re used No The air bags are designed to inflate only once After inflation some new parts will be required These will include the air bag module and possibly other parts A competent service technician with access to the vehicle s service manual and the required tools should replace the required components after a deployment crash If my vehicle has air bags why should I have to wear my safety helt Air bags are in many vehides today and will be in most of them in the future But they are supplemental systems only so they work with safety belts not instead of them Every air bag system ever offered for sale has required the use of safety belts Even if you re in a vehicle that has air bags you still have to buckle up to get the most protection That s tr
238. ount the equipment outside of the deployment zone Air bags inflate with great force and will interact with any object in the deployment zone Therefore to reduce the risk of injury to vehicle occupants GM recommends that the air deployment zone be kept free of any equipment If a piece of equipment were to become dislodged it could strike an occupant in the vehicle and result in injury The likelihood of an object becoming dislodged is influenced by many factors including the proximity of the object to the inflatable restraint the size and shape of the object and the means by which the object is secured to the vehicle In addition to these factors the trajectory and velocity of a dislodged object can be influenced by the type and severity of vehicle crash Objects that are in the deployment zone but do not become dislodged by an inflating air bag can still affect the performance of the air bag For example such objects could tear the fabric or affect the shape of the air bag thus reducing the ability of the bag to provide restraint Is it possible to shield equipment that is installed in the passenger side frontal air bag deployment zone in a manner that will allow full and safe air bag deployment Due to the complexity of influencing variables GM is unable to evaluate the potential for shielding expected equipment configurations in all accident scenarios in order to assure that the air bag performance would be unaffected While shielding
239. ounted in a different orientation on the Silverado Crew Cab pickup truck roof structure from those in the Tahoe Suburban HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES VIEW FROM REAR CARGO AREA 80 mm A B 80 mm A Head curtain air bag deployment zone F Seat centerline B Underside of headliner G Bottom of door windows C Edge of headliner H Front seat headrests D Inner center pillar trim I Seat mounted side impact air bags deployment zone front seat E Inner door pad J Top surface of outboard front seat cushion Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL ANTI LOCK BRAKING SYSTEM FAQ 15 GM offers Anti Lock Brake Systems as standard or optional on all North American passenger vehicles and light truck lines The computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors moni
240. ower and signal circuits are also included in the wire coiled under the instrument panel near the center of the vehicle They include A yellow 20 gauge 0 5 mm2 circuit HOT in ACCESSORY RUN or RAP Retained Accessory Power Pink 20 gauge 0 5 mm2 circuit HOT in START RUN 7 amp maximum load A yellow black 20 gauge 0 5 mm2 transmission park signal This circuit provides switched power when the transmission is in P Park and the engine is running The circuit is at 0 volts when the transmission is in any other position i e R Reverse N Neutral D Drive or M Manual 6 1 NOTE that the circuit is also at 12 volts with the transmission in P Park and the ignition is OFF To avoid the possibility of undesired parasitic electrical load with the ignition is OFF it is suggested that the Park Signal circuit be isolated by routing it through the normally open contacts of a customer furnished ignition controlled relay dark green white 20 gauge 0 5 mm Vehicle Speed Signal VSS provides 4 000 pulses per mile The breaker and relay center is located behind and above the instrument panel storage compartment Remove contents from the storage tray Using the tab at the back of the compartment drop the tray down gently toward the floor You will find the breaker relay center above the right rear corner of the storage compartment These two circuits share a 15 amp fuse 10 amp combined maximum load NOTE For wiring
241. owner s manual supplement for proper cargo loading distribution 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 POLICE PKG DIMENSIONS 11 IMPALA POLICE PACKAGE Rear Qtr Glass lontside Gl Rear Side Glass ront Side Glass 29 wx 15 5 27 5 x15 5 h 200 5 Shown with optional body side moldings and rear spoiler Estimated material sizes to wrap Hood 60 x 65 Front Doors 46 x 30 Rear Doors 43 x 32 Roof 87 x 48 e Trunk Lid 36 x 53 Optional rear spoiler and bodyside moldings shown 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 12 IMPALA LIMITED amp 9C3 SPECIAL PAINT AVAILABLE To accommodate customers who require special painted vehicles orders will be sent to Kerr Industries who will special paint the cars once they are built Please note this ordering process is substantially different from the way special paint is ordered on other vehide lines and requires an additional charge See your local dealer for current pricing It is recommended that the customer review the first vehicle painted when special paint is ordered however it is not mandatory If the customer chooses not to review a pilot vehicle Kerr Industries will require sign off by the customer before the vehicle will b
242. p the occupants more gradually I ve heard that a deployed air bag produces whet appears to be smoke is the air hag hot After the bag has deployed in a crash the air bag itself will not be hot to touch Some components within the air bag module will be hot for a short time A small amount of smoke coming from a deployed air bag module is normal and should not be cause for concern Also when the nitrogen gas is vented out of the air bag small particles from inside the bag are also vented into passenger compartment These airborne particles look like smoke and some particles are deposited as residue on and around the air bag I ve heard that the dusts that are released into the passenger compartment from the air bag are harmful is this true For most people the only effect the dusts will produce is some irritation of the throat and eyes and that is only if the occupant remains in the vehicle for many minutes after the air bag deployment with no ventilation and windows closed However some people with asthma may develop an asthmatic attack from inhaling the dusts If this happens they should first treat themselves the same way their doctor has advised them to treat any other asthma attack and then immediately seek medical treatment Can the air bag system be re used No The air bags are designed to inflate only once After inflation some new parts will be required These will include the air bag module and possibly other parts A
243. pe hoist or other means to safely elevate the front of the vehicle to at least an angle of 20 degrees above horizontal See your GM dealer to get more information about this coachbuilder procedure Keeping the center of gravity midway between the axles is also important to provide proper braking performance About half the total vehicle weight on each axle is recommended Weigh your vehicle after the additional equipment has been installed to determine the actual weight of your vehicle Weigh the vehicle with a full tank of fuel and without passengers You may need to put a limit on how many people or other equipment you can carry inside your vehicle after the additional equipment has been installed Note See loading zone weight chart and diagram on page 22 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 TAHOE 4WD SPECIAL SERVICE 5W4 LOADING ZONES Loading zone for customer installed equipment and cargo without passengers Front Floor to Roof Zone Area B Front Roof Zone Area C Back of Front Door D Rear Roof Zone Area E Rear Floor to Roof Zone Area F Ground Loading Zone Weight Chart Tahoe Special Service Package 5W4 Loading Zones Front Axle Weight Rear Axle Weight Total Roof 38 Ibs 17 kg 52 165 24 kg 90 Ibs 41 kg Floor to Roof 137 lbs 62 kg 546 Ibs 248 kg 683 Ibs 310 kg Total 175 Ibs 80 kg 598 Ibs 271 kg 773 165 351 kg Using heavier suspension components to get added durability might not chan
244. pers on the front end of the vehicle affect the deployment of the air bag General Motors is not aware of adverse effects during crash events from the many push bumpers thai have been installed on GM police vehicles Because there are many styles of push bumpers available with varying crash characteristics installation of push bumpers may or may not affect deployment timing of the air bags Push bumpers should be mounted to avoid modifying the vehicle structure and interfering with the front air bag sensors mounted on the upper radiator support cross member Two front impact sensors are installed in General Motors vehicles Do not relocate or disconnect the front sensors The location and orientation of the front sensors are critical for correct operation of the air bag system Avoid mounting components on or near the sensors Push bumper styles with vertical pushing members that are in foreaft alignment with the front air bag sensors are not recommended When should an air bag inflate The driver s and right front passenger s frontal air bags are designed to inflate in moderate to severe frontal or near frontal crashes But they are designed to inflate only if the impact speed is above the system s designed threshold level In addition your vehicle has dual stage frontal air bags which tailor the the amount of restraint according to crash severity For moderate frontal impacts the air bags inflate at a level less than full deployment F
245. r Additional Assistance Phone 1 800 FLEET OP 353 3867 or visit www gmfleet com 6 NOTES GMFLEET COM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL Shown with aftermarket equipment All new column mounted shifter for increased room e comfort and convenience Standard center console steel mounting platform for attaching equipment more easily see page 12 for details All new instrument panel and gauge cluster with 8 inch Chevrolet MyLink touch screen color display featuring AM FM radio and CD player Bluetooth streaming audio and cell phone connectivity voice recognition and music navigator Applications requiring a USB connection are not compatible Surveillance Mode wiring provision for customer supplied switch connection suppresses all automatic lighting Ultra high strength steel added to both A pillars for significant improvements in roof crush safety Revised front seats with increased comfort and support while wearing a utility belt front hip room increased to 57 5 in from 56 7 in Extended safety belt receivers for easier buckling Driver and front passenger 4 way power seat adjusters Trunk release button now on both front door interior panels Standard Electric Power Steering for efficient cornering i and stability Engine Idle Hour meter Thicker front struts 82mm from 30mm for handling and tuning with
246. r bag components Inflation devices may be mounted on the vehicle roof side behind the rear doors as well as air bag tethers retained to the windshield pillars Care must be taken to avoid damage to these components or interference with their operation when installing roof mounted equipment such as emergency lamps and communication antennas Recommended GM service procedures must be followed to remove and re install the instrument panel top pad to ensure that the top pad will release properly in the event of a passenger air bag deployment On the right half of the top pad closest to the passenger air bag module GM recommends that no equipment be mounted When mounting equipment on the driver side of the top pad GM recommends that the total mass of the top pad mounted special equipment not exceed 8 pounds 3 6 kilograms since some top pads tend to rotate about the left end Fasteners used to secure special equipment to the instrument panel top pad the windshield glass or to the windshield upper frame header should be selected to ensure that these devices will remain attached during a vehicle crash and possible air bag deployment Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children ar
247. r bags in GM vehicles deploy in different ways depending upon the type of vehicle and the particular instrument panel design In some vehicles the passenger air bag deploys through a discrete door located on the top surface of the instrument panel top mount air bag systems In other vehicles such as the Chevrolet Tahoe the passenger air bag deploys through a discrete door mounted on the vertical rearward surface of the instrument panel above the glove box door mid mount air bag system With these types of top mount and mid mount passenger air bag systems the top pad of the instrument panel remains in place during deployment Some GM passenger air bag systems like the system in the Chevrolet Impala deploy from beneath the instrument panel top pad These are considered 3 4 mount air bag systems with a deployable top pad The entire instrument panel top pad is the deployment door from under which the inflating air bag emerges When an air bag deployment is commanded the forces from the inflating passenger air bag push up on the instrument panel top pad releasing special fasteners across the rearward edge of the top pad This allows the top pad to rotate upward so that the passenger air bag may emerge The top pad rotates upward to open widest at the right hand side and is usually forced upward into contact with the windshield on the right hand side of the vehicle during a deployment Instrument panel top mounted special equipme
248. r bars Goodyear P235 55R17 SBR blackwall W rated with compact spare full size spare is available see option RUF on page 9 CHECK TIRE PRESSURE will show on driver message center see page 17 for description i Deactivated when Police Performance Mode is engaged B 6 speed automatic electronically controlled transmission provides protection against over revving the engine in low gear and mechanical low gear blockout is not required if a driver manually selects low gear and fails to manually upshift to high gear the powertrain control module automatically protects the drivetrain It can be manually shifted up and down with buttons located on Steering wheel 17 x 7 5 heavy duty steel Chrome bolt on metal 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 IMPALA LIMITED POLICE PACKAGE 9C1 POWERTRAIN ENGINE TRANSMISSION OPTION DISPLACEMENT FUEL OPTION TYPE OPTION CODE LITERS CU IN SYSTEM CODE CODE FlexFuel 6170 LFX 3 6 217 gas or E85 MXO 6 speed F71 ethanol auto with OD EMISSIONS MUST BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and
249. r bars Patrol vehicle specific shock spring and stabilizer bar tuning Goodyear P235 50R18 W rated blackwall with compact spare full size spare is available see option SG8 on page 6 CHECK TIRE PRESSURE will show on driver message center excludes spare tire Deactivated when police performance mode is engaged button located on instrument panel left side of steering column 6 speed automatic electronically controlled transmission provides protection against over revving the engine in low gear if a driver manually selects low gear the powertrain control module automatically protects the drivetrain Includes Sport Shift mode where maximum transmission responsiveness is required The Sport Shift mode On Off button is located on the instrument panel to the left of the steering column When in Sport Shift mode the transmission will delay upshifts and allow earlier downshifts In addition the transmission can sense enthusiastic driving at which point it may delay upshifting and downshifting earlier when braking and is designed to maximize vehicle performance 18 x 8 heavy duty steel Bolt on pressed forged aluminium 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE PACKAGE 9C15 POWERTRAIN ENGINE TRANSMISSION OPTION DISPLACEMENT FUEL OPTION TYPE OPTION CODE LITERS CU IN SYSTEM CODE CODE LFX V6 3 6 217 E85 FlexFuel or gasoline 6L45 6 speed ra Standard auto with OD L77 V8 6 0 364 E85 FlexFuel
250. r ground termination Recommended torque for the terminal connection nut is 7 3 lb ft 10 N m plus or minus 1 lb ft 1 3 N m KEYLOCK CYLINDER TRUNK LID If your vehicle is equipped with the Theft Deterrent System option UA6 an audible alarm will occur when the key is used to open the trunk instead of the remote keyless entry transmitter See your dealer retailer to disable the audible alarm ENLARGED VIEW OF THE BATTERY POWER FUSE BLOCK A Relays and circuit breakers B Front of the vehicle C Floor of the vehicle 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP STD 17 TIRE PRESSURE MONITOR Your vehicle is equipped with a Tire Pressure Monitor TPM System which warns of low tire pressure Your Impala Police Package may be equipped with a full size spare tire see page 18 The full size spare tire has a sensor but is not programmed to read the spare tire pressure When the full size spare tire from your vehicle or spare tire from another Police Package is placed in use as a road wheel the system will not read the presence of the new TPM sensor and must be calibrated Refer to your owner s manual for additional information on the Tire Pressure Monitor and Sensor Programming The space saver spare tire does not have a tire pressure monitor High capacity radiator with 225 watt fans ENGINE TRANSMISSION AND POWER STEERING COOLERS S Transmission Cooler
251. r optional on all North American passenger vehicles and light truck lines The computerized Anti Lock Braking System ABS is designed to keep the vehicle s wheels rotating as the brakes are applied to assist the driver in achieving a controlled stop Sensors monitor how fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is approaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles Does A
252. r seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 12 Model tested with standard head curtain side impact air bags SABs Government 5 Star Safety ratings are part of the National Highway Traffic Safety Administration s NHTSA s New Car Assessment Program www SaferCar gov 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 4WD SPECIAL SERVICE 5W4 15 ASSIST STEPS BODY SIDE MOLDINGS DEFOGGER DOOR HANDLES DOOR LOCKS FASCIA FRONT FASCIA REAR FOG LAMPS HEADLAMPS HORNS KEYLESS ENTRY KEYS LUGGAGE RACK MIRRORS REAR LIFTGATE RECOVERY HOOKS UNDER HOOD LAMP WINDSHIELD WIPERS AIR CLEANER ALTERNATOR BATTERY BRAKES COOLING ENGINE FRAME FUEL TANK CAPACITY OIL COOLERS RADIO SUPPRESSION SPARK PLUGS STABILITRAK STEERING SUSPENSION FRONT SUSPENSION REAR TIRES TIRE PRESSURE MONITOR TIRE SPARE TRAILERING EQUIPMENT TRANSFER CASE TRANSMISSION WHEELS WHEEL CENTER CAP EXTERIOR FEATURES Black mounted between front and rear wheels Optional see option B85 on page 19 Electric rear window Matte Black Power non programmable with lockout protection and automatic door locking and unlocking door lock cy
253. r who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NET is ordered for delivery to a dealer located in California 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL SUBURBAN COMMERCIAL FLEET CC10906 CK10906 2WD 1 2 Ton 4x4 1 2 Ton SPECIFICATIONS Cin mm Wheelbase 130 0 3302 Overall length 222 4 5649 Body width 79 1 2009 Overall height 76 8 1951 Head room front 41 1 1044 Head room center 38 5 978 Head room rear 38 1 968 Shoulder room front 65 2 1656 Shoulder room center 65 2 1656 Shoulder room rear 64 7 1643 Hip room front 60 3 1532
254. r window Matte Black Power non programmable with lockout protection and automatic door locking and unlocking door lock cylinder no longer available on passenger front door and rear liftgate child safety locks included in rear side doors Body color Body color with step pad Not available Dual halogen composite with flash to pass feature automatic exterior lamp control and daytime running lamps to delete automatic lamp control see option 9G8 on page 7 Dual note Includes two transmitters with non functional panic button stealth mode feature includes exterior lamps and horn disable if remote start Option AP3 is included running lamps will remain illuminated additional transmitters are available see option AMF on page 7 Two sided random code for ignition and driver door only Not available Outside heated power adjustable manual folding Matte Black Liftgate liftglass with washer and wiper and no lock cylinder on liftgate Two front Not available Intermittent wet arm with flat blade and pulse washers CHASSIS FEATURES High capacity 160 amp with idle boost transmission in PARK or NEUTRAL based on battery energy level 660 CCA 80 amp hour rating with battery rundown protection does not protect customer installed equipment Heavy duty 4 wheel anti lock front and rear disc with vacuum boost power assist Heavy duty high capacity radiator electric fans and extended life coolant coolant hoses are EPDM ethylene propylene die
255. rable at rear doors Black heavy duty front and rear Replaces production carpeting but operate from driver position Remote rod is shipped in the glove box for future installation 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 WIRING DIAGRAMS 123 FOR 12 VOLT BATTERY POWER SUPPLY Fusible Power Distribution Fusible Link Schematics in Block BU BK Wiring Systems Underhood 3 LI 502 RD BK Circuit Breakers 1 2 3 and Relays 1 2 are in Fuse Block SEO under IP near Fusible Link GY WH 2 402 RD BK 5 A Steering Column TF Circuit P ACircuit Cutat l 50 Breaker Right E E A ly Front N bs B Floor 6843 Blunt Cut at Right Front Floor Blunt TI A Circuit 6842 B1 C5 B5 Blunt Cut at Right Front Floor 6839 1450 6840 3740 L GN BK D GN RD WH 3 0 35 3 5 Blunt Cut at Right Front Floor Blunt Cut at Right Front Floor Blunt Cut at Right Front Floor 771 G204 loop of wire coiled under the instrument panel in the passenger s side footwell Each relay is operated by an 18 gauge 0 8 mm blunt cut light or dark blue control lead included in the 5 foot 1 5 m coil under the instrument panel An 8 gauge 8 0 mm ground lead is also provided in the 5 foot 1 5 m coil The total current available through the 12 volt power supply is 110 amps 1320 watts Battery power
256. ram see page 29 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 TAHOE PPV amp 5W4 WIRING DIAGRAMS WIRING DIAGRAM FOR 12 VOLT BATTERY POWER SUPPLY ALL BLUNT CUTS UNDER VP NEAR FLR CONSOLE To Ground at the BLUNT CUT BLUNT CUT BLUNT CUT Mid Electrical Center MAXI CIRCUIT BREAKER BLUNT CUT FRONT CENTER FLOOR LOOP ANCHOR LOOP ANCHOR BLOCK ASM JCK BLK 15225214 LOOP ANCHOR REAR CARGO AREA WIRING DIAGRAM FOR CONTROLLED POWER AND SIGNAL CIRCUITS WITH 12 VOLT POWER SUPPLY Shared F38 15 AMP FUSE UBEC TO O71 Hot In BCM 10 AMP UBEC VSS Ground ACCESS Hot In x Hot In Vehicle 4 ft Blunt RUN PARK START Speed Cut at front RAP SIGNAL RUN Signal of RH sill plate 143 5813 739 817 20 ga 0 5mm 20 ga 0 5mm 20 ga 0 5mm 20 ga 0 5mm YE YE BL PK D GM WH 0 5 ALL BLUNT CUTS LOCATED UNDER P NEAR FLOOR CONSOLE Zero volts out of PARK engine running HOT in PARK with ignition OFF NOTE Wiring diagrams for these options are shown in the Police Package owner s manual supplement shipped in glove box 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE PPV amp 5W4 WIRING DIAGRAMS 2 WIRING DIAGRAM FOR OPTION 6J3 AND OPTION 6J7 BLUNT CUT 0 8 D GN REI 6820 1 LT BLU 6837 1LTGRN 6836 1GRY 6838 1TAN 6835 INTERIOR 6J3 JUMPER c268 B 1 C268 C 1 C268 D 1 c268 v Miura 0 8 D GN RED 6820 107 BLU 6837 11T GRN 6836 1GRY 6838 1
257. rance companies give discounts that range from 5 to 10 In the states of New York and Florida all insurance companies are required to give an ABS discount of 5 on certain coverages such as bodily injury property damage collision and personal injury protection In other states the discount varies from insurance company to insurance company When buying auto insurance always ask your insurance agent if his her company gives a discount for vehicles equipped with anti lock brakes 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 3 A Always maintain a safe following distance ABS does not allow you to stop on a dime Generally a 2 second following distance is considered safe in ideal conditions Watch the vehicle in front of you pass a fixed marker such as a sign Count seconds one thousand one one thousand two until your front bumper reaches the marker If you do not count out IMPORTANT DRIVING SAFETY TIPS B Always drive carefully especially on slippery surfaces ABS cannot create friction between the tires and the road surface it can only give the driver the maximum advantage of the existing adhesion If the vehicle is traveling on a surface with no adhesion the best ABS in the world cannot provide a shorter stopping distance or good steering s ANTI LOCK BRAKING SYSTEM AND STABILITRAK C Itisa good idea to practice an ABS activated stop and get the feel of the brake pedal However please make sur
258. re the proper size for the tires Install them on the tires of the rear axle Don t use chains on the tires of the front axle Tighten them as tightly as possible with the ends securely fastened Drive slowly and follow the chain manufacturer s instructions If the chains contact the vehicle stop and retighten them If the contact continues slow down until it stops Driving too fast or spinning the wheels with chains on will damage the vehicle SEATS AND INTERIOR TRIM SEAT OPTIONS STANDARD Front cloth 40 20 40 split bench power driver side seat only A23 Rear vinyl 60 40 split bench 5T5 OPTIONAL Front cloth buckets with center console power driver and passenger seat A95 Rear vinyl 60 40 split bench 515 OPTIONAL Front cloth buckets without center console power driver and passenger seat A95 and 9N5 Rear vinyl 60 40 split bench 515 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE 4WD SPECIAL SERVICE 5W4 17 AVAILABLE EXTERIOR COLORS Champagne Mocha Steel Crystal Red Silver Ice Black Concord Summit White Silver Metallic Metallic Tintcoat Metallic Metallic New Actual colors may vary Additional Charge SEO PAINT AVAILABLE WA COLOR DESCRIPTION CODE 9260 Victory Red 514 ACTUAL COLOR MAY VARY NOTE All normally body colored non sheet metal parts SEO p
259. remember not to exceed the Gross Vehicle Weight Rating GVWR or the Gross Axle Weight Rating GAWR of the front or rear axles To keep the available load weight less than the vehicle capacity weight you may need to limit the number of passengers you carry in your vehicle or change your choice of additional equipment CENTER OF GRAVITY CG A vehicle s center of gravity is an imaginary location inside the vehicle and is a balance point for the vehicle mass as it moves down the road The police vehicle s center of gravity before you add a load and passengers is approximately midway between the center of the axles up from the ground to just below the front window and between the driver and passenger Equipment location and weight on the vehicle s center of gravity is important to keep in mind when planning an installation Heavy equipment should be positioned as low and as far forward in the rear load compartment as possible Try to mount the equipment below the bottom of the side windows Refer to the Loading Zone chart and diagram to help with your installation plan A procedure to make the necessary measurements and formulas to calculate the vehicle longitudinal lateral and vertical position of the center of gravity can be found in the GM Coachbuilders Manual Equipment required to conduct the measurements for calculating the center of gravity are Weight scales of sufficient capacity to measure the vehicle weight at each wheel A post ty
260. rements for performance durability and safety gm recommends only the original equipment tire for replacement Tire Plys Tread 2 Polyester 2 Steel 1 Nylon Sidewall 2 Polyster Total 7 Ply Do not use tire chains See your Owner s Manual for more information SEATS AND INTERIOR TRIM SEAT OPTIONS STANDARD Front Cloth 40 20 40 split bench AN3 Rear Cloth full bench non folding seat back AVAILABLE EXTERIOR COLORS Silver Ice Black Summit White Ashen Gray Metallic Metallic NOTE For special paint and paint schemes see page 12 through 14 Actual colors may vary 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED 9C1 amp 9C3 OPTIONS B86 UAG 968 6J7 K05 6B7 6J5 AMF 6E2 6C7 7Y6 T53 VK3 B34 DK2 6N6 6B2 6N5 D81 AP3 7XB 7X7 7X8 7X9 RUF A88 6C8 WX7 6J3 64 6F5 BODY SIDE MOLDINGS Body color installed on all 4 doors CONTENT THEFT DETERRENT ALARM SYSTEM Requires AP3 remote start unauthorized entry sounds horn and lamps flash DELETE DAYTIME RUNNING LAMPS AND AUTOMATIC HEADLAMPS Exterior lamps are operated manually see page 17 FLASHER SYSTEM HEADLAMPS AND TAIL LAMPS DRL compatible headlamp flasher module with control wire and body control module rear lamp flashing see page 19 for description FLOOR COV
261. reo with MP3 compatible CD DVD player and navigation USB Port seek and scan digital clock auto tone control Radio Data System RDS speed compensated volume and TheftLock not available with UEO OnStar delete UA1 BATTERY Heavy duty 770 CCA maintenance free with rundown UPF BLUETOOTH FOR PHONE Personal cell phone connectivity to vehicle audio system requires UE1 OnStar US8 AM FM stereo with MP3 compatible CD player U2K XM Radio NP5 leather wrapped steering wheel W1Y steering wheel controls 703 Convenience Package Not available with UEO OnStar delete on UYS V37 BUMPERS Front and rear chrome with step pad included with ZR7 Chrome Appearance Package ZR7 CHROME APPEARANCE PACKAGE Includes V37 front and rear chrome bumpers with step pad and V22 chrome grille with dual composite halogen headlamps V10 COLD CLIMATE PACKAGE Includes engine block heater includes K08 if ordered with 6 6L turbo diesel U80 COMPASS 8 point digital located in the Driver Information Center included and only available with C69 rear air conditioning CONSOLE Deluxe with swing out storage bin ZQ3 CONVENIENCE PACKAGE Tilt wheel and cruise control K34 CRUISE CONTROL Included and only available with 703 Convenience Package tilt wheel and cruise control C49 DEFOGGERS Rear window requires tinted glass YA2 DOOR Sliding passenger side requires C69 rear air conditioning AUS DOOR LOCKS Power with lock out protection included with 702 C
262. rice Impala and Tahoe police vehicles LAMP Red and white front auxiliary dome separately switched see page 14 for description LAMPS Alternate flashing red and blue trunk lid warning LED lamps see page 15 for description MAT Trunk custom fitted heavy duty vinyl molded edge to keep spills contained removable for easy cleaning see page 15 for description MATS Carpeted front and rear not available with 6A3 heavy duty vinyl floor covering MIRRORS Heated outside rearview power manual folding Black REAR DOOR LOCKS AND HANDLES INOPERATIVE Rear door latch release and locks are inoperable at rear inside door locks operate only from driver s position rear doors can be opened only from outside see page 14 for description REAR DOOR WINDOW SWITCHES INOPERATIVE Rear door windows only operate from driver s position see page 14 for description SEAT Rear vinyl includes 6A3 heavy duty vinyl floor covering SPEED LIMITER Limits top speed to 130 mph SPOTLAMP DRIVER Separately fused six inch black housing with halogen lamp see page 14 for description SPOTLAMP DRIVER AND PASSENGER Separately fused six inch black housing with halogen lamp see page 14 for description SPOTLAMP PROVISION DRIVER Includes bracket with pillar hole sealed see page 14 for description SPOTLAMP PROVISION DRIVER AND PASSENGER Includes bracket with pillar hole sealed see page 14 for description TIRE SPARE Full size includes TPM sens
263. road surface severity of braking initial vehicle speed etc On some surfaces such as gravel roads braking distances can be longer but you will still have the control benefits of ABS The important capability of ABS is control ABS provides improved vehicle steerability and stability when braking What can affect the ABS advantage It is important that you follow the maintenance schedule recommended in the owner s manual of the vehicle tires should be at their proper inflation level the brake pads should be checked regularly etc While driving you should sit comfortably so that your hips are back in the seat and your knees are bent even while braking Your foot should be positioned so that your heel is on the floor and your toes are secure on the lower half of the pedal And though ABS may reduce stopping distance remember The faster you go the longer it takes you to stop Keeping a safe distance between you and the vehicle in front of you is always necessary even with ABS What happens if ABS becomes inactive The ABS electronic control unit has on board diagnostic capability If a fault is detected the vehicle will revert to the base brake system and the ABS telltale on the dash will be illuminated Should this happen the vehicle should be taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the brake peda
264. roducts and relationships that address the vehicle requirements of the Law Enforcement Community LAW ENFORCEMENT PRODUCT COUNCIL 3 John Woronczuk Royal Canadian Mounted Police john Woronczuk rcmp grc gc ca 613 843 3775 John Dillon Federal Bureau of Investigation john dillon ic fbi gov 202 324 4925 Lloyd Dow York Regional Police 176 yrp ca 905 830 0303 Ext 7380 Tammee Turcott Phoenix Police tammee turcott phoenix gov 602 261 8393 Ron Gromak Michigan State Police gromakr michigan gov 517 322 5598 Oliver Harris Tulsa Police Department oharris cityoftulsa org 918 669 6020 Gregory Dimesa New York City Police Department gregory dimesa nypd org 718 476 7537 Rich Lee San Francisco Police Dept rich lee sfgov org 415 553 1221 David Lindon City of Hoover lindond ci hoover al us 205 739 7187 Jerry Newbury Texas Department of Public Safety jerry newbury dps texas gov 512 424 2043 Ed Sanow Law and Order Magazine esanow hendonpub com 800 843 9764 Ext 28 Kyle Shelton Colorado State Patrol kyle shelton cdps state co us 303 273 1660 Dave Winter Durham Regional Police Service dwinter drps ca 905 579 1520 ext 4739 Jon Gaddis Portland Police Bureau john gaddis portlandoregon gov 503 823 4730 LEPC members are available to all of law enforcement for questions comments or ideas you wish to convey to General Motors 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL REGIONAL GOVERNMENT S
265. rs 45 x 32 Roof 45 x 64 Trunk Lid 38 x 50 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE 9C1 DRIVER INFORMATION CENTER CERTIFIED SPEEDOMETER CLUSTER T 70 80 9 CERTIFIED Engine Hours 29 4 Idle Hours 9 7 DRIVER INFORMATION MESSAGE CENTER MESSAGES SHOWN MESSAGES DISPLAYED ARE DEPENDANT ON VEHICLE VARIANT NOT ALL MESSAGES MAY DISPLAY BATTERY SAVER ACTIVE AUTOMATIC LIGHT CONTROL ON LOW BATTERY AUTOMATIC LIGHT CONTROL OFF SERVICE BATTERY CHARGING SYSTEM CHECK LAMP NAME LAMP BRAKE FLUID LOW CHECK INDICATOR NAME LAMP SERVICE BRAKE ASSIST INDICATOR ON TURN SIGNAL LEFT OR RIGHT CRUISE SET TO XXX SERVICE TRACTION CONTROL DRIVER DOOR OPEN HOOD OPEN LEFT REAR DOOR OPEN PASSENGER DOOR OPEN RIGHT REAR DOOR OPEN TRUNK OPEN A C OFF DUE TO HIGH ENGINE TEMPERATURE ENGINE OVERHEATED IDLE ENGINE ENGINE OVERHEATED STOP ENGINE CHANGE ENGINE OIL SOON OIL PRESSURE LOW STOP ENGINE ENGINE OIL LOW ADD OIL ENGINE POWER IS REDUCED FUEL LEVEL LOW SPEEDOMETER CERTIFICATION THEFT ATTEMPTED SERVICE AIR CONDTIONING SYSTEM SERVICE VEHICLE SOON SERVICE POWER STEERING TURN STEERING WHEEL TURN KEY OFF amp ON TURN STEERING WHEEL START VEHICLE AGAIN SERVICE TIRE MONITOR SYSTEM TIRE LEARNING ACTIVE TIRE PRESSURE LOW ADD AIR TO TIRE SERVICE TRANSMISSION SHIFT DENIED SHIFT TO PARK TRANSMISSIO
266. rtain at edge of headliner Air bag inflator location on sail panel Back of deployment zone at rear of quarter window Front of deployment zone at front of outside mirror patch Forward air bag tether line Thorax air bag deployment zone OOP gt HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES VIEW FROM REAR SEAT 127 mm A 127 mm 5 in C 5in A d D D E ies 102 mm 102 mm 4in SSN GZ 4in 7 DN N 2 WZ 127 mm de G H G ker 127 mm Sin N 2 Sin N ZZ VA J J A Edge of headliner F Inner door pad B Underside of headliner G Seat centerline C Head curtain air bag deployment zone H Bottom of door windows D Inner center pillar trim I Thorax air bag deployment zone front seat E Headrest J Groove in front door armrest Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 30 ANTI LOCK BRAKING SYSTEM FAG GM offers Anti Lock Brake Systems as standard o
267. s 0 F 18 C 660 Reserve capacity 80 F 27 C 135 minutes TL g VEHICLE WEIGHT Ibs kg GVWR 6800 3084 p g Curb weight 5285 2397 5 Payload with bucket seats 1516 688 400 600 800 1200 1400 1600 1800 2000 2200 2400 ENGINE SPEED RPM NORMAL IDLE SPEED 600 650 RPMS YY ff COMPUTER CONTROLLED IDLE SPEED RANGE PARK 800 1000 RPM 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL NOTE See owner s manual supplement for loading information 3 Cargo and load capacity limited by weight and distribution 4 EPA estimated MPG 5 Gross Vehicle Weight Rating GVWR When properly equipped includes vehicle passengers cargo and equipment 6 Maximum payload capacity includes weight of driver passengers optional equipment and cargo 10 Curb weight in operational status with 100 fuel fluids and standard base equipment excludes optional content Published dimensions indicated are at curb weight TAHOE POLICE PPV AND SPECIAL SERVICES DIMENSIONS As TAHOE POLICE PPV AND SPECIAL SERVICE PACKAGE Rear Qtr Glass 40 w x21 h Front Side Glass Rear Side Glass 32 w x 20 h 28 w x 19 5 h Rear Window Estimated material sizes to wrap 61 5 w x 25 h Hood 70 x 52 Front Doors 50 x 36 Rear Doors 40 x 36 Roof 114 x 55 Rear hatch 65 x 26 10
268. s and other information see message listing on page 6 See exterior lamps control on page 24 for operation description Tilt wheel with column mounted gear shift lever Vehicle PASS Key Ill and content theft unauthorized entry OR ENTRY WITHOUT USE OF KEYLESS REMOTE FOB sounds horn and lamps flash For Content Theft Alarm disable option UTQ must be ordered see page 7 Padded with cloth trim extends on rod driver and front passenger illuminated vanity mirrors Headlamp on key in ignition driver and right front passenger safety belt unfasten and turn signal on Power with driver express down and lockout features ELECTRICAL FEATURES 100 amp ignition and main power supply wiring at lower center of instrument panel see wiring provisions for 12 volt battery power supply on page 23 100 amp auxiliary power in cargo area see page 23 Two studs located in rear compartment near bottom of liftgate opening see page 23 Prevents the power door locks from locking the driver s door if the keys are left in the ignition manually lockable with engine running Two 12 volt 20 amp located on Instrument panel and one 12 volt 20 amp in cargo area Battery power is present at all times See pages 28 through 31 for description also see Tahoe Police Package owner s manual supplement located in glove box folder with standard owner s manual Forward lamp harness in line connector for Exterior Lamps Flashing System see option 6J7 on page 7 1 Hea
269. s at the right front corner of the equipment mounting platform The flashing module is located is located on the rear side of the passenger side upper radiator support The headlamp flashing module is activated by the application of 12 volts to a dark green wire in the upfitter harness When activated the headlamp high beams and the high beam instrument cluster indicator will flash alternately at 2 4 flashes per second When the flashing module is turned on the module sends a signal to the BCM which alternately flashes the stop lamps and backup lamps at the same flash rate as the headlamps Depressing the brake pedal will override the stop lamp flashing and placing the transmission in Reverse will override the backup lamps flashing During daylight conditions the Daytime Running Lamps DRL are automatically turned off whenever the headlamps flashing module is activated During night time conditions the low beam headlamps automatically turn on while the high beam lamps flash Turning on the high beam headlamps manually will override the flashing module and the high beam headlamps will operate continuously During night time conditions the tail lamps will turn on automatically If Option VVS is present the low beam headlamps and tail lamps will not come on automatically The Center Mounted Stop Lamp will operate only when the service brakes are applied 15 amp fuse labeled EF35 protects the flasher module circuit The fuse
270. s at www siriusxm com Other fees and taxes will apply All fees and programming subject to change 2 If you subscribe after your trial period subscriptions are continuous until you call SiriusXM to cancel See SiriusXM Customer Agreement for complete terms at www siriusxm com Other fees and taxes will apply All fees and programming subject to change TIRE Spare LT265 70R17 all terrain blackwall Included and only available with RCS LT265 70R17C blackwall tires TIRE Spare P255 70R17 all season blackwall Included and only available with RBZ P255 70R17 all season blackwall tires TIRE Spare P265 70R17 all season blackwall Included and only available with RC3 P265 70R17 all terrain blackwall tires TIRES LT265 70R17C blackwall TIRES P265 70R17 all terrain blackwall TRAILER BRAKE CONTROLLER Integrated WT CONVENIENCE PACKAGE Includes AQQ Remote Keyless Entry and DL8 outside heated power mirrors 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 8 SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 1WT GCWR ENGINE REAR AXLE RATIO COMBINATION WITH AUTO TRANSMISSION GCWR GROSS COMBINATION WEIGHT RATINGS Ibs kg ENGINE 11 000 4 990 12 000 5 443 14 000 6 350 15 000 6 804 16 700 7 575 LV3 Vortec 4 3L V6 EcoTec3 AFM 3 23 3 42 L83 Vortec 5 3L V8 SFI FlexFuel 3 08 3 42 3 42 373 Requires RPO NHT Max Trailering Package With Regular cab standard box model CREW CAB SPECIFICATI
271. s you plan on adding to your police vehicle like roof mounted light bar s push bumpers security barrier s rear storage organizer highway flares fire extinguishers weapons ammunition radios and video equipment The weight and number of passengers you intend to carry in your vehicle The total weight of any additional cargo you intend to carry in your vehicle When planning your vehicle equipment installation remember not to exceed the Gross Vehicle Weight Rating GVWR or the Gross Axle Weight Rating GAWR of the front or rear axles To keep the available load weight less than the vehicle capacity weight you may need to limit the number of passengers you carry in your vehicle or change your choice of additional equipment CENTER OF GRAVITY CG A vehicle s center of gravity is an imaginary location inside the vehicle and is a balance point for the vehicle mass as it moves down the road The police vehicle s center of gravity before you add a load and passengers is approximately midway between the center of the axles up from the ground to just below the front window and between the driver and passenger Equipment location and weight on the vehicle s center of gravity is important to keep in mind when planning an installation Heavy equipment should be positioned as low and as far forward in the rear load compartment as possible Try to mount the equipment below the bottom of the side windows Refer to the Loading Zone chart and diagram
272. strument panel remains in place during deployment Some GM passenger air bag systems like the system in the Chevrolet Impala deploy from beneath the instrument panel top pad These are considered 3 4 mount air bag systems with a deployable top pad The entire instrument panel top pad is the deployment door from under which the inflating air bag emerges When an air bag deployment is commanded the forces from the inflating passenger air bag push up on the instrument panel top pad releasing special fasteners across the rearward edge of the top pad This allows the top pad to rotate upward so that the passenger air bag may emerge The top pad rotates upward to open widest at the right hand side and is usually forced upward into contact with the windshield on the right hand side of the vehicle during a deployment Instrument panel top mounted special equipment such as a radar antenna and control unit or video camera must be positioned to the left of the vehicle center line This equipment must be mounted as low as possible and securely fastened to the top pad to avoid being dislodged in the event of a crash and possible air bag deployment In the process of securely fastening special equipment to the top DO NOT fasten down the top pad itself to any other vehicle component such as the cluster trim plate As described above the top pad rotates upward during a deployment In order to enable the proper deployment of the passenger air bag sp
273. such as a parked car the threshold level will be higher The driver s and right front passenger s frontal air bags are not designed to inflate in rollover side impacts or rear impacts because inflation would not help the occupant Seat mounted side impact air bags are designed to inflate in moderate to severe side crashes The side impact air bags will inflate if the crash severity is above the designed threshold level The threshold level can vary with specific vehicles design The side impact air bags are not designed to inflate on frontal or near frontal impacts or rear impacts because inflation would not help the occupant Roof rail mounted head curtain air bags are designed to inflate in moderate to severe side crashes In addition certain vehicles have head curtain air bags which are also designed to inflate in situations where an impending rollover condition is identified by the vehicle s rollover sensing system and or frontal or near frontal impacts if the crash severity is above the designed threshold level Safety belt pretensioners at the driver and front passenger seat positions are designed to deploy in frontal near frontal side and rear crashes that exceed the threshold level of crash severity to help reduce slack in the safety belt Safety belt pretensioners will also deploy in impending rollover situations How long will the air bag remain inflated It takes approximately 1 20th of a second to fully inflate the fr
274. t driving conditions Each time the vehicle is started the StabiliTrak system is fully on StabliliTrak can be controlled by a StabiliTrak button on the instrument panel located below the dimmer control on the headlamp switch see page 17 The condition of the system is displayed by an instrument panel StabiliTrak indicator light and Driver Information Center DIC Messages Push once Performance Mode is active and Traction Control is off push and hold five seconds Traction Control and StabiliTrak are off push again and Traction Control and StabiliTrak are turned back on Prevents starter from engaging while the engine is running Power rack and pinion Heavy duty 4 wheel independent firm ride and handling with increased ride height springs heavy duty front and rear stabilizer bars Goodyear P235 55R17 SBR blackwall W rated with compact spare full size spare is available see option RUF on page 9 CHECK TIRE PRESSURE will show on driver message center see page 17 for description Deactivated when Police Performance Mode is engaged 6 speed automatic electronically controlled transmission provides protection against over rewing the engine in low gear and a mechanical low gear blockout is not required if a driver manually selects low gear and fails to manually upshift to high gear the powertrain control module automatically protects the drivetrain It can be manually shifted up and down with buttons located on steering wheel 17 x7 5 heav
275. t bottom frame structural tubes A B Center floor tunnel mounted crush box NOTE Do not remove the crush box for aftermarket equipment installation SERVICE PARTS IDENTIFICATION LABEL SERVICE PARTS IDENTIFICATION DO NOT REMOVE 2G1WD5EM3B1 142351 PDBJCH swig AGK AG2 ALO AMF AP3 ARQ AYO A75 76 BDR B3B B42 B86 B9V C67 E2C FE9 FRY IPG JAQ 9 KD KG4 LGD NK5 NT7 99 OST QPP RV RON R97 SLM UN9 UT7 Uwe U77 VT7 V8D WL9 190 500 191 3FL 6 6E2 6 6J1 6J3 7B3 7HP 7M9 7X6 8MZ 09 1 9M BC CC U 636R A Service Parts Identification SPID Label provides Vehicle Identification Number VIN specific Option Code content list Engineering Model Number Nameplate body style Exterior paint system Exterior paint color code and Interior trim level and color The SPID label for the Impala is located on the right side rear compartment floor The rear compartment trim must be lifted to access the label 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 18 IMPALA LIMITED 9C1 amp 9C3 SPECIAL EQUIP OPT 6C8 WIRING COAXIAL RADIO ANTENNA CABLE 7Y6 LAMP INOPERATIVE DOME Cy RG58 Coaxial radio antenna cable routed from just rearward of the dome lamp Dome and courtesy lamp will not operate when doors are opened Dome lamp location to trunk Approximately 24 inches of extra cable is coiled between is controlled only by the instrument light dimmer on the instrument panel headliner and roof pane
276. t collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL EXPRESS TRANSPORT VAN 115 amp 215 POWERTRAIN ENGINE TRANSMISSION MODEL CODE DISPLACEMENT FUEL STANDARD TYPE OPTION LITERS CU IN SYSTEM CODE 1LS L20 4 8L 293 SFI Automatic Automatic GU6 Standard Vortec HD 6 speed 1LS L96 6 0L 366 SFI Automatic Automatic GU6 Optional Vortec FlexFuel2 HD 6 speed 215 LGH 6 6L 403 Turbo Automatic Automatic GHO Standard Duramax diesel HD 6 speed NOTE Emission type must be ordered FE9 Federal YF5 California NG1 Northeast States SEATS AND INTERIOR TRIM SEAT OPTIONS EBONY COLOR STANDARD Front Vinyl trimmed high back buckets inboard armrests and reclining Medium Pewter Rear Vinyl trimmed bench seat and split four passenger last seat OPTIONAL Front Bucket with custom cloth trim head restraints and inboard armrest Medium Pewter Rear Bench seats with custom cloth head restraints not available on rear bench seats NOTE Vinyl trim only available in Medium Dark Pewter
277. t standard in states requiring front license plates others must order option VK3 Body color electric Left hand and right hand remote heated mirrors are available see option DK2 on page 9 Base coat clear coat i Standard Electric ignition controlled button located on left side of instrument panel ignition control release is available see option A98 on page 9 Not available Intermittent anti lift with washer CHASSIS FEATURES 170 amp with idle boost transmission in PARK or NEUTRAL controlled by battery energy level sensing 720 CCA 70 amp hour with battery rundown protection does not protect customer installed equipment Body frame intergal unibody Heavy duty reinforced body components 4 wheel anti lock disc brakes with police calibration and heavy duty front brake pads Heavy duty high capacity with 225 watt fans and extended life coolant coolant hoses are EPDM ethylene propylene diene monomer rubber silicone hoses are not required coolant is DEX COOL good for 5 years 150 000 miles protects from 34 F to 4 265 F and against rust and corrosion see also page 17 Lubed for life chassis 3 6L V6 DOHC SIDI spark ignited direct injection engine with with Variable Valve Timing VVT with FlexFuel2 gas or E85 ethanol includes wide open throttle air conditioning cut off when overhead lamps spotlamps radio antennas sirens and other emergency equipment are installed overall performance may be reduced Stainless steel
278. taken to a dealership for repair as soon as possible How do I use ABS Depress and hold the pedal DO NOT PUMP THE BRAKES that prevents the system from working Just hold the brake pedal down and let the ABS work for you You may feel the brake pedal vibrate or you may notice some noise but this is normal as the system works for you Should I drive an ABS equipped vehicle differently than I would drive a vehicle with conventional brakes Most of the time under normal driving circumstances there is no difference and you should always drive with the same caution and care It is important to realize that ABS only makes a difference when it is activated when you have to brake hard and that would only be when the computer senses that a wheel is approaching lockup When ABS activates keep steady pressure on the brake pedal and then let the ABS work for you Don t pump the brakes or try to find the threshold Simply hold the brake pedal down and steer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder and or brake system performance are being sold in the aftermarket Some of these prod
279. teer if necessary to avoid an obstacle Is ABS always active ABS is always available but not always activated ABS is activated only when the brake pedal is applied and the computer detects an impending wheel lock condition Can older cars be retrofitted with ABS No The brake system is one of the most important features on any passenger vehicle Several products which tap into the master cylinder and or brake system performance are being sold in the aftermarket Some of these products imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems which deplete fluid from the master cylinder on brake apply may actually increase a vehicle stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner A properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that eve
280. ter inflation some new parts will be required These will include the air bag module and possibly other parts A competent service technician with access to the vehicle s service manual and the required tools should replace the required components after a deployment crash If my vehicle has air bags why should have to wear my safety belt Air bags are in many vehicles today and will be in most of them in the future But they are supplemental systems only so they work with safety belts not instead of them Every air bag system ever offered for sale has required the use of safety belts Even if you re in a vehicle that has air bags you still have to buckle up to get the most protection That s true not only in frontal collisions but especially in side and other collisions 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 IMPALA LIMITED 9C1 amp 9C3 AIR BAG DIMENSIONS TOP VIEW OF INSTRUMENT PANEL AND APPROXIMATE DEPLOYMENT AREA OF THE AIR BAG ZONE A Shift selector arc B Driver side door C Front of steering wheel in maximum downward position D Driver air bag deployment zone E Driver centerline also see side view F Vehicle centerline G Inside rearview mirror H Passenger centerline also see side view I Passenger air bag deployment zone J Approximate maximum dimension of inflated air bag K Passenger side door L Rear edge of instrument panel top pad M Zone from instrument panel top to windshield
281. terior code changed from 4BB to 4AA Front bucket cloth seat with cloth rear bench seat code changed from ADX to H1T Front bucket cloth seat with vinyl rear bench seat code changed from ACC to HCQ Driver Information Center programming controls moved from steering wheel to turn signal lever on left side of steering column MyLink 8 inch touch screen display houses features for vehicle customization Front door lock buttons relocated to the top rear of door trim pad as a dedicated post pull handle once to unlock pull again to open door Fleet key options and BE4 will not be compatible with previous model years 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 CAPRICE POLICE PACKAGE 9C1 THIS VEHICLE HAS BEEN DESIGNED FOR POLICE WORK UP TO AND INCLUDING HIGH SPEED EMERGENCY VEHICLE OPERATIONS GM RESTRICTS THE SALE OF POLICE VEHICLES AND THEY ARE NOT TO BE SOLD TO RETAIL CUSTOMERS MODEL AVAILABILITY TEW19 9C1 Rear wheel drive STANDARD EGUIPMENT SUMMARY MAINTENANCE WARRANTY AIR CONDITIONING BLUETOOTH BOTTLE HOLDER CAPTURE SPEED FEATURE COMPASS CRUISE CONTROL DOME LAMPS DRIVER INFORMATION CENTER FLOOR COVERING GLASS GLOVE BOX MOUNTING PLATFORM MIRROR INSIDE REARVIEW NAVIGATION SYSTEM ONSTAR OUTSIDE TEMP DISPLAY RADIO RESTRAINT SYSTEM SEAT FRONT SEAT REAR SHIFT LEVER SMOKER S PACKAGE SPEEDOMETER CLUSTER SURVEILLANCE MODE STEERING WHEEL THEFT DETERRENT SYSTEM
282. ters with non functional panic button the keyless entry system used on the police Impala includes a stealth mode feature When the unlock or lock button is depressed no exterior lamps or audible sounds are activated however the interior OEM dome lamp will illuminate unless option 7Y6 lamps Inoperative Dome and Courtesy Lamps is ordered during remote start feature running lamps will remain illuminated additional transmitters are available see option AMF on page 9 Two sided random code for ignition driver door and trunk only single key locking system to operate entire fleet is available fleet coded single key is available see option 6E2 and 6EBonpage9 Mounting hardware located in glove box front bracket standard in states requiring front license plates others must order option VK3 Body color electric left hand and right hand remote heater mirrors are available see option DK2 on page 9 Base coat clear coat Standard Electric not ignition controlled button located on instrument panel left of steering column manual inside trunk safety release ignition control is available see option A98 on page 9 Not available a Intermittent anti lift with washer CHASSIS FEATURES 170 amp with idle boost transmission in PARK or NEUTRAL controlled by battery energy level sensing 720 CCA 70 amp hour with battery rundown protection does not protect customer installed equipment Body frame inergal unibody Heavy duty rein
283. the bag are also vented into passenger compartment These airborne particles look like smoke and some particles are deposited as residue on and around the air bag I ve heard that the dusts that are released into the passenger compartment from the air bag are harmful is this true For most people the only effect the dusts will produce is some irritation of the throat and eyes and that is only if the occupant remains in the vehicle for many minutes after the air bag deployment with no ventilation and windows closed However some people with asthma may develop an asthmatic attack from inhaling the dusts If this happens they should first treat themselves the same way their doctor has advised them to treat any other asthma attack and then immediately seek medical treatment Can the air hag system be re used No The air bags are designed to inflate only once After inflation some new parts will be required These will include the air bag module and possibly other parts A competent service technician with access to the vehicle s service manual and the required tools should replace the required components after a deployment crash If my vehicle has air bags why should I have to wear my safety helt Air bags are in many vehides today and will be in most of them in the future But they are supplemental systems only so they work with safety belts not instead of them Every air bag system ever offered for sale has required the use of safety b
284. through the MENU items PRESS MENU UNTIL THE SPEED IS DISPLAYED TURN THE ROTARY SWITCH TO SCROLL THROUGH THE MENU ITEMS SPEED UNIT gt Digital Speed gt Engine Hours Idle Hours gt Fuel Used gt Battery Voltage gt Average Speed gt Coolant Temp gt Instantaneous Fuel Economy gt Remaining Oil Life gt Average Fuel Economy gt Tire Pressure gt Fuel Range gt Trip gt Captured Speed NOTE Other vehicle features can be programmed via the radio See also the Owners Manual for additional DIC features information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL CAPRICE POLICE 9C1 DRIVER CUSTOMIZATION FEATURE 1 69 F 1 21 PM 69 F 1 21 PM Home Page 2012 Now Playing AUX Bluetooth PANDORA STITCHER El internet radio SMART RADIO lt G Pandora Stitcher Config Messages Quick Info The Following Items Are Permanently Disabled on Caprice USB AUX In ELECTRICAL FUNCTION CUSTOMIZATION FEATURE With Radio OFF Day Date Time Exterior Temperature and Chevrolet MyLink are displayed Display Screen can be turned off see DISPLAY SETTINGS COMFORT AND CONVENIENCE FACTORY DEFAULTS IN BOLD LANGUAGES English Francais Canadien Espanol Mexicano CHIME VOLUME Normal High TIME AND DATE 12 hr 24 hr Format BUTTON CHIME Buttons click when touched On Off RADIO SETTINGS Auto Volume Gracenote Options Max Startup Volume PHONE SETTINGS Bluetooth gt Device List Pair Device LIGHTING FACTORY DEFA
285. ticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 Federal emissions is ordered for delivery to a dealer located in California Connecticut Delaware Massachusetts Maryland New Jersey New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State Required when option code YF5 CALIFORNIA EMISSIONS or option code NET CT DE ME MD MA NJ NM NY OR PA RI VT WA EMISSIONS is ordered for delivery to a dealer located in any state except California Connecticut Delaware Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles NB9 Required when option code YF5 is ordered for
286. tion to these factors the trajectory and velocity of a dislodged object can be influenced by the type and severity of vehicle crash Objects that are in the deployment zone but do not become dislodged by an inflating air bag can still affect the performance of the air bag For example such objects could tear the fabric or affect the shape of the air bag thus reducing the ability of the bag to provide restraint Is it possible to shield equipment that is installed in the passenger side frontal air bag deployment zone in a manner that will allow full and safe air bag deployment Due to the complexity of influencing variables GM is unable to evaluate the potential for shielding expected equipment configurations in all accident scenarios in order to assure that the air bag performance would be unaffected While shielding may protect certain equipment from being damaged or dislodged it may also negatively affect the inflation characteristics of the air bag The air bags shape inflation angle fold pattern and inflation rate and pressure are developed to maximize the protection capability of the inflatable restraint system Therefore GM cannot recommend the placement of any equipment in the deployment zone even if it is shielded to protect it from damage Front air bag systems and instrument panel mounted equipment Passenger air bags in GM vehicles deploy in different ways depending upon the type of vehicle and the particular instrument pa
287. tions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 1 AIR BAGS HEAD CURTAIN AND FRONT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT ZONES PASSENGER SIDE SHOWN DRIVER SIDE SIMILAR B C 01 02 121 U Tahoe Suburban Silverado Crew Cab Seat Rows 1 and 2 Tahoe Suburban 3rd Row Seats A Top of deployment zone along head curtain at edge of headliner M Deployment zone Tahoe 3rd seat B Back of deployment zone at rear top corner of rear door pad N Deployment zone Suburban 3rd seat C Rear quarter window 0 Rear zones at back corner of headliner 1 Tahoe 2 Suburban D Bottom outside edge of rear quarter window P Bottom of 3rd seat zone at rear side trim cup holders E Bottom of air bag deployment zone parallel to outside bottom edge of Q Top edge of rear quarter trim at window rear quarter glass R Rear of Tahoe F Top edge of rear door pad S Rear of Suburban G Top edge of front door pad H Dimension at mirror patch from top edge of front door pad Tahoe Suburban Silverado Crew Cab Seat Air bag I Front of deployment zone at front upper corner of front door pad T Center of door trim pull handle J Windshield pillar trim with grab handle U Top of surface of outboard front seat cushion K Visor V Back edge of center pillar trim L Deployment zone Tahoe seat rows 1 and 2 NOTE The head curtain air bag inflators are m
288. to help with your installation plan A procedure to make the necessary measurements and formulas to calculate the vehicle longitudinal lateral and vertical position of the center of gravity can be found in the GM Coachbuilders Manual Equipment required to conduct the measurements for calculating the center of gravity are Weight scales of sufficient capacity to measure the vehicle weight at each wheel A post type hoist or other means to safely elevate the front of the vehicle to at least an angle of 20 degrees above horizontal See your GM dealer to get more information about this coachbuilder procedure Keeping the center of gravity midway between the axles is also important to provide proper braking performance About half the total vehicle weight on each axle is recommended Weigh your vehicle after the additional equipment has been installed to determine the actual weight of your vehicle Weigh the vehicle with a full tank of fuel and without passengers You may need to put a limit on how many people or other equipment you can carry inside your vehicle after the additional equipment has been installed Note See loading zone weight chart and diagram on page 11 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL TAHOE POLICE PPV LOADING ZONES 1 Loading zone for customer installed equipment and cargo without passengers A Front Floor to Roof Zone Area B Front Roof Zone Area C Back of Front Door D Rear Roof Zone Area
289. tor how fast the wheels rotate and feed the data continuously to the ABS computer The vehicle s brakes slow each wheel as the brake pedal is applied However when ABS is activated due to road conditions the system repeatedly releases and applies pressure to the brakes The wheels can keep rolling thus retaining steering ability and enhanced stability while providing a higher braking force on most surfaces than a locked wheel provides How exactly does ABS work In cars without ABS hitting the brakes can cause the wheels to lock leaving you unable to steer the vehicle until you decrease the pressure so the wheels can roll again With an ABS as you apply the brakes the ABS computer monitors the wheel speed sensor information If the computer senses that a wheel is approaching lock up it sends a signal to the hydraulic modulator to reduce then to reapply brake pressure several times a second for as long as you maintain firm pressure on the brake pedal The process is much like the threshold braking technique used with conventional brakes However ABS does it much faster and more accurately than any driver can leaving you free to focus on steering away from obstacles Does ABS reduce stopping distances Yes in braking situations where the wheels on a non ABS equipped vehicle would lock up ABS will generally provide shorter controlled stopping distance The amount of improvement in stopping distance depends on many factors includin
290. ts because inflation would not help the occupant Roof rail mounted head curtain air bags are designed to inflate in moderate to severe side crashes In addition certain vehicles have head curtain air bags which are also designed to inflate in situations where an impending rollover condition is identified by the vehicle s rollover sensing system and or frontal or near frontal impacts if the crash severity is above the designed threshold level Safety belt pretensioners at the driver and front passenger seat positions are designed to deploy in frontal near frontal side and rear crashes that exceed the threshold level of crash severity to help reduce slack in the safety belt Safety belt pretensioners will also deploy in impending rollover situations How long will the air bag remain inflated It takes approximately 1 20th of a second to fully inflate the frontal air bags This is faster than the blink of an eye The air bags begin to deflate immediately helping to stop the occupants more gradually I ve heard that a deployed air bag produces whet appears to he smoke is the air hag hot After the bag has deployed in a crash the air bag itself will not be hot to touch Some components within the air bag module will be hot for a short time A small amount of smoke coming from a deployed air bag module is normal and should not be cause for concern Also when the nitrogen gas is vented out of the air bag small particles from inside
291. ucts imply performance similar to new vehicle anti lock brake systems However contrary to their claims add on systems which deplete fluid from the master cylinder on brake apply may actually increase a vehicle s stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner A properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that even a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However performance is reduced Do insurance companies give a discount for ABS Yes many insu
292. udes remote keyless entry 2 transmitters requires ATG ZP3 SEATS 15 passenger seating 2 3 3 3 4 seating configuration AS5 SEATS Front bucket with custom doth trim head restraints and inboard armrests requires G interior trim When ordering a seating arrangement that includes rear seats includes rear bench seats with custom cloth trim Head restraints are not available on rear bench seats 074 SMOKER S PACKAGE Includes ash tray and lighter 280 TRAILERING SPECIAL EQUIPMENT Heavy duty included platform trailer hitch 7 wire harness DH6 VISORS Driver and front passenger padded with cloth trim and dual vanity mirrors illuminated on passenger side included and only available with TR9 auxiliary lamps 40P WHEEL FINISH PAINTED WHITE White painted wheels in lieu of standard Gray painted wheels WHEEL TRIM Chrome center 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 8 Visit OnStar com for coverage map system limitations and details 9 XM Radio requires a subscription sold separately by XM after the trial period Not available in Canada Alaska or Hawaii For more information visit gm xmradio com 10 Go to gm com bluetooth to find out which Bluetooth phones are compatible with the vehicle 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL EXPRESS TRANSPORT VAN ILS amp 215 5 AVAILABLE EXTERIOR COLORS
293. ue not only in frontal collisions but especially in side and other collisions 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL EXPRESS TRANSPORT VAN 1LS amp 215 AIR BAG DIMENSIONS OVERHEAD VIEW Driver Side Bag Deployment Zone Passenger Side Air Bag Deployment Zone REAR VIEW RIGHT SIDE VIEW Passenger Side Alr Bag Deployment Zone Instrument 720mm gt Windshield Front of Vehicle 355mm 14 0 R from center of steering wheel Bottom of Passenger Side Air Bag Deployment Door Driver Side Air Bag Deployment Zone Passenger Side Air Bag Deployment Zone Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information NOTE All dimensions are approximate and subject to change 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 10 EXPRESS TRANSPORT VAN 1LS amp 2LS AIR BAG DIMENSIONS ZONE A BACK OF BACK OF FRONT OF DOOR C PILLAR B PILLAR MIRROR PATCH ZONES ZONE ROOF RAIL ROOF RAIL INFLATOR LOCATION L NFLATOR LOCATION FRONT OF DOOR
294. uffler and tailpipe Fully boxed hydroformed front section 26 gallon 98 liter 3 23 ratio with 2WD 3 42 with 4WD see engine axle transmission chart page 5 Stability control system with Proactive Roll Avoidance and traction control includes electronic trailer sway control and hill start assist Electric Power Steering EPS assist rack and pinion Independent coil over shock includes 35mm twin tube shock absorbers and 36mm front stabilizer bar 2 Stage multi leaf springs semi elliptic Locking utilizes same key as ignition and door Tire Pressure Monitor System does not apply to spare tire Outside winch type mounted under frame at rear P255 70R17 all season blackwall Keyed cylinder lock that utilizes same key as ignition and door Floor mounted shifter requires 4 wheel drive model 6 speed automatic electronically controlled with overdrive and tow haul mode Includes Cruise Grade Braking and Powertrain Grade Braking 17 x 7 5 43 2 cm x 19 1 cm steel 6 lug painted includes painted center caps spare wheel will not cosmetically match the other 4 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 4 SILVERADO 1500 CREW CAB PICKUP WORK TRUCK 1WT SEATS AND INTERIOR TRIM INTERIOR JETBLACK DARK ASH STANDARD Front 40 20 40 split bench with fold down armrest and fixed driver lumbar i OPTIONAL Front 40 20 40 split bench with fold down armrest and driver manual adjustable lumbar OPTIONAL Front 40 20 40
295. unk see page 16 Auxiliary located in trunk see page 16 Not available driver door can be locked with the key in the ignition Lock out protection feature cannot be activated Two 12 volt 20 amp located on lower center of instrument panel Battery power is present at all times See pages 23 through 25 for description also see Impala Police Package owner s manual supplement located in glove box folder with standard owner s manual Forward lamp harness in line connector for Exterior Lamp Flashing System see option 6J7 on page 9 1 Head curtain side air bags are designed to help reduce the risk of head and neck injuries to front and rear seat occupants on the near side of certain side impact collisions Always use safety belts and the correct child restraints for your child s age and size even in vehicles equipped with air bags Children are safer when properly secured in a rear seat See your vehicle Owner s Manual and child safety seat instructions for more information 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL IMPALA LIMITED POLICE PACKAGE 9 1 BODY PANELS BODY SIDE MOLDINGS DEFOGGER DOOR LOCKS HEADLAMPS HORNS KEYLESS ENTRY KEYS LICENSE PLATE MIRRORS REARVIEW PAINT TRUNK LAMP TRUNK RELEASE UNDER HOOD LAMP WINDSHIELD WIPERS ALTERNATOR COOLING CHASSIS LUBRICATION ENGINE EXHAUST SYSTEM FUEL TANK CAPACITY OIL COOLERS RADIO SUPPRESSION STABILITRAK STARTER INTERRUPT STEERING STRU
296. usetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington for a purchaser who will be registering the vehicle in one of these states or sold as permitted below under EPA Policy on the Sale of California Emission Vehicles Required when option code YF5 is ordered for delivery to a dealer located in Connecticut Maine Maryland Massachusetts New Jersey New Mexico New York Oregon Pennsylvania Rhode Island Vermont and Washington Required when option code NE1 is ordered for delivery to a dealer located in California AUTOMATIC TRANSMISSION with BALL HITCH LV3 4 3L 6 AFM DI L83 5 3L V8 ECOTEC3 AFM DI MODEL VVT FLEXFUEL ALUMINUM BLOCK VVT FLEXFUEL ALUMINUM BLOCK AXLE RATIO MAX TRAILERING AXLE RATIO MAX TRAILERING AXLE RATIO MAX TRAILERING CC15543 5900 2676 6800 3084 9800 4445 CC15743 5800 2631 6700 3039 9700 4400 CK15543 6700 3039 6600 2994 9600 4355 CK15743 6600 2994 6500 2948 9500 4309 Silverado 1500 models are limited to 5000 Ib trailer rating unless equipped with 285 Handling Trailering Suspension Package 260 High Performance Suspension Package or Z71 Off Road Suspension Package Addition of trailer tongue weight cannot cause vehicle weights to exceed Rear Gross Axle Weight Rating RGVWR of Gross Vehicle Weight Rating GVWR 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 6 SILVERADO 1500 CREW CAB PICKUP WORK TRUCK
297. ution and care GM s StabiliTrak system StabiliTrak is designed to be as seamless as possible in operation to be part of the overall vehicle response and to make a good vehicle better 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL EXPRESS TRANSPORT VAN 1LS 2LS 1 e SILVER ICE METALLIC GAN e CYBER GRAY METALLIC GBV e BROWNSTONE METALLIC GWX e SANDSTONE METALLIC 15U GRAYSTONE METALLIC 16U e SHEER SILVER METALLIC GGZ e MIRRORS OUTSIDE HEATED POWER ADJUSTABLE BLACK MANUAL FOLDING WITH INTEGRATED TURN SIGNALS DE7 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 2 EXPRESS TRANSPORT VAN 1LS amp 215 NOTE This vehicle is NOT designed nor intended for use IN HIGH SPEED EMERGENCY VEHICLE OPERATIONS MODEL AVAILABILITY CG33406 1LS GAS DIESEL CG33706 2LS GAS DIESEL Rear wheel drive Rear wheel drive STANDARD EQUIPMENT SUMMARY 3 years 36 000 mile bumper to bumper whichever comes first see dealer for details 5 years 100 000 mile limited powertrain whichever comes first see dealer for details INTERIOR FEATURES RESTRAINT SYSTEM WARRANTY AIR CONDITIONING Single zone manual front Rear air and rear Safety belts driver and front passenger with heat available on 33706 models CUP HOLDERS Three on engine console cover DEFOGGERS Front and side windows DOME LAMPS Three dome lamps with defeat switch and door activated switches DRIVER INFORMATION CENTER See order guide FLOOR CO
298. which deplete fluid from the master cylinder on brake apply may actually increase a vehicle s stopping distance This may cause the vehicle to fail to comply with Federal brake standards Does ABS always activate at the same speed No the system operates when the computer detects wheel lockup at any speed above 8 mph Will ABS wear out a vehicle s brakes sooner A properly maintained brake system will be unaffected by ABS operation under typical driving conditions Are there different types of ABS Yes there are rear wheel anti lock systems RWAL used on some trucks and four wheel ABS available on cars and trucks Do Federal Safety Standards mandate ABS No Federal standards establish minimum braking performance requirements that all vehicles must meet but do not specify how they should be met It should be noted that even a vehicle with failed ABS meets the Federal safety standard for stopping distances Will a tire size change affect ABS Use of tires other than original equipment may affect ABS performance Owners should consult and follow the recommendations contained in the vehicle owner s manual regarding replacement tire size NOTE ABS will work with original equipment spare tire or tire chains However performance is reduced Do insurance companies give a discount for ABS Yes many insurance companies give discounts that range from 5 to 10 In the states of New York and Florida all insurance companies are r
299. width 723 1852 Exhaust Single with dual outlets Overall 58 7 1491 Minimum recommended fuel octane 87 width Pale Fuel tank capacity gallons liters 17 5 66 2 width 61 5 1562 Oil with filter quarts liters 4 0 3 8 Turning diameter curb to curb ft m 38 0 11 6 Cooling capacity quarts liters 10 6 10 0 Ground clearance lower control arm bolt 6 46 164 FRONT COMPARTMENT in mm P Automatic electronically controlled with overdrive 6 speed Mead room Fluid removed amp filter replaced quarts liters 7 4 7 0 Shoulder room 58 7 1491 Hip room 56 4 1433 AXLE Leg room 42 3 1074 Ratio 2 44 REAR COMPARTMENT in mm BRAKES Head room 37 8 960 ABS with vacuum boost Disc Disc Shoulder room 58 6 1488 Front swept area sq in sq cm 246 3 1589 6 Hip room 57 2 1453 Rear swept area sq in sq cm 175 8 1134 Leg room 37 6 955 Total front and rear swept area sq in sq cm 422 1 65 5 Front rotor diameter in mm 12 7 323 LUGGAGE COMPARTMENT CAPACITY cu ft liters Rear rotor diameter in mm 10 9 277 Luggage capacity with space saver 18 6 526 Front rotor thickness in mm 1 2 30 EPA passenger compartment volume index 104 8 2968 Rear rotor thickness in mm 5 14 FUEL EGONOMY RATINGS CITY HIGHWAY COMBINED TIRES 3 6L engine 17 28 21 Type All Season W speed rated EPA label values actual mileage will vary with options driving conditions driving habits and Size P235 55R17 vehicle condition ALTERNATOR NIEL
300. x LPO LPO WHEEL LOCKS Set of 4 dealer installed MIRRORS Outside heated power adjustable black includes driver s side spotter mirror Included and only available with PCR WT Convenience Package MIRRORS Outside high visibility vertical camper style Black with manual folding and extension and lower convex spotter glass ONSTAR 6 months of Directions and Connections plan Visit onstar com for details and system limitations LPO ALL WEATHER FLOOR MATS Front and rear dealer installed POWER OUTLET 110 volt AC Included and only available with PCR WT Convenience Package REAR AXLE 3 08 RATIO Requires L83 5 3L V8 EcoTec3 engine REAR AXLE 3 42 RATIO Standard on 4WD LV3 4 311 V6 EcoTec3 engine and L86 Available with 183 5 3L V8 EcoTeg engine REMOTE KEYLESS ENTRY With 2 transmitters Included and only available with PCR WT Convenience Package SEATS front 40 20 40 split bench 3 passenger cloth Includes driver and front passenger recline with outboard head restraints and center fold down armrest with storage Also includes manually adjustable driver lumbar lockable storage compartment in seat cushion and storage pockets SIRIUSXM SATELLITE RADIO AND HD RADIO Requires 104 4 2 color radio with Chevrolet MyLink and UE1 OnStar If you subscribe after your trial period subscriptions are continuous until you call SiriusXM to cancel See SiriusXM Customer Agreement for complete term
301. y Blank Basic Key with Blank Transmitter 92271668 Key Door Lock and Ignition Lock UNCUT KEY Fleet AU7 Key Blank 6E3 6E4 Basic Key with Blank Transmitter See Dealer Key Door Lock and Ignition Lock CUT KEY Fleet AU7 Keyed Alike 6E3 Basic Key with Blank Transmitter See Dealer Key Door Lock and Ignition Lock CUT KEY Fleet AU7 Keyed Alike 6E4 Basic Key with Blank Transmitter 19302076 See Dealer Key Door Lock and Ignition Lock CUT KEY Master AX2 Random Cut Basic Key with Blank Transmitter KITS Key Door Lock and Ignition Lock CUT KEY Fleet AU7 Keyed Alike 6E3 Package of 6 Basic Keys with Blank Transmitter AMF PACKAGE OF 6 KEY AND TRANSMITTERS Key retraction button Unlock Vehicle Lock Vehicle Trunk Release j Remote Vehicle Start Panic non functioning Option AMF Package of 6 Keys and Transmitters includes 6 cut keys with integrated remote keyless entry Transmitter are not programmed Each transmitter including the two standard with the vehicle must be programmed at the same time by the customer or by a dealer at customer expense Transmitter programming is not a warranty item Common frequency keyless entry for fleet keyed vehicles not available each fleet keyed vehicle will have a different keyless entry See your owner s manual for additional programming information PROGRAMMING THE KEY AND TRANSMITTER 1 The six RPO AMF keys
302. y duty steel Full size plastic wheel covers 2 E85 is 85 ethanol and 15 gasoline To see if there is an E85 station near you go to www gmaltfuel com e85 station locator 2014 CHEVROLET MUNICIPAL VEHICLES TECHNICAL MANUAL 8 IMPALA LIMITED UNDERCOVER POLICE PKG 9C3 POWERTRAIN ENGINE TRANSMISSION OPTION DISPLACEMENT FUEL OPTION TYPE OPTION CODE LITERS CU IN SYSTEM CODE CODE FlexFuel 6170 LFX 3 6 217 gas or E85 MXO 6 speed F71 ethanol auto with OD EMISSIONS MUST BE SPECIFIED FEDERAL EMISSIONS Use for ordering vehicles that will be registered in all states except California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont and Washington State CALIFORNIA EMISSIONS Use for ordering vehicles that will be registered in California CT ME MD MA NJ NY OR PA RI VT WA EMISSIONS Use for ordering vehicles that will be registered in Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pennsylvania Rhode Island Vermont or Washington State Required when option code FE9 Federal emissions is ordered for delivery to a dealer located in California Connecticut Massachusetts Maryland New Jersey New York Oregon Pennsylvania Rhode Island and Washington State for a purchaser who will be registering the vehicle outside California Connecticut Maine Maryland Massachusetts New Jersey New York Oregon Pen
303. you Also if the roads are wet or icy or visibility is poor you should increase your following distance world cannot provide a shorter stopping distance or good steering ELECTRONIC STABILITY CONTROL SYSTEMS STABILITRAK Q How does StabiliTrak work A StabiliTrak has the ability to apply control forces to the vehicle independent of the driver StabiliTrak uses sensors to continuously compare the path indicated by the steering wheel position to the vehicle s actual path If a discrepancy is detected StabiliTrak selectively controls vehicle brakes and engine torque to create a yaw moment that helps restore the vehicle s actual path to the path indicated by the steering wheel position StabiliTrak has the ability to help correct both understeer where the vehicle is not turning as much as the steering wheel position indicates and oversteer where the vehicle is turning more than the steering wheel position indicates The illustration at right shows how selective braking at a particular wheel can create a compensating yaw moment to help restore the vehicle s actual path to the path indicated by the steering wheel position Will a tire change affect StabiliTrak A Use of tires other than original equipment may affect StabiliTrak performance StabiliTrak is designed to make the best use of available traction The performance characteristics of the original equipment tires are part of the overall system effectiveness When you
304. ystem and frontal air bag ON OFF indicator dual head curtain air bags for front and rear outboard occupants and front seat back mounted thorax pelvic air bags High density foam cloth bucket seats with seat back security panel 6 way power driver and passenger seat adjusters see page 4 and manual reclining seat backs Driver seat has manual lumbar control Front seat frames are strengthened for side impact resistance see page 17 Vinyl bench with high density foam non folding seat back see page 4 Not available 140 mph certified analog speedometer 5 mph increments with digital trip odometer and warning lamps Driver Information Center includes 1 mph redundant digital speed display see message center listing on page 15 See exterior lamps control on page 17 for operation description Tilt wheel with column mounted gear shift lever Vehicle PASS Key Ill content theft deterrent is disabled to enable content theft deterrent option UA6 must be ordered Heavy duty see page 17 Brake safety belt air bag anti lock brake check engine see page 14 for additional information Key in ignition driver door open driver and passenger safety belt not buckled headlamps on Power with driver express down rear window lockout switch ELECTRICAL FEATURES 100 amp ignition and main power supply wiring under lower right side of instrument panel see wiring provisions for 12 volt battery power supply on page 16 100 amp auxiliary power outlet in tr

2014 chevrolet municipal vehicles technical manual

Contents

Download Pdf Manuals

Related Search

Related Contents