Likorall 243 ES - Dynamic Medical Systems
Contents
1. Lift unit weight Emergency lowering Intermittent operation Degree of protection 12 6 kg 28 Ibs Electrical Int Op 10 90 active operation max 6 min Out of a time of 100 active must be less than 10 though not more than 6 min IP 43 3 Intended for indoor use Type B according to the degree of protection against electric shock www liko com Assembly Likorall must be assembled and installed by qualified personnel and in accordance with installation instructions provided by Liko After assembly check to ensure that e lift functions correspond to markings on hand e the battery charger is functioning and the indi control cator lamps light during charging e the electrical emergency lowering is functioning e the batteries have been charged for 8 hours the SSP Limit Switch is functioning before the lift is used for the first time Se J NOTE The lifting equipment must always be tested with maximum load after installation Mounting lifting accessories N Lift strap with Locking Plate standard Most of Liko s lifting accessories can be used with Likorall Use fitted bolt 810x12 and locking nut M8 special These are included with the lifting accessory Check that the bolt passes the locking function of the locking nut with 2 mm C N sf Lift strap with Q link accessory If the lift strap is equipped with Q link Liko s Quic2. All Liko stretcher models can be used in combination with Likorall Contact Liko for more information Scale In need of weighing persons in combination with Liko rall we recommend the use of LikoScale The scale is preferably used with Adapter kit LikoScale LikoScale is certified according to the european directive NAW I 90 384 Non Automatic Weighing Instruments Contact Liko for more information Support Springs Elastic springs enable a gentler springing motion which makes activities such as gait training easier and more natural Springs are available in two sizes Short Prod No 3166512 and Long Prod No 3166511 Both sizes are intended for lifting less than 70 kg 154 Ibs For patient weights up to 100 kg 220 Ibs use Prod No 3156513 short See Instruction Guide for Liko MasterVest mod 60 64 or Liko Lift Pants mod 92 for more information Liko Bathing Chair Prod No 3156025 Contact Liko for more information Slingbar Cover Paddy 30 Prod No 3607001 fits Universal Slingbar 350 450 and 600 and Slingbar Slim 350 Likorall 243 ES 7EN120109 01 Quick release Hook Quick release Hook Universal Prod No 3156508 Prod No 3156502 wW Q link Prod No 31590005 LikoScale 350 Prod No 3156228 Y y y AN z S a R 1 i DN AR x A N z h h W WW aio U S gt www liko com Hang Up Handcontrol Hanger Prod No 3156100 10 p
3. buzzer sounds during lifting e a diode lights up during lifting The battery should be charged immediately when either of these indicators is activated www liko com Charging the Batteries a N Alternative charging procedure a Jla Q m a To ensure maximum battery life it is important that batteries are charged regularly We recommend charging whenever the lift is not in use Maximum charge is reached after maximum 8 hours Fully charged batteries in perfect condition are good for about 60 normal lifting cycles The charger is approved for use in wet areas 1 Check to ensure that the emergency stop button is not pressed in during charging 2 Place the handcontrol in the socket on top of the charger 3 Plug the charger into a 100 240 VAC wall socket 4 The green lamp lights to indicate that the charger is connected to the power supply 5 Charging begins automatically and the yellow lamp indicates that charging is in progress 6 Once the battery is fully charged the charger shuts off automatically and the yellow light goes out Multi Station Prod No 3126110 As an alternative to charging via the handcontrol Li korall can be charged with a Multi Station In this case Likorall needs to be equipped with a Multi connector or a Transfer Motor The batteries are then charged by parking the lift unit in the charging position at the
4. function for lifting and lowering e Check to ensure that the emergency lowering works properly e Charge the battery every day the lift has been used and check the charger function When necessary clean the lift with a moist cloth using common surface cleaners or disinfectants NOTE Do not use cleaning products that contain phenol or chlorine since these can eventually damage aluminum and polyamide material Inspection and control Likorall should be thoroughly inspected for wear of parts at least once per year Inspection should be in accordance with Liko service manual and conducted by authorized personnel A IMPORTANT Repairs and maintenance may only be carried out by personnel authorized by Liko using original Liko spare parts Transport and storage During transportation or when the patient lift is not to be used for some time the emergency stop button should be pushed in Store the lift at a temperature exceeding freezing point and at normal relative humidity no more than 60 Service agreements Liko invites you to sign a service agreement for regular maintenance and testing of your Likorall lift Contact your local Liko representative for more information Liko s products are constantly being updated and refined Liko reserves the right to change aspects of the products without prior notice Contact your local Liko representative for updated information and advice Recycling For instructions on how Likorall should
5. Multi Station This charging procedure is also suitable when Likorall is operated by Handcontrol Remote IR X Old batteries are to be left at the nearest recycling station or given to personnel authorized by Liko Pb Likorall 243 ES 7EN120109 01 www liko com Maximum Load Different maximum load limits may apply for the different products constituting the compound lift unit lift slingbar sling and other accessories It s always the product with the lowest maximum load that determines the maximum load for the compound lift unit For example A Likorall that is approved for 230 kg 507 Ibs could be equipped with a slingbar that is approved for 300 kg 660 Ibs In this case a maximum load of 230 kg 507 Ibs applies for the com pound lift unit Study the markings of the lift and accessory or contact your Liko representative if you have any questions Recommended Lifting Accessories Liko s product range includes many slings stretchers scales and other accessories to meet most lifting needs Appropriate slingbars for Likorall are listed below Consult the sling instruction guide for advice on combining Liko slingbars and slings or contact Liko if you are still unsure For choice of appropriate lifting accessories see our accessory brochures and other product information For further guidance in selecting the right sling study the instruction guide for each sling model For advice and information about new products in Lik
6. alted electrically This protects the lift motor from mechanical strain and also prevents squeeze injuries F np y 3 TN Pw lf oe EN y For reliable operation during lifting it is important that the lift strap is as close to vertical as possible i e the lift unit is directly above the centre of grav ity The SSP Limit Switch is intended to halt the lift ing motion if the lift strap is subjected to strain that may damage it e g if it pulls at a bias or becomes twisted during lifting If the SSP Limit Switch is ac tivated so that lifting is interrupted upward motion can be resumed when the strap is taut again a slight delay of motion is normal in this event A Caution Operate the lift only when tension is applied to the lift strap Adjustable Friction Brake The lift unit s rolling resistance on the rail can be varied by adjusting the friction brake on the car riage Turn the brake adjustment screw clockwise to increase resistance and counter clockwise to reduce resistance The following carriages are equipped with ad justable friction brakes Prod No 3126011 and 3126015 r Ne H Hang Up Handcontrol Hanger When not in use the handcontrol can be hung on the Hang Up Likorall 243 ES 7EN120109 01 Charging indicator Likorall has two indicators for low battery charge a
7. be recycled please visit our website www liko com Made in Sweden Liko is quality certified according to ISO 9001 and its equivalence for the medical device industry ISO 13485 Liko is also certified according to environmental standard ISO 14007 K Liko www liko com Manufacturer National Distributor in USA and Canada Liko Distributor in UK Liko AB Liko North America Liko UK Ltd SE 975 92 Lule 122 Grove Street Brunel Centre Sweden Franklin Ma 02038 USA Stroudwater Business Park info liko se Phone 508 553 3993 1 888 545 6671 Stonehouse Gloucester Fax 508 528 6642 GL10 3RU United Kingdom info liko com Phone 44 0 1453 827272 Fax 44 0 1453 828844 info liko co uk Copyright Liko AB 2007 05
8. cs set Multi connector Prod No 3126111 The Multi connector is mounted on Likorall enabling the lift to operate rail switches and be charged via the rail system This requires that the rail system also is equipped with a Multi Station Prod No 3126110 Transfer Motor Prod No 3126044 Likorall 243 ES is prepared for use with the Transfer Motor which enables motorized transfer of the lift unit along the rail Parking Panel Parking Panel 600 Prod No 3126005 Parking Panel 1500 Prod No 3126006 Enclosed with the Parking Panel is a set of short instructions for the most important lift functions a charger plate on which to fasten the battery charger and a parking bracket for the slingbar Charger and slingbar are not included Carriage Adapter LR Prod No 3126029 for Quick release Hook The Carriage Adapter makes it possible to easily and without tools move a Likorall motor from one rail system to another Contact Liko for more information Easy Switch 2 button Prod No 3107010 4 button Prod No 3107011 Easy Switch is developed for caregivers patients who may have a problem operating the lift with the regu lar buttons on the handcontrol due to impaired hand functions Easy Switch can easily be mounted on the handcontrol Fits with Likorall handcontrols Prod No 3126034 3126035 and 3126036 Likorall 243 ES 7EN120109 01 10 www liko com Simple Troubleshooting The lift doesn t w
9. d plate of the lift unit controlled by the and buttons l Handcontrol Remote IR is equipped with replace In the event of malfunction of the handcontrol the able batteries 2 pcs AAA LR03 lift can be operated by pressing the directional but pss i f tons and on the end plate of the lift unit J NE A Emergency stop Electrical emergency lowering To stop in case of emergency press the red In the event of malfunction of the handcontrol or emergency stop button power supply the emergency lowering function is To reset turn the button in the direction of the ar activated by pressing the directional button on rows until it pops out the lift unit The red button on the end plate of the lift unit is to Always ensure that the patient is lowered to a bed be used in case of emergency If the button has wheelchair or other suitable location been pressed in the contact between the motor and the source of power supply will disconnect and the lifting movement will stop Likorall 243 ES 7EN120109 01 5 www liko com SSP Limit Switch The lifting movement stops when the SSP Limit Switch on the underside of the lift unit is touched lightly see illustration If Likorall has been run upward to its highest position creating a physical contact between the SSP Limit Switch and the strap connector the SSP Limit Switch will be activated When the SSP Limit Switch is activated lifting movement is h
10. k Release Hook system can be used to facilitate ex change of lifting accessories Read more on page 9 See applicable assembly instruction for information about how to change strap connector Likorall 243 ES 7EN120109 01 4 www liko com Operation Several different handcontrols can be used with Likorall Which handcontrol to choose depends on how the Likorall motor and the railsystems are equipped Special handcontrols are to be used if a transfer motor and or rail switches are being used or if there is a need for wireless operation of the lift x O 0 0 qe 0 ol Liko BLiko OLiko BLiko vhs Operation Handcontrol Remote IR Prod No 3126060 Likorall is operated by lightly pressing the buttons Likorall 243 ES can be equipped with a wireless on the handcontrol Arrows indicate direction handcontrol The handcontrol has six buttons Movement ceases when buttons are released and works exactly like the cable connected hand The handcontrol for Likorall with Transfer Motor control see explanation to the left has four buttons Travel along the rail is regulated The handcontrol normally works within a radius of by pressing the and buttons 2 5 metres from the lift depending on the angle Likorall s handcontrol for control of switches has between the handcontrol and the IR receiver on four alternatively six buttons Switch direction is the en
11. o s product range contact your Liko representative or visit www liko com Slingbars Slingbar Mini 220 Prod No 3156005 G Max 205 kg 450 Ibs Universal Slingbar 350 Prod No 3156074 GES Max 300 kg 660 Ibs B Universal Slingbar 450 Prod No 3156075 CE N Max 300 kg 660 Ibs A Universal Slingbar 600 Prod No 3156076 pom Max 300 kg 660 Ibs Universal Twinbar 670 Prod No 3156077 Max 300 kg 660 Ibs Universal Side bars 450 Prod No 3156079 incl storage bag Max 300 kg 660 Ibs Sling Cross bar 450 Prod No 3156021 Max 300 kg 660 Ibs Sling Cross bar 670 Prod No 3156018 Gi Max 300 kg 660 Ibs op Likorall 243 ES 7EN120109 01 8 www liko com Quick release Hook Liko Quick release Hook system enables quick and easy exchange of lifting accessories on Liko s mobile and overhead lifts Likorall 243 ES can be equipped with Q link Prod No 31590005 so that it can be used with Quick release Hook mounted on the lifting equipment Quick release Hook Universal Prod No 3156508 fits Universal Slingbar 350 450 and 600 Prod No 3156074 3156076 Quick release Hook TDM Prod No 3156502 fits Slingbar Mini 220 Prod No 3156005 and Sling Cross bar 450 and 670 Prod No 3156021 and 3156018 See Guide to Liko s Quick release Hook system which can be downloaded at our website www liko com Contact Liko for more information about the use and features of the Quick release Hook system Stretchers
12. ork A repeated signal can be heard from the lift Check that the emergency stop button is not pushed in page 5 Check that the handcontrol is firmly connected Charge the battery page 7 If the lift still does not work satis factorily contact Liko The lift stops in the elevated posi tion Charge the battery immediately page 7 If the lift still does not work satis factorily contact Liko The lift does not achieve maxi mum lifting capacity Check that the emergency stop button is not pushed in page 5 Check that the handcontrol is firmly connected Use the indicated electrical emer gency lowering to safely lower the patient page 5 Charge the battery page 7 If the lift still does not work satis factorily contact Liko Charge the battery page 7 If the lift still does not work satis factorily contact Liko If you hear unusual sounds Likorall 243 ES 7EN120109 01 Contact Liko www liko com Care and Maintenance For safe and troublefree operation a few routine procedures should be performed every day the lift is used e Visually inspect the lift and check for external damage or wear e Check that all screws and lock nuts on the slingbar are tight e Check the lift strap for wear and make sure it is not twisted e Check that the safety latches work properly e Check the operating
13. s with the requirements of directives for medical technical Class products MDD 93 42 EEC Likorall complies with the requirements according to IEC 60601 1 IEC 60601 1 2 EN ISO 10535 UL 60601 1 and CAN CSA C22 2 No 601 1 Particular care must be taken when using strong sources of potential disturbance such as diathermy etc so that cables are not positioned on or near the lift If you have questions please consult the responsible assistive device technician or the supplier Maximum load 230 kg 507 Ibs Likorall 243 ES 7EN120109 01 2 www liko com Definitions N 1 Lift unit 2 IR receiver 3 Emergency stop 4 Emergency lowering raising electrical 5 Contact for handcontrol 6 SSP Limit Switch 7 Handcontrol 8 Contact for Transfer Motor Contact rail 9 Strap connector 10 Charging indicator 11 Handcontrol Remote IR 12 Hang Up 13 End plate Ne J Likorall has SFS Single Fault Safety spool and speed guard The lift strap has a ten fold safety margin Maximum load Batteries Battery charger Lifting speed Lifting range Electrical data Lift unit dimensions Technical Data 230 kg 507 Ibs Two 12 V 2 6 Ah valve regulated lead acid gel type batteries New batteries are available from Liko 100 240 VAC 40 60 Hz max 600 mA 5 cm s 200 cm 78 7 inch height adjustable 24V 12A 320x250x125 mm LxWxH 12 6x9 8x4 9 inch LxWxH Likorall 243 ES 7EN120109 01
14. struction guide contains important information about the use of the product All personnel who use this product must be thoroughly familiar with the contents of this instruction guide Remember to keep the instructions where they are easily accessible for caregivers Safety Instructions Before using for the first time make certain that Before lifting always make certain that e the lift is assembled according to the instructions e the lift strap is not twisted or worn and that it moves e lifting accessories are correctly applied to the lift easily into the power unit the batteries have been charged for at least 8 hours the lifting accessories are not damaged you have read and understood the instruction guides the sling is correctly and securely applied to the pa for the lift and lifting accessories tient so that no personal injury can occur personnel using the equipment have received appro the lifting accessory is correctly applied to the lifting priate instructions and training equipment e you have selected the correct type size material e the sling s strap loops are correctly fastened to the and design of slings and accessories to safely meet slingbar hooks when the sling strap is extended but the patient s needs before the patient is lifted from the underlying surface A Never leave a patient unattended in a lifting situation CE Likorall 243 ES is tested by an accredited testing institute and complie
15. t types of slings in a variety of sizes and models is available for Likorall In this document the person being lifted is referred to as the patient and the person helping is referred to as the caregiver Aisa warning triangle used for situations that demand extra care and attention Cli IMPORTANT Read instructions for the lift and accessories carefully before use Lifting and transferring a person always presents a potential risk A thorough understanding of the contents of instruction guides is essential Only trained personnel should use the equipment If you have questions please contact Liko or your local Liko representative Contents Sey MSU OMS ser soos sand ceeerandsiceetvake cage EE E EEE 2 Permon 25252 sets tas cdt fastens dafaatecncagiessaade A 3 TechiniGal Data tcteicicsgeccatitigiagetenaeecetenddigeestahigtcecginavenecets nbd EEE TEENE 3 ASSOMbIy cide Aue h Asses E a eta Anat ea a ea talon sta nant 4 Operation kaane nnti ition ecco adel a tier eee 5 6 Charging the Batteries svcs c iys c cee agactbevestic tense a ie Wehbe tev aie eae 7 Maximum Load 2 203 see ccee Ae eae ae ee ee 8 Recommended Lifting Accessories 0 0 0 eect eeeneeeeeeteteeeeeeetteeeeeettaeeeeeenea 8 10 Simple Troubleshooting 0 ccceeeeeeceeeeeeeeeeeneeeeeeeneeeeeeeeeeeeeeeieeeeeetaeeeeeeeiea 11 Care and Maintenance ceccececeeeeeeeeeeeeecneee eee eineeee eee eeeeeeeeieeeeretaeeeeeeeaa 12 A NOTE This in
16. u Liko Likorall 243 ES Instruction Guide English 7EN120109 01 2007 05 11 Applies to the following models Likorall 243 ES natural Prod No 3123001 Likorall 243 ES white Prod No 3123002 Product Description Likorall is a stationary lift often referred to as an over head lift Likorall is mounted on Liko s rail systems which are adapted to the room s they are to be used in The rail system can be built as a Straight rail with or without curves a Traverse system or a Room to room system Liko s rail systems consist of hundreds of com ponents and each part is specifically selected so that every installation is adapted to the room s it is to be installed in The rail system can be either a stationary installation or a freestanding installation such as Liko FreeSpan and Liko FreeStand The installation should be performed by qualified per sonnel and in accordance with installation instructions provided by Liko Likorall is intended for lifting and transferring patients e g from the bed to the wheelchair to and from the floor for visits to the lavatory and bath for walking standing gait and balance training for weighing and for lifting in combination with a stretcher Likorall 243 ES is prepared for wireless control IR Likorall 243 ES can also be equipped with a Transfer Motor which facilitates motorized transfer along the rail A large comprehensive range of accessories includ ing differen
Download Pdf Manuals
Related Search